2025 Toyota Highlander

On occasion the car will not accelerate from a dead stop like it should. I think it’s turbo lag. There have been a few times I thought I was going be broadsided pulling out into traffic when normal acceleration would have been safe but with a dead pedal for a few seconds it was terrifying. I’ve brought this up to two different dealers and they say without being able to experience it there’s nothing they can do. Someone going to die because of this.

Reported

Jul 2026

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

[XXX] was turning left onto [XXX] from [XXX]. Two lanes turn left. She was in the inside lane. The traffic light was red, and when it turned green, she started to turn. Partway through the turn, the steering became unresponsive. She couldn't get it to turn left, and she could not complete the turn, and crashed into the pole that holds the traffic signal. She traveled less than 100 ft total from the light to the pole. The accident was at 1:30 PM on a dry and clear day. The car has 8087 miles on it. There were no observed indications of warning lights and no symptoms of a problem. The vehicle was towed to a salvage lot, the Insurance company inspected it and declared it a total loss. All the airbags went off. I mentioned to the adjuster that there was a mechanical problem, and he said they would not investigate that. [XXX] suffered a broken rib on her left side and has some serious cuts from the airbag below the dash, and of course, the seatbelt soreness. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

Crash 1 injuries

After coming to a complete stop at a stop sign or stop light, then trying to go, the vehicle will stall. It will not go when given gas. The first time it happened, I was at a busy intersection with oncoming traffic coming towards me with the pedal to the floor, nothing would happen for 5-10 seconds. It was terrifying. Thank god the car coming towards us went around in time. It then happened again in my neighborhood a week later. Thankfully that time I wasn’t in traffic. I have noted that it seems to happen when very hot outside (Florida July summer) and air is on full blast. Also seems to be happening only during the first trip of the day, within the first 5-10 minutes of said trip. The dealership has not been able to recreate this to see for themselves. I think it would have to be with them overnight and they start it/drive it for the first time that day. It has now happened a total of 3 times since I’ve been driving it (2.5 months). I have 3 children and very worried I will get t-boned one day when it stalls next. I love my car so much so it’s heartbreaking that I have to drive it in fear. No lights/warnings/messages when this happens.

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

This vehicle has just over 18,000 miles on it and is 14 months old. It has a manufacturer design defect that allows small stones or birds to hit and puncture the air conditioning condenser. It is a known defect and Toyota refuses to warranty their product, forcing the consumer to pay out of pocket $1,500-$1,700 for repairs. Oddly, the sister Lexus vehicle has a screen over the condenser to prevent this.

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Radiator issue summer of 2025, when in back to back traffic at low speeds my vehicle overheated at a stand still took vehicle in to dealership with no real answers. The following summer 2026 same scenario but the engine was smoking. Took into dealership and they stated the connection for the radiator fan was disconnected which meant it was not colling the engine. A month later the AC is blowing hot air when AC is set to the coolest setting, scheduled another appt with dealership likely another radiator issue. Fuel gauge inaccuracy. Manual states 17 gallon tank capacity but my car states empty and can only fill the tank with 14 to 15 gallons. Dealership had no help and stated it does that to protect the hybrid engine. Transmission shifting issues, in the summer hotter temperatures I notice at times the transmission has difficulty shifting in lower gears and really revs up the RPMs to shift sometimes. At times the the transmission shift is jerky or harsh when going speeds form 20- 40 mph.

Reported

Jul 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Subject: Potential Safety Defect Report – Infotainment System Interference with Driver Assistance Systems This submission reports a potential safety-related software interaction issue involving infotainment startup processes and Toyota Safety Sense 3.0 (TSS 3.0). During startup conditions, infotainment system activity coincides with delayed or unavailable driver assistance alerts and camera system functionality. Observed Conditions: - Delay or suppression of collision warning alerts - Temporary loss of rear and surround-view camera feeds - System unresponsiveness during startup sequence Safety Concern: Potential reduction in driver situational awareness during low-speed maneuvering due to system prioritization conflicts. Request: Evaluation for potential systemic safety defect and determination of whether further investigation or corrective action is warranted.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

While I was driving using the screen for the GPS the screen become black just sound. The volume got stuck and no image was displayed. Try to use manual control on steering wheel and they didn’t respond neither. Is not the first time that the screen freezes glows black or just glitches.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2025 Toyota Highlander. The contact stated that while she and her husband were driving at 60 MPH, she heard a loud explosion noise from above her head and felt air whipping on top of her head. The contact stated that the sunroof exploded; however, the sunroof shield prevented the glass from entering the vehicle. The vehicle was steered to the side of the road and inspected, but the contact did not find anything wrong at that time. The vehicle was taken to a dealer where it was diagnosed that a rock may have hit the sunroof. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 8,498.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

While driving on the highway, I heard an extremely loud noise followed by rush of wind. I was not under or near an overpass and there was nothing to indicate an impact by a foreign object. I arrived at my house 10 minutes after the incident and inspected my car. I determined the noise I experienced was the panoramic sunroof, of which the front panel spontaneously exploded while operating the vehicle. I could find no other damage to the car. The sunroof and internal shade cover were closed and not in use, nor was I trying to operate them. The sunroof had a large hole in the center directly under a luggage rail, and the glass around the hole was angled upwards. The small shards of tempered glass were contained on top of the sliding sunroof shade. There was no foreign object, damage to the soft interior sliding shade, or any dents/scratches on the roof. Had the sliding shade been open, the shards would have rained down on me and any passengers (none at time of incident). There were no vehicle warnings of any kind. I took it to the Toyota dealer who inspected the damage but refused to cover it under warranty. I filed an insurance claim with photos and it was approved for repair.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Adaptive cruise control causes quicker wear on rotors. Had to have them replaced at 16,000.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The speedometer registers speed up to 7mph over actual speed for the first 15 miles then returns to matching GPS speed. Reported to Toyota, dealer said they have seen this before but not identified a fix as of today

Reported

May 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

While driving my new Grand Highlander, I have experienced a serious and recurring safety issue. Even with lane assist turned off, the vehicle automatically steers to the right when I exit a regular highway — apparently misinterpreting the widening road as a lane shift. When this happens, the steering overrides my input and I am forced to pull the wheel hard to regain control and stay in my lane. This loss of steering control is dangerous and frightening, and I am formally reporting it as a significant safety concern that requires immediate attention.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Component that failed: Sunroof How was safety at risk: I was driving my 2025 Grand Highlander on Sunday, [XXX} in the morning. While I was driving, my sunroof exploded, causing a loud noise and a blowout in the front part of the sunroof (pictures included). There was no debris on the road or any other reason for the sunroof to have exploded. This was extremely shocking and concerning - if we had not kept the sunroof shade closed, the glass from the sunroof would have fallen directly on myself and my wife as we were driving, potentially causing an extremely dangerous situation. The sunroof blew outward, NOT inward as would have been expected if something had hit it and caused it to shatter. I also found multiple forums where I discovered that this is a common problem: [XXX] [XXX] [XXX] The problem is widespread enough across models that there is an ongoing lawsuit regarding panoramic sunroofs: [XXX] The dealer and Toyota are claiming that it had to be an external source, but again, there was no debris in the area or any other reason to cause the blowout. The vehicle has been inspected by the manufacturer's field service technicians. It is currently still at the dealer, awaiting final decision on coverage for the blowout. There were no warnings. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

On multiple occasions (four) my 2025 Toyota Grand Highlander Hybrid Max has failed to accelerate when I push the gas pedal. Once in traffic, which was extremely scary and a huge hazard. I have contacted the dealership about this issue and have not heard back from them. It has been almost 2 weeks. No warming lamps turned on and this issue lasted about 15 seconds each time. I press the gas, the car does not respond other than an audible RPM raising sound.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

“The aluminum vehicle hood exhibits severe, abnormal fluttering and vibration across the rear-center section when driving at highway speeds (approx. 55-70+ mph). This movement is constant and highly distracting, creating a safety hazard by drawing the driver's attention away from the road and causing concern about the structural integrity of the hood latch system. Despite having the manufacturer's recommended repair (T-SB-0111-24) performed by an authorized dealership, the condition persists without improvement. I am concerned the hood could eventually unlatch or detach completely at high speeds, posing a danger to myself and other motorists.”

Reported

May 2026

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

The electronic parking brake on my 2025 Toyota Grand Highlander intermittently fails to auto-release when shifting from Park to Reverse or Drive. Curiously, the system does respond to the gear shifter when returning to Park, as the brake will then engage or release as expected once cycled. This indicates a failure specifically in the transition out of the Park position. This intermittent delay or refusal to release prevents the vehicle from moving when expected, creating a potential safety hazard in traffic or during time-sensitive maneuvers. No dashboard warnings are present, and the issue occurs even when the driver's seat belt is buckled and the foot brake is fully depressed.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

I was driving on in the left most lane on a highway at 70 miles speed with multiple trucks speeding from behind. My car suddenly lost acceleration and saw multiple warning messages on my car display. I barely managed to save my car from being hit by the trucks speeding from behind, applying emergency lights and steering my vehicle from the left lane to the right side of the highway. After towing the car to nearest dealer I understood that a stone went through the front grill of the car and it got the radiator converter leaking all the coolant and that created the loss of acceleration. This is a safety issue in the design of the car grill as it has unusually large holes leaving a critical part vulnerable and failure leads to loss of acceleration and a safety hazard. For similar other hybrid models in Lexus or Toyota Sienna the same grill is protected with smaller vents in the grill.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The 2025 Grand Highlander XLS front sun roof exploded. Will be taken to dealer upon appointment. Had the interior cover not been closed, we would have been showered with glass particles. According to many articles this is a known defect by Toyota. Lemberg Law phenom. Vehicle will be inspected by Toyoto dealer on Apr 29, 2026. There were no warnings. Outside temp was 64 degrees F. Traveling at 45 mph at 2:30 EDT, Apr 27, 2026. Massive exploding sound, like a gunshot. Pulled over to check vehicle and noticed front sun roof center blown outward and rest of glass fractured.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Due to the design of the grill located at the front end of the 2025 toyota grand highlander the vehicle poses vulnerability for multiple debris items to fly up into exposed air conditioning condensor. The damage caused by the debris is not covered by the warranty because it is considered an outside occurrence. However the design creates the vulnerability for the ac to become damaged. It is also sitting below the radiator posing an additonal risk for damage and should have additonal protection to help prevent damage. I am currently having to dispute the refusal to cover the damage to my own ac condensor done by a rock flying into the grill space causing damage and losing freon, because they state it is an outside occurrence regardless of the fact that the design is faulty. There are multiple people who have experienced this happening to their vehicles some not even at the 2000 mile mark and are responsible for the financial cost. Upon doing research the 2026 toyota grand highlander model was created with an even lower setting bumper that provides better coverage and protection for the air conditioning condensor and all other important mechanical components. Suggesting that Toyota is aware of the issue if they created an additonal part to help protect that area from damage. I am literally at risk each time I drive my car just for the fact that rocks are on every road way as well as other debris. I have called the customer relations department with no resolution given only to be told I am responsible for the cost of the repair. I believe this is something that needs to be addressed as well as fixed for the sake of the buyer and the already large cost of owning and maintaining a vehicle. If it happens more than a few times its not bad luck, it's a flaw in the creation of the product and consumers should not have to be held financially responsible for someone else mistake, whether individual or corporate entity. I have previously owned 4 other toyotas with no issues!

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

We have two forward facing car seats in the third row. When buckled according to the car seat user manuals - the seatbelts do not stay buckled. The seatbelts unbuckle while driving, creating an extremely dangerous situation for our toddlers. We take out and redo their car seats daily due to them being unbuckled while the vehicle is in motion. Our toddlers are not able to unbuckle them - so we know it is a vehicle defect. The car has been taken to the dealership where they simply tell us they can’t find an issue. We do not feel safe in this vehicle and do not want our children in there. No safety lights appear on the dash to notify us that the seats have become unbuckled.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Transmission slipping, holding high RPM, Jerky shifts, back seat not locking at times, infotainment freezing up

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Driving when it sounded like a gunshot went off in the car. I looked to the back of my car to see what was around me (nothing), and saw no damage to any windows. I could hear glass cracking so I went to open my moonroof screen to check the glass and I could hear glass on the screen so I closed it right back. I pulled over and was able to confirm the sunroof had busted across the back of the glass. It did not look like it was hit by anything, but like it blew out then spidered across the remainder of the glass.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Sunroof spontaneously exploded leaving an 8” hole and a completely shattered sunroof. The sunroof is flexed upwards like it was under extreme pressure. The high temperature was 70 degrees in Tuscaloosa today with cloudy skies and misty rain. So there shouldn’t have been any concerns from heat or cold. This left shattered glass every above the sunshade. Fortunately the shade was closed to catch most of the shattered glass.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The front panel of the sunroof shattered while the vehicle was parked in our garage. Glass shards are inside the car. The dealership submitted a claim to Toyota who denied any material defect and refused to repair under warranty.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

Dear National Highway Traffic Safety Administration, I am submitting this complaint to formally report a serious safety issue involving the left front axle of my Toyota Grand Highlander Hybrid XLE. The vehicle was first diagnosed by my local Toyota dealer on January 14, 2026, at which time the left front axle issue was identified. I contacted **Toyota Motor Corporation**, and I was initially informed that the required replacement part would arrive on February 6, 2026. After that date passed, I was told the part would arrive in early March. I have now been told it will not arrive until late March. Based on these repeated delays, I am concerned that “late March” could easily become late April or even later, with no firm commitment or guaranteed repair date. I have contacted Toyota dealership multiple times and made several phone calls seeking assistance, updates, or a definitive timeline. Unfortunately, no one has been able to provide a clear solution, firm delivery date, or alternative support while the part remains on back order. Due to the axle issue, I do not feel safe operating the vehicle, as I believe it presents a significant safety risk. This vehicle is essential for my work and daily financial responsibilities. Because I do not feel it is safe to drive, I am unable to use the car to earn my day-to-day income and meet my financial obligations. As a result, I am currently losing wages, and the prolonged delay is causing financial hardship and significant inconvenience. Given the safety implications and the ongoing lack of resolution, I respectfully request that the National Highway Traffic Safety Administration review this matter. I would appreciate guidance on the appropriate next steps, including whether this issue warrants further investigation, inspection, or potential recall action. I also seek clarification regarding what protections or remedies may be available to consumers when critical safety components are unavailable for extended periods.

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

outside temperature reading is 2 to 7 degrees high, which is not good when it makes the difference between freezing temps and not freezing temps

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The car was running perfect, 9 months after I bought this car, before 20,000 miles Front Left Axle become defective, and therefore, the dealer promised to reemplaced it, but I am still waiting from the dealer. It is a big risk to runs the car like that.

Reported

Feb 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

At a complete stop my car started shaking violently back and forth. It felt like we were in an earthquake. It has happened before but not as violently and not as long. No warning lights or anything. It has had problems with lurching and stuttering since we bought it. The dealership said they fixed it once (the stuttering) but it’s still happening. They cannot duplicate it and it’s not throwing any codes.

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

The entire life of the car from initial purchase the fuel gauge is incorrect. The car has a 17 gallon gas tank and the fuel gauge is calibrated to around 13 gallons. The car thinks it is out of gas around 13 gallons when there is actually 4 more gallons left.

Reported

Jan 2026

Incident date

Mar 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2025 Toyota Grand Highlander. The contact received notification of NHTSA Campaign Number: 25V744000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and diagnosed the vehicle and determined that the camera had failed, and that the contact would be notified when the remedy was available. The contact stated that after leaving the vehicle with the dealer, the back over camera started to fail. The back over prevention camera no longer switched the screen for the camera while in reverse, but remained on the home screen or radio instead. The contact had not heard from the dealer regarding the parts availability for the repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 29,000.

Reported

Jan 2026

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2025 Toyota Highlander. The contact stated while driving at an undisclosed speed, there was an abnormally strong odor entering the cabin of the vehicle through the vents. The windows were rolled down due to the obnoxious odor. The vehicle was taken to the dealer and the contact was informed that the vehicle was tested for leaks in the exhaust; however, no leaks were found. The contact was informed that the fumes were possibly from burning wires or a new vehicle odor because the vehicle was a brand-new vehicle. In addition, the contact was offered the option to trade the vehicle in for a new vehicle. The contact stated that the odor was extremely strong and foul, and the odor stuck to clothing and the contact’s skin. In addition, the contact described the odor as an old lawnmower or snow blowing odor. The contact was advised by the state Attorney General Office of Illinois to contact NHTSA Hotline to report the failure. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 100. The VIN was not available.

Reported

Jan 2026

Incident date

Apr 2025

Mileage

Not provided

Outcome flags

None reported

I am reporting a safety defect in the 2025 Toyota Highlander Hybrid Nightshade involving the multifunction turn signal switch. The interior trim adhesive on the steering column has experienced a chemical breakdown (adhesive migration), causing the turn signal stalk to become stiff and bind. This obstruction makes it difficult to engage the turn signal and occasionally prevents the signal from "auto-canceling" after a turn. The dealership has acknowledged the adhesive failure by authorizing the replacement of the steering column covers but refuses to replace the contaminated turn signal switch. Operating a vehicle with a binding turn signal switch is a direct safety hazard, as it compromises the driver's ability to communicate intent to other motorists. Additionally, the dashboard material is experiencing systemic delamination and producing a white crystalline powder (crystallized adhesive). I am requesting an investigation into the heat-resistance standards of the interior bonding agents used in the 2025 Nightshade trim, as these materials are failing and compromising safety-critical electronic controls. Thank XXX XXX

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

2025 Toyota Grand Highlander Hybrid AWD, with about 16000 miles. While driving, the brakes failed. The brakes would only work if the pedal was pushed all the way to the floor. A "Low Brake Power" warning light came on the dash. The following warnings came on at the same time. Parking Brake System, Advanced Ultrasonic Detection, Vehicle Stability Control, Check Engine, Smart Stop System, Brake System, Electronically controlled Brake, Secondary Collision Brake, Anti-lock Brake System. I was lucky to have been traveling on a road that was not busy and was traveling at less than 30 mph very close to my home. Had I been driving on the interstate, on a busy road, or near pedestrians, the event could have injured or killed myself, my family, or others. The car was towed into the dealership. The dealership said that the issue was not current and the car operated normally when after it was towed in. The following DTC codes where present (P05E000, P05E062). This indicates an issue in wiring or brake pedal stroke sensor. They suspect its an intermittent issue with the sensor. The sensor was replaced (P/N, 89510-0R010 and 62112-0E040-C1). They also said the car battery was low and replaced it (P/N 00544-H5061-540). The dealership said that they would send the affected part to Toyota for inspection, but I have not heard anything back. The dealership experience was poor (Mark Jacobson Toyota, Durham, NC).

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The vehicle takes an excessively long time to make heat, I know NHTSA only has requirements related to defrosting the windshield and it's clear Toyota is aware of the heating issue because they added an electronic defrost to be able to pass the defrost test. The vehicle when it is less than 20f outside takes 40+minutes to warm the cabin to a reasonable temperature. The dealership let the vehicle warm up in their 80deg F shop and said it took 20minutes to get heat out of the vents and claimed that this was normal behavior. I have owned several new cars and also work as an engineer in testing so I've driven countless new vehicles to do various tests and have never had it even take 20 minutes to have heat in a vehicle.

Reported

Jan 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

While driving under normal conditions, the air conditioning system in my Toyota Grand Highlander suddenly stopped working. The vehicle was inspected by a Toyota dealership, which determined that the AC condenser had a hole/puncture that caused a refrigerant leak and complete AC failure. Toyota denied warranty coverage, classifying the damage as “road hazard,” despite acknowledging that this is a common issue with the Grand Highlander. There was no collision, no unusual road event, and no warning prior to failure. The condenser appears to be positioned in a highly exposed and vulnerable location, allowing small road debris to puncture it easily. Based on discussions with the dealership and reports from other owners, this issue is occurring repeatedly and results in expensive repairs (approximately $1,500–$2,000). This appears to be a design-related vulnerability, not an isolated incident or abnormal use. A failure of the air conditioning system significantly impacts vehicle safety and operability, particularly in extreme heat conditions. I am reporting this issue to document a pattern of premature AC condenser failure in Toyota Grand Highlander vehicles and to request further investigation.

Reported

Jan 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Black Toyota Highlander Hybrid AWD 2025 ~15000 miles What component or system failed or malfunctioned, and is it available for inspection upon request? Without any warning, the braking action is delayed. It is a momentary loss and happens occasionally at light braking application, nowhere near hard enough to lock the wheels up The vehicle is available for inspection upon request How was your safety or the safety of others put at risk? If I were been closer to another vehicle/pedestrian/obstacle, an accident could happen Has the problem been reproduced or confirmed by a dealer or independent service center? No, yet, I will book an appointment to allow the dealer to verify the issue Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? NO Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? NO General: I have been driving the Highlander for a little bit more than a year, and this issue has happened at least 5 times, twice (2) this week

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

While accelerating from low speeds and turning, the car exhibits a rotational clicking noise from one or both front drive shaft assemblies. Seems to be the identical issue noted in the 2024 Grand Highlander that was presumably fixed during later production lots (T-SB-0082-24). That issue was seemingly solved with driveshaft replacement. The dealer said they “could not duplicate” the issue; however, it happens often while I am driving the vehicle and others have reported it to the same dealer as well. It seems to be an existing related safety issue that the dealer, and potentially the manufacturer, are ignoring until we get past the warranty.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2025 Toyota Grand Highlander with an Evenflo Revolve 360 Slim car seat, Model Number: 36812470A, Manufactured Date: December 12, 2022, installed in the vehicle. The contact received notification of NHTSA Campaign Number: 25C010000 (Child Seat). The contact stated that while driving at an undisclosed speed with the child secured in the car seat, the contact became aware that there was an object in the child’s mouth. The contact pulled over to the side of the road and removed a foam piece from the child's mouth. The contact inspected the car seat and became aware that the foam was from the headrest. Medical attention was not needed. The manufacturer was not notified of the failure, but the contact stated that the manufacturer mailed tape to cover the exposed areas of the car seat.

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Shortly after powering on the GHHM vehicle, driving a short distance, coming to a stop and depressing the accelerator the vehicle does not accelerate as though no power is getting to the drive train. This does not often happen but has always happened when the EV battery level is 3 bars or less and the vehicle is in its Normal mode (as opposed to Sport or ECO). This acceleration failure event lasts for a few seconds. No warning indicators are displayed prior to, during or after this happens. The dealer checked the vehicle on 30AUG2025, was not able to reproduce, but applied a firmware update TSB-0040-25, which has not solved the problem. Took it back to dealer on 14OCT2025, but the dealer was again not able to reproduce the problem. It poses a safety risk when attempting to cross intersections or entering round-abouts and the vehicle can only move at a coasting speed instead of the expected normal acceleration.

Reported

Nov 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

While driving at approximately 50 MPH with no other vehicles around, there was a loud bang and then the sound of air. We identified that the panoramic sunroof had exploded. We pulled over immediately and took photos of the sunroof which at that time was shattered but intact. There was a clear bulge upward and no sign of impact from an outside force. We then continued driving to our home approximately another 40 miles, during that drive shards of glass flew onto the roadway leaving a hole in the sunroof of approximately 10-12 inches. We brought the vehicle to Toyota dealership for a warranty repair. Toyota refuses to cover under warranty, stating outside influence. I am confident there was no outside influence causing the glass to explode. The vehicle is a 2025 Grand Toyota Highlander Hybrid Limited with approximately 9000 miles on it, the incident happened on Nov 2nd. 2025 around noon. Weather was mild, 50-60 degrees F, no precipitation or severe winds.

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Inconsistently but on numerous occasions, this vehicle has experienced harsh shifting, hesitation, or jerking during low-speed acceleration (e.g., 20-40 mph) or gear engagement. This was a known and reported issue with the 2024 model for which Toyota provided a fix. They have not provided one for the 2025 models. This issue is a safety risk while driving because with the surge you feel you must quickly let off the pedal, and with the hesitation you let off the brake indicating you will move forward yet the vehicle doesn’t accelerate.

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

On 11/02/2025 with the cruise at 55mph all glass closed. Heater on with no vehicles around, the sunroof exploded. It pushed up from the inside. With less than 9k miles on the vehicle. It took my dealer 8 days to look at it then Toyota denied the warranty. Then Quoted me over $2,100 to replace. This vehicle isn't safe to drive as told to me from the dealer.

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

There is a coolant leak in the hybrid radiator caused by a puncture. When taken to the dealer, they said a rock must have punctured it. The dealer currently has the part. Me, my husband, and 2 children were driving on I-5 when the car stopped accelerating and a "hybrid malfucntion" code and "engine malfunction" code started flashing. Prior to this, there were no warnings. I was thankfully able to full over safely, but we were stuck on the side of I-5 for at least an hour waiting for a tow. I am reading online that this is an issue with the car and seems to be a design flaw. The gaps in the grill are too large, and there is no mesh or anything else behind the grill to protect the front end of the car.

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Poor acceleration from 0 to 40. Vehicle will start shuttering at a dead stop. The engine has shut off once with this issue. It happened around 4800 miles.

Reported

Oct 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

Sun roof shattered unprovoked in 2 month old vehicle while driving slowly in parking lot. We didn't know what happened at first but then opened interior lining and the shattered glass fell into the cabin; nobody was hurt. when we took this to dealership, we were told this wasn't under warrantee and we had to get it fixed independently. I filed a complaint with Toyota Care but they denied covering cost to fix the shattered sun roof. We did not have the shattered sun roof inspected by anybody else but it has been fixed by glass shop.

Reported

Oct 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

While waiting for a traffic light to change, I pressed the pedal to accelerate, and the car would not move. Like my pedal was dead. I have experienced this issue three times. I have also experienced bucking or jerking issues.

Reported

Sep 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

Windshield is prone to cracks and chips. Experienced multiple chips/cracks going at various speeds with precaution to other vehicles.

Reported

Sep 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

I am told my 2025 Grand Highlander has a hole in the AC Condenser from "road debris" according to a Toyota dealership leading to no air conditioning. I've never taken the car off-roading. A simple google search shows that others are having this issue and are buying extra netting to protect it from happening again. I'm told I need to pay $1,800 to have this fixed when I haven't even had the car for a year. This seems like a design flaw that needs to be addressed.

Reported

Aug 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

I have experienced intermittent transmission issues. Specifically, the car often fails to shift gracefully from first gear, resulting in rough or hard shifts that are jarring and unsafe, particularly during acceleration or in stop-and-go traffic. On multiple occasions, the vehicle has refused to shift correctly, requiring me to pull over, turn the car completely off, and restart it to restore proper shifting functionality. This issue is not only inconvenient but also poses a significant safety risk, especially when merging into traffic or navigating busy roads. For a vehicle marketed as a reliable and family-friendly SUV, these transmission problems are unacceptable. The transmission issues have significantly undermined my confidence in the vehicle’s safety and reliability, particularly as I rely on it for family transportation. The need to pull over and restart the car to address shifting problems is not only inconvenient but also dangerous in certain driving conditions. Furthermore, the reports of similar issues among other owners indicate that these problems may persist without proper intervention from Toyota.

Reported

Aug 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

The car only accepts 11-13 gallons of gas when refueling an empty tank despite the advertised 17.2 gallon capacity. I believe this is a fuel gauge or DTE system problem. I’ve seen many many similiar complaints on the forums. Fuel gauge issue could leave drivers stranded on the road.

Reported

Aug 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023-2024 Toyota Venza, 2023-2025 RAV4 Prime, RAV4, Highlander, GR Corolla, Crown, 2024-2025 Lexus TX, LS, Toyota Tacoma, Grand Highlander, and 2025 Lexus RX, Toyota Crown Signia, Camry, RAV 4 Plug-in Hybrid (PHEV), and 4 Runner vehicles. Due to an error in the instrument panel software at vehicle startup, the instrument panel may fail to display vehicle speed, brake system, and tire pressure warning lights.

Risk: An instrument panel display that does not show critical information can increase the risk of a crash or injury.

Remedy: Dealers will update the instrument panel software over-the-air (OTA) for non-PHEV vehicles, free of charge. For PHEV vehicles, dealers will inspect the instrument panel assembly, and either replace it, or update the software, free of charge. Owner letters were mailed December 5, 2025. Additional letters will be sent, anticipated in May 2026. This is a phased recall. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB08 and 25TA08. Lexus' numbers for this recall are 25LB05 and 25LA05.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2026 Toyota, Lexus, and Subaru Solterra vehicles equipped with a Panoramic View Monitor (PVM) system. Please see the recall report for a complete list of models. A software error may cause the rearview camera to freeze or display a blank screen when the vehicle is in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Risk: A rearview camera that fails to display an image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

Remedy: Dealers will update the parking assist software, free of charge. Owner letters were mailed January 2, 2026. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB13 and 25LB06. Subaru's number for this recall is WRE25.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2024-2025 Highlander and Highlander Hybrid vehicles. The third row center seat belt roof anchor may have been installed at an incorrect angle, preventing the seat belt from properly restraining the occupant.

Risk: A seat belt that does not properly restrain an occupant increases the risk of injury during a crash.

Remedy: Dealers will reinstall the seat belt anchor with a new bolt, free of charge. Owner notification letters were mailed January 27, 2026. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 25TA16.