2018 Hyundai Tucson

While driving my 2018 Hyundai Tucson Limited 1.6L Turbo with the 7-speed EcoShift dual clutch transmission (DCT), the vehicle has repeatedly failed to engage and hold gears, resulting in loss of motive power in traffic. Diagnostic scanning retrieved codes P074B (Unable to Engage Gear 3), P074B71 (Unable to Select 3rd Gear), P074B07 (Gear Dropped Out of 3rd Gear), P092177 (1st Gear System Referencing Failure), and P0921 (Gear Shift Forward Actuator Circuit Range/Performance). A Hyundai dealer diagnosed the failure as requiring transmission replacement at approximately 93,000 miles. This is the same 7-speed DCT and the same failure mode addressed by NHTSA Campaign 16V628000 (Hyundai Recall 149) and Hyundai Service Campaign T1B, which covered 2016–2017 Tucson vehicles but excluded the 2018 model year despite using the same transmission. Hyundai has acknowledged this defect in 2018 vehicles through TSB 21-AT-014H and TSB 22-AT-007H, which prescribe a TCU software update, but issued these as service bulletins rather than a recall, so owners were never notified. When I requested the TSB software update, the Hyundai dealer refused to perform it. This defect creates a serious safety hazard: the vehicle can drop out of gear or fail to accelerate without warning while in traffic, increasing the risk of a crash — the identical hazard NHTSA cited in granting recall 16V628000. I request that NHTSA review whether the existing recall scope should be expanded to include 2018 Tucson vehicles.

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Car shaking, oil is burning , and drive hard. Engine and, oil light is now appearing.

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

-Very high oil consumption. Going through a little over a quart very 900-1000 miles. Has a GDI turbo engine. -Transmission issues. Has a dual clutch transmission that slips.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

January 9, 2026, driver was on I25, when driver heard a loud thud and the RPMs kept rising but the vehicle would not accelerate. Was very dangerous and barely avoided a collision with other drivers on the road. Barely got it home and shut it off. Tried to drive again but would not get out of reverse. Car was towed to Hyundai dealership for inspection. EGO4 Check Engine Light Diagnostic. 120883. Transmission and rear coupler/differential replaced. Test driven and dealership said it drove as designed and shifted as designed. Cost $10,955.29.

Reported

Jun 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

On June 5, 2026, driver was on I25, when driver heard engine making a winding and weird noise. Vehicle immediately went from 60 mph to 40 mph. It was extremely dangerous and driver barely evaded a collusion with several other vehicles. A check oil and engine light came on. Towed back to same Hyundai dealership. They claim engine needs replaced and needs maintenance kit. Total cost $16,892.87. Note: prior to, in January 2026 the transmission and differential were replaced. Was told there were no other issues (same Hyundai dealership).

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

While idling at a standstill (in a drive-thru queue), my 2018 Hyundai Tucson suddenly experienced a severe engine overheat, causing the vehicle's air conditioning system to immediately blow hot air and shut down. The vehicle was brought directly to an authorized Hyundai dealership (Chapman Hyundai on [XXX]) for an emergency inspection.The dealership's certified technicians confirmed that the electric Engine Cooling Fan Assembly completely failed and subsequently caused the main Front Wiring Harness and Fuse Box to physically melt. The dealership documented this catastrophic electrical and thermal meltdown under Repair Order #XXX.This is a critical safety defect. A melted engine wiring harness poses an immediate and severe risk of an electrical short circuit, sudden vehicle stalling in live traffic, or a catastrophic under-hood engine fire. Because this component controls the primary cooling of the powertrain, its failure creates an extreme hazard to the vehicle occupants and surrounding traffic. Hyundai must investigate this component failure before it results in a thermal fire incident or an accident due to sudden power loss. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

This vehicle had a engine replaced by the dealership Nov 2024.Has not run the same since.Getting worse and seems like transmission issues.I was told The first and the 2nd owner which I'm the 2nd owner has a 5 year 100,000 mile warranty.It's been 4 years and since I've had the vehicle I've driven round off 60,OOO miles .The vehicle had $84,000 something miles on it when I got it.It's becoming very dangerous to drive around other cars giving out of power in the middle of streets and barely not going up hills or freeways and streets.

Reported

May 2026

Incident date

Nov 2024

Mileage

Not provided

Outcome flags

None reported

While operating the vehicle on the highway at speeds around 55 to 60 mph, without warning, the engine suffered a sudden, catastrophic internal mechanical engine failure that resulted in an immediate and complete loss of motive power, rendering the vehicle entirely undriveable. The vehicle was towed to an authorized Hyundai dealership for a formal tear-down and diagnosis. They Hyundai dealership technician formally diagnosed the issue as a catastrophic internal "pin failure" (Structural failure of an internal engine pin component). This component defect caused a total mechanical breakdown of the engine assembly. Hyundai Motor America has issued a corporate warranty denial for an engine replacement, despite the vehicle being covered under the Hyundai Engine II Class Action Settlement (which extends powertrain protections due to widespread internal engine manufacturing defects), A sudden, un-warned loss of engine power while driving poses a severe and immediate safety hazard to the driver, passengers and other motorists on the highway. Hyundai's refusal to remedy this known structural defect leaves a dangerous vehicle un-repaired. I am requesting an investigation into Hyundai's denial of coverage for structural engine component failures on the 2.0L Nu engine platform.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

UNKNOWN -A catalytic converter clogged after being installed - only 14 months following installation, causing rough and unsafe acceleration, inability to shift gears properly, and need to drive with hazards on. It is clear that there is an issue with the engine/exhaust and system in this vehicle. Additionally, the car needs oil added regularly and seems to be burning it, as indicated by low level.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The 2.0L engine catastrophically failed during normal highway driving, consistent with a thrown connecting rod. The vehicle suddenly lost power on a roadway with tractor-trailer traffic. The driver and a child passenger narrowly avoided being struck by a semi-truck before the vehicle could be brought to a safe stop. No prior warning lamps, no check engine light, no abnormal noises, and no indications of any kind preceded the failure. The failed engine is currently at a Hyundai dealership and is available for inspection. The dealer has confirmed catastrophic engine failure and submitted an engine replacement request to Hyundai Motor America. Hyundai Motor America declined the engine replacement request, citing incomplete status on Service Campaign 966 (Knock Sensor Detection System update for connecting rod bearing wear). The owner purchased the vehicle used and was never notified by Hyundai of Service Campaign 966. The owner also was never notified of NHTSA Recall 20V543000 (ABS module fire risk), which remains open and unrepaired on this vehicle, demonstrating a pattern of failed manufacturer notification to the current registered owner. This vehicle is a Class Vehicle in the Hyundai/Kia Theta II engine class action settlement (In re: Hyundai and Kia Engine Litigation), which extended powertrain coverage to a lifetime warranty for connecting rod bearing failure on 2018 Tucson vehicles equipped with the Theta II 2.0L engine. The failure mode experienced is precisely the defect this settlement and Campaign 966 were designed to address. Component that failed: engine, specifically connecting rod bearing/short block assembly. Component is available for inspection. Vehicle has approximately 71,000 miles. The failure created an immediate and severe risk of fatal collision involving a child passenger. Manufacturer has been contacted and has denied warranty coverage. NHTSA action is requested regarding both the engine defect denial pattern and the unrepaired ABS fire-ri

Reported

May 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

This complaint involves a catastrophic engine failure in a 2018 Hyundai Tucson that appears to be part of a broader pattern of similar failures reported by other owners. Prior to failure, the vehicle exhibited excessive oil consumption and progressive engine performance issues. These symptoms have been widely reported by other consumers with the same vehicle, suggesting a systemic defect rather than an isolated incident. The engine failed completely while the vehicle was being driven to a mechanic for evaluation. The vehicle experienced sudden loss of power and shut down in the middle of an active intersection, creating a significant safety hazard and risk of collision or fatality. Online consumer reports, forums, and complaints indicate that many 2018 Hyundai Tucson vehicles experience similar symptoms—specifically excessive oil consumption followed by engine failure. Despite this apparent pattern, no comprehensive recall or sufficient consumer warning has been issued. The manufacturer has refused to provide assistance, citing warranty limitations, which raises concerns that known defects are not being addressed and unsafe vehicles remain in operation. This issue presents a serious safety risk due to sudden and unexpected loss of engine power while driving. I am requesting that NHTSA evaluate this as a potential widespread defect and initiate a formal investigation that could lead to a recall to protect consumers

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Approximately one month ago I had a high pressure fuel pump installed in my 2018 Hyundai Tucson. While driving on the highway, about ten minutes from home, my car suddenly burst into flames. There were no warning lights in the cockpit. There was no smoke in the cabin. Another motorist flagged me down. I got out of the vehicle just in time for it to become fully engulfed in flame. It burned down on the highway. Police and fire responded. Insurance is investigating. If I was inside the vehicle, I would have certainly died.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

Fire

The transmission system failed. The vehicle had previously been serviced at a Hyundai dealership for a transmission-related issue and was returned to me as repaired; however, the problem persisted. Shortly after the repair, the transmission failed again, indicating that the issue was not properly resolved. The vehicle is currently available for inspection upon request. The failure occurred while I was actively driving, creating a serious safety risk due to the potential loss of power and reduced ability to safely control or maneuver the vehicle. At the time, my [XXX] child was in the car, placing both of us, as well as other drivers on the road, at risk. The issue was confirmed by the Hyundai dealership following the initial repair attempt. Despite being advised that the vehicle was repaired, the transmission failed again, and the dealership acknowledged that the transmission remains defective. The vehicle has been inspected by the Hyundai dealership’s service department but has not been evaluated by police or insurance representatives. There were no warning lights or messages prior to the failure. The transmission failed unexpectedly after the vehicle had already been serviced and returned as repaired. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The oil consumption issue has begun. At about 75k miles, my 2018 Hyundai Tucson 1.6L Turbo is burning oil at an insane rate. And there is no indicator of it occurring (no codes or anything on the dash) until it's too late. Hyundai is now WELL KNOWN, and aware, for this problem and it is a catastrophic safety issue because of the possibility of the engine seizing and disabling the vehicle. It isn't negligence on the consumers part either, especially when timely and consistent oil changes are being done. *NOTE* My vehicle has had the transmission (6 speed dual clutch) replaced at around 30k miles and is having the same issue again (at 75k miles). So first the transmission and now the engine!

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

I bought this car 6 months ago. I did not know it had a recall on the engine. The engine just died a week ago. I brought it to hyundai and the confirmed it was a recall and go ahold of corporate. Corporate is refusing to fix the recall because they said "I should have brought it in at the original recall in 2020." I did not own the car there and I was not aware of the recall at all. [XXX] is my husband he is the other owner of the car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

My specific Tucson is equipped with 1.6L Turbo and a 7 speed Dual-Clutch Transmission. I see there are recalls for the 2016 models equipped with the same transmissions, so I'm concerned as to why there hasn't been a recall for the newer models. My transmission was replaced by Hyundai when the car only had approximately 15,000 miles (give or take) and now at 73,000 miles, I'm experiencing the same issue again! The delayed engagement when accelerating from a stop has been stressful, to say the least. I hope this can be taken more seriously and investigated further. Just take a Tucson, like my version, through a Starbucks drive-through and you'll understand just how awful the shudder is. It gets so bad, I worry that the vehicle will shut off.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

I have experienced two near-fatal incidents involving a sudden, uncommanded loss of motive power while traveling at highway speeds (approx. 70 MPH). On February 11, 2026, the vehicle entered "Limp Home Mode" without warning, dropping speed to 60 MPH and 2000 RPM in heavy traffic. This caused an immediate and dangerous speed differential, nearly resulting in a high-speed rear-end collision. Simultaneously, the AC system disabled, indicating a severe engine protection event. Manufacturer Negligence: The vehicle was taken to Courtesy Hyundai of Tampa twice for this issue (Code P0087). They performed a "Knock Sensor" replacement and cleared data points, assuring me the vehicle was safe. The failure recurred immediately. I subsequently took the vehicle to Brandon Hyundai on February 13, 2026. Despite my reports of near-fatal highway failures, Brandon Hyundai was instructed by Hyundai Corporate to merely repeat the "Knock Sensor" replacement—a repair that had already failed to resolve the dangerous condition. Critical Safety Admission: On 02/23/2026, Brandon Hyundai Service Advisor Abel Gomez explicitly admitted that this repair is "not a fix, it is a temporary thing until it shows again," yet stated they must follow Corporate’s directive to release the car. Requested Action: Hyundai is knowingly releasing a vehicle with a recurring, life-threatening defect (P0087/Sudden Power Loss) by performing "band-aid" sensor swaps instead of addressing the high-pressure fuel system or internal engine failure. This practice is a direct violation of the Safety Act. I request an immediate investigation into Hyundai’s refusal to perform permanent repairs on GDI engines displaying these catastrophic failure codes.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

Hyundai Tucson has been jerking and shaking for over over 4 years now and either when taking to the dealership they reset the dual clutch and have replaced the same part twice in the dual clutch. This shaking has been happening since the car was bought brand new like a year after. The vehicle now will get stuck in gear and while driving will go down to 20 mph and get stuck in that speed. This is a serious safety issue. The dealer could replicate the shaking but not the gears being stuck. It has happened on more than one occasion and they just reset something but this continues to happen. There are no warning lights when the gears get stuck it just happens while driving and it has happened twice now in the last 3 weeks.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

I am writing this letter to formally document a series of catastrophic safety failures and gross negligence regarding my 2018 Hyundai Tucson. On two separate occasions, including as recently as Wednesday, February 11, 2026, I narrowly escaped a fatal high-speed collision because this vehicle entered "Engine Protection Mode" while traveling at highway speeds. Incident Timeline: Previous Service: I have visited Courtesy Hyundai of Tampa twice for engine-related symptoms and code P0087. They replaced the knock sensor and assured me the vehicle was safe. Safety Incident (Feb 11, 2026): While driving on the highway, the vehicle suddenly lost power, dropping to 60mph and 2000 RPM (Limp Mode) in heavy traffic. This sudden deceleration nearly caused a high-speed rear-end collision. Current Status: The vehicle is currently at Brandon Hyundai (as of Feb 13, 2026). I have been told a review will take 3-5 business days, leaving me without safe transportation or a loaner vehicle. Negligence and Liability: Courtesy Hyundai of Tampa was aware of the recurring P0087 code and engine performance issues. By clearing codes or replacing minor sensors (knock sensor) without addressing the underlying high-pressure fuel or internal engine failure, they released a dangerous, defective product onto the road. This vehicle is clearly covered under the Theta II GDI Engine Settlement and Service Campaign 966. The local dealerships are willfully avoiding a necessary engine replacement to save on internal costs, despite knowing the vehicle is prone to sudden failure. Demand for Action: Immediate Loaner Vehicle: I require a safe rental/loaner vehicle immediately, paid for by Hyundai, while my car is being inspected. Full Engine Replacement: I am demanding a full engine replacement as previously indicated by technicians should the light return. Expedited Review: I am extremely unsatisfied to be told again I have to wait "3-5 business days" for a safety-critical evaluation of a vehicle that has alre

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2018 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the vehicle lost automotive power. The vehicle was pulled over to the shoulder lane, engine oil was added, and the contact waited for several minutes for the vehicle to return to normal operation. There was no warning light illuminated. The vehicle was taken to be diagnosed; however, the dealer was unable to determine the cause of the failure. The dealer suggested that the contact occasionally add oil to the vehicle. The vehicle was not repaired. The contact stated that while the accelerator pedal was depressed, there was an abnormal sound coming from the engine compartment. The vehicle was taken back to the dealer, where it was diagnosed, and it was determined that the catalytic converter needed to be replaced. The vehicle was not repaired. The vehicle was taken to an independent mechanic, where it was diagnosed, and it was determined that the catalytic converter needed to be replaced and that an oil change was needed. The vehicle was repaired; however, the failure persisted. The manufacturer was not notified of the failure. The failure mileage was approximately 99,400.

Reported

Feb 2026

Incident date

Mar 2025

Mileage

Not provided

Outcome flags

None reported

My 2018 Hyundai Tucson experienced sudden catastrophic engine failure when a connecting rod threw while driving. The engine burned through its oil and the vehicle became inoperable. Hyundai denied warranty coverage for this engine failure because I had not completed the 2021 KSDS (Knock Sensor Detection System) recall. I was never notified of this recall. The KSDS recall is a software update intended to detect engine knock. It does not prevent mechanical engine failure. Denying warranty coverage due to a software update that I was unaware of raises safety concerns, as engine failure can occur suddenly while driving and creates risk of crash or injury. This appears related to known engine issues in Hyundai vehicles. I am concerned this is a broader safety defect affecting other consumers.

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

While driving on a public road, the vehicle experienced multiple simultaneous, dangerous malfunctions: Dashboard Warnings: All lights illuminated, including engine (flashing), ABS, traction control, airbag, TPMS, and parking brake, which stayed on though disengaged. Engine & Transmission: Tachometer fluctuated wildly in park; engine revved without accelerator input. Shifting to drive/reverse caused unexpected “kicks.” Vehicle sometimes failed to move when pressing gas, requiring engine restart. Driving Issues: Speedometer read 0 or jumped inconsistently. RPM continued erratically while maintaining speed without accelerator. Steering became extremely difficult. I immediately determined the vehicle was unsafe to drive and returned home with it, which was only a couple miles away. Follow-Up: Hyundai advised dealership diagnosis; they suggested a backup camera module will resolve the issues I experienced in entirety, but also in the same email stated that they could not guarantee it would resolve all of the issues I experienced. This is the second major engine/powertrain failure: first approximately ~70,000 miles (full engine replacement), current approximately ~95,000 miles (approximately ~25,000 miles post-replacement). Recurrence indicates a serious, unresolved safety defect. I am deeply concerned for passenger safety, including children. Other owners report similar issues; the attorney general’s office advised reporting to NHTSA. Summary of Safety Risks: sudden loss of control/power, erratic acceleration, dashboard failures, steering resistance, unpredictable handling, recurrence of major defect. I am submitting this report to NHTSA to request investigation of these recurring defects. I do have video documentation of all of this, as well as ALL written communication with Hyundai National Consumer Affairs and the dealership. I am having a hard time uploading them because of the file limits. Please let me know if any of this will be helpful to you.

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Purchased 9/5/25 at 76,280 and oil change light shown by 10/1/25 when i received an oil change at Valvoline and was told of my engine issues at 77,733 miles. Car then looked at by Elizabeth Auto Sales [XXX] and confirmed oil consumption at no fault of my own and metal shavings in oil. Car then towed to #1 Cochran Hyundai Monroeville [XXX] and looked at by Dale. Oil change and oil consumption test started and confirmed of burning more than 1 qt per 1k miles. 2/4/2026 engine test cleaning requested and denied. Car stalls at random times can possible cause an accident. yes the problem was produced to the dealership purchased from which was Kenny Ross Subaru Irwin pa 15642. Yes the problem was confirmed by Hyundai on 11/7/25. Only warning was the oil change light flashing which forced me to get an oil change less than a month of purchasing on 10/1/25 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Feb 2026

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

DRIVING ON FREEWAY NO WARNING LAMPS ON DASHBOARD. EXIT FREEWAY TO GET GAS AND THERE IS MINIMAL ENGINE PERFORMANCE AND CHECK ENGINE LIGHT ILLUMINATES. CYLINDERS ARE NOT FIRING, NO COMPRESSION. ENGINE FAILURE CONFIRMED BY HYUNDAI SERVICE DEPT AND INDEPENDENT MECHANIC.

Reported

Jan 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

My 2018 Hyundai Tucson experienced repeated no-start conditions. The vehicle was initially diagnosed by Randy Wise Hyundai in Flint, Michigan, and I paid approximately $776 for tune-up services that did not resolve the issue. Shortly afterward, the vehicle continued to fail to start. The dealership later determined the starter had failed and provided an estimate of approximately $985 for replacement. Hyundai Motor America denied goodwill assistance and reimbursement for the prior misdiagnosed repair and stated the starter replacement is customer-pay. The vehicle’s inability to start caused loss of reliable transportation and safety concerns due to being stranded. I am submitting this complaint to document starter failure and potential diagnostic issues affecting vehicle safety.

Reported

Jan 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

The situation I’m about to explain has happened twice—once in December 2025 and again on January 22, 2026. In December, the roads were very icy, but there was no snow on the ground. As I made a right turn into a Walmart parking lot, I heard a loud metal-breaking sound while turning. I immediately got out and looked underneath my 2018 Hyundai Tucson SEL but didn’t see anything unusual. After finishing my shopping, I started the SUV to pull out of the parking space. The car was trying to move, but the rear tires were not moving at all. A man waiting for my parking spot noticed this and told me one of the tires wasn’t turning. As I drove home, I heard extremely loud metal noises coming from the back of the vehicle—sounds like metal twisting, breaking, and falling to the ground. At no point did any warning lights come on. I took the car to a highly rated mechanic, Premier Car Care, where they did a thorough inspection and found nothing wrong. After being reassured that the vehicle was safe, I continued driving it. Then on January 22, 2026, the same issue happened again. I was driving to my internship, and the roads were slushy. Suddenly, the Tucson became unstable, slid unexpectedly, and I heard the same metal twisting and breaking noises. This time, the ABS light came on briefly and then went off. The vehicle felt unsafe and unstable, even though I was driving very slowly—around 15 miles per hour. I was terrified and nearly hit someone. I had the car towed through Triple A back to the mechanic, but once again, they were unable to find the cause after inspecting it, and it is sitting in my driveway. I am reaching out because I am on disability, I have three children with autism, and I am also currently in school. I rely on this vehicle, and I truly need help investigating what is happening so this issue can be properly identified and fixed before someone gets seriously hurt.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

The car began making a knocking sound on my 5.8 mile drive. On my drive home from work, the knocking was louder, and the car barely accelerated on the highway and over-revved trying to hit at least 50 mph to keep up with the flow of traffic. I took the car to the Hyundai Service Center immediately using city streets rather than the highway. I had a family member follow me to make sure I made it to the service center as well as give me a ride home after I dropped off the vehicle. As I was driving there, the car had a hard time accelerating from a stop and barely maintaining speed of the flow of traffic and the “Check Engine” light came on and flashed as I got closer to the dealer service center. The dealer service center confirmed that the engine needs to be replaced due to the connecting rod bearing failure, a common issue with the 2.0L I4 F DOHC 16 V engine in my 2018 Hyundai Tucson. The Hyundai Service Manager has repeatedly confirmed that the engine issues presented in my car are consistent with a recall for the same model engine found in my car.

Reported

Jan 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

There is oil that leaks on a couple spark plugs.....when I remove the plug there is oil on the plug cover and inside where the plug goes in.........disturbing.....can you help....supposed to be a recall but I don't know what to do.....I would like to get that straightened out..... I want to keep it .....also like to buy my wife a new one......can you help on this problem.... They were supposed to fix recall..... Hundai Uniontown Pa. Can you help.... [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jan 2026

Incident date

Feb 2025

Mileage

Not provided

Outcome flags

None reported

The engine and engine management system of my 2018 Hyundai Tucson experienced repeated failures resulting in loss of propulsion and unsafe drivability. In November 2025, while traveling approximately 75 mph on a freeway, the vehicle suddenly entered limp mode without any prior warning, causing an abrupt loss of power in active highway traffic. No warning lamps or messages appeared before the failure. After the loss of propulsion occurred, the check engine light, battery light, and oil light illuminated sequentially. Diagnostic trouble codes P1326 and P0326 were recorded. Initial inspection indicated severe oil consumption despite a recent oil change less than 2,000 miles earlier. A Hyundai dealership replaced knock sensors under warranty. Shortly after release (30 miles), the vehicle again exhibited severe drivability issues, including a flashing check engine light, and required immediate towing. A second Hyundai dealership replaced the short engine block under warranty. Approximately 180 miles after the engine replacement, the vehicle again developed unsafe drivability symptoms, including delayed throttle response, failure to accelerate unless the accelerator was fully depressed multiple times, jerking or lugging when slowing or stopped, and a faint whining noise. The check engine light illuminated again. These failures represent repeated loss of propulsion and unsafe operation following manufacturer-approved repairs, including full engine replacement. The vehicle has been out of service for approximately 57 days and remains in the custody of a Hyundai dealership awaiting diagnostics. The vehicle is available for inspection upon request. The sudden and unpredictable loss of power at highway speed created a significant risk of collision and serious injury to the driver and surrounding motorists.

Reported

Jan 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

The engine is burning excessive oil. Down 3 quarts over approx. 3,000 miles. Mechanic verified there are no leaks - it is burning the oil.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

High Oil Consumption

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

My 2018 Hyundai Tucson has been experiencing oil consumption issues for over a year. It began at around 80k miles, when it should have been covered by warranty but they made me pay out of pocket for an oil consumption test only to ultimately recommend a top end cleaning, which I also paid for and it did not solve the problem. This is a known issue with Hyundai, and they have settled many lawsuits but have consistently denied any repair or solution for me. I am burning about 5 quarts of oil every week, and this is a problem they refuse to help solve.

Reported

Dec 2025

Incident date

Nov 2024

Mileage

Not provided

Outcome flags

None reported

Oil consumption, will change oil and within weeks i will be down 23 Quarts of oil

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The engine on this vehicle burns oil quickly which is a known defect. I took the vehicle to the dealership and both times I was told everything was working fine. On 12/5/2025 the vehicle just lost power while driving. After getting the vehicle towed to a mechanic they said I needed a new engine.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

My 2018 Hyundai Tucson experienced complete engine failure at around 118,000 miles. The motor suddenly blew without warning. This vehicle uses an engine type known for widespread engine defects, including bearing wear and internal failure. I bought the vehicle used in 2023, maintained it regularly, and there were no warning lights or overheating before the failure. I had to put oil in my vehicle every week. I had to use 5qts of oil. It smelled like fumes coming through the vents. It then stalled on the highway while we had our son in the vehicle and shaked profusely. Mind you we had our son in the vehicle. How unsafe is that. I then did my research and found out Hyundai engines of this generation have a history of stalling, seizing, and internal damage. I am filing this complaint because this appears to be part of a known safety defect that can cause sudden loss of power while driving. We took it to shop and confirmed the motor blew. It was faulty. Also, sometimes the electrical components would turn off in vehicle such as radio and would go black. Also the turn signal would be on and then turn off. It would also shake while driving. This needs to be taken care of ASAP as it almost caused danger to my family and also caused financial strain on my family too as I now had to roll over my vehicle loan into a new safe vehicle. I would like to be contacted in regards to this. Thank you.

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

My car on the expressway wouldn't go over 40 and this was happening intermittently so my car was unsafe. No check engine light but it was just at the dealership for an oil change. Has. been an ongoing problem since I bought the car! Smells, gets hot!

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Excessive oil consumption (failed 3 tests) now adding two quarts a week.... Transmission shifting issues (already had a replacement at 65,000 miles. Hesitation with acceleration. AWD and can barely make it up my driveway. Rpms rev when trying to go slow. Already needed a moonroof replaced because the motor died. USB randomly disconnects and reconnects for GPS.

Reported

Nov 2025

Incident date

Mar 2024

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2018 Hyundai Tucson. The contact stated that while driving at various speeds, the vehicle almost stalled. The contact stated that the check engine warning light illuminated and was flashing off and on. The accelerator pedal was depressed; however, the vehicle failed to respond as needed. The contact pulled over to the side of the road, and the vehicle remained running. The contact waited for a while and then shifted to drive(D) and was unable to accelerate above 30 MPH. The contact stated that the failure was a recurring failure. The vehicle was taken to a Parts Store and was scanned, and DTC: P1326 was retrieved. The contact had not taken the vehicle to a dealer or to an independent mechanic. The vehicle was not diagnosed or repaired. The contact was no longer driving the vehicle. The manufacturer was not informed of the failure. The failure mileage was approximately 102,000.

Reported

Nov 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

Shortly after purchase, I had an oil change and vehicle inspection performed. I was informed that my engine may have an internal defect causing it to burn oil excessively. I later took the vehicle to a AAA-approved Hyundai service center, where they confirmed that the engine is burning oil due to a known manufacturer issue and that it is not the result of owner misuse or neglect. I have been quoted approximately $11,000 for a replacement engine, which is an extreme and unexpected cost for a recently purchased vehicle in otherwise good condition.

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

I purchased this car [XXX] as a CPO vehicle from a Ford dealership. By [XXX] the oil pressure light would flicker and it was clear the car was burning a lot of oil between changes. On 8/22 an oil change was completed at dealer. On [XXX] the oil pressure light flickered and it was three quarts down. An oil consumption test was started at 112,000. On Sat [XXX] while driving to dealer for oil check, the car began shuddering violently and the check engine light came on, and went into limp mode. I was on a dangerous mountain pass at the time and it could have been a major issue. The day before a tractor trailer had almost run me off the road, if my car had stalled then I might not be here. Hyundais have a known issue with oil burning and engine damage. Right now I am stuck in a 14K loan with a car that is unsafe to drive. I am not sure what the dealer plans to do, or what the diagnosis is, but its clear these engines are not safe. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

My 2018 Hyundai Tucson SEL PLUS limited showed a flashing check engine light on 10/14/2025 and basically gave up acerating pass 60mph while I was driving , I pulled over and called the dealership where I bought it from they told me to drive it in, I did and they did an oil change and filled up, we then began the oil consumption test which I brought it back yesterday 10/24/2025 and was told the whole engine needed to be replaced due to a major oil consumption problem, they advised me to bring it the Hyundai dealership to get it fixed they rudely told me no we can't fix this, we would have to wait for it to flash the check engine light again and it would have to fail a bearings test before it can be fixed and still have a possibly of it not fixing. only confirmed by the lot I bought it from since Hyundai refused to look at it.

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

The contact's sister owns a 2018 Hyundai Tucson. The contact stated that while his sister was driving at an undisclosed speed, the vehicle briefly jerked and jolted, prompting her to pull over to the shoulder of the roadway to turn off the vehicle. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed failures with all four fuel injectors and the injector assembly. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the independent mechanic, who then diagnosed a failure with the catalytic converter. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 78,563.

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

My 2018 Hyundai Tucson 1.6 Turbo (VIN [XXX] , 113,000 miles) burns oil excessively and was deemed to need full engine and turbo replacement ($15,382.95). Hyundai refuses responsibility (case #XXX). This is a widespread defect that causes potential loss of power while driving. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

2018 Hyundai Tucson has excessive oil consumption. Burns multiple quarts of oil per 1000 miles. Hyundai refuses to remedy the oil consumption. Oil consumption has also led to having to replace the catalytic converter due to oil burn off.

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

On October 13th 2025, we were involved in a serious collision while driving our 2018 Hyundai Tucson. The vehicle was struck from behind and spun into a semi-truck, totalling the vehicle. Despite the forward and lateral collision to the semi-truck, no airbags deployed at all during the accident. This resulted in the Tucson driver striking his head on the steering wheel. Our 5-month old son was also on-board the vehicle in his car seat. While everyone walked away from the accident, both adults passengers had whiplash/minor neck injuries that could have been mitigated by airbags deploying. We have serious safety concerns about Hyundai's airbags because of this incident.

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

Crash

I am filing a complaint under the NC Unfair and Deceptive Trade Practices Act (N.C. Gen. Stat. § 75-1.1) regarding Hyundai’s handling of my 2018 Hyundai Tucson (purchased new May 2018). Since 2019, the vehicle has had repeated headlight failures (at least 12 bulb replacements), persistent “bulb out” warnings, and eventually melted wiring requiring headlamp assembly replacement in 2025. These issues were first reported in April 2023 under warranty but dismissed as “could not duplicate.” Hyundai later attempted to deny coverage, only replacing the assembly after escalation to Corporate. At the April 2023 visit, I also reported a rear noise that Hyundai dismissed. After warranty expiration, it was attributed to a leaking shock. Shocks were covered under warranty; failure to act while coverage was active left me unprotected. In May 2023, the engine failed due to oil loss and lock-up. Hyundai retained my vehicle from 5/15–6/30/23 for engine replacement. From Aug–Sep 2025, the car was held an additional 24 days, with no permanent fix for the electrical defect. Overall, my Tucson has been out of service for 60+ days between 2023–2025. Examples of unfair/deceptive conduct: Dismissing documented defects under warranty, only acknowledging later after expiration. Attempting to shift labor costs onto me in Jan 2025 despite warranty obligations. Returning my vehicle with only ~39 miles of gas after requiring me to return a loaner full. Repeated misdiagnoses and delays despite video and documentation provided. These actions are deceptive and unfair, leaving me with an unsafe, unreliable vehicle and causing financial loss and hardship to my work as a self-employed pet sitter and dog groomer. I request the Attorney General investigate Hyundai’s conduct and enforce consumer protections under UDTPA. Service records, receipts, and communications are available upon request.

Reported

Oct 2025

Incident date

Apr 2025

Mileage

Not provided

Outcome flags

None reported

Van Hyundai Dealership in Carrollton, TX has confirmed excessive oil consumption causing catalytic converter failure that results in the engine stalling and unable to accelerate. We’ve already replaced the catalytic converter once in 2024 because it was full of oil and causing engine failure. Less than a year later (less than 10,500 miles) the same problem was reproduced. The dealership refuses to replace our engine due to the engine defect. This problem directly impacts the engines ability to perform, unable to accelerate on the interstate, and engine stalling which directly impacts our safety and puts our family into a life threatening situation when the engine fails on the highway. The engine has a defect that Hyundai refuses to address. There are no warnings or engine lights that appear beforehand which is extremely concerning and a liability. Hyundai motor company is corrupt. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Sep 2025

Incident date

Apr 2024

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2018 Hyundai Tucson. The contact stated that while driving at 60 MPH, the vehicle lost automotive power, with the check engine warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed, and the contact was advised that there were metal shavings found on the camshaft sensor. The contact was advised that the camshaft sensor, oil flow solenoid, and variable tee valve were faulty and needed to be replaced. The vehicle was repaired; however, the failure reoccurred 3 months later. The contact stated that while driving 60 MPH, the vehicle failed to accelerate as needed, with the check engine and oil light illuminated. The vehicle was taken to a local dealer, where the vehicle was diagnosed, and the contact was informed that the engine was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 56,942.

Reported

Sep 2025

Incident date

Apr 2025

Mileage

Not provided

Outcome flags

None reported

Over the past nine months, I’ve been experiencing ongoing issues with my 2018 Hyundai Tucson engine and transmission. After four consumption tests and a flush confirming that the engine is burning between 0.8 and 0.3 liters of oil for every 1,000, I was informed Hyundai refuses to either repair the issue or conduct testing to determine the cause. The timeline is summarized below: •February 2025 – I was told by [XXX] my vehicle simply did not have enough oil after the last oil change; •March 2025 – I was informed an initial consumption test needed to be completed; •May 2025 – a second consumption test revealed the engine was burning more than 1 liter per 1000 and a flush was completed; •July 2025 – a third consumption test was completed, revealing that while the engine was excessively burning oil, it was not currently at 1 liter per 1000 based on that test; August 2025 – the oil light came on & I was instructed to put a liter of oil into my vehicle to make it to the certified dealer for next steps. The next steps were another consumption test. Unfortunately, because I was told to add oil to make it to the dealership, I was then informed that this added oil would alter the testing, and we had to start over. •September 2025 – I am now awaiting the results of the fourth consumption test. I have receipts for every 6 months or 7,500 of service since purchasing the vehicle., Despite the engine and transmission being under warranty, the dealership has refused to conduct testing to determine the cause of the issue or remedy the excessive consumption. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Sep 2025

Incident date

Mar 2025

Mileage

Not provided

Outcome flags

None reported

I took my car in for a daily oil change and inspection, where I learned that there was no oil is in my car after coming in 5k miles before as I have been religious about oil changes. I came in on Saturday September 20th for an inspection and was topped off with 3 quarts of oil but am now back in the shop Monday September 22nd to test the oil. The oil that was checked came out Black.

Reported

Sep 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

Hyundai Motor America (Hyundai) recalled certain 2019-2021 Tucson vehicles on September 4, 2020. On December 30, 2020, Hyundai expanded the recall population, and added certain 2016-2018 Tucson vehicles. The Anti-lock Brake Hydraulic Electronic Control Unit (HECU) could corrode internally and cause an electrical short, possibly resulting in an engine compartment fire.

Risk: An engine compartment fire can increase the risk of injury or crash.

Remedy: Hyundai will notify owners, and dealers will replace the HECU fuse. For 2019-2021 model years, the Electronic Stability Control (ESC) software will also be updated. Recall repairs will be performed free of charge. Owners are advised to park outside and away from structures as a precaution until the recall repair is complete. The recall began November 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 195.