2016 Kia Soul

Check engine light came on and car was out of oil even though an oil change was done about a month ago. Catalytic converter was replaced once already. Per mechanic excess heat caused out to leak catalytic converter needs replacing again and now engine is damaged as all engine oil leaks out where it cannot be detected on ground. Danger of fire according to recall sc176 and mechanic. Car was smoking so it has been parked for safety to avoid fire

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Kia Soul. The contact stated that while the vehicle was parked, it was started, and there was smoke coming from the engine compartment. The vehicle was turned off to stop the smoking. The check engine warning light was illuminated. The vehicle was towed to a dealer, where it was diagnosed, and it was determined that the engine needed to be replaced. The vehicle was not repaired. The contact researched and became aware of an unknown recall; however, the VIN was not under recall. The manufacturer was not notified of the failure. The failure mileage was approximately 140,000.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

What component or system failed or malfunctioned, and is it available for inspection upon request? The vehicle is a 2016 Kia Soul 1.6L GDI with approximately 83,000 miles. The vehicle experienced engine performance issues, loss of power, and stalling. A Kia dealership diagnosed a failed/melted catalytic converter and reported metal shavings in the engine oil. The vehicle has not been repaired and is available for inspection upon request. How was your safety or the safety of others put at risk? The vehicle stalls and loses power, creating a safety hazard while driving in traffic. A sudden loss of power increases the risk of being struck by another vehicle and makes it difficult to safely maintain speed, merge, or cross intersections. Because the vehicle is unreliable and may stall unexpectedly, I do not consider it safe to operate. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The condition was confirmed by an authorized Kia dealership. The dealership diagnosed a clogged/melted catalytic converter and reported metal shavings in the engine oil. The dealership advised that the catalytic converter must be replaced before they would perform further engine diagnosis. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The vehicle was inspected by an authorized Kia dealership. Kia Customer Care was notified of the issue and reviewed the claim but declined assistance. To my knowledge, the vehicle has not been inspected by a Kia field engineer, police agency, or insurance investigator. Were there any warning lamps, messages, or other symptoms prior to the failure, and when did they first appear? Yes. The vehicle experienced drivability issues, loss of power, and check engine light illumination. Diagnostic trouble codes reported included P0420, P2191, and P2196. The symptoms progressively worsened and eventually resulted in severe performance issues and stalling.

Reported

Jun 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Kia Soul. The contact stated that while his wife was driving 35 MPH, the brakes became inoperable. The contact’s husband, who is an independent mechanic, inspected the vehicle and became aware that the brake fluid lines were rusted and ruptured underneath the middle of the vehicle. The contact stated that brake fluid was added but the brake pedal was mushy while depressed. The brake warning light was illuminated after the failure. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 40,000.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

AIR BAG

Reported

Jun 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

hello nhtsa i have a problem with my car. which kia soul plus with 83000 miles on it. It have check engine light blinks with code p1326 which is knock sensor recall. i went to kia dealer at federico kia at wood river illinois they replaced the knock sensor. it show up back in 6 miles. i took it back to the dealer.they hold the car for one week. they said you got denied of engine replacement due to lack of maintenence. it have sevice records on carfax.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

We would like to file a complaint and request a recall so that Kia Corporation is responsible to pay for a new paint job on our vehicle, 2016 Kia Soul. With Kia Corp, paint is covered under warranty for 3 years, however a customer would not know there is a paint adhesion problem within the first 3 years. The problem - Our paint is peeling off of the vehicle and started out of nowhere, no rock chip...nothing. It started as a bubble on the side of our vehicle and that bubble broke open and began peeling. We also have areas SEPARATE from the original area that just randomly flaked off with no bubble...just started peeling from the edges of the window, especially on top of the roof. No matter where it starts (and it continues to do so), it peels on its own. We have a white Kia and white (amongst a few other colors) seems to be an issue from KIA's manufacturer. Kia knows it. It seems the mfg used the incorrect paint adhesion product from the beginning, therefore it is peeling off. We've never seen anything like it. We currently have 77K miles on the car, but this started a year ago. We just had no idea this first, tiny area would turn into the entire car's paint peeling off. This is a manufacturing issue. The vehicle peels to the gray level first and then to a mustard color, so we are down to the original metal. This is all without us touching it at all. It peels ON ITS OWN. I have called Kia customer care to see what is wrong with the Kia Soul. The first time, KIA's customer care rep did not log it as a case number, so there is no record of my call. The 2nd time, calling on 6/15/26, I had to request to file a complaint so that a case number was created. I am now filing a complaint with NHTSA. Please see photos. Thank you for your consideration, [XXX] and [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jun 2026

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

UNKNOWN. See my statement below. I also have pictures I will upload. My vehicle is suffering from Severe factory paint and clear coat delamination on the vehicle's flat surfaces (hood and roof and now starting on the door handles and mirrors), resulting in total material deterioration down to the bare primer and exposed underlying metal sheet. This vehicle has been driven only 63,000 miles, has been impeccably serviced entirely at authorized Kia dealerships on schedule, and has suffered no accidents or body modifications. The factory finish has completely dissolved, exposing the bare structural metal of the roof and hood to rain and heavy humidity. This structural exposure presents an imminent safety risk of premature body panel corrosion, structural rust degradation, and potential panel perforation, which will compromise the structural integrity of the cabin and roof in a collision. Furthermore, this clear coat failure has been visually documented on multiple identical 2016 Caribbean Blue models in my immediate geographic area, confirming a widespread chemical bonding defect at the manufacturing plant. I have color photos I will uplaod of my vehicle sitting next to an identical 2016 Kia Soul, the same paint color, that has the same paint issues. That's when I first realized this must be a factory issue when the vehicle was manufactured. I have since discoverd many customers complaining on the Internet about the same issues with their 2016 Kias, proving once again this was an issue that happened at the factory but was never recalled by Kia North Amercia. I am in the process of writing Kia North America requesting a Goodwill paint job for my vehicle. I will be including all service records, vehicle registation, numerous color photos of the vehicle as well as a copy of the original sticker on the vehicle when I purchased it new. I am requesting that the NHTSA you open a case concerting my issue.

Reported

Jun 2026

Incident date

May 2024

Mileage

Not provided

Outcome flags

None reported

My 2016 Kia Soul (1.6L GDI engine) experienced a catastrophic, sudden engine failure while driving, preceded by Check Engine Light code P0420 (Catalyst System Efficiency Below Threshold). This exact failure sequence is the precise subject of active NHTSA Safety Recall Campaign 19V120 (Kia Campaign SC176).Although the vehicle received the mandated SC176 preventative software update in 2019, the underlying mechanical defect was not cured. High exhaust gas temperatures caused the catalytic converter to degrade and fracture internally. The fractured abrasive substrate particles were then siphoned backward into the engine combustion chamber during normal valve operation. This caused immediate, severe scoring of the cylinder walls and piston damage, leading to total engine seizure and failure. This defect presents an extreme safety risk. Sudden engine failure at highway speeds causes an immediate loss of motive power, braking assistance, and power steering, significantly increasing the risk of a high-speed collision. Furthermore, fractured connecting rods or oil leakage stemming from this specific engine failure pose a severe vehicle fire hazard. The vehicle is currently held for diagnostic verification at Kia Riverside in California. I am filing this complaint because the manufacturer's 2019 software remedy was entirely ineffective at preventing the mechanical destruction of the engine and catalytic converter. I am requesting that the NHTSA hold Kia accountable to fulfill the physical repair and replacement mandates of Recall SC176 at zero cost to the consumer, regardless of the prior software logging.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The vehicle is burning oil. It creates residue in my engine which may make it dangerous to drive and ruin the catalytic converter, among other issues. I was first notified of this problem during my second oil change in 01/2026 at a Kwik Kar Lube & Tune, about 6 months after purchasing the vehicle in 06/2025. As of 05/2026, an oil warning lamp began to appear on the vehicle dashboard to notify me that the oil was low. I checked the oil stick, and there was burnt oil, albeit very little of it. I had gotten a full synthetic oil change, so it was not yet time to change my oil, but clearly this issue is causing premature oil loss.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Kia Soul. The contact stated that while driving at various speeds the vehicle suddenly stalled. During the failure the odor of fuel was present. The failure had occurred on several occasions. The vehicle was towed to an independent mechanic who diagnosed that catalytic converter and damaged exhaust muffler. The vehicle was not repaired. The manufacturer and local dealer were not contacted. The contact indicated that the catalytic converter was previously replaced but the failure had reoccurred. The failure mileage was 120,786

Reported

May 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Kia Soul. The contact stated that while driving at an undisclosed speed, the engine oil warning light illuminated. The contact pulled over and inspected the vehicle. The contact discovered that there was no oil in the engine; however, the vehicle previously had an oil change. The contact added oil to the engine. The failure persisted. Additionally, the vehicle made rattling sounds and emitted a burning oil odor. The brake pedal had to be firmly depressed to stop the vehicle, the windows inadvertently rolled down, and the interior lights intermittently failed due to an electrical system failure. The vehicle was taken to the dealer, who determined that the timing cover needed to be resealed and the brake master cylinder, oil pan gasket, brake fluid, spark plugs, ABS, and window master switch needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 19V120000 (Engine, Engine And Engine Cooling); however, the VIN was not included in the recall. The manufacturer was made aware of the failure. The failure mileage was approximately 80,000.

Reported

May 2026

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

I reported to Kia regarding 2016 KIA Soul EV electronic gear shift and power system as follows. "I am writing to formally report a serious safety concern regarding the electronic gear shift and power system on my Kia Soul EV. I have experienced several dangerous incidents involving the vehicle's behavior when parking on an incline. Specifically, if the vehicle is parked on a slope and the power switch is turned off while the gear selector is still in 'Drive' (D), the control power shuts down immediately, and the vehicle begins to roll down the hill because it does not automatically engage 'Park' (P) or the electronic parking brake. While I understand the importance of manually selecting 'Park,' it is common for electronic shifters in modern EVs to automatically shift to 'Park' or engage a safety brake when the power is turned off to prevent such hazardous rolling. The current logic poses a significant safety risk to the driver, passengers, and bystanders. I would like to know if there is a software update available to address this logic or if Kia has a recommended safety protocol to mitigate this risk. I look forward to your prompt response regarding this matter." and received email from KIA "After reviewing your concern, we can confirm that at this time there are no updates, recalls, or service campaigns related to the parking logic or automatic engagement of Park or the parking brake for the condition you described. We recommend reviewing the Parking Brake section of your Owner’s Manual (Section 5, Page 25), which outlines the designed operation and proper procedures when parking the vehicle, particularly on an incline." Please review this case and find resolutions for this safety issues. Thank you

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

sudden reduced acceleration / limp mode while driving P1326 knock code potential engine failure / loss of power

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Kia Soul. The contact stated that an abnormal, knocking sound would emit upon depression of the accelerator pedal as a check engine light appeared on the instrument panel. The vehicle was initially taken to an independent mechanic where the diagnosed the vehicle with a defective rod knock sensor; he was then advised to no longer operate the vehicle. The vehicle was later towed to a dealer where they discovered that engine rod#4 had become defective which led to engine failure. Upon investigation, the contact discovered NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling) which he linked to his failure. The manufacturer was then notified of the failure and the contact was informed that the vehicle was already serviced for the recall prior to him owning the vehicle. The vehicle was not repaired and remained in his possession. The failure mileage was approximately 90,000.

Reported

May 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

I am reporting a safety concern related to NHTSA Recall 19V120 involving my Kia Soul. The recall identifies a defect related to catalytic converter overheating, which can lead to engine damage, stalling, and increased risk of fire. My vehicle is currently experiencing an illuminated check engine light and unsafe driving conditions. During service evaluation at Kia of Columbus, I was informed that my vehicle has a catalytic converter blockage contributing to these issues. However, I was also told that my vehicle does not qualify for recall repair because no engine code was detected during diagnostics. This is concerning, as the vehicle is actively exhibiting symptoms consistent with the recall condition, including a confirmed catalytic converter issue and an illuminated malfunction indicator lamp. Despite this, I was denied full recall coverage and instead offered a goodwill repair requiring me to pay 50% of the cost. I believe this situation represents a failure to properly apply recall criteria and raises concerns regarding customer safety, as the vehicle may be at risk for engine failure or fire. I am requesting further review of this matter and investigation into the handling of this recall by the servicing dealership.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Kia Soul. The contact stated that while driving at 55 MPH, the check engine warning light illuminated, and the vehicle stalled. Upon further research, the contact associated the failure with NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling). The vehicle was taken to an independent mechanic who determined that the catalytic converter needed to be replaced. The mechanic informed the contact that the inside of the catalytic converter had melted, but there was no fire. The vehicle was repaired, but the failure reoccurred. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 105,000.

Reported

Apr 2026

Incident date

Aug 2024

Mileage

Not provided

Outcome flags

None reported

I just bought the car one month ago, and While driving my 2016 Kia Soul on a high-speed highway at approximately 98,000 miles, the vehicle suddenly lost power without warning. The engine stopped responding and the car could not accelerate. This created a very dangerous situation because traffic was moving at high speed and I was at risk of being hit from behind. I was driving with my son, who has a disability, and I was taking him to his therapy appointment. The sudden loss of power made the situation even more stressful and unsafe because I was responsible for his safety while the vehicle was failing in traffic. Fortunately, I was able to carefully move out of the main highway and exit the road to avoid a crash. I managed to reach a nearby auto mechanic shop, where the vehicle had to remain because the engine had failed and the car could no longer be driven safely. This incident represents a serious safety concern because the vehicle lost power suddenly while driving on a fast highway, which could easily have resulted in a serious accident.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

I had the oil changed on my car at a local tire and lube shop. Two weeks later I drove to Vegas (7 hrs one way). While in Vegas I started to hear a super faint clicking noise coming from under my hood, but no lights came on inside, so I assumed maybe it was nothing serious and would have it checked when I returned home 3 days later. On the way home (2 hrs from home) the clicking got louder. I attempted to pass some cars and, as I accelerated, the clicking got much louder and then I heard a loud clank and the car shuttered. I proceeded to pull over and got out of the car and saw small flames and smoke coming from under my car. A couple had pulled over with me and had a fire extinguisher which they used to put the fire out. Upon towing the car home I found a piece of metal hanging from a melted piece of plastic. I inspected it and discovered that it was a piece of a piston from my engine. There was also a puddle of oil and a streak of gasoline on the trailer that had come from my car. I experienced catastrophic engine failure. When the engine broke it punched a hole in my oil pan which caused a fire and burned a hole in my fuel line. I am unsure of what caused the engine to fail, but in seeing the recalls for the exact same thing happening to previously recalled Kia Souls I figured i'd check it out to see if I may be included in that. No lights came on alerting me to any problems. There were no signs of leaking oil. Just clicking that got louder and then a loud noise and shudder and fire.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

Fire

Complaint Summary: Post recall catalytic converter failure on 2016 Kia Soul with 1.6L GDI engine (SC176 recall previously performed). Complaint Details: I own a 2016 Kia Soul equipped with the 1.6 liter Gamma GDI engine (engine code G4FD, emissions family GKMXV01.6DBE). This engine is part of Kia’s SC176 recall for catalytic converter overheating and thermal damage. My dealer performed the SC176 ECU software update in May 2019, but did not replace the catalytic converter at that time because the P0420 code had not yet appeared. In early 2026, my catalytic converter failed with a P0420 “Catalyst Efficiency Below Threshold” code. My mechanic confirmed the converter was internally damaged. This failure is consistent with the known SC176 defect, where converters can be partially damaged before the ECU update and fail later. Kia and the dealer refused to replace the converter under the recall, stating that because the P0420 code did not appear in 2019, the converter is no longer covered. I was forced to pay $2,781.91 out of pocket for a new catalytic converter, exhaust manifold, and oxygen sensors. The diagnostic test was another $120 plus tax. This appears to be a case where the converter was already compromised by the SC176 defect prior to the software update, but the failure occurred later. I am requesting that NHTSA document this issue, as it suggests the recall remedy may not fully address pre existing catalyst damage and may leave owners with significant repair costs. VIN: [XXX] Mileage at failure: ~90,000 miles Engine: 1.6L Gamma GDI (G4FD) Recall: SC176 (ECU update performed, converter not replaced) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

I kept all of the maintenance records for the oil changes. The engine blew a piston and I will need a new engine. Driving down the road, it just lost power and died. Local mechanic looked at it and said I needed a new engine. When I began looking for a new engine, the cost would have been $3500.00 plus labor. When looking for a used engine, the salvage person said there was a recall on the engines. I took it to the local dealer, said I was over the mileage. and would probably cost the dealer $9000.00. The car is almost 10 years old. It was a good car. It was a standard, which should mad it last longer.

Reported

Apr 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

March 22, 2026: driving through town when the engine started making an odd high pitched sound then lost all acceleration and had to get it towed back to my house. No indicator lights on the dashboard came on. March 26, 2026: my mechanic diagnosed it as a catalytic converter clog. 2019: vehicle was serviced at a Kia dealer for SC176 recall relating to catalytic converter failure. December 2022: Kia replaced the engine due to failure from metal shavings from the tie rod getting into the oil. In 2024 kia reimbursed me for the cost of this replacement due to a class action lawsuit for this issue. March 30, 2026: both Kia dealership and Kia phone line advised that my vehicle no longer qualifies for catalytic converter replacement since the recall service was completed in 2019.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The contact owned a 2016 Kia Soul. The contact received notification of NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling). The contact stated that while driving at an undisclosed speed, the vehicle lost motive power and the engine made an abnormal sound. The contact turned off the vehicle to let it cool down. The vehicle was restarted and taken to an independent mechanic, who determined that the catalytic converter and exhaust pipe had caught fire and melted. The mechanic performed an oil change and drilled a hole in the catalytic converter, and advised the contact to take the vehicle to the dealer for the recall repair. The vehicle was taken to the dealer, who determined that the spark plugs were saturated in engine oil. The dealer flushed the radiator and performed a second oil change; however, the dealer refused to perform the recall repair. The vehicle was taken back to the independent mechanic, who replaced the spark plugs but refused to repair the engine until the recall was repaired. The contact stated that later while coasting downhill in neutral (N) after adding a quart of engine oil due to no oil in the engine, he heard an implosion coming from behind the driver's side front seat. No warning light was illuminated. The contact unbuckled his seat belt and jumped out of the vehicle, fracturing his ribs. The contact suffered burns to his right hand, legs, left side of face, nose, and eyebrows. The contact stated that the vehicle rolled downhill, and there were flames underneath the vehicle on the passenger's side. The contact ran after the vehicle. The vehicle drove into the bushes and came to a stop. Two bystanders alerted the contact that there were flames inside the vehicle. The police were called and arrived, attempting to extinguish the fire with an extinguisher until it was empty, and the fire had restarted. The firefighters arrived and extinguished the fire. A police report was filed and included with the fire department. The contact was transported to the hospital via ambulance and received medical attention. The vehicle was towed to the tow yard, where it was totaled by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was approximately 79,000.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

Fire 1 injuries

Car only goes 20 mph Engine knock Unsafe to drive I have multiple service repair documentation regarding engine knocking, oil consumption, unable to go above 20 mph. Car frequently goes into limp mode

Reported

Mar 2026

Incident date

Aug 2023

Mileage

Not provided

Outcome flags

None reported

Safety defect P1326 code is a known indicator of rod bearing wear. When it triggered, the vehicle immediately went into Limp Mode, creating a significant safety hazard. The behavior aligns with the documented defect affecting NU GDI Engines and is not consistent with normal Engine wear. I have confirmed the KSDS software update was performed. I have taken the vehicle to Clay Cooley Kia of Plano and my service advisor has confirmed that the engine is defected per the NU GDI Engine Settlement and related federal safety actions.

Reported

Mar 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

I can not gain speed. The dealership says it’s the catalytic converter and there is an active recall for this on Kia souls. They previously did recall work to my car but now the catalytic converters not showing as a recall

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Kia Soul. The contact stated that while driving at an undisclosed speed, the vehicle shut off while driving on a ramp, and the vehicle coasted to the side of the road. The vehicle lost automotive power and stalled in a high-traffic area, creating a safety risk. The vehicle was towed to an independent mechanic, where it was diagnosed, and the vehicle was associated with NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling). The dealer was not notified of the failure. The vehicle was repaired but the vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 120,000.

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

Vehicle paint(white) is peeling off 2016 Kia Soul

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

When car is turning a right, the car turns off. When car is parked & stearing isnt straight car wont turn on.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

Kia Soul 2016 white color. The factory paint is peeling off completely.

Reported

Feb 2026

Incident date

Oct 2024

Mileage

Not provided

Outcome flags

None reported

SUBJECT: Engine → Stall → Loss of power while driving: While driving normally, the vehicle began losing power and could not accelerate properly. The engine warning light illuminated and the vehicle repeatedly entered a reduced-power condition where it could barely maintain speed. The vehicle would stall while driving and then restart after sitting. This occurred multiple times over a period of time and progressively worsened. The engine also began consuming large amounts of oil between oil changes. Eventually the engine suffered catastrophic failure and would no longer run. A dealership later stated internal engine damage was present, including a failed valve and spark plug damage. The vehicle is currently at a dealership and available for inspection. The loss of power and stalling created a safety hazard because the vehicle could not maintain normal traffic speed and could have been struck by other vehicles. The problem was confirmed by a dealership service department. Warning lights were present prior to final failure and appeared during the loss of power events.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Kia Soul. The contact stated that while driving at an undisclosed speed, while making a right turn, the right turn signal blinked extremely fast. The contact stated that while making a left turn, the left turn signal blinked normally. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The dealer was made aware of the failure. The vehicle was scheduled for a diagnostic test. The manufacturer was not made aware of the failure. The failure mileage was approximately 73,000.

Reported

Feb 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

I have put my 3rd Catalytic Convertor on this car. It looses power going uphill. Which is not safe. Just had 3rd on replaced yesterday Feb. 9, 2026. The mechanic said there is too much oil going to the engine. Mechanic said next thing would be replacing the engine. Why does my 2016 not have a recall on the engine.

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

I paid almost 3,500 dollars and Kia kept my car two months and I’m still having transmission issues and now they are asking for service receipts. After I picked up my vehicle from the original transmission repair I was back in less than 7 days because transmission was roughly jumping in gear and shifting horribly with burning smell. The technician noticed the problem and immediately took my car to the back but they kept my car another 30 days saying that they did an update and now I’m stuck suffering with a struggling transmission. My mpg has drastically dropped on this vehicle to a 9.6 and that is not normal. I paid cash and Kia need to help me in any way. They are trying to wait until the 12,000 mile warranty runs out and leave me stuck and that’s not fair when I’ve been complaining since I picked up the car the second time but they won’t assist me now. My Vehicle experiences delayed transmission engagement, RPM increases without acceleration, hesitation, and loss of fuel economy. Dealer refuses diagnosis unless complete failure occurs. This creates unpredictable vehicle response and loss of power concerns. Transmission hard shifts and jerks violently during gear changes and acceleration, causing loss of smooth power delivery and unsafe vehicle behavior.

Reported

Feb 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The vehicle is suffering from excessive oil consumption (over 1 quart per 1,000 miles) and a recurring P0420 (Catalyst Efficiency) code. This is a documented precursor to catastrophic engine failure and engine compartment fire in the 2.oL Nu GDI engine. The engine's oil consumption is poisoning the catalytic converter, causing it to clog. This creates extreme exhaust backpressure, leading to sudden loss of motive power (stalling) while driving. This defect poses an unreasonable risk of a high-speed collision and fire if oil comes into contact with the hot exhaust manifold. Due to current extreme winter conditions (-20F with wind chill), a sudden engine stall or seizure creates a life-threatening emergency. I no longer feel safe operating this vehicle, as an engine failure in these temperatures could leave me stranded without heat in sub-zero weather.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

While driving on a road trip from Charleston, South Carolina to Florida in January of 2023 the factory installed catalytic converter failed (front facing) clogging the exhaust system and damaging the engine (engine now experiences blow by and pistons rings have been damaged). A recall for the overheating of the catalytic converter was marked as repaired before I bought the car. However, I believe that either the update was not done to the on-board computer or that a damaged catalytic converter was not replaced. This directly led to the subsequent failure in question and has since damaged my engine. At the time of the incident, an investigation of both catalytic converters revealed heavy sediment deposits and the core of the filtering component of the front facing unit had become so corroded that a chunck of it had broken loose and become lodged in the connecting hose that linked it to the rest of the exhaust system, leaving the entire system blocked. Because I bought the car used, I wasn't aware of the recall history at the time of purchase. Nor was I given a vehicle history report or receipts for any work that had previously been done. When I pulled a vehicle history report shortly after the incident I was unable to accertain what the actual repairs to the car were previous to my ownership, just that it had been taken to a Kia dealership for service with dates listed. The issues still remain and I am unable to afford the lengthy and very expensive repairs suggested by multiple mechanics to correct them. I also still owe money on the note as the result of having to deal with a predatory business to secure financing in the first place. I hate to think I was taken advantage of but I can't help but feel like the catalytic converter should have been changed during that previously marked recall repair and clearly wasn't. Please help me figure out what went wrong here and if possible help me remedy this situation, especially if there was indeed fraud involved. Thank you

Reported

Jan 2026

Incident date

Jan 2023

Mileage

Not provided

Outcome flags

None reported

Engine knock engine failure

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

They have a recall on the catalytic converters for the 1.6 engines but not the 2.0. I have had to have mine replaced two times in a year. There is definitely a problem. The second time it almost caught fire due to glowing red cause it got so hot. The same problem is happening to the 2.0 engines just like the 1.6 engines, but nothing is being done.

Reported

Jan 2026

Incident date

Feb 2025

Mileage

Not provided

Outcome flags

None reported

The Instrument Cluster, the Speedometer and "NOW" the Odometer are not working--absolutely dead. "NOW" is in caps because to my surprise I noticed just recently that the Odometer is not working. In April 2021, after several weeks of waiting for the repairs to be finished, a Kia dealer, PEAK KIA in Colorado replaced the Instrument Cluster because of the faulty Speedometer. (This repair was done after several months of back and forth to more than one Kia Dealer about this problem. Unlike now where the Speedometer is dead, not moving at all, at that time it would stop working periodically, perhaps when my car was cold or not. It took several months of dealing with Kia dealerships to acknowledge that it was a problem.) Right after the replacement in 2021, I texted the PEAK KIA mechanics-representative, named Trevor, that it was still a problem, not working every now and then. He replied in a text "What?" and that he would check with his technician. He never got back to me with an answer, and would not return my phone calls.) Since that time, I've been dealing with this infrequent or sometimes-problem. Note, I work from home so I do not drive my car every day, only once or twice a week. However, just recently before and around the holidays, I noticed first that the Speedometer was dead, the needle was not moving at all during the entire time of driving, instead of every now and then. And closer to the holidays, I was shocked, noticing that the Odometer was NOW not moving. This had never been the case before. To date, I only have a Powertrain Warranty(?) left that expires in December 2028. I called Kia, the manufacturer, the other day and reported the above information. They said too bad, they will not cover it because the warranty for that 2021 repair expired 12 months after the repair, something I did not know. My concern is whether the Kia Dealer, Arapahoe Kia--where I usually go , will or should cover it. Plus, I feel this is a serious safety issue.

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

I went into the store come out of the store and got in the driver seat shut my door and the rear windshield exploded. I looked it up online and there are other customer complaints of the Kia soul with the same issue of the rear window exploding I called Kia and they told me even if the warranty was still good on my vehicle that it would have to go under inspection and it still would be an if he situation because other factors could be making the windshield explode Kia was unhelpful rude and did not want to help with the problem

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Greetings, I have a base 2016 kia soul manual transmission that I thought was under safety recall for its engine, but when I search it says 0 unrepaired recalls, when I look this up it does claim my vehicle had this problem, but I never had a dealer fix it, I did contact the one I got it from a couple of years ago and asked if my vehicle qualified for the recall since it already has 200,000 miles on it but they never got back to me, did they just claim to fix it, because it has not been worked on. Still runs great at 300,000 miles but if the engine has a safety issue that might catch on fire then I want to get it addressed regardless of its high mileage

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

A. Safety Defect and Failure Sequence I am filing this complaint because my Kia Soul, which is subject to the widespread engine defect and extended warranty under the Hyundai/Kia Class Action Settlement, suffered a catastrophic failure immediately following dealership intervention. Responsible Action: I brought the vehicle to the authorized Kia dealership on September 25th the instant the Check Engine Light illuminated for the very first time. The vehicle was driven to the dealership under its own power. Triggering Event: The dealership performed the required engine-related software update (Knock Sensor Detection System, KSDS) and routine service. Immediately following this service, the engine went into limp mode and ceased functioning, requiring a complete engine replacement. This sequence strongly suggests the failure was either caused by the known defect covered by the recall or was triggered by the software update itself. Manufacturer Denial: Kia is denying the claim under the Class Action Extended Warranty (which provides a lifetime or 15-year/150,000-mile warranty) using the unsubstantiated and unjustifiable excuse of "damage done prior to bringing the car in." B. Manager Misconduct and Manufacturer Bad Faith The Service Manager, Braden Anaya, has demonstrated calculated deception and bad faith, resulting in severe financial and logistical harm: Fraudulent Promise: The manager explicitly promised me the engine replacement would be approved if I titled, registered, and insured the vehicle. Relying on his direct word, I incurred a financial loss of $800 in fees for an unusable vehicle. Documented Deception: After a long delay, Mr. Anaya sent a formal denial email on December 5th confirming Kia would not cover the engine replacement. Despite this formal denial, he then contacted me and demanded "trust and patience," claiming he was actively fighting the claim for the following three weeks. This was an intentional stall and clear act of deception. Logistical Negli

Reported

Dec 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

Several times in the past year the power steering has spontaneously failed requiring significant Force to stabilize the vehicle and creating an obvious Hazard while driving. The forward Collision system indicates there's a fault while this occurs. Sometimes this is cleared by cycling the power on and off. The vehicle has been inspected by the dealer who indicated they cannot locate the source of the problem. Even a casual search / look at Community Bulletinboards online indicates that this is a much larger problem that Kia refuses to address. https://www.kia-forums.com/threads/loss-of-power-steering-when-driving.84792/

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

When the steering wheel tilt is adjusted while driving, the vehicle experiences a complete electrical shutdown — dashboard goes black and the engine may shut off. Electrical power may return when the steering wheel position is changed again. Because this involves a total loss of power while the vehicle is in motion, I am concerned about driver safety and would like this addressed as soon as possible.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Kia Soul. The contact stated that while driving at various speeds or while shifted into park(P), there was an abnormal knocking sound coming from the engine. The check engine warning light was illuminated. The vehicle had been taken to the local dealer, where it was diagnosed as needing a Product Improvement Code before the failure. The vehicle was not repaired due to the cost. The contact stated that a rental vehicle was paid for out of pocket. The contact related the failure to NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling); and the contact was informed that the vehicle was repaired prior to ownership in 2020. The manufacturer was made aware of the failure. The failure mileage was approximately 117,000.

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Kia Soul. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact became aware that there was oil leaking from the engine near the spark plugs while checking prior to the warning light being illuminated. The vehicle was taken to a local dealer who diagnosed the vehicle and determined that the head gasket needed to be replaced. The vehicle was repaired; however, the vehicle was still leaking oil, and the check engine warning light was illuminated. The contact was constantly adding oil to the engine. The contact had taken the vehicle back to the same dealer and was advised that the catalytic converter needed to be replaced, and a tune-up was needed. The catalytic converter was not replaced, and the contact stated that the engine was still leaking oil. The vehicle was not repaired. The contact had taken the vehicle to several independent mechanics and was advised that the engine needed to replace, however the vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 177,000.

Reported

Dec 2025

Incident date

Sep 2021

Mileage

Not provided

Outcome flags

None reported

Transmission failed when mileage was at 88,000 miles and is not opererational to drive. After taking car to a pirate auto shop the mechanic informed me it showed codes P0753 and P073, and informed me the transmission fluid had metal debris inside it. This is a known defect from this specific Kia model. Then took it to the Kia Dealership in Chula Vist, for diagnostic, they informed me P073 code shown up and recommended to replace the transmission. This is known defect that is associated with the Kia Soul manufacturer, and is related to the recall. My safety was put at risk when I was driving and after I stopped at a red light the car was in drive and would not accelerate when I pressed the gas, this problem was confirmed by the dealership with diagnosis paperwork. Their was no warning when this issue occurred, additionally Kia corporate refuses to accept responsibility for their manufacturer defect.

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

While driving my 2016 Kia Soul on the highway, the vehicle suddenly began shaking and immediately lost power. The check engine light came on and the car would not accelerate, even when pressing the gas pedal. This happened with no prior warning. I had to coast to the shoulder in moving traffic, which created a safety concern. The engine then stalled completely and would not restart. The vehicle was towed to Findlay Kia in Las Vegas. Their technicians diagnosed a major internal engine failure. The repair report shows zero compression in cylinder 2, a cracked intake valve, oil contamination, and extensive internal engine damage requiring a full engine replacement. Diagnostic trouble codes included P0300, P0302, P0303, and P0326. There were no earlier symptoms, no overheating, and the vehicle has been properly maintained. The failure was sudden and left the car completely inoperable. I opened Case #[XXX] with Kia Corporate. They reviewed all documents, service records, and the dealer’s findings. Although they did provide assistance in reviewing the case, the final outcome was not in my favor, and they declined to cover the repair. This is concerning given the history of engine-related issues and recalls involving Kia Souls from similar model years, particularly involving sudden engine failure and loss of power. My vehicle remains inoperable at the Kia dealership. The sudden loss of power while driving presents a clear safety risk. Based on my experience and the dealership’s findings, I believe this engine failure is safety-related and should be evaluated further by NHTSA. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Nov 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

AIRBAGS DID NOT DEPLOY

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

Crash 1 injuries

I was driving in the carpool line to Anaheim with my daughter, the car starts pulling and make a noise in the front part and start loosing speed, from 75 miles per hour to 40 miles per hours in 2 minutes. I drove to the safety zone but in high risk to a crash. All the sensor lights on in the front part. And the steering feels hard, no movement. We feel so stressed and unsafe. The police officer help us and The 511 towing help this was on October 16th. We pay $830 dlls to the AAA to bring the car to San Diego.

Reported

Nov 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

Kia Motors America (Kia) is recalling certain 2014-2016 Soul and Soul EV vehicles. The pinion plug may allow the pinion gear to separate from the steering gear assembly.

Risk: If the pinion gear separates, steering will be lost, increasing the risk of a crash.

Remedy: Kia will notify owners, and dealers will inspect and secure the pinion plug or replace the steering gear assembly, as necessary, free of charge. The recall began November 16, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC155. Note: This recall supersedes campaigns 14V-332 and 15V-736. Vehicles previously remedied under those numbers are being recalled again under this campaign.

Kia Motors America (Kia) is recalling certain 2012-2016 Kia Soul vehicles equipped with 1.6L Gasoline Direct Injection (GDI) engines. High exhaust gas temperatures may damage the catalytic converter, possibly resulting in abnormal engine combustion and damage to one or more of the engine's pistons and possible piston connecting rod failure.

Risk: Piston damage may result in an engine stall, increasing the risk of a crash. A broken connecting rod may puncture the engine block allowing engine oil to escape. The leaking oil may contact the exhaust, increasing the risk of a fire.

Remedy: Kia will notify owners, and dealers will upgrade the Catalytic Overheating Protection Engine Control Unit logic to prevent overheating of the catalytic converter. In addition, the catalytic converter will also be replaced if it has been damaged. Depending on the extent of any damage, the engine may also be replaced, free of charge. The recall began April 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC176.