2021 Ford F-150

The contact owns a 2021 Ford F-150. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted from 10th gear to 8th gear and then independently shifted into 9th gear and downshifted to 8th gear before independently shifting back into 10th gear. The contact stated that there was an abnormally loud bang. The power train and check engine warning lights were illuminated. The vehicle was driven to the shoulder of the road and turned off. The contact stated that while attempting to start the vehicle, the vehicle started. The check engine and power train warning lights were off. The vehicle was taken to an independent mechanic where it was diagnosed with transmission failure. The contact was advised to take the vehicle to the dealer. The vehicle was taken to the dealer where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was in the process of being repaired. The contact was informed that the failure was a known failure with the vehicle. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 93,000.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

The verticals led daytime running light (DRL) on the passenger side has stopped working.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

On July 15, 2026, I took the vehicle to Lafontaine Ford for maintenance and to address open recalls. I was informed that the open recall for the low-pressure fuel pump (campaign 25S75) did not have a solution available. Due to the severity of the recall, I contacted the Ford Customer Care Center. A representative stated that a solution would be available on July 17, 2026, and that they would contact Lafontaine Ford to prioritize the vehicle for repair on July 18, 2026. On July 17, 2026, I followed up with Lafontaine Ford and confirmed they had received no contact or notation from Ford regarding prioritization. Lafontaine Ford also stated they had no information on when parts would become available and that nothing could be done at that time. I then contacted the Ford Customer Care Center again because no action had been taken, even though the recall has been open since approximately July 8, 2025. A Ford Customer Care Center representative confirmed that no remedy was available for my model year and that they did not know when one would be available. Due to the seriousness of the recall, I requested a courtesy vehicle. The Ford representative contacted Lafontaine Ford regarding this request and then disconnected the call. The Lafontaine Ford representative informed me they could not provide a courtesy vehicle without written confirmation from Ford due to the dealership having no reasonable timeframe of when parts/remedy would be available. When I called the Ford Customer Care Center back and explained what Lafontaine Ford had told me, I was treated indifferently and was disconnected twice. I eventually spoke with a supervisor who refused to escalate the concern or provide any assistance with the documentation Lafontaine Ford said they needed in order to provide a courtesy vehicle. The low-pressure fuel pump is the component identified in the recall and can fail, resulting in loss of engine power or stall while driving. This creates a significant safety risk, part

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

Transmission has harsh shifts all the time this is dangerous and well known by ford

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

Vehicle is subject to open NHTSA recall 25V455 for fuel pump failure that can cause loss of fuel pressure and engine stall. Vehicle is now completely non-drivable — will not start at all. Dealer confirmed awareness of the recall but stated the manufacturer has not yet provided parts or a repair procedure. Recall status shows incomplete, remedy not yet available. Vehicle owner currently has no working transportation and no timeline for repair from the manufacturer.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

The steering wheel becomes crooked almost 90 degrees to the left and car still driving straight, just happened overnight I believe after system update

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

Truck has just started misfiring out of the blue, have had Ford dealerships look at it, have changed all 6 spark plugs and one ignition coil. The recall NHTSA 2025-366 may be the reason, it states there still is no remedy for this, recall was issued 1 year ago, July 2025. I need this remedy.

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Recall has been issued on my fuel pump for one year now and there is still no remedy. I do not feel safe traveling far from home knowing this is still an issue.

Reported

Jul 2026

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

Good Morning :) This is my second complaint (1st #XXX) as my truck completely shut down as I was leaving the shop around 4:30pm. As I accelerated it shut down in the middle of the street blocking traffic. I was able to start it again, however it shut down a second time as soon I accelerated. NOTE: On XXX I did take my truck into Ford for this issue, however nothing could be done as there was no solution yet. (Mileage 32899) Thank You, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

I recently purchased a 2021 f-150 with 48,000 miles on it. Just over 60,000 miles I was noticing some bad shifting occurring with my 10R80 transmission. It progressively got worse by harsh shifting, terrible gear hunting, then finally after driving in manual for a couple days: I was in the middle lane of state road 41 approaching sun lake road, the light turned green and my truck went nowhere. I immediately put my hazards on as cars were trying to get around me and I tried to shift into gear. I managed to find 4th after at least a minute (it skipped 1-3) and I limped to the side of the road where my dad later came with his trailer to pick it up. This is a known issue that ford acknowledges with this particular year for the 10r80 (the CDF drum being the component that fails) yet they have done nothing to address it, even though they DID FIX IT it in the 22+ models. My truck is now at a shop with 60,646.1 miles where they are installing a new transmission for over $5,000 (awaiting for them to finish and I’ll provide the receipt / proof of purchase). Also, they couldn’t even put it in neutral to roll it off the trailer even after disconnecting the computer and manually shifting it from underneath the truck. I’m contacting NHTSA in hopes you can make some noise and file a complaint with Ford, they told me they won’t do anything since I’m out of warranty and there are no recalls for the transmission. It’s ridiculous that I’m dealing with this on just a 60k mile truck that’s a few hundred miles out of warranty and they know this is an issue.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 ( FUEL SYSTEM, GASOLINE) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Reported

Jul 2026

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

Transmission began shifting hard through each gear. Especially on deceleration. Causes lunging. Early signs were at about 90K miles. Undrivable at 130K. Took to dealership and the said it needs a new transmission. Just under $9k. Their words were, "This is a known design failure". A drum bushing can slide out of position.

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Good Afternoon. The Pro Power Onboard high-voltage electrical system has experienced a permanent malfunction, locking out with a "Ground Fault Detected" warning. The vehicle is a 2021 Ford F-150 Rocky Ridge conversion. This failure stems directly from a defective or incomplete execution of Safety Recall 23S35 (NHTSA Campaign 23V613000).The initial remedy applied by the dealership consisted only of adding protective tape to the rear wiring harness. However, due to the increased travel and ride height of the official Rocky Ridge suspension lift, the wiring harness pulled out of its factory retaining side clip. This caused excessive tension and stretching on the high-voltage lines, completely exposing the bare interior colored wires and leaving them vulnerable to road moisture and friction against the metal frame.The system now triggers a permanent short-to-ground error, creating an imminent risk of an electrical short circuit or vehicle fire under the high-voltage (120V/240V) lines. The Ford dealership and corporate customer care refuse to remedy this recurring safety hazard under the recall warranty because it was previously marked as completed, even though the applied remedy failed to safely secure the harness. The component is available for inspection.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

My transmission has started to shift hard. While driving at speeds 30-50, the transmission will lag and cause a "jump".

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The truck’s fuel system can cut out under acceleration. This is very dangerous. Various times it has nearly stalled out under acceleration while trying to merge. The worst time was driving up a bridge, the truck began to hesitate nearly causing a crash. Every time it signals cylinder misfire, but that whole system has been replaced. Very dangerous, very disappointing.

Reported

Jul 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The passenger side running light in the headlight has gone out. Not the entire part just the vertical section of the running light

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford F-150. The contact received notifications of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline) and 26V104000 (Electrical System, Exterior Lighting); however, the parts to do the recall repairs were not yet available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Reported

Jun 2026

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

The passenger side light has the outer-most vertical LED segment out (not lit up). This appears to be common on this model truck after researching.

Reported

Jun 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Component/system affected: Power train / automatic transmission. Description of safety issue: The transmission has recurring harsh and erratic shifting, most noticeable on the first drive of the day. Symptoms include slipping/flaring, delayed or failed upshifts, sudden harsh gear engagement, unexpected large gear changes, loss of power, and occasional operation as if stuck in 4th gear/limp mode. The issue has become severe enough that I have had to manually intervene and pull over. Specific safety incident: On or about June 24th, I was leaving my apartment complex and turning left onto a busy main street. As I approached and entered the turn, the truck was in 1st gear and I was pressing the accelerator, but the transmission appeared to struggle or delay shifting into the next gear. The vehicle did not respond normally, so I continued applying throttle to complete the turn. When the transmission finally shifted, it engaged extremely harshly and caused the truck to lurch forward unexpectedly into the intersection. I had to slam on the brakes to narrowly avoid colliding with another vehicle. This created a serious crash risk because the vehicle first had delayed/lost propulsion and then suddenly surged forward during a left turn across traffic. Safety risk: This defect can cause unexpected loss of motive power, delayed acceleration, harsh engagement, and sudden vehicle lurching while driving. This is especially dangerous when merging, turning across traffic, entering intersections, passing, or driving at highway speed. The problem occurs without a clear warning light or check-engine light, so the driver may not have advance warning before the transmission behaves unpredictably. I am reporting this because the 10R80 transmission behavior caused a near crash due to delayed acceleration followed by sudden harsh engagement/lurching into traffic, and because the failure appears consistent with a known valve body/CDF drum issue affecting Ford 10-speed transmissions.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

My complaint is for an issue that currently has a manufacturer recall as well as a NHTSA recall since Dec. 22, 2023. Manufacturer Recall Number - 23S65 NHTSA Recall Number - 23V896 My right rear axle bolt broke off 2 years ago and I took it to the dealer for repair. At that time they took pictures and the vehicle information to start a claim. They told me they needed to order the parts and would contact me when they received them. As of the date of this complaint the dealer tells me they still do not have parts to resolve this recall. I filed a complaint with the manufacturer and they told me parts should be available by the 3rd quarter of this year (2026) If, that were to happen ? It will be 3 years from the time I was notified of the recall to finally resolving the issue. This is unacceptable for a safety issue to take that long to be resolved and the only excuse is that there are no parts available. I use my vehicle daily for work/income and also for personal use towing a heavy trailer. I cannot believe that a potential accident causing injury or death can possibly occur from a known safety issue to continue because the manufacturer can't get parts. Please look into this matter before someone gets seriously injured or killed. I have been very patient but anyone put in this situation would be very frustrated. Please help me to get my vehicle repaired.

Reported

Jun 2026

Incident date

Dec 2023

Mileage

Not provided

Outcome flags

None reported

My check engine light has been on for a few months, I called Sioux Falls Ford to ask about it and they told me it's a minimum $200 out of pocket to even look at it. I asked what would happen if the check engine alert had to do with the active recall that is almost a year old that Ford has made no progress to fix, and they said I could file for reimbursement if they deemed the engine warning had to do with the recall. I took my truck to another garage and they found that the check engine light was indeed caused by the fuel pump running at 52psi - the recommended is 51-85psi for my truck. They said the new part would be in the following week to fix it for $1200. When I relayed all of this information to Ford National they told me they weren't able to help me and they were still investigating. They told me that they also weren't responsible for damage to my truck as my powertrain warranty expires next month. They refused to help in any way or offer a timeline of when I could expect a fix. Ford has left me stuck with no options to prevent a potential crash if this faulty piece makes my truck stall on a highway - I can either pay $1200+ for a part from another garage they are legally supposed to fix, or continue to drive a potentially unsafe vehicle based on Ford's negligence. Sioux Falls Ford and Ford National, based on a year timeline with several calls and text chats with both, are refusing to comply with their legal responsibility to remedy this safety recall.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

2021 Ford F-150 Platinum VIN: [XXX] Failure around 95,500 miles Symptoms: Harsh shifting in lower gears Intermittent slipping Progressively worsening over several weeks Dealer diagnosis: Internal transmission issues Concerns consistent with CDF drum, clutch, and planetary component issues Repair: Dealer-performed transmission overhaul Updated CDF drum installed Updated clutch and planetary cylinder Updated valve body separator plate Cost: $6,959.15 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Check engine light went on. Knock sensor failure. Vehicle running rough and knocking. On line lots of people complaining. Gentleman in the service department who works for Ford said that he has been getting a lot of knock sensor failures lately.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The problem and or issue on my 2021 Ford F150 is the Day Running light on the Upper Passenger side went out and does not work anymore. I reported it to the Dealer. I believe it to be a safety issue if all Day Running lights are not fully operational. This happened with about 66,026 miles on my vehicle.

Reported

Jun 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

When using the window wipers, they become inoperable. Stopping in the middle of the window, pausing when moving, or completely stopping and unable to get them to start moving until they begin to move on their own. This has occurred multiple times and at multiple different speeds of operation for the wipers. This was a previous recall issued by Ford that has been completed on the vehicle yet the same result is occurring.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

2021 Ford F-150 PowerBoost Hybrid, VIN [XXX]. At 112,000 miles — just 1,000 miles outside of warranty — the vehicle experienced catastrophic failure of the hybrid battery system. Ford's own technician diagnosed a short in the high voltage battery system that caused damage to the hybrid electric drive unit. Repair estimate is $19,000. Ford declined goodwill warranty coverage despite the vehicle being only 1,000 miles outside warranty and the failure occurring on a known problematic system. This is a $72,000 vehicle purchased new in 2021 that has suffered a catastrophic drivetrain failure at only 3 years old. The high voltage battery short and hybrid drive unit failure represent a potential safety hazard to drivers and other motorists. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The EPAS (Electric Power Assisted Steering) module experienced an internal sensor failure, causing a sudden and complete loss of power steering assist. The vehicle is available for inspection upon request and the EPAS module has been retained. The loss of power steering occurred without warning while the vehicle was in motion, requiring significantly greater physical force to maintain control of the steering wheel. This creates a serious risk of losing vehicle control, particularly at higher speeds, during lane changes, or in emergency maneuver situations. Because the failure occurs randomly and without any prior indication, there is no opportunity to safely prepare or pull over before it happens, putting both the driver and other motorists at risk. Yes. The issue has been acknowledged by multiple Ford dealerships and independent mechanics, all of whom confirmed this is a known and recurring problem with this vehicle’s EPAS system. Numerous online automotive forums also document other owners experiencing the identical failure, suggesting this is a widespread issue rather than an isolated incident. The vehicle was inspected by an authorized Ford dealership, which confirmed the EPAS module failure and acknowledged familiarity with the issue. No warning lights, dashboard messages, unusual sounds, or handling changes occurred before the failure. The power steering loss happened suddenly and without any prior symptoms, leaving no opportunity to anticipate or react to the malfunction before it occurred.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

I haven't had a issue yet, but I'm not comfortable continuing to drive my truck with a known safety recall that Ford has no solution for even though it's been a recall for several months. I live in a area with no Ford dealerships, so it's a little difficult to get warranty work done.

Reported

Jun 2026

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

Vertical Daytime Running Lamp is out and from doing multiple hours of research it looks as if it was a quality control issue. The LED board was not secured internally and it caused an LED to touch the tube and burned it. It is very common on 2021-2023 models and the manufacturer changed it for 2024. Please we need to get this as a recall.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

See attached document for complaint.

Reported

Jun 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

See attached document for complaint.

Reported

Jun 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

My 2021 Ford F-150 intermittently displays the warning message “Reverse Brake Assist Not Available – See Manual” when the vehicle is placed in reverse. When this message appears, the reverse brake assist / parking collision warning feature is not available, which may reduce safety while backing up. The vehicle was inspected by a Ford dealership. The dealership confirmed DTC U3000:49 in the IPMA module and identified Ford TSB 23-2040 as applicable to the concern. The dealer stated that the repair requires an IPMA software/module update and calibration. The quoted repair cost was approximately $1,100. This appears to be a software/programming-related condition affecting a driver assistance and brake-related safety feature, not normal wear and tear or a failed mechanical component. The warning is intermittent, but it has appeared multiple times. The vehicle is available for inspection upon request. No crash, injury, or fire has occurred. Ford Customer Support was contacted and case number XXX was opened. Ford advised that no active warranty, recall, or customer satisfaction program currently provides repair cost coverage, and that because this involves Reverse Brake Assist, I may choose to file a safety concern report with NHTSA. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Misfire at 51000 miles and told it was 2 cracked spark plugs

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

After a day of heavy rain, the vehicle stalled at a stop light and would not restart. The steering wheel and transmission locked, preventing the vehicle from being placed in neutral, creating a safety hazard as the vehicle was immobile in traffic. No warning lamps appeared prior to the failure. The vehicle required a tow. The dealer confirmed water had intruded through the passenger side cowl/firewall seam due to inadequate factory sealing, tracking down and pooling directly onto the Body Control Module (BCM) mounted on the passenger side firewall. The BCM failed due to water damage, causing PATS desynchronization and the no-start condition. The BCM failure subsequently shorted out the starter motor. Dealer replaced the BCM, repaired the leak, and replaced the starter. Total repair cost approximately $3,200. Failed components are available for inspection at the dealership. This identical failure; passenger side cowl water intrusion leading directly to BCM damage — is documented across numerous 2021+ F-150 owner forums, indicating a widespread factory sealing defect at the cowl/firewall/inner fender seam junction.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Manufacturer Recall Number: 23S65

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

At a stoplight the truck began running rough. When the light turned green, the truck failed in just 3 blocks (approximately 1 minute). Power was greatly reduced. Check engine illuminated on dashboard, then another red icon, followed by a stop safely now message. Immediately I attempted to pull over from the left lane to the right lane but the truxk Immediately stalled across both lanes, blocking all traffic. Ford dealer has ordered a new fuel pump and the repair is pending.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Transmission kept slipping out on the freeway. Led to a near accident. Then ended up broken down on a highway while towing a trailer. Transmission couldn’t find gear for the next serval times we tried to place in gear. Then on the third time it went into gear and started driving again only to slip out and lead to another breakdown on the highway. Still had to drive it into dealership in its unsafe condition.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

2021 Ford F-150 Lariat, 5.0L Coyote V8, purchased new, now 65k miles. Two interrelated safety defects: OIL CONSUMPTION: On 3/21/2026 at 62k miles, I discovered the engine was critically low on oil. Only 3 quarts drained during a full oil change, against a rated 8.8 quart capacity. The engine had been running on one third of required oil. The onboard oil life monitor showed 9% remaining and gave NO low-oil warning, no warning lights, no alerts. No external leak. On 5/22/2026, Koons Ford Woodbridge formally confirmed excessive oil consumption after a documented oil consumption test. Ford TSB 19-2365 acknowledges this exact defect on the 5.0L Coyote for 2018-2020 model years, attributing it to high intake manifold vacuum during deceleration fuel shut-off pulling oil into the combustion chamber. The 2021 engine is mechanically identical. TRANSMISSION: Hard and slipping gear shifts reported to Ford within months of purchase in 2021. Ford issued multiple software updates over the years to mitigate the behavior, most recently late 2025. Fix was temporary; hard/slipping shifts returned. CATASTROPHIC FAILURE: While awaiting Ford HQ authorization on repairs, the vehicle suffered complete drivetrain failure on Friday night. Engine lost power and transmission failed entirely. I was near home and coasted safely off the road. Had this occurred at highway speed during my daily commute, the result could have been catastrophic. Vehicle towed to Koons Ford Woodbridge. SAFETY CONCERN: This is my only vehicle, used for daily highway commuting. The oil consumption defect provides no warning before engine damage. The transmission has degraded despite years of Ford software patches. The vehicle has demonstrated total drivetrain failure capability with no driver warning. Ford Corporate case opened: CXH-07446845-G0J0K0. Filing to document this at the federal level and add to the existing pattern of complaints. Requesting NHTSA review whether these defects warrant investigation.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

My 2021 Ford F-150 has been having trouble with the transmission. Hard shifting, shifting to 10th gear at 40mph and unable to downshift after slowing down. I have also had issues with the daytime running lights not working since around 45k miles. My truck only has 59K miles at the time of me typing this.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Incident Description:The vehicle experienced a complete internal transmission failure while driving, creating a severe and sudden loss of power on the roadway. A professional technician's diagnostic assessment confirmed active fault code P07F7 (Incorrect Gear Ratio 10th Gear) and explicitly cited Ford Technical Service Bulletin TSB #25-2474, pointing directly to a failed internal mechanical CDF clutch drum sleeve.On October 31, 2025, the dealership attempted to patch the issue by replacing only the external electronic transmission solenoids. However, this did not address the true internal mechanical defect, causing the transmission to fail again immediately with the exact same symptoms.Ford has acknowledged this severe design flaw via an internal Customer Satisfaction Program but has strictly capped coverage at 70,000 miles. Because this identical mechanical failure occurred at 81,893 miles, Ford has denied all financial and safety assistance to fix the actual broken mechanical hardware. This widespread manufacturing defect affecting 10R80 transmissions causes vehicles to suddenly lose propulsion in traffic, creating an imminent crash hazard. This campaign must be expanded to a mandatory safety recall.

Reported

Jun 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Vehicle suddenly locked the steering wheel at approximatelyn20-25 MPH dash displayed a front camera failure and the motor stopped. I had to put the vehicle in park and restart. It happened again with in a minute. Then a third time after driving apron. 120 miles. As I slowed to a stop light the same thing happen a third time. This occurred at 20-25 MPH.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

RECALL 25V-315/25S49 has not been fixed on my truck. ive taken in multiple times since last year and programming doesnt fix the issue. final conclusion from the dealer is replace camera system. which they want me to pay $800 for. Since this is a recall Ford should take care of these charges. info. below [XXX] =aXXX INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

May 2026

Incident date

Jan 2025

Mileage

Not provided

Outcome flags

None reported

There has been a recall issued since last year with no remedy

Reported

May 2026

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

In the winter the two front doors freeze. I had my twelve year old daughter in the car and turned a corner and the door opened at 25 miles and hour and she had to hold on. We have bungy corded the doors shut during the winter. Ford does not have a safety recall and stated to let the car heat up for 30 mins before use. From online forums this is a common issue for 2021 F150's. Ford should be responsible for fixing the issues

Reported

May 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The transmission had a lengthy delay shifting into reverse when shifted from park. I removed my foot from the brake and all of a sudden it jumped into reverse and I ended up in the road. Fortunately there were no cars or pedestrians behind me.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

When stopping for a redlight the 10r80 transmission locks itself into 10th gear. I have taken 7 or 8 actual videos for proof of that. Also when leaving a intersection the transmission runs up to the rev limiter in 1st gear then slams into 2,3,4 and 5th gear. Unfortunately I don’t have that on video because I am already moving when it happens. Also unfortunate for me is I called the local dealership and shared with them the issues and asked for a transmission service to be done on it and between the phone call and the service time the factory warranty ran out. The day after the transmission service and 8 days after the factory warranty expired the pickup left me stranded with no forward gears. So here I am with a truck with only 52,000 miles on it scratching my head… no check indicator lights have shown up either.

Reported

May 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford F-150. The contact stat3ed while driving at an undisclosed speed, the steering wheel failed to turn in the intended direction. The steering assist failure warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed with a failed rack and pinion. The contact was informed that the rack and pinion needed to be replaced. The vehicle was not repaired. The contact was informed that the parts were in back order. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 73,000.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

When I'm driving my truck, usually when I have come to a stop on an incline, the parking/emergency brake will engage on its own. For example, most recently I was pulling out of a driveway with an incline. I was stopped at the bottom of the driveway to wait for the roadway to clear before I pulled out. When I hit the gas to go, the rear wheels skidded and the truck came to a stop in the oncoming traffic lane. I looked at the dashboard and saw that the parking brake symbol was on, indicating that the parking brake had engaged. I did not engage the parking brake- the truck did it on it's own.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Both of the Daytime Running Lamps (DRLs) on my 2021 F150 have failed. They cost `$2,000 each to replace. They are LEDs, and were billed as never needing replacement, and certainly not under 50k miles. A quick search shows that this is a common issue with 2021+ F150s, and looking around on the road, I notice many with the same issue. This failure of safety equipment reduces visibility and could contribute to accidents.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.

Risk: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.

Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.

Risk: An engine stall increases the risk of a crash.

Remedy: Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Interim notification letters notifying owners of the safety risk were mailed July 16, 2025. Second letters will be sent once the remedy is available, anticipated 2nd Quarter 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.

Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.

Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.

Risk: Inoperative windshield wipers can reduce visibility in certain conditions, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the wiper arms, as necessary, free of charge. Owner notification letters were mailed December 13, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S10. This recall expands previous recall number 22V-250.

Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.

Risk: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios increases the risk of a crash.

Remedy: Dealers will inspect and repair the driveshaft, as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed September 1, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S53.

Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The front windshield wiper motor may become inoperative, causing the wipers to fail.

Risk: Inoperative windshield wipers can reduce visibility in certain conditions, increasing the risk of a crash.

Remedy: Dealers will replace the front windshield wiper motor, free of charge. Owner notification letters were mailed June 22, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S12.

Ford Motor Company (Ford) is recalling one 2021 F-150 vehicle. A single vehicle may have been assembled without a fuel tank front attachment resulting in an unsecured fuel tank attachment strap.

Risk: An improperly attached fuel tank increases the risk of a fuel leak and potential for fire.

Remedy: Dealers will inspect and repair (if necessary) the fuel tank strap bracket, free of charge. Owner notification letters were mailed July 1, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S42.

Ford Motor Company (Ford) is recalling certain 2021 F-150 and 2020-2021 F-250, F-350, F-450, and F-550 Super Duty vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."

Risk: In the event of a crash, if the windshield separates from the vehicle, it can increase the risk of injury.

Remedy: Ford will notify owners, and dealers will remove and reinstall the windshield, free of charge. The recall began April 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C06.

Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The two-piece driveshafts may have been improperly assembled, which could result in driveshaft separation.

Risk: Driveshaft separation may result in a sudden loss of drive power, or unintended vehicle movement if the vehicle is in park without the parking brake applied, increasing the risk of a crash.

Remedy: Dealers will inspect the driveshaft, and replace it if necessary, free of charge. Owner notification letters were mailed on June 15, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S25.

Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The steering gear may have internal damage, which could result in difficulty steering, or the inability to rotate the steering wheel while driving.

Risk: Loss of steering control can increase the risk of a crash.

Remedy: Owners are advised to not drive their vehicles until the repair is complete. Vehicles will be towed in for service, and dealers will remove and replace the steering gear, free of charge. Owner notification letters were mailed on June 4, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S28.

Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The electronic brake booster may leak brake fluid into the electronic control unit, which could result in reduced braking performance.

Risk: Reduced braking performance can increase the risk of a crash.

Remedy: Dealers will replace the electronic brake booster assembly, free of charge. Owner notification letters were mailed on July 28, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S33.

Ford Motor Company (Ford) is recalling certain 2021 F-150 Super Cab vehicles. The front seatbelt webbing may be incorrectly routed.

Risk: A misrouted seatbelt may not adequately restrain an occupant in a crash, increasing the risk of injury.

Remedy: Owners are advised to perform a preliminary self-inspection of the front seatbelts. If the passenger-side seatbelt fails inspection, owners should not use the passenger seat until the repair is performed. If the driver-side seatbelt fails inspection, owners should not drive their vehicle until the repair is performed. Dealers will inspect the front seatbelts and, if the webbing is misrouted, will replace the seatbelt retractor and pretensioner, free of charge. Owner notification letters were mailed on October 14, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C20.

Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250, F-350, 2021 F-150, Expedition, and Lincoln Navigator vehicles. The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."

Risk: An air bag that does not deploy properly during a crash increases the risk of injury.

Remedy: Dealers will replace the driver and passenger front door side impact sensors, free of charge. Owner notification letters were mailed November 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C26.

Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.

Risk: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.

Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed February 4, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S56.

Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The Diagnostic Trouble Code (DTC) for low transmission fluid pressure may falsely activate and cause the transmission to unexpectedly shift into neutral.

Risk: An unexpected shift into neutral will cause a loss of drive power and increase the risk of a crash.

Remedy: Dealers will update the Powertrain Control Module (PCM) software, free of charge. Owner notification letters were mailed on April 12, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S15.

Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.

Risk: Loss of trailer brake functionality could result in extended stopping distance, increasing the risk of a crash.

Remedy: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 22, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S17.

Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.

Risk: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.

Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.

Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. The front windshield wiper motor may become inoperative, causing the wipers to fail.

Risk: Inoperative windshield wipers can reduce visibility in certain conditions, increasing the risk of a crash.

Remedy: Dealers will replace the front windshield wiper motor, free of charge. Owner notification letters were mailed June 30, 2023. Remedy parts are expected in the 3rd Quarter of 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S71. This recall expands previous recall number 22V-142.

Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 vehicles equipped with a single exhaust system. Contact with the rear axle housing may damage the wiring harness, causing the electric parking brake to activate unexpectedly.

Risk: Unexpected activation of the electric parking brake while driving increases the risk of a crash.

Remedy: Dealers will install a protective tie strap, tape wrap, and replace the harness as necessary, free of charge. Owner notification letters were mailed February 12, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S35.

Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 vehicles equipped with the Trailer Tow Max Duty package and a 9.75-inch heavy duty axle with a 3/4 float axle design. The rear axle hub bolt may fatigue and break, which can result in damage to the axle hub splines.

Risk: Damaged axle hub splines can result in a vehicle rollaway when the vehicle is in park without the parking brake applied or cause a loss of drive power. Both of these conditions can increase the risk of a crash.

Remedy: Dealers will replace the left and right rear axle shaft assemblies, free of charge. Owner notification letters were mailed on May 9, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S65.

Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles equipped with the Onboard Scales feature. An over-the-air software update to the body control module (BCM) may have disabled both reverse lights.

Risk: Disabled reverse lights cannot alert others that the vehicle is reversing, increasing the risk of a crash.

Remedy: Dealers will update the body control module software, free of charge. Owner notification letters are were mailed June 26, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S38.

Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. The engine intake valves may break while driving, which can result in engine failure and a loss of drive power.

Risk: A loss of drive power increases the risk of a crash.

Remedy: Dealers will perform an engine cycle test and replace the engine as necessary, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S55.

Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles previously repaired incorrectly under recall number 22V-193. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.

Risk: Loss of trailer brake functionality can extend the distance required to stop, increasing the risk of a crash.

Remedy: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S18.

Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles previously repaired incorrectly under recall number 22V-188. The Diagnostic Trouble Code (DTC) for low transmission fluid pressure may falsely activate and cause the transmission to unexpectedly shift into neutral.

Risk: An unexpected shift into neutral will cause a loss of drive power and increase the risk of a crash.

Remedy: Dealers will update the Powertrain Control Module (PCM) software, free of charge. Owner notification letters were mailed April 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S24.

Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles equipped with the Onboard Scales feature that were repaired incorrectly under recall 24V443. An over-the-air software update to the body control module (BCM) may have disabled both reverse lights.

Risk: Inoperative reverse lights may fail to alert others that the vehicle is reversing, increasing the risk of a crash.

Remedy: Dealers will update the body control module software, free of charge. Owner notification letters were mailed on June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S57.

Ford Motor Company (Ford) is recalling certain 2021-2022 Expedition, Lincoln Navigator, 2021-2023 F-150, 2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The moonroof wind deflector clips may be inadequately attached to the moonroof frame, which can result in the wind deflector detaching from the vehicle.

Risk: A detached wind deflector can become a road hazard and increase the risk of a crash.

Remedy: Dealers will inspect and repair the moonroof wind deflector as necessary, free of charge. Owner notification letters were mailed November 10, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB7. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 30, 2025.

Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."

Risk: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.

Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.

Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.

Risk: Park system damage may result in a vehicle rollaway, increasing the risk of a crash.

Remedy: Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 26, 2026.