2016 Hyundai Tucson

The engine is failing at 128,000 miles. The car is burning so much oil that it is impossible to drive more than 500 miles without the oil running dry. The problem has been inspected by the Hyundai dealership nearest me. The vehicle notified me of the oil issue by illuminating the oil light. The issue started after the turbo failed at 127,000 miles. The turbo was replaced at a cost $3,500 and immediately afterwards the vehicle which previously did not burn oil now does. It doesn't just burn oil it consumes it like a black hole.

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

While driving, the vehicle experienced a sudden and severe loss of motive power accompanied by a loud, catastrophic internal knocking sound from the engine compartment. The vehicle was towed to an authorized Hyundai dealership (Piazza Hyundai of Limerick), where a certified diagnostic technician confirmed a severe internal connecting rod bearing failure (rod knock). This sudden engine failure creates a significant highway safety hazard due to the immediate loss of acceleration and power steering/brake assistance if the engine completely seizes while operational. Hyundai has issued widespread safety recalls and a 15-year/150,000-mile extended warranty (TXXM) for this exact failure mode in other engine displacements (such as the 2.0L Nu GDI), yet they have excluded the 1.6L Turbo engine from identical coverage despite it suffering from the exact same manufacturing defect and presenting the same public safety risk.

Reported

Jul 2026

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

All the door locks and actuators/latches are failing. Hyundai claims there is no recall for it, and the price for one door repair is $1384... This is a safety issue since the passenger in the rear seat could not get out in an emergency!

Reported

Jun 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Hyundai Tucson. The contact stated that while the vehicle was parked, the front passenger’s side door failed to unlatch as needed. The front passenger's side window failed to roll up or roll down. The driver's side rear door failed to unlatch or latch as needed. Additionally, the trunk switch failed to operate as needed. The dealer was made aware of the failures but provided no assistance. The contact was informed that the repairs were not covered under recall or warranty. The contact stated that the vehicle was unsafe to operate. The contact feared being locked inside the vehicle and being unable to exit the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 52,000.

Reported

Jun 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Hyundai Tucson. While the contact’s daughter was driving approximately 55 MPH, the vehicle started to lose motive power. The vehicle failed to restart immediately. The vehicle was started after a while; however, the check engine warning light was illuminated. The vehicle was taken to a Goodyear Service Center to be diagnosed. The contact was informed that the engine had seized and needed to be repaired. The dealer was contacted. The manufacturer was not made aware of the failure. The failure mileage was approximately 119,479.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Within the last month, the passenger side front door will no longer open from the outside even if the door is unlocked. The driver must lean over to open the passenger door from the inside. Then approximately one week ago, the passenger rear door began to have issues in that it would not open from the outside nor would it open from the inside. This is a known safety issue which puts passengers at risk. A Technical Service Bulletin 21-bd-006h extends the warranty coverage to 10 years/unlimited mileage, however my 2016 Hyundai Tuscon is six (6) months outside of this window. The local Hyundai dealership will not fix under this door latch warranty extension and quoted a cost of $885.00 to remove and replace both latches. I currently have a case opened with Hyundai USA Customer Affairs and am waiting to see if Hyundai will cover the cost of repairs and fix the two door latches. If they do not, I will consider legal remedies.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The vehicle severely shudders, jerks, and hesitates from a stop and while making a turn, during both acceleration and deceleration, making it entirely unsafe to drive. The vehicle has been completely un-driveable for the past 6 days. The check engine light illuminated, and on 4/9/26, the dealer documented a failed transmission judder test and kept the car, issuing a loaner. A temporary software patch failed after two weeks. Upon return, the dealer reported they were unable to recreate the problem, recommended returning when the vehicle demonstrates the problem more frequently, and refused to mechanically repair the dual-clutch transmission under my active original-owner 100,000-mile powertrain warranty, basically instructing me to continue to drive a seriously un-safe vehicle. Most recently, a yellow dashboard warning light illuminated, and the vehicle entered a dangerous 'limp mode,' severely restricting power and struggling to move before the light cleared after cooling down. The vehicle is completely un-driveable and parked.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Oil consumption engine ticking hesitate to change gears poor acceleration.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Hyundai Tucson. The contact stated while driving 50 MPH, the vehicle failed to accelerate as intended and stalled. There was no warning light illuminated. The contact was able to pull over to the side of the road, where the contact restarted the vehicle. The contact drove to his workplace and parted the vehicle. However, the vehicle later failed to start. The vehicle was towed to the dealer it was purchased from, and the contact was informed that the engine had failed. The vehicle was not repaired. The vehicle was then towed to Affordable Towing and Repair, where it was diagnosed that the engine had failed and needed to be replaced. The manufacturer was not contacted. The vehicle was towed to 125,000.

Reported

Jun 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Driver door does not open from the outside. Rear passenger door does not open at all.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Transmission previously replaced after failed Judder test. Transmission is failing again: Last few days the car will accelerate to 15 then it attempts to shift and power drops and pressing the pedal has no response or very little then it changes into what feels like 4th or 5th gear at 20 mph and acceleration is very sluggish and also switching into manual gear control is completely unresponsive. Power drop at 15 mph, the transmission jumping into what feels like 4th or 5th gear at 20 mph, and sluggish acceleration — is consistent with the clutch pack slipping and the TCM essentially giving up on lower gears and defaulting to a higher gear to protect itself. Manual mode being completely unresponsive is a significant red flag — it means the TCM may have entered a limp or failsafe mode where it’s overriding driver input entirely.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The power window motor and regulator on the drivers side failed to roll up the window. It was raining and made it stessful driving home . The window was stuck down and the rain was soaking the inside of the car. Very distracting while driving.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

delayed response when accelerating from a stop

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Oil drains very fast even with regular oil changes and maintenance. The vehicle began shaking and then completely stopped with very little warning. Check engine light flashed for under 60 seconds then vehicle would not move forward on the highway creating a major safety hazard. Engine smelled hot and like burning rubber.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the check engine warning light was illuminated and there was an abnormal sound coming from the engine compartment. The vehicle was taken to a dealer where it was diagnosed that the vehicle needed an oil consumption cleaning. The vehicle was repaired however, the failure persisted. The manufacturer was not notified of the failure. The failure mileage was unknown.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The engine in this 2016 Hyundai Tucson has experienced progressive failure symptoms consistent with the known rod bearing defect covered under Hyundai's engine warranty extension campaign. Symptoms include: excessive oil consumption requiring frequent top-offs over several months, severely degraded acceleration, failure to upshift under load, and an audible metallic crunching noise occurring around 4,000 RPM. A knock sensor fault code (P1326) was previously triggered (on 2/16/26), confirmed by a mechanic (on 2/17/26), and cleared. The dealer was visited (on 2/17/26) and refused to perform the campaign repair, stating no active code was present at that time. The vehicle is available for inspection. The problem has not been confirmed by the dealer despite a visit; the dealer declined to act citing absence of an active code. The vehicle has not been inspected by police or insurance. Warning symptoms include the prior knock sensor code, oil consumption, loss of power, and the current mechanical noise. Symptoms first appeared several months ago and have progressively worsened. The dealer's refusal to act under the existing campaign despite documented symptoms has left this vehicle in a dangerous condition on public roads.

Reported

May 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

Both rear doors actuators will not allow to open from inside or outside, the passenger will open from inside and the driver door intermittently is the same and I have to juggle the handle or smack above the handle to get it to open on driver side. The passenger is only opening from inside and have to smack above the handle or put pressure to door to have the actuator release....both rear doors do not open at all. This is a safety egress issue. I have minor children and they cannot get out of the vehicle and if an emergency, the first responders cannot get into it.

Reported

Apr 2026

Incident date

Apr 2025

Mileage

Not provided

Outcome flags

None reported

I have had 3 window motors go out in the last 7 months.

Reported

Apr 2026

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

Took vehicle to dealership and had it diagnosed for the electrical system faults cause all the dashboard warning lights came on. Shop said it could be bad vacuum pump.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Driver side door lock actuator failure yesterday. 4/10/26 Purchased this car 8/15/25 was not told there was a problem and recall

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Three power window regulators have failed on my 2016 Hyundai Tucson within a six-month period. The front driver and front passenger windows both failed first and required replacement. The rear driver-side window has now also failed and is currently stuck in the open position. When the failures occur, the window will move up slightly but then drop back down or will not stay closed, indicating a failure of the regulator mechanism rather than normal wear. The fact that multiple window regulators have failed in a short period suggests a defect or premature failure of this component. This creates a safety concern because one window is stuck open, exposing the vehicle interior to weather, reducing security, and potentially affecting driver visibility and safe operation. This appears to be a known issue with this model year, but my vehicle is not included in any recall.

Reported

Apr 2026

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the engine compartment. Moments later, the vehicle stalled after driving a very short distance. An independent mechanic arrived at the residence to perform an oil change and found metal shavings inside the oil. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 94,000.

Reported

Mar 2026

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

All dash warning lights are on and dash lights have a intermittent bright light surge. Hard to shut off engine and have to disconnect battery for electric power to shut off. Very noticeable hesitation in acceleration starting to drive

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Hyundai Tucson. The contact stated that while attempting to buckle the driver's side seat belt, the seat belt failed to buckle securely, and the seat belt failed to retract as designed. The contact had not attempted to pull on the seat belt and the seat belt was unable to buckle securely. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The local dealer was contacted dealer and referred the contact to the NHTSA Hotline for assistance. The manufacturer was not informed of the failure. The failure mileage was 78,361.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Hyundai Tucson Sport 2016 GDI engine. I am the original owner of this truck I have taken care of this truck so much it being my first brand new purchase. No oil leaks NOTHING! When I first purchased the vehicle I noticed that it would stall when I would accelerate but did not think too much of it since it was brand new. A few years passed started to notice frequent oil changes were supposed to be made. Another few years turbocharger went out had to get it replaced. The engine consumes so much oil at first I thought it was because the turbocharger was out so when I got it fixed I thought that would fix that issue and it didn’t. I got an oil change March 2, 2026 and on March 21, 2026 I was on the highway and the truck started to shake really bad I exited the highway went straight to the oil place they said I had no oil on the dipstick I got ANOTHER oil change (expensive) and when I turned on the car to leave the car shook again and the engine light was flickering on and off and finally stayed on the dash board. Barely made it home. Got a tow truck to tow it to Hyundai dealership they told me they will not see it unless I pay the diagnostic fee of $200 and even then they think it’s the engine with everything I described to them. They said since there are no recalls on the Tucson that Hyundai will not do anything for me I would have to pay out of pocket for everything. Had to pay the tow truck again to tow it to my house ($250). My car has all the symptoms all the other cars have that they have recalled. This is a huge safety issue because i drive on the highway a lot and everyone knows a car with no oil is extremely dangerous.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

I had ANOTHER door latch lock assembly fail on my 2016 Hyundai Tucson. There was a TSB for this issue that the dealership said expired for my vehicle three months ago. They wanted a $200 diagnostic fee for a total repair of close to $1000. They confirmed it was another door latch lock assembly, although I’m not sure how because the door would not open from the inside OR the outside. When the rear passenger side assembly failed a week ago, my kids were stuck in the back of the vehicle. This is a potentially dangerous issue that Hyundai seems to be aware of. If the front driver’s side goes at the wrong time, and I am not able to open my door, it could have disastrous consequences. I could become trapped in my car in the event of an accident, fire, etc. Hyundai needs to recall all door latch assemblies and just replace them all free of charge. It’s ridiculous that it’s a guessing game of when they might stop functioning properly and potentially trap you inside the vehicle.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

I am writing regarding the diagnosis provided for my vehicle [XXX] . I was informed today that the engine failure is being attributed to a "water hose failure" rather than the engine defects covered under the active safety recall/settlement regarding Connecting Rod Bearing failure. As there were no coolant leaks before or after the vehicle was towed to your dealership. I am formally requesting a re-evaluation and more detailed evidence. Given the known history of these engines seizing, I need to ensure this diagnosis is absolutely correct and not a symptom of the internal defect. I request the following information be provided immediately: 1. Evidence of Overheating: Did the vehicle store any specific "overheating" codes in the ECU prior to the engine shutting off? 2. Oil Pan Inspection: Has the oil pan been removed to inspect for metal shavings or debris? If the connecting rod bearings failed (the recall issue), there will likely be metallic debris in the oil, regardless of the condition of the water hose. 3. Bearing Clearance Test (BCT): Was the mandated Bearing Clearance Test performed? If not, I request that this be done, or that a teardown be performed to inspect the rod bearings specifically. 4. Causal Link: Can you provide evidence that the water hose failed causing the engine to seize, rather than the engine seizing causing a pressure spike that damaged the cooling system? I have no transportation to work and school. They would not honor a loaner. This has happened since Decemeber of 2025. I await your written response with the requested photos and technical data. My case # with Hyundai Consumer Affairs # XXX Please provide: All relevant photographs Freeze-frame and ECU data Technician diagnostic notes Results of oil pan inspection and/or BCT (if performed) Any physical evidence supporting the stated cause of failure I request this information be sent in writing at your earliest convenience. Thank you for your attention to INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Mar 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Vehicle: 2016 Hyundai Tucson Issue Category: Engine / Powertrain / Vehicle Safety Complaint: I am reporting a serious safety issue involving my 2016 Hyundai Tucson equipped with a Theta II engine. My vehicle first displayed an engine oil warning light. I immediately took the vehicle to an authorized Hyundai dealership, where I was charged approximately $500 for an oil change and diagnostic testing. I was told there were no issues with the vehicle. Within approximately 20 miles of leaving the dealership, the vehicle suddenly entered limp mode while driving and displayed diagnostic code P1326. This created a dangerous situation as the vehicle lost power unexpectedly. I returned the vehicle to the dealership, where a software update was performed. However, within another 20–30 miles, the exact same issue occurred again, with the vehicle entering limp mode and triggering code P1326. Hyundai has now refused to repair the engine under warranty and is attempting to attribute the issue to a catalytic converter problem, despite the presence of code P1326, which is associated with engine rod bearing failure and is part of a known defect affecting these vehicles. This condition presents a significant safety risk, as the vehicle can lose power suddenly while driving, increasing the risk of a crash. I believe this issue is directly related to the known Hyundai Theta II engine defect, which has been the subject of recalls and a class action settlement. I am requesting that NHTSA investigate Hyundai’s handling of these failures and their refusal to repair vehicles experiencing known engine defects that pose a safety risk

Reported

Mar 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Three window regulators have failed, leaving the windows completely useless. The first occurring in heavy rain and making it impossible to close. This is an issue reported countless times online.

Reported

Mar 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

The transmission began slipping and hesitating within days of purchase. The vehicle intermittently fails to accelerate when pressing the gas pedal, especially when pulling into traffic or crossing intersections. This creates a serious safety risk because the vehicle does not respond when needed, leaving me exposed to oncoming traffic. The issue is intermittent and does not always trigger warning lamps or fault codes. The problem has been reproduced multiple times by me while driving under normal conditions. The selling dealer performed only a brief test drive and stated they could not duplicate the issue, but the hesitation and failure‑to‑accelerate continue to occur. The vehicle has not yet been inspected by Hyundai, but the symptoms match known issues with the 2016 Tucson’s dual‑clutch transmission and TCM logic. There were no warning lights prior to the failure, and the symptoms first appeared within the first week of ownership. The vehicle is available for inspection upon request.

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

"On [XXX], my 2016 Hyundai Tucson (VIN [XXX] ) experienced severe engine power loss and mechanical noise under load while driving uphill, creating a dangerous safety situation. This occurred 2 days after a dealer visit (February 19, 2026) where an open KSDS Service Campaign (TSB HCE22-14-E600-TL, Issue 10D021) — directly related to engine monitoring — was left incomplete. The dealer subsequently denied an engine evaluation citing mileage over 150,000, despite the open campaign having no mileage restriction and despite a prior verbal commitment to cover repairs. Multiple follow-up attempts by phone, email, and WhatsApp have been ignored." INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

No check engine lights came on! The entire car caught fire and was engulfed in flames!!! Driver could have been killed!

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

Fire

My car had a KSDS knock sensor detection system campaign 966 installed in 2022 specifically to active if having rod bearing wear. Towed my car to Hyundai under the TXXM warranty and they said my bearing clearance was ok and i need new lifters and timing chain cost for repair $2900. I have asked for the full rod bearing wear test report and they will not provide it. They have had my vehicle for 20 days now and I am out of work on disability. Hyundai service center is generally expected to provide you with a report following a rod bearing wear test (often referred to as a Bearing Clearance Test or by a related service campaign, such as T6G or TSB 21-EM-004H). Here is what you can expect regarding reports and documentation: Documentation of Results: The dealership should provide a copy of the results, specifically noting if the bearing clearance passes or fails. Proof of Inspection: If the test is performed under a recall or Service Campaign (e.g., Campaign 966, 982, or T6G), they are required to document the inspection, which you can request for your records. Evidence of Damage: If the test results in a failed diagnosis, technicians often take photos of the engine internals, such as metal flakes in the oil pan or excessive wear, which are used to support the warranty claim. If the Test Passes: If your vehicle passes, ask the technician to print a copy of the results. If the Test Fails: A formal diagnosis of rod bearing failure, confirmed by this test, is required for engine replacement under the extended 15-year/150,000-mile warranty. Hyundai - Recalls +3 This is a safety issue without the full rod bearing report to consumer. Thank you for upstanding, [XXX] cell - [XXX] email - [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

Excessive oil consumption caused engine failure on December 17, 2025. My truck stopped and I was stranded on Highway I55 South for 4 hours. Hyundai and the Extended warranty has denied fixing my truck. It is still at [XXX] Hyundai as of today. Hyundai’s failure to properly diagnose or repair this issue when it was first reported under warranty has caused financial burden, diminished vehicle value, loss of use and inconvenience, and emotional distress and stress. This is a legitimate safety concern. I am demanding resolution of an ongoing excessive oil consumption defect in my 2016 Hyundai vehicle. This defect began while the vehicle was under warranty and has continued despite proper maintenance and compliance with Hyundai’s service requirements. I expect Hyundai to honor its legal and contractual obligations without further delay. Please contact [XXX] [XXX] Hyundai) @ [XXX] for details regarding repairs, oil consumption tests, etc. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Feb 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The engine, specifically cylinder # 3, has had a catastrophic failure at 114,000 miles. Engine repair shops and engine experts have determined the only fix is a complete engine replacement. Cost estimates are $8500 for a new engine + labor estimated at $2000. Scrap value is estimated at $1000 - $1500 The dealer from whom we bought the car in late 2015 said it is out of warranty. This is unacceptable. Please, please issue a recall on the engine of this vehicle. The vehicle is available for inspection if requested. Failure was catastrophic Problem has been confirmed by engine experts The car is not drivable to a manufacturing facility The engine has not been inspected by police nor our insurance company There we no warning lamps or messages Symptoms include shuddering at initial acceleration beginning at 75,000 miles Dealer said there was no problem and recommended and performed a transmission fluid change

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Window regulator and motor have failed due to plastic gears stripping out. I have replaced my two front windows in 2024 at $1063 a window. This week I had both rear windows fail allowing the windows to drop down unexpectedly. I was able to manually pull the windows up and tape them. I was supposed to receive a call from Hyundai twice this week about getting these covered under a recall since all four has failed, but they have failed to contact me.

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Hyundai Tucson. The contact stated that the check engine warning light was illuminated, and there was a ticking sound coming from the front of the vehicle. The vehicle was taken to Auto Zone, where a mechanic diagnosed the vehicle with a knock sensor failure. The knock sensor was replaced. The mechanic informed the contact that the vehicle was included in Manufacturer Campaign: CS966 for the transmission control module (TCM). The vehicle was taken to the dealer, who confirmed that the vehicle was included and the software update was performed. After the vehicle was repaired, the check engine warning light was no longer illuminated; however, approximately 30 minutes later, the vehicle failed to exceed 35 MPH, and the check engine warning light started flashing. The vehicle was returned to the dealer, and the contact was informed that the software update caused the vehicle to enter LIMP Mode to protect the engine. The dealer informed the contact to drive the vehicle for 30 days or a total of 500 -1000 miles, and if the vehicle continued to enter LIMP Mode or failed to operate as needed, to return the vehicle for the engine to be replaced. There were no additional repairs performed. The manufacturer was not informed of the failure. The failure mileage was approximately 125,000.

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

I have diligently maintained the vehicle with all scheduled services performed at the Rick Case Hyundai dealership. My maintenance records show a documented history of proper oil changes and other essential services. These records confirm that the vehicle was regularly serviced according to the manufacturer's recommendations. The diagnostic report from the dealership indicates bad piston and heat marks, but there is no evidence to suggest this was caused by a lack of proper maintenance.

Reported

Jan 2026

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

I am filing this complaint regarding my 2016 Hyundai Tucson due to excessive oil consumption. The vehicle burns oil at an abnormal rate, requiring me to add approximately one quart of engine oil every one to two weeks, even though the vehicle is driven very infrequently. This condition poses a serious safety risk because the engine could run low or completely out of oil while the vehicle is in operation, potentially causing sudden engine failure. This vehicle is used to transport my family, including children, which puts their safety at risk. I have taken the vehicle to Hyundai dealerships multiple times for full ispection , but no defect, warning, or solution was ever identified or communicated to me. There have been no warning lights or messages on the dashboard to alert me of low oil levels or engine problems, increasing the risk of failure without warning. The problem is ongoing and repeatable, and the vehicle and engine are available for inspection upon request.

Reported

Jan 2026

Incident date

Dec 2023

Mileage

Not provided

Outcome flags

None reported

The car has been diagnosed with internal engine failure by both an independent service center and a dealership service center. The issue was described as a rod timing issue causing knocking, leading to failure of the engine. A light was not on for a majority of the issue but did start flashing before car became completely undrivable. The car was sold to me with this issue and has been driven for nearly 3 years with a power loss issue that was dismissed as turbo lag or other issues. Driving a car with this issue that does not alert with a check engine light is a major threat to driver and passenger safety as it can result in engine seizure and vehicle fires. The engine issues began at the least before 58,000 miles, with total failure occuring at roughly 96,000 miles. Hyundai is known for this issue, particularly in turbo model engines. Only once during ownership of the car did the check engine light come on prior to engine failure. When checked, it was described as a catalytic converter issue. The service center also did an oil change on the car, and the light went off. The check engine light did not come on again for more than a year. The check engine light did not come on until after the issue was diagnosed by the independent service center it was taken to in January 2026.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

There is a major problem with certain year Hyundai vehicles from 2016-2021 with the engine burning oil and clogging up the exhaust. My moms vehicle has been at dealership for evaluation and combustion cleaning multiple times and the problem still continues. There has been times where she is driving car and it starts to bog down and loose power which is a safety issue especially if on highway. The vehicle is burning oil, occasionally have to add oil. The engine light does come on at times. The car has been at dealership for recommended oil consumption test at every 1000 miles and has not passed. Combustion cleaning done each time and sent on way. Called and made complaint with Hyundai corporate and and got no where. The tech department at Hyundai factory gave dealership recommendations to do which were completed and still having same issue. The factory was only willing to cover 70% off the cost of new catalytic convertor and my mom to be responsible for remaining balance. Hyundai claimed that the convertor was out of warranty 8 years/80,000 miles even though this has been going on for past 2 years. This is not a problem caused by consumer but an issue with factory. Hyundai not living up to there 10 year/100,000 mile warranty as they advertise. There are facebook groups with people having same problems as we are with dealership not really doing anything other than combustion cleaning as advised by factory and corporate not doing anything either. I believe this is a major safety/defect issue with engines in these Hyundai Vehicles . What happens when someone is on the highway and the vehicle bogs down and another vehicle comes from behind and slams into you?

Reported

Jan 2026

Incident date

Apr 2022

Mileage

Not provided

Outcome flags

None reported

On my husband's way home from work he explained to me that the car had a "hiccup" and then an engine light blinked on, then it died at an intersection. He was pretty close to home so he got it started again and drove it home. He replaced spark plugs and coil packs and it still had a misfire. We took it to an auto repair shop where they did a scan and told us it had a dead hole in cylinder 2 and that it needs a full engine replacement. The car also had an oil change just before Thanksgiving. My husband checks oil regularly and added a quart a month before the oil change and it seems to consume more oil then it should.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Numerous issues with this vehicle. Now, when having oil change, told by the hyundai service center that it is using excessive oil and may need a new engine. In researching this problem, have discovered hyundai has had several problems with excessive oil consumption in their many of their hyundai vehicles, including the 2016 Tuscan

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

My 2016 Hyundai Tucson experienced engine failure consistent with known Hyundai engine defects. After reporting multiple battery outages, rapid oil consumption, and limited acceleration ability, outstanding warranties were checked and updated. However, the issues persisted, and the engine failed suddenly while I was driving. Hyundai denied warranty coverage without proof of the issues being unrelated to the warranty. This presents a serious safety hazard due to unexpected engine failure.

Reported

Jan 2026

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Hyundai Tucson. The contact stated that after coming to a complete stop, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The vehicle went into LIMP Mode. In addition, the vehicle failed to accelerate above 30 MPH. No warning light was illuminated. The vehicle was taken to several dealers. The contact was informed that the unknown hoses and the dipstick melted inside due to the engine overheating. The contact stated that the catalytic converter was replaced; however, the failure persisted. The contact stated that the catalytic converter had been replaced three times since the first failure. The contact stated that on a separate occasion, the engine was consuming an excessive amount of engine oil. The contact was adding engine oil every two weeks. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The failure was a recurring failure, and the contact drove the vehicle intermittently due to the safety concerns. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.

Reported

Jan 2026

Incident date

Jan 2023

Mileage

Not provided

Outcome flags

None reported

While driving under normal conditions, my engine experienced a sudden and catastrophic failure. The check-engine light illuminated, the vehicle began shaking violently, and I was forced to pull over immediately due to safety concerns. There was no prior warning and no oil pressure or oil warning light activated at any time before or during the failure. After stopping safely, I checked the oil level and found it lower than expected. I added oil as a precaution, but the condition did not improve and the vehicle became inoperable and required towing. The engine assembly remains intact and available for inspection upon request. This failure posed a serious safety risk, as the loss of engine function occurred without warning while the vehicle was in motion, creating the risk of stalling or loss of control. The vehicle was inspected by an authorized Hyundai dealership. Hyundai Motor America denied warranty and goodwill assistance, citing mileage and alleged insufficient maintenance documentation, despite the vehicle being within the 10-year powertrain period and despite the nature of the failure. Routine maintenance was performed throughout ownership; however, some historical service records are unavailable due to the age of the vehicle and changes in service locations over time. Multiple facilities no longer retain records from that period. Notably, no oil warning indicators never activated, which raises concern regarding the failure mechanism. Hyundai has acknowledged widespread engine issues in this engine family involving oil consumption, bearing failure, and sudden engine seizure. The symptoms and progression of this failure closely align with those known defect patterns. This complaint is submitted to document a sudden engine failure presenting a clear safety concern and to assist in identifying potential defect trends. This car has undergone previous engine repair, AC condenser and entire turbo by their service department previously 2022 & 2024 respectively.

Reported

Jan 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Car died/lost power while driving in traffic 11/28/25. Good Samaritan was kind enough to push me off the road out of traffic. Car was towed to Hyundai dealer that day, then 12/1 told engine failure, required engine replacement. Class action lawsuit settlement for engine replacement, but denied by Hyundai because of "neglect", since I am not able to locate all of the service records that they request. Known faulty rotating assembly, and Hyundai has implemented concerted practice of denying warranty coverage for failed engine. Now having to pay almost $8K to replace with new engine, but concern that new engine will have same issue. (multiple posts about this). There was high potential for significant traffic collision, injury due to sudden, catastrophic engine failure. Traumatic experience.

Reported

Jan 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

While driving on the highway at normal speed, the vehicle suddenly lost power and shut off without warning. There were no warning lights or messages prior to the loss of power. I was able to safely pull over, but the engine would not restart at that time and the vehicle required towing. The sudden engine shutdown occurred in active traffic and created a safety risk due to loss of propulsion. The vehicle later restarted, but I brought it to an authorized Hyundai dealership for inspection. The dealership diagnosed internal engine damage, including piston ring failure and cylinder wall scoring, and advised that the engine would need to be replaced. Since the incident, the vehicle has shown intermittent oil pressure warning lights and reduced performance. The issue has been confirmed by a dealer inspection. The vehicle is currently not considered reliable or safe for regular driving.

Reported

Dec 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

Drove into a parking space, with the foot pressing on the brake pedal, the car suddenly and without warning rapidly accelerated uncontrolled causing the vehicle to accelerate past the end of the parking space causing property damage.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

Crash

My motor has a knocking/tapping noise that is obnoxiously loud. My oil level is always changed on time every 3k miles. I have 146,257 miles on my vehicle. I was informed from my mechanic shop that many of the 1.6L motors have issues. I have never had an engine noise then boom its knocking. I was informed not to drive my car to further damage the vehicle. I do not drive it but now am stuck in a loan for a vehicle I cannot drive. I had zero warning for this matter.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Hyundai Motor America (Hyundai) recalled certain 2019-2021 Tucson vehicles on September 4, 2020. On December 30, 2020, Hyundai expanded the recall population, and added certain 2016-2018 Tucson vehicles. The Anti-lock Brake Hydraulic Electronic Control Unit (HECU) could corrode internally and cause an electrical short, possibly resulting in an engine compartment fire.

Risk: An engine compartment fire can increase the risk of injury or crash.

Remedy: Hyundai will notify owners, and dealers will replace the HECU fuse. For 2019-2021 model years, the Electronic Stability Control (ESC) software will also be updated. Recall repairs will be performed free of charge. Owners are advised to park outside and away from structures as a precaution until the recall repair is complete. The recall began November 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 195.

Hyundai Motor America (Hyundai) is recalling certain model year 2016 Hyundai Tucson vehicles manufactured May 26, 2015 to January 15, 2016 and equipped with an accessory trailer hitch harness either included with the accessory trailer hitch or sold as a service part. In the affected vehicles, when the vehicle's engine is running and the brake lights are illuminated, if the turn signal is activated, the trailer turn signal lights will either turn off or remain continuously illuminated (not flash). As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard Number 108, " Lamps, Reflective Devices, and Associated Equipment."

Risk: Failure to illuminate the trailer's turn signal lights would prevent the communication of the driver's intent, increasing the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will update the tow hitch harness, free of charge. The recall began on May 2, 2016. Owners may contact Hyundai customer service at 1-855-371-9640. Hyundai's number for this recall is 142.

Hyundai Motor Company (Hyundai) is recalling certain model year 2016 Tucson vehicles manufactured May 19, 2015 to March 14, 2016. In the affected vehicles, if the primary hood latch has been released, and the vehicle is driven, the secondary hood latch may not hold adequately secure the hood to prevent it from opening while the vehicle is in motion.

Risk: If the primary hood latch is inadvertently released and the secondary latch cannot secure the hood, the hood may unexpectedly open while driving, increasing the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the secondary hood latch, free of charge. The recall began on June 30, 2016. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 145.

Hyundai Motor Company (Hyundai) is recalling certain model year 2016 Tucson vehicles manufactured May 20, 2015 through May 31, 2016 and equipped with a 7-speed EcoShift Dual Clutch Transmission. Certain driving conditions and high temperatures may cause the vehicle to not move if the accelerator pedal is pressed and released repeatedly.

Risk: Inability to move the vehicle while in traffic may increase the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will update the Transmission Control Module software, free of charge. The recall is expected to begin on October 28, 2016. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 149.

Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."

Risk: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.