2017 Hyundai Sonata

I am writing to report a direct violation of the Theta II Class Action Settlement terms by Hyundai Motor America. This morning , I emailed an Executive Case Manager explicitly explaining that my 2017 Sonata has an active P1326 code, has the 2019 KSDS update, and requires a mandatory diagnostic under NHTSA Recall 17V226 that cannot be denied due to a salvage title. Instead of replying to my facts, the Case Manager Kathy gave me a hard denial falsely framing my federal recall safety request as a "voluntary goodwill warranty" issue to justify her rejection. Please help me in getting authorization my car with Hyundai dealership in Plano Tx to run the bearing rod test and get it fixed.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

My engine seemed to be consuming oil way to much I had to do a oil change at 61,000 recommend by tire plus but at 58,000 is when I had to change my oil I also noticed there is a buring smell and its also been leaking oil at times I went to get it checked out by a mechanic at tireplus but they also they are seeing that the oil consumption was not normal and they recommend a possible recall for it because it hazardous for how fast its consuming and the leaks

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Driving home from work on [XXX] (not a safe location)when my car lost power and engine light began to flash. I pulled off to the side of road and called my dad. He came with a code reader and said there was a code P1326. He cleared the code and car drove normally again. 2 days later it began to run rough. I was told about the engine recall so I called Hyundai corporate and told them this same story. I was advised to take to dealership and have the “rod bearings inspected” and shouldn’t matter that my dad cleared the code. The dealership(Massey Hyundai MD) said it had a burnt valve and not part of warranty. But never checked rod bearings. When I called corporate. They said nothing they could do. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

High oil consumption, burning a quart of oil or more every 500 miles since bought used at Hyundai dealership.

Reported

Jun 2026

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

My 2017 Hyundai Sonata SE, equipped with the Theta II 2.4L GDI engine, is experiencing severe powertrain failures including rhythmic metallic engine knocking, catastrophic oil consumption, and un-commanded surges/jumping in speed while driving. These symptoms manifested following an unauthorized engine replacement performed by Hyundai of El Cajon under Repair Order [XXX], where the dealer covertly outsourced my vehicle to a third-party shop (Legacy Motor Works) to install an unverified used salvage engine block rather than a certified factory assembly. This vehicle is a Class Vehicle under In re: Hyundai and Kia Engine Litigation (Case No. [XXX]), and the KSDS software update (Campaign 953) was successfully completed on my vehicle in 2019. The engine knock, surging, and oil consumption are consistent with the known connecting rod bearing failure defect described in NHTSA investigation PE17-007. The dealership is currently denying warranty coverage, citing a mileage limit that does not exist under my Lifetime Powertrain Warranty, and they are withholding physical documentation of the repair terms. The vehicle is also experiencing secondary safety failures, including a continuous airbag SRS warning light (two years) and electrical shorts caused by the salvage-yard alternator installation, which have destroyed 4 to 5 car batteries. This engine failure represents a significant safety hazard, as the vehicle periodically loses power and surges without driver input. I am requesting that NHTSA investigate this pattern of warranty denial, parts-sourcing fraud, and the safety risks posed by this substandard engine installation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jun 2026

Incident date

Sep 2021

Mileage

Not provided

Outcome flags

None reported

The RED light is lit on the dashboard for the airbag. Unable to use steering wheel electronic features which helps with and was designed for hands free controls. I am unable to cycle through the electronic features or engage the cruise control due to the steering wheel electronics are in-op. Please help and get a recall started. This is not on the consumer.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The Hybrid Electric Vehicle (HEV) system in my 2017 Hyundai Sonata Hybrid Limited malfunctioned. On three separate occasions, the HEV warning light illuminated while I was driving on the highway, followed by a sudden loss of power. The vehicle stalled and stopped running, leaving it inoperable. The incidents occurred in approximately August 2022, November 2023, and February 2026. The vehicle is available for inspection upon request. Each incident occurred while driving on a highway. The vehicle suddenly lost power and stalled in moving traffic, creating a significant safety hazard. I was forced to attempt to move the vehicle out of active traffic lanes while other vehicles were traveling at highway speeds. The unexpected loss of propulsion increased the risk of a crash, serious injury, or death to myself, my passengers, and other motorists. The vehicle was taken to a Hyundai dealership after each incident. However, the dealership did not provide an explanation for the HEV warning light, loss of power, or stalling condition. To my knowledge, no permanent repair was identified, and the problem recurred on multiple occasions. The vehicle was inspected by a Hyundai dealership following each towing event. The vehicle was towed after each incident because it was not safe to drive. To my knowledge, Hyundai did not provide a definitive cause for the failures. The vehicle has not been inspected by police or insurance representatives in connection with

Reported

Jun 2026

Incident date

Jul 2022

Mileage

Not provided

Outcome flags

None reported

[XXX] [XXX] [XXX]; [XXX] [XXX] [XXX] Date: XXX To: National Highway Traffic Safety Administration Office of Defects Investigation (ODI) Subject: Formal Safety Defect Complaint – 2017 Hyundai Sonata Theta II Engine Failure, Excessive Oil Consumption, Intake/Engine Component Failure and Safety Hazard Dear Sir or Madam: I am submitting this formal complaint and request for immediate investigation into the dangerous and ongoing mechanical failures involving my 2017 Hyundai Sonata equipped with the Theta II engine. I believe this vehicle contains a serious manufacturing and/or engineering defect that presents a substantial safety hazard to consumers. My vehicle has experienced a pattern of progressive mechanical failure beginning with abnormal and excessive oil consumption, which appears to be directly associated with malfunctioning engine airflow and intake-related components. Specifically, the lower engine airflow system and intake functionality appear defective, placing excessive strain on the intake manifold system and contributing to cascading engine failures. As a result of these failures, the vehicle has experienced: Severe and excessive oil burning/consumption Intake manifold malfunction and abnormal operating stress Suspected overheating and/or premature head gasket failure Ignition coil failure and electrical shorting/misfires Progressive engine deterioration rendering the vehicle unsafe and unreliable Increased risk of sudden engine shutdown, stalling, fire hazard, or catastrophic engine failure while operating The vehicle has become increasingly unreliable and inoperable due to these conditions. These failures raise significant concerns regarding public safety, especially given the known history of complaints and recalls associated with Hyundai Theta II engine defects. I am deeply concerned that this vehicle may reflect a broader pattern of defective manufacturing, insufficient quality control. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Supplemental Information to Existing NHTSA Complaint involving a 2017 Hyundai Sonata Plug-in Hybrid (VIN: [XXX] ) While traveling at approximately 70 MPH on a heavily traveled highway, the vehicle suddenly and completely lost propulsion without warning. The vehicle rapidly decelerated in traffic, creating a significant safety hazard for my family and surrounding motorists and requiring emergency maneuvering to reach the shoulder. The vehicle was towed to an authorized Hyundai dealership, where diagnostic testing identified multiple high-voltage battery system fault codes: • P0B68 • P0B6D • P0B72 The dealership diagnosed a high-voltage battery system failure requiring battery replacement. The vehicle is currently non-drivable. During my research, I found multiple owner reports involving Hyundai Sonata Hybrid and Plug-in Hybrid vehicles experiencing loss of power, hybrid system failures, limp mode conditions, and propulsion-related incidents. I also learned that Hyundai previously issued Recall 18V166000 involving 2016–2018 Sonata Plug-in Hybrid vehicles due to battery management system and voltage protection device concerns that could result in loss of power while driving. Dealer says does appply for my car. Although my vehicle’s fault codes may differ from those addressed in the recall, both involve battery-related failures capable of affecting propulsion and creating a highway safety risk. My concern extends beyond my individual vehicle. A high-voltage battery or battery management system failure that can cause a complete loss of propulsion at highway speed without warning presents a potentially serious safety risk. I respectfully request that NHTSA evaluate whether similar incidents involving Hyundai Sonata Hybrid and Plug-in Hybrid vehicles indicate a broader safety concern warranting further review. I can provide dealership diagnostic reports, repair estimates, towing records, photos, and videos upon request. Thank you for your consideration, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

I am writing to report a serious, premature failure of a primary emissions and safety-related component (the catalytic converter) that has occurred as a direct consequence of a known, unaddressed manufacturing defect in Hyundai's Theta II engine. My vehicle has a documented history of excessive engine oil consumption. This inherent manufacturing flaw causes the engine to burn motor oil at an extreme rate, forcing unburned oil directly into the exhaust system. Over time, this oil has fouled and destroyed the catalytic converter substrate, triggering trouble code P0420 and causing a complete component failure. A dealership inspection at Heritage Hyundai Towson (RO #XXX) confirmed "excessive wear" and failure of the catalytic converter. Because the catalytic converter is failing prematurely due to a liquid defect (excessive oil burning) rather than standard wear and tear, it poses an environmental hazard, compromises vehicle emissions control, and can lead to sudden engine stalling or reduced power while driving, presenting an active safety risk. Hyundai Motor America (Case #XXX) has formally denied assistance to rectify this consequential damage, despite full awareness of the underlying engine defect. I request that NHTSA investigate how Hyundai’s ongoing oil consumption manufacturing issues are causing cascading safety and emissions component failures in these vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The rod bearings failed in the engine. The vehicle is currently at the dealership and is available for inspection. Rod bearing failure can cause complete engine seizure while driving, creating a serious risk of losing vehicle control at any speed. This is a known issue with Hyundai's Theta II engine. Yes. The dealership performed a diagnostic on April 27, 2025 and confirmed rod bearing failure. Yes. The dealership inspected the vehicle and Hyundai corporate opened a warranty case and arranged the repair appointment, initially confirming coverage before later denying the claim without providing documentation. The dealership has also repeatedly failed to provide documentation supporting the denial of my warranty claim despite my requests beginning April 29, 2025. I have also been unable to get callbacks from the dealership after being promised updates on May 1st, May 7th, and after requesting a manager on May 18th. As of May 27, 2025 I have still not received any documentation or a callback. The check engine light came on prior to the failure. I proactively checked and changed the oil, added Lucas oil treatment, replaced the spark plugs, and replaced the battery attempting to diagnose and resolve the issue before bringing it to the dealership. No oil pressure warning light ever appeared. The check engine light persisted despite these efforts which is what led me to bring the vehicle in.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

I have a Hyundai Sonata 2017 one year after I bought the car I started having acceleration problems. I have had the throttle changed and the valve gasket cover repaired. On April 15, 2026 the check engine light came on. On April 29th I got theta 2 emissions update installed at Hyundai Auburn, Al. I took it too auto zone the same day the code P1326 was showing up and P0014. On May 5th my car entered limp mode for excessive oil leakage, I got an oil change April 6, 2026. My car has never done that until the update was installed. I get my oil changed every 6 months and also have sent them records. They denied my claim due to lack of maintenance.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Engine failed while driving, Took it to dealership and the engine is seized. We were declined by Hyundai an engine replacement even though the Theta 2 engines have a lifetime replacement warranty because these engines are known to fail. They constantly deny due to 'severe owner neglect' because people do their own oil changes.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The vehicle experienced repeated engine-related failures associated with the P1326 error code, which indicates a potential engine defect. The issue first occurred around February 2023 at approximately 51,500 miles, when a warning light appeared. The problem has recurred multiple times despite inspections and service attempts. In January 2024, a dealership performed a software update related to the P1326 code. Shortly after this update, the engine began consuming excessive oil (approximately 2 liters per 1,000 miles). The condition worsened over time, and the vehicle failed an oil consumption test conducted by a dealership. The issue was confirmed by an authorized dealership, which ultimately diagnosed the engine as failed and requiring replacement in May 2026 at approximately 99,000 miles. The problem has been reproducible, with the P1326 warning code appearing multiple times over the life of the vehicle. This condition creates a significant safety risk because the engine may lose power, misfire, or stall unexpectedly while driving, increasing the risk of a crash, especially at highway speeds or in traffic. The vehicle has already experienced engine misfire and severe performance issues. Warning indicators included the P1326 error code and check engine light, which first appeared in 2023 and recurred multiple times thereafter. The engine oil consumption issue developed after the 2024 service and continued to worsen. The failed engine is currently available for inspection upon request.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

On 12/20/25, the car - a Sonata plug-in hybrid - failed to start. When I pushed the "start" button, the dashboard display lit up w many clearly irrelevant error messages. Each time I pressed start, somewhat fewer error messages blasted toward me, and finally, no response at all. On 12/21/2026, the tow driver said it was the 12-volt battery. He gave us a jump start and we drove a few blocks. However, it failed at the turn lane while waiting for the light to turn. We turned it back on, bought a new battery, had it installed. On 12/29/25, my husband was driving. He turned into the intersection with a traffic light. As he was making the turn, the car simply quit. No warning. The car was dead, and blocking traffic! He pressed the start button to turn off the car, then again to turn it on. He was able to complete the turn and parked on the side of the road. By this time it had a "check engine" light on. He then drove slowly the few blocks back to our house. On 12/30/2025, the car was towed to a local mechanic. He said it threw the code PODE7, "almost certainly for a failed High Voltage battery." It was still under warranty, and we had the car towed to the dealership. After keeping it for 2 or 3 weeks, they confirmed the code and that the control panel needed to be replaced. We finally picked up the car (w new control panel) on 2/20/2026. In the meanwhile, we looked up Hyundai control panel repairs on a reddit forum. We found lots of chatter about it. Turns out it's a recognized problem in Sonata and Ioniq EV and PHEV's! Clearly, a car failing in the middle of an intersection, highway, etc is a safety problem and needs to have repair/replacements made BEFORE THEY HAPPEN!

Reported

May 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Engine experienced severe metallic knocking and loss of power. A certified Hyundai technician confirmed a FAILED Bearing Clearance Test (RO #354331). Hyundai Motor America is refusing to honor the Engine II Class Action Settlement warranty, citing internal code A99 because the vehicle was purchased at an auction, even though the title is CLEAN. This pose a safety risk of engine seizure and potential fire.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Consistent burning of oil

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The failed component is the engine assembly in my 2017 Hyundai Sonata SE with the 2.4L Theta II GDI engine. The failure involves excessive oil consumption and internal engine failure, specifically suspected piston ring deterioration allowing oil to pass into the combustion chambers. The vehicle is available for inspection upon request. Safety was put at risk because the engine was losing oil rapidly. If the oil level drops too low, the engine can seize, stall, or lose power while driving. Sudden engine failure at road or highway speeds could increase the risk of a crash. The issue required constant oil monitoring and made the vehicle unsafe to rely on. The problem was confirmed by both an independent repair shop and a Hyundai dealership. At about 99,813 miles, an independent shop diagnosed oil burning from the tailpipe. I then paid for major repairs, including cylinder head and valve work, but the oil consumption continued. A later independent inspection found internal oil consumption consistent with failed piston rings and oil bypassing into the combustion chambers. The Hyundai dealership performed Hyundai’s oil consumption testing process, including combustion chamber cleaning and rechecking oil level. The vehicle failed and engine replacement was approved. The dealer quoted $11,400-$12,000 for replacement. The vehicle has been inspected by an independent repair facility, a Hyundai dealership, and reviewed by Hyundai Motor America Customer Care under case number 42489659. Hyundai denied assistance, stating the vehicle is outside warranty due to time and mileage. Symptoms first appeared around 99,813 miles and included excessive oil consumption, burning oil from the tailpipe, reduced power/dragging, abnormal rattle/noise during low-speed acceleration, and poor fuel economy. After repairs, the oil level still dropped below minimum quickly. I am filing this complaint because this condition may cause sudden engine damage, stalling, or loss of power while driving.

Reported

Apr 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

I am reporting a serious safety issue involving a 2017 Hyundai Sonata Plug-in Hybrid (VIN: [XXX] ), originally purchased in California. While driving at approximately 70 mph on a highway, the vehicle suddenly lost all propulsion without warning and rapidly decelerated. This created a dangerous situation with surrounding traffic and put me and my family at risk. I had to quickly maneuver to the shoulder to avoid a potential collision. The vehicle was towed to an authorized Hyundai dealership in Utah, where it was diagnosed with a failure of the high-voltage battery system. I was informed that the battery requires replacement. This type of sudden loss of propulsion at highway speed is extremely hazardous and could result in a crash, injury, or fatality. There were no prior warnings indicating an imminent failure of this severity. Given the safety risk associated with unexpected loss of propulsion, I am concerned this may represent a broader issue affecting similar vehicles. The vehicle is equipped with an interior camera, and video of the incident can be provided if needed. I respectfully request that this issue be investigated as a potential safety defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

See attached document for complaint.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Burns through oil Oil will be black and barely any on the dip stick Cannot make it to recommended oil change miles or date Goes into limp mode

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

2/25/2026 vehicle was put in service for a safety warranty recall. 2/26/2026 Hyundai approved the replacement of the engine, but there were costs involved that I was responsible for (approx. $800). 3/9/2026 I was informed by Hyundai the vehicle was complete, and would now last "for another 200,000 miles". I picked up the vehicle and only drove 5+ miles from the dealership when the vehicle’s motor completely shut down, putting me in a VERY UNSAFE driving condition, almost causing a serious accident. Vehicle was returned to Hyundai the same day and I was informed they were still figuring out the failure and to be patient. 3/11/2026 Hyundai informed the vehicle would now need a new catalytic converter and O2 sensor, and that it would all be covered under warranty. On 3/12/2026 Hyundai informed me that they would not fully cover the cost of the new parts and I ended up paying another $1300. 3/19/2026 Hyundai notified me that the vehicle service was complete, and the vehicle was ready for pick-up. I picked up the vehicle that day and again only drove 5+ miles when the vehicle repeated the same failure with the motor completely shutting down and again putting me in a VERY UNSAFE driving condition and almost causing a serious accident. Vehicle returned to Hyundai the same day. 3/23/2026 was told I would receive update once technician gets to the vehicle. 3/26/2026 informed that the vehicles Brake Booster Actuator needed replaced, and I have to cover the almost $4000 to replace this part and later informed Dealerships GM was covering cost. 4/8/2026 vehicle being worked on and completed by the end of that day. 4/9/2026 vehicle failed a 3rd time with same codes and limp mode. Tech line stating to replace EGR valve and Intake Manifold. 4/13/2026 informed that Hyundai refused to pay total amount, but were going to re-submit to not be completely out of pocket. 4/15/2026 vehicle has now been in Service for 7 weeks for a Safety Warranty recall.

Reported

Apr 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

I am submitting a vehicle safety complaint regarding a recurring HEV warning system indicator affecting my 2017 Hyundai Sonata Hybrid that was not properly diagnosed despite multiple service visits to Nalley Hyundai beginning around July or August 2022. During several service visits while the vehicle remained covered under an extended warranty, I reported the HEV warning indicator to the dealership. Each time the vehicle was returned to me, the warning light was no longer illuminated, giving the appearance that the issue had been resolved. I was not billed for these visits. However, I was informed that the dealership could not determine the cause of the warning indicator, and no permanent repair solution was completed. Because this issue involves the hybrid electric system, I am concerned this may represent a safety-related condition affecting vehicle reliability and drivability. The warning indicator has continued intermittently and has now progressed to the point that my vehicle is no longer dependable transportation. I respectfully request that this complaint be reviewed as a potential hybrid system warning indicator concern affecting the 2017 Hyundai Sonata Hybrid.

Reported

Apr 2026

Incident date

Jul 2022

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Hyundai Sonata. The contact stated that the front driver’s side seat belt failed to lock securely. The contact stated that the seat belt loosened unexpectedly and failed to properly protect the driver while operating the vehicle. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 102,000.

Reported

Mar 2026

Incident date

Mar 2022

Mileage

Not provided

Outcome flags

None reported

Care recently became inoperable. The engine was knocking, then stalling and then inoperable. Checked Hyundai website to find Engine Recall describing exactly what my Hyundai was/is experiencing. I brought vehicle to Clay Cooley dealership (39444 Lyndon B Johnson Fwy, 75232) and explained that I see the recall on the Hyundai website describing what my vehicle is experiencing. After their service mechanics review, the Service Department Representative falsely accusing me of the engine failure, stating that I "must not have changed my oil regularly". According to the service department, my 2017 Hyundai Sonata (132,000 miles) is not covered in the engine recall, and I must pay $4,926.53 for the repair. cc: FTC - ReportFraud.ftc.gov Texas Attorney General - Consumer-Protection/file-consumer-complaint

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

To the National Highway Traffic Safety Administration, I am filing this formal safety complaint regarding a dangerous engine failure incident involving my 2017 Hyundai Sonata Plug-in Hybrid. Description of Incident: While traveling on CA-85 near Mountain View, California, at approximately 65 miles per hour, the engine suddenly and without warning lost all power. The vehicle began to slow down involuntarily in active highway traffic, creating an immediate and serious risk of rear-end collision. The driver had no ability to maintain safe highway speed or accelerate out of danger. The vehicle had to be towed from the scene to the dealership. There was no warning light or prior indication that engine failure was imminent. The failure was sudden, complete, and occurred at highway speed in heavy traffic conditions. Safety Risk to the Public: This incident represents a significant and ongoing public safety hazard. A sudden, unpredictable loss of engine power at highway speed — with no prior warning — places the driver, passengers, and surrounding vehicles at serious risk of collision. This is not an isolated mechanical inconvenience; it is a life-threatening failure mode. Known and Documented Defects: The 2017 Hyundai Sonata Plug-in Hybrid has been the subject of multiple recalls and class action litigation related to engine defects. My incident is consistent with the known failure patterns documented in those proceedings. Despite this history, Hyundai Motor America has denied my warranty claim, citing missed services — a characterization I dispute, as the vehicle was serviced exclusively at an authorized Hyundai dealership whenever the onboard system indicated service was due, and no technician ever identified or disclosed any engine damage during those visits. Request to NHTSA: I respectfully request that NHTSA: 1. Open or expand an investigation into engine failure incidents in the 2018 Hyundai Sonata Plug-in Hybrid 2. Investigate whether a recall is warranted

Reported

Mar 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Hyundai Sonata. The contact stated that while his wife was driving at an undisclosed speed, the vehicle experienced engine failure. The vehicle made a knocking sound prior to the failure. No warning lights were illuminated. The vehicle was towed to the residence and eventually towed to the dealer, but was not diagnosed or repaired. The dealer acknowledged the engine failure and that the failure was a common failure. The dealer declined the repair due to a lack of service records. The contact was offered a combustion cleaning; however, the vehicle was disabled. The manufacturer was notified of the failure. The approximate failure mileage was 95,000.

Reported

Mar 2026

Incident date

Oct 2023

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Hyundai Sonata. The contact stated that the vehicle had experienced excessive oil consumption, caused by engine rod bearing failure. The engine rod bearing failure caused excessive oil consumption and premature spark plug fouling, requiring the frequent replacement of the spark plugs. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 132,000.

Reported

Mar 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Sun roof flew off while driving, the metal framing was twisted and dent. Sun Roof was closed at the time. Pictures were sent to insurance company but no one has looked at it yet. No warning. Sun roof was working properly.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

I have a 2017 hyundai sonata sport,it started using a lot of oil,one day I was driving and it just lost speed and the car just started jerking. I checked the spark plugs and oil had gotten on them. I changed the spark plugs,drove it for about 2 weeks and it did it again. I was constantly having to put oil it and changing the spark plugs every 2 weeks. The check engine light would come on every time this happened. I took it to a hyundai dealership they first wanted to do a oil test which they realized would not work because it was using to much oil ,second they wanted to do some other test that would cost almost $300 dollars which would still not determine if I would be eligible for the recall. Can i get some help please,please

Reported

Feb 2026

Incident date

Mar 2024

Mileage

Not provided

Outcome flags

None reported

Here is your updated review with that included: ⸻ I am very disappointed with Hyundai Motor America and the service I received at Hyundai of Renton. I own a 2017 Hyundai Sonata and received a letter about a required software update and ignition cylinder protector due to known theft issues. I went to the Renton dealer for the recall service. They performed the software update and were supposed to install the ignition cylinder protector. Unfortunately, my car was later stolen because of this exact issue. The ignition was damaged during the theft, and I had to replace it myself just so I could drive the car. When I returned to the dealer, they refused to install the ignition cylinder protector, saying the ignition was broken. It was broken because of the theft — which happened due to Hyundai’s known defect. After the recall software update, my key fob also stopped working properly. I went back to the dealership, and they refused to fix or properly reprogram my key fob. On top of that, the service manager, John, was very rude and unprofessional. This has been the worst experience I’ve had with a vehicle and a dealership. Because of this situation. Very disappointed.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

While driving around 45 mph, the steering wheel locked up and car came to a hard stop. Luckily cars swerved to avoid me. This was the second time it happened. The first time I was in a parking garage and the steering wheel locked up. After restarting the vehicle, the steering wheel worked again. The dash showed no fault codes or engine light. I found out there is a service bulletin and took it in to the dealer. Once there, the confirmed it was the power steering and is covered by the service bulletin and extended warranty. However, because the bulletin requires the dealer to clear code to try and reproduce it, I have to pick up vehicle because they could not reproduce the fault code. So now I have to drive the vehicle knowing their is a service bulletin for the problem and have it happen again before it is fixed. There is an extremely high likelihood of injury considering you lose all power at wheel and car continues to move.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

My 2017 Hyundai Sonata Hybrid has a permanent and recurring DTC P1326 (Knock signal range/performance) from the Knock Sensor Detection System (KSDS), indicating potential connecting rod bearing wear in the Nu 2.0L engine. The vehicle enters limp mode (reduced power, limited acceleration/speed) on the highway under load, with hard engine vibration, tinkling/knocking noise from under hood, and significantly reduced MPG. These symptoms create a serious safety risk: sudden loss of power at highway speeds (e.g., 50+ mph) makes it difficult to maintain speed, merge, or avoid hazards, increasing crash risk or stranding in traffic. In rare cases, bearing wear can lead to engine seizure or failure. The problem first appeared summer 2024 at approximately 115,000 miles. The Check Engine Light illuminates (cristmass tree), and limp mode triggers during highway driving. I have an OBD scan showing confirmed, pending, and permanent P1326, plus related hybrid communication codes (U0293, U1004) likely secondary to the protection mode. The vehicle has been inspected multiple times (four visits) by a Hyundai dealer. Each time they scanned the code, performed basic checks, but stated “engine is working normal, no road vibration, nothing” and did not resolve the issue. The code returns immediately after clearing. I replaced the knock sensor, engine mounts, spark plugs, ignition coils myself—did not fix it. Dealers did not perform the full bearing clearance test or follow TSB 22-01-023H (Service Campaign T6G) procedure as required for this known issue (related to Recall 209 and Campaign 966). The component (engine/connecting rod bearings) is still in the vehicle and available for inspection. No police, insurance, or other parties have inspected it beyond the dealer. This matches a widespread known defect in 2011–2019 Sonata Hybrids (bearing wear triggering P1326/limp mode).

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

Car just sputtered and then the engine stopped working in cyclinder 2

Reported

Feb 2026

Incident date

Nov 2024

Mileage

Not provided

Outcome flags

None reported

This car is becoming more of a headache than it’s worth. Turned the car on, My car started shaking and my check engine light came on. then I got this message “A possible condition with your engine control system has been detected on a 2017 Hyundai Sonata”

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

My car stayed with up to date oil changes and everything. One day I noticed it was leaking oil and had to stay on top of adding oil. When took to a mechanic they said my motor was blown and needed a new one. I took very good care of this car and it’s crazy that I need a new motor after babying the car.

Reported

Feb 2026

Incident date

Jan 2025

Mileage

Not provided

Outcome flags

None reported

Was just driving and lost steering, basically very hard to turn the wheel. Traction control light and a red steering wheel light came on.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

My 2017 Hyundai Sonata is exhibiting a severe metallic knocking noise and metal debris in the engine oil—primary indicators of the Theta II engine defect (NHTSA Campaign 17V578). These symptoms indicate imminent engine failure, posing a significant stall and crash risk. On or around 8/20/25, I took the vehicle to Earnhardt Hyundai-San Tan. I informed the technician of the oil burning and metal shavings. They refused to perform the recall repair and charged a $200 diagnostic fee for an inspection related to a federally mandated safety recall. Under federal law (49 U.S.C. Chapter 301), recall remedies must be provided at no cost to the owner. Furthermore, components were not reassembled correctly during the inspection. The vehicle is now leaking oil onto my driveway and has been rendered inoperable. It has not been driven since I picked it up on August 25, 2025. I am requesting that Hyundai be compelled to perform the recall remedy and reimburse the unauthorized diagnostic fee.

Reported

Jan 2026

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

Please see the attached paperwork and I have more if needed. I am not receiving any help from the local Hyundai dealership in which I purchased the car, and I have reached out to the main Headquarter. This is the 2nd Hyundai I purchased, and I was not made aware of the oil consumption issue.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

My vehicle has a documented excessive oil‑consumption defect. After a 1,000‑mile oil‑consumption test performed by a Hyundai dealership, the engine was found to have consumed 2.8 quarts of oil, which is far above normal and poses a safety risk. The dealer referenced TSB 23‑EM‑008H and recommended a chamber cleaning but could not guarantee it would resolve the issue. Hyundai Motor America declined to cover the repair and refused to escalate my case. This level of oil consumption is consistent with known Theta II engine defects that have led to engine seizure, stalling, and fire in other vehicles. I am reporting this as a safety concern due to the risk of sudden engine failure while driving.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

The 2017 Hyundai Sonata has had an ongoing engine malfunction defect that is causing engine knocking, stalling, and smell and rapid depletion of oil. The continuous issues are concerning especially when the car is not driven on a regular basis as it is utilized as a second vehicle. This has been a noticeable issue for quite sometime now. I have taken the car to the Hyundai dealership on multiple occassions after notably heavy oil consumption in a short time period in between scheduled oil changes. I am told by the dealership that it is evident that the engine is rapidly processing and burning oil inappropriately from a possible manufacturing defect recall related to connecting-rod bearing failure that was issued by Hyundai for various Hyundai models. The damaged engine may stall, increasing the risk of a crash. In addition, oil may leak onto hot exhaust components, increasing the risk of fire.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

I was involved in a severe motor vehicle collision in a 2017 Hyundai Sonata. The airbags failed to deploy during the crash. I sustained serious injuries and was transported from the scene by EMS. This vehicle has known safety recalls, and I believe the airbag non-deployment may indicate a safety defect.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

Crash 1 injuries

Manufacturer has refused engine replacement under federal KSDS recall settlement without providing causation proof. Owner has maintenance records. Request NHTSA compliance review.

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Manufacturer is refusing recall engine replacement alleging neglect without proof of causation. Vehicle has documented maintenance. Denial appears improper under recall compliance law.

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The vehicle’s dashboard continuously displays a “hood open” warning even though the hood is fully closed and securely latched. The hood has been physically inspected and confirmed to be closed, yet the warning persists. The issue appears to be related to a faulty hood latch sensor or switch, which is part of the hood latch assembly. The warning is inaccurate and does not reflect the actual condition of the hood. I am requesting that NHTSA review this issue for potential investigation, as it may represent a defect in the hood latch sensor system on the 2017 Hyundai Sonata that could affect multiple vehicles and pose a safety risk.

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Airbags did not deploy no indicator light came on before nor after I was struck from my driver side front area and yes it is available for inspection upon request. My safety along with my sisters safety was put at risk due to the negligence and cheapness of the dealership I purchased the car from also from there misleading information and improper inspection before selling me the car Car has not been reproduced or confirmed The car was inspected by a third party appraisal company for damages amounts There were no lights on at all before the accident and I am pretty certain that the dealership cleaared the codes before selling me the car

Reported

Jan 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

Crash

Cylinders in the engine are misfiring causing car to shake. Pistons in the engine are having trouble keeping the air compressed so psi to continue to decrease causing the misfire.

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

My 2017 Hyundai Sonata Sport Limited 2.4 has a known engine defect causing excessive oil consumption. The vehicle was at an authorized Hyundai dealership for the oil consumption test and had been approved for a new engine replacement. Prior to the repair, I completed $2,300 in maintenance, specifically an oil combustion cleaning and spark plug replacement, which the dealership said was required to perform the oil consumption test. While the vehicle was in the dealership’s custody, it caught fire on 12/19/2025 at World Hyundai Matteson. No one was injured, but the car was destroyed. This occurred while the vehicle was under warranty repair, creating a serious safety risk. I am submitting this complaint to document the fire and the associated safety issue with this engine defect.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

Fire

My car steering is locking up while driving on highway and regular roads. Resulting almost in not being able to control and crash. I also had a recall for my engine which was already replaced and now having same issue with oil burning and not leaking.

Reported

Dec 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

Car consuming EXCESSIVE Oil. Oil changes went from lasting 6-7k miles, to less than 4k miles, to less than 2k miles within a year. Checked for leaks, nothing found. Here is the breakdown, I added more oil when the oil lights would flash on. : 12/06/24 FULL OIL CHANGE Mileage: 80,735 6/11/25 FULL OIL CHANGE 86,164 miles 10/6/25 1 qt  89,000 miles 10/10/25 FULL OIL CHANGE 90,121 miles 1 qt 11/30/25 91,550 miles 1 qt 12/11/25  92,700 miles Hyundai is AWARE that this is an ongoing issue - they should legally be required to fix this whether a car has a warranty or not. Bad for the engine and engine replacements aren't cheap

Reported

Dec 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

Hyundai Motor America (Hyundai) is recalling certain 2017-2018 Sonata, 2016-2018 Sonata Hybrid, 2018-2020 Accent, and 2016-2017 Azera vehicles. The trunk latch may become damaged, preventing the opening of the trunk from the inside. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 401, "Internal Trunk Release."

Risk: A person inside the trunk compartment may become trapped, increasing their risk of injury.

Remedy: Dealers will replace the trunk latch base, free of charge. Owner notification letters were mailed December 4, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 208.

Hyundai Motor Company (Hyundai) is recalling certain model year 2017 Hyundai Elantra vehicles manufactured April 15, 2016, to September 13, 2016, and Sonata vehicles manufactured May 27, 2016 to September 16, 2016. In these vehicles, the end seal for the driver's frontal air bag inflator may not have been properly installed, possibly resulting in reduced inflation of the frontal air bag in the event of a crash.

Risk: In the event of a crash, an air bag that does not inflate fully increases the risk of injury.

Remedy: Hyundai will notify owners, and dealers will replace the driver's frontal air bag module, free of charge. The recall began February 13, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 156.

Hyundai Motor America (Hyundai) is recalling certain 2015-2017 Sonata, 2016-2017 Sonata Hybrid, and Sonata Plug-In Hybrid vehicles. The Smart Junction Box (SJB) software logic may not properly interpret the signals received from the multifunction switch, which could cause the turn signal to activate in the opposite direction of what the driver intended.

Risk: A turn signal that activates in the opposite direction of what was intended by the driver increases the risk of a crash.

Remedy: Dealers will update the SJB software, free of charge. Owner notification letters were mailed November 19, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 210.