2012 Chevrolet Express

About 6:45 in the morning on November 10th, the vehicle was in a high-speed. Front end collision with adult cow elk at 70 miles an hour on the freeway, and the airbags failed to deploy in the Van on both front seats and the vehicle was severely damaged. Injuries were sustained.

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

Crash 2 injuries

Vehicle is upfitted as a school bus. Forward fuel tank strap failed in operation. Our company operates more than 100 of these vehicles and we experience a failure of fuel tank straps at a rate of about one vehicle per month. If the 2nd strap would also fail the gasoline tank would become dislodged and present a re hazard. This is even more critical as these vehicles are carrying students as a school bus. We perform visual inspections of the straps at 6 month intervals (per Pennsylvania these vehicles are subject to Semi-Annual State Inspection). There were no symptoms of the problem before this failure. There are never symptoms of the problem.

Reported

Apr 2025

Incident date

Apr 2025

Mileage

Not provided

Outcome flags

None reported

Vehicle is upfitted as a school bus. Forward fuel tank strap failed in operation. Our company operates more than 100 of these vehicles and we experience a failure of fuel tank straps at a rate of about one vehicle per month. If the 2nd strap would also fail the gasoline tank would become dislodged and present a fire hazard. This is even more critical as these vehicles are carrying students as a school bus. We perform visual inspections of the straps at 6 month intervals (per Pennsylvania these vehicles are subject to Semi-Annual State Inspection). There were no symptoms of the problem before this failure. There are never symptoms of the problem before any failure. Failed fuel tank straps on this were repaired by GM Dealer (Faulkner GMC, 705 Auto Park Blvd, West Chester, PA 19382) (Invoice #677658 - Invoice Date Feb 25 2025).

Reported

Mar 2025

Incident date

Feb 2025

Mileage

Not provided

Outcome flags

None reported

UNKNOWN...THE VEHICLE VEARED OFF ROAD AN INTO ON COMING TRAFFIC. Did not seam like steering was working properly. The final out come there were 2 deceased operators. In 2 different vehicles. I'm not sure if the recalls were ever repaired.

Reported

Aug 2023

Incident date

Apr 2023

Mileage

Not provided

Outcome flags

Crash 2 deaths

VEHICLE ROLLS WHILE IN PARK

Reported

May 2019

Incident date

May 2019

Mileage

Not provided

Outcome flags

None reported

TL* THE CONTACT OWNS A 2012 CHEVROLET EXPRESS 4500. IN COLD WEATHER, THE DIESEL EXHAUST FLUID (DEF) FROZE, WHICH CAUSED THE VEHICLE TO DECELERATE UNTIL IT EVENTUALLY IDLED. THE DEALER (KUPPER CHEVROLET, 1500 2ND ST NE, MANDON, ND 58554) STATED THAT THEY NEEDED TO KEEP THE VEHICLE IN A HEATED SHOP TO PREVENT THE DEF FROM FREEZING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS ALSO CONTACTED AND WAS UNABLE TO PROVIDE ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 86,000. THE VIN WAS UNAVAILABLE.

Reported

Feb 2018

Incident date

Jan 2013

Mileage

Not provided

Outcome flags

None reported

THE VAN IS A 2012 CUT AWAY SCHOOL BUS. ON 1-20-2018 DEVELOPED A GASOLINE LEAK ON THE VENT SIDE OF THE FUEL MODULE ON TOP OF THE FUEL TANK.TOOK TO CHEVY DEALER FOR REPAIRS. THEY REPLACED THE FUEL MODULE INTHE TANK. THEY HAD TO REMOVE THE TANK TO PERFORM REPAIRS. AT A COST OF 1188.39$.

Reported

Feb 2018

Incident date

Jan 2018

Mileage

Not provided

Outcome flags

None reported

HAVE A 2012 CHEVROLET CUT AWAY VAN FOR A SCHOOL BUS USE. STARTED LEAKING GASOLINE OUT OF THE PRESSURE SIDE LINE ON THE FURL MODULE. HAD TO HAVE TOWED TO CHEVY DEALER FOR REPAIRS. THEY HAD TO REMOVE FUEL TANK TO MAKE REPAIRS . THEY REPLACED FUEL MODULE IN THE TANK. THE COST OF REPAIRS WAS 1166.41$.

Reported

Feb 2018

Incident date

Jan 2018

Mileage

Not provided

Outcome flags

None reported

HAVE 2 2012 CHEVY CUT AWAY VAN SCHOOL BUSES WITH THE FUEL PUMP MODULE START LEAKING. 1 LEAKED ON THE PRESSURE LINE,THE OTHER ON THE VENT LINE. BOTH BUSES HAVE LESS THAN 150000 MILES.

Reported

Jan 2018

Incident date

Jan 2018

Mileage

Not provided

Outcome flags

None reported

WHEEL BEARINGS AND TIRES ARE BECAUSE OF RE-CALL ON THE TORG IS NOT ALIGN PUT BRAND NEW TIRES ON AND THE TIRES ARE ALREADY BALD IN THE FRONT.

Reported

Dec 2017

Incident date

Nov 2017

Mileage

Not provided

Outcome flags

None reported

I MANAGE A FLEET OF 53 SCHOOL BUSES, MODEL YEARS RANGING FROM 2008 TO 2015. I HAVE NOTICED A TREND WITH THE HYDRO BOOSTERS AND MASTER CYLINDERS, THEY TEND TO LEAK INTERNALLY ON THESE GM VEHICLES SOME HAVE BEGUN TO LEAK AS EARLY AS 30,000 MILES. I EXPECT TO HAVE TO REPLACE ALL OF THESE COMPONENTS, ON EVERY BUS IN THE NEAR FUTURE. AS THE FLEET AGES THE TREND IS GETTING INCREASINGLY WORSE. I BELIEVE THIS IS A DANGEROUS SITUATION BECAUSE I AM VIGILANT WITH KEEPING UP ON THIS ISSUE, HOWEVER I AM NOT SURE THAT THE GENERAL PUBLIC WILL HAVE THE SAME UNDERSTANDING ABOUT THE DANGER OF THIS DESIGN FLAW. I HAVE HAD BUSES COME IN BLEEDING BRAKE FLUID OR HYDRAULIC FLUID.

Reported

Apr 2017

Incident date

Apr 2017

Mileage

Not provided

Outcome flags

None reported

VEHICLE HAD NO RUNNING LIGHTS. CHECKED BULBS AND FUSES OK .VAN WENT TO CHEVY DEALER WAS CHARGED 100.00 CHECKOUT FEE. THE DEALER FOUND NO GROUND FROM BCM . THEY TOLD ME IT WOULD BE 752 55 TO THIS POINT FOR THEM TO RUN AN AUXILIARY CIRCUIT TO FIX OR IT WOULD COST 1200.00 -1500.00 TO FIND THE PROBLEM AND REPAIR. I WENT WITH THE CHEAPER OPTION. I DO BELIEVE NO RUNNING LIGHTS ON A VEHICLE WOULD QUALIFY AS A SAFETY CONCERN.

Reported

Feb 2017

Incident date

Dec 2016

Mileage

Not provided

Outcome flags

None reported

ON 9/30/2016, A THERMAL EVENT OCCURRED WHILE THE BUS WAS IN THE SHOP FOR ROUTINE MAINTENANCE. AS THE BUS WAS BEING MOVED (BACKED-OUT) OF THE SERVICE BAY AND SMOKE WAS SEEN ESCAPING FROM THE CNG TANK STORAGE COMPARTMENT AT THE REAR OF THE BUS. LOCATION: 4127 ELM ST., DALLAS, TX 75226 A DALLAS AREA RAPID TRANSIT (DART) EMPLOYEE QUICKLY OPENED THE COMPARTMENT AND EXTINGUISHED THE SMALL FLAME. DAMAGE WAS LIMITED TO THE CNG FUEL TANK SOLENOID (MELTED) AND THE CONNECTING HARNESS (MELTED). THIS VEHICLE HAS A HIGH PRESSURE ELECTRONIC SHUT-OFF SOLENOID VALVE MOUNTED DIRECTLY TO THE ON-BOARD CNG FUEL TANK(S). NOTE: IF THERE IS A FUEL LEAK OR OTHER COMBUSTIBLE MATERIAL IN THE VICINITY, THERE IS A RISK OF IGNITION. DART HAS A TOTAL OF 123 EA., 2012 MODEL YEAR GM 6.0L CHEV EXPRESS SHUTTLE BUSES WHICH WERE PURCHASED FROM NATIONAL BUS SALES & LEASING BY DART. PRIOR TO DELIVERY, THE BUSES WERE MODIFIED BY ARBOC AND CONVERTED TO DEDICATED CNG OPERATION BY IMPCO AUTOMOTIVE IN UNION CITY, IN. EACH VEHICLE IS CONFIGURED WITH (2 EA.) LINCOLN 21' X 80' CNG CYLINDERS FITTED WITH OMB SOLENOID VALVES MOUNTED INSIDE AN ENCLOSED STORAGE COMPARTMENT BEHIND THE PASSENGER AREA. THERE WERE SIMILAR OCCURRENCES DOCUMENTED UNDER OTHER RECALL NOTIFICATIONS (GM BULLETIN #: 13139 AND IMPCO AUTOMOTIVE #: 13V-225); WHERE THE OEM IDENTIFIED ROOT CAUSES AND CORRECTIVE ACTIONS. UNDER THOSE GM AND/OR IMPCO REPORTS AND/OR DEFECT RECALLS REPORTED TO NHTSA, SIMILARLY, THE CONNECTOR TO THE CNG FUEL TANK EXPERIENCED HIGH-RESISTANCE SHORT IN THE CONNECTOR AND CAUSED OVERHEATING OR IN SOME INSTANCES A SELF-EXTINGUISHING FLAME.

Reported

Dec 2016

Incident date

Sep 2016

Mileage

Not provided

Outcome flags

Fire

WE TOOK OUR VAN IN FOR A ROUTINE OIL CHANGE. OUR MECHANIC NOTICED THAT THE FUEL FILL CLAMP HAD BEEN RUBBING AGAINST THE BRAKE LINE THAT WAS STARTING AN INDENTATION FROM THE ONGOING RUBBING. HE HAD SEEN THIS HAPPEN IN ANOTHER 2012 CHEVY VAN, BUT IN THAT CASE, THE RUBBING OF THE FUEL CLAMP, RESULTED IN A BRAKE IN THE LINE, LEAKING OF ALL BRAKE FLUID, CAUSING TOTAL LOSS OF BRAKING FUNCTION & ABILITY TO STOP VEHICLE. OUR MECHANIC ADVISED US TO GO TO THE NEAREST CHEVY SERVICE CENTER, WHERE THEY COULD ORDER THE PROPER PARTS AND FIX THE ISSUE BEFORE SOMETHING TRAGIC (LIKE TOTAL LOSS OF BRAKE FUNCTION) COULD HAPPEN. I TRULY BELIEVE THAT THIS MALFUNCTION IS NOT AN ISOLATED CASE AND STEPS SHOULD BE TAKEN FOR AN IMMEDIATE RECALL TO CHECK THESE 2012 VANS.

Reported

Jun 2016

Incident date

Jun 2016

Mileage

Not provided

Outcome flags

None reported

THE ENGINE WILL GO TO LOW POWER AND NOT GO MORE THAN 30 MPH WITHOUT WARNING. THIS IS AN AMBULANCE CHASSIS AND IS A KNOW PROBLEM GM HAS NOT ADDRESSED YET IN THE 2012 AND 2013 CHASSIS. IT CAN DO THIS ON HWYS WITH SPEED LIMITS OF 55, 65, 70 MPH SUDDENLY WHICH COULD CAUSE AN ACCIDENT AS NO STOP LIGHTS GIVE ANY WARNING AND YOU CAN'T SPEED UP ANYTIME IN POOR VISIBILITY OR AT ANYTIME. NOT ONLY IS IT BAD FOR THE INJURED OR ILL PATIENT IT COULD CAUSE AN ACCIDENT AND INJURY OTHERS. GM HAS FIXED THIS ON THE 2014 AND NEWER MODELS BUT NOT 12 &13. THIS IS NOT JUST OUR ONE UNIT THIS IS 2012 AND 2013 CHEVY DIESELS AMBULANCE ALL OVER THE US. WE HAVE FOUR UNITS THAT IT CAN HAPPEN TO AND TWO THAT IS HAS WITH PATIENTS. I HAVE CONTACTED THE EPA, GM, AND OUR INDIANA STATE SENATORS TRYING TO GET THIS DANGEROUS SITUATION TAKEN CARE OF IN THE LAST FEW DAYS. I AM ASKING ANYONE WHO WILL LISTEN TO HELP PUSH GM FOR A FIX.

Reported

Sep 2015

Incident date

Sep 2015

Mileage

Not provided

Outcome flags

None reported

ENGINE WAS AT IDLE HAD PULLED INTO GAS STATION . ALARMS WENT OFF CHECK ENGINE LIGHT CAME ON, STABLE TRACK ERROR, MULTIPLE TONES. AFTER 20 SECONDS ENGINE STALLED. WOULD NOT CRANK. AFTER TALKING TO PEOPLE AND COUPLE TRIES FIX TOOK TO DEALERSHIP AS IT WAS DIAGNOSED TO BE THE ENGINE CONTROL MODULE SHORTED. I HAD GONE THRU RAIN EARLIER AND A COUPLE STORMS PASSED THRU WHILE AT STATION AND EATING. DEALER REPLACED ENGINE CONTROL MODULE AND PROGRAMMED IT. THIS COULD OF HAPPENED WHILE DRIVING AND WOULD OF LOST ENGINE POWER AND POWER STEERING. SINCE JUST MODULE REPLACED AND BEN TOLD IT IS KNOW TO SHORT OUT WHEN WET IT COULD HAPPEN AGAIN.

Reported

Sep 2015

Incident date

Jun 2015

Mileage

Not provided

Outcome flags

None reported

DRIVER'S SETABELT LOCKS UP, PREVENTING THE BELT FROM BEING DRAWN OFF THE REEL. THIS PREVENTS THE DRIVER FROM USING THE SEAT BELT. THE ISSUE OCCURS WHILE THE VAN IS PARKED AND STATIONARY, REPEATED ATTEMPTS TO GIVE SLACK ON THE REEL AND EXTEND IT ARE UNSUCCESSFUL. THIS IS THE THIRD CHEVROLET EXPRESS VAN MY COMPANY OWNS THAT HAS EXPERIENCED THIS PROBLEM.

Reported

Jul 2015

Incident date

Jul 2015

Mileage

Not provided

Outcome flags

None reported

TL* THE CONTACT OWNS A 2012 CHEVROLET EXPRESS. WHEN THE BRAKES WERE DEPRESSED AND RELEASED, THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE CONTACT MENTIONED THAT THE STABILITRAK ACTIVATED INDEPENDENTLY AFTER BEING TURNED OFF WITHOUT WARNING. THE VEHICLE WAS TAKEN TO DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 47,000.

Reported

Jun 2015

Incident date

Aug 2014

Mileage

Not provided

Outcome flags

None reported

DRIVER'S SEAT BELT REEL SEIZED WHILE THE VEHICLE WAS PARKED SO THE BELT COULD NOT BE EXTENDED AND BUCKLED. THE OPERATOR WAS NOT ABLE TO WEAR THE SEAT BELT AS REQUIRED BY LAW. VEHICLE WAS BROUGHT TO THE CHEVROLET DEALER AND REPAIRED UNDER TSB 05-09-40-002G TODAY, A SECOND VEHICLE OF THE SAME MAKE/MODEL 2014 MODEL YEAR EXPERIENCED THE SAME PROBLEM.

Reported

Oct 2014

Incident date

Sep 2013

Mileage

Not provided

Outcome flags

None reported

TRAVELING AT 50 TO 55MPH I MAKE A EASY BRAKE APPLICATION AND THE FRONT WHEELS WILL START OSCILLATING UNTIL THE FRONT GOES INTO A VIOLENT SHAKE. RELEASING THE BRAKE WILL STOP THE SHAKING. THIS IS A CUTAWAY SCHOOL BUS. I'M THE MECHANIC AND THE DRIVER BROUGHT IT TO MY ATTENTION. SHE NOTICED IT WHILE BRAKING ON A DOWNHILL. I WAS ABLE TO DUPLICATE IT ON A LEVEL SURFACE. HAVEN'T FOUND THE FIX YET. *TR

Reported

Apr 2013

Incident date

Apr 2013

Mileage

Not provided

Outcome flags

None reported

PARKING BRAKE CABLE FOUND RUBBING ON THE HYDRAULIC SERVICE BRAKE LINE, FORWARD OF THE REAR AXLE ON DRIVERS SIDE OF CHASSIS. WEAR IS EVIDENT ON HYDRAULIC SERVICE BRAKE LINE AND PARKING CABLE, ALONG WITH COMPONENT PARKING BRAKE ASSEMBLY WAS STUCK UNDER. *TR

Reported

Apr 2013

Incident date

Apr 2013

Mileage

Not provided

Outcome flags

None reported

THIS IS A BRAND NEW BUS, GM CHASSIS. IT HAS A LIMITED SLIP DIFFERENTIAL. THE BRAKE LINES ARE ROUTED IN FRONT OF THE REAR DIFFERENTIAL. TWICE, WE HAVE HAD ROCKS HIT THE BRAKE LINE AND SHEER IT OFF CAUSING TOTAL BRAKE FAILURE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Reported

Mar 2013

Incident date

Feb 2013

Mileage

Not provided

Outcome flags

None reported

VIOLENT SHAKING WHILE APPLYING BRAKES. *TR

Reported

Jan 2013

Incident date

Sep 2012

Mileage

Not provided

Outcome flags

None reported

GM IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET EXPRESS AND GMC SAVANA VEHICLES MANUFACTURED FROM JUNE 2, 2011, THROUGH OCTOBER 17, 2011. THE SECOND STAGE OF THE DUAL-STAGE AIR BAG WILL NOT INFLATE IN A SEVERE FRONTAL IMPACT. ACCORDINGLY, THE AIR BAGS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY NO. 208, "OCCUPANT CRASH PROTECTION."

Risk: AN IMPROPERLY DEPLOYED AIR BAG WILL INCREASE THE RISK OF INJURY TO THE OCCUPANT.

Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL INSTALL A NEW FRONT PASSENGER AIR BAG FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 29, 2011. OWNERS MAY CONTACT GMC AT 1-800-462-8782 OR CHEVROLET AT 1-800-222-1020.

GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET EXPRESS AND SUBURBAN VEHICLES, AND GMC SAVANA AND YUKON XL HEAVY DUTY VEHICLES. THE STEERING GEAR PITMAN SHAFT MAY NOT HAVE BEEN ADEQUATELY HARDENED AND COULD FRACTURE.

Risk: IF THIS CONDITION OCCURS, A LOSS OF STEERING COULD RESULT, INCREASING THE RISK OF A CRASH.

Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE STEERING GEAR AND, IF NECESSARY, REPLACE THE STEERING GEAR PITMAN SHAFT. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON APRIL 4, 2012.

General Motors LLC (GM) and IMPCO Automotive Division of IMPCO Technologies, Inc. (IMPCO) are recalling certain model year 2011-2013 Chevrolet Express and GMC Savana Cargo vans that have a compressed natural gas (CNG) fuel system installed as original equipment by IMPCO. The fuel systems, manufactured February 14, 2011, through February 20, 2013, have a fuel shut-off solenoid connector to the CNG tank that may corrode and form a short.

Risk: A short at the connector may cause overheating, resulting in an increased risk of fire.

Remedy: GM will notify owners and GM dealers/fleets will perform the remedy which will include replacing the solenoid assemblies and fuel pump fuses and adjusting the wiring routing. The recall began on August 5, 2013. GM's number for this recall is 13139. Impco's number for this recall is FA13GM001. Owner's may contact GM Fleet Action Center at 1-800-353-3867.

General Motors LLC (GM) is recalling certain model year 2009-2014 Chevrolet Express and GMC Savana vans manufactured January 27, 2009, through March 7, 2014 with a gross vehicle weight rating of 10,000 pounds and less and equipped with front passenger air bags. In the affected vehicles, during a frontal impact below the air bag deployment threshold, if an unbelted front passenger's head hits the instrument panel above where the passenger air bag is located, the panel may not sufficiently absorb the impact. As such, these vehicles fail to meet the requirements of Federal Motor Vehicle Safety Standard number 201, "Occupant Protection in Interior Impact."

Risk: In the event of a crash below the air bag deployment threshold, an unbelted front passenger seat occupant has an increased risk of injury.

Remedy: GM will notify owners, and dealers will modify the passenger instrument panel free of charge. Notices to the owners of the heavy duty vans were mailed on April 28, 2014. The recall began on May 19, 2014. Chevrolet owners may call 1-800-630-2438. GMC owners may call 1-866-996-9463. GM's number for this recall is 14082.

General Motors LLC (GM) is recalling certain model year 2011-2014 Chevrolet Express compressed natural gas (CNG)vehicles manufactured September 10, 2010, to April 28, 2014, and GMC Savana CNG vehicles manufactured May 23, 2011, to April 21, 2014. The affected vehicles may leak natural gas from the CNG high pressure regulator.

Risk: A natural gas leak in the presence of an ignition source increases the risk of a fire or explosion.

Remedy: GM will notify owners, and dealers will replace the high pressure regulator, free of charge. The recall began February 13, 2013. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 14321.

General Motors LLC (GM) is recalling certain 2009-2014 Chevrolet Silverado HD and GMC Sierra HD, 2009 GMC Topkick 5000, 6000, 7000 and 8000 Series and Isuzu F Series, and 2009-2018 Chevrolet Express, and GMC Savana vehicles, equipped with certain Plastic-Handle Fire Extinguishers or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Risk: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: GM will notify owners, instructing them to contact Kidde to get a replacement fire extinguisher, free of charge. The recall began June 11, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Isuzu customer service at 1-866-441-9638. GM's number for this recall is 18146.