2016 Mercedes Sprinter

Unshielded rear-center generator exhaust pipe positioned with approx 12 in clearance above the ground, ignited the exterior of vehicle when generator operated, causing total loss. My safety as well as my pets was put at great risk due to this design and lack of shielding. The problem has not been reproduced of confirmed by dealer or independent service center, however the fact of such pipe getting hot, and nbeing related to the generator was recognized by the dealer. There were no warning lamps, warning stickers near the electronic start switch in the vehicle; no messages or other symptoms of the problem prior to the failure. The design foreseeably exposes owners to fire risk, given owners only recognize the exhaust from the rear side of the vehicle; assume if the engine is off no exhaust heats up enough to start a grass or other fire. But, the majority of owners like myself do not know of any other exhaust outside of the vehicle is present. The shocking 12 inch proximity from the ground; at the rear of a 25 ft vehicle typically parking in car spaces with an overhang of the rear behind the rear wheels or a curb is a ridiculous fire risk to all owners, and the surrounding community. This is a design flaw still inherent in that same vehicle today,

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

Fire

The power steering system lost it's fluid and pump is cavitating. It's available for inspection. The vehicles can be steered at the moment, but if it were to fail completely, it could cause loss of control at highway speeds. The problem is ongoing but hasn't been presented to a dealer or independent service center. No, the this hasn't been inspected. There were no warning lamps or messages or symptoms prior to failure. NOTE: there is an existing recall for 2015-2020 Sprinter vans for this issue, however upon contacting the dealership, the 2016 model doesn't currently fall under this recall.

Reported

Jun 2025

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

Power steering return hose slipped off 1/2” and fluid leak. Has a recall, but not applicable to this vin. Although it appears to be effecting it? Secured line to best abilities.

Reported

Nov 2024

Incident date

Nov 2024

Mileage

Not provided

Outcome flags

None reported

The primary issue is the seal on the air conditioning unit, which is on top of the Sprinter van. Prior to purchasing it, we read multiple reviews that the seal breaks frequently and water pours into the cabin. It is a known defect and quite prevalent. Whenever we drive through rain and the seal is intact, we get drips of rain. When the seal needs to be replaced, gallons of water pour into the cabin. Replacing the seal costs thousands of dollars and we've replaced it a few times. We travel with buckets and a dozen bath towels in case we drive through rain. Seals for the air conditioning unit only last about a year before a new one is needed. Our local dealership is aware that this a widespread problem on Sprinters but Mercedes is refusing to to fix the issue. Secondly, the interior lights do not work. We've had them replaced and they quickly stop working. I'm not certain how prevalent this issue is in other Sprinters, but it is an issue that does not appear to have a long-time fix on our model.

Reported

Jul 2024

Incident date

Jul 2024

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Mercedes-Benz Sprinter 3500. The contact stated while driving approximately 65-70 MPH, the hood unintendedly opened, striking the windshield. The contact pulled to the side of the road and became aware that the latch screws had detached; however, the latch was still welded to the vehicle. The contact was able to clamp the hood down with a ratchet. The contact related the failure to NHTSA Campaign Number: 19V665000 (Latches/Locks/Linkages). The contact was referred by the Insurance provider to Safelite Auto Glass to have the windshield replaced. However, due to the damage done to the roof of the vehicle, the vehicle was not repaired. The vehicle had not been repaired. The dealer was contacted and informed of the failure. The dealer informed the contact that the VIN was not included in a recall. The vehicle had not been taken to the dealer. The manufacturer was made aware of the failure. The failure mileage was 200,000.

Reported

May 2024

Incident date

May 2024

Mileage

Not provided

Outcome flags

None reported

Had 2 rims develop cracks causing loss of air pressure in tires. 1st occurred at approx. 45000 miles (2019), 2nd occurred at 110000 (2023). Both failures occurred to area of rim where welds to lock in center (with lug holes) on outer rim (where tire sits) are situated. Both failures manifested as small air leak then suddenly crack increases in size dramatically to where tire can only hold air for a few hours before deflating fully

Reported

Jan 2024

Incident date

Jan 2024

Mileage

Not provided

Outcome flags

None reported

The check engine light came on in the Sprinter van. There is a Hissing noise coming from the engine when accelerating. The Sprinter van loses speed when on the highway. The vehicle could not keep up with traffic on the road. The Mercedes Benz dealer, Ft. Mitchell, Kentucky has inspected the vehicle and stated that it has a defective intake manifold. This vehicle has 140,000 miles at this time. At this time the van has not been repaired, the cost is $3132.77

Reported

Jul 2023

Incident date

Jul 2023

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Mercedes-Benz Sprinter 2500. The contact received notification of NHTSA Campaign Number: 19V003000 (Air Bags), 19V004000 (Air Bags), and 20V663000 (Steering) however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Reported

Jun 2023

Incident date

Jun 2023

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Mercedes-Benz Sprinter 3500. The contact stated that while driving at 30 MPH, the ABS warning light and the electronic stability control warning lights illuminated. The contact also stated that the motorhome was making abnormal clunking sounds. The contact was able to continue to drive at less than 30 MPH. The manufacturer was notified of the failure and advised the contact that one of the wheels must have failed to patch the ground. The manufacturer advised the contact to turn the vehicle on and off three times using the ignition key for the warning lights to disappear. The contact stated that he did so and the warning lights and warning messages disappeared; however, they reappeared the next day. The contact stated that while driving at 50 MPH and towing his Volkswagen vehicle, the transmission disengaged and the vehicle made an abnormal clunking sound. Then the transmission reengaged and disengaged causing the vehicle to lurch forward. The contact continued to drive the vehicle. The contact stated upon starting the vehicle the failure reoccurred. The RV was taken to the dealer who diagnosed that the rear axle speed sensors, knock sensors needed to be replaced, and the recall repair for NHTSA Campaign Number: 21V042000 (ELECTRONIC STABILITY CONTROL) was completed. The contact also stated that the dealer cross-fired the speed sensors which caused the computer to not allow the vehicle to drive more than 35 MPH. The vehicle was not diagnosed or repaired. The contact stated that while driving at 5 MPH, the vehicle leaned on his right side and crashed into a street sign. The air bags failed to deploy. There were no injuries sustained. A police report was not filed. The contact stated that while driving at an undisclosed speed, The warning lights reappeared and the vehicle leaned and hit the curb. The air bags did not deploy. There were no injuries sustained. A police report was not filed. The manufacturer was notified of the failures and offered the contract to trade the vehicle. The vehicle was not repaired. The failure mileage was approximately 2,000.

Reported

Jan 2022

Incident date

Jan 2022

Mileage

Not provided

Outcome flags

Crash

trucks cut speed limit 65 to 10 normal highway i do understood %35 degrees slow down but its only %2 degrees uprise there is no power at engine rpm is shows less then 1 rpm and even if press the gas pedal all the way the truck does not accelerate like truck is lock right there very dangers any one drive back of me they are not accept that much speed change they are in dangers scarr to drive truck be couse same one get git back of truck and can get kill

Reported

Nov 2021

Incident date

Oct 2021

Mileage

Not provided

Outcome flags

None reported

There is a known issue and recall for wheel speed sensors on Mercedes Sprinter 3500 models. However, this same issue applied to 2500 models also. Along with other RV owners, I have just experienced this problem. I was in city traffic when all the sudden multiple warning lights came on: "ESP, visit workshop", "Brake force distribution, visit workshop", ABS warning light, ESP, warning light, collision prevention malfunction warning light, check engine light with fault code U0416. The presence of all these errors, beeping, red messages sounds extremely scary to any driver. The fact that it says brake force distribution isn't working properly suggests a hazardous condition that could lead to a crash if brakes are not working properly. Since this is being caused by a failing wheel speed sensor, these should all be replaced and the recall expanded to include other models like mine.

Reported

Nov 2021

Incident date

Nov 2021

Mileage

Not provided

Outcome flags

None reported

My 2016 Sprinter is suffering from a failing EGR valve that's causing intermittent power loss. The issue started after only 25000mi on the odometer. No errors are shown, nothing indicates malfunction. The problem is quite severe and presenting itself through random power loss. When accelerating the car will jerk and lose acceleration force suddenly. Driving uphill is the worst and producing constant jerking. Once moving at a good speed it's less notable but still present. The main safety concern is that the behavior is unpredictable and in situations where it's necessary to accelerate into a road with traffic, this can lead to a hazardous when the car doesn't accelerate as intended. In multiple occasions I was unable to properly speed up and get moving and thus blocking traffic behind me and forcing them to slow down or change lanes. The Mercedes dealer diagnosed a malfunctioning EGR valve on the edge of failing completely which would put the Sprinter in "limp home mode" which has limited power output to prevent further damage. Since this is a known issue and the EGR valves have been failing frequently with various Sprinter models, these should be recalled and replaced! Currently, it's not even possible to get this issue addressed. The EGR valves are back-ordered and not available for 6 MONTHS! That's 6 months of limping through traffic with the potential of the valve failing completely. Unacceptable!

Reported

Nov 2021

Incident date

Oct 2021

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Mercedes-Benz Sprinter 3500. The contact stated that while driving, several unknown warning lights illuminated. The contact pulled over and restarted the vehicle. The contact received notification of NHTSA campaign number: 21V042000 (Electronic Stability Control) however, the part to do the recall repair was unavailable. The contact called the local dealer who stated that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the failure. The approximate failure mileage was 8,000. Parts distribution disconnect.

Reported

Oct 2021

Incident date

Aug 2020

Mileage

Not provided

Outcome flags

None reported

The NHTSA law requires that the recall be done on a timely manner . Mercedes benz is not doing this . The wheel sensor recall is being not being done in a timely manner by Mercedes benz. They are typically making appointments 1 month to 3 months out to do a recall that takes 40 minutes to accomplish. .They are purposely endangering sprinter RV owners by their untimely repair schedule.

Reported

Sep 2021

Incident date

Aug 2021

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Mercedes-Benz Sprinter 3500. The contact received notification of NHTSA Campaign Number: 21V042000 (Electronic Stability Control) however, the part to do the recall repair was unavailable. The contact stated that while driving over a railroad track at a slow speed, the vehicle independently accelerated with the ABS, check engine, and traction control warning lights illuminated. The contact was able to safely stop the vehicle and shut-off the vehicle. Due to the failure, the contact had the vehicle towed to the dealer. Due to the parts for the repair not being available, the dealer decided to place a new, yet defective, speed sensor on the vehicle as a temporary repair and the contact drove the vehicle back home. The manufacturer was informed of the failure but offered no assistance. The contact had called three separate dealers and it was confirmed that the part would not be available until the fourth quarter of 2021. The vehicle was not repaired. The failure mileage was 23,580. Vin tool confirms parts not available.

Reported

Jul 2021

Incident date

Jun 2021

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Mercedes-Benz 2500. The contact stated while driving 21 mph, the vehicle independently accelerated when the brake pedal was depressed. The contact was not able to control the vehicle however, the contact was able to shift the vehicle into neutral to stop the vehicle. The contact stated there was no warning light illuminated. The vehicle was not taken to a local dealer nor an independent mechanic to be diagnosed. The contact was relating the failure to faulty wheel speed sensors. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 50,600.

Reported

Jul 2021

Incident date

Aug 2018

Mileage

Not provided

Outcome flags

None reported

WHILE DRIVING ON THE ROAD IN CRUISE CONTROL ENGINE JUST SUDDENLY GOES INTO LIMP MODE AND LOSES POWER. IT IS VERY UNSAFE TO PULL OVER THE SIDE OF THE FREEWAY OR WHILE GOING UPHILL. ERROR CODE WAS P0087- LOW FUEL RAIL PRESSURE! AFTER PULLING OVER AND SHUTTING OFF THE VEHICLE AND RE-STARTING IT THEN IT GOES BACK TO NORMAL. NEED TO ADDRESS THIS ISSUE AS IT IS VERY UNSAFE! IT HAPPENED 4X DURING MY TRAVEL OF 8000 MILES

Reported

Jul 2021

Incident date

Jun 2021

Mileage

Not provided

Outcome flags

None reported

THE WHEEL SPEED SENSORS ON THIS VEHICLE HAVE BEEN REPLACED FOUR TIMES IN 15000 MOLES. WHEN THE SENSOR FAILS THE VEHICLE SUDDENLY SHUDDERS TO A LOS SPEED WHICH CAN CREATE A VERY DANGEROUS SITUATION FOR MYSELF AND MY FAMILY

Reported

Apr 2021

Incident date

Apr 2021

Mileage

Not provided

Outcome flags

None reported

MY ROOF IS LEAKING. I HAVE BEEN WONDERING WHERE THE STAINS ARE COMING FROM ON MY CEILING. TODAY IS A RAINY DAY IN CINCINNATI. I GO TO PUT MY GROCERY IN THE VAN THE CEILING IS SOAK AND WET. NOW I UNDERSTAND WHY MY DISABLED CHILD AND I STAY SICK AND WHY ITS RUSTING OUT.

Reported

Apr 2021

Incident date

Apr 2021

Mileage

Not provided

Outcome flags

None reported

TL* THE CONTACT OWNS A 2016 MERCEDES-BENZ SPRINTER 3500. THE CONTACT DISCOVERED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 21V042000 (ELECTRONIC STABILITY CONTROL) HOWEVER, THE PARTS TO DO THE RECALL REPAIR WAS UNAVAILABLE. MERCEDES-BENZ OF WILSONVILLE (25035 SW PARKWAY AVE, WILSONVILLE, OR 97070, 503-454-5000) WAS CONTACTED AND IT WAS CONFIRMED THAT THE PART WAS NOT YET AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

Reported

Mar 2021

Incident date

Mar 2021

Mileage

Not provided

Outcome flags

None reported

I'VE OWNED THIS CAR 2 YEARS. IN THE SUMMER TIME WHEN WE TURN ON THE A/C THERE IS A BAD ODOR COMING OUT OF THE VENTS. ONLY IN THE SUMMER IT'S NOT A PLEASANT SMELL. DURING THE WINTER TIME LAST YEAR WAS A GASOLINE SMELL BUT THAT GOT FIXED. I WOULD LIKE FOR YOU TO LOOK INTO IT PLEASE IT'S A MOLDY SMELL.

Reported

Mar 2021

Incident date

May 2020

Mileage

Not provided

Outcome flags

None reported

ON SEPTEMBER 30, 2019, I WAS DRIVING DOWNHILL ON A MOUNTAIN ROAD WHEN OUR RV, A 25' LTV UNITY ON A MERCEDES SPRINTER 3500 CHASSIS, SUDDENLY LURCHED AND FELT OUT OF CONTROL. THE BREAKS AND STEERING WERE UNRESPONSIVE, AND I WAS PUMPING THE BREAKS, HARD! AFTER ABOUT 10 MINUTES OF STRUGGLING TO CONTROL THE VEHICLE AROUND A CURVEY DOWNHILL ROAD, CONTROL WAS RESTORED. LUCKILY, I WAS GOING SLOW ENOUGH THAT NO ACCIDENT RESULTED, BUT IT REALLY SHOOK ME! A COUPLE OF DAYS LATER THE VEHICLE (STILL UNDER WARRANTY) WAS LOADED ONTO A FLATBED TRUCK AND HAULED 2 HOURS AWAY TO KNOXVILLE, TN; THE CLOSEST MERCEDES SPRINTER VAN SERVICE CENTER. THEY REPLACED THE RIGHT REAR WHEEL SPEED SENSOR. I WAS TOLD THE OTHER SENSORS MIGHT ALSO FAIL, BUT THEY COULD NOT BE REPLACED UNTIL THEY FAILED. SINCE THEN, WE HAVE HEARD FROM SEVERAL OTHER RVERS WITH MERCEDES SPRINTER CHASSIS THAT THIS IS A COMMON PROBLEM. FOR US, THE VEHICLE NO LONGER FEELS SAFE TO TAKE ON THE ROAD SINCE WE HAVE NO IDEA WHEN THE NEXT SENSOR WILL FAIL. (PS - I TRIED TO SUBMIT THIS FORM EARLIER, BUT ACCIDENTALLY SELECTED 'I DO NOT WISH TO RECEIVE SAFETY RECALL ALERTS' - I DO WISH TO RECEIVE THOSE ALERTS.

Reported

Feb 2021

Incident date

Sep 2019

Mileage

Not provided

Outcome flags

None reported

WHEEL SPEED SENSORS KEEP FAILING. I HAVE HAD EIGHT SENSORS FAIL IN THREE YEARS OF OWNERSHIP. TRANSMISSION SHIFTS ERRATICALLY, SPEED SURGES, ABS, CHECK ENGINE LIGHT AND BRAKING IS IMPAIRED. THIS HAPPENS WHEN VEHICLE IS IN MOTION.

Reported

Jan 2021

Incident date

Jan 2021

Mileage

Not provided

Outcome flags

None reported

FOR THE THIRD TIME THE ESP AND ABS SYSTEM WARNING MESSAGE IS SHOWN, AT FIRST THE SPEED OF THE VEHICLE INCREASES, IN THIS CASE FROM THE SET 60 MPH TO 70, AT WHICH POINT I SHUT THE CRUISE CONTROL DOWN. FROM THEN ON FOR THE REST OF THE DAYS TRAVEL C.A.200 MILES AND FOR THE REST OF THE TRIP (450 MILES) CRUISE CONTROL WAS INOPERATIVE. EACH TIME IT HAPPENS A MECHANIC VISIT IS NECESSARY. THE VEHICLE IS A WINNEBAGO NAVION

Reported

Jan 2021

Incident date

Jan 2020

Mileage

Not provided

Outcome flags

None reported

I OWN AN RV ON A MERCEDES 3500 SPRINTER CHASIS. I HAVE EXPERIENCED NUMEROUS FAILURES THAT CAUSE THE RV TO SPEED UP RAPIDLY AND I HAVE TO TAKE EMERGENCY ACTION TO AVOID AN ACCIDENT. USUALLY, I SHIFT INTO NEUTRAL TO DISENGAGE THE TRANSMISSION. I HAVE ~43,000 MILES ON MY RV AND I HAVE EXPERIENCED THIS ISSUE AND MERCEDES HAS REPLACED THE WHEEL SENSORS 6 DIFFERENT TIMES. ALL MAINTENANCE PERFORMED ON THE VEHICLE HAS BEEN PROVIDED BY A MERCEDES DEALER SERVICE CENTER. DOESN'T SEEM TO MATTER IF I AM DRIVING ON THE FREEWAY OR CITY STREETS, WHEN THE FAILURE HAPPENS, THE VEHICLE STARTS TO ACCELERATE RAPIDLY, RPMS SKYROCKET, THE DASHBOARD GETS THREE TROUBLE INDICATOR LIGHTS THAT COME ON, THE CHECK ENGINE LIGHT COMES ON. I AM PICKING UP THE VEHICLE FROM THE LOCAL MERCEDES DEALER TODAY AFTER JUST HAVING ANOTHER SENSOR FAILURE. I WAS DRIVING ON I-10 WHEN THE MOST RECENT FAILURE OCCURRED. THE VEHICLE BEGAN TO ACCELERATE, RPMS WENT VERY HIGH. VERY SCARY SITUATION. THE "WHEN DID THIS HAPPEN" DATE I'VE ENTERED IS FOR THE MOST RECENT FAILURE. I HAVE EXPERIENCED THIS ISSUE NUMEROUS TIMES.

Reported

Jan 2021

Incident date

Dec 2020

Mileage

Not provided

Outcome flags

None reported

DRIVING ON A DRY DAY, SMOOTH ROAD, WITH CRUISE CONTROL ON 65MPH AT 7:45PM. THIS VEHICLE IS CONVERTED WITH A THOR 24HL CAMPER ON THE CHASSIS. FIVE HOURS INTO THE DAYS DRIVE THE VEHICLE FLASHED ASR/ESP TRIANGLE - AND JERKED ABRUPTLY BUT INSTANTANEOUSLY BUT REMAINED ON CRUISE CONTROL. 2 SECONDS LATER: ABS LIGHT ON, ASR/BAS LIGHT ON, ESP LIGHT ON CRUISE CONTROL STOPPED FUNCTIONING (FYI - A VERY HEAVY ACCELERATOR PEDAL SPRING MAKES DRIVING DIFFICULT, FOR HOURS ON END, WITHOUT CRUISE WORKING - ESPECIALLY FOR THE OLDER DRIVERS LIKELY TO BE DRIVING THIS RIG.) PULLED OFF THE SIDE OF THE ROAD, SET FLASHERS, AND TURNED OFF ENGINE FOR ONE MIN HOPING TO RESET THE FAULT. TURNED BACK ON - NO CHANGE OFF THEN BACK ON AND THE YELLOW CHECK ENGINE CAME ON STEADY ALONG WITH THREE PREVIOUS AUCTION LIGHTS (ABOVE) VEHICLE HAD EXPERIENCED (WITH THE PREVIOUS OWNER) A PREVIOUS 'WHEEL SPEED SENSOR FAILURE' AND IT WAS REPAIRED. . 'WHEEL SPEED SENSOR FAILURE' APPEAR AT EPIDEMIC LEVELS ON THE TWO RV FACEBOOK GROUPS ASSOCIATED WITH THIS VEHICLE. THE 5TH KEY TURN AFTER INITIAL FAULT AND FAILURE OF CRUISE CONTROL THE THREE LIGHTS WENT OUT BUT THE CHECK ENGINE LIGHT REMAINED ON. ON APPROXIMATELY THE TENTH KEY TURN THE CHECK ENGINE LIGHT WENT OUT. VEHICLE RETURNED FOR SERVICE AT MERCEDES DEALERSHIP 'UNDER WARRANTY'. MY ISSUE LAYS IN THE POTENTIAL FOR THE VEHICLE TO ENTER INTO THE LIMP MODE IF ANOTHER CENSOR SHOWS A FAULT AND I'M ON THE ALASKA HIGHWAY 200 MILES FROM THE NEAREST POSSIBLE SERVICE. DEALER REFUSES TO SHARE TECH DATA CONCERNING RESET OF FAULT CONDITION OR A MERCEDES FIX FOR THIS NOW WELL KNOWN AND DOCUMENTED VEHICLE SHORTCOMING. THIS ISSUE CAN AND WILL GET PEOPLE KILLED AS THEY 'LIMP' DOWN THE HIGHWAY TO GET SERVICED OR ARE FORCED TO PULL OVER IN HEAVY TRAFFIC TO CHECK OUT WHAT MERCEDES SHOULD BE WARNING IS ALL ABOUT PROACTIVELY.

Reported

Jan 2021

Incident date

Dec 2020

Mileage

Not provided

Outcome flags

None reported

I HAVE HAD TO REPLACE OUT OF POCKET ALL FOUR BRAKE SPEED SENSORS WHILE THEY SHOULD HAVE BEEN COVERED UNDER WARRANTY. MY LOCAL MERCEDES DEALER EVENTUALLY ACKNOWLEDGED THIS, BUT WILL NOT REIMBURSE SINCE THEY DID NOT REPLACE THEM. THIS ALL HAPPENED BETWEEN 17 AND 21,000 MILES AND CREATED UNSAFE DRIVING CONDITIONS.

Reported

Dec 2020

Incident date

Dec 2019

Mileage

Not provided

Outcome flags

None reported

REAR WHEEL SPEED SENSOR HAD TO BE REPLACED AT 30,000 MILES AND NOW BOTH FRONT WHEEL SENSORS ARE FAULTY AT 50.000 MILES. IN MY READING THIS IS A COMMONLY FAULTY PART AND IT COST $ 760.00 TO REPLACE BOTH SENSORS. FORTUNATELY THE FIRST SENSOR WAS UNDER WARRANTY. IT WOULD BE GREATLY APPRECIATED IF YOU WILL LOOK INTO THIS ISSUE. BECAUSE YOU CANNOT AFFORD TO TRADE AN RV. I WAS ON A TRIP WHEN THE INDICATOR LIGHTS CAME ON ON DASH AND I WAS ABLE TO DRIVE 7 HOURS HOMES. MY OWNERS MANUAL EXPRESSED I SHOULD SEEK TECHNICAL ASSISTANCE ASAP.

Reported

Dec 2020

Incident date

Nov 2020

Mileage

Not provided

Outcome flags

None reported

BOTH LEFT AND RIGHT REAR WHEEL SPEED SENSORS FAILED RESULTING IN TRANSMISSION LIMITED TO 2ND GEAR AND BACK UP. VEHICLE HAS DRIVEN 9800 MILES TOTAL.

Reported

Nov 2020

Incident date

Nov 2020

Mileage

Not provided

Outcome flags

None reported

THE WHEEL SENSORS ON THIS VEHICLE ROUTINELY FAIL. WHEN THEY FAIL AT HIGH SPEEDS(FREEWAY DRIVING) THE CRUISE CONTROL, ABS, STABILITY CONTROL, 4WD IS NO LONGER FUNCTIONAL. IF IT FAILS AT START UP, ALL THE SAME SYSTEMS ARE EFFECTED IN ADDITION YOU CANNOT DRIVE THE VEHICLE OVER 30MPH, IT WILL ACCELERATE ON ITS OWN, IT WILL SURGE ALSO. THIS HAS HAPPENED EVERY YEAR I HAVE OWNED THE VEHICLE. SOMETIMES TWICE A YEAR. EACH WHEEL SENSOR HAS FAILED, SOME TWICE.

Reported

Nov 2020

Incident date

Aug 2020

Mileage

Not provided

Outcome flags

None reported

WHEN I WENT TO TRY THE 4 WHEEL DRIVE THE FOLLOWING THINGS HAPPENED: A CLUNKING SOUND IN THE REAR OF THE VEHICLE. NUMEROUS WARNING LIGHTS CAME ON . ABS, COLLISION AVOIDANCE, CRUISE CONTROL, CHECK ENGINE, ESC OR ESP. OVER TIME THE LIGHTS CLEARED BUT CAME BACK ON WEEKS APART. I AM A RETIRED NASA SAFETY/RELIABLY ENGINEER. IN MY OPINION ALL OF THESE LIGHTS COME ON AS A RESULT OF FAILURES OF ONE OR MORE WHEEL SPEED SENSORS. THIS IS A MAJOR SAFETY PROBLEM AS WHEN THERE IS A FAILED OR INTERMITTENT OPERATION OF A FAILED SPEED SENSOR. ALL OF THESE SAFETY SYSTEMS FAIL WHEN THE ONE SENSOR FAILS. THIS FAILURE COULD OCCUR UNEXPECTEDLY AT ANY TIME. LEADING TO LOSS OF LIVES AND VEHICLE. I HAVE NOT RECEIVED ANY WARNING LETTERS ON THIS MAJOR SAFETY FAILURE. ACCORDING TO THE DEALER MERCEDES IS AWARE OF THIS ISSUE. AFTER THE VEHICLE IS OUT OF WARRANTY MERCEDES SAYS THEY WILL CHARGE THE OWNER TO FIX IT. AT THE VERY LEAST THE ISSUE CLEARLY NECESSITATES THAT THIS ISSUE BE ELEVATED, TO CONSUMERS, AND THAT THE ISSUE BE FIXED . A WARNING THAT DESCRIBES THE ISSUE AND MERCEDES STATUS ON A FIX SHOULD GO OUT TO ALL THE APPROPRIATE PARTIES IMMEDIATELY. THE VEHICLE WAS STOPPED PUT IN NEUTRAL THEN 4 WHEEL DRIVE WAS ENGAGED, IMMEDIATELY WHEN MOVING THERE WAS A BIG CLUNK AND THE WARNING LIGHTS CAME ON. THEY WENT OUT THEN CAME BACK ON INTERMITTENTLY FOR MONTHS. ONE TIME THEY CAME ON JUST SITTING AT THE LIGHT. FAILURE OF MULTIPLE SAFETY SYSTEMS DUE TO A SENSOR FAILURE IS UNACCEPTABLE. I BELIEVE A DESIGN FIX IS URGENTLY NEEDED AND SHOULD BE PRESSED FOR HARD BY THE GOVERNMENT. CURRENTLY THERE IS NO FIX. AND MERCEDES IS NOT ADEQUATELY WARNING THE PUBLIC OF THE ISSUE. UNTIL I PRESSED MERCEDES HARD ON THIS INTERMITTENT PROBLEM I WAS NOT MADE AWARE OF WHAT EXACTLY THE PROBLEM WAS. THE FAILURE OF ONE SENSOR SPEED CAUSES MULTIPLE SAFETY SYSTEMS TO NOT WORK.

Reported

Nov 2020

Incident date

Nov 2017

Mileage

Not provided

Outcome flags

None reported

THIRD-TIME SPEED SENSOR FAILED WHILE DRIVING ' ALL 3 TIMES WHILE DRIVING ON HIGHWAY. CAUSES THE VEHICLE TO SPEED UP / SLOW DOWN AND LURCH WITH THE ENGINE DOING HIGH REVS. CRUISE CONTROL BECOME INOPERABLE. ABS, FORWARD COLLISION, AND PARKING SENSORS BECOME INOPERABLE. BRAKES PERFORM ERRATICALLY FOR SEVERAL MOMENTS AND THEN ABS INDICATES IT IS INOPERABLE. VAN BECOMES HAZARDOUS TO DRIVE WHILE THE ELECTRONICS ATTEMPT TO SORT OUT WHAT IS GOING ON. VERY GLAD I WAS NOT IN CONGESTED TRAFFIC EACH TIME THIS HAPPENS AS THE VAN BECOMES UNSTABLE. M-BENZ SOLUTION IS TO REPLACE SENSOR ' THIS DOES NOT SEEM SAFE NOR VIABLE LONG TERM FIX.

Reported

Nov 2020

Incident date

Nov 2020

Mileage

Not provided

Outcome flags

None reported

TL* THE CONTACT OWNS A 2016 MERCEDES-BENZ SPRINTER 3500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V003000 (AIR BAGS) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT CONTACTED TROPHY MERCEDES-BENZ OF VALENCIA (23355 VALENCIA BLVD, SANTA CLARITA, CA 91355, (661) 753-5555) WHERE IT WAS CONFIRMED THAT PARTS WERE NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

Reported

Oct 2020

Incident date

Oct 2019

Mileage

Not provided

Outcome flags

None reported

DRIVING ALONG IN CRUISE CONTROL AROUND 65 MPH ALL OF A SUDDEN CRUISE CONTROL STOPS WORKING AND VEHICLE BUCKS QUITE A BIT,VERY STARTLING.THEN I NOTICE ON DASHBOARD THE SO CALLED THREE STOOGES LIGHTS APPEAR.THIS WAS MY FIRST ENCOUNTER AROUND 18,000 MI.AUGUST 2020.PROBLEM FIXED IN CT UNDER WARRANTY. TWO MONTHS LATER DRIVING THROUGH VIRGINIA,SAME STOOGE LIGHTS APPEAR IN THE MOUNTAINS SHIFTING ERRATICALLY.CALLED M B TECH, VERY HELPFUL,DIRECTED ME TO MERCEDES BENZ OF FREDERICKSBURG VA 77 MILES AWAY.INCONVENIENCED BUT GRATEFUL WORK WAS DONE UNDER WARRANTY.I BELIEVE THIS IS A HAZARD ON THE ROADS AND SHOULD BE A RECALL.

Reported

Oct 2020

Incident date

Oct 2020

Mileage

Not provided

Outcome flags

None reported

MB SPRINTER HAS FAULT THAT GENERATES INSTRUMENTS INDICATORS OF ABS, SKIDDING AND ANOTHER. BEFORE THIS OCCURRED TRANSMISSION SHIFTING BECAME ERRATIC AND WHEN BREAKING THE ENGINE REVVED UP AND ALSO MADE BRAKES UNLESS. NO ACCIDENT OCCURRED BUT WAS ALMOST OUT OF CONTROL.

Reported

Oct 2020

Incident date

Oct 2020

Mileage

Not provided

Outcome flags

None reported

WHEEL SPEED SENSOR FAILURE CAUSED VEHICLE TO DISABLE CRUISE CONTROL, ABS BRAKE SYSTEM AND PUT THE TRANSMISSION IN LIMP MODE. CANNOT ACCELERATE MORE THAN 25 MPH ON THE INTERSTATE. WAS TRAVELLING AT 62 MPH WHEN EVENT OCCURED. FRIGHTENING EXPERIENCE!

Reported

Oct 2020

Incident date

Sep 2020

Mileage

Not provided

Outcome flags

None reported

WHEEL SPEED SENSOR FAILED AT 10000 MILES (REFER TO PREVIOUS COMPLAINT), AGAIN FAILS AT 20000 MILES CAUSING ERRATIC TRANSMISSION SHIFTING AND PROPULSION WITHOUT DRIVER INPUT.

Reported

Oct 2020

Incident date

Oct 2020

Mileage

Not provided

Outcome flags

None reported

RV TRANSFER SWITCH CAUGHT FIRE WHILE SLEEPING. 5100 SERIES TRANSFER SWITCH.*DT CONSUMER STATED DIDN'T KNOW WHY IT HAPPENED BUT COULD OF BEEN THE VIBRATION WHICH MAY HAVE LOOSEN THE SCREWS.*JB

Reported

Sep 2020

Incident date

Sep 2020

Mileage

Not provided

Outcome flags

Fire

2016 MERCEDES BENZ SPRINTER 3500. CONSUMER WRITES IN REGARDS TO ACCELERATION ISSUES. *LD THE CONSUMER STATED, WHILE DRIVING ON HIGHWAY 20, THE VEHICLE LOST THE ABILITY TO ACCELERATE AND SHIFT GEARS. THE SPEED DECREASED TO LESS THAN 20 MPH. *JS

Reported

Sep 2020

Incident date

Jun 2020

Mileage

Not provided

Outcome flags

None reported

WE RECEIVED A SAFETY RECALL (NHTSDA #19V004) INDICATING THE PASSENGER-SIDE AIRBAG IS AFFECTED BY THIS RECALL BASED ON THE DEFECT DECISION OF TK HOLDINGS, INC. ("TAKATA"). AT THE TIME WE WERE BATTLING CANCER AND THE CORONA VIRUS, SO WE DID NOT GET IT SERVICED AND IT REMAINED IN THE STORAGE. IN THE MEANTIME WE RECEIVED NUMEROUS CALLS TO BRING IT IN FOR SERVICE, BUT DID NOT HAVE THE TIME TO GET IT OUT OF STORAGE AND DRIVE 400 MILES TO GET THE RECALL FIXED. NOW THAT WE HAVE THE TIME, WE CALLED MERCEDES DEALER AND MAIN COMPANY, BUT THEY INDICATE THE RECALL DISAPPEARED EVEN THOUGH WE HAVE A LETTER AND RECEIVED MANY CALLS PRIOR TO GET IT CHANGED OUT. THE LETTER INDICATES "THE DEFECT IN YOUR PASSENGER-SIDE AIRBAG INFLATOR MAY CAUSE THE INFLATOR HOUSING TO RUPTURE.A PASSENGER-SIDE INFLATOR RUPTURE DURING DEPLOYMENT COULD RESULT IN METAL FRAGMENTS STRIKING THE FRONT PASSENGER OR OTHER OCCUPANTS, POSSIBLY CAUSING SERIOUS INJURY OR DEATH." SO WE ARE CONCERNED. HOW DID MERCEDES MAKE THIS DISAPPEAR WITHOUT CORRECTING THE PROBLEM?

Reported

Aug 2020

Incident date

Aug 2020

Mileage

Not provided

Outcome flags

None reported

MY 2016 2500 SPRINTER CONTINUES TO HAVE WHEEL SPEED SENSOR FAILURES EVERY 2K-3K MILES. WHEN THIS HAPPENS THE TRANSMISSION ACTS ERRATICALLY, ANTI-LOCK BRAKE SYSTEM STARTS TO ENGAGE AND DISENGAGE SPORADICALLY AND THE VAN SOMETIME ACCELERATES AND PREVENTS STOPPING. THIS CREATES A VERY DANGEROUS SITUATION, ESPECIALLY WHEN IN THE RAIN OR EVEN HEAVY TRAFFIC. EVNTUALLY ONCE THE SYSTEM DETECTS THE FAILURE IT LIGHTS UP THREE LIGHT ON THE DASH AND DISABLES THE ANTI-LOCK BRAKES, ESP, AND TRACTION CONTROL. THE TRANSMISSION CONTINUES TO SHIFT ERRATICALLY AT TIMES EVEN AFTER LIGHTS COME ON.

Reported

Aug 2020

Incident date

Aug 2020

Mileage

Not provided

Outcome flags

None reported

AT 24,000 MILES TWO WHEEL SPEED SENSORS FAILED CAUSING ESP, ABS, AND CHECK ENGINE WARNING LIGHTS TO ILLUMINATE. ALSO THIS DISABLED THE CRUISE CONTROL. VEHICLE SAT OVERNIGHT AND UPON STARTING NO ERROR MESSAGES APPEARED. THE FOLLOWING DAY THESE ISSUES REOCCURRED. TOOK VEHICLE TO MB DEALER FOR DIAGNOSTICS, WHICH CONFIRMED THE SPEED SENSOR FAILURES. COST OF REPAIR $1,100. UNDERSTAND THIS IS A KNOWN, COMMONLY REPORTED PROBLEM WITH SPRINTERS BETWEEN 2013 - 2016. MB SHOULD BE HELD RESPONSIBLE FOR RECALLS AND THE COST OF REPAIRS.

Reported

Aug 2020

Incident date

Aug 2020

Mileage

Not provided

Outcome flags

None reported

HAVE HAD THREE DIFFERENT WHEEL SENSORS GO OUT CAUSING ENGINE TO GO INTO LIMP MODE RESULTING IN HAZARDOUS DRIVING CONDITIONS. MOST MERCEDES DEALERS CANNOT DO THIS SERVICE. THIS IS A DANGEROUS FAULT THAT MANY HAVE EXPERIENCED AND IS A SERIOUS ROAD SAFETY HAZARD. IN ALL INSTANCES I WAS DRIVING VEHICLE ON 'WASHBOARD' ROAD CONDITIONS; ONCE IN I-70 WESRBOUND FROM KANSAS CITY.

Reported

Jul 2020

Incident date

Jun 2020

Mileage

Not provided

Outcome flags

None reported

DRIVING ALONG ON CRUISE CONTROL. CRUISE CONTROL DEACTIVATES, ANTI-LOCK, TRACTION CONTROL AND ANTI-SKID LIGHTS COME ON. I STOP THE VEHICLE, THE TRANSMISSION WANDERS BETWEEN GEARS JERKING. I GO TO MB DEALERSHIP THEY REPLACE R REAR SPEED SENSOR MILEAGE:9659MILES. AT 12,060 MILES THE SAME THING HAPPENS. I DRIVEA FIVE HOUR ROUND TRIP TO MB DEALER, THEY REPLACE THE L REAR SPEED SENSOR. AT 17,000 MILES (NOW OFF WARRANTY) ALL THE LAMPS ARE ON AGAIN, THE TRANSMISSION WILL NOT SHIFT INTO DRIVE AND I FACE A 133 MILE TOW TO KNOXVILLE, TN MERCEDES DEALERSHIP.

Reported

Jun 2020

Incident date

May 2018

Mileage

Not provided

Outcome flags

None reported

ABS/ESP/CECK ENGINE WARNING LIGHTS ALL CAME ON AT ONCE. MERCEDES DEALER DIAGNOSED PROBLEM AS LEFT REAR RPM SENSOR. MADE REPAIR. UNDERSTAND FROM OWNER FORUMS SENSOR FAILURE IS VERY COMMON ON THESE VEHICLES. ONLY HAD 22,700 MILES. MERCEDES NEEDS TO WORK ON IMPROVING THESE PARTS OR MAKE REPAIRS AT NO CHARGE. *TR

Reported

Jun 2020

Incident date

Jun 2020

Mileage

Not provided

Outcome flags

None reported

THE ROOF TOP AIR CONDITIONER SEAL HAS FAILED. DURING THE RAIN IT'S AN INDOOR SHOWER. THERE IS ALREADY A CLASS ACTION LAWSUIT OVER THIS ISSUE WITH MERCEDES. *TR

Reported

Jun 2020

Incident date

May 2020

Mileage

Not provided

Outcome flags

None reported

TL* THE CONTACT OWNS A 2016 MERCEDES-BENZ SPRINTER 3500. THE CONTACT STATED THAT WHILE THE RV WAS PARKED, THE CONTACT BECAME AWARE THAT THE DRIVER'S SIDE REAR TIRE WAS FLAT. THE CONTACT DROVE THE RV TO AN INDEPENDENT MECHANIC WHERE IT WAS DISCOVERED THAT THE WELDING ON THE BACK OF THE REAR DRIVER'S SIDE WHEEL HAD FRACTURED, WHICH PUNCTURED THE TIRE. THE CONTACT STATED THAT HE WAS CONCERNED THAT THE WELDING DEFECT ON THE OTHER WHEEL COULD LEAD TO OTHER TIRES BEING PUNCTURED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE WHEELS WERE NOT REPAIRED NOR REPLACED. THE FAILURE MILEAGE WAS 36,000.

Reported

Jun 2020

Incident date

May 2020

Mileage

Not provided

Outcome flags

None reported

THIS MB SPRINTER 3500 3.0 DIESEL IS THE CHASSIS FOR A 2018 THOR CHATEAU 24FS RV. 2018-07-06 - 8485 MILES: LEFT REAR SPEED SENSOR REPLACED. 2018-09-14 - 9488 MILES: RIGHT REAR SPEED SENSOR REPLACED. 2020-05-22 - 14127 MILES: LEFT REAR SPEED SENSOR REPLACED. IN ALL CASES THE TRACTION, SKID, AND ABS LIGHTS COME ON ALONG WITH THE CHECK ENGINE LIGHT INTERMITTENTLY. WHEN THIS OCCURS, THE TRANSMISSION CAN SHIFT MANY TIMES PER SEC WHEN TURNING A SHARP CORNER (AND CAUSE THE RV TO "BUCK"). ALSO THE TRANSMISSION CAN DROP OUT OF DRIVE MULTIPLE TIMES AND REV THE ENGINE RPMS AT HIGHWAY SPEEDS, ALSO CAUSING THE RV TO "BUCK". A STARTLED DRIVER MIGHT TRY TO TURN OFF THE ENGINE AT HIGHWAY SPEEDS AND LOCK THE STEERING WHEEL. MB SERVICE AGENT ON 5-22-2020 TOLD ME THAT THEY SEE THIS WITH RV'S "ALL THE TIME, BUT NEVER SEEM TO SEE IT WHEN THE SPRINTER IS JUST A VAN. UNCLEAR WHY THIS IS HAPPENING". THIS IS A SAFETY ISSUE THAT COULD CAUSE AN ACCIDENT!!! IT ALMOST DID FOR ME DRIVING 55 MPH ON I-515 IN GA NEAR WOODSTOCK AND OTHER TIMES. ALSO CAUSED ME TO HAVE THE RV TOWED TO THE MB DEALER IN ATLANTA FROM TYBEE ISLAND GA AT AN EXPENSE OF $600. AT MINIMUM, MB SHOULD UPDATE THEIR ESP COMPUTER TO SANITY CHECK THE DATE BEING GIVEN BY THE WHEEL SPEED SENSORS. IF THEY DON'T MAKE SENSE, THEN DISABLE ABS, TRACTION AND SKID, BUT DON'T START SHIFTING THE TRANSMISSION MULTIPLE TIMES PER SECOND, OR TAKE IT OUT OF GEAR AND REV THE ENGINE. *DT*JB*DT *DL

Reported

May 2020

Incident date

May 2020

Mileage

Not provided

Outcome flags

None reported

MERCEDES BENZ REFUSES FOR OVER A YEAR TO FIX MY AIRBAGS PASSENGER SEAT AIRBAG DEPLOYED WITH NO ACCIDENT. JUST DRIVING ABOUT 25 MILES AN HOUR IT EMPLOYED AT OF NOW NOWHERE BUT AIRBAG DIDN'T COME OUT

Reported

Dec 2019

Incident date

Dec 2019

Mileage

Not provided

Outcome flags

None reported

BEEN WAITING 11 MONTHS FOR PARTS FOR THE PASSENGER SIDE AIRBAG RECALL AND I STILL CAN'T GET A DATE AS TO WHEN THEY WILL BE ABLE TO CORRECT THE SITUATION.

Reported

Dec 2019

Incident date

Dec 2019

Mileage

Not provided

Outcome flags

None reported