2021 Ram ProMaster City

Cracked cylinder head requiring full engine replacement at ~80,000 miles. Out of warranty. This is one of two vehicles, purchased at the same time from same dealer in 6/2021 with the same engine failure at ~80,000. Second vehicle is [XXX] . It is likely that these two vehicles came off the assembly line fairly close to each other, during covid and all the issues that that brought to supply chains and manufacturing. One I could have chalked up to bad luck. Two is just too much of a coincidence to believe that there isn't something wrong with these engines. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Dec 2024

Incident date

Nov 2024

Mileage

Not provided

Outcome flags

None reported

Cracked cylinder head requiring full engine replacement at ~80,000 miles. Out of warranty. This is one of two vehicles, purchased at the same time from same dealer in 6/2021 with the same engine failure at ~80,000. Second vehicle is [XXX] . It is likely that these two vehicles came off the assembly line fairly close to each other, during covid and all the issues that that brought to supply chains and manufacturing. One I could have chalked up to bad luck. Two is just too much of a coincidence to believe that there isn't something wrong with these engines. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Dec 2024

Incident date

Sep 2024

Mileage

Not provided

Outcome flags

None reported

Engine oil leak at the oil filter. The oil filter monting surface has a defect (not flat) allowing oil to push out. It is currently available for inspection, but it is scheduled to been seen by the dealer to be replaced under warranty. Safety - issue was noticed before enough damage was done to be unsafe. The leak was substantial, so I imagine it would lead to a safety issue due to abrupt engine failure. Oil filter was properly installed, verified by independent repair facility. Leak was reproduced / verified by independant repair facility. No warning indicators for the issue.

Reported

Apr 2022

Incident date

Mar 2022

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ram Promaster City. The contact had initially received a recall notice for NHTSA Campaign Number: 21V728000 (Exterior Lighting). He then called the dealer and was informed that there was an additional recall on the vehicle for NHTSA Campaign Number: 21V699000 (Seat Belts) however, the parts for the recall repair were not yet available. He was informed that if he were to take possession of the vehicle, he would be held liable for any vehicle failure, including any recalls. The vehicle remained in the possession of the dealer and was not serviced. The manufacturer was also notified of the issue but offered no assistance. The contact stated that the manufacturer had exceeded reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect. Vehicle has been repaired. Dealer made arrangements for a loaner at no charge.

Reported

Dec 2021

Incident date

Nov 2021

Mileage

Not provided

Outcome flags

None reported

Two instances of rooftop tent opening without human interaction. Incident 1 // 9-17-21: Vehicle was parked and the front drivers side latch (attached photo) opened due to gusts of wind. Incident 2 // 9-19-21: When driving approximately 65 mph (cruise control) on Interstate 40 in Arizona, the front passenger side latch released and front passenger side of rooftop tent opened. I could not see that the tent opened while driving but noticed a change in wind noise and also steering control. I immediately pulled off the highway and observed that the front passenger side of the tent was open and about a 6 inch gap between the top and bottom halves of the tent was exposed. The center strap and drivers side latch were both still engaged. At the speed of travel it was possible for the tent to open completely which could have harmed my passengers or drivers of other vehicles on the road. I have seen numerous reports of this problem on the Roofnest Flock facebook group. The equipment is available for inspection upon request. It has not been inspected by anyone else. There was no warning sign other than the product opening while parked. The product was purchased in May 2021.

Reported

Sep 2021

Incident date

Sep 2021

Mileage

Not provided

Outcome flags

None reported

Chrysler (FCA US, LLC) is recalling certain 2021 Ram ProMaster City and Ram ProMaster vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: An unsecured child restraint system can increase the risk of injury during a crash.

Remedy: Dealers will inspect and replace the seat belt retractors as necessary, free of charge. Owner notification letters were mailed October 28, 2021. Owners may contact FCA US LLC customer service at 1-800-853- 1403. FCA US LLC's number for this recall is Y61.

Chrysler (FCA US, LLC) is recalling certain 2020-2021 Ram ProMaster City vehicles. The Anti-Lock Brake System (ABS) module may have internal damage, which could result in a loss of braking performance or autonomous braking functions.

Risk: The loss of braking performance or autonomous braking functions can increase the risk of a vehicle crash without prior warning.

Remedy: FCA US, LLC will notify owners, and dealers will replace the ABS module, free of charge. The recall began on March 30, 2021. Owners may contact FCA US, LLC customer service at 1-800-853-1403.

Chrysler (FCA US, LLC) is recalling certain 2019-2021 Ram ProMaster City vehicles. If one or both turn signal lights fail, the flashing rate may not change to warn the driver of the failure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: The driver may be unaware that the turn signals are not signaling their intentions to other drivers, which can increase the risk of a crash.

Remedy: Dealers will update the Body Controller Module (BCM) software, free of charge. Owner notification letters were mailed October 28, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is Y71.