2022 Ford Transit Connect

The factory windshield is loose/improperly bonded causing MOLD. This problem was found when i first bought the only four year old vehicle because of a musty/moldy smell. On the way home from the dealership it happened to storm and there were a few raindrops coming in at the top center of the windshield. I also had terrible allergy symptoms and headaches after only a few minutes of driving. I peeked under part of the vinyl floor and discovered major water and mold issues. I took it to my local Ford dealership who confirmed the windshield was likely the culprit as it was very loose. I researched this online and found an auto leak specialist demonstrating this same make/year/model van that the windshield could be easily moved simply by pushing lightly on the glass from inside the cabin, showing a bonding issue. This was the case on my van as well. This is the same issue that there WAS a recall for on the previous model (there just isn't one for this model yet) The damage was extensive and very dangerous for people like me who are sensitive to mold and can cause respiratory issues. I removed the seats and floor. There was approximately half gallon of water under the vinyl floor and mold everywhere. the vinyl floor conceals the water as it is waterproof. I spent well over a week on mold mitigation with drying/contaminated part removal/disinfecting. The insulation in the footwell was soaked and full of mold as well as the open cell foam on the underside of the vinyl. The metal body parts also had mold. I reached out to Ford Customer Care who claimed there's nothing they could do to help because there are no recalls for this model. I have to pay for everything myself. The windshield was confirmed by an auto glass specialist to have been factory and an original factory bead of sealant. They also confirmed it was a bonding issue, They were able to detach and reset it PROPERLY for $424. I still have to replace the insulation and entire vinyl floor.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

My 2022 transit van caught on fire. I was driving with my son. There were no warning lights nothing. It burt to the ground.

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

Fire

Speedometer stops working/ lighting up. I called Ford regarding recall 25C19 and they said it doesn't cover this vehicle.

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

The radioator failed it started leaking the car is only 60k ish miles

Reported

Aug 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

While driving my 2022 Ford Transit Connect (cargo model, 2.0L) in city traffic, I experienced a serious intermittent issue. Twice now, the vehicle suddenly jerked, throttle response was delayed or non-existent, and a “Collision Detection Disabled” warning flashed on the dash. Simultaneously, the “Service Vehicle Soon” light illuminated. Both times, I pulled over and shut off the vehicle. Upon restarting, the warnings cleared and the vehicle drove normally again. There were no prior warning signs or fault messages. I brought the vehicle to Mullinax Ford in Apopka, FL, and explained the issue in detail. However, I was told there were no diagnostic trouble codes (DTCs) stored, and they refused to conduct any further testing. I specifically asked them to perform: A full scan of all vehicle modules (including the IPMA/collision system), Check the forward collision camera and wiring, Confirm all PCM/ADAS software is up to date, Perform a battery and charging system test, Inspect the throttle body or related sensors. They declined, saying “if there are no codes, there’s no issue.” This is concerning because the symptoms are intermittent and potentially safety-related — including unexpected loss of power and the disabling of a major safety system. Based on owner reports and technical bulletins from Ford for similar symptoms in other models (such as F-150 and Explorer), this may be due to software or hardware faults that do not always trigger DTCs. This issue affects my confidence in the safety and reliability of the vehicle. I am requesting that Ford investigate further, open a case, and provide support in ensuring proper diagnostics and resolution — even if the dealer won’t take further action.

Reported

May 2025

Incident date

Apr 2025

Mileage

Not provided

Outcome flags

None reported

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Risk: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.