2017 Mercedes Sprinter

The vehicle has swivel seats. When the driver’s seat swivel, it’s severed the wires, the control the SRS system.

Reported

Jun 2026

Incident date

Jun 2019

Mileage

Not provided

Outcome flags

None reported

Odometer Fraud. The contact purchased a 2017 Mercedes-Benz Sprinter 2500. The contact stated that it was discovered that there was a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the mileage was 41,000. It was later discovered upon diagnosis that the mileage was 95,000.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Mercedes-Benz Sprinter 2500. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The check engine warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed with a failed knock sensor, debris in the EGR valve, insufficient Selective Catalytic Reduction(SCR), and low DEF. The contact was informed that the knock sensor and the SCR converter needed to be replaced, and the EGR valve needed to be cleaned. The vehicle ws not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 73,000.

Reported

Jul 2025

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Mercedes-Benz M3CA76 Sprinter 3500. The contact stated while driving at approximately 65 MPH, the diesel purifier, Diesel Exhaust Fluid, DEF system, warning illuminated. The contact stated that the failure of the DEF system had occurred before the recent failure. The contact stated that the first failure had occurred several years ago. The contact had taken the vehicle to an independent mechanic where it was diagnosed and determined that the DEF system again needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 325,000.

Reported

Dec 2024

Incident date

Dec 2024

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Mercedes- Benz Sprinter 350. The contact stated that while driving at various highway speeds the warning message "DEF Is Low" had suddenly displayed and the vehicle went into "Limp Mode" causing the speed to suddenly reduce to 5 MPH. The vehicle was taken to the local dealer who diagnosed that the DEF tank was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure but no assistance was offered. The failure mileage was 44,000.

Reported

Dec 2024

Incident date

Nov 2024

Mileage

Not provided

Outcome flags

None reported

Check engine light Nox sensor failure message

Reported

Jun 2024

Incident date

Jun 2024

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Mercedes-Benz Sprinter 2500 equipped with Kumho Tires, Tire Line: Road Venture TR, Tire Size: LT245/75/R16, DOT Number: H211YD5F1717. The contact stated that while he was cleaning the vehicle, he noticed that the front tires had pieces of tire rubber around the tire and that the tread was delaminating. The contact inspected the rear tires and noticed that there was premature tire wear on the tread of both tires. The contact called the tire manufacturer who directed him to take the vehicle to an independent tire dealer for diagnostic testing where it was confirmed that the tires were undergoing premature wear. The manufacturer was notified of the failure. The approximate vehicle failure mileage was 18,000 and the tire failure mileage was 18,000.

Reported

Aug 2023

Incident date

Jun 2023

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Mercedes-Benz Sprinter 3500. The contact stated while driving approximately 25 MPH, he had to brake abruptly, due to an animal crossing the roadway. Then he heard a loud sound coming from underneath the vehicle, when he took his foot off the brake. . The contact pulled over to the side of the road and saw the water tank had fallen to the ground. The vehicle was taken to an independent mechanic where the water tank was firmly re-attached to the RV. The manufacturer was notified of the failure, but has to date denied responsibility for inadequately attaching the water tank to its RVs. The failure mileage was 49,500.

Reported

Aug 2023

Incident date

Jul 2023

Mileage

Not provided

Outcome flags

None reported

The ESP and ABS warning lights went on suddenly after what sounded like a thud. The car had not run over anything. There was some initial brief chattering of the break pedal, and that subsided. The car was not near a suitable and available repair shop at the time. It was driven to complete a trip. There were several instances of break pedal chattering that led concern about the controllability of the vehicle. During the trip, it was taken to a brake shop, and the technicians felt it was likely safe to drive. Eventually after the servicing dealer first replaced the front speed sensors, the ESP unit was found to be shorted. This event is of concern because the speed sensors on the rear have been replaced on recall and the front speed sensors have been granted an extended warrantee. Both feed into the ESP unit that failed. It seems possible the previously suspect parts may have damaged the ESP unit. There appears to be a safety issue with faulty break performance in this situation. The vehicle only had about 13,000 miles on the odometer. at the time of the event. Service an repair records are available upon request

Reported

Aug 2023

Incident date

Jul 2023

Mileage

Not provided

Outcome flags

None reported

The front left wheel cover shifted and nearly sheared off the tire valve stem. Had this happened while we were on the road, the tire would have had a very fast deflate/explosion. This would have put the 24ft. RV into an uncontrollable nose-dive and possible crash situation. The nearly-sheared valve stem was discovered by technicians while we were having routine maintenance done at the authorized Mercedes dealership. They removed the tire and replaced the valve stem. We were told by the Service Manager that this usually happens to the rear dual wheels, not the front. We have had zip ties put on to keep the wheel "hubcaps" (beauty rings) on the wheels because they are notorious for flying off. There are no warning lights etc. to indicate any wheel issues. This RV (Sprinter) has been in to authorized Mercedes Sprinter dealership for regular service over the past 4 years and only this time (June 26, 2023) was the problem discovered. The Mercedes Service Dept. in Eugene is the only technicians this RV has been in contact with. They seem to be aware that this "sheering" of valve stems is a reoccurring problem with Sprinters.

Reported

Jul 2023

Incident date

Jun 2023

Mileage

Not provided

Outcome flags

None reported

I'm getting wheel sensor errors and the vehicle goes into limp mode and disables the cruise control, even after replacing the sensors. Very frustrated with this dangerous situation!

Reported

Jun 2023

Incident date

May 2023

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Mercedes-Benz Sprinter 3500. The contact stated that on two separate occasions while driving at undisclosed speeds, the vehicle started shaking and the contact heard a loud sound coming from the vehicle. The contact veered off the roadway and noticed that the hub cap had detached from the wheel. The contact stated that he was not aware that the inside tire had deflated. The contact then stated that he removed the hubcap from the road and continued driving to the nearest tire shop where it was diagnosed that rear driver’s side inside tire was deflated and needed to be replaced. The vehicle was repaired. The contact stated that on another occasion the vehicle was taken to the dealer for service, where the two rear passenger’s side tires were rotated, and the contact retrieved the vehicle however, while driving at an undisclosed speed, the vehicle failed to operate as needed. The contact pulled over to the nearest service station where it was inspected and the contact was informed that the two rear passenger’s side valve stem were entangled in the hub caps and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and the contact was informed that the VIN was not included in a recall. The failure mileage was approximately 26,000.

Reported

May 2023

Incident date

Oct 2022

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Pleasure Way RV built on a 2017 Mercedes-Benz Sprinter 2500 chassis. The contact stated while driving approximately 70 MPH, the vehicle experienced a loss of motive power, brakes, power steering, and engine functionality. The vehicle was pulled over and restarted and functioned as designed however, the failure recurred. The contact stated no warning light was illuminated. The contact had the vehicle towed to a local dealer, where it was diagnosed with needing the engine wiring harness replaced. The dealer reported that the harness showed signs of abrasions which caused the harness to ground out leading to loss of power. The vehicle was repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 55,000.

Reported

Feb 2022

Incident date

Jan 2022

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Mercedes-Benz Sprinter 2500. The contact received notification of NHTSA campaign number: 20V663000 (Steering) however, the part to do the recall repair was unavailable. The contact called the local dealer who stated that parts were not yet available. The contact was informed the parts were backordered until May 30, 2022. The contact stated the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified. The contact had not experienced a failure. Parts distribution disconnect.

Reported

Oct 2021

Incident date

Jan 2021

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Mercedes-Benz Sprinter 3500. The contact received notification of NHTSA Campaign Number: 20V663000 (Steering) however, the part to do the recall repair was unavailable. The dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.

Reported

Aug 2021

Incident date

Feb 2021

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Mercedes-Benz Sprinter 3500. The contact received a recall notification for NHTSA Campaign Number: 21V042000 (Electronic Stability Control) however, the dealer informed the contact that the part for the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the issue. The contact had not experienced a failure. Vin tool confirms parts not available.

Reported

Jul 2021

Incident date

Jul 2021

Mileage

Not provided

Outcome flags

None reported

The contact's parents own a 2017 Mercedes-Benz Sprinter 3500. The contact stated that his parents had experienced multiple flat tire failures with various tires on the vehicle. An independent mechanic discovered that there were multiple cracks on three of the rims on the vehicle. Due to that discovery, his parents had all six tires and rims replaced on the vehicle. Recently, the contact discovered that the driver’s side inner tire had blown out after parking the RV. The contact called for emergency assistance and had the tire replaced. On a separate occasion, the contact noticed after parking the vehicle, the rear passenger’s side outer tire was flat. The contact again called for emergency assistance and while the tire was being replaced, it was discovered that the sidewalls had all fallen apart inside the tire. The vehicle was not diagnosed nor repaired. The contact believed that the cause of the tire failures was related to the rims on the vehicle. Neither the manufacturer nor the dealer was notified of the failure. The failure mileage was 8,100.

Reported

Jul 2021

Incident date

Jul 2019

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Mercedes-Benz Sprinter 3500. The contact received notification of NHTSA campaign number: 21V042000 (Electronic Stability Control) however, the part to do the recall repair was unavailable. The contact called the local dealer and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue but was unable to provide a date when parts would be available. The contact had not experienced a failure. Vin tool confirms parts not available.

Reported

Jul 2021

Incident date

Jul 2021

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Mercedes-Benz Sprinter 3500. The contact stated while driving at 65 MPH, the cruise control disengaged as the ABS and ESP warning lights illuminated. The contact pulled the vehicle over and read the owner's manual to get information on the failure. Upon restart, the check engine warning light illuminated. The contact received notification of NHTSA campaign number: 21V042000 (Electronic Stability Control) however, the part to do the recall repair was not yet available. The manufacturer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was 5,500. Vin tool confirms parts not available.

Reported

Jun 2021

Incident date

Apr 2021

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Mercedes-Benz Sprinter 3500. The contact received notification of NHTSA campaign number: 21V042000 (Electronic Stability Control) however, the part to do the recall repair was unavailable. The local dealer was contacted and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Vin tool confirms parts not available.

Reported

May 2021

Incident date

May 2021

Mileage

Not provided

Outcome flags

None reported

TL* THE CONTACT OWNS A 2017 MERCEDES-BENZ SPRINTER 2500. THE CONTACT STATED THAT THE CARGO SLIDING DOOR FAILED TO OPEN FROM THE INSIDE OR OUTSIDE. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VIN WAS NOT UNDER RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 36,000.

Reported

May 2021

Incident date

Apr 2021

Mileage

Not provided

Outcome flags

None reported

SIDE ENTRY DOOR OPENED TWICE WHILE DRIVING. 1ST WE THOUGHT WE DIDN'T CLOSE IT RIGHT, BUT I CHECKED AND DOOR HAD LOCKS ENGAGED. THE 2ND TIME THAT DOOR OPENED UP, I PULLED OVER AND CHECKED AND ENGAGED ALL LOCKS ON DOOR AND THEN PUSHED IT A BIT AND TO MY SURPRISE THE DOOR OPENED UP! IT TURNS OUT THE SCREWS WERE LOSE SO THE LOCKS WERE NOT ENGAGING. SO I TIGHTENED THEM UP WITH THE DRILL AND PROBLEM SOLVED. THIS IS AN RV AND IT IS DRIVEN MANY MILES AND ON BUMPY ROADS SO THE SCREWS WILL LOOSEN UP CAUSING THE DEADBOLT LOCKS NOT TO ENGAGE PROPERLY. 2ND ISSUE, HOLES UNDERNEATH BED DESIGNED TO ALLOW SLIDEOUT ROLLERS TO EXTEND BED IS A SAFETY CONCERN AS GAS FUMES ENTER THE RV.*DT

Reported

Apr 2021

Incident date

Apr 2021

Mileage

Not provided

Outcome flags

None reported

TL* THE CONTACT OWNS A 2017 MERCEDES-BENZ SPRINTER 3500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 21V042000 (ELECTRONIC STABILITY CONTROL). THE CONTACT STATED THAT MERCEDES-BENZ OF SAN JOSE SERVICE CENTER LOCATED AT 3000 E. CAPITOL EXPY SUITE A, SAN JOSE, CA 95148, (408) 214-3009) EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE PART WAS NOT AVAILABLE FOR THE REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

Reported

Apr 2021

Incident date

Jan 2021

Mileage

Not provided

Outcome flags

None reported

WE ARRIVED HOME AFTER A SHORT TRIP, PARKED THE VEHICLE AND DIDN'T SEE IT UNTIL THE NEXT MORNING. WE THEN FOUND THAT BOTH LEFT REAR TIRES WERE FLAT. AIRED THEM UP AND DROVE TO DISCOUNT TIRE WHERE WE WERE INFORMED THAT BOTH RIMS WERE CRACKED AT THE EXACT SAME WELD. THE TIRES WERE IN PERFECT CONDITION: NO BLESS, BUBBLES, OR MARKS. MERCEDES BENZ REFUSED TO WARRANTY OR REPLACE THE RIMS. WE NOW SEE THERE IS A RECALL PENDING ON AN ESP FOR THE REAR TIRES - WE BELIEVE THAT ARE CONNECTED ISSUES.

Reported

Mar 2021

Incident date

Feb 2021

Mileage

Not provided

Outcome flags

None reported

EVERY 400 0R SO MILES THE CHECK ENGINE LIGHT COMES ON. CODES ARE 19DE00H AND P16CC00 AND P18F100 RELATING TO THE DEF BURN. I HAVE STOPPED AT THREE MB DEALERSHIPS. THEY LOOK AT CODE AND RESET SYSTEM AND TELL ME TO DRIVE THE VEHICLE. THEY ALSO HAVE SENT SEVERAL PEOPLE LETTERS TO REQUEST THEY HAVE THE VEHICLES FOR TWO WEEKS TO STUDY THE PROBLEM. I CAN'T DO THAT.

Reported

Feb 2021

Incident date

Feb 2021

Mileage

Not provided

Outcome flags

None reported

OUR 2018 CLASS C TIFFIN WAYFARER IS BUILT ON THE 2017 MERCEDES SPRINTER 3500 CHASSIS. AT 17,380 MILES, WITH NO WARNING, WHILE MOVING, THE VEHICLE BEGAN BANGING, LURCHING AND SPED UP. ALL THIS OCCURRED WHILE ATTEMPTING TO GO THROUGH A CITY STREET INTERSECTION. TO STOP THE VEHICLE FROM THIS ERRATIC MOTION, I IMMEDIATELY SWITCHED IT OFF AND COASTED TO THE SIDE. HAD THERE BEEN A VEHICLE OR PERSON DIRECTLY IN FRONT OF ME, THERE IS NO QUESTION THAT I UNFORTUNATELY WOULD HAVE HIT THEM AS THE VEHICLE SPED UP EVEN WITH BRAKES APPLIED. I RESTARTED THE VEHICLE AND MOVED IT OUT OF THE INTERSECTION. MULTIPLE ERROR AND WARNING LIGHTS CAME ON THE DASH. WITH ONLY THREE MONTHS REMAINING ON THE WARRANTY, MERCEDES HAD THE VEHICLE TOWED TO A DEALERSHIP WHO HAS JUST INFORMED ME THE FAILURE WAS CAUSED BY THE LEFT REAR WHEEL SPEED SENSOR WHICH THEY REPLACED. THERE ARE FOUR OF THESE SENSORS NONE OF WHICH SHOULD HAVE FAILED WITH THIS LOW MILEAGE. WHEN WILL THE OTHER THREE FAIL? WHAT RISK OF ACCIDENT OR INJURY WILL THEIR POTENTIAL FAILURE CAUSE? THIS IS A MAJOR CONCERN. APPARENTLY MERCEDES IS WELL AWARE OF THESE SENSOR FAILURES AS THE SERVICE AGENT SUGGESTED THIS AS A PROBABLE CAUSE WHEN I DESCRIBED THE PROBLEM AND REASON FOR HAVING THE VEHICLE TOWED IN. I DO NOT BELIEVE MERCEDES HAS NOT ISSUED A RECALL OR EXTENDED THE WARRANTY ON THESE WHEEL SPEED SENSORS. IN MY OPINION, MERCEDES SHOULD DEFINITELY REMEDY THESE FAILURES WITH BETTER PARTS AND WARRANTY SO AS NOT TO CAUSE RISK OF ACCIDENT OR INJURY. I ASKED FOR THE FAILED PART, BUT WAS TOLD MERCEDES HAS THE DEALER SEND THE PARTS TO THEM.*DT CONSUMER STATED REAR SENSORS AND MOISTURE BEING INVESTIGATED AND FEELS THAT IS NOT THE CAUSE. SERVICE TECH FEELS IT IS A FAULTY PART OR DESIGN. NEW REPLACEMENT SENSOR HAS BEEN REPLACED BUT FAILED AFTER 45 MILES. FRONT SPEED SENSORS ALSO FAILED.*JB

Reported

Oct 2020

Incident date

Oct 2020

Mileage

Not provided

Outcome flags

None reported

RMP SENSOR FAILED CAUSING VEHICLE TO LOSE ANTI LOCK BRAKES, TRACTION CONTROL AND CRUISE CONTROL. PLUS FORCED VEHICLE INTO LIMP MODE SO IT WOULD BARELY MOVE TO REST AREA TO CALL FOR ASSISTANCE. I'VE BEEN TO THREE DEALERSHIPS WITH THIS ISSUE AND THEY ARE ALL VERY AWARE THAT THESE FAULTY SENSORS EXIST. THEY HAVE BEEN AND ISSUE FOR YEARS PUTTING 100S IF NOT THOUSANDS OF SPRINTER OWNERS AT EXTREME RISK WITH LOSS OF ANTI LOCK BRAKES AND TRACTION CONTROL AT THE SAME TIME. MERCEDES BENZ NEEDS TO CORRECT THIS FAULTY PART AND RECALL ALL VEHICLES AND FIX

Reported

Oct 2020

Incident date

Aug 2020

Mileage

Not provided

Outcome flags

None reported

LOWER POWER STEERING HOSE DETACHING FROM COOLER CAUSING LOSS OF POWER STEERING. I HAVE 8500 MILES ON THE VAN. THIS IS A KNOWN ISSUE ACROSS ALL SPRINTER FORUMS. I HAVE TO ADD A NEW CLAMP TO FIX THE ISSUE. IM SO SURPRISED TO LEARN THAT MB HAVE DONE NOTHING TO FIX THAT ISSUE ON ALL SPRINTER VAN... ITS A "TIME BOMB" TO HAPPEN 7 COULD SERIOUSLY HAVE A DEADLY CONSEQUENCE IN AN EMERGENCY LOSING YOUR POWER STEERING

Reported

Aug 2020

Incident date

Aug 2020

Mileage

Not provided

Outcome flags

None reported

TRAVELING ON I-95 WITH THE CRUISE CONTROL SET AT 70 MPH. SUDDENLY THE VEHICLE DECELERATED AND THREE WARNING LIGHTS (ABS, TRACTION & THE ACCELERATION SKID CONTROL / ELECTRONIC BRAKING ASSIST) CAME ON THE DASH. THE VEHICLE FELT SLUGGISH AND THE CRUISE CONTROL WOULD NO LONGER WORK. THERE ARE ONLY 21,200+ MILES ON THE VEHICLE AND THIS WAS A VERY DANGEROUS SITUATION FOR MY FAMILY AND I WHILE TRAVELING ON THE INTERSTATE.

Reported

Aug 2020

Incident date

Jul 2020

Mileage

Not provided

Outcome flags

None reported

I PURCHASED A 2017 RV (17,00 MI) MERCEDES BENZ CHASSIS IN DEC 2019 AND IN FEB 2020 WHILE DRIVING HOME FROM A CAMPING TRIP (55 MPH HIGHWAY) THE WARNING LIGHT COME ON AND VEHICLE WAS SURGING. I LOOKED UP THE ISSUE (WHEEL SENSOR FAILURE) AND SLOWLY DROVE HOME. GOT APP WITH MB DEALER AND REAR SENSOR REPLACEMENT MADE UNDER WARRENTRY. I TALKED WITH PREVIOUS OWNER AND WAS GIVEN THE HISTORY OF REAR WHEEL SENSOR FAILURES WITH THIS RV. BELOW IS HIS RECORD NOV 2018 (12,00 MI) BOTH REAR WHEEL SENSOR FAILURES AND REPLACED. APRIL 2019 REAR WHEEL SENSOR FAILED AND REPLACED. JULY 2019 ONE SENSOR FAILED AND REPLACED. I HAVE READ WHERE THIS HAS BEEN A CONTINUED FAILURE ISSUE WITH MB WHEEL SENSORS. PLEASE LOOK INTO THIS ISSUE AND GET MB TO CORRECT THE PROBLEM. THANK YOU

Reported

Apr 2020

Incident date

Feb 2020

Mileage

Not provided

Outcome flags

None reported

WHEEL SPEED SENSOR FAILURE. ABS, TRACTION CONTROL SIT DOWN UNTIL REPLACED SENSOR.

Reported

Mar 2020

Incident date

Mar 2020

Mileage

Not provided

Outcome flags

None reported

BODY PARTS ARE FALLING OF FOR RUNNING BOARDS, PARTS HAVE FALLEN OFF ON THE HIGHWAY AND HIT OTHER VEHICLES. DEALER UNABLE TO FIND PARTS TO RESOLVE ISSUE.

Reported

Jan 2020

Incident date

Sep 2019

Mileage

Not provided

Outcome flags

None reported

I HAVE A 2018 THOR SIESTA MOTOR HOME BUILT ON A MERCEDES BENZ 3500 CHASSIS. I WENT ON A 6700 MILE CROSS COUNTRY TRIP AND UPON RETURN FOUND THE FRONT PASSENGER TIRE FLAT. A LOCAL SHOP DISCOVERED THAT THE RIM WAS LEAKING AIR FROM A BAD WELD SPOT/CRACK ON THE INSIDE. I REPLACED THE RIM BACK ON MAY 27, 2019. I THEN WENT ON A 1000 MILE ROUND TRIP AND THE FOLLOWING DAY I NOTICED ANOTHER FLAT TIRE THIS TIME ON THE INSIDE REAR DUAL ON THE PASSENGER SIDE. MY LOCAL SHOP CONFIRMED THE SAME ISSUE WITH A WELD/CRACK ON THE INSIDE OF THE RIM ON MAY 29, 2019. I HAD TO REPLACE THAT RIM ALSO. BOTH TIMES I NOTICED THE FLAT TIRES AFTER PARKING THE VEHICLE UPON RETURNING FROM LONG ROAD TRIPS. ON THE SECOND WHEEL REPLACEMENT, I WAS SHOWN WHERE THE LEAK WAS DETECTED WHICH WAS AT THE CORNER OF THE INSIDE WELD SPOT. THERE ARE 8 WELD SPOTS ON THE INSIDE OF EACH RIM. EACH TIME THERE WAS AIR LEAKING AT THE SITE OF A WELD SPOT. I CALLED MY LOCAL MERCEDES BENZ DEALERSHIP TO INQUIRE IF THERE WAS A REPORTED ISSUE FROM THE FACTORY AND WAS TOLD NO. I THEN CALLED MY MOTOR HOME DEALERSHIP WITH THE SAME INQUIRY AND WAS TOLD THAT THEY HAVE NOT BEEN MADE AWARE OF ANY SUCH ISSUE.

Reported

Jul 2019

Incident date

May 2019

Mileage

Not provided

Outcome flags

None reported

THIS IS A FOLLOW-UP TO MY COMPLAINT OF AUGUST 27 2018, NHTSA NUMBER 11122749. I PREVIOUSLY REPORTED THE DATES AND CIRCUMSTANCES OF 3 WHEEL (RIMS) FAILURES DUE TO A CRACKED WELD WHERE THE TWO PIECES OF THE RIM ARE JOINED, CAUSING AIR TO LEAK AND TIRES TO DEFLATE. ON APRIL 12, 2019, I HAD ANOTHER FLAT TIRE DUE TO THE SAME REASONS AS STATED IN MY PREVIOUS REPORT, A WELD IN THE RIM THAT FAILED TO HOLD AIR. THUS FAR, FOUR OF THE SEVEN WHEELS/RIMS ON MY VEHICLE HAVE FAILED OVER AN 8 MONTH PERIOD AND 6500 MILES. DURING MOST OF THIS PERIOD THE VEHICLE WAS IN STORAGE. I DISCOVERED ALL THE PROBLEMS DURING MORNING AIR PRESSURE CHECKS AFTER DRIVING THE PREVIOUS DAY. I HAVE NO IDEA HOW MUCH DAMAGE COULD HAVE BEEN SUSTAINED TO THE TIRES WHEN THEY WERE AT 61PSI AT THE START OF ONE DAY AND AT 30PSI THE NEXT MORNING AFTER A 400 PLUS MILE DRIVING DAY. THEY WERE ALL SLOW LEAKS THAT MANIFESTED THEMSELVES AFTER A DAY OF DRIVING. THE VEHICLE WAS PURCHASED NEW IN NOVEMBER, 2018. IT IS A 2018 WINNEBAGO VIEW ON A 2017 SPRINTER CHASSIS.

Reported

Apr 2019

Incident date

Apr 2019

Mileage

Not provided

Outcome flags

None reported

THE RECALL HAS BEEN EFFECT SINCE 2013. AND YOUR NOTIFING MY NOW IN 2019 !?! WHAT'S WRONG WITH YOU PEOPLE!!

Reported

Mar 2019

Incident date

Mar 2019

Mileage

Not provided

Outcome flags

None reported

SPRINTER COMPLETELY LOST ELECTRICAL POWER, ENGINE AND DRIVE TRAIN PROPULSION. THE TACH AND SPEEDOMETER FROZE IN PLACE AT 2500 RPM AND 15MPH. 60 SECONDS PASSED AND THE DASH LIGHTS BLINKED AND THEN ALLOWED ME TO RESTART VEHICLE. IT WAS LIKE THE SYSTEM RE-BOOTED ITSELF. LUCKILY I WAS NOT AT SPEED OR IN A DRIVING LANE WHEN THIS HAPPENED. I HAD JUST FILLED THE TANK WITH DIESEL, MY DEF WAS AT 80% FULL AND I WAS DEPARTING THE SERVICE STATION. I WAS ABLE TO START VEHICLE AND RETURN HOME, 10 MILES. WHEN I ATTEMPTED TO RESTART THE VEHICLE AT HOME THE STARTER MADE A GRINDING NOISE AND THE MB DEALERSHIP HAS HEARD THE SAME NOISE. CALLLED MERCEDES SPRINTER HOTLINE AND GOT THE SPRINTER TOWED TO THE DEALERSHIP. *DT CONSUMER CONTACTED MANUFACTURER FOR THE SERVICE CALL.*JB

Reported

Mar 2019

Incident date

Mar 2019

Mileage

Not provided

Outcome flags

None reported

TL* THE CONTACT OWNS A 2018 MERCEDES-BENZ SPRINTER 2500 (NA). WHILE DRIVING 10 MPH, THE TRANSMISSION WENT INTO NEUTRAL AND THE VEHICLE FAILED TO ACCELERATE. THE CONTACT HAD TO QUICKLY SHIFT GEARS WHILE IN TRAFFIC. AFTERWARDS, THE VEHICLE DROVE NORMALLY. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED THREE TIMES. THE VEHICLE WAS TAKEN TO MERCEDES-BENZ OF PEMBROKE PINES (14199 PINES BLVD, PEMBROKE, FL 33027, (954) 644-5033) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 10.

Reported

Aug 2018

Incident date

Jul 2018

Mileage

Not provided

Outcome flags

None reported

THE CROSSWIND ASSIST IS NOT WORKING. BECAUSE OF THE HIGH PROFILE ON THIS VAN, IT BECOMES VERY DANGEROUS IN WINDY CONDITIONS. WE ALMOST GOT BLOWN OUT OF THE FREEWAY BECAUSE OF THIS FEATURE NOT WORKING ON OUR 2017 VAN. I TOOK IT TO THE DEALER AND THEY CAN NOT DUPLICATE THE ISSUE. OF COURSE NOT, WE LIVE IN FRESNO WHERE ONLY GETS WINDY ONCE A YEAR.

Reported

Jun 2018

Incident date

Apr 2018

Mileage

Not provided

Outcome flags

None reported

TL* THE CONTACT OWNS A 2017 MERCEDES-BENZ SPRINTER 2500. WHILE DRIVING VARIOUS SPEEDS, A RATTLING NOISE WAS HEARD INSIDE THE CARGO AREA. ALSO, DURING EXTREME HEAT, THE PASSENGER SIDE WOULD WARP. THE VEHICLE WAS TAKEN TO MERCEDES-BENZ OF TEMECULA (40910 TEMECULA CENTER DR., TEMECULA, CA 92591, (951) 216-7800) WHERE NO FAILURE WAS FOUND AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS DESIGNED IN THAT MANNER. THE VEHICLE WAS THEN TAKEN TO MERCEDES-BENZ OF LONG BEACH (2300 E SPRING ST, SIGNAL HILL, CA 90755, (562) 372-2707) WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE NEEDED TO BE INSULATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE SEVERAL TIMES AND A CASE WAS OPENED. THE MANUFACTURER REFERRED THE CONTACT BACK TO THE DEALER. THE CONTACT ALSO FILED A COMPLAINT WITH THE FEDERAL TRADE COMMISSION AND WAS INFORMED OF A PENDING RECALL IN REGARDS TO THE VEHICLE STRUCTURE. THE APPROXIMATE FAILURE MILEAGE WAS 80. *TT CONSUMER STATED THE BUMPER WAS DAMAGED AND REPLACED WHEN THE TRUCK WAS DELIVERED IN THE DARK. THE CARGO FLOOR WAS DEFECTIVE 2 FLORRS WERE ORDERED. UPDATED 9/25/18*JB

Reported

Jun 2018

Incident date

Sep 2017

Mileage

Not provided

Outcome flags

None reported

WHILE DRIVING SLOWLY (10MPH), ROUGHLY STRAIGHT, ON A GRAVEL ROAD, THE POWER STEERING SUDDENLY FAILED. I WAS ABLE TO STEER, BUT STEERING EFFORT WAS VERY HIGH. THE LOWER HOSE CONNECTED TO THE COOLER FOR THE POWER STEERING FLUID HAD FALLEN OFF AND ALL THE FLUID HAD BEEN EXPELLED. I COULD SEE NO REASON FOR THIS TO HAVE HAPPENED. THE CLAMP WAS STILL CONNECTED TO THE HOSE. THERE WAS NO EVIDENCE OF ANYTHING HITTING THE HOSE. THERE WAS NO EVIDENCE OF DAMAGE TO THE HOSE. I RE-ATTACHED THE HOSE. I DROVE TO THE NEAREST AUTO-PARTS STORE (~ 70 MILES, MIXED GRAVEL AND PAVEMENT) AND REFILLED THE POWER STEERING FLUID. I CONTINUED TO CHECK THE HOSE FREQUENTLY. I FOUND THAT DRIVING SLOWLY (10-15 MPH) ON GRAVEL ROADS, THE HOSE WORKS LOSE AND HAS TO BE PUSHED BACK ON EVERY 10 MILES OR SO. I THINK THERE IS CONSTANT RISK OF SUDDEN LOSS OF POWER STEERING. SUDDEN LOSS OF POWER STEERING IN A CORNER WITH A HEAVY VEHICLE LIKE THIS COULD BE CATASTROPHIC. THE TWO IMAGES BELOW SHOW THE CONNECTIONS TO THE COOLER FOR THE POWER STEERING FLUID BEFORE AND AFTER A SECTION OF GRAVEL ROAD THAT IS ABOUT 10 MILES LONG. THE ROAD WAS DRIVEN AT ABOUT 10 MPH. THE RECOMMENDED SPEED FOR THIS ROAD IS 25 MPH. THE LOWER HOSE IN THESE IMAGES IS THE HOSE IN QUESTION. IN THE SECOND IMAGE NOTICE THAT THE CLAMP IS ON THE FLARE. THIS HOSE IS ABOUT TO FALL OFF. *TT *JS *JS

Reported

Jun 2018

Incident date

Jun 2018

Mileage

Not provided

Outcome flags

None reported