2018 Ford Focus

The contact owns a 2018 Ford Focus. The contact stated that the vehicle intermittently stalled with excessive fuel consumption. As a former Ford independent mechanic, the contact diagnosed the vehicle with a deformed fuel tank. The vehicle was taken to the dealer, where the canister purge valve was replaced under NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline); however, the manufacturer denied coverage for the fuel tank replacement. The contact stated that the failure reoccurred. No warning light was illuminated. The contact later received notification of NHTSA Campaign Number: 26V369000 (Fuel System, Gasoline), and the vehicle was taken to the dealer, where the canister purge valve was replaced a second time; however, the failure persisted. The dealer notified the manufacturer of the failure. The vehicle was not further repaired. The failure mileage was approximately 180,000.

Reported

Jul 2026

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

An authorized dealership performed a mandatory manufacturer safety recall repair on my vehicle for the Engine Oil Pump Belt and Tensioner (Ford Recall 23S64 / NHTSA Campaign 23V-905). While performing this specific recall, the initial facility negligently compromised the cooling system and created a severe leak, directly causing complete and total engine destruction. A subsequent independent diagnostic inspection by a separate authorized dealership confirmed this negligence. The vehicle became instantly disabled while driving, creating a severe road hazard. Total documented property damages are $14,448.31. Furthermore, the dealership and Ford Corporate have explicitly refused to repair the vehicle, despite Ford's dealer bulletins authorizing long-block engine replacements for failures related to this recall. They have also refused to reimburse me for the totaled vehicle or the out-of-pocket expenses incurred. Ford customer service has employed shady tactics, denying liability and stonewalling my attempts to reach a resolution, completely failing to provide the remedy mandated by this safety recall. The vehicle and all documentation are available for inspection upon request.

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2018 Ford Focus. The contact stated that while driving at an undisclosed speed, the vehicle shuddered, and the transmission was not shifting properly while accelerating. There was no warning light illuminated. The vehicle was taken to a local dealer, where it was diagnosed with a clutch failure, and a clutch replacement was suggested at 27,000 miles. The vehicle was repaired under warranty. The contact stated that the shuddering persisted, and the purge valves were replaced after the clutch repair at 69,000 miles. The contact stated that on another occasion, while driving at an undisclosed speed, the vehicle shuddered and almost stalled. The vehicle was pulled over into a parking lot. The vehicle was driven back to the residence. The vehicle was taken back to the dealer, where it was diagnosed with a second clutch failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 86,000.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

I am adding a major update to my safety recall complaint because this dealership just tried to pull an illegal financial ambush on me.After my 2019 Focus started stalling out on the highway right after they did Recall 18V735, I brought it back. I explicitly told them in writing on our text thread: 'I do not authorize any standard diagnostic fees, parts, or repair charges.' I just wanted them to show me proof that they didn't pinch a wire or glitch the software during the recall work.Instead of showing me proof, they sent me a text message today saying my vehicle was 'ready for pick up' just to lure me down to the lobby. When I got there, they slapped an unauthorized invoice for $988.82 in front of my face for parts and labor. They did nearly $1,000 worth of work after I told them 'no' in writing, clearly trying to quietly fix their botched recall mistake under the table and force me to pay for it.When I showed the advisor the texts proving I denied the charges, the staff panicked and couldn't answer who authorized the job. I refused to sign it or pay it, and I walked out. My car is currently stranded on their lot because they are holding my keys hostage over unauthorized bills on a federal safety recall file. I have already escalated this to Ford Corporate under Case # CXH-0831-1568-S8L7B8

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Purge valve sensor and canister is malfunctioning causing my car to stall out

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The plastic gas tank was warped by heat and a faulty purge solenoid. The warped gas tank is a known issue for the 2018 Ford Focus and other versions of the car are covered by the recall, but my VIN apparently was not despite experiencing the same issue at less than 50,000 miles. The warped gas tank caused a dangerous car shutoff in traffic.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The ford focus I drive is constantly shuddering and having trouble selecting gears. The problem has been consistent since I bought the vehicle and I have read that this is a common issue with the ford focus transmission. I bought the vehicle for my sons first car and I can’t even let him drive it

Reported

Jun 2026

Incident date

Jun 2019

Mileage

Not provided

Outcome flags

None reported

The vehicle was serviced for NHTSA Recall 18V735 (Canister Purge Valve/Fuel Tank stalling hazard). Immediately upon pickup from the dealership, the vehicle began severely stumbling and stalling while driving on the highway. It died while driving on the street. The dealership's diagnostic paperwork confirmed an 'O2 sensor logic error causing the vehicle to stall' right after they performed the mandatory computer software flash and valve replacement. The dealership is refusing to verify if their technician damaged the adjacent wiring harness or glitched the software flash, leaving the vehicle an active highway stalling hazard. As for my experience, The car died in Clear Lake by Baybrook Mall. Extremely high traffic, almost got hit. (Yelled at by several drivers). Constant stalling happened in Baytown. Scariest incident was going over the very tall Fred Hartman bridge. My 10 year old daughter and I felt sure it was about to die and we were going to roll backward down the bridge becauseit kept dropping power. We took the ferry home because we were so scared.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

I had an oil pressure light come on while driving and it was followed by the car shutting off and not starting back up. It was towed to a mechanic who told me the timing belt broke while driving and the car requires a new engine. The car was the towed to a ford dealer who confirmed his diagnosis. The car has the 1.0l ecoboost engine and manual transmission. I saw that there is an open investigation on this exact problem and a recall would be greatly appreciated. I'm shocked they are allowed to use a wet timing belt and not a chain.

Reported

Jun 2026

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

Last July my car was overheating and breaking down as I was driving on I4 to work one morning which it overheated and broke down which was the precursor the last time My engine blew in December 2024 which the engine was already repaired January 2022 (Dumphy Ford,Pa), December 2022 (Tropical Ford, Fl) then I got notices there is a recall with the oil pump and belt since February 2023 however the remedy parts were not available and kept getting notices that the parts would be in by fall 2024 then it kept getting pushed back when they would be available, meanwhile my car broke down again July 2024 which the engine needed to be replaced and was covered because oil and coolant was leaking into the engine due to the recall and they still didn’t have parts available and then car broke down again December 2024 which Tropical Ford covered because the recall parts were still not available. So in July 2025 they attempted to fix it and I picked it up and it overheated again and they kept it till September 2025 and fixed a bunch of things like transmission, recall and other things and now the car began to overheat again and took it to [XXX] and now they are saying the engine is blown again… I believe the recall failed and I shouldn’t have to pay for the 5Th engine replacement INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The vehicle's transmission control module is not working. The Ford Focus vehicle put my family and I at risk because we would be driving along in the Ford vehicle then all of a sudden it would slow down abruptly in traffic as it loses power. We've only had the vehicle 7 years and it is one of the most expensive problems to have with the car. Many reports online state that transmission control modules and transmissions in general are known complaints for 2018 Ford Focus cars. A diagnostic was performed by a Ford dealer's service center. It was determined the part needs to be replaced. This is very dangerous. I would like for this to be repaired without causing any additional expenses to my family as the Ford company is aware that more than few models have this problem before reaching 7 years or 100,000 miles

Reported

May 2026

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

I replaced my canister purge valve prior to TSB or recall (18S32). Once I received the letter for reimbursement, I sent my paperwork to the dealer that performed the work (Pierre Ford Seattle on 01/05/25). They said they were going to reimburse me for the work that they did but did not. I went back to the dealer on 04/22/26 with my paperwork again. They made a copy and said they were going to submit my reimbursement. After a week or two they said that the recall reimbursement program had expired earlier this year.

Reported

May 2026

Incident date

Jan 2025

Mileage

Not provided

Outcome flags

None reported

This is the 2nd time the transmission has went on this vehicle. First time was 12/2022 when my son was on his way home from [XXX] to [XXX] from school. Towed to Ford in MA. Ford stated there was a recall on the TCM. Vin did not fall under the recall. Thank god we had Mechanical breakdown with Geico. Had transmission repaired. April 29, 2026, car will not go in reverse or forward once again! RIDICULOUS!!! Cant afford to get a new transmission. Vehicle does not even have 90K on it. If Ford is going to put out a recall, like they did years ago on this issue, they should put it out for ALL and not just certain models. We have always purchased Fords, but I am getting a little sick and tired of recalls not being all ALL the models for that year. Who can afford a new car nowadays?? Thank the [XXX] no one was injured while my son was driving. Ford needs to do something about this issue ASAP! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

While driving, the transmission went into limp/safety mode and became difficult to control. Diagnostic scan confirmed codes P0806 (Clutch Position Sensor A Circuit Intermittent) and P2872 (Clutch A Stuck Engaged). The failure is electrical — wiring harness damage near the clutch position sensor. This has happened multiple times. The vehicle is a 2018 Ford Focus SE with DPS6 PowerShift transmission. Repair estimates range from $1,500 to $2,600. The manufacturer has declined goodwill assistance despite this being a known defect on this model.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

While driving, the transmission went into limp/safety mode and became difficult to control. Diagnostic scan confirmed codes P0806 (Clutch Position Sensor A Circuit Intermittent) and P2872 (Clutch A Stuck Engaged). The failure is electrical — wiring harness damage near the clutch position sensor. This has happened multiple times. The vehicle is a 2018 Ford Focus SE with DPS6 PowerShift transmission. Repair estimates range from $1,500 to $2,600. The manufacturer has declined goodwill assistance despite this being a known defect on this model.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The vehicle has been inspected at the Ford dealership, erratic behavior, stalling in the middle of the street shaking miss shifting net starting not going in reverse not going back. It left me stranded on the streets very unsafe. It is an ended up being a TCM and the clutch and Forks. This is a known issue with this transmission. It needs to be recalled before someone gets hurt.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

RECALL 23V905 February 2024 This is a complaint about service for the Recall. Or, the lack thereof. Still hasn't been serviced by dealer Serramonte Ford in Colma, CA.650-395-2728 Car was delivered to dealer Wednesday April 22, 2026. And still hasn't been serviced, as far as I know. Inquired for status on Thursday 23rd, and Friday 24th. Never received any. call back. Called today, Saturday April 25, and was told that Service Department is closed. Left message on Service Manager voicemail. Monday the 27th will be 6 days without a car.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The dual clutch PowerShift DCT transmission has failed. When placed in reverse, the engine RPM increases when accelerating but the vehicle does not move at all. While driving forward, the vehicle struggles to reach 10mph and the transmission slips severely. The vehicle is essentially undriveable. The vehicle has gotten stuck on neighborhood roads on 3 separate occasions due to complete loss of reverse function. I was stuck for 30 minutes to an hour which put me in way too much preassure and possibly, I could have ended up in danger. The vehicle had to be physically pushed by hand to move it. This created a dangerous situation for myself and others on the road. An independent mechanic diagnosed and replaced the clutch actuator assembly and fuel pump. After repairs the problem persists unchanged. The mechanic has noted the vehicle requires a full transmission replacement. This is a known defect with the Ford PowerShift DCT transmission affecting multiple model years. Repair costs have exceeded $1,500 with no resolution. The failed transmission puts safety at risk as the vehicle cannot accelerate properly in traffic and has no reverse function. Problem has been confirmed by an independent service center. Vehicle is available for inspection.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Was seen by Ford Dealer And confirm TCM issues

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

During their recall repair work on my cpv/ecm recall Rowe Auburn Ford allowed my car to leave their custody with the airbag light on and have refused to take responsibility or offer resolution to fix this issue without costing me more money.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2018 Ford Focus. The contact stated that while driving approximately 65 - 70 MPH with the cruise control activated, the vehicle suddenly decelerated and then accelerated to the desired cruise control setting. The failure had occurred several times. Approximately 2 weeks later, while driving approximately 30 MPH, the vehicle stalled, and the hazard lights were activated. The vehicle was towed to the dealer, who diagnosed the vehicle with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed that the repair was not covered under warranty or recall. The failure mileage was approximately 150,000.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

I purchased a 2018 Ford Focus in Sept of 2023 with 30k+ miles. Financed. In April of 2025 the car started making strange noises when starting and then would not go into reverse. The car pushed in neutral and drove about 2 miles. Stopped for gas and then the car would not start. The car was towed to a mechanic. He had the vehicle for 2 wks trying to purchase a part called an Actuator. I reside on St. Croix USVI and purchased this vehicle from a fleet sale from Centerline Rental Cars. After the Actuators were placed, I drove the car and within a day had a screeching sound upon starting car. Drove it back to mechanic and we did a test drive.21 The car would slow down and speed up on it's own. The vehicle this time died and had to be pushed onto the lot. Was worked on again and still did not work properly. Car was towed to Ford Metro for analysis. The car now has 40k+ miles in 18 mos of use. They quoted me $4,213.00 for parts and labor. I am still paying $359.00 a month since April 2025. The car was towed back to my residence where it sits dead. Please advise.

Reported

Apr 2026

Incident date

Apr 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2018 Ford Focus. The contact stated that while driving at an undisclosed speed, the vehicle was shuddering, jerking, and hesitating to accelerate as needed. The vehicle then stalled. No warning light was illuminated. The vehicle was towed to the dealer, who determined that there was coolant intrusion into the cylinders and that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 26V011000 (Equipment); however, the VIN was not included in the recall. The manufacturer was made aware of the failure. The failure mileage was approximately 62,000.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

car stalled and I took it to three mechanics who all said transmission was shot.I replaced two oil pumps (low and high) in the last year or so also.Car is barely 8 yrs old with 101k miles on it. ONline says this problem is widespread.

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

Engine light is on with the code reading the clutch and the transmission is overheating with sticking gears as I drive

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Recall 23s64 was completed and immediately was smelling and losing oil. Took back to dealer twice and second time they said it was fixed. A few thousand miles later I had sudden turbo failure. Lost all power and a huge amount of smoke making it impossible for me and other highway drivers to see. The turbo failed

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

All a sudden struggling to start. Crankshaft was bad and replaced. Still had issues. Checked plugs and they needed replaced less than 18.5k miles since engine and plugs replacement (under previous owner). Still had trouble starting. At least 12 different codes. Dropped off for diagnostics and now they're saying they found coolant in the cylinders and I need a whole new UPDATED engine. If the engine was replaced just under 2 years ago, why was the updated engine NOT used?? Engine replaced at 65k miles in April 2024. I bought the car used in July 2025 with 78k. Car now has 84k. I can tell you the exact miles I was able to get out of it was 7887. That's it. I have not had my car since thanksgiving 2025. This issue is STILL ongoing.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The DPS6 clutch failed rapidly. It is available for inspection. The car will suddenly and aggressively speed up while trying to shift gears or will suddenly slow down when downshifting making a collision very likely. They problem has been confirmed by a dealer. It has been inspected by a ford dealership and confirmed bad. There were no warning lamps or other symptoms prior to failure. It first started around 2/08/2026. This is a well known faulty clutch in the ford focus and ford fiesta lines from 2012-2018. Several repair shops and dealerships in the area i spoke with all acknowledge the high rate of failures with this specific type of clutch.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

I am reporting about the recall that was previously done about the backup camera going black and hard to see out of ect for the ford fusion and other ford vehicles . However I own a 2018 ford focus SE hatchback and the camera is doing the same thing and it is not added to the recall so I am hoping you can investigate this and help with it getting a recall for safety because the recall on the other vehicles states it can cause an accident and this would be a huge issue as there are blind spots so the camera is important thank u for your time.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2018 Ford Focus. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine and Cooling); however, the part to do the recall repair was not yet available. The contact stated that while driving approximately 35 MPH, the vehicle stalled and stopped in the middle of the roadway. There was no warning light illuminated. The contact was unable to pull to the side of the road and activated the hazard lights. The vehicle was towed to the dealer, while the contact and her [XXX] son were picked up by the contact's grandmother. The dealer diagnosed the vehicle and determined that the failure was engine-related. The contact was informed that the repair would be covered under the recall; however, the part was not yet available. The dealer ordered the part. The contact stated that the vehicle had been with the dealer for approximately six weeks. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was unknown. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Feb 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2018 Ford Focus. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling). The contact stated that while driving at an undisclosed speed, the oil pressure and check engine warning lights illuminated. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the camshaft sensor was not operating properly. The vehicle was not repaired. The vehicle was taken to the residence, where a handheld diagnostic machine confirmed a failure with the camshaft. The contact’s son became aware that the rear sensor was covered in oil and the front sensor was dry. The vehicle was driven for 20 minutes but the failure persisted. Three separate dealers were contacted, but the contact was informed parts were not yet available. The manufacturer was notified of the failure but was unable to assist because parts were not available, even though it was indicated that parts were available. The failure mileage was approximately 89,000.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

At 80000miles I noticed misfires and replaced original spark plugs per spec At 107578, misfires occurred, when I pulled plugs pos 1 was completely worn out, as well as pos 4.Codes were seen P0304 and P0301. Car ran well after replacement. I have been troubled by loss of coolant lately and could find no leaks. Also temp gauge in dash “wanders” Being retired I can’t afford to go to dealership. I believe spark plugs should not wear out after approx 25000 miles No overheating of engine has occurred . I drive about 12000/yr. Car is available to be seen. Dealer has not seen car Concerned problem could cause engine failure. Thank you

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The engine stopped running do to bad timing belt / oil pump belt.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2018 Ford Focus. The contact stated that the vehicle was included in NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling) and was taken to the dealer to be repaired under the recall. Approximately 2-3 months after the recall repair was completed; while driving approximately 25 - 35 MPH, the engine made a loud thumping sound. There were no warning lights illuminated. The vehicle was not returned to the dealer. The manufacturer was not made aware of the failure. The failure mileage was 17,000.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Ford diagnostic revealed transmission friction element stuck in A. The service center mechanic said the damper unit, forks, motors, bearing sleeve, TCM needed to be replaced.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

There is a documented recall and class action suit filed and awarded that I was unaware of. I purchased this vehicle from Enterprise rental car and it was not disclosed to me. I have been repairing this exact issues with transmission skipping, stalling and making it dangerous to drive for years. The last independent service visit i was told there was nothing more that could be done except complete transmission replacement at my own expense. When looking for recall information my VIN is showing no issues. What’s happening and how do I stand with this situation?

Reported

Jan 2026

Incident date

Jan 2024

Mileage

Not provided

Outcome flags

None reported

The malfunctioned component Engine Oil Pump failed while driving on highway causing the vehicle to both overheat and stall all at once, causing the vehicle to stop running in the middle of a main highway forcing me and another pedestrian to push the car into a gas station, out of the way of oncoming traffic, Ford did send out a recall notice for the Failed Oil Pump in December 2025 the same month my vehicle broke down. The vehicle was inspected by a mechanics shop, Master Muffler & Brake repair shop in Wareham Ma. as well as Empire Ford of New Bedford, Master Muffler & Brake concluded that the Head Gasket had blown, and Empire Ford of New Bedford concluded the issue was due to a cracked engine block. Prior to any issue there had been no warning signs then once the 2018 Ford Focus began to stall an overheating warning light as well as the check engine light began to flash at the same exact time as the vehicle itself breaking down.

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Loss of engine power, engine noise. I am submitting this complaint regarding Ford Motor Company’s handling of an active safety recall affecting my vehicle and its failure to complete recall-related repairs after directing me to a dealership for evaluation. I previously filed a complaint with NHTSA regarding this safety issue. Following that complaint, Ford Motor Company contacted me and instructed me to bring my vehicle to an authorized Ford dealership for recall inspection and repair. I complied fully and delivered my vehicle as directed. The vehicle remains at the dealership and has not been returned to me in a repaired or operable condition. After the vehicle was brought to the dealership, Ford Customer Service opened Case # [XXX]. I was advised in writing by a Ford representative that the matter would be escalated and that a supervisor would contact me on or about December 30, 2025. No supervisor ever contacted me. I waited almost two weeks beyond the promised date and followed up by email with no response. When I later contacted Ford Customer Service by phone, I was informed that my case had been closed. I was not notified in advance of the closure, was not provided any written explanation, and the promised supervisory review never occurred. At the time the case was closed, my vehicle remained at the dealership and the recall issue had not been resolved. I am requesting that NHTSA review Ford Motor Company’s handling of this matter to determine whether Ford is complying with its own published recall bulletin and service guidance for this specific recall number, including required inspection, escalation, and resolution procedures. I relied on Ford’s recall bulletin and representations when bringing my vehicle to the dealership. I respectfully request that NHTSA evaluate whether Ford’s actions comply with federal recall obligations and whether recall-related cases are being closed without proper review, notice, or completion of required repairs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jan 2026

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

Ref Recall #23V905: I brought my 2018 Ford Focus into Northside Ford, San Antonio on Tuesday, Jan 6th, to comply with referenced recall. I was told that to "get in line" I would have to leave my vehicle at the dealership until parts were available, approximately a one month wait. There was no provision for a written recall wait list - then notify the customer when parts are available. Nor was a loaner car available. I believe such a policy that requires customers to lose use of their vehicle for a month is a barrier to referenced recall compliance. I ask that Ford change their procedure.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

My 2018 Ford Focus with DPS6 PowerShift transmission exhibits documented defect symptoms: shuddering, delayed engagement, jerking, slipping, and unpredictable low-speed behavior. Ford corporate has refused to open a defect case or provide arbitration review. This transmission family has known litigation history and systemic defect documentation.

Reported

Jan 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

I was driving on a major road at about 40mph. The oil light unexpectedly came on and I experienced a sudden reduction of engine power. There was no prior warning about this issue before the oil light suddenly came on. This power reduction caused unpredictable vehicle driving behavior that could have caused an accident. I was able to get the car to a nearby Ford dealership who told me that the oil light came on because the timing belt started to break apart and began to seize up the engine. They have told me that the entire engine will need to be replaced. The malfunctioning parts should still be available for inspection. So far, only the initial Ford dealership and the auto shop I had my car towed to for repair has inspected the vehicle. I have called Ford directly and they would not help with my problem because there has been no recall issued for my manual Focus model, though the automatic models have been recalled for a very similar or the same issue according to the Ford dealer.

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2018 Ford Focus. The contact received a notification of NHTSA Campaign Number: 23V905000(Engine and Engine Cooling), and the vehicle was taken to the dealer for the recall repair. The dealer informed the contact that the engine was replaced; however, the contact stated that after the recall repair, the vehicle started to overheat. The contact added coolant to the vehicle, but the failure persisted. The contact stated that the vehicle was not experiencing the failure prior to the recall repair. The vehicle was taken back to the dealer, where it was diagnosed with coolant contamination. The dealer replaced two reservoirs and cleaned out the coolant. The contact stated that upon attempting to start the vehicle in the driveway, the vehicle failed to start. The vehicle was towed to an independent mechanic, where the spark plugs were removed, and the mechanic noticed that there was coolant leak on the spark plugs. The mechanic determined that the engine had seized. The contact sent pictures of the failure to the dealer, who advised that they would need to diagnose the vehicle. The vehicle was then towed to the dealer, but was not yet diagnosed due to the cost. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 74,947.

Reported

Jan 2026

Incident date

Jul 2024

Mileage

Not provided

Outcome flags

None reported

I was driving on a 40mph road, went to pass someone and touched the gas to do so and the car shuddered, lost power, and made a whining noise anytime the turbo would engage. The turbocharger had to be replaced. Luckily this occurred on a road that wasn't busy and was close to home. The car has 55,000mi on it and it meticulously maintained.

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Vehicle experienced a highway-speed overheat and automatic engine shutdown. Inspection revealed antifreeze intrusion into the under-hood engine fuse box, causing widespread fuse degradation and electrical failure. This occurred following recall-related service. Vehicle lost power and is unsafe to operate due to electrical contamination and fire risk. Manufacturer and dealer have been unresponsive.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2018 Ford Focus. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted several times and informed the contact that the recall repair part had been ordered. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The contact owned a 2018 Ford Focus. The contact received notification of NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING). The contact stated that while driving 60 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. While the contact was about to pull over to the side of the road, the vehicle functioned normally. No warning lights were illuminated. The contact called the dealer; however, the contact was advised that there was a waiting list. The vehicle was not repaired. The contact stated that on a separate occasion, while starting the vehicle, the message "Engine Pressurized - Stop Immediately" was displayed on the instrument panel. The vehicle was towed to the dealer, where it was diagnosed, and determined that the radiator hose had detached. The vehicle was not repaired and was pending an inspection of the engine. The contact stated that the recall repair was still pending. The dealer failed to provide an appointment for the recall repair. The contact was informed that there were several warning lights illuminated; however, the contact stated that no warning lights were illuminated. The contact was the second owner of the vehicle and stated that the original owner experienced the same loss of power with the vehicle. The manufacturer was not notified of the failure. The failure mileage was approximately 100,000.

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2018 Ford Focus. The contact stated that while driving at an undisclosed speed, the vehicle failed to shift into gear properly. There was no warning light illuminated. The contact stated that while at a stop, the vehicle shimmied while attempting to shift into gear. The vehicle was taken to an independent mechanic, and the contact was informed that the failure was related to the transmission and the contact was referred to the dealer for further assistance. The vehicle was not diagnosed or repaired by the independent mechanic. The vehicle was then taken to the dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 64,000.

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

The fuel pump has failed and causes my car to loose power after the car has started. This is able to occur while operating the vehicle and results in immediate loss of power. This component has been inspected by an auto mechanic and will be looked at by the Ford dealership. A check engine warning appeared on 27Oct2025. However, my vehicle had been showing symptoms starting as early as Nov 2023. The symptoms included: a clunking vibration while accelerating the vehicle and switching gears, stalling at low speeds, and making weird noises when switching between gears at low speeds. I first contacted a Ford dealership about these symptoms six months ago.

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2018 Ford Focus. The contact stated that while driving approximately 15 MPH, the check engine warning light illuminated, and the vehicle felt as if the transmission had slipped into neutral(N). The contact was not able to get the vehicle back into gear, and the vehicle lost forward momentum. The contact was in the parking lot of the residence and stopped and called a tow truck. The vehicle was towed to a local dealer, where it was diagnosed and determined that the clutch needed to be replaced. The vehicle was repaired. The contact stated that it was the fifth time that the clutch had been replaced. The contact stated that the clutch was most recently replaced in May 2024. The contact called the manufacturer and was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 43,000.

Reported

Oct 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

My wife was driving her car home from work when her car suddenly overheated in light traffic. She pulled over and called me. I came by and we saw that the coolant level was low, so we filled it up to the normal level and she drove it another 20 minutes back to our home. She said it was shuddering the whole way back. I started it in the driveway later that evening and a large amount of white smoke came out of the exhaust pipe and the engine still seemed to be misfiring. I tried starting it again the next day and it would crank but not start. It seems to be an issue with the engine, my guess is a ruptured head gasket. The shuddering caused by the misfires made the car unstable to drive especially if it died while she was at speed with other cars around. The car was towed to a dealer over 30 days ago and they said that it may be related to the open recall, but they won't know until they tear it down. Which they still haven't done. There were no engine codes or prior lamp indications until the overheating event.

Reported

Oct 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

Ford Motor Company (Ford) is recalling certain 2012-2018 Focus vehicles previously repaired incorrectly under recall number 18V735. The Canister Purge Valve (CPV) may malfunction, causing the engine to stall unexpectedly while driving.

Risk: An engine that stalls while driving increases the risk of a crash.

Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters are expected to be mailed July 6, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S40. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6,2026.

Ford Motor Company (Ford) is recalling certain 2015-2018 Focus and 2013-2016 Fusion vehicles previously repaired incorrectly under recall numbers 18V169 and 18V845. The clutch may fracture, resulting in damage to the transmission assembly and possibly a transmission fluid leak.

Risk: A transmission fluid leak in the presence of an ignition source such as hot engine or exhaust components can increase the risk of a fire.

Remedy: Dealers will update the software, free of charge. Owner notification letters are expected to be mailed July 6, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S43. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6,2026.

Ford Motor Company (Ford) is recalling certain 2012-2018 Ford Focus vehicles with a 2.0L GDI or 2.0L GTDI engine. The Canister Purge Valve (CPV) may malfunction, possibly causing excessive vacuum in fuel vapor management system.

Risk: The excessive vaccuum may result in an engine stall while driving, without warning and without the ability to restart the vehicle, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the Powertrain Control Module. Dealers will also check for fault codes and replace the CPV as needed. If the CPV is replaced, dealers will inspect and replace the carbon canister, fuel tank and fuel delivery module as necessary. The recall began August 19, 2019. Owners may contact Ford Customer service at 1-866-436-7332. Ford's number for this recall is 18S32. Note: Until the vehicle is serviced for this concern, owners are advised to keep the fuel tank at least halfway full.

Ford Motor Company (Ford) is recalling certain 2016-2018 Ford Focus vehicles equipped with a 1.0L Fox GTDI engine and a 6-speed manual transmission. The clutch may fracture, resulting in damage to the transmission assembly and possibly a transmission fluid leak.

Risk: A transmission fluid leak in the presence of an ignition source such as hot engine or exhaust components can increase the risk of a fire.

Remedy: Ford will notify owners, and dealers will update vehicles with software that detects and prevents prolonged clutch slip, and will replace the clutch, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 18S07. Note: This recall is an expansion of Recall 18V-169.

Ford Motor Company (Ford) is recalling certain 2016-2018 Ford Focus and 2018-2022 Ford EcoSport vehicles. The oil pump drive belt or drive belt tensioner may fail, resulting in a loss of engine oil pressure.

Risk: A loss of oil pressure can result in an engine stall and a loss of power braking assist, increasing the risk of a crash.

Remedy: Dealers will replace the oil pump tensioner assembly and oil pump drive belt, free of charge. If engine failure occurs due to a damaged oil pump belt and/or oil pump belt tensioner, Ford has authorized dealers to replace the engine assembly as an interim repair before the availability of remedy parts for the final repair. This repair will be free of charge (parts and labor). Owner notification letters were mailed August 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S64.

Ford Motor Company (Ford) is recalling certain 2013-2018 Focus, 2013-2019 Escape, and 2015-2016 MKC vehicles equipped with a 2.0L engine. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Risk: An electrical short circuit can increase the risk of a fire.

Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed March 6, 2026. Additional letters will be sent once the final remedy is available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S01. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on January 16, 2026.

Ford Motor Company (Ford) is recalling certain 2016-2018 Focus, 2019 Explorer, and 2024 Explorer vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Risk: An electrical short circuit can increase the risk of a fire.

Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed February 13, 2026. Additional letters will be sent once the final remedy is available, anticipated in October 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on January 16, 2026. This recall expands previous recall number 25V685.