2021 Kia Soul

Took my vehicle in a year ago for the oil piston recall to the Kia dealer in North Huntington, Pa. I was told they corrected the recall during other servicing. My vehicle just broke down and is unable to be driven due to this unresolved issue.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

Noise while driving and over bumps and steering

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Vehicle: 2021 Kia Soul LX, 2.0L Engine Subject: Loss of Motive Power and Stall While Driving Under Recall SC336 Description of Incident: On 07/02 @ roughly 6:15PM, while driving on the highway I-35E at approximately 60 MPH, my vehicle's engine experienced a sudden and complete loss of engine power, stalling while in motion. I was able to safely navigate to the shoulder, activate my hazard lights, and restart the vehicle after pulling over. This stall occurred despite the vehicle being covered by Recall SC336 for defective piston oil rings . The recall condition explicitly warns that engine seizure can result in "loss of motive power," creating a significant risk of crash or injury. Ongoing Symptoms (Documented): · Excessive oil consumption: Over 2.5 quarts low after approximately 1,000 miles since the last oil change. This aligns with the recall's "increased oil consumption" warning. · Audible engine knocking when shutting off and ticking during acceleration. This matches the "abnormal noise from the engine" described in the recall. · Active Diagnostic Trouble Codes (DTCs) stored: P0017, P0014, P000B, P0172, P0300, P0301, P0302, P0303, P0304. These indicate timing issues, misfires on all four cylinders, and oil pressure-related failures. Vehicle had similar codes when visited for recall February of this year. Was told everything looked fine. · The vehicle shows signs of instability when accessories (A/C, headlights) are engaged, suggesting the engine is struggling to maintain idle. Safety Risk: The vehicle is unsafe to drive. The stall on the highway presented an immediate crash risk due to the sudden loss of power, which also disables power steering and power brakes.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Kia Soul. The contact received notification of NHTSA Campaign Number: 25V099000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the vehicle lost automotive power while the accelerator pedal was depressed. No warning light was illuminated. The contact pulled over to the shoulder of the road, where the vehicle was later towed to the residence. The vehicle was towed to a local independent dealer, where it was determined that the engine oil level was low. The contact associated the failure with NHTSA Campaign: 25V099000 (Engine and Engine Cooling). The local dealer was contacted and submitted a claim along with service records. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, and a claim was not filed. The failure mileage was approximately 72,000.

Reported

Jul 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The vehicle burns oil. The first incident occurred when the car stopped running. Fortunately I was in a residential area and was able to pull into a parking lot. My mechanic confirmed it was lack of oil in the engine. I have taken it to the dealership and had it tested, but they said it was not enough, and then with the recall, they again said it was not the problem. It continues to burn oil and I have to check it at every gas refill to check the level.

Reported

Jun 2026

Incident date

May 2024

Mileage

Not provided

Outcome flags

None reported

I am filing this complaint regarding my 2021 Kia Soul due to repeated engine and powertrain failures and concerns about the quality and safety of the repairs. While my vehicle was under Kia's 100,000-mile powertrain warranty, I repeatedly brought it to the dealership for excessive oil consumption and transmission problems. Despite multiple visits, the dealership performed minor repairs or claimed they could not identify the transmission issue. I also contacted Kia Consumer Affairs but received no assistance. Shortly after my warranty expired, Kia determined both the engine and transmission required replacement. The repairs were completed as a "good faith" repair rather than a warranty or recall repair, using remanufactured components. Since then, I have continued experiencing problems. The replacement engine appears to have been installed improperly, including stripped motor mount bolts/pins and a missing bracket. Within months, I also developed radiator and coolant reservoir problems, raising additional safety concerns. I understand Kia has issued recalls and service campaigns involving similar engine and powertrain defects. When I previously checked my VIN, I recall it showing an engine-related recall. However, a recent search showed no open recalls. Regardless, my vehicle experienced the same failures and required replacement of both the engine and transmission after I repeatedly sought repairs while still under warranty. I believe these repeated failures and the apparent improper installation of the replacement engine warrant investigation. I have repair records documenting my complaints, the repairs, and the continuing issues.

Reported

Jun 2026

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

Nothing happened - YET. I'm reporting a manufacturing error. Refer to my upload. I wouldn't be suprised that this defect has been the root cause of some accidents though.

Reported

Jun 2026

Incident date

Apr 2021

Mileage

Not provided

Outcome flags

None reported

The first incident occurred on November 2, 2025. I was driving down a state road. I missed my turn so I pulled into a parking lot to turn around. Once I was able to pull out, I put my foot on the accelerator and felt no resistance. The car rolled out of the parking lot onto the road. I kept pressing the accelerator hoping the gas would return but my car rolled along without picking up speed. I was able to turn into a gas station to get my car off the road. I turned the engine off. When I turned it back on, all of the lights on the dashboard came on, before the only one that remained lit was the check engine light. I had the car towed to my local mechanic who after diagnosing, told me my car over consumed oil which resulted in the engine shut down. I was due for a change in a 400 miles. He said it was a known problem with Kia Souls and advised me to take it to a Kia dealership for inspection, which I did. I've taken it to Kia Danvers. Since 11/2/25, the issue has persisted. On 3/27/26, my car shut down 4 times while driving. Each time I would hear a loud noise coming from the engine, and I could feel the power draining from the steering wheel and pedals before the engine would shut off. After a minute or two, the car would restart. The problems continued on 3/29/26 where it happened 8 times. I was able to get it to Kia Danvers on 4/1/26 for a diagnostic exam and an oil change. They suggested an oil consumption test which I did on 5/4/26. They said my oil reduction was normal. On 5/7/26, while driving, my car began violently shaking with the shaking occurring in the engine. The check engine light came on. I pulled over and immediately called the dealership to explain what happened. The said to come in but I wasn't able to get it towed. When I took it in for scheduled service on 5/27/26, they noted the car consumed a lot of oil and suggested another oil change, and a combustion chamber cleaning.

Reported

Jun 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

My vehicle has been in the shop 7 times for misfire in all cylinders over a 2 1/2 year span Kia dealer refused to replace the engine, 8 months after I threatened to sue the dealership for saying they fixed the misfire in all cylinders issue and 8 months later I’m getting misfire in 4th cylinder. As the engine light came on again and I have a high end car diagnostic tool attached to the car which is giving me that code and previous codes of misfire in all cylinders. First misfire in all cylinders started at 16,000 miles bought car brand new and it continued all the way to 37,067 miles . The Kia dealership keep saying it’s this or that and it’s been fixed but the lights come on the previous 7 times after a week or less after taking it home from the dealer and then saying it’s fixed last time I wanted a new engine a Kia representative said it doesn’t need a new engine. I talked to a technician there about reading about this issue in alot of same vehicles he said I was right but Kia doesn’t want to pay for a new engine so they give excuses or just reset or clear the codes which doesn’t resolve the problem , Kia has changed the fuel tank, changed the spark plug wires, the spark plug cables the assembly,ecm which never resolved the problem

Reported

Jun 2026

Incident date

Aug 2023

Mileage

Not provided

Outcome flags

None reported

I took my 2021 Kia Soul to the dealership for a piston ring recall; they ran their standard test and said it passed, but my car is still showing a misfire fault. I replaced the ignition coil, spark plug, and fuel injector, yet the problem persists. I’ve taken it back to the Kia dealership twice, but they refuse to inspect it because it already passed their test.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

On XXX My car was stopped at a light, the vehicle shot down, and would not restart. I had the car towed to Galeana Kia, [XXX]. Upon isnpection at Kia it was found that the engine oil was three quarts low. I was shocked. There had been no warning lights on the dashboard. I had a synthetic oil change 9,000 miles previously. Galeana Kia charged me $315.96. There was a subsequent recall 25V099. "The piston oil ring(s) in your vehicle may have been manufactured incorrectly...This may lead to increased oil consumption..." On April 16, 2025, subject to the recall, Galeana Kia replaced the engine block. I requested a refund of the $315.96 for the work done on November 25, 2024. Galeana Kia refused. Because the repair work done in November 25, 2025 obviously relates to the subsequent recall, I request that you have Kia reimburse me. See Kia case XXX INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jun 2026

Incident date

Nov 2024

Mileage

Not provided

Outcome flags

None reported

States having problems with oil lost, but only inside the motor as if the rings are faulty

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Kia Soul. The contact stated that while checking the engine oil level, the contact noticed that the vehicle was consuming excessive oil. Upon inspecting underneath the vehicle, the contact's husband did not find any leaks. No warning light illuminated. The vehicle was taken to an independent mechanic, where it was determined that the piston oil rings needed to be replaced, and the engine was consuming excessive oil. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 21V259000 (ENGINE); however, the VIN was not included in the recall. The manufacturer was notified of the failure and informed the contact that the VIN was not included in a recall due to the vehicle mileage. The approximate failure mileage was 82,000.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Initial Breakdown: July 2024, my 2021 Kia Soul (under 40,000 miles) idled roughly and stalled while in motion. It restarted, but as a precaution, I towed it to Kia Greenbrier Chesapeake while it was operable. After diagnostics, the vehicle would no longer start. Warranty Denial: The dealer blamed engine sludge from two missed oil changes in 2022 and quoted $10,000 for a new engine. In August 2024, I appealed the decision but was denied (Exhibit A & B). There were no recalls active for the 2021 model at this time, but there were recalls for the 2018-2020 models for identical symptoms. Third-Party Repair: I paid $3,017 out of pocket to an independent shop for a new timing assembly to make the vehicle safe and drivable again (Exhibit C). Because my daughter is disabled and requires transportation, getting repairs was imperative. A new valve kit, fresh synthetic oil, and filter service were completed by the third-party repair shop. I also returned to Kia Virginia Beach for several subsequent oil changes (Exhibit D). In April 2025, Kia Corporate issued an official safety recall for my exact vehicle (Exhibit E). Before that, in March 2025, I attempted to have the newly issued recall (25V-099) performed, but the dealer turned my vehicle away, claiming a lack of parts. Final Failure: In May 2025, the night before a rescheduled recall appointment, the car became permanently inoperable (at only 47,500 miles). Due to extreme financial hardship and health concerns, I am without my vehicle and without an option. Complaint: The Kia dealership refused to perform the safety recall remedy, verbally citing the same 2022 maintenance gaps from the previous year. The dealership violated federal recall regulations for a known defect. I was left stranded, resulting in a financial charge-off of my auto loan.

Reported

Jun 2026

Incident date

Jul 2024

Mileage

Not provided

Outcome flags

None reported

Was issued a recall from kia for an oil piston ring that wasn't heat treated properly, kia told me the problem was fixed and the recall shouldn't affect me, my car was in an out of the shop for months after that, they replaced my timing belt and transmission under warranty, said i sould be fine between oil changes my car started knocking, i checked the oil and it was completely dry, no warning lights which is part of the recall fix is early detection warning light. I add oil to my car seems to run better for the day, the next morning on my way to an oil change the engine starts knocking the warning light comes on and then im on the side of the road with all my oil on the ground

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Kia Soul. The contact stated while at a light the vehicle stalled. No warning lights were illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 25V099000 (Engine and Engine Cooling). The vehicle was taken to the local dealer, where it was determined that the valve train needed to be replaced. The vehicle was repaired, but the failure recurred. The vehicle was taken back to the local dealer, who informed the contact that the engine light was illuminated. The manufacturer was not notified. The failure mileage was approximately 82,000.

Reported

Jun 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

2021 Kia Soul | VIN: [XXX] | Recall SC336 (NHTSA 25V099) | Kia America Case No. XXX DEALER: Team Kia of El Cajon, 541 N. Johnson Ave, El Cajon, CA 92020 SYMPTOMS: Rapid oil consumption, abnormal engine noise, overheating, vehicle stalling at complete stops, difficulty restarting. All symptoms are explicitly documented in SC336 TSB (Rev 6, 10/21/2025) as consequences of defective piston oil rings. DEALER CONDUCT ISSUES: 1. CHARGED $280 DIAGNOSTIC FEE TO PERFORM A RECALL. Owner confirmed open recall on VIN before arrival. Dealer required $280 diagnostic payment as condition of recall service, in violation of 49 U.S.C. 30120. 2. 24-HOUR TSB PROTOCOL VIOLATION. SC336 TSB requires engine vibration inspection no sooner than 24 hours after R/O open date. R/O opened May 16 at 7:38 AM. Inspection report also dated May 16 with no timestamp. If test ran same day, PASS result is invalid under Kia's own guidelines. 3. FAILED TO OPEN REQUIRED TECHLINE CASE. SC336 TSB Page 2 states: if engine noise is present and inspection results in PASS, dealer must open a Techline case. Owner continues to experience engine noise. Dealer has not provided a Techline case number despite two written requests. 4. DEMANDING $2,500 FOR RECALL-RELATED SYMPTOMS. Dealer is attributing stalling and oil consumption to a separate camshaft issue and demanding $2,500 more. SC336 TSB documents that piston ring damage causes cascading engine damage including timing components. 5. OWNER IS [XXX] , drives for Uber. Vehicle out of service 12+ days. Lost income and rental costs incurred. Kia America corporate (Case XXX) has been copied on correspondence but has not responded. Requesting NHTSA review of this dealer's SC336 recall compliance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Cv joint and axle causing car to stall when turunning

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Kia Soul. The contact stated that upon starting the vehicle, the oil pressure sensor light was illuminated. The vehicle was making an abnormal knocking sound. The contact had to add additional oil. The vehicle was taken to an independent mechanic who informed the vehicle was related to the recall. The vehicle was towed to the local dealer, where it was diagnosed that the camshaft and timing needed to be replaced. The vehicle was not repaired. The contact stated that the vehicle was taken previously to the local dealer for NHTSA Campaign Number: 25V099000 (Engine and Engine Cooling). The manufacturer was contacted, who confirmed there was no warranty coverage. The failure mileage was approximately 126,000.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Kia Soul. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who determined that one cylinder had low pressure while the other three cylinders had pressures higher than 100%. The contact was informed that the engine needed to be replaced. The vehicle was then taken to the dealer, who performed the recall repair under NHTSA Campaign Number: 25V099000 (Engine And Engine Cooling); however, the engine was not replaced. The piston ring was tested and passed. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 109,000.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact noticed the oil drained quickly and RPMs increased rapidly upon starting the vehicle. The approximate failure mileage was 86,100. The vehicle was taken to the dealer where the ECU was replaced twice, the piston rings were not replaced; the issue persisted. The manufacturer was notified of the issue. The approximate failure mileage was 86,100

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Kia Soul. The contact stated while driving at approximately 25 MPH, the vehicle stalled. All of the warning lights were illuminated. The vehicle was taken to a dealer where it was diagnosed that the alternator needed to be replaced. The vehicle was repaired however, the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 75,000.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

took to kia of jackson for recall sc209a they said they would not do recall because i was a dealer ,called customer service and they said do to the fact that i was a dealer it would not be covered kia of jackson [XXX] kia customer service case [XXX] [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

On [XXX], the check engine light illuminated. No other warning indicators activated — no low oil pressure warning, no low oil level warning, no driver alert of any kind regarding engine condition. On [XXX], at approximately 53,845 miles, the vehicle began running rough. I checked the engine oil and found the dipstick registered empty — no measurable oil in the engine. No low oil level or low oil pressure warning had been provided by the vehicle at any point prior to this discovery. I added two quarts of oil. The vehicle stalled while being driven to obtain the oil, and stalled again after the oil was added. I drove the vehicle to Jiffy Lube and had a full oil change performed. Mileage at the oil change was 53,852. I then scheduled an appointment with Gervais Kia in Lowell, Massachusetts, the nearest Kia dealer, less than one mile from my home. The earliest available appointment was approximately one week later. Because the vehicle stalled repeatedly at idle, I drove it to the dealer using both feet — keeping engine revs elevated with the accelerator while braking — to prevent stalling at stops. The vehicle is currently at Gervais Kia for diagnostic inspection. The symptoms match the failure mode documented in NHTSA recall campaign 25V-099 (Kia recall for 2021-2023 Soul and Seltos with 2.0L Nu MPI engines, piston oil ring manufacturing defect). My vehicle has the 2.0L Nu MPI engine and was manufactured at the Kia Autoland Hwaseong plant identified in the recall filing. However, my VIN does not appear in the current recall population per NHTSA VIN lookup and Kia’s recall lookup. The recall remedy includes installation of Piston-ring Noise Sensing System (PNSS) software specifically because the defect provides no driver warning before failure — consistent with my experience, in which the engine ran empty of oil with no warning whatsoever. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

My 2021 Kia Soul experienced repeated overheating despite replacement of major cooling system components including the thermostat and water pump. The vehicle continued to overheat and was later diagnosed by a Kia dealership with engine damage requiring full engine replacement. This failure occurred around 105,000 miles. The symptoms and failure pattern are consistent with known issues affecting similar Kia engines, yet my VIN is not included in any recall. I am concerned this represents a broader defect that may not be fully captured in current recalls.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

What component or system failed or malfunctioned? The engine (piston rings) and catalytic converter failed. The catalytic converter is available for inspection upon request. How was safety put at risk? The engine ran low on oil without any external leak, causing warning lights and engine rattling. Low oil pressure can lead to sudden engine seizure or fire. The failed catalytic converter can clog, causing loss of power on highways and increasing the risk of a crash. Has the problem been confirmed by a dealer or independent shop? Yes. A Kia dealer found the engine 2 quarts low, with no external leak, and recommended replacing the catalytic converter at a cost of over $6,000. An independent mechanic confirmed code P0420, which indicates catalytic converter failure. Has the vehicle been inspected by the manufacturer? The vehicle was inspected by an authorized Kia dealer, but they did not complete the required inspection for Recall SC336 (defective piston oil rings). They did add the software. Were there warning lamps or other symptoms? Yes. The oil pressure warning light and other dashboard lights came on. The engine made a rattling noise. The vehicle later felt sluggish on acceleration, fuel economy dropped, and the exhaust developed a smell. The check engine light came on and later turned off, but code P0420 was stored in the system.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The car rpm fluctuated from 1000 to 5000 rpm while in cruise control going 65 mph. At a stop, thr transmission took 30 seconds to engage to low speed. The car was stuttering and bucking at 10mph to 45mph

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

the engine is consuming a quart of oil per thousand miles.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

I am filing a complaint regarding a safety recall (NHTSA Recall 25V099) on my 2021 Kia Soul that was marked as completed, but the defect was not properly repaired. On 3/17/26, I took my vehicle to a Kia dealership to have the recall addressed. The dealership performed only a software update and diagnostic testing and marked the recall as complete. No engine repair or replacement was performed. Within approximately one week of this recall service, my engine suffered a catastrophic failure while driving, resulting in a hole in the engine block and total engine failure. This created a serious safety risk due to sudden loss of power and fire hazard. I then had the vehicle inspected by a second Kia dealership. They informed me that the engine failure was consistent with the defect described in recall 25V099 (piston oil ring failure) and that the prior recall repair did not correct the underlying issue. This indicates that the recall remedy performed on my vehicle was incomplete or ineffective, and that the vehicle was returned to me in an unsafe condition. I am concerned that other vehicles may be receiving only software updates without proper inspection or repair, which could lead to similar dangerous failures. I am requesting that this situation be investigated as a failed recall remedy and a continued safety risk. Timeline: 3/17/26: Recall repair performed (software update only) 3/29/26: Engine failed catastrophically 4/2/26: Second dealership confirmed failure related to recall defect

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Hi my vehicle was stolen and the police found the vehicle. The car was damaged part of the damages was a broken ignition. I am unable to fix the damages until I get paid from the kia classaction lawsuit. The car still starts and stays running. I have the key for the car but I have been starting the car was butter knife bc it's easier then the key. I made an appointment to have the oil piston ring looked at. When I brought it I. They refused to look at it bc it has a broken ignition. I don't think the safety recall has anything to do w the ignition. The car is easy to turn on and shut off. I wouldn't care if my car wasn't stalling at traffic lights. My car is going thru a lot of oil. I am not working currently. This car was purchased for me by my dad. He paid cash for it. He bought it bc I had just been diagnosed w a rare autoimmune disease. He bought it so I would have something safe and reliable to drive in. We have had nothing g but problems since day 1. All I wanted was for them to look at it so im not going to be in harms way. Idk what to do the dealership said they cant look at it until I fixed the ignition. But like I said I won't have money to do that until I get the class action lawsuit.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Manufacturer defect: Massive paint delamination/adhesion failure on the roof. Large sheets of paint are flaking off while the vehicle is in motion, creating a debris hazard for following drivers and distracting the operator. The failure has exposed the bare metal structure, which may lead to premature rusting.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Kia Soul. The contact stated that while driving approximately 80 MPH, the vehicle unexpectedly stalled, with the check engine warning light illuminated. The vehicle was restarted; however, the failure reoccurred. The contact stated that while driving uphill, the vehicle failed to accelerate as needed. The vehicle was taken to the dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and case was opened. The approximate failure mileage was 41,000. The VIN was not available.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Mi carro hay veces que prende la luz de la engine, lo lleve a checar y salió en la computadora que era un problema de Power Train system, que era secondary DTCs P1C28 Y P1C28000, lo busque en Google y salía que era un problema muy recurrente en Kias souls y sorentos. Que podría causar incendios

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

I am writing to formally report a failure by Classic Kia of Streetsboro to provide the federally mandated safety remedy under Recall SC336 for my 2021 Kia Soul (VIN: [XXX] ). I have reason to believe the dealership has bypassed the mandatory safety protocols by intentionally omitting my documented diagnostic data—specifically Codes P0014/P0017, engine stalling, and excessive oil consumption—from the Techline Case Narrative. Evidence of Non-Compliance: 1. Improper Component Installation: Despite the documented timing failures, the dealership appears to have installed a Short Block (Part # 21102) instead of the required Long Block Assembly (Part # 21101-QQK). This leaves my oil-contaminated camshafts, valves, and VVT solenoids in the vehicle, posing a continued stalling risk. 2. Failure to Address Consequential Damage: The dealership is attempting to charge me a $99 "Customer Pay" fee for a catalytic converter back-pressure test. Under SC336, testing for consequential damage caused by a defective engine is the manufacturer's responsibility. 3. Withholding Documentation: The dealership has refused to provide the Techline Case Number or the Engine Part Number upon request, preventing me from verifying that the safety remedy was performed correctly. I will not be taking possession of the vehicle until Kia Corporate verifies that a Long Block Assembly was installed and that all diagnostic fees related to the recall symptoms are waived. This matter is currently being escalated but could definitely use your assistance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

NHTSA SAFETY COMPLAINT: RECALL SC336 (CAMPAIGN 21V-301) NON-COMPLIANCE VIN: [XXX] I. PATTERN OF RECALL EVASION Vehicle (2021 Kia Soul) was towed to Classic Kia [XXX] ) on 3/13 with documented engine stalling, knocking, and codes P0014/P0017 (VVT/Timing failure). The dealership withheld this data from Kia Techline for 13 days (3/13–3/26), delaying the safety remedy until state authorities intervened. II. MECHANICAL IMPOSSIBILITY & REMEDY VIOLATION On Saturday 3/28, the dealer claimed a full engine swap was "installed and tested" in only 6.5 hours (7:30 AM–2:15 PM). Per the SC336 mandate, a compliant Long Block assembly (Part # ending in QQK) requires extensive fluid flushes, software reflashing, and safety recalibrations that cannot be performed correctly in this window. I suspect a "Short Block" shortcut was taken, reusing contaminated components in violation of the federal safety remedy. III. FRAUD BY OMISSION & UNIFIED SAFETY HAZARD The dealership is demanding a $99 "diagnostic fee" for an exhaust back-pressure test. Under SC336, testing for "consequential damage" (clogged catalytic converter) caused by the recall defect must be covered by the manufacturer. By omitting the stalling/timing symptoms from the initial Techline report, the dealer bypassed the mandatory exhaust safety testing. Reusing oil-contaminated VVT solenoids, camshafts, and valves from the failed engine poses an immediate fire and safety hazard. IV. DEMAND FOR INVESTIGATION I request NHTSA oversight to ensure Classic Kia provides: 1. Proof of Long Block (21101-QQK) installation vs. unauthorized Short Block (21102). 2. Time-stamped DEVT and GDS Full System Scan logs from 3/28. 3. Verification that all contaminated components were replaced, as a partial remedy leaves the vehicle in a hazardous state. Reusing oil-soaked VVT/cams & skipping exhaust tests creates a fire risk. An incomplete remedy violates SC336, leaving the car a high-risk liability for fire & stalling. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Kia Soul. The contact stated that while driving at an undisclosed speed, there was an abnormally loud sound coming from the vehicle with the check engine warning light illuminated. The vehicle idled abnormally rough, and the engine was pulsing. The oil level was checked and was noticeably low. The contact added oil to the engine. The vehicle was taken to Precision Auto Care for an oil change. The contact was informed that the oil level was low. The contact informed the technician that the oil had been recently topped off. The contact was informed of the excessive oil consumption. The contact was provided with information on NHTSA Campaign Number: 25V099000 (Engine and Engine Cooling). The vehicle was taken to the dealer, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced or repaired before the recall repair could be performed. The vehicle was not yet repaired. The manufacturer was made aware of the failure, and a case was filed. In addition, the contact was informed that the vehicle had to be repaired before the recall repair was performed. The failure mileage was approximately 134,431.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Kia Soul. The contact stated that while driving approximately 40 MPH, the vehicle started losing automotive power. The message that the engine was overheating warning was flashing on the instrument panel with an audible chime. The contact pulled over but was unable to restart the vehicle. The vehicle was towed to a local dealer and was diagnosed with engine failure. The contact stated that the VIN was included in NHTSA Campaign Number: 25V099000 (Engine and Engine Cooling); and was advised by the dealer that the engine failure was not related to the recall, and the dealer refused to perform the recall repair. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was unknown.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

My 2021 Kia Soul is exhibiting a severe safety defect documented in Recall SC336: frequent, unpredictable stalling in traffic ("Loss of Motive Power") and audible engine knocking. These symptoms create a high risk of a rear-end collision or being stranded in a dangerous traffic situation. The vehicle is currently at Kia of Streetsboro. Despite being provided with evidence of these active mechanical failures, the dealership is attempting to "remedy" the safety recall based solely on a "Pass" result from the Piston Ring Noise Sensing System (PNSS) software diagnostic. As the TSB SC336 notes that the root cause is physical damage to cylinder walls caused by defective piston oil rings, a software diagnostic "Pass" is not a physical repair and does not address the existing mechanical stalling. I have not received any status updates or communication from the dealership service department since Friday. The dealership is refusing to perform a borescope inspection or open a Kia Techline case to investigate the stalling, effectively denying a proper safety remedy. I am reporting this as a failure of the manufacturer and dealership to provide a safe and effective remedy for a known life-safety defect. The car remains unsafe to drive.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

DEALER ADMISSION OF NON-COMPLIANCE: I am updating my complaint to document that Kia of Streetsboro is officially refusing to perform the mandatory mechanical inspection required by Recall SC336. Despite the vehicle suffering from "Loss of Motive Power" (stalling in traffic) and "Abnormal Engine Noise," the dealership’s service department stated via text on March 17: "I asked my manager and he said as of right now since your vehicle passed the tablet we cannot do anything else." The dealer further stated: "I suggest calling consumer affairs since you have an open case and letting them know what's going on and seeing if they can help." TECHNICAL VIOLATION: The dealer’s refusal based on a "tablet pass" is a direct violation of TSB SC336, Step 18c, which states that if a vehicle exhibits mechanical symptoms that "contradict a PASS result," the dealer MUST open a Techline Case for further instructions. By their own admission, the dealer is choosing to follow a "manager’s" opinion rather than the Federal Recall Protocol. They are attempting to release a vehicle that is actively stalling at intersections, which they define as an "Early Warning" system success, while ignoring the actual mechanical failure (the stalling). SAFETY RISK: This is a documented Ineffective Remedy. The dealer is punting the safety diagnosis to a "Consumer Affairs" call center rather than performing the borescope and Techline escalation required by the NHTSA. I am reporting this dealer for knowingly attempting to return a stalling, unsafe vehicle to a consumer while claiming the recall is complete.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

My car experienced engine stall, fire risk, and piston ring failure while returning from a family road trip. Myself, my son, [XXX] old, and [XXX] pup was left in a ditch on a very busy road as the car stalled while driving. My VIN is excluded, however car experienced exact symptoms of recall SC2091. Codes P0300 P0304 P0302 P219D P0303 with no pressure in cylinder 2 and 4.This happened in 0ct 2025 and dealership and corporate do not want to exend goodwill to replace the engine. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Mar 2026

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

1. Component or System Malfunction Engine (internal piston/piston ring system) is malfunctioning. The vehicle exhibits clanking noises (“marbles in a can”) and cuts off or stalls unexpectedly while driving. The car is available for inspection by a Kia dealer or independent mechanic. 2. Safety Risk Vehicle loses power while driving, which is extremely dangerous, particularly on highways or in traffic. Stalling while moving poses a risk of collision, loss of steering or braking control, and endangers both driver and others. This makes the vehicle unsafe to drive long distances. 3. Reproduction of Problem Symptoms have been observed consistently during normal driving and acceleration. Not yet confirmed by a dealer, but the stalling is reproducible during operation. 4. Vehicle Inspection The vehicle has not yet been inspected by the manufacturer, dealer, police, or insurance representatives. Immediate inspection is recommended due to engine stall risk. 5. Warning Lamps / Symptoms Clanking engine noise noted prior to stalling. Engine cutting off/stalling occurs while driving. No warning lights illuminated prior to stalling. Symptoms first appeared during recent driving prior to planning transport or repair. 6. Additional Notes The vehicle is a candidate for Kia engine piston/piston ring recall (SC209 / SC336). Owner recommends urgent inspection and repair to prevent potential engine failure and safety risks.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

I am filing this complaint to report a serious safety failure involving the service braking system and the failure of Forward Collision‑Avoidance Assist (FCA) and Automatic Emergency Braking (AEB) on my 2021 Kia Soul. During an imminent collision event, the vehicle failed to brake as expected, and FCA/AEB did not activate, despite conditions that should have triggered emergency braking. This created an extremely dangerous situation and placed me and other motorists at risk of serious injury or death. The vehicle is currently subject to an active recall and has now been inoperable at the dealership for approximately one month under the lemon law process. The failure involved federally regulated safety systems, not supplemental or convenience features. I reported this incident to Kia America Customer Care, but the manufacturer has declined to conduct a manufacturer‑level safety investigation unless I personally pay for removal and shipment of the ACU/Event Data Recorder (EDR). Kia America has also declined to provide any transportation assistance while the vehicle remains unsafe and inoperable and has referred the matter back to the dealership and my insurance instead. Kia America has stated in writing that they rely solely on dealerships for diagnosis and repair and that they will not investigate further unless I incur additional costs. This refusal to independently investigate a braking system failure raises serious safety concerns, particularly given the potential risk to other drivers if this defect is not addressed. Due to the prolonged loss of use of the vehicle, I am experiencing significant financial hardship and risk to my employment, as I can no longer afford a rental vehicle. I am submitting this complaint so that NHTSA is aware of a potential defect involving brake system failure and non‑functioning collision‑avoidance systems on this model.

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

Crash

Vehicle consistently stalls at complete stops in traffic. After the engine stalls, it requires a manual restart to resume operation. This creates a severe safety hazard, as the vehicle becomes immobile at intersections and in stop-and-go traffic, increasing the risk of a rear-end collision. The dealership is refusing to perform the necessary diagnostic for the engine stalling issue under the Havis v. Kia Settlement/KSDS recall protocols, claiming maintenance gaps, despite the vehicle having 0 open campaigns and the KSDS software update previously installed. This stalling issue is a known defect currently under NHTSA investigation (Audit Query AQ23-001) for this specific model and engine.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Check engine light on due to catalytic converter, took it to Kia motors in Bakersfield, California due to recall let them know that there was a check engine light on after buying the vehicle and only having it for one month and I thought it was due to the recall, which was on oil, piston rings, the dealership stated I could give all my paperwork that I had in regards to that, and if the engine failed, they would take care of it. After the test for the recall was done the engine failed and then a few days later a new updated recall, came out where the engine had to be running hot for the test to be done and then my recall passed so nothing was ever fixed with my vehicle. I believe that the catalytic converter is bad due to oil running into or around the catalytic converter. I also believe due to the malfunction of the oil, piston rings being bad/malfunction or whatever the recall was on is a determination of why my check engine light is on stating it’s a catalytic converter I believe if I continue driving my vehicle in the condition that it’s in it eventually will catch fire due to the issue.

Reported

Mar 2026

Incident date

Jul 2024

Mileage

Not provided

Outcome flags

None reported

My 2021 Kia Soul is having the same piston issues leading to engine failure as other previously recalled Kia Soul vehicles but for some reason my VIN is not part of any recall. Now it has been determined there is heavy scoring in my engine and I will need a new engine. My car is only 5 years old and there should be no reason for such major engine damage. My car has stalled on me while driving and other very similar issues as described on previous recalls. How does NHTSA determine when a certain model/year of car needs to be part of a national recall?

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The entire car is dead from the engine to the key function completely dead. The car broke down 3 time in the middle of the street which could've caused a serious crash putting my safety and others at risk. The problem has been addressed to two different dealers and Kia corporate without resolution. I did make a police report about the mold infestation inside the car. I did now see any warnings prior to the complete reck. The cars been dead from the past 3 months. Both dealers are refusing and/or delaying any type of resolution in fact they gave me even more pressure. Causing me more anxiety than tranquility. Elevating my emotional health.

Reported

Feb 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Kia Soul. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated, and the engine seized. The contact stated that nearby drivers assisted with pushing the vehicle to the shoulder of the roadway. The failure had occurred while driving on a busy highway. While attempting to restart the vehicle, the vehicle started; however, it was unsafe to drive the vehicle. The vehicle was towed to the dealer, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. Prior to the engine seizing, the vehicle was consuming an excessive amount of engine oil. The contact stated that 3 to 4 quarts of oil needed to be added between oil changes. In addition, the contact stated that in 2021, the vehicle was repaired under NHTSA Campaign Number: 21V259000 (Engine). The contact stated that after the recall repair was performed, the excessive oil consumption started. The manufacturer was not made aware of the failure. The failure mileage was approximately 88,200.

Reported

Feb 2026

Incident date

Feb 2024

Mileage

Not provided

Outcome flags

None reported

Description of Incident: On February 13, 2026, at approximately 3:00 PM, I was driving my 2021 Kia Soul (VIN: [XXX] ) on Calvine Road in Elk Grove, CA. A vehicle suddenly merged into my path. I immediately attempted to apply the brakes, but the pedal failed to depress or engage normally. Despite the imminent collision, the Forward Collision-Avoidance Assist (FCA) failed to provide any alert, and the Automatic Emergency Braking (AEB) system did not activate. To avoid a high-speed rear-end collision, I was forced to perform an emergency steering maneuver toward the curb and into roadside bushes to stop the vehicle. This maneuver resulted in severe mechanical failure, including a broken driver-side axle, damaged rims, and broken brake pads. The dealership (Elk Grove Kia) has provided an estimate of $9,461.67 for these repairs but has failed to explain why the primary safety systems and service brakes failed to function as designed during this emergency. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

Crash

We are the 2nd owner of 2021 Kia Soul bought in July 2025. Took to a dealership for open recalls shortly after purchase. After supposedly passing the piston ring recall (NHTSA 21V259) for the next several months after it had severe oil consumption but other wise drove fine. Then immediately after our last oil change on Feb 13, 2026, less than 10 miles later the car stalled and was knocking badly. Towed to nearest dealership and after diagnostic was told engine needs replacing. Wants us to pay for it. The software update (Piston Ring Noise Sensing System or PNSS) installed during the recall visit did not fix the faulty piston rings and also failed to give any warning for the impending engine failure. We never had any check engine or oil pressure lights come on until this incident.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

Description of Incident: On February 9, 2026, at approximately 3:00 PM, I was driving my 2021 Kia Soul on Calvine Road and Winterberry in Elk Grove, CA. A vehicle suddenly merged into my path. I immediately attempted to apply the brakes, but the pedal failed to depress or engage normally. Despite the imminent collision, the Forward Collision-Avoidance Assist (FCA) failed to provide any alert, and the Automatic Emergency Braking (AEB) system did not activate. To avoid a high-speed, rear-end collision, I was forced to perform an emergency steering maneuver toward the curb and into roadside bushes to stop the vehicle. This maneuver resulted in severe mechanical failure, including a broken driver-side axle, damaged rims, and broken brake pads. The dealership (Elk Grove Kia) has provided an estimate of $9,461.67 for these repairs but has failed to explain why the primary safety systems and service brakes failed to function as designed during this emergency.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

Crash

Kia Motors America (Kia) is recalling certain 2020-2021 Soul, and 2021 Seltos vehicles equipped with 2.0L Nu MPI engines. The piston oil rings may not have been properly heat-treated, which may result in engine damage.

Risk: A damaged engine may stall, increasing the risk of a crash. In addition, oil may leak onto hot exhaust components, increasing the risk of a fire.

Remedy: Kia will notify owners, and dealers will inspect and, if necessary, replace the engine, free of charge. In addition, Kia will deploy Piston Ring Noise Sensing System (PNSS) software. The recall began June 11, 2021. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC209.

Kia America, Inc. (Kia) is recalling certain 2021-2023 Seltos and Soul vehicles. The piston oil rings may have been manufactured incorrectly, which can result in engine damage.

Risk: Engine damage can cause a vehicle stall or fire, increasing the risk of a crash or injury.

Remedy: Dealers will inspect and replace the engine as necessary, free of charge. Dealers will also install piston-ring noise sensing system (PNSS) software, free of charge. Owner notification letters were mailed April 4, 2025. Owners may contact Kia customer service at 800-333-4542. Kia's number for this recall is SC336.