2013 Chevrolet Express

The contact owns a 2013 Chevrolet Express 3500. The contact stated that while driving 70 MPH, the exterior rear wheel cover liner detached from the wheel. The wheel liner cover missed crashing into a vehicle in the opposite lane on the freeway. No warning lights were illuminated. In addition, the contact had lost ten wheel covers out of a set of twelve. The contact purchased three sets through Amazon. The contact called the manufacturer and was informed that unless the failure was regarding an ambulance, it was not their responsibility. The contact stated that the manufacturer refused to assist with the failure and referred the contact to call Phoenix. The contact called Phoenix, and Phoenix refused responsibility and referred the contact to call Amazon. The contact stated that Phoenix wheel cover liners were no longer listed on Amazon. The failure mileage was unknown.

Reported

Oct 2025

Incident date

Oct 2023

Mileage

Not provided

Outcome flags

None reported

Vehicle is upfitted as a school bus. Forward fuel tank strap failed in operation. Our company operates more than 100 of these vehicles and we experience a failure of fuel tank straps at a rate of about one vehicle per month. If the 2nd strap would also fail the gasoline tank would become dislodged and present a fire hazard. This is even more critical as these vehicles are carrying students as a school bus. We perform visual inspections of the straps at 6 month intervals (per Pennsylvania these vehicles are subject to Semi-Annual State Inspection). There were no symptoms of the problem before this failure. There are never symptoms of the problem before any failure. Failed fuel tank straps on this were replaced by GM Dealer (Faulkner GMC, 705 Auto Park Blvd, West Chester, PA 19382) (Invoice #677130 - Invoice Date Feb 21 2025).

Reported

Mar 2025

Incident date

Jan 2025

Mileage

Not provided

Outcome flags

None reported

The Brakes will Lock up while driving Due to an issue with the Power Brake Hydro Boost System. The Hydro Boost Control Valve will allow Pressure to apply the Brake Master Cyl. with Engine speed increasing while the vehicle is traveling in a normal Fashion. Overheating the Brake calipers to the point of Protective boots burning up. Rotors and pads are damaged also. This a known problem Posted on repair search boards. I am a Certified ASE Master Mechanic with over 40 Years This a Very Dangerous Event and Part Failure

Reported

Oct 2021

Incident date

Oct 2021

Mileage

Not provided

Outcome flags

None reported

BRAKES DO NOT RELEASE AFTER SUDDEN STOP, THREE TIMES, ON HIGHWAY 95. STEERING WHEEL STARTED TREMBLING SLOWLY FOR 10 MILES AND THEN VIOLENTLY, THEN BRAKE PEDAL GETS HARD. PASSENGER SIDE STARTED SMOKING, ON 8 SOUTH IN CT 4/9/2020. MANAGED TO STOP VAN ON SOFT SHOULDER. THIS BRAKE SYSTEM IS VERY DANGEROUS FOR ME.

Reported

Apr 2020

Incident date

Apr 2020

Mileage

Not provided

Outcome flags

None reported

TL* THE CONTACT OWNS A 2013 CHEVROLET EXPRESS CUTAWAY. THE CONTACT STATED THAT WHEN THE BRAKE PEDAL WAS DEPRESSED, IT TRAVELED TO THE FLOORBOARD. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE BRAKE LINES HAD EXTENSIVE RUST, CORROSION, HOLES, AND WERE FRACTURED. THE VEHICLE WAS UNABLE TO BE DRIVEN AND WAS TOWED TO BERGER CHEVROLET (2525 28TH ST SE, GRAND RAPIDS, MI 49512, (616) 949-5200) FOR DIAGNOSTIC TESTING AND REPAIRS. THE MANUFACTURER HAD NOT ISSUED ANY BRAKE SYSTEM RECALLS; HOWEVER, ONE TECHNICAL SERVICE BULLETIN FOR THE BRAKES WAS ISSUED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 20,000.

Reported

Jun 2019

Incident date

Jun 2019

Mileage

Not provided

Outcome flags

None reported

PREVIOUS COMPLAINTS 11102768 , 11111685 VEHICLE IS A FOREST RIVER SUNSEEKER RV/ 2013 CHEVY EXPRESS CUTAWAY 4500 MODEL G33803 159" 6.0 GVW 14,200. THE FUSE/RELAY BLOCK HAS BEEN REPLACED. PART 22767373. THE TECH HAS MADE A COMMENT ON THE INVOICE. THE ORIGINAL FUSE BLOCK HAD A LACK OF VOLTAGE TO VARIOUS COMPONENTS AND MAY CAUSE FUTURE ELECTRICAL FAILURES DUE TO THIS.THE VEHICLE HAS 9100 MI ON IT. THIS FUSE BLOCK(UNDERHOOD) HAS BEEN A PROBLEM IN MANY VEHICLES INCLUDING AMBULANCES. NOT GOOD, AS IT CAN CAUSE THE VEHICLE NOT TO START OR LOOSE POWER. THIS IS A SERIOUS PROBLEM AND NEEDS TO BE ADDRESSED.

Reported

Jul 2018

Incident date

Jul 2018

Mileage

Not provided

Outcome flags

None reported

COMPLAINT 11102768 FILED PREVIOUSLY FOR CRANKSHAFT SENSOR AND CAMSHAFT SENSORS. NEW COMPLAINT : VEHICLE WOULD NOT START 7/11/2018. CALLED CHEVY DEALER. WAS TOLD TO REMOVE AND REPLACE RELAY IN FUSE BLOCK. VEHICLE STARTED. DEALER INFORMED US THAT THEY HAVE HAD TO REPLACE FAULTY FUSE BLOCK IN MANY SIMILAR VEHICLES. OUR VEHICLE IS A 2013 CHEVY EXPRESS CUTAWAY 4500. MODEL G33803 159" 6.0 GVW 14,200. IT IS A FOREST RIVER SUNSEEKER RV. THEY HAVE HAD TO REPLACE THEM IN AMBULANCES AND OTHER HEAVY TRUCKS. THE PART NUMBER FOR THE FUSE/RELAY BLOCK IS 22767373 THIS ITEM IS NOT ON RECALL LIST. PLEASE HELP. THE VEHICLE HAS JUST OVER 9000 MILES ON IT AND THESE ITEMS ARE MAJOR, POTENTIALLY DANGEROUS PROBLEMS. THANK YOU

Reported

Jul 2018

Incident date

Jul 2018

Mileage

Not provided

Outcome flags

None reported

DRIVING ALONG INTERSTATE 10 OUR MOTOR HOME BEGAN TO SHAKE LIKE TIRES BEING OUT OF BALANCE. I STOPPED AT EXPRESS TIRE IN FREDERICKSBURG, TX. THEY FOUND THAT THE TREAD WAS SEPARATING ON THREE OF THE SIX TIRES. BECAUSE WE WERE TRAVELING I ONLY REPLACED THE THREE PROBLEM TIRES. CONTINUING OUR TRIP WE TRAVELED ANOTHER 1,000 MILES AND A FOURTH TIRE SEPARATED. AT THAT TIME I WAS ONLY 200 MILES FROM RETURNING HOME SO HAD THE SPARE PUT ON AND CONTINUED HOME WITH NO FURTHER PROBLEMS. I DO INTEND ON PURCHASING FOUR MORE NEW TIRES BEFORE OUR NEXT TRIP.

Reported

Jul 2018

Incident date

Jun 2018

Mileage

Not provided

Outcome flags

None reported

VEHICLE WOULD TURN OVER BUT NOT START. CODE FOR CRANKSHAFT POSTION SENSOR. REPLACED. STARTED. 3 DAYS LATER VEHICLE WOULD NOT START. CODE FOR CAMSHAFT POSTION SENSOR. ON ORDER. VEHICLE WAS STATIONARY BOTH TIMES.PLEASE NOTE THIS VEHICLE IS IN PRISTINE CONDITION AND ONLY HAS 9000 MILES ON IT.

Reported

Jun 2018

Incident date

Jun 2018

Mileage

Not provided

Outcome flags

None reported

2013 COACHMEN FREELANDER -CHEVROLET EXPRESS 4500 CUTAWAY. MILEAGE -19,662; BRAKE LINE RUSTED OUT AND BRAKE FLUID LEAKED OUT. BRAKES FAILED WHILE ON THE ROAD, WARNING MESSAGE "SERVICE BRAKES'". MADE IT TO A CHEVROLET DEALERSHIP AND BRAKE LINE REPLACED. *DT UPDATED 10/5/18*JB *TR

Reported

May 2018

Incident date

May 2018

Mileage

Not provided

Outcome flags

None reported

THIS IS THE SECOND TIME I AM REPLACING THE RADIATOR. BECAUSE IT IS LEAKING FROM A SEAM ON THE TOP OF THE RADIATOR. EVEN THE MECHANIC SAYS IT IS A MANUFACTURERS DEFECT IT HAPPENED THE FIRST TIME AT AROUND 46000 MILES AND NOW AGAIN AT 120000. THIS IS NOT RIGHT !!!

Reported

Apr 2018

Incident date

Apr 2018

Mileage

Not provided

Outcome flags

None reported

THE TRANSMISSION IS SLIPPING AND I ONLY HAVE 77,000 MILES. IS THIS NORMAL? THE VAN IS ONLY A 2013 MODEL.

Reported

Dec 2017

Incident date

Dec 2017

Mileage

Not provided

Outcome flags

None reported

FAULITY CONTACT IN IGNITION SWITCH AND FAULITY NEUTRAL SWITCH. VEHIVLE DOES NOT START HAVE TO HOLD AUTOMATIC SHIFTER ON COLUMN TO START. NOT MAKING CONTACT WITH IGNITION.

Reported

Oct 2017

Incident date

Oct 2017

Mileage

Not provided

Outcome flags

None reported

THIS VEHICLE WILL NOT TURN OFF WHEN THE IGNITION KEY IS REMOVED. THIS POSES A GREAT RISK TO ANY PASSENGERS IN THE VEHICLE AS IT CAN BE MOVED WITHOUT THE KEY IN THE IGNITION. THE VEHICLE REMAINS FULLY POWERED WITH THE KEY REMOVED.

Reported

Sep 2017

Incident date

Sep 2017

Mileage

Not provided

Outcome flags

None reported

AIR BAG FRONT CRASH SENSOR FAILURE. AIR BAG LIGHT CAME ON ON START UP.

Reported

Aug 2017

Incident date

Aug 2017

Mileage

Not provided

Outcome flags

None reported

VEHICLE GOES INTO ENGINE REDUCED SPEED AND SERVICE TRACTION CONTROL AND SERVICE STABILI TRACK WARNING LIGHTS TURN ON. I HAVE HAD THIS PROBLEM STARTING A WEEK AFTER I PURCHASED MY VAN AND WAS "REPAIRED" ON NUMEROUS OCCASIONS AND THE PROBLEM KEEPS REOCCURRING. THE INCIDENTS HAPPEN WHILE DRIVING AND WHEN STATIONARY WHILE ENGINE WAS RUNNING. THE DEALER REPLACED THE ACCELERATOR PETAL ASSEMBLY A COUPLE OF TIMES AND ALSO REPLACED THE THROTTLE BODY POSITION SENSOR AND THE PROBLEM STILL CONTINUES. THE LAST TIME I TOOK IT IN THE DEALER PUT DIELECTRIC IN THE HARNESS AND SAID I MIGHT HAVE A MOISTURE PROBLEM. THE PROBLEM REOCCURRED AGAIN A FEW WEEKS LATER. I DON'T SEE HOW MOISTURE COULD BE THE PROBLEM SINCE IT STARTED A WEEK AFTER PURCHASE AND CONTINUES 4 YEARS LATER.

Reported

Apr 2017

Incident date

Apr 2017

Mileage

Not provided

Outcome flags

None reported

ENGINE WILL NOT START WHEN BELOW 30 DEGREES F.

Reported

Jan 2017

Incident date

Jan 2017

Mileage

Not provided

Outcome flags

None reported

TL* THE CONTACT OWNS A 2013 CHEVROLET EXPRESS. WHILE DRIVING 43 MPH, THE VEHICLE WAS INVOLVED IN A CRASH. THE AIR BAGS DID NOT DEPLOY. IN ADDITION, THE SHOULDER OF THE SEAT BELT DID NOT LOCK, WHICH CAUSED THE CONTACT'S BODY TO BE JERKED AROUND IN THE SEAT. THE REAR PASSENGER SEAT BELT FRACTURED. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES TO THE HEAD, THUMB, LOWER TORSO, AND KNEES. THE CONTACT ALSO SUFFERED WHIPLASH. MEDICAL ATTENTION WAS REQUIRED. THE VEHICLE WAS TOWED TO A REPAIR SHOP. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 48,000.

Reported

Oct 2016

Incident date

Jul 2016

Mileage

Not provided

Outcome flags

Crash 1 injuries

TL* THE CONTACT OWNS A 2013 CHEVROLET EXPRESS. THE CONTACT STATED THAT THERE WAS A WARNING LIGHT THAT RANDOMLY FLASHED, INDICATING A LOSS OF ENGINE POWER. IN ADDITION, THE VEHICLE RANDOMLY STALLED MORE THAN ONCE. THE FAILURE WAS REPORTED TO A DEALER, BUT THEY DID NOT HAVE THE TOOLS TO PROVIDE DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 2,000.

Reported

Jul 2016

Incident date

Mar 2016

Mileage

Not provided

Outcome flags

None reported

CONCERN THAT VEHICLE HAS NO TPMS. IF TIRE WOULD DEFLATE COULD CAUSE VEHICLE LOSS OF CONTROL. RECEIVED RECALL ALERT FROM SUPPORT@DEALERRATER.COM #15819. STATING THAT SOME VEHICLES HAD BEEN RECALLED BECAUSE VEHICLE DID NOT PASS FMVSS NUMBER 138.

Reported

Apr 2016

Incident date

Apr 2016

Mileage

Not provided

Outcome flags

None reported

THE VEHICLE RANDOMLY AND AUTONOMOUSLY APPLIES THE BRAKES AND CUTS ENGINE POWER WHILE DRIVING. AT THIS TIME THE VEHICLE STATES "SERVICE STABILITRAK" AND THE ICON FLASHES THAT I AM SKIDDING, WHICH I AM NOT (I HAVE VIDEO PROOF OF THIS OCCURING). AFTER 4 TRIPS TO THE DEALERSHIP THE PROBLEM STILL PERSISTS. IT IS ONLY A MATTER OF TIME FOR THIS TO OCCUR WHILE MERGING, OR MAKING A LEFT ACROSS TRAFFIC AND CAUSE A SERIOUS AND POTENTIALLY FATAL COLLISION.

Reported

Jul 2015

Incident date

Jun 2015

Mileage

Not provided

Outcome flags

None reported

TL* THE CONTACT OWNS A 2013 CHEVROLET EXPRESS. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND THE ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED TWICE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 65,000.

Reported

Jun 2015

Incident date

Jun 2015

Mileage

Not provided

Outcome flags

None reported

TL* THE CONTACT OWNS A 2013 CHEVROLET EXPRESS. WHEN ATTEMPTING TO ACTIVATE THE WINDSHIELD WIPERS DURING EXTREMELY COLD TEMPERATURES, THE WINDSHIELD WIPER FLUID FROZE AND THE WIPERS BECAME INOPERABLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 59,100.

Reported

Jan 2015

Incident date

Jan 2015

Mileage

Not provided

Outcome flags

None reported

THE FIRST AND SECOND (OF THREE INCIDENTS) BOTH APPEARED MINOR, LASTING ONLY A FRACTION OF A SECOND. ABOUT HALF WAY THROUGH A 150-MILE DRIVE, THE ENGINE WENT DEAD BUT AS QUICKLY FIRED UP AGAIN SO AS NOT TO BE TAKEN SERIOUSLY BY ME. BUT A THIRD INCIDENT WAS WORRISOME. WHILE DRIVING ABOUT 50 MPH ON A STRAIGHT, FLAT-AND-LEVEL STRETCH OF A MACADEM FARM ROAD, THE VAN SUDDENLY, VERY ABRUPTLY, SHIFTED INTO WHAT MUST HAVE BEEN ITS LOWEST GEAR, AND DURING ABOUT 15 OR 20 SECONDS THEREAFTER IT JERKED BACK AND FORTH AS IF IT WERE STRUGGLING TO CLIMB A VERY STEEP HILL. I HAD NOT BEEN SHIFTING OR TRYING TO SHIFT GEARS, AND HAD BEEN TRAVELING UNEVENTFULLY BEFORE I WAS THROWN AGAINST THE STEERING WHEEL. (NO BRAKE LIGHTS WOULD HAVE WARNED OTHER VEHICLES THAT THE VAN WAS ABRUPTLY SLOWING DOWN, HAD I BEEN IN BUSIER, FAST MOVING TRAFFIC.) I VISITED THE (FAIRFIELD, LEWSIBURG, PA) DEALER FROM WHOM I BOUGHT THE BRAND NEW VAN, AND HE APPEARED UNABLE TO DISCOVER ANYTHING WRONG BUT "BRUSHED" CLEAN THE CONTACT POINTS WITHIN ELECTRONIC DISPLAYS (AS I UNDERSTOOD HIS EXPLANATION) ON THE DASHBOARD . BUT THE INCIDENT COULD NOT BE DUPLICATED JUST BY TEST DRIVING. HOWEVER, MY CONCERNS GREW AT THE PROSPECT OF AGAIN DRIVING LONG DISTANCES ON BUSY HIGHWAYS. I EMAILED CHEVROLET (AS DIRECTED IN THE VAN'S MANUAL).. LAST I RECALL, CHEVROLET ASKED THAT I RETURN A SURVEY SENT TO ME OVER THE INTERNET, BUT EACH OF NUMEROUS TIMES THAT I TRIED TO, USING THE PASSWORD THEY PROVIDED, I COULD NOT ACCESS THE SURVEY. THAT SURVEY SNAFU MAY BE WORTH MENTIONING BECAUSE WHEN I COMPLAINED ABOUT THEIR WEB SITE NOT FUNCTIONING, THEY REPLIED THAT THEY HAD NO PROBLEM ACCESSING THE SURVEY! ODD REACTION? SO I WAS NOT ABLE TO COMPLETE THE SURVEY, WHICH IS PARTLY WHY I AM SENDING THIS MESSAGE INSTEAD TO YOU. (THE VAN TO DATE HAS FEWER THAN 2,000 MILES DRIVEN.) *TR

Reported

Jan 2015

Incident date

Jun 2014

Mileage

Not provided

Outcome flags

None reported

V=INCIDENT HAS OCCURRED SEVERAL TIMES. EACH TIME VEHICLE TAKEN TO DEALER WHO "CORRECTS" THE PROBLEMS. LESS THAN A 1000 MILES LATER, PROBLEM REOCCURS. VEHICLE WILL BE TRAVELLING WHEN CHECK ENGINE & DEF INDICATOR LIGHTS COME ON. MESSAGE ON ODOMETER READS "EXHAUST FLUID QUALITY POOR" ... XX MILES UNTIL SPEED REDUCED TO 65 MPH. AFTER EACH INCIDENT THE DEALER INDICATES IT IS A SENSOR PROBLEM, NOT A FLUID QUALITY PROBLEM. THIS UNIT IS AN EMERGENCY RESPONSE AMBULANCE IN A RURAL AREA THAT MUST TRANSPORT EMERGENCY PATIENTS AT LEAST 30 MILES TO NEAREST HOSPITAL. *JS

Reported

Jul 2014

Incident date

Jul 2014

Mileage

Not provided

Outcome flags

None reported

WILL NOT TAKE FUEL. *JB

Reported

Sep 2013

Incident date

Apr 2013

Mileage

Not provided

Outcome flags

None reported

TL* THE CONTACT OWNS A 2013 CHEVROLET EXPRESS. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE FRONT PASSENGER SIDE BRAKE ENGAGED AND THE ELECTRONIC STABILITY CONTROL LIGHT ILLUMINATED. THE CONTACT STATED THAT HE SLOWED THE VEHICLE DOWN AND THE LIGHT TURNED OFF AND THE VEHICLE FUNCTIONED PROPERLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THAT THEY COULD NOT DIAGNOSE THE CAUSE OF FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 2,500.

Reported

Jun 2013

Incident date

Apr 2013

Mileage

Not provided

Outcome flags

None reported

THIS IS A C CLASS RV BY THOR MOTOR COACH. THE COACH SERIAL NUMBER IS [XXX]. THE VEHICLE WOULD NOT TAKE FUEL. I BOUGHT IT TO TWO CHEVROLET DEALERS WHO WOULD NOT LOOK AT IT BECAUSE IT HAD A MOTORHOME BODY. ONE DEALER HOOKED IT UP TO A FAULT FINDER AND FOUND THERE WAS A FUEL VENTING PROBLEM. THEY SAID IT LOOKED LIKE THE MOTOR COACH MANUFACTURER HAD CHANGED THE FUEL VENTING SYSTEM AND MOVED THE TANK. I FINALLY WAS SERVICED, UNDER WARRANTY, BY AN RV DEALER IN TULSA OKLAHOMA. THEY TOLD ME THE FUEL TANK HAD BEEN MOVED WHICH CAUSED A KINK IN THE FUEL FILLER HOSE TO THE TANK. THEY TOLD ME THIS WAS SOLVED BY CUTTING A SECTION OF THE FUEL FILLER HOSE TO MAKE IT SHORTER AND ELIMINATING THE KINK. MY CONCERN IS IN A ROLLOVER ACCIDENT WILL FUEL NOW LEAK? THIS IS A MEDIUM DUTY CHEVROLET CHASSIS SO I DON'T REALLY KNOW IF THE SAME STANDARDS APPLY AS DO CARS RE. FUEL CUTOFF WITH ROLLOVER ACCIDENTS OR IF I SHOULD REPORT THIS TO ANOTHER AGENCY? THANK YOU. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Reported

May 2013

Incident date

Apr 2013

Mileage

Not provided

Outcome flags

None reported

General Motors (GM) is recalling certain model year 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT; Chevrolet Avalanche, Express, Silverado HD, Silverado LD, Suburban, and Tahoe; and GMC Savana, Sierra HD, Sierra LD, Yukon, and Yukon XL vehicles, manufactured between November 7, 2012, through December 18, 2012, for failing to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect", and FMVSS No. 114, "Theft Protection and Rollaway Prevention." The vehicles may have been built with a fractured park lock cable or a malformed steering column lock actuator gear in the lock module assembly.

Risk: As a result, the vehicle may shift from Park with the ignition key removed or the ignition key in the OFF position. The vehicle may also shift out of Park without application of the brake pedal while the key is off. Either of these scenarios may cause the vehicle to roll away after the driver has exited the vehicle, resulting in a possible vehicle crash and/or injury.

Remedy: GM will notify owners, and dealers will inspect the affected vehicles and replace the steering column as necessary, free of charge. The recall began on January 21, 2013. Chevrolet owners may call 1-800-630-2438. Cadillac owners may call 1-866-982-2339. GMC owners may call 1-866-996-9463.

General Motors (GM) is recalling certain model year 2013 Chevrolet Express vehicles manufactured November 1, 2012, through December 21, 2012; and model year 2013 GMC Savana vehicles, manufactured November 14, 2012, through November 20, 2012. It may be possible to remove the key from the ignition when the vehicle is running or the transmission is not in the Park position. As such, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard 114, "Theft Protection."

Risk: If the ignition key is removed while the vehicle is still on and/or the vehicle is not in Park, the vehicle may rollaway and the unintended movement of the vehicle may result in a possible crash or injury to pedestrians.

Remedy: GM will notify owners, and dealers will replace the ignition lock cylinder and the two associated keys. This service will be performed free of charge. The recall began on February 8, 2013. For more information, GMC owners may call 1-866-996-9463 and Chevrolet owners may call 1-800-630-2438.

Explorer Van Company, Inc. is recalling certain model year 2013 Explorer and Explorer Limited SE vehicles built on GMC Savana and Chevrolet Express chassis, manufactured August 1, 2012, through April 9, 2013. The wiring harness that powers the seat adjuster and the seat heating circuit may not be properly secured. As a result, the harness may become lodged in the seat riser mechanism.

Risk: If the wires become lodged in the seat riser mechanism, they may become severed and potentially short circuit. A short circuit may result in a fire.

Remedy: Explorer Van Company will notify owners, and dealers will secure the seat wiring harness. Any damaged seat wiring harnesses will be replaced. These services will be completed free of charge. The recall began on May 10, 2013. Customers may contact Explorer Van Company at 1-800-926-7878. Explorer's number for this campaign is 2013-1.

General Motors LLC (GM) and IMPCO Automotive Division of IMPCO Technologies, Inc. (IMPCO) are recalling certain model year 2011-2013 Chevrolet Express and GMC Savana Cargo vans that have a compressed natural gas (CNG) fuel system installed as original equipment by IMPCO. The fuel systems, manufactured February 14, 2011, through February 20, 2013, have a fuel shut-off solenoid connector to the CNG tank that may corrode and form a short.

Risk: A short at the connector may cause overheating, resulting in an increased risk of fire.

Remedy: GM will notify owners and GM dealers/fleets will perform the remedy which will include replacing the solenoid assemblies and fuel pump fuses and adjusting the wiring routing. The recall began on August 5, 2013. GM's number for this recall is 13139. Impco's number for this recall is FA13GM001. Owner's may contact GM Fleet Action Center at 1-800-353-3867.

General Motors (GM) is recalling certain model year 2013-2014 Chevrolet Silverado HD, Chevrolet Express, and GMC Sierra HD vehicles, and model year 2013 GMC Savana compressed natural gas (CNG) vehicles that fail to comply with Federal Motor Vehicle Safety Standard No. 303 "Fuel System Integrity of Compressed Natural Gas Vehicles." In the affected vehicles, the text of the CNG fuel-only label is smaller than the required size, and as a result, may be less noticeable.

Risk: Text that does not conform to the required labeling size could inhibit fuel tank inspection practices and safe refueling, increasing the risk of a fire.

Remedy: GM will notify owners and will send them a replacement label, free of charge. The recall began December 3, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 13365.

General Motors LLC (GM) is recalling certain model year 2009-2014 Chevrolet Express and GMC Savana vans manufactured January 27, 2009, through March 7, 2014 with a gross vehicle weight rating of 10,000 pounds and less and equipped with front passenger air bags. In the affected vehicles, during a frontal impact below the air bag deployment threshold, if an unbelted front passenger's head hits the instrument panel above where the passenger air bag is located, the panel may not sufficiently absorb the impact. As such, these vehicles fail to meet the requirements of Federal Motor Vehicle Safety Standard number 201, "Occupant Protection in Interior Impact."

Risk: In the event of a crash below the air bag deployment threshold, an unbelted front passenger seat occupant has an increased risk of injury.

Remedy: GM will notify owners, and dealers will modify the passenger instrument panel free of charge. Notices to the owners of the heavy duty vans were mailed on April 28, 2014. The recall began on May 19, 2014. Chevrolet owners may call 1-800-630-2438. GMC owners may call 1-866-996-9463. GM's number for this recall is 14082.

General Motors LLC (GM) is recalling certain model year 2011-2014 Chevrolet Express compressed natural gas (CNG)vehicles manufactured September 10, 2010, to April 28, 2014, and GMC Savana CNG vehicles manufactured May 23, 2011, to April 21, 2014. The affected vehicles may leak natural gas from the CNG high pressure regulator.

Risk: A natural gas leak in the presence of an ignition source increases the risk of a fire or explosion.

Remedy: GM will notify owners, and dealers will replace the high pressure regulator, free of charge. The recall began February 13, 2013. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 14321.

General Motors LLC (GM) is recalling certain 2009-2014 Chevrolet Silverado HD and GMC Sierra HD, 2009 GMC Topkick 5000, 6000, 7000 and 8000 Series and Isuzu F Series, and 2009-2018 Chevrolet Express, and GMC Savana vehicles, equipped with certain Plastic-Handle Fire Extinguishers or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Risk: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: GM will notify owners, instructing them to contact Kidde to get a replacement fire extinguisher, free of charge. The recall began June 11, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Isuzu customer service at 1-866-441-9638. GM's number for this recall is 18146.