2025 Ford Explorer

When going around a curve the steering wheel is sticking on the right. I have to tighten my grip on the wheel and manually straighten the wheel. This happened to me several times today on my 50 min trip. This was very frightening to me making me scared the wheel would stick and I have no control of the car while driving. I purchased this car on sat June 27. It just started today July 3. I am planning to take it back to the dealership on Monday.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

The Speed Sign Recognition feature misread a "CC" cross road sign as being a 60mph speed limit sign and caused the Predictive Speed Assist feature to change the speed control set pont from 25mph to 60mph while in town and in a school speed zone. The abrupt change in speed control setting caused the vehicle to aggressively accelerate without warning and without driver input. The issue has been reproduced many times with many new vehicles at multiple locations. It is consistent.

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

For the second time now, When changing out wiper blades, the wiper arm has sharp points which easily allow the arm to shatter the windshield. To change the wiper you have to push a button and pull quite hard which can easily cause the wiper arm to slip out of your grasp . This can cause the arm to shatter the windshield even at an inch away.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

While driving the infotainment center will randomly go black and loose all function. Eventually only the defrost icon will show up and if I stop and go into reverse , there is a delay for the back up camera to come on. Another issue with this happening is that if you’re using your GPS or CarPlay GPS and relying on it while in heavy traffic especially on the highway, this becomes very nerve wracking and could cause an accident if drivers aren’t sure where they are going or distracted by the blacking out of their screens.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

I took my explorer in on 4-20-2026 for routine maintenance. The ford dealership perform a IPMA update. In the result the update fail and cause front, rear cameras, blind spot, lane assist, front collision, and parking sensors to fail and not work. The dealership informed they contacted ford headquarters but they have no ETA on a solution. The dearlership allowed me to leave in the vehicle that I felt very unsafe in. I have call ford headquarters and filed a complaint 5-18-2026. Still no update to the solution.

Reported

Jun 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

I am reporting a severe safety hazard regarding an immediate, drastic increase in fuel consumption and erratic fuel range calculations following a manufacturer recall repair. My 2025 Ford Explorer ST-Line was operating perfectly until a Ford Mobile Service technician performed safety recall 26S21 (IPMA Reset). According to official Ford manufacturer specifications, this SUV has an expected driving range of up to 501 miles on a full 17.9-gallon tank of fuel. However, immediately following this software update, the vehicle's total driving range drastically dropped. On a 100% full tank of gasoline, the dashboard's "Distance to Empty" (DTE) display now only reads 316 miles left to empty—nearly 200 miles below the manufacturer's expected capability. Furthermore, during a subsequent continuous, short 1.8-mile drive near my residence with no stop-and-go traffic, the DTE display rapidly plummeted from 15 miles down to 5 miles remaining, dropping visibly every two seconds. The vehicle is physically burning through gasoline at an accelerated, unsafe rate. This creates an immediate safety risk. If the vehicle is suffering from an uncalibrated software glitch in the powertrain/fuel modules due to the recall update, or if the procedure triggered a mechanical fault, the vehicle is at high risk of a sudden highway stall or leaving the driver stranded in live traffic due to inaccurate fuel signaling. I request that NHTSA look into whether the software installation process for recall 26S21 can corrupt engine/fuel management maps or trigger fuel delivery faults on the 2.3L EcoBoost platform.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Bought my vehicle from a dealership advertised as Ford gold certified. Immediately after taking delivery of the car, the steering had an issue. Above ~30 mph the steering wheel does not reliably return to center on it's own. Forcing the driver to manually re-center the wheel. Meaning that if I take my hands off the wheel while turning, the car continues turning in that directly. Brought to the dealership immediately for servicing to fix the issue. They replaced several major components including the steering rack only to find that the issue persists. Despite all of the failed repair attempts, ford is now refusing to continue attempting to repair as they claim it's normal driving characteristics. It is not. I've driven other similar models that do not do this.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Deputy driving the vehicle reported to Fleet of Little to no power brake assist. Fleet found ABS fault codes C0020:64:68 present and sent to the dealer. Dealer is reporting back of possible ABS HCU fault.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Brake system Fault - no power assist. While the Deputy was driving his vehicle every light on the dash lit up and it said all systems were not working. He stated that only brakes he had were the regenerative brakes for the electric motors. He stated that he turned the car off for 10 minutes and everything worked again. The vehicle was taken to a local dealer and they are looking to replace the ABS HCU on this vehicle. Additionally we have a second one that was purchased around the same time as this one with similar issues of no power assist brakes.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The tailgate on the vehicle has experienced repeated misalignment issues. The first occurrence happened at 811 miles. The vehicle was taken to the dealer, and the body shop performed adjustments to correct the alignment. Approximately nine months later, at around 7,500 miles, the tailgate became misaligned again. The vehicle is currently undergoing another adjustment under warranty to address the same issue. This repeated condition raises concern about the integrity and durability of the tailgate alignment and related components. Improper alignment could potentially affect the secure closure of the tailgate and may pose a safety risk if it were to open unexpectedly or fail to latch properly while driving.

Reported

Jun 2026

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

While driving on a clear road, the vehicle suddenly applied automatic emergency braking with no obstacle present. The braking was extremely aggressive and unexpected, creating a significant rear-end collision risk and causing physical discomfort (neck strain). Immediately following the event, the vehicle displayed a “Lane Keep Assist Off” message. There were no other vehicles around me at the time, so there was not a risk of a collision this time. However, it could have caused an accident if someone was behind me. Also, the sudden braking could have easily caused me to loose control of the vehicle. I am also concerned because my vehicle has already had Recall 26S21 performed (related to the camera/ADAS system). I took the vehicle to the dealer and said Ford is working on a fix for the 4th quarter this year, but not sure what to do in the meantime.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The gear shifter gets tight to put it from park to drive and drive to park, but doesnt stay constant. Brought it in and was told that I am spinning it to fast to spin it slower. I told the dealer I do spin it slow with the same issue. They told me they will not do anything until it gets stuck. Upon doing research, I have found several others have had the same issue.

Reported

May 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Vehicle shut down while driving. Stop safely now, red triangle on IC, and engine disabled. PCM code P1A0C:00:28 Hybrid Powertrain Control Module - Engine Disabled.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

2025 Hybrid PIU/Explorer) for a CEL with PCM codes P0A1E:00:A8 for a starter/generator control module fault.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Hybrid Fault - Service charging system fault displayed. Verified concern. Hooked up IDS and checked for codes. Multiple codes in multiple modules present for engine restart, battery, and low voltage conditions. Hooked up Ford battery tester and performed battery test on both the 12-volt main and auxiliary batteries - main 12-volt battery failed at 70cca. Received warranty code: 11VBE9140L3K and ACES code: HG1HR. Replaced 12-volt main battery and reassembled vehicle. Performed BMS reset, cleared codes, and retest, OK.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

I was driving on the Highway and all the sudden for absolutely no apparent reason the Passenger side door window completely shattered into small bits of glass. I check the vehicle for any damage other than the window not a scratch on the door at all I have no idea what caused the window to shatter.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

1 injuries

Front side windows (driver and passenger side) have a quality issue that creates a distorted, wave-like view when looking out the window. This results difficulty viewing objects seen in the side mirrors. Also, when viewing anything out the side windows (ie. cross traffic) the view is distorted. Further, this makes the driver and passenger nauseated. The issue is constant and does not depend of environment, temperature, weather, or time of day. No warning lamps or messages appear. The dealer confirmed the issue, but stated nothing could be done because other Ford Explorers on-site also have the issue. The issue has also been confirmed on other Explorers in the market.

Reported

Apr 2026

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

Alignment went bad 23489 miles and took to dealer. It was inspected and found out the front cam bushings and bolts were already worn out and had to be replaced both sides. Plus realignment after. Cost was 544.00 dollars had to pay because alignment from factory only goes to 12000 miles , how convenient on fords part , nothing would wear out that soon or shouldn't under normal wear. So , I had to pay. asked my service advisor and he said he has gone round and round with ford and to no end , basically ford said to bad. My advisor said ford knows and knew of this for the last few years on explorers , broncos and f150 trucks and doesn't care to want to cover the cost of repairs and or fix the problem. here's the main point , my advisor said ford knows they put less quality , inferior parts made from less strength material made parts and doesn't care. My advisor told me the after market parts are made of better material and better quality and I will never have this problem again. That said , YES , this is a safety problem if , the parts were to break or come apart , could cause an accident , crash and worse case could kill someone if this were to fail on the highway at high speeds. So , I feel Ford needs to correct this , recall all the vehicles involved and , I and many others so far should be repaid for customers having to fix this problem. As my advisor said , many others so far and ford corp doesn't care. WHERES THE RECALL. Before someone gets killed! No option but to fix as to replace the parts and get realignment to save the tires from wearing out and having to be replaced , of course at my cost! Per my work order of inspection and required repairs.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

My 2025 Ford Explorer pulls hard to the left, the steering wheel feels heavy, stiff, and gets hard to steer my wife and I are constantly fighting with the car to get it to steer right and stay in the lane. If I let it, I can keep the steering wheel straight and the car will just veer to the left Into the left lane, it’s dangerous, my wife won’t even drive it anymore. Then there are times while driving on curvy roads, the wheel or the cars steering will get stuck and if I wanted to, it will stay turning on its own around corners or curves. Also when we take a turn onto another street sometimes it gets stuck again, doesn’t come back like most cars do. We have had it in the shop more than 3 times for these problems. They have replaced the steering rack/gear, done alignments, but the problem still persists we are afraid that the steering is going to get stuck, that we won’t be able to pull it back into our lane and cause a major accident. We have brought it to the dealer but say they have done what they can and need direction from Ford. I don’t know if it’s related but there has been warning lights but it said it was for the parking brake. I have even been on rides with a service manager from a ford dealership and it has happened but, without an answer from ford they could not do anything. This problem has going on for months now and the dealership can’t fix it I bought it September 2nd, 2025 I can’t remember when it started exactly, October or November but it has gotten worse and worse it seems by the day. The first time we brought it in was in December 31st, 2025 that’s when the dealership changed the steering rack/steering gear I tried to upload files to this form but they are too big

Reported

Apr 2026

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2025 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle started shaking violently. The check engine warning light came on, and the vehicle lost motive power and stalled. The contact used a scanner to identify an error code. The contact was able to restart the vehicle and drove to the residence while driving 20 MPH with the vehicle shaking abnormally. Upon arriving at the residence, the vehicle lost power. The contact called Ford Customer Service and spoke with a Ford Roadside Assistance representative to retrieve the vehicle from the residence. An appointment was scheduled for the dealer to pick up the vehicle at the residence. The vehicle was taken to Ciocco Ford, but was not diagnosed or repaired; however, the spark plugs were replaced but the failure persisted. The manufacturer was made aware of the issue. The approximate failure mileage was 9,000.

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

On March 2nd 2026, while operating my 2025 Ford Explorer ST at highway speeds of approximately 78 MPH, the vehicle experienced a sudden, uncommanded shift from Drive into Neutral. This resulted in an immediate and total loss of motive power in live traffic, creating a life-threatening safety hazard as I was unable to maintain speed or accelerate away from surrounding vehicles. Notably, the dashboard displayed no warning lights, wrench icons, or error messages during or after the event. I was forced to coast across lanes of traffic to reach the shoulder. This is the 7th significant warranty-related issue this vehicle has experienced since purchase in May 2025, representing a substantial impairment to the vehicle's safety, use, and market value under Wisconsin Lemon Law.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

I am writing to formally report a series of catastrophic and life-threatening mechanical and electronic failures in my 2025 Ford Explorer Active (VIN: [XXX] ]), purchased in Bogotá, Colombia. Despite immediately notifying the Ford Post-Sales Support Line after the first incident, the technical response was insufficient, leading to a second, more severe event that nearly resulted in a fatal high-speed collision on February 9, 2026. Incidents Summary: 1. Total Power Loss: Engine and all electrical systems shut down while in motion (40 km/h), losing steering and braking assistance. 2. Brake System Failure: At 70 km/h, The vehicle presented a multi-system failure of sensors, audible alarm and illumination of warning lights (ABS, Traction Control, Pre-collision Assistant, hill start assist not available, check brake system, BRAKE, ESC check, driving modes not available). the vehicle experienced a total loss of brake pedal response followed by a sudden, uncontrolled autonomous "hard braking" event. This happened on a high-traffic highway (Autopista Norte). Global Safety Concern: I am formally requesting a Global Technical Investigation into this unit and the 2025 Explorer Active series. The failure of the electronic brake booster and the total system shutdown represent a "Product Liability" risk that could lead to mass-casualty events. I demand: • Direct intervention from Ford Global to Ford Colombia. • A formal safety alert or recall investigation for similar units. Sincerely, [XXX] MAIL [XXX] bogota colombia phone [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The vehicle failed the inspection related to Recall 25C42. Since owning the vehicle, I have experienced repeated intermittent failures of multiple safety and driver-assistance systems, which raise serious safety concerns. The Pre-Collision Assist system has activated without any apparent reason on four separate occasions, including situations where there were no vehicles, pedestrians, or obstacles present. These unexpected activations are alarming and could increase the risk of a collision. I fear for my safety when driving the vehicle due to these unpredictable safety system activations. Additionally, the Rear Cross Traffic Alert system functions intermittently and does not activate consistently when vehicles are present, further reducing confidence in the vehicle’s safety systems. While driving, the vehicle’s phone connectivity system has disconnected unexpectedly, and during these events the GPS/navigation system became unavailable, preventing the use of turn-by-turn directions. These failures occur while the vehicle is in motion and contribute to driver distraction and safety concerns. The vehicle was inspected for Recall 25C42, and I was informed that the required repair cannot be completed because the replacement part is on backorder until June. As a result, the vehicle continues to be operated with known and unresolved safety-related defects for an extended period of time. These issues occur intermittently and without warning, making them difficult to reproduce or diagnose. Due to the ongoing malfunction of critical safety systems and the delay in recall repairs, I fear for my safety while driving this vehicle.

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

While using Ford Blue Cruise, the Blue Cruise system failed to maintain lane control and fought the driver's steering wheel input, resulting in the vehicle colliding with a traffic cone. I have had 3 other instances where Blue Cruise has randomly jerked me toward the shoulder or an exit ramp, this is the first time colliding with anything. Only damage to the vehicle from this incident is a ripped fender well liner, there are some markings on tire sidewall but no damage. Certainly could have been worse. The cone collision happened on Interstate 79 Northbound at MM101 in West Virginia. I have had lane jerking happen with Blue Cruise twice Northbound at MM105, and once Southbound at MM118. The system is on by default, I am trying to figure out how to turn it off to prevent future safety issues.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

Crash

Ever since I bought that vehicle, it's had system malfunctions. I received three letters directly from Ford explaining the problems this vehicle had or could have. But he and the dealerships, where I took my vehicle for repairs, never did them. They always denied that it had any problems and said that my vehicle was new and had nothing wrong with it.

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Car was parked on a driveway, decent grade, with 50 miles left to empty (no low fuel light on). Facing downward. Car did not turn over. Had to use manual override to put vehicle into neutral and coast to a more level area and start it up. Seen this issue posted on the Explorer ST Facebook group multiple times, so I was lucky I knew what the issue is. Most other people would be stranded. There is a flaw in the Explorer's fuel tank system that will not allow the car to start if fuel level gets below a certain threshold when parked facing down a steep street or driveway.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2025 Ford Explorer. The contact stated that on the first day after the vehicle was purchased, the pre-collision camera failed to function as intended. The contact stated that the alarm failed to beep as intended when a person or an object was in front of or passing by the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. A diagnostic test was performed, and it was determined that the pre-collision camera worked as designed. The contact stated that the manager at the dealer took the vehicle home and confirmed that the pre-collision camera sensor had failed to function as intended; however, the vehicle was not repaired. The vehicle was taken to Biener Ford; however, no cause for the failure was found. The contact stated that on a separate occasion, while driving at an undisclosed speed in the snow, the message "Pre-collision Camera Blocked" was displayed. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was made aware of the issue. The failure mileage was approximately 11.

Reported

Jan 2026

Incident date

Feb 2025

Mileage

Not provided

Outcome flags

None reported

Since new. Thousands of dots or specs are visible in the window upon sun up of sun down. This is not the snow flake safety campain that Ford has. Others have the same complaint on social media.

Reported

Jan 2026

Incident date

Oct 2024

Mileage

Not provided

Outcome flags

None reported

First, we took this vehicle to a dealer because the rear window buttons were not working. They wouldn't roll down. Second, the dome lamps inside only work part of the time, when we take the vehicle to the dealer or another Ford dealer that we decided to try, they say they can't do anything because they see no issue as the lights are working AT THAT TIME. Third, while connected to a trailer, an error message appears several times stating that the trailer has been disconnected. It just flashes and pings, and then disappears. This is a safety issue, as it has caused me to make sudden stops as I am made to believe that the trailer has became disconnected. All these things are stated in the recall we received on this vehicle, and we just want the body control module replaced as it says they should do, but both dealers(Bruce Walters Ford - Pikeville KY) and the dealer we switched to to try and remedy the issue (Freedom Ford of Wise VA) say that there is no issue, and refuse to do the control module replacement. This vehicle has been inspected at the least 6 different times for these issues, and still nothing has been fixed.

Reported

Jan 2026

Incident date

Jan 2025

Mileage

Not provided

Outcome flags

None reported

Parked vehicle on snowy driveway, went to back to unload personal items from liftgate, and vehicle began sliding backwards towards me. Ran to the driver‘s door, got in, put on brakes, started vehicle and pulled it forward. Put it in park, and as I was exiting the vehicle, it began sliding backwards again. Rear wheels were locked. However, the front wheels were rolling. Apparently the transmission park pawl did not engage. I took pictures of the tires after the last roll. Front tracks show clear tread in the snow (rolling); rear show lines and pushed show (sliding)

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

I brought my 2025 Explorer in on 12/19/2025 for a recall check. I mentioned to the Service Advisor that the left rear inner wheel well skirt was detached from the quarter panel. After the car was looked at, he came to me and said that they can be replaced at a cost of $600...XXX. He said it is from the snow and ice tearing them because of the larger tires on the vehicles now....NO XXX..we live in WNY. This is a brand new-ish vehicle with 15,000 miles. How is this something that is my cost, there is obviously a problem with parts or engineering. Basically I will have to replace these after every winter season for the reason that was given....AGAIN...why is this not covered. I regress, he did say Ford MAY help the first time...REALLY?? What happens the next winter and the one after that?? $40K+ for the vehicle and this

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Front and side curtain air bags failed. Was side swiped and hit a guard rail head on at 60-70 mph. I was going on the far left lane on the interstate 85. When a lady in the center lane hit the side of my car not paying attention that I was in my lane.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

My remote start would not work from inside of a restaurant so I went out to manually start the car. It started fine. It was very cold out so I thought that I would drive up next to the building to get close to the entrance. The parking lot was not slippery at all , when I applied the brakes I had absolutely no brakes and the car bumped into the building. No damage to the building but my license plate bracket was broken and the bumper had minor damage.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

We purchased a 2025 Ford Explorer Active RWD and had a couple of issues with it. Twice when starting the car, foot on brake and when putting it into D the brake pedal drops a notch. It had some error codes as well and OF Course the dealer could find anything wrong. So we trade it in in less than a month for this model 2025 Ford Explorer Active 4WD. The brake has done the same thing to me twice. We purchased this second vehicle on 10/31/2025. Today was the second time this happened. It happened approximately a week ago as well. It's always when putting it into Drive. I have never ever owned a vehicle where the brakes fall a bit...has a rough notch as it falls!! It does not fall to the floor, it is as though a firm brake pedal just falls an inch or so and it's rough, like it's broken. After it happens I drive very slowly and carefully to make sure my brakes are still working. Not normal by any circumstances and the best I can describe this. We drove three Explorers before choosing this one and all three, four with other one purchased the brakes felt different! Brakes should not feel softer or firmer on new vehicles. Our dealer is about 50 miles away and I can almost guarantee they will not find anything because they can't or won't be able to reproduce it as it only happens once in a great while. Like I mentioned, today 12/8/2025 is the second time this has occured on this second Explorer. They would need to drive it everyday for weeks on end and only while putting it Drive as it hasn't happened in Reverse on either vehicle. I do use the park brake while at home, but all times this occured the park brake was not being used and on a flat level surface. Very scary driving a new vehicle around not knowing what is going to go wrong with it especially with brakes! We should feel SAFE in our newly.purchased vehicles. I sure hope Ford figures these issues out before someone gets hurt or dies.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

My wife found an article about this, so I guess it happens to other people as well. I will leave the link that she sent to me in this report. To put it very simple there seems to be a problem with the seat, memory module in the door of some Ford Explorers. So many times when my wife has had to move my car from the driveway she gets in the car. She pushes the number two button for her seat settings, and she begins to drive the car. While the car is in motion, at any random interval, the seat will reset to my position without any notice. This means the seat begins to move while the car is in motion. In our case, I am about a foot and a half taller than her so when the seat goes back to my position, even though she’s driving, she can no longer reach the brake. Several times while in motion she has had to just hit the power button and shut the car off. This is bad for the car, but it is also best for her safety. I can see this situation causing an accident. It seems Ford knows about it, and they have fixed it in some cars, however until it happens to you I don’t think you’re going to be aware of the problem if you’re moving quickly, it could be a huge problem. I think this is something that Ford needs to address with expediency Here is the article where she found a similar experience of another customer online [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

There is a large black box on the interior windshield surrounding the rearview mirror. This box blocks the defrost on the windshield, causing ice buildup on the windshield in this area thus causing ice buildup on the windshield wipers. This causes the windshield wipers to be ineffective at removing water, snow, slush, - whatever debris is on the windshield from being removed greatly decreasing visibility in freezing temperatures. I first noticed this when it started to get cold and my windshield wipers were making a strange noise. I got out of the car to see what was going on with the windshield and noticed the ice building up at the top middle of the windshield. As I drove, and the temperatures dropped, the top half of my windshield where this black box is iced up causing my windshield wipers to be ineffective on about the top half of my windshield. This greatly reduced visibility in already reduced visibility driving conditions. This was not just ice on the windshield. It was very obviously accumulating where this box is, due to ineffective defrost of the windshield.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

My vehicle originally showed more than 10 open safety recalls in the FordPass app and at the servicing dealer. I saved screenshots of each recall. After Ford performed a remote over-the-air software update, all but one recall suddenly disappeared from the app even though no physical repairs were done and no documentation was provided. NHTSA still shows Recall 25V543 as incomplete, involving BCM soldering defects that can cause trailer taillamp failure, electrical malfunctions, HVAC issues, mirror/window failures, power outlet issues, and other safety-related electrical problems. The dealer has not scheduled the repair despite parts being listed as available. Ford Motor Company and the dealer have not provided any recall history, OASIS report, repair documentation, or explanation for why multiple recalls disappeared. This creates a safety concern because the vehicle may have unresolved electrical or lighting defects that were not properly repaired or were prematurely marked as closed after a software update. The issue has not been resolved, and Ford has not responded to multiple requests.

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

12 V Battery continues to die and I've had the car less than a year. On [XXX] the battery was dead. Our neighbor put it on his supercharger. On [XXX] the 12V battery low light came on while I was driving 30 miles away. It went off the next day and reappeared on Thursday [XXX] disappeared on Friday and back on Saturday. I called the Future Ford on Monday and technician [XXX] said it only showed 15% charge. I took it in to the dealership and it was kept over night and the next day he said it was charged to 90%. I was not happy with the "you can come and get it". I told him I'm a [XXX] and bought this car so I wouldn't breakdown and now I don't feel safe with it. He checked the charge again while we were on the phone and he said it dropped to 80%. He said thats not good it will probably need a new battery. That evening he text and said it is fully charged and I can come get it without a new battery. I was not happy as I've received no reason for why it was losing charge. So I did some research on my on and text him back that evening. I told him about my research and found this was an ongoing problem and that they need to find out what is causing the draining issue. I'm sure the dealership had to know as there was a recall for this issue. I suggested a Parasitic test, or software glitch issues to check. He said they would run the parasitic test.. He said it would take several days. I checked back on 12/4/25 and he said No Progress today. I told him I want a copy of all the test run. Wouldn't you know it he gets right back to me saying a handful of modules need updated software. That they will attend them this morning. I think they were trying to get out of the fix as my warranty runs out this month. Why are only certain vehicles being recalled (mine not one of them), when they all should be recalled. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

When making a turn or going around curves the steering does not return to center and sticks in whatever direction you are turning

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

I would need to change many more of the points on the top, see report.

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

-EPAS malfunctioning and is available for inspection. -Steering sticks in turns and requires too much effort to return to center causing me to overcorrect which causes the steering to stick in the opposite direction and so on. This is not consistent or predictable Also The car is constantly drifting left to right and requires constant corrections to maintain center. -I replicated the issue with the dealer in the car. Dealer said the other car drove the same so there was nothing they could do. -only the dealer has looked at it -no warning lamps present at this time -i have videos that show the car taking turns on a mountain pass and I am able to let go of the wheel and the car continues to turn. Without steering assist features activated. It should at least try to center on its own.

Reported

Nov 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

Steering drifts to left and will not return to center with out darting to the right when correcting , a constant movement back and forth to keep it in your lane !

Reported

Nov 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

“I rented vehicle VIN [XXX] from Budget Rental Car in Panama City Beach, FL (Reservation #XXX, Rental Agreement XXX). I later discovered the vehicle had an unrepaired federal safety recall (NHTSA Recall 25V543 / Manufacturer Recall 25C42) involving the Body Control Module. Budget never informed me of the recall at any time. On November 11, 2025, when I attempted to extend my rental, the representative told me the vehicle had been ‘sold’ and must be returned within two days. When I attempted to exchange it on November 12–13 at three different Budget locations in Lansing, MI, they refused to take the vehicle, stating it had a safety recall and should not have been rented out. Only after this did I check the VIN myself and learn of the safety recall. The recall affects multiple electrical and visibility-related components: trailer lights, interior lights, mirrors, windows, rear defroster, USB/12V ports, and HVAC systems. These issues can reduce driver visibility and increase the risk of a crash. While driving the vehicle, I experienced visibility problems. The windows fogged up severely, and the defroster did not operate properly. As a result, I was unable to see an animal that entered the roadway and unfortunately struck it. There is now damage to the front driver’s side of the vehicle. This visibility impairment aligns with the Body Control Module recall defects described by NHTSA. This vehicle should not have been rented to any customer, especially with the remedy unavailable until late 2025. I am reporting this because an unrepaired safety recall vehicle placed into active rental service directly resulted in a visibility hazard and an unavoidable collision while I was driving.” I did not make it back in time to return the vehicle yesterday 11/14/2025 I am finishing up this report and on my way to Budget in Panama City Beach Florida to return it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Ever since the last recall got resolved the car has failed to go into the gear it’s set to. Such as it fails to go in park when you shift it into park. This is a serious issue as I have now almost rear ended cars in parking lots a few times because of this issue.

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

See Attached Repair Order

Reported

Nov 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

Stopped at traffic light when changed to green pushed on the gas started to roll backwards . Got it stopped and pushed on gas would barely go sounded like transmission slipping. Finally got it thru the stoplight and it started again. Got it home called local dealership took it in and have to take it back Friday morning at 8. Scary!

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

Three times in 5 months since purchasing our 2025 Ford Explorer, all dash lights will come on while driving and vehicle will come to a stop. Braking pressure is reduced greatly and then vehicle will not continue in forward or reverse. Multiple restart attempts will allow the vehicle to move under 5 MPH but will brake hard to a stop if it goes over 5MPH. Two different dealerships have inspected and preformed the same software updates Ford is recommending and its not fixing the issue. Ford is refusing to do anything about it at this time because they claim the software update is as far as they are allowed to go in diagnoses. I have a Ford Case #XXX

Reported

Oct 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

My 2025 Ford Explorer ST-Line is up to date on recalls as of October 7, 2025. However, I am still experiencing engine "shudder" and hesitation at low RPMs (between idle and 1500 RPM) when accelerating. The 10 speed transmission is also continuing to shift harshly at times. I am very concerned that the hesitation and shudder could be an issue when pulling out into traffic. By comparison, my previous 2017 Explorer did not exhibit this behavior, whichh I consider disconcerting. Also, this car (and all 2025 Explorer models ) injects Fake Engine Noise into the audio speakers to make the 2.5L engine sound more powerful. These fake "bass tones" are disturbing to some passengers with hearing aides, and per Ford's website there is no way to disable the fake noise. Thus, some people with a hearing disability cannot ride in my car without removing their hearing aides. It should be unacceptable to not be able to disable that feature. Note updated form dated 8/1/25 states Fake Noise cannot be turned off.

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

The carpet on the wheel wells is not functional. We live out on a ranch on a dirt road and when it rains the mud gets stuck on the carpet and weighs is down. This can cause more damage to the vehicle. We took it in to a dealership and they said there was nothing they could do until the carpet gets ripped off. When we bought an expensive 4x4 vehicle we expected it to be sturdy enough to not have to worry about mud (especially when the car has a built in mud feature).

Reported

Oct 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

While traveling down the road - not turning or braking - several alerts and alarms started flashing on the driver dashboard on my 2025 Explorer. At this time, I completely lost the ability to slow the car down. The digital emergency brake made no changes to the braking ability. I was able to eventually able to get the vehicle to slow down by engine torquing and turning. I reached out to my local dealership where I purchased the vehicle, and they told me to call Ford Roadside Assistance immediately. They contracted a local towing agency, and they promptly towed the vehicle to that dealership. I was able to take a movie of the incident.

Reported

Oct 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

Ford Motor Company (Ford) is recalling certain 2025-2026 Explorer vehicles. The Dynamic Bending Light (DBL) system software may cause the passenger-side headlight to turn in the wrong direction when driving through curves in the road. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."

Risk: A headlight that turns incorrectly can result in increased glare to other road users, increasing the risk of a crash.

Remedy: The headlight control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C12. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.

Ford Motor Company (Ford) is recalling certain 2025 Ranger, Lincoln Nautilus, Mustang, Maverick, Explorer, Escape, Lincoln Corsair, Bronco Sport, and Bronco vehicles. The exhaust gas recirculation (EGR) valve may fail, resulting in an unexpected loss of drive power.

Risk: An unexpected loss of drive power increases the risk of a crash.

Remedy: Dealers will replace the EGR valves, free of charge. Interim letters, notifying owners of the safety risk, were mailed March 20, 2026. Additional letters will be sent once the final remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S10. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.

Ford Motor Company (Ford) is recalling certain 2025 Explorer vehicles. The powertrain control module (PCM) may reset while driving, which can damage the park system or cause an engine stall.

Risk: A damaged park system can result in a vehicle rollaway when the vehicle is placed in park without the parking brake applied. An engine stall while driving can result in a sudden loss of drive power. Either of these scenarios can increase the risk of a crash.

Remedy: Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed June 6, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S35.

Ford Motor Company (Ford) is recalling certain 2024-2026 Explorer and 2024-2026 Lincoln Aviator vehicles. The trailer hitch assembly bolts may be loose.

Risk: While towing a trailer, loose trailer hitch bolts can cause a loss of vehicle handling and control, or cause the trailer to detach. Either of these conditions can increase the risk of a crash.

Remedy: Dealers will inspect and tighten the trailer hitch bolts, or replace them as necessary, free of charge. Owner notification letters were mailed October 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA3. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

Ford Motor Company (Ford) is recalling certain 2025 Explorer and Aviator vehicles. A mounting bolt for the front subframe may have been tightened improperly.

Risk: A loose subframe bolt may reduce the vehicle's performance in a crash, increasing the risk of injury.

Remedy: Dealers will inspect and tighten the subframe bolts as necessary, free of charge. Owners may contact Ford Customer Service at 1-866-436-7332. Owner notification letters were mailed May 21, 2025. Ford's number for this recall is 25S43.

Ford Motor Company (Ford) is recalling certain 2025 Explorer vehicles. The bolts securing the front brake caliper may not be tightened properly, which can result in a loss of front brake function and possible wheel damage.

Risk: Loss of brake function and wheel damage can increase the risk of a crash.

Remedy: Dealers will inspect and tighten the bolts as necessary. If bolts are missing, the brake caliper and pads will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed June 19, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S60.

Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.

Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

Ford Motor Company (Ford) is recalling certain 2023 Lincoln Corsair, 2023-2024 Escape, 2024 Mustang, and 2025 Explorer vehicles. The fuel injectors may have been assembled without O-ring support discs, which can result in a fuel leak.

Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Dealers will install new fuel injector O-rings and O-ring support discs, free of charge. Owner notification letters were mailed on October 7, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S54.

Ford Motor Company (Ford) is recalling certain 2025 Explorer and Lincoln Aviator vehicles. The rearview camera image may fail when the vehicle speed reaches 10 MPH or greater. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk: The loss of the rearview camera image while in reverse can reduce the driver's rear visibility, increasing the risk of a crash.

Remedy: The accessory protocol interface module (APIM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed on March 28, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C34.

Ford Motor Company (Ford) is recalling certain 2025 Ford Explorer and Lincoln Aviator vehicles. The transmission may be improperly secured due to loose cross member bolts.

Risk: An improperly secured transmission can result in a loss of drive power, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the transmission cross member bolts as necessary, free of charge. If the cross member bolts are missing, dealers will replace the cross member and install new bolts, free of charge. Owner notification letters were mailed January 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S03.

Ford Motor Company (Ford) is recalling certain 2024-2025 F-150, Bronco, 2024 Ranger, 2025 Mustang, Explorer, and Aviator vehicles. The transmission valve body may have been machined incorrectly, which can cause reverse gear failure, or unexpected forward movement in reverse or neutral gear.

Risk: Unexpected vehicle movement increases the risk of a crash.

Remedy: Dealers will replace the transmission main control valve body, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S19.

Ford Motor Company (Ford) is recalling certain 2025 Transit, F-150, and Explorer vehicles. The connecting rod and rod bearing components may have manufacturing defects that can lead to engine damage and engine failure.

Risk: A damaged engine can result in engine failure and a stall, increasing the risk of a crash.

Remedy: Dealers will inspect the connecting rods and replace the engine long block assembly as necessary, free of charge. Owner notification letters were mailed August 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S55.

Ford Motor Company (Ford) is recalling certain 2020-2025 Aviator, and Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, folding, or sliding unexpectedly while driving.

Risk: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing their risk of injury.

Remedy: Dealers will inspect the second-row seat switch, and replace the bezel around the switch as necessary, free of charge. Owner notification letters were mailed August 7, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S67.

Ford Motor Company (Ford) is recalling certain 2025 Explorer and Aviator vehicles. When towing a trailer, the tail lights on the trailer may fail to illuminate due to an improperly manufactured body control module. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."

Risk: Trailer tail lights that do not illuminate as intended can reduce visibility to other drivers, increasing the risk of a crash.

Remedy: Dealers will replace the body control module C on vehicles with less than 9,000 miles. For vehicles over 9,000 miles, dealers will perform a functional check on the body control module C and replace it as necessary. Repairs will be performed free of charge. Aviator 2025 owner notification letters were mailed October 13, 2025. Explorer 2025 owner letters were mailed November 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C42.

Ford Motor Company (Ford) is recalling certain 2025-2026 Lincoln Corsair, Lincoln Aviator, and Explorer vehicles. The windshield glass may have visible air bubbles, which can obscure the driver's visibility. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 205, "Glazing Materials."

Risk: Reduced visibility while driving can increase the risk of a crash.

Remedy: Dealers will inspect and replace the windshield as necessary, free of charge. Owner notification letters were mailed November 6, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C60. Vehicle Identification Numbers (VINs) involved in this recall become searchable on NHTSA.gov beginning October 27, 2025.

Ford Motor Company (Ford) is recalling certain 2020-2026 Explorer and Lincoln Aviator vehicles. The seat belt anchor bolts at the second-row outer seating positions may be improperly secured.

Risk: A loose seat belt buckle may not properly restrain an occupant during a crash, increasing the risk of injury.

Remedy: Dealers will inspect the second-row outer seat belt lower anchor bolts and replace or repair them as necessary, free of charge. Owner notification letters were mailed March 30, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C18. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 19, 2026.

Ford Motor Company (Ford) is recalling certain 2022-2025 Lincoln Navigator, 2024-2025 Lincoln Nautilus, 2025 Lincoln Aviator and Explorer vehicles. The Image Processing Module A (IPMA) may experience multiple unexpected resets, resulting in loss of the rearview camera image and advanced driver assistance (ADAS) features, including pre-collision assist, lane-keeping assist, and blind-spot monitoring.

Risk: Loss of the rearview camera image and certain driver assistance features, can reduce the driver’s ability to detect hazards, increasing the risk of a crash.

Remedy: The Image Processing Module A software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. This is a Phased campaign. Phase 1 will include 2025 Aviator, 2025 Explorer, 2025 Nautilus notified owners on 4/13/2026. Phase 2 will include 2025 Navigator will notify owners on or about 4/20/2026. Phase 3 will include 2022-2024 Navigator will notify owners on or about 6/8/2026. Phase 4 will include 2024 Nautilus will notify owners on or about 6/22/2026. Owner notification letters were mailed April 13, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S21. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 25, 2026.

Ford Motor Company (Ford) is recalling certain 2025-2026 Explorer, Ranger, and Bronco vehicles. The engine may fail, which can result in a loss of drive power.

Risk: A sudden loss of drive power can increase the risk of a crash.

Remedy: Dealers will replace the engine long block, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 5, 2026. Additional letters will be sent once the remedy is available, anticipated in November 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S35. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 28, 2026.

Ford Motor Company (Ford) is recalling certain 2020-2027 Aviator and 2020-2026 Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, tipping, or sliding unexpectedly.

Risk: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing the risk of injury.

Remedy: Dealers will inspect and replace the bezel around the switch as necessary, free of charge. Interim letters explaining the safety risk are expected to be mailed July 27, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S52. This recall expands Recall 25V393. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.