2015 GMC Sierra 1500

my rear window defrost turned on when i auto started my pickup. i realized it was on after about a half hour and looked back and my drivers side of the rear sliding window was shattered completely

Reported

Jul 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

When backing up, either on a hill or flat surface, the brakes fail to stop the vehicle. There is a pulsing sensation with the brakes due to failure of the vacuum. The brake pedal also becomes impossible to depress. No warning lights appear when this occurs.

Reported

Jul 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2015 GMC Sierra 1500. The contact stated that while driving at 25 MPH, the front driver's seat belt completely failed. The lap belt portion came apart, causing the chest strap to loosen. Upon inspection, the contact observed that the steel anchor cable bolted to the floor had separated. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 153,000.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

For no apparent reason the truck goes into “low power mode” and gives off code p2138 often happens around 30-35 mph. Have had it happen to me also around 45 mph also. I have replaced sensors and parts to which a month or so goes by and it happens again.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Vehicle doesn't stop in low speeds

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2015 GMC Sierra. The contact stated that while driving at an undisclosed speed and also while the vehicle was parked, the ABS and stability control warning lights would unexpectedly illuminate. The vehicle was taken to an independent mechanic, where the warning lights were cleared. The contact was informed that if the failure recurred, the EBCM and BPMV would need to be replaced. The vehicle was not repaired. The contact stated that the failure recurred. The vehicle was then taken to the dealer, where it was diagnosed that the EBCM and BPMV had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 90,100.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Active Fuel Management Miss firing Idle rough Shaking Loss of power #7 cylinder loss of all compression Bad fuel mileage Skipping

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2015 GMC Sierra 1500. While traveling on a two-lane highway at approximately 55 MPH, another vehicle suddenly turned into the contact's lane, resulting in a severe frontal "T-bone" collision. The force of the impact caused the other vehicle to be propelled into a ditch, while the contact's vehicle remained on the roadway. Despite the significant nature of the crash and the speed involved, no air bags deployed. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 218,000.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

Crash

Truck started to make loud clunking noise when driving taken it to two shops and wrong parts were installed as stated below. Bought from a used car dealership and they sold it as is now with the wrong parts.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Bad paint used by manufacturers that causes frames to rust out.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2015 GMC Sierra 1500. The contact stated that while driving at approximately 45 mph, he observed a popping noise beneath him. The contact stopped the vehicle and observed smoke emanating from the front of the vehicle. The vehicle went into limp mode, lost power, and when the brake was depressed, the vehicle did not slow the vehicle down as intended. The contact stated that as he pulled into a parking lot to inspect the vehicle, he observed flames emanating from the hood. The contact stated that he pressed the hood latch, which did not open the hood, and he then exited the vehicle and observed the hood engulfed in flames. The contact mentioned that a store employee brought a fire extinguisher out and attempted to extinguish the flames. The fire department was called and extinguished the fire fully. There was no police report, but the police did come out to assist. The contact sustained a right-hand injury, but medical attention was not needed. The vehicle was then towed to the residence. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 124,000.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

Fire

Another GM truck AFM failing. It failed at 70,000 miles causing P0307 cylinder 7 misfire. No aggressive driving just commuting to work. Truck just got done with a new oil change. It's another to add to the hundreds/thousands seen on Reddit threads of all 5.3/6.2 AFM/DFM that this organization turns a blind eye to.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

I had and still have the Brake Assist failure warning light on and having issues with brake pedal effort not working as it should to stop vehicle and also the stability control warning lights., the brakes hardly work at all at low speeds and most of the time don't stop the vehicle almost causing several crashes. I took vehicle to gm service center and they said they updated software but when I picked up the vehicle and drove it not long after the brake assist warning came back on and I still had no brakes at slower speeds and the problem had actually gotten worse than it was before i took it to them. I called the dealership and told them that the problem had not been fixed and it was worse they said that I would have to pay the service fee / price for parts if I wanted to bring the vehicle back in and to have problem fixed...I explained it was a re call and it was taken to them to have issue fixed in the first place ...and I was told I would have to pay since they updated software ..I then explained it was worse than when I took it to them and still got denied any kind of resolution to the problem. Nothing was fixed or solved. I still had the warning lights on dash and the problem was worse then when I took the vehicle to them for repair. Not long after the transmission went out and the vehicle hadn't been drove. So it sat for 2 yrs or so. I just got a new one put in and the vehicle still has the same problems with the brake system . I reached out to dealership once again and was told I would still have to pay to have the issues fixed when it was never taken care of by them to begin with.

Reported

Mar 2026

Incident date

Nov 2023

Mileage

Not provided

Outcome flags

None reported

I remote started my truck, and when I got to it there was smoke and a flame coming from the rear power window. The remote start activates the rear defrosters, which started the electrical issues. I shut off the engine, and a loud pop followed, which was the shattering of the driver side rear window. The flame went out, and could have easily ignited the tarp covering the truck bed. There were no warnings on the console for the issue, and no recalls available. I have seen similar recall, but in a different state and back in 2022. This leaves me with a shattered window in the back, which is unsafe for visibility, and a bill to pay due to manufacturing errors for a feature in the truck. The rear window is all melted, and the glass is chipping away.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

Fire

During day to day driving when the truck is accelerating from a stopped position there's a massive clunk or hard shift from either 1st to 2nd gear. have also heard similar complaints from other 2015 sierra 1500 owners saying the transmission is having a hard shift on acceleration from a stop. Have seen possible issues with the TCCM

Reported

Feb 2026

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2015 GMC Sierra 1500. The contact stated that while driving at an undisclosed speed, the brake pedal was firm and unresponsive, and the vehicle was difficult to stop. The vehicle eventually came to a stop with the ABS warning light illuminated. The vehicle was driven back to the residence. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 132,235.

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Tranmission is shuttering and not wanting to shift right

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2015 GMC Sierra 1500. The contact stated that while at a complete stop and attempting to shift into reverse(R), Drive(D) or park(P), the gear shifter was stuck, and the contact had to go underneath the vehicle to move the shifter cable into the intended gear. The vehicle was taken to an independent mechanic, where the upper and lower shifter cables were replaced. The contact stated that upon returning to the residence and attempting to park the vehicle, the gear shifter failed to remain in the intended gear and was moving unintendedly. The vehicle was not repaired. The dealer and the manufacturer were not contacted. The failure mileage was approximately 225,740.

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

I remote started my truck. I got in about 5 minutes later. When I shut the door the rear window, passenger side of the power sliding window blew out. GM says my VIN is not affected by the recall but my truck shows that it should have been part of the recall or customer satisfaction program. N192265660 Rear Window Defroster Thermal EventS

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The engine seized up traveling about 40MPH in the middle lane on a busy road with my child in the passenger seat. I was able to get off the busy road but part of my truck was still intruding into the lane. The truck is parked at my house. The vehicle has not been inspected by anyone and is still in the same condition as the day the engine seized. The only thing that indicted any issue was a couple popping noises right before the engine seized. It all happened while I was driving in traffic and I did not notice any indications on dash. I was more concerned about getting off the road and out of traffic before I got rear-ended or involved in a pile up.

Reported

Jan 2026

Incident date

Mar 2024

Mileage

Not provided

Outcome flags

None reported

The GMC Sierra 1500 started a knocking sound. The collapsed lifter on a AFM cylinder bent a push rod which led to cam failure. Metal fragments are throughout the oil system.

Reported

Dec 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

Loses power steering when vehicle is low speed or stopped. Same details as safety recall 14743 for 2015 gmc sierra.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2015 GMC Sierra 1500. The contact stated that while driving at an undisclosed speed, the vehicle lost power steering functionality and shut off. The contact was able to pull over to the side of the road even though the steering wheel was difficult to turn. The contact was able to restart the vehicle after several attempts. The contact stated that the failure had recurred while driving. The contact stated that the message "Service Stabili-trak" might have been displayed. The local dealer and another dealer were contacted and confirmed that the VIN was not included in NHTSA Campaign Number: 18V586000 (Steering). The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 130,379.

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2015 GMC Sierra 2500 Denali. The contact stated that while driving at 65 MPH, the vehicle lost motive power with the “Engine Power Failure” warning light illuminated. The vehicle was towed to the residence. The vehicle was later towed to an independent mechanic, where it was diagnosed and determined that the fuel system had failed and there were metal shavings in the fuel system. The contact was informed that the fuel system needed to be replaced. The vehicle was not repaired. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 160,000.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

While driving the vehicle at approximately 40MPH the motor made a tapping sound, I was able to pull into a parking lot and have the vehicle towed to the dealer. The dealer told me that the vehicle was out of warranty and appeared that under initial inspection the would have to rebuild the motor due to a lifter failure at the estimated cost of $18,000. I had the vehicle towed to a reputable repair shop and after the did a tear down to the small block they determined a bent push rod and broken lifter, all pushrods and AFM lifters were replaced at the cost of $10,754. dollars as invoice shows. The issue occurred again on 10/25/25 causing catastrophic failure that will cost me a complete engine replacement.

Reported

Nov 2025

Incident date

Sep 2024

Mileage

Not provided

Outcome flags

None reported

This occurred 5+ years ago. Coming home one night I had a sudden loss of power with the truck and barely made it home. Was able to limp the truck to the dealership the next day and was told that one side of the engines lifters had failed. Prior to the failure I had noticed a ticking sound coming from the engine that was becoming increasingly more prominent. It was several thousand dollars to repair. Fortunately the failure occurred near home, not on the freeway where I could have been dodging cars while trying to limp the truck to the shoulder. Some online research while the repair was being done revealed that several other owners with the 6.2L engine had the same problem. When I mentioned it to the dealer the response was that they had no bulletins from GM on the issue and I was stuck with the bill. Got the same response a year or two later when the torque converter on the transmission went out. The reason I am reporting it now is I saw that GM is recalling 6.2L vehicles with lifter issues but not back to 2015 even though the issue appears to go back farther than that. They claim it's limited to a specific run of engines for the recall. They have been having various lifter problems for many years that have put drivers in danger when they fail but refuse to acknowledge it. As for the repair they made to the engine I've driven another 70 K miles and the ticking has started again. I fear another failure. Please note that the date previously given for the incident is my best guess.

Reported

Oct 2025

Incident date

Jun 2020

Mileage

Not provided

Outcome flags

None reported

The temperature sensor in the transmission is faulty leading to hard/delayed shifting, shuttering, and vibration

Reported

Oct 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

Transmission failed at 110k miles roughly. Safety was put at risk due to this happening on a highway. Yes, transmissiom was replaced by a local repair shop, the means of failure was identical to thousands of vehicles in this model year failing prematurely. No it wasnt inspected by the dealer. No there was no warning light, we were going up a hill and it failed.

Reported

Oct 2025

Incident date

Apr 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2015 GMC Sierra 1500. The contact stated the front passenger’s seat belt was difficult to buckle, and it recently started unbuckling while a passenger was seated in the passenger’s seat with the seat belt buckled. The contact stated that when the seat belt was unbuckled, the seat belt warning light was illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic to be diagnosed or repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 170,000.

Reported

Oct 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

Lifter and camshaft failed

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

Push rod failure in #4 cylinder at 104,000 miles. Bent push rod. Possibly due to AFM.

Reported

Oct 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

I have owned 4 of these trucks in my lifetime ranging from 2007-2015 all equipped with the same drivetrain. 5.3l engine and 6l80 transmissions. All have had the same failures. The engine afm system particularly the lifters fail which in turn destroys the camshaft and destroys the engine. More importantly the transmission torque converter fails sending debris through the whole system causing a sudden loss of drive. This happened while driving down the road and was a safety concern for myself and others. This time it costed me $6500 to replace the transmission. All of the trucks I have owned experianced the same failures how is this not a problem?

Reported

Aug 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

Headlights on this vehicle, since purchased, have not cast enough light in order to see in unlit backroads, or extrememly dim areas. I have to drive with my brights on constantly, in order to get enough light thrown onto the road, for the left and right sides, as well as the front. These were not working well since purchase. I took my child to a friends house in rural PA, and I literally could NOT SEE THE street signs, let alone far enough down the road. I nearly hit a stone wall.. My eyes keep asking to see more, but truck does not produce enough headlight. I even went to the eye doctor, after that situation, thinking it was my vision dimming, but was told I have 20/20. There needs to be a formal recall. I am not the only one complaining about these HORRIBLE projection headlights. To replace these headlights would cost over 1000K, out of pocket, which is not something I should have to fix. I am complaining now, because with the light getting darker earlier, am noticing how lousy driving at night really is.. and honestly, being BLINDED by oncoming LED's , without having proper headlights on my truck in order to see when blinded, really [XXX]. Please address these [XXX]. Make headlights great again! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Aug 2025

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2015 GMC Sierra 1500. The contact stated that while the vehicle was parked, the contact’s son closed the front passenger’s side door, and rear window glass exploded. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was made aware of the failure and a case was opened. The approximate failure mileage was 163,353.

Reported

Aug 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

the steering assist fails, Power and steering is reduced at driving speeds. Steering wheel locks and vehicle looses voltage and stalls while driving at low speeds and have been close to collision. Vehicle was inspected by Group One Gmc in el Paso Texas. They did not fix recall because it "did not pertain to my vin" . There is a recall for the steering assist on all gmc 2015 1500, but not for my gmc 2015 1500 for some reason. Whether it was manufactured in the us or the moon its still a gmc 2015 1500 with faulty steering assist system from the manufacturer with an open recall. Thanks for your help

Reported

Aug 2025

Incident date

Mar 2025

Mileage

Not provided

Outcome flags

None reported

Starting vehicle in parking lot and backing out of parking space. Brakes failed and truck continued to roll backwards almost hitting a pedestrian. I was able to stop hard on the pedal and stop the vehicle. This has happened several times. I have a steep driveway and backing down to the street the brake pedal will unexpectedly have little resistance and the truck will continue to roll into the street almost hitting oncoming traffic.

Reported

Jul 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

The mount for the rear shock absorber has completely rusted away on the driver side. The tube is gone now that it was attached to. This is a way to new of a truck for that kind of rust to happen I have been around 40 year old trucks that this never happened to.

Reported

Jul 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

Brake pedal pivot nut came loose and fell off while driving.

Reported

Jul 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

When parking and turning the wheel the truck stalled, radio turned off and on, ac stopped working, battery reading dropped. Maybe an electrical issue since it happens continuously, while making turns at slow speeds the truck wants to turn off, lights dim then go back to normal.

Reported

Jul 2025

Incident date

Jan 2025

Mileage

Not provided

Outcome flags

None reported

At low speeds when applying the brake, whether in a turn or traffic, the vehicle will shut off completely. This has happened multiple times and has almost caused accidents on a few occasions. It has also happened while just driving down the road, the entire truck lost power and then came back, the windshield wipers came on as well.

Reported

Jul 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

fuel pump losses prime overnight. gas sprays from fuel line onto top of fuel tank. problem was brought to my attention by a repair shop.. found several instances listed on YouTube of this problem

Reported

Jul 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

I was driving pulling an empty small U-Haul trailer and attempted to pull in to a fuel station when my brake became impossible to depress. I barely was able to miss hitting gas pumps and ran down into a ditch before the truck stopped. I informed the dealership where I had just purchased this truck used. I took it to their service department and I was told there was no issues with the brakes. They had to have this recall bulletin in their computer system yet failed to make me aware or to perform this recall or report it to GM. The problem continues to worsen to the point I am scared to drive it. I almost rear ended another car at a stoplight yesterday because I was unable to depress the brake pedal. I stood on the brake and heard an electronic sound but finally came to a stop.

Reported

Jul 2025

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

I am writing to formally submit a serious safety complaint regarding the transmission in my vehicle, which nearly caused a life-threatening accident while driving under normal conditions. While traveling on a two-lane rural highway, I was attempting to climb a steep hill when the transmission suddenly began to slip. My vehicle lost power mid-ascent, despite steady pressure on the gas pedal. The RPMs shot up erratically, but the vehicle failed to accelerate. As I began to crest the hill, the transmission completely disengaged, forcing my vehicle into a free-roll situation. The danger escalated quickly. As I started to descend the hill, I attempted to downshift to control my speed—but the transmission would not respond. It slipped again, and I was essentially coasting with no engine braking. An 18-wheeler was behind me, approaching fast. I could see it barreling toward me in my rearview mirror, and I had nowhere to go. With the road shoulder too narrow and no pull-off in sight, I had to veer dangerously close to the edge to avoid being rear-ended. I truly believe that if the driver of the semi hadn’t taken evasive action, I would not be here to write this complaint today. This transmission failure is not only unacceptable—it is a critical safety issue. A vehicle should not lose all power and braking control during normal highway driving. This is not just an inconvenience or a performance issue. This is a defect that puts lives at risk. I am requesting that this transmission be investigated for an official recall. I have since learned that I am not the only one experiencing these symptoms, and it is only a matter of time before this defect causes a fatal accident. Please take immediate action to investigate this issue. I am willing to provide full documentation, diagnostic reports, and be available for further interviews if needed. Lives depend on it.

Reported

Jun 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

I am reporting a critical issue with the transmission. The transmission frequently slips, hesitates, and jerks unexpectedly during acceleration and gear shifts. On multiple occasions, the vehicle has lost power or failed to respond while entering intersections, merging onto highways, or attempting to accelerate—posing a serious safety risk. The issue often occurs without warning and has worsened over time. Additionally, there are instances of harsh downshifting, delayed engagement from park to drive, and sudden lurching forward or backward, which could easily result in a collision. Despite visits to the dealership and complaints made, the issue has not been resolved, and I’ve learned that many other owners of this same model have reported nearly identical symptoms. This appears to be a systemic problem with the transmission system. Given the safety risk, especially in traffic and at high speeds, I strongly believe this defect warrants immediate investigation and a formal recall.

Reported

Jun 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2015 GMC Sierra 1500. The contact stated while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle failed to stop as intended. No warning lights were illuminated. The contact noticed an abnormal sound, and the vehicle rolled forward before the vehicle stopped. The vehicle was taken to the dealer but was not diagnosed. The dealer was made aware of the failure. The contact was informed of an unknown recall; however, the recall repair had expired. The contact had not received a recall notification. The vehicle was not diagnosed or repaired by an independent mechanic. The manufacturer was made aware of the failure and confirmed that the recall had expired in June 2024. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 75,000.

Reported

Jun 2025

Incident date

Aug 2018

Mileage

Not provided

Outcome flags

None reported

See attached document for complaint.

Reported

May 2025

Incident date

Mar 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2015 GMC Sierra 1500. The contact stated while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle failed to stop as intended. The vehicle was taken to the dealer; however, the vehicle was not diagnosed. The vehicle was not repaired. The contact stated that the failure became a persistent failure. The manufacturer was made aware of the failure. The contact referenced an unknown recall repair as a possible cause of the failure; however, the VIN was not included. The failure mileage was unknown.

Reported

May 2025

Incident date

May 2016

Mileage

Not provided

Outcome flags

None reported

The contact owns 2015 GMC Sierra 1500. The contact stated that while driving on several occasions at various speeds, the vehicle lost motive power. The contact stated that the check engine warning light was illuminated for approximately a month. The vehicle was taken to an independent mechanic and the contact was informed the high-pressure fuel pump was leaking fuel into the crank case, and the high-pressure fuel pump needed to be replaced. The vehicle was repaired; however, the failure reoccurred approximately 1 year and 5 months later. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the high-pressure fuel pump needed to be replaced. The vehicle was repaired. The contact stated that on several occasions while driving at various speeds, there was a loud sound coming from the engine compartment. The vehicle was towed to an independent mechanic where it was diagnosed that the fuel injectors on one side of the engine were not working properly, and that the fuel injectors needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 178,137.

Reported

Apr 2025

Incident date

Nov 2023

Mileage

Not provided

Outcome flags

None reported

A valve spring broke while going around 40 mph. Was not accelerating when it happened. Destroyed the piston, head and cracked the block. Once apart found the AFM lifter had started to wipe a lobe on the cam. Engine shut off after running real rough luckily my son was able to pull over. Truck had regular service and taken good care of. My favorite truck I have ever had. Had 137,000 miles on the odometer. This could have ended badly.

Reported

Apr 2025

Incident date

Mar 2025

Mileage

Not provided

Outcome flags

None reported

With all the GM engine problems being recalled, the known issue witht he AFM/DOD on all the models 2013 and up on 5.3L and 6.2L engines should have been recalled. The valves are known to collapse and nending push rods, causing damage to the cam shaft. This can cause ht eengine not to run. The symptoms and possible icidents include the same as the current recall NHTSA Campaign Number: 25V274000. My engine has been repaired twice now due to this AFM/DOD issue. I have all the paperwork from GM dealer that repaired it. I will upload the first repair, I need to scan the second repair. The engine is now making the ticking valve sound ans the vehicle is services regularly. What component or system failed or malfunctioned, and is it available for inspection upon request? AFM/DOD valves collapse causing enegine damage. How was your safety or the safety of others put at risk? Lack of power while driving, loud engine knock Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, by the dealer Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Insepcted by the dealer, and only the damaged parts replaced, not all the valves that can still collapse. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No warning, engine light came on due to misfire on both incidents.

Reported

Apr 2025

Incident date

Dec 2021

Mileage

Not provided

Outcome flags

None reported

General Motors, LLC (GM) is recalling certain 2014-2016 Chevrolet Silverado 1500, 2015-2016 Chevrolet Tahoe, and 2014-2015 GMC Sierra 1500 vehicles that may have received an incorrect replacement tensioner cable assembly as part of a previous recall remedy or a subsequent repair. The flexible steel cable connecting the driver's seat belt to the outboard side of the seat may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.

Risk: A broken pretensioner cable reduces the effectiveness of the driver's seat belt, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the driver seat belt lap pretensioner, free of charge. The recall began on May 5, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212330040.

General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500, 2500, 3500, and Chevrolet Silverado 1500, 2500, and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.

Risk: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.

Remedy: Dealers will replace the left and right side RRAB modules, free of charge. Interim owner notification letters informing owners of the safety risk were mailed on August 18, 2021. Owners will receive a second notice when the remedy is available. Phase I owner notification letters were mailed on May 5, 2022. Phase II owner notification letters are expected to be mailed on May 31, 2022. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. This recall supersedes NHTSA recall number 20V-736. GM's number for this recall is N202324251.

General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.

Risk: As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192268490.

General Motors LLC (GM) is recalling certain 2015 Chevrolet Silverado 1500, Tahoe and Suburban, GMC Sierra 1500 and Yukon, and Cadillac Escalade vehicles. Electric power steering (EPS) assist may be lost momentarily, followed by a sudden return of EPS assist.

Risk: If EPS assist is lost and then suddenly returns, the driver may have difficulty steering the vehicle, especially at low speeds, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will update the EPS module software, free of charge. The recall began October 12, 2018. Owners may contact Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is 18289.

General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.

Risk: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.

General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado 1500 and GMC Sierra 1500 trucks manufactured January 29, 2013, to January 21, 2015. While entering the vehicle, the seat belt tensioner cable may be positioned such that the driver slides over it. This movement may result in the fatigue and separation of the cable.

Risk: If the tensioner cable separates, the driver may not be properly restrained in the event of a crash, increasing their risk of injury.

Remedy: GM will notify owners, and dealers will modify the vehicles to prevent the tensioner from being damaged. Any tensioner that has already been damaged will be replaced, free of charge. The recall began on August 11, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 15822.

General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.

Risk: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.

General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.

Risk: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.

General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500 and Chevrolet Silverado 1500 and 2015 GMC Sierra 2500 and 3500, and Chevrolet Silverado 2500 and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator.

Risk: If the end cap separates from the inflator, the compressed gas will escape and the end cap can be propelled into the vehicle, increasing the risk of injury or a crash.

Remedy: GM will notify owners, and dealers will replace the RRAB modules on the left and/or right side, free of charge. Interim owner notification letters were mailed on December 22, 2020. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. Note: GM filed a new recall, number 21V-504 that supersedes this recall. All vehicles previously recalled under 20V-736 will now be repaired under the new recall number 21V-504. GM's numbers for this recall are N202309680, N202309681, and N202309682.