2016 Ford Focus

Transmission is taking to change gears and when going up a hill it jerks with you the problem was worked on by dealership and it still does same thing after work on it was done and dealership kept making excuses It was a recall on it about 3 years ago and it wasn't fixed and still does the same

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

Transmission overheated. Transmission fluid leaked but the computer in the car didn't let me know there was a leak. Couldn't move my car into reverse so I had to get a tow to Ford. They said it was a Transmission leak which caused the overheating. But once the car received Transmission fluid the car did not go into reverse. Clutch failed.

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

While driving at highway speed, the transmission slipped, skipping gears. Very difficult to drive care safely. Could not accelerate vehicle safely. Had to stay in right lane with hazard lights on. Basically, using only gears 1, 3 & 5. Later discovered intermittently no reverse. DTC P090C Clutch Actuator B - Circuit Low.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

When I bought the car it stuttered it ended up being the clutch then my transmission went out The bolt in my engine mount broke and my engine was basically on the ground

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

So I had check engine light I took it to the mechanic the code was p1450 the mechanic told me it’s the purge valve and it’s recall with ford book and appointment from the website witch is I did after I checked my vin I found out that’s this purge valve has recall and it’s free of charge I went to dealer they denied and said they have to do their diagnostic that will cost 190$ and they did not accept the car

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

We bought this vehicle from Carvana in February 2023. Since very early on owning this vehicle, the engine hesitated and stuttered when trying to shift from first to second gear, and would lunge forward slightly. In December 2024, I received a letter from Ford Motor Company about a customer satisfaction program, Campaign 24N07. The letter addressed the symptoms my vehicle exhibited, including engine hesitation, engine running rough, and engine stalling at low speeds, though the check engine light was not on. The letter states that Ford Motor Company provides a one-time replacement of the canister purge valve, given these symptoms and the check engine light being on. When I called all the local Ford dealerships, they refused to do it because the check engine light was not on, and that Ford Motor Company issued this as a customer satisfaction program, rather than a safety recall.Everything that was listed in Campaign 24N07 is MOST DEFINITELY a safety issue, and should not be taken lightly. It is highly concerning that Ford Motor Company didn’t think to consider ENGINE ISSUES a safety recall. The class action lawsuit Vargas et al v. Ford Motor Company had a deadline of November 4, 2020, which was 2 years and 3 months prior to us buying the vehicle, so any vehicles of the affected years and models should have been either repaired, or not allowed to be sold unless the repairs were done by an authorized Ford dealership. This information was not told to us when we bought the vehicle.On May 25, 2026, while driving, the engine fault and steering assist fault warnings came on, as well as the check engine light. When we were able to safely park the car, we discovered the entire power train is non operational. The engine no longer turns over, and we are now having to buy a new car.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

My car Transmission dual clutch went out in 2024. Car makes a loud winding noise car hesitate when stops Yes,confirmed by dealership and Coleman's transmission. Yes, by the manufacturer. No warning lamps or messages.

Reported

May 2026

Incident date

May 2024

Mileage

Not provided

Outcome flags

None reported

[XXX] driving her 2016 ford focus hit me [XXX] she claims her btakes did not work hitting multiple times she hit me so hard her car flew many feet back. I believe her car was defective it was alittle snowy but nothing bad. [XXX] said her brakes did not work at all. Me and multiple cars were able to come to complete stop with no skidding i have toyota rav4. I think her car might have been told my car needed repairs. I was severely injured severe permanent concussion brain neck back shoulder arm hand chest back muscle nerve damage. Dunno if [XXX] was also injured INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

May 2026

Incident date

Jan 2025

Mileage

Not provided

Outcome flags

Crash 1 injuries

Transmission is slipping. Dealer reported cluthes going out. This is a known issue with all of these cars.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Ford Motor issued two safety recalls regarding this, but has since closed them without providing a safe resolution for consumers. July 8 2019 Ford issued Ford Safety Recall program 19S22 (following 18S32) for stuck open canister purge valve (CPV). This can result in a failure to bleed the vacuum from the gas tank, and deforms the gas tank upon failure. This has been confirmed, reproduced, and recalled by Ford before, but continues to happen nationwide to Ford Focus ST owners as a small subset of their vehicles. A stuck open CPV can result in a number of codes. In my case, I got a P1450, Ford-Specific check engine light on the MIL. This can cause inability to start, along with rough idle and stalling while driving. Ford reports closing these safety recalls and provides no further support for the issue.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The powertrain/transmission in my 2016 Ford Focus is malfunctioning. Specifically, the vehicle shudders and hesitates when accelerating in low gears, causing delayed engagement and unpredictable power delivery. This issue occurs at low speeds, such as when entering traffic or moving through intersections, creating a potential safety risk for myself and other drivers. The problem has been officially diagnosed by a Ford dealership as a transmission/clutch issue, with a repair estimate of approximately $3,700. The issue has been reproduced consistently and confirmed by the dealer. No warning lights appeared prior to the malfunction, but the shuddering and hesitation are noticeable during normal driving. The vehicle currently has approximately 26,000 miles, which is very low for transmission failure, and the manufacturer has denied goodwill assistance despite the early and confirmed failure.

Reported

Mar 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

The car shakes when I turn the car on. I always thought it was normal until they told me it wasn't. Also ive smelled like a burn oil smell... Ive gotten stuck on intersection, guessing its the transmission.. i had to put the car it park and put it drive to see if it moved. When it did moved the whole front car shook while doing the turn. That happened like 2x. Both times I've parked afterwards and I tried to put it in reverse and nothing. It did not reverse. And that was the last of it moving.

Reported

Mar 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

The transmission in this model is horrible they already have recall for the 1.0L mine of course is the 2.0L its 2016 Ford Focus it has last than 165,000 miles. I already replaced put new transmission in it last year and here I am again transmission is out. And of course no repair shops will touch my car deal this known issues

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Ford Focus. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the vehicle shuddered unexpectedly. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with dual clutch failure. The contact was informed that the dual clutch needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact referenced NHTSA Campaign Number: 18V169000 (Power Train); however, the VIN was not associated with the recall. The failure mileage was approximately 65,000.

Reported

Mar 2026

Incident date

Feb 2025

Mileage

Not provided

Outcome flags

None reported

My car is showing signs of recalls but it’s stating that it doesn’t have any recalls. There is a recall of the transmission failing because of the clutch and causing the car to just randomly cut off while driving putting risk of a crash to me and my kids There is a recall on the fuel pump being messed up causing the car to cut off randomly while driving because of the vapors and that’s what my car has been doing also putting danger to me and my kids while driving.

Reported

Feb 2026

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

NHTSA Recall Number23V905 Recall Status recall Incomplete Ford performed an interim engine repair in 2024. Due to the unavailability of parts when the recall was initiated, it took approximately 8 months for the interim engine and repair to be completed. I received my car back in August 2024 and then a supplement to the recall was placed. After getting the car back, my check engine light came on but Ford advised that it didn't have anything to do with the engine replacement and associated parts. Then I began experiencing symptoms of a valve purge issue and received an EVAP code. I attempted to address this at the dealership during routine maintenance but it was not checked or repaired. In January 2026, my engine failed again with similar symptoms. It was towed to the same dealership where they informed me that I was out of warranty on the engine and my new issue had to do with coolant intrusion. When I checked my service records, they had noted that a coolant hose was broken and replaced during recall repairs. Additionally there is a recall for other 2016 Ford Focus coolant intrusions caused by a heater block. This leads me to believe that the repair may have been faulty. Additionally, the 23V905 recall is still open with a supplement to the original.

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Ford Focus. While operating the vehicle, the vehicle was shaking abnormally while idling, while low on fuel, while driving long distances, or while driving uphill. The vehicle shut off unexpectedly intermittently. On several occasions, the RPM increased; however, the vehicle failed to respond, and the vehicle eventually stalled. The accelerator pedal was depressed to the floorboard, but the vehicle failed to respond. The brake pedal became firm. The contact stated that the vehicle stopped and restarted several times or shut down unintendedly. After refueling, the contact had to wait for approximately 2 to 10 minutes before the vehicle responded as needed. Occasionally, the contact had to wait for over an hour before the vehicle was restarted. The check engine warning light illuminated intermittently and later turned off. While depressing the accelerator pedal, the engine revved excessively without the vehicle responding as needed. An abnormal sound was coming from the vehicle. The Oxygen sensor error code was displayed. The failure persisted over time. The vehicle was previously repaired at an unknown dealer under NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline). Additionally, the high-pressure fuel pump was replaced. The local dealer was not contacted regarding the current failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 150,000.

Reported

Feb 2026

Incident date

Feb 2024

Mileage

Not provided

Outcome flags

None reported

The vehicle experienced failure of the DPS6 dual-clutch automatic transmission. The transmission began slipping during acceleration, hesitating between gear engagement, and triggering a “Transmission Overheat” warning. Eventually, the vehicle lost the ability to reliably shift between Drive and Reverse and would not consistently engage gears. The vehicle can start and move forward but cannot reliably switch directions within the same ignition cycle. The vehicle is available for inspection. The transmission malfunction created safety concerns due to delayed or failed acceleration when entering traffic. The vehicle hesitated and slipped under throttle input, which could prevent timely acceleration when merging or crossing intersections. Additionally, the inability to reliably shift between Drive and Reverse could create hazardous situations in parking lots or emergency maneuvering scenarios. The sudden transmission overheat warning and gear disengagement could result in loss of power in traffic. The issue has been confirmed by an independent mechanic who diagnosed transmission failure. The vehicle has a known history of prior clutch replacement under similar symptoms. The transmission malfunction is consistent with documented DPS6 transmission failures in 2016 Ford Focus models. The vehicle has been inspected by an independent service center. The manufacturer has not inspected the vehicle. Prior to failure, the vehicle exhibited shuddering during acceleration from a stop, particularly at low speeds. This condition has been intermittently present for several years following a prior clutch replacement. In the days leading up to failure, the vehicle experienced difficulty accelerating and hesitation under throttle. A “Transmission Overheat” warning message appeared while driving. After cooling, the vehicle temporarily resumed operation but subsequently lost reliable gear engagement.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

I am writing to file a formal complaint regarding an ongoing mechanical issue with my 2016 Ford Focus. Although my vehicle currently shows zero active recalls, I have experienced a recurring and concerning problem. Each time I turn on the air conditioning and the air begins to blow cold, my engine temperature rises significantly and causes the vehicle to overheat. This issue occurs consistently and makes it unsafe to operate the vehicle while using the air conditioning. Overheating poses a serious safety risk and may lead to engine damage or sudden breakdowns. Given that this problem appears to be directly connected to the operation of the air conditioning system, I am concerned that this may be a known defect or design issue that has not been addressed through a recall. I am requesting that this issue be formally documented, investigated, and addressed. I would appreciate guidance on next steps, including inspection, repair options, or whether this issue has been reported by other 2016 Ford Focus owners. Thank you for your time and attention to this matter. I look forward to your prompt response.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Transmission is slipping. Check engine light is on. Code P07A5 (3/3) Permanent Transmission Friction Element B Stuck on.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

When driving my car all of a sudden it loses power almost like it’s struggling to go but the RPM revs up and makes a loud noise and my car kind of got stuck for a minute and there were cars behind me then it started going but every couple minutes it would do that again rev up really loud even when I barely push the gas and lose power and then go I have no idea why it was doing that I took it to get it looked at, but there was no light on then a light finally came on and it came up with P07A3. Transmission friction element A stuck on. It starts end doing that with no notice. Light came on later after I tried to get it scanned. There seems to be extended warranty satisfaction things offered on vehicles at the same time mine was made. Same vehicle. But my number is not on the vin recall. But it exhibits same symptoms. The ford customer satisfaction program 14m02 covers same issues but my vin is not listed. This is a driving hazard unsafe that I feel is issues from their manufacturing.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

This vehicle been having problems with heater

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Ford Focus. The contact stated that while driving at various speeds, the vehicle unexpectedly stalled with the message "Transmission Overheating" displayed. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. The contact stated that the failure persisted. The manufacturer was not contacted regarding the failure. The failure mileage was 55,000.

Reported

Jan 2026

Incident date

Oct 2023

Mileage

Not provided

Outcome flags

None reported

Fuel purge valve is malfunctioning. Vehicle loses power and is sluggish. Idles very rough and sometimes has a loss of power. My car has been at Ford twice in the last six months and problem still isn't fixed. Complete engine was replaced about a year and a half ago due to recall issue which I don't want happening again. I do not feel safe driving this car. I made an appointment with Ford a month ago for tomorrow for same stalling issue. I went to drop off and explain I wanted the repairs done for the recall to see if that fixed the problem. I filled up my gas tank on Sunday. The car wouldn't start and engine light came on saying engine failure service now. I let it sit for about ten minutes and it hesitantly cranked and engine light went off but accelerates slower with loss of power. It keeps doing this intermittently and sometimes loses power, and struggles when idling. I cut off let sit and then is okay until I pump gas again. I told the service repair person what happened and handed him the key to drop off the vehicle. He said if the light was not on at the time he would not be able to fix it and they couldn't schedule my vehicle for any additional recalls that are greatly needed for the car. It is running terrible. It idles and intermittently loses power while driving. Evan at Ford (Greer) response was to wait until it got bad enough that the engine light came on and stayed on. This was at D&D Ford in Greer, SC. He said it was Ford's policy the light had to be on to replace under recall with no charge. I told him it is unsafe to drive if it gets any worse it could cause an accident. I have two children and his recommendation to wait until it gets worse was appalling. He kept backlashing Ford and stated he doesn't work for Ford he works for D&D and only represents Ford. I said to him he was not representing Ford very well and that it was highly unlikely they would agree with his statements. I asked for documation of this policy--it contradicts what he says.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Having fuel problems with this ford se. Adding gas after starting the car it doesn't run right. It misses n doesn't have power. Plus Transmission went out two times again. First time it went out. It was about a year ago. Now the second time [XXX]. First time was about a year ago. It was repaired. Because I had a car warranty from the car dealer ship. Now they won't repair it again. This ford focus Se had the double clutch in it Plus the notorious speed shifter known to go out. These transmissions are known to have problems. But the car place never told me. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Something wrong with the transmission the one that Ford extended warranty on and my car is a 2016 and Ford extended it 10 years and they said it ended a few months ago as well as the TCM replacement I didn't know about because I just purchased the vehicle a little over a year ago.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The car is stalling randomly with no engine lights coming on

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Lee County was working on the road and were replacing a section of Lazy D Farm Road and there was a section cut out and try to get across the section the transmission over heating light came on

Reported

Nov 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

In the Ford 3 cylinder 1.0L Ecoboost engines there is a terrible wet belt system, there is a recall on the automatic models but nothing for the manual models, regardless of the fact that the manual models are designed far more poorly than the automatic models in the sense that the manual models have no tensioners and rely solely on the factory tension of the screws, keeping in mind that the belt is both rubber and sitting in hot oil when in use, if not a money grab, my best guess is that they hoped the wet rubber belt would simply not not stretch in good faith. 4 days after getting basic maintenance, the wet belt failed, clogging the oil pickup causing engine failure, and temporary loss of power steering, after the engine was given time to warm up, luckily the road was nearly empty, and i was driving at a slower pace. However the fact that Ford Motor Company has gone nearly a decade without dealing with the issue, and then denies having knowledge of this design flaw, is absolutely and abundantly absurd. I have all vehicle maintenance records, as well as mechanic testimony, all of which point to this incident being caused by poor engine design. In addition to the estimated cost to replace the engine is 8,500$, or about 140% the cars total value prior to the engine failure. This a NOT a minor issue, this is not even a uncommon fail point on many other manual models, this IS a major safety concern, that god forbit it, could lead to a major accident. I simply think that the Ford Motor Company should be made accountable for cheaping out for profit, at the cost of customer’s safety.

Reported

Nov 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

The transistor arm or tensioning arm for the wet belt, which drives the oil pump in the oil pan failed, leading to oil starvation to the engine, causing total catastrophic engine failure, and temporary loss of power steering, while driving, fortunately, I was moving at a slow pace in minimal traffic, however, this is a known fail point in Ford 1.0 L ecoboost 3 cyl engines, that Ford claims my vehicle does not have, and refuses to cover, regardless of the fact that it did happen, and I have pictures in mechanic testimony to prove this to be true, had I’ve been on a different road, or had more traffic, this could have to a fatality. The engine replacement would cost a estimated 4500-7500$

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

The clutch had to be replaced a second time and the engine became disabled while driving due to parts failure and it blowing up. This is all happening with 60,000 miles on the vehicle. My safety came into question with both failures disabling my car while I was driving on the interstate. The clutch was replaced and paid for out of pocket and I have been trying to work with ford about the engine but they have not helped at all. The issues just popped up and failed immediately while driving. This engine failure issue is covered for my vehicle, but my VIN is not covered. The only explanation I have received is that it is because my car is a manual transmission, which has no link to the part that failed on the engine. I was also notified by the ford service manager that my vehicle was made in the exact location and time frame that the recall covers, but my VIN still is not covered. I have received absolutely no help or solution with my vehicles failure and have been without a vehicle for 9 months because of the large price on replacing an entire engine, right after I had to pay for a very expensive clutch replacement.

Reported

Oct 2025

Incident date

Jan 2025

Mileage

Not provided

Outcome flags

None reported

Fuel pump went out and caused car to stall and leave me stranded on the side of the road when dash indicator showed 23 miles left to travel. I had this fixed through the dealership Drive Time sent me to mechanic shop as was still under dealership warranty.

Reported

Oct 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Ford Focus. The contact stated while driving 40 MPH and depressing the accelerator pedal, the vehicle hesitated. The contact also stated that while attempting to start the vehicle, the vehicle failed to respond as intended. Additionally, while driving at an undisclosed speed and attempting to make a left or right turn, the lost motive power. An independent mechanic was contacted, and the vehicle was taken to the independent mechanic to be diagnosed. The mechanic retrieved DTC: P2872 (Clutch "A" Stuck Engaged). The vehicle was not repaired. The contact related the failure to Customer Satisfaction Program: 14N02 (Extended Warranty Coverage for PCM Reprograming in the Event of ABS Vehicle Speed Signal Related Communication Loss that Disables OBDII System Monitors); however, the VIN was not included in the CSP. The manufacturer was notified of the failure, and informed the contact that the VIN was not under warranty or recall. The failure mileage was 108,000.

Reported

Sep 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

I was driving the car other all of a sudden died on me and told me to put it in park I put it in park and then turned the key off and tried to restart it. It did not restart and would not turn of kept popping up a warning saying starter system failure. Could not turn my wheel or pit it in neutral to get it out of te middle of the road.

Reported

Sep 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

The rear view camera does not work most of the time. Hasn't for years. Seems Ford can't make a rear view camera that works, since I see Ford recalling all manner of other vehicles for their rear view camera. They need to do it for the Focus as well.

Reported

Sep 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Ford Focus. The contact stated that while her granddaughter was driving approximately 30 MPH, the low oil pressure and check engine warning lights illuminated. The contact stated that her granddaughter heard an abnormal knocking sound coming from the engine compartment. The vehicle was driven to a dealer who was unable to diagnose the vehicle immediately. The vehicle was then taken to an independent mechanic. The vehicle was diagnosed, and it was determined that the oil pump had failed and stopped pumping oil to the engine, resulting in damage to the engine. The contact was advised that the engine and the oil pump needed to be replaced. The vehicle was not repaired. The contact had received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, parts for the recall repair were not yet available to repair the vehicle. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact mailed a letter to the manufacturer about the failure, but had not yet received a response. The failure mileage was approximately 99,000.

Reported

Aug 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Ford Focus. The contact stated that while driving at approximately 60 MPH, the vehicle started losing motive power. The contact heard an abnormal grinding sound coming from under the floorboard. The contact stated that while depressing the accelerator pedal, the vehicle failed to accelerate as intended and was jerking and vibrating abnormally. The contact stated that the failure was more pronounced after the initial failure. The contact stated that later, the check engine warning light illuminated, and the vehicle was difficult to start. The contact stated that the check engine warning light was orange. The vehicle was taken to a local dealer, where it was diagnosed, and determined that the clutch actuators needed to be replaced. The vehicle was repaired. The contact researched online and related the failure to a problem with the dual clutch transmission installed in the vehicle. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 113,000.

Reported

Aug 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Ford Focus. The contact stated that the vehicle stalled while driving at various speeds and while idling. The contact was able to pull over to the side of the road. The vehicle failed to restart and had to be towed several times. The contact stated while driving 70-75 MPH, the vehicle stalled. The contact was able to pull over to the side of the road. The vehicle failed to restart and was towed to the dealer, where it was diagnosed with oil pump and fuse failure. The manufacturer was notified of the failure and related the failure to NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling). The VIN was included in the recall. The contact was charged a fee for the repair. The vehicle was not yet repaired. The failure mileage was approximately 10,000.

Reported

Aug 2025

Incident date

Mar 2025

Mileage

Not provided

Outcome flags

None reported

The car failed to start, it did not recognize it was in park. After trying to start my car with the keys it failed. My safety is put at risk, my car failing to recognize which gear shift it is in causes malfunctions while I am on the road, especially since I drive long distances at high speeds. I had a Master Technician review and preform a diagnostic on my vehicle and the codes formed for this test matched hand in hand with TCM issues under the TSB. After this, I went to the dealership to discuss this issue and the only thing that came of it was informing me that I was not eligible for a recall due to my VIN, even if I have all the symptoms under the TSB for my Ford Focus 2016. Since my car failed to start I was not able to bring it to Ford and have it tested, especially after asking if it is eligible and they insisted that it was not. No warning signs from the dashboard appeared on my vehicle to inform me of this issue. I travelled to meet with family and did not end up using my vehicle for a few days and when I tried to start my car, it would not engage. The only warning sounds I would consider a correlation before the problem would be a clicking from the starter pre-firing when I opened the door, and while the car was off.

Reported

Aug 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Ford Focus. The contact stated that while driving at 45 MPH, the RPMs became drastically elevated, and the vehicle shut off unintendedly. The check engine warning light was illuminated. The contact pulled over, and the vehicle failed to restart. The vehicle was towed to the residence, and after three days the contact attempted to restart the vehicle, and the vehicle started without hesitation, and the check engine warning light was no longer illuminated. The vehicle was driven to the local dealer to be diagnosed; however, there was no cause for the failure found. The vehicle not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 40,000.

Reported

Aug 2025

Incident date

Aug 2024

Mileage

Not provided

Outcome flags

None reported

It is my transmission problem, there is an engine light on and the shifting is very rough and it also jumps gears, i know ford had a recall for this problem i believe it should be under warranty it is the TCM

Reported

Aug 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

2016 Ford Focus, VIN: [XXX] Power Train: Automatic Transmission: Control Module (TCM) This complaint details a recurring and severe safety defect in our 2016 Ford Focus. The vehicle's Transmission Control Module (TCM) has failed twice, resulting in sudden, complete loss of power and dangerous stalling incidents at highway speeds. In January 2023, at approximately 8,000 miles, the vehicle suddenly lost all propulsion while traveling on a highway. We were forced to execute a dangerous emergency maneuver across lanes of traffic to reach the shoulder. A Ford dealership diagnosed a failed TCM which had, in turn, caused the clutch to burn out. In July 2025, after only 7,000 additional miles (total vehicle mileage ~15,000), the identical, catastrophic failure occurred again. The vehicle once more stalled without warning on a major highway, creating another life-threatening situation. The diagnostic codes confirmed the same TCM and clutch failure, proving the issue is a persistent, underlying defect and not a random occurrence. This failure is entirely consistent with the widely-documented defect in Ford's Powershift (DPS6) transmission. This problem has been the subject of multiple national class-action lawsuits and is detailed in thousands of other consumer complaints filed. The repeated failure in our low-mileage vehicle underscores that this is a predictable and systemic design flaw that makes the vehicle inherently unsafe. We attempted to address this critical safety failure directly with Ford Motor Company. Our concerns were met with dismissal, and despite being issued a case number, Ford has failed to respond to our calls registered letter. This vehicle is unsafe to operate. We are filing this complaint to implore the NHTSA to launch a formal investigation into this defect. The repeated, sudden loss of power presents an unreasonable risk of serious injury or death to occupants and other motorists. We believe a mandatory recall is urgently required. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Aug 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

The contact's son owns a 2016 Ford Focus. The contact stated that while at a stop, the vehicle shuddered while depressing the accelerator pedal. There was no warning light illuminated. The contact then stated that while his son was driving at an undisclosed speed, the message "Transmission Hot - Wait 5 Mins" was displayed on the instrument panel. The contact's son followed the instruction; however, the warning light returned soon after restart the vehicle. Due to the failure, the vehicle was towed to the residence. The manufacturer was notified of the failure but offered no assistance. The vehicle was not repaired. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 137,000.

Reported

Aug 2025

Incident date

Apr 2025

Mileage

Not provided

Outcome flags

None reported

Transmission Control Module failed and i had that replaced. Now the clutch pack failed and had that replaced. Now it says transmission hot and to pull over. All of this has been recalled on 2012 to 2016 but for some reason my car is not and its the same powershift transmission. Im over 4000 dollars into these repairs and still having problems.

Reported

Aug 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

The transmission is slipping. Research shows it's a known issue. Ford has acknowledged the issue and extended support. My local ford dealership is refusing to fix the issue even though I fall within the extended service mileage. I called 2 transmission shops who refused to work on this specific model due to the dual clutch design and known problems. Attached is a letter I am disseminating requesting proper assistance with this issue.

Reported

Jul 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

Additional information related to a case I opened earlier today Vehicle: 2016 Ford Focus SE Component: PowerTrain – Transmission My 2016 Ford Focus has experienced three failed clutch packs with the Ford DPS6 PowerShift transmission. The first clutch was replaced at ~22,000 miles, the second at ~27,500 miles, and it now requires a third replacement at 80,000 miles. This is a known and dangerous defect that was part of a class-action lawsuit. Despite multiple replacements and low mileage, Ford is requiring me to pay over $4,000 for a third repair. This transmission causes slipping, hesitation, and safety issues when pulling into traffic or hills. I am requesting that NHTSA re-investigate or expand the scope of past complaints on this vehicle to include continued post-settlement failures.

Reported

Jul 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

Restraint Module went bad and after I looked it up online this was a recall for my year make and model.

Reported

Jul 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

Went to refuel my car with gas. Got into my car and it didn’t start right away. When it finally did the check engine light came on. I took to go check it out and was told the fuel tank/canister purge valve was faulty. I tried contacting ford to see if under warranty and or recalled. But nothing has come out of it. My 2016 Ford Focus only has 67k miles on it

Reported

Jul 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

I am writing you today because my ford focus with transmission DPS6,7SPDCT has all the same problems the older models have. Ford has stopped there 10 year 150000 mile warranty on there transmission on all models built after November 5 2015. Mine is January 1 2016 with all same transmission components. And all my warranty is ran out and still having transmission problems.

Reported

Jul 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2016 Ford Focus. The contact stated that while accelerating from a complete stop or while driving at various speeds, the vehicle jerked, hesitated, experienced difficulty shifting into gears and stalled. The check engine warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the transmission clutch actuator had failed and needed to be replaced. The vehicle was not repaired. The contact stated that the part was previously replaced under Ford Customer Satisfaction Program Number: 19N08. The manufacturer was notified of the failure. The failure mileage was approximately 130,000.

Reported

Jul 2025

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

Ford Motor Company (Ford) is recalling certain 2012-2018 Focus vehicles previously repaired incorrectly under recall number 18V735. The Canister Purge Valve (CPV) may malfunction, causing the engine to stall unexpectedly while driving.

Risk: An engine that stalls while driving increases the risk of a crash.

Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters are expected to be mailed July 6, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S40. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6,2026.

Ford Motor Company (Ford) is recalling certain 2015-2018 Focus and 2013-2016 Fusion vehicles previously repaired incorrectly under recall numbers 18V169 and 18V845. The clutch may fracture, resulting in damage to the transmission assembly and possibly a transmission fluid leak.

Risk: A transmission fluid leak in the presence of an ignition source such as hot engine or exhaust components can increase the risk of a fire.

Remedy: Dealers will update the software, free of charge. Owner notification letters are expected to be mailed July 6, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S43. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6,2026.

Ford Motor Company (Ford) is recalling certain 2013-2014 Ford Fusion vehicles equipped with a 1.6L GTDI engine and 6-speed manual transmission and 2015-2016 Ford Focus vehicles equipped with a 1.0L GTDI engine and 6-speed manual transmission. Also included are four 2017 Ford Focus vehicles that had clutch replacements with potentially affected parts. The clutch may fracture, resulting in damage to the transmission assembly and possibly a transmission fluid leak.

Risk: A transmission fluid leak in the presence of an ignition source such as hot engine or exhaust components can increase the risk of a fire.

Remedy: Ford will notify owners, and dealers will update the Focus vehicles with software that detects and prevents prolonged clutch slip, and will replace the clutch, as necessary, free of charge. Owners of Fusion vehicles will have their clutch assembly replaced free of charge. The recall began August 3, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S07.

Ford Motor Company (Ford) is recalling certain model year 2013-2017 Ford Focus hatchback vehicles manufactured February 14, 2012, to August 26, 2016 and equipped with a manual transmission. The hatchback of the affected vehicles may be unlatched with a single press of the interior latch release button. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."

Risk: With only a single press needed, the driver may accidently unlatch the hatchback, increasing the risk of injury to any unsecured passengers in the back.

Remedy: Ford will notify owners, and dealers will reprogram the Body Control Module with updated software, free of charge. The recall began February 10, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16C13.

Ford Motor Company (Ford) is recalling certain 2016 Focus and C-Max vehicles. The floor pan may have improperly welded left-hand apron joints.

Risk: Improperly welded apron joints may reduce the front-end structural integrity of the vehicle, increasing the risk of injury in the event of a crash.

Remedy: Ford will notify owners, and dealers will inspect the apron joints, repairing the vehicle, as necessary, free of charge. The recall began March 8, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S03.

Ford Motor Company (Ford) is recalling certain 2012-2018 Ford Focus vehicles with a 2.0L GDI or 2.0L GTDI engine. The Canister Purge Valve (CPV) may malfunction, possibly causing excessive vacuum in fuel vapor management system.

Risk: The excessive vaccuum may result in an engine stall while driving, without warning and without the ability to restart the vehicle, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the Powertrain Control Module. Dealers will also check for fault codes and replace the CPV as needed. If the CPV is replaced, dealers will inspect and replace the carbon canister, fuel tank and fuel delivery module as necessary. The recall began August 19, 2019. Owners may contact Ford Customer service at 1-866-436-7332. Ford's number for this recall is 18S32. Note: Until the vehicle is serviced for this concern, owners are advised to keep the fuel tank at least halfway full.

Ford Motor Company (Ford) is recalling certain 2016-2018 Ford Focus vehicles equipped with a 1.0L Fox GTDI engine and a 6-speed manual transmission. The clutch may fracture, resulting in damage to the transmission assembly and possibly a transmission fluid leak.

Risk: A transmission fluid leak in the presence of an ignition source such as hot engine or exhaust components can increase the risk of a fire.

Remedy: Ford will notify owners, and dealers will update vehicles with software that detects and prevents prolonged clutch slip, and will replace the clutch, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 18S07. Note: This recall is an expansion of Recall 18V-169.

Ford Motor Company (Ford) is recalling certain 2016-2018 Ford Focus and 2018-2022 Ford EcoSport vehicles. The oil pump drive belt or drive belt tensioner may fail, resulting in a loss of engine oil pressure.

Risk: A loss of oil pressure can result in an engine stall and a loss of power braking assist, increasing the risk of a crash.

Remedy: Dealers will replace the oil pump tensioner assembly and oil pump drive belt, free of charge. If engine failure occurs due to a damaged oil pump belt and/or oil pump belt tensioner, Ford has authorized dealers to replace the engine assembly as an interim repair before the availability of remedy parts for the final repair. This repair will be free of charge (parts and labor). Owner notification letters were mailed August 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S64.

Ford Motor Company (Ford) is recalling certain 2013-2018 Focus, 2013-2019 Escape, and 2015-2016 MKC vehicles equipped with a 2.0L engine. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Risk: An electrical short circuit can increase the risk of a fire.

Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed March 6, 2026. Additional letters will be sent once the final remedy is available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S01. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on January 16, 2026.

Ford Motor Company (Ford) is recalling certain 2016-2018 Focus, 2019 Explorer, and 2024 Explorer vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Risk: An electrical short circuit can increase the risk of a fire.

Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed February 13, 2026. Additional letters will be sent once the final remedy is available, anticipated in October 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on January 16, 2026. This recall expands previous recall number 25V685.