2017 Hyundai Tucson

The Core Symptoms: "The high-pressure fuel pump is leaking internally. Raw gasoline is flooding into the engine oil crankcase, causing severe fuel dilution. The engine air filter is physically soaked in raw fuel and smells strongly of gasoline." My engine is always extremely hot after I have only went 15 mins away from home. Sometimes takes over two hours to cool down. The Safety Risk: "When attempting to accelerate, the vehicle experiences severe fuel starvation, causing the engine to bog down and act like it is going to stall in the middle of traffic, creating a severe crash hazard. Additionally, there is a loud 'popping' sound/mini-backfire upon turning the vehicle off due to unburnt fuel vapors, presenting a high risk of an underhood engine fire. I have only 83,000 miles on my car.

Reported

Jul 2026

Incident date

May 2021

Mileage

Not provided

Outcome flags

None reported

Subject: Formal Safety Complaint Regarding Steering Failure – 2017 Hyundai Tucson To Whom It May Concern, I am submitting this complaint to request that the National Highway Traffic Safety Administration (NHTSA) investigate a potentially serious safety defect involving the Motor-Driven Power Steering (MDPS) system in my 2017 Hyundai Tucson. I am the second owner of this vehicle. The vehicle currently has approximately 61,000 miles and remains within Hyundai's 10-Year/100,000-Mile Powertrain Warranty period applicable to subsequent owners. Approximately two years ago, the vehicle's engine was replaced under a Hyundai safety recall. Recently, I began experiencing intermittent steering problems in which the steering wheel becomes extremely difficult to turn and appears to momentarily jam or lock while driving. This condition significantly affects vehicle control and creates a serious safety hazard, particularly during turns, lane changes, or emergency maneuvers. I brought the vehicle to Advantage Hyundai in [XXX] for diagnosis. The dealership determined that the vehicle had a Motor Position Sensor Error (Diagnostic Trouble Code C2401) within the Motor-Driven Power Steering (MDPS) system. The dealership informed me that the repair is not covered under the vehicle's warranty and declined to repair it. The dealer also submitted a request to Hyundai for goodwill assistance (Prior Authorization No. XXX), but Hyundai denied that request. I subsequently contacted Hyundai National Consumer Affairs (Case No. XXX) seeking assistance. Unfortunately, Hyundai also denied my request despite the relatively low mileage and the serious safety implications of the steering malfunction. My concern extends beyond the cost of repair. A malfunction in the electronic power steering system that causes steering to bind, jam, or become difficult to control presents a significant risk of a crash, injury, or loss of life. Steering is one of the most critical safety INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, an abnormal knocking sound was heard coming from under the hood, and the RPMs independently increased. The "Check Engine Oil" warning light illuminated. The contact managed to pull over to the shoulder of the road, and the vehicle was towed to a local Midas shop, where it was diagnosed with total engine failure.The vehicle was towed to a local dealer, who discovered metal shavings in the engine oil pan during diagnosis. The vehicle was not repaired due to the high cost. Upon further investigation, the contact associated the failure with an unknown NHTSA Campaign number. The manufacturer was made aware of the failure. The failure mileage was approximately 62,000.

Reported

Jul 2026

Incident date

Jul 2024

Mileage

Not provided

Outcome flags

None reported

#1. This vehicle uses a lot of oil !!! It burns through it like crazy I have to check the oil every other day. #2. When I come to a stop while driving and give it gas to take off IT WONT GO !!!!! It hesitates and when it does go it LUNGES FORWARD!! This is a huge manufacturer problem not a buyer problem. The engine is junk.! 3. I’ve called numerous places to get help. This car needs to be recalled. This is a huge safety violation. It doesn’t wanna go when you give it gas and when it does, it lunges forward that can cause a huge accident on the highways. This car was made in China. It is junk. I’ve called to get help with this issue and no one wants to help. Nobody returns my calls and I’ll Hyundai wants to do is it even more money out of me when this isn’t my fault the car is junk. For safety concerns I would like someone to call me at [XXX]. This car needs to be recalled and my daughter has one. It’s doing the same thing except hers is a lot worse. Hers is further advance where it’s actually stalling in the middle of the road while driving huge safety violation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jun 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

I am filing a safety complaint regarding my Hyundai vehicle after experiencing a sudden engine failure that appears consistent with known rod bearing and engine defects affecting certain Hyundai engines. While driving, my vehicle began making a knocking noise and shortly thereafter suffered catastrophic engine failure. The engine lost power and became inoperable, requiring the vehicle to be towed. This failure occurred without any prior indication that the engine was about to fail. My concern is that this type of engine failure creates a significant safety hazard because it can occur unexpectedly while driving, potentially causing a loss of power in traffic and increasing the risk of a crash. The dealership inspected the vehicle and engine but did not report excessive sludge buildup. I have provided available maintenance records showing that oil changes were performed during my ownership. Despite this, there appears to be disagreement regarding the cause of the failure. I am aware of reports involving rod bearing and engine failures in similar Hyundai vehicles and believe NHTSA should investigate whether this failure is related to a broader manufacturing or design defect. The cost of replacing the engine is substantial, and consumers may be placed at risk if these failures occur while vehicles are being operated on public roads. I am requesting that NHTSA review this issue and determine whether additional investigation, recalls, or other corrective actions are warranted. Vehicle Information: Year: 2017 Make: Hyundai Model: Tucson Mileage at Failure: Approximately 72,000 miles Date of Failure: [XXX] VIN: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

While traveling on the highway the car began to lose speed rapidly until coming to a complete stop, no warning lights were present prior.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Hyundai Tucson. The contact stated that while driving at undisclosed speeds, the vehicle was consuming an excessive amount of engine oil. The contact stated that oil was frequently added to the engine. The vehicle became inoperable. The vehicle was towed to a dealer, where it was diagnosed and determined that the catalytic converter needed to be replaced. The catalytic converter was replaced; however, the failure persisted. The vehicle was returned to the dealer for inspection, and the catalytic converter was replaced a second time. The vehicle was repaired; however, the failure persisted. No additional repairs were performed. The manufacturer was notified of the failure. The approximate failure mileage was 86,000.

Reported

Jun 2026

Incident date

Jun 2023

Mileage

Not provided

Outcome flags

None reported

Catastrophic engine failures AT 57k miles while driving, resulted in engine replacment under recall warranty. Timing chain replacement done at 93K miles. Second Engine failure while driving at 107K. Hyundai refuses to fix the engine.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

2017 Hyundai Tucson | VIN: [XXX] | Mileage: 75,000 I have owned this vehicle for approximately five years and have experienced severe excessive oil consumption for the past two to three years. The issue was first discovered when the vehicle entered protective mode due to critically low oil levels despite a routine oil change having been performed only a few months prior. I am currently required to add approximately one quart of oil every month to maintain safe operating levels. I visited an authorized Hyundai dealership to have an oil consumption test performed. The dealership informed me that if the test confirmed excessive consumption, I would be required to pay out of pocket for an engine replacement. I declined, as Hyundai Motor America has publicly acknowledged this exact defect in the 2017 Tucson through NHTSA Recall 21V727000, multiple Technical Service Bulletins, and a class action settlement covering 2014-2021 Tucson vehicles with the Nu 2.0-liter GDI engine. My VIN was found ineligible on the class action settlement website despite the acknowledged defect. Hyundai has admitted this engine suffers from premature bearing wear, excessive oil consumption, and risk of engine failure and fire. I am requesting NHTSA investigate why my VIN falls outside current recall coverage despite presenting identical symptoms to affected vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Catalytic converter has now failed twice with only 105,000 miles

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The engine (connecting rod bearings in the 2.0L Nu GDI engine) failed. The vehicle entered limp mode with DTC P1326, then died on the road and the engine seized completely (will not turn by hand when attempted; only clicks on starter). It is currently at First Hyundai dealer in [XXX], under Repair Order #XXXand available for inspection. The vehicle suddenly lost power and died while driving on the road. This created a significant risk of an accident or being stranded in traffic. I was on a busy highway and almost got hit twice. There is also a known fire risk associated with this exact defect (oil leaking onto hot engine components), as stated in Recall 209 (NHTSA 21V727). The vehicle was towed to First Hyundai. They have documented the no-start/seized condition on Repair Order #XXX. A prior independent scanner reading showed P1326 before the code was cleared. The dealer has not performed the full diagnostic inspection (scheduled around June 11). Hyundai Corporate (Claim #XXX) has been notified but has not responded after multiple escalation emails. The vehicle first went into limp mode ("Engine Protection Mode") with DTC P1326 on the scanner. Shortly after, the engine died completely and would not restart. This occurred after Recall 209 (bearing/KSDS campaign) was completed on XXX. Additional Details: This is a known issue with premature connecting rod bearing wear. The dealer is refusing to provide a loaner/rental upon drop-off, which contradicts TSB 22-01-023H (Dealer Best Practices for P1326 vehicles). The vehicle has been inoperable since 6/4 ..with no resolution. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Left rear passenger door latch failure to open either from inside or outside. This is a mechanical failure of the cables operating the latch. A passenger could not easily exit the vehicle in an emergency situation, also there is no way short of breaking the glass to easily access or if necessary extricate the passenger in an emergency situation. As evidenced from online searches and forums this failure is all too common and has been addressed with a narrow set of vehicles with an extended warranty applied to this failure. This is an issue of safety. There needs to be a recall to upgrade affected vehicles and their door mechanisms.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

I am submitting a complaint regarding a 2017 Hyundai Tucson Ultimate AWD equipped with the 1.6L Turbo Gamma GDI engine. My vehicle currently has approximately 127,000 miles and has experienced sudden engine knocking consistent with rod bearing failure and/or catastrophic internal engine damage. The vehicle has been properly maintained, including regular oil changes. However, the engine began consuming excessive oil without warning. Upon inspection by an independent repair facility, the engine was found to have extremely low oil levels despite being within the normal oil change interval. After refilling the oil, the engine continued making severe knocking noises, and the repair facility advised that the engine is likely non-repairable and requires replacement. This failure appears materially similar to the rod bearing and engine failure issues already widely documented in Hyundai/Kia engine defect investigations and class action settlements involving related Gamma and GDI engine platforms. I have learned that Hyundai extended warranties for certain vehicles with similar engine defects up to 15 years/150,000 miles; however, my specific Tucson trim/engine configuration does not appear included despite experiencing the same type of failure. This vehicle has also previously required major drivetrain repairs under warranty, including two transmission replacements and turbocharger replacement. My concern is both financial and safety-related. A sudden engine failure or seizure while driving could create a serious roadway hazard and risk of loss of power in traffic. Additionally, Hyundai dealerships have advised that replacement engines for this vehicle are no longer readily available. I believe Hyundai should further investigate whether the 2017 Tucson 1.6T Gamma GDI engine should be included in existing engine defect warranty extensions and/or recalls.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The vehicle has experienced life-threatening safety defects during operation; shaking, hesitation, and stalling in high-speed traffic. The vehicle unexpectedly stalled/lost power while driving, putting myself and others in direct risk of collision. The Hyundai dealership claimed it needed an Actuator Gasket replacement, Throttle Body replacement, and ECM/TCM update. The vehicle had NO warning lights until after it stalled, then warning lights illuminated briefly. The Hyundai dealership claimed repairs were "completed" 5/8/26; within 72 hours of "completion" the vehicle's symptoms reappeared. The Hyundai Executive Case Manager has made NO efforts to resolve this LIFE-THREATENING SAFETY issue. This has put myself and children in danger and is legally unsafe to drive.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

My 2017 Hyundai Tucson is experiencing dangerous, sudden engine stalling, which are symptoms directly matching Service Campaign T1B. These critical safety issues surfaced following a total engine replacement in June 2025. Despite the vehicle being within the 12-month/12,000 mile workmanship warranty, the dealership is refusing to honor this coverage or offer goodwill assistance. My claim is based on a documented pattern of physical and technical negligence: - Failure to Update Software: The dealership failed to perform the mandatory ECM/TCM software integration (Campaign T1B) during engine swap, which is required to prevent the exact stalling I am now experiencing. - Dismissal of Warning Lights (Code P0456): One day after the engine replacement was “completed,” I returned to the dealership because the Check Engine Light illuminated with Code P0456. This was dismissed by the service provider without a proper diagnostic resolution, despite being a direct indicator of improper vacuum line reconnection during the engine installation. - Mechanical Negligence (Coolant Leak): Post-engine swap, the vehicle developed a coolant leak, which was a direct result of improper reassembly. Additional proof of the lack of due diligence during the repair. The lack of follow-through, combined with the dismissal of a life-safety defect and poor physical workmanship, suggests a total failure in the case management process. I am urgently requesting assistance to resolve this hazardous situation.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The panoramic sunroof glass suddenly shattered while the vehicle was being driven on the interstate, with no visible impact, object strike, or prior damage observed. The component involved is the sunroof glass panel, and it has already been removed and replaced through insurance repairs, so it is not available for inspection (however, pictures are available upon request). The incident created a loud, explosion-like sound and resulted in glass fragments falling into the interior of the vehicle, including onto the driver and the front-seat passenger, causing minor injuries. This also created a significant safety risk due to driver distraction, panic, and the potential for more serious injury while the vehicle was in motion at highway speeds. The issue has not been reproduced or independently duplicated by a dealer or service center; however, it was inspected and documented by the insurance company and repair facility during the claims and repair process, which confirmed that full glass replacement was necessary. The vehicle or component has been inspected by insurance representatives and a repair shop, but it has not been inspected by the manufacturer or law enforcement. There were no warning lamps, dashboard messages, or any prior symptoms indicating a problem before the failure occurred, and the sunroof appeared to fail suddenly and without any advance indication while the vehicle was in motion.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

2 injuries

The vehicle has a difficult time turning over when cranking, the RPMs are sticking and the car periodically shuts off at red lights. Several warning lights pop up when it won't crank and then other warnings when the car just completely shuts off at red lights. I drive the interstate in [XXX] daily for work, so with the engine stalling my safety is at risk every time I drive it. Likewise when it won't crank, my safety is at risk. I had two Hyundai recalls updated in my car in 2022, Hyundai Recall 209 which was a connecting rod bearing test and my car passed so they installed the other Hyundai Recall 966 which was software update for the knock sensor detection system to alert the driver of future issues. Those issues are now current. The software is detecting a critical failure which is why the car is shutting off - entering limp mode, or the engine is failing. On April 9th through the 11th, 2026 my vehicle was inspected by a Hyundai dealership, where a technician identified a developing engine concern and advised me to continue driving the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

My Hundai Tuscon 2017 was making a whurring sound on the highway, at which time my RPM's were not going over 3. As I was looking for places to pull over on the highway, I heard a loud 'pop' and then my engine started smoking and an intense rattling ensued to where I could hear a series of parts drop out of the bottom of my car. My car began smoking and the engine completely stalled just in time for me to make it to the side of the road. I took it to a local shop for repairs and they showed me three holes in my engine.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Hyundai Tucson. The contact stated that after the vehicle was taken to the dealer for a recall repair, there was a burning odor coming from the vehicle, with white smoke from the tailpipe. Additionally, the check engine warning light was illuminated. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 50,000.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Knocking noise in motor and metal flakes in the oil. Called local dealership. They report no recalls for this issue.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the engine made a ticking sound. No warning light was illuminated. The vehicle was taken to the dealer and was repaired under NHTSA Campaign Numbers: 20V543000 (Service Brakes, Hydraulic) and 21V727000 (Engine); however, the failure occurred after the recall repairs were performed. The contact stated that while driving at an undisclosed speed, the vehicle stalled and failed to accelerate above 40 MPH. Additionally, while depressing the accelerator pedal, there was an extremely loud ticking sound coming from the engine. The check engine warning light was illuminated. The vehicle was taken back to the dealer; however, the vehicle was not yet diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 67,700.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Hyundai Tucson. The contact stated that the vehicle was consuming an excessive amount of engine oil. There was an abnormal knocking sound coming from the vehicle. There was no warning light illuminated. Due to the failure, the vehicle was towed to a dealer, and the excessive oil consumption was confirmed. The contact was informed that the vehicle was included in NHTSA Campaign Number: 21V727000 (Engine), and the engine was replaced. The vehicle was repaired, and a family member retrieved the vehicle and drove it to the residence without failure. Several days later, the family member started the vehicle, and fuel started pouring out from underneath the vehicle. Due to the failure, the vehicle was towed back to the dealer and was diagnosed the vehicle with an O-ring failure inside the fuel injectors. The dealer repaired the O-ring, and the contact picked up the vehicle from the dealer. Soon after retrieving the vehicle, fuel started pouring out from under the vehicle at start-up. The vehicle was towed back to the dealer and remained with the dealer. The manufacturer was notified of the failure, and a claim was filed. The vehicle was not repaired. The failure mileage was approximately 68,000.

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

the door latches are no longer opening the doors from the inside of the vehicle. This started with the passenger rear and now is effecting the drivers door. The only way to get out of the vehicle is to crawl over the seat to get to a door that is still operational. No warnings, just doesn't open when you pull on the handle. Will be making an appointment with a local dealer/service dept but given the security concerns this is being reported here as well.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Hyundai Tucson. The contact stated that while starting the vehicle and driving at an undisclosed speed, there was an abnormally loud grumbling sound coming from the engine. There was no warning light illuminated. The contact stated that the vehicle unexpectedly entered LIMP Mode. There was no warning light illuminated. The vehicle was towed to the dealer but was not diagnosed or repaired. The manufacturer was made aware of the failure and informed the contact that documentation of previous oil changes was required. The contact stated that the manufacturer accused the contact of a lack of maintenance, which was associated with the engine failure. The failure mileage was approximately 98,000.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

To Whom It May Concern, I am writing to formally escalate an unresolved safety issue involving my 2017 Hyundai Tucson (VIN: [XXX] ) that has now been ongoing for over two years. I have made repeated attempts to complete a safety recall repair through multiple authorized Hyundai dealerships, including Hyundai of [XXX] and Hyundai in [XXX] . Despite scheduling several appointments, I have consistently been turned away, had appointments effectively canceled, or been told that no one is available to perform the repair. This has occurred across more than one location and over an extended period of time. This is unacceptable. A federally mandated safety recall especially one involving the engine is not optional and must be completed within a reasonable timeframe. The continued failure to complete this repair places me at risk and reflects a serious breakdown in both dealership accountability and corporate oversight. Additionally, my vehicle has experienced significant paint chipping. While I understand this may not be a safety recall issue, it has affected the overall condition and value of my vehicle. Given the prolonged delay and inconvenience I have experienced, I am requesting that this concern also be reviewed for potential goodwill repair or coverage. At this point, I am requesting immediate action: Assignment of a case manager A confirmed and honored appointment date for recall repair at a dealership that is able to complete the work Written confirmation that the repair will be completed without further delay Information regarding a loaner vehicle or transportation if the repair requires extended time Please note that I am filing a formal complaint with the Illinois Attorney General’s Office due to the repeated failure to complete a federally required safety recall. If this matter is not resolved promptly, I will pursue additional consumer protection and legal remedies. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Mar 2026

Incident date

Jan 2017

Mileage

Not provided

Outcome flags

None reported

My ABS has been sticking and finally the pad broke off. my car made a squealing noise everytime I drove it. I had parked in my driveway and there was a piece of metal on the ground. I showed it to my son, he took the tire off and said it held my ABS Brake pad on to my Driver side rear. He is a master tech for Subaru. I just haven't had time to take it into Hyundai. It has stopped squealing, but my ABS brakes no longer work.

Reported

Mar 2026

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

About every 500 miles I have to add about a quart of oil. I brought my car to McDaniels Subaru for maintenance on my car. My son is a master tech there and I know he is very thorough. My contract lets me go there also. So he checked the dipstick and it was below a quart of oil. He did change the oil change. I cannot drive a long distance without carry a large container of oil. He has warned me not to let it get low again or the engine will seize. This car gets all its regular Maintenance on time. I have a contract to do this. The dealership had all the maintenance records at the time I purchased it. It has been very well maintained.

Reported

Mar 2026

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

On my 2017 Hyundai Tucson, my steering wheel light is illuminated. I took it to the dealership and they said I need a new steering wheel collar. My Hyundai has about 98,000 miles.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

On March 10, 2026, my 2017 Hyundai Tucson entered 'Limp Home Mode' while driving, a known safety defect that causes a sudden loss of engine power. Diagnostic testing confirmed error code P1326 (Knock Sensor Detection System - KSDS). Despite this vehicle being covered under the Theta II Engine Class Action Settlement (Recall 209), which provides a 15-year/150,000-mile extended warranty for this specific issue, the dealership (Jim Ellis Hyundai of Atlanta) is refusing to perform the warrantied repair. Instead, the dealership has provided an estimate (#XXX) attempting to charge me $816.22 for the knock sensor replacement. They are also withholding the full GDS diagnostic scan reports and freeze frame data despite multiple written requests. Furthermore, the dealership is threatening to charge daily storage fees while actively denying a mandated safety repair. This refusal to honor the settlement warranty leaves the vehicle in an unsafe, unrepaired condition. This vehicle is a subject of the In re: Hyundai and Kia Engine Litigation II settlement. The refusal of the dealership to perform the KSDS-related repair (P1326}) is a direct violation of the court-approved settlement terms and a failure to address a documented safety defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

This car has major oil consumption that affects the engine and catalytic converter. This can cause engine damage and stalls in driving that affect safety on the roads because the car doesn't accelerate properly. There were no warning signals to indicate this being a problem with the car, especially at purchase. This car will get an oil change and in less than a week, the oil is gone and bone dry.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

While driving my vehicle, the engine RPM suddenly revved very high, and the vehicle hesitated to accelerate. A warning messaged appeared stating "Transmission too hot stop safely." I was driving up a hill when this happened. I pulled over and turned the vehicle off for about two minutes. When I restarted the vehicle, the warning message disappeared even though the vehicle would not realistically have cooled down that quickly. The issue concerns me because it could create a dangerous situation in traffic if the vehicle loses power or hesitates to accelerate when pulling into traffic or climbing a hill. The problem has occurred without warning and does not leave and persistent warning lights afterwards. I am very scared to drive this car, especially when I have my child with me. If I need to move out of the way and someone is driving that is not paying attention, there will be an accident because of the hesitation and the non-movement when I accelerate. I am reporting this issue in case it is related to a defect with the transmission system in this vehicle.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The contact's wife owns a 2017 Hyundai Tucson. The contact stated that the engine was consuming an excessive amount of engine oil. During frequent oil checks, the oil on the dipstick was low soon after an oil change. The vehicle was taken to the dealer approximately 15 times for oil consumption issues. Several oil consumption tests were performed on the vehicle for every 1,000 miles driven; however, the results varied from normal to low oil consumption. The engine had been partially disassembled twice, and pictures were taken and sent to the manufacturer. The manufacturer approved a combustion chamber cleaning to be performed on the vehicle; however, the failure persisted. The contact had spoken with the manufacturer several times and was provided a case number. The manufacturer ultimately denied the request for an engine replacement. The vehicle was not repaired. The failure mileage was 63,547.

Reported

Mar 2026

Incident date

Aug 2024

Mileage

Not provided

Outcome flags

None reported

While driving on the interstate at highway speed, my 2017 Hyundai Tucson lost power without any warning lights or prior symptoms. The vehicle experienced an immediate loss of propulsion while I was traveling in traffic, creating a dangerous situation because surrounding vehicles were also moving at highway speed & I had to quicky maneuver the vehicle to the shoulder with no power. The vehicle had approximately 73,861 miles at the time of the failure. After the incident, the vehicle was taken to a Hyundai dealership and diagnosed with a burned exhaust valve requiring replacement of the cylinder head & valve. The estimated cost of repair provided by the dealership was approximately 7550. The vehicle had no prior warning lights or symptoms before the sudden loss of power. A sudden engine failure resulting in loss of propulsion at highway speed presents a serious safety risk to both the driver and surrounding traffic. This was an extremely dangerous failure.

Reported

Mar 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

I purchased this car from drive time, and when told about a possible recall on the engine i asked about it. We were told that the issue had been resolved. Not even 10 minutes after driving it off the lot the engine started misfiring, we had done a test drive prior to purchasing this vehicle and nothing had popped up on the dash about any problems. We have been unable to get it looked at. I was not sure if a report should have been filed until now. i am unable to produce photos at this time

Reported

Mar 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Car engine seized and lost ALL power going 60mph down the highway at night with my child in the back seat. I have poured quarts and quarts of oil in this vehicle because it burns oil at an alarming rate until it eventually runs dry and the engine seizes. This is extremely dangerous and luckily my child and I were able to drift to the side of the road without harm and injury. Very discouraging that there are thousands of these cars and engines on the road that can literally seize up at any minute. Maintenance was performed and kept up with. The Oil pressure light had been flashing when the vehicle turned but was flashing even when oil had just been changed. These engines are dangerous and have people in a financial hard spot. I still owe $16k on a car I can no longer drive and that Hyundai is saying due to owner maintenance will not get an engine replacement. The Facebook group Hyundai Oil Consumption test has thousands of people dealing with the same exact issue on these cars and engines.

Reported

Feb 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Purchased used via Carvana in Sept 2025, check engine light came on while driving it home indicating a pre-existing mechanical defect. We submitted the claim through Silver Rock (Carvana's warranty company) and brought to their approved mechanic. The recommended the following repairs, several that were denied by Carvana/SilverRock: spark plugs, alternator, serpentine belt, fuel injection service, electrical ignition coil. A month later check engine light illuminated again and through further diagnostics the mechanic found that 2 of the faulty spark plugs were an incorrect model/fit for our vehicle and reported that information which resulted in replacement being approved (a month after initial request). Fast forward to January 2026 we experienced the widely reported knocking noise while driving coming from the engine and had it towed. The damage is a thrown rod and damaged bearing, which is consistent with the current oil consumption litigation, requiring engine replacement. Our 2017 Tucson 1.6 L turbocharge is not included in the recall. Furthermore, Carfax report shows last oil change reported was 2023. Carvana confirms an oil change is part of their 150 point inspection before a sale, however unable to provide me with documentation and failed to report a record of the work to Carfax. There are many instances of negligence on Carvana's part from failure to provide record of maintenance, which is also failure to adhere to their standard policy, and declining recommended service directly from their approved mechanic, knowing that this vehicle could be impacted by the well known defects through Hyundai. We are requesting assistance with engine replacement meeting safety standards and ensuring consumer protection.

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

MY engine check engine light and than a warning light came on saying not to drive it and i took it to be repaired at a shop and a hyndai dealer and they told me my engine needed to be replaced even though i always serviced my car. It has 103,000 miles on it. It is the same problem as the other person that reported this problem. The other models were recalled but not this one. Im sure by now you know there is a problem with this engine too. It should be replaced by the company!!

Reported

Jan 2026

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Hyundai Tucson. The contact stated that while driving approximately 70 MPH, the vehicle lost power, decelerated, and the check engine warning light started flashing on and off. The vehicle was parked on the left shoulder of the highway and later driven to the right shoulder with the assistance of a State Trooper. The vehicle was later towed to the local dealer, who diagnosed that the engine had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the vehicle was previously serviced under NHTSA Campaign Number: 21V727000 (ENGINE). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 66,000.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

2017 Hyundai Tucson SE vehicle mileage approx. 54,000 miles Was driving on a Highway doing approx. 65-70mph within 30 minutes of the 1hr and 1/2 drive I had lost complete POWER STEERING. Wheel stiffened up and was scary and difficult to lane change to a slower lane or attempt to pull over at 11:00PM due too safety and could not pull over for over an 1 hour until I was home safely. Had to hold the wheel tightly for an hour. It was very difficult to turn and enter my double wide driveway and took 3 times to get car straight enough and pull in without Power Steering. Turned vehicle off and I had looked into possible issues with the (EPS) Electric Power Steering and read possible loss of Power Steering check MDPS Fuse in vehicle Interior Fuse Panel for blown fuse and all was Fine with that Fuse.. Then checked MDPS Fuse Panel in engine compartment near battery and found no issue on the long circuit fuse for the MDPS. After researching 2017 Tucson EPS issues I ran a test by Turning Key on and turn Wheel all the way too Right and leave it there for a minute then turn wheel all the way too the Left and leave there for a minute ,then turn steering wheel till wheels are straight and turn key off. Then start car and see if Power Steering comes back when turning steering wheel in which it did but I'm still skeptical if that was the Fix. Hyundai Car dealership wants to charge me $250 too run tests and diagnostics with computer system. Why should I have to pay for this since there have been numerous recalls on 2017 Tucson and the failure rate on some of the Electronics and Safety features and Engine issues and was originally in for a New Paint job for the Recall. And I just received a notification for the Anti-Theft Ignition Cylinder Protector hardware too be installed Free of charge for the ignition and hardware to be added. I have read and seen MDPS assembly issues causing sudden loss of Steering Assist on many of the sites and on these internet Hyundai Blog complaints.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Following the knock sensor detection system update, this car has a P1326 code that forces it into limp mode. Occurs during moderate-hard acceleration, e.g. getting on a highway. The car is limited to ≤2000 RPM and ≤ 45 mph, and rapidly decelerates to that speed if necessary. Acceleration is very limited. This occurs roughly every two weeks, despite having a brand new sensor installed by Hyundai. Hyundai has also allegedly performed cleaning on the sensor and related parts. This has been going on since November, when the recall that installed this update was performed.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Engine lost power suddenly on the highway. Vehicle entered limp mode and became limited to 45MPH and reduced acceleration.

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The vehicle has a transmission (powertrain) malfunction that first appeared in July 2025, a few weeks after I purchased the vehicle and after the warranty had expired. At the time the issue began, the vehicle had well under 80,000 miles. The transmission slips, fails to properly engage, and cannot provide sufficient power, particularly when accelerating or driving uphill. The vehicle struggles to move forward and behaves unpredictably during normal driving conditions. This defect has put my safety and the safety of others at risk. On one occasion, the transmission failed while I was driving and I became stuck in the middle of an intersection, unable to accelerate, creating a serious traffic hazard. The issue has been reproduced consistently and has persisted despite repeated transmission fluid services. Multiple mechanics have inspected the vehicle and have indicated that the problem is not due to lack of maintenance, but instead is likely caused by the transmission not being properly filled with transmission fluid at the time of manufacture. Despite servicing, the problem continues, indicating an internal or manufacturing-related defect. I have also been in contact with multiple owners of the same make and model vehicle who report the same transmission failure, suggesting this is a widespread issue rather than an isolated incident.

Reported

Jan 2026

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

am submitting a safety complaint regarding my Hyundai vehicle due to repeated engine power loss (limp mode), excessive oil loss, and a denied engine recall replacement. I initially brought my vehicle to the dealership after experiencing engine power loss/limp mode, engine oil loss, and illuminated check engine warning lights. The dealership confirmed that my vehicle was covered under an engine recall and stated that the recall procedure was completed. As part of this process, the dealership performed an engine combustion-related service and charged me approximately $1,600. After this repair, I drove the vehicle for approximately 1,000 miles. When I returned the vehicle to the dealership, the vehicle entered limp mode on the same day it was brought in, and the check engine light was illuminated again. The dealership advised me that the vehicle had lost an excessive amount of engine oil during the 1,000-mile period. Due to the continued engine issues and oil loss, the dealership requested a full engine replacement under the recall. However, Hyundai denied the engine recall replacement request. The vehicle’s repeated loss of power, excessive oil consumption, and limp mode create a serious safety concern, especially while driving at normal road speeds. I am concerned that the recall remedy was ineffective and that the denial of an engine replacement places drivers at risk. I am requesting that NHTSA review this matter for potential safety defects and improper handling of a known engine recall issue.

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to two independent mechanics, and DTC: P1326; was retrieved. The vehicle was not repaired. The contact was advised not to drive the vehicle and to have the vehicle towed to the dealer. The vehicle was towed to the dealer, and the contact was informed that a diagnostic fee would be charged. The contact stated that the TSB: 21-01-023H was performed in February 2025. The dealer was informed that the same failure had occurred. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 92,200.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Engine is burning oil causing the catalytic converter to clog and fail. Hyundai dealership told me after I had the car towed to them for repair on 12/30/2025 that the catalytic converter had already been replaced before in March 2024. I had purchased the car from another dealership March 2025 and the catalytic converter replacement was not on the car fax. I was also I formed by the Hyandai dealership that my car has an extended warranty of 10 year/150,000 miles on the engine due to the known oil consumption issue. My car has 131,000 miles. I was told Hyandai will make it very difficult for engine replacement since I’m a second owner. There needs to be a recall immediately.

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, an abnormal pop sound could be heard coming from the engine. The oil warning light was illuminated. The contact was about to merge to the side of the road when the contact noticed a glow on the underside of the vehicle. The contact then pulled into a parking lot, smoke was emitting from under the hood, and entered the vehicle through the A/C vents, and noticed the flames under the hood. The contact stated that the heater was turned on, and the contact immediately turned off the heater. The contact opened the hood and used a fire extinguisher to extinguish the flames. The fire department was called to check the vehicle to make sure the fire was extinguished. The fire department used a thermo reader to make sure that there was no more risk of a fire. The vehicle was towed to the residence. The contact towed the vehicle to the dealer, where it was diagnosed that the engine had failed. The contact was informed that the vehicle had an open recall pending: NHTSA Campaign Number: 21V727000 (ENGINE). The dealer informed the contact that since the recall was not performed, the engine had failed. The contact stated that he was the second owner and that the vehicle was purchased in 2022. The contact was unaware of the recall at the time of purchase. The dealer refused to complete the recall repairs. The vehicle was not repaired. Most recently, the contact was informed that the connecting rod failed and punctured the bottom end of the engine. The vehicle remained at the dealer unrepaired. The manufacturer was made aware of the failure and denied the recall repairs. The failure mileage was approximately 107,000.

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

Fire

The contact owns a 2017 Hyundai Tucson. The contact stated that while driving at various speeds or accelerating from idle, there was a knocking sound coming from the engine. While accelerating from idle, the vehicle failed to exceed 30 MPH, requiring that the driver slowly accelerate and gradually increase the speed. No warning lights were illuminated. The vehicle was taken to a certified mechanic who diagnosed the vehicle with transmission failure. The mechanic replaced the brakes and tires. The vehicle was then taken to the dealer, who diagnosed failures with the muffler assembly and catalytic converter related to the failure to accelerate. The failure persisted, and the vehicle was returned to the dealer, who confirmed the noises coming from the engine while the accelerator pedal was depressed, with a burning odor, and oil issues. After five visits to the dealer, an oil leak from the drain plug was determined. The drain plug and oil pan were replaced a year and six months later. The vehicle continued to fail to accelerate properly, making it difficult to drive uphill. The vehicle was taken to another dealer, Niagara Hyundai of Grand Island (1910 Alvin Rd, Grand Island, NY 14072), who confirmed that the vehicle was not safe to drive. The catalytic converter was replaced again but the failure persisted, and there was no engine oil in the vehicle. While driving 65 MPH, the vehicle started shaking. The contact pulled over to the side of the road and waited approximately 10–15 minutes before continuing to drive at 50 MPH. The contact inspected the vehicle and noticed that the engine was hot. The vehicle was towed back to the second dealer, who performed an oil consumption test requiring the contact to drive 1,000 miles. The test determined the engine oil level was extremely low. The dealer suggested a chamber cleaning, but the request was still pending. The manufacturer was made aware of the failure and opened a case. The failure mileage was approximately 63,000.

Reported

Jan 2026

Incident date

Feb 2024

Mileage

Not provided

Outcome flags

None reported

severe oil consumption. the vehicle eats the oil at an alarming rate. having to fill the oil tank very often and the engine light has been on. it is affecting acceleration at 30mph where the engine warning light will flash. It also completely dies while driving. very unsafe and needs to be resolved.

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Issue was first noticed in October 2025 - there are roughly 70k miles on the vehicle. It is a 2017 vehicle, and has regular service (oil, inspection). There was a class action lawsuit for this issue (wylie v hyundai), which was settled prior to the purchase of the vehicle. Vehicle stutters when shifting into and out of first gear. A local mechanic and hyundai both confirmed that it was a transmission defect. The Hyundai dealership initially thought it was an actuator issue, but has since said that it is a faulty gear assembly. it has a DCT (dual clutch transmission). Vehicle suddenly stops and is erratic when driving. Coming out of a stop risks the vehicle shuddering; going through an intersection or turning cross traffic is extremely dangerous as the vehicle could stop momentarily and cause a collision. Vehicle is unable to maintain flow of traffic. The problem appears to be widespread - there are various forums we found where others have this same issue. There were no warnings on the dashboard prior to the issue. When issue appeared a check engine light was displayed.

Reported

Dec 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

I purchased a CPO 2017 Hyundai Tucson in June'22 and brought it in for engine stuttering, the car stalling in intersections and was told they couldn't duplicate the problem. I emailed and brought the car in again and still noting was rectified. I've made the oil changes, changed spark plugs, flushed the engine in July and got new oil and everything looked at and in October the engine seized while my husband was driving to work: no oil lights on no engine lights on. Neither Hyundai or the extended warranty will help. My VIN didn't come up in a recall but there's too many problems with other 2017 I would hope they'd look again and help their customers.

Reported

Dec 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

Hyundai Motor America (Hyundai) recalled certain 2019-2021 Tucson vehicles on September 4, 2020. On December 30, 2020, Hyundai expanded the recall population, and added certain 2016-2018 Tucson vehicles. The Anti-lock Brake Hydraulic Electronic Control Unit (HECU) could corrode internally and cause an electrical short, possibly resulting in an engine compartment fire.

Risk: An engine compartment fire can increase the risk of injury or crash.

Remedy: Hyundai will notify owners, and dealers will replace the HECU fuse. For 2019-2021 model years, the Electronic Stability Control (ESC) software will also be updated. Recall repairs will be performed free of charge. Owners are advised to park outside and away from structures as a precaution until the recall repair is complete. The recall began November 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 195.

Hyundai Motor America (Hyundai) is recalling certain model year 2016-2017 Tucson vehicles manufactured May 19, 2015, to November 14, 2016, and 2017 Santa Fe vehicles manufactured November 28, 2015, to November 14, 2016. The affected vehicles may be equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result, in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."

Risk: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will replace the affected accessory trailer hitch wiring harnesses, free of charge. The recall is expected to begin January 13, 2017. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 153.

Hyundai Motor America (Hyundai) is recalling certain 2017 Tucson and Sonata Hybrid vehicles. The connecting rod bearings inside the engine may wear prematurely, which can result in engine damage.

Risk: A damaged engine can increase the risk of a fire or it can cause an engine stall, increasing the risk of a crash.

Remedy: Dealers will inspect the engine. If bearing damage is found, the engine will be replaced. Dealers will also install a software update containing a new Knock Sensor Detection System (KSDS). Repairs will be performed free of charge. Owners were notified of the defect on November 16, 2021. Owner notification letters were mailed January 15, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 209.