2024 Ford Expedition

Intermittent warning of front camera collision / braking malfunction. Usualy less then 10 seconds but on one occassion persisted for about 10 minutes. Has been to dealership for investigation without resolution. Happened last on 7/16/2026. Arrived at dealership withing 20 minutes, they were able to call up the alert on there service advisors computer but could not do further investigation at the time. Vehicle is again scheduled to go to dealership on 3 August 26. Prolonged alert was 6/2/26, immeadiatly went to dealer (within 3 miles) vehicle into dealer fror a week on 7/6/26 without resolution

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

The contact rented a 2024 Ford Expedition from Enterprise Rent-A-Car. The contact stated that while the vehicle was parked and occupied, the contact was informed by his grandson that the seat belt was not operating properly. The contact inspected the seat belt and became aware that the third-row seat belt rear passenger’s side seat belt buckle assembly was damaged. Neither a dealer nor an independent mechanic was contacted. The vehicle was not taken to a dealer or an independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure, and no assistance was provided. The failure mileage was 80,240.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

Forward collision system does not work or alert under any circumstances. Vehicle has forward collision mitigation as well as collision mitigation alerting, but neither systems work. Dealer able to verify these systems do not work, but have no recourse for repair, as Ford engineering has not provided a solution.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

Incident happened 06/26/2026. My wife was driving with our 4 kids down the highway to family event. My wife smelled a funny odor coming from the vents and was going to drive to the next exit and then noticed smoke. At that moment she wasn’t sure where the smoke was coming from. She put the hazards on and started pulling off to the shoulder thinking possibly it was the radiator. She came to a stop and called me (husband) that something was wrong with the vehicle. She was going to leave the kids in the car, get out and check the radiator. That’s when smoke started coming in through the air vents. She didn’t want the kids to breath in the smoke so they exited the vehicle, that’s when she noticed a fire under the engine. At that point a state trooper arrived on scene. He checked on my wife and kids and brought them back to his patrol car. The trooper went back to the vehicle to grab the baby’s diaper bag and wife’s purse. The trooper tried to extinguish the flames but the front of the vehicle was well involved already. Within 10-15 minute from my wife stopping the whole car was burnt to the ground and nothing left of the car. Looking back my wife only had a couple minutes to get to safety, had they lingered before getting out of the vehicle this could have been a tragic fatality incident. Our children do not feel safe riding in a vehicle since the incident happened. The safety of the trooper on scene was at risk helping get everyone to safety. It seems that something on the engine failed with how quickly the fire started. Vehicle can and should be inspected to find out what happened so this does not happen to another family. The vehicle has not been inspected yet. No warning lights ever came on. There was never any symptoms prior to this incident and the vehicle has been serviced by the dealer prior to and since we purchased the vehicle.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

Fire

The spring for the door for the 4-flat trailer plug on vehicle is too powerful. This resulted in the door wearing away at the trailer plug and has resulted in the wires of the trailer light plug breaking. This is available upon request. It puts our safety at risk as our trailer lights can go out and result in less information for other drivers, possibly resulting in a rear-end crash. The problem has not been reproduced, and has not been inspected. The only symptom of the problem in the vehicle is it telling us the trailer was disconnected. The trailer was a 2020 Malone microsport trailer.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Several of automatic sensors were not working (tire pressure) and the horn. The dealer stated I had road damage and wires were torn loose. I'm a 76 year old woman and I do not take this car off road or have any recollection of such an incident. I maintain the underside of the vehicle is improperly protected. They charged me $2300 to fix it.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

No accident, malfunction, warning lights, or safety-related issues occurred. Vehicle is operating normally at this time.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The third row seats both have reachable access to the third-row PowerFold buttons even in car seats. My two toddlers can easily reach the fold buttons while strapped in to their seats and are able to recline and move their seats forward and backwards. This caused major safety hazard because their car seats become loose. The buttons are placed very close to the third row seat and are accessible to 35 lb children to press and play with them. While strapped into their car seats, my children easily reached and both touched the buttons and loosened their car seats while the car was in motion and I was driving. There is no software setting or built-in dashboard switch to disable the third-row PowerFold buttons in a Ford Expedition. To prevent the seats from accidentally folding, the most effective permanent solutions are removing the associated fuse, disconnecting the physical wiring harness from the button panel, or physically blocking the switch. This is extremely dangerous and needs to be fixed

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Transmission failure. Vehicle has failed to accelerate and then failed to move at all. Still under warranty and no codes shown. Vehicle left immobile on interstate due to intermittent transmission failure. Initial repair was not sufficient as issue has returned. No solutions for additional repair to address safety issue.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

This is a report of a recurring, life-safety defect involving unintended vehicle movement in a 2024 Ford Expedition. The vehicle has experienced two separate incidents where it was placed in 'Park,' remained stationary for 13-30 seconds, and then began driving itself backward without driver intervention or throttle input. Incident 1: Occurred on March 29, 2026 and I have this one on video. Incident 2: Occurred on April 8, 2026. The video clearly shows the vehicle remaining stationary and in 'Park' for 13 seconds before the unintended movement begins. This delay proves the movement is not a 'start-up rocking' sensation or 'normal clutch drag,' but a delayed mechanical or electronic failure of the park actuator or transmission system. I presented the vehicle for service at a Ford dealership on April 17, 2026. Despite my report of a delayed-onset rollaway, the dealership documented the issue as a 'normal and desired characteristic' of the 10-speed transmission. They characterized the event as a minor 'rocking' sensation that occurs immediately, which is factually contradicted by my video evidence showing a 13-second delay. This leaves me with an unsafe vehicle prone to unintended movement. I am requesting a formal investigation into a potential park-engagement failure.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Since I purchased the vehicle brand new, none of the safety features have been functional. The following sensors are faulty and none of them have worked since I bought the vehicle: 1) Cross Traffic Alert; 2) Blindspot System Fault; 3) Pre-Collision Assist; 4) Front Camera Fault; 5) Parking Sensor Fault; 6) Lane Keeping Assistance. I tried to take the vehicle into the service department of the dealership to fix the problem several times, but as of this time, there has been no solution. The dealership said the problem cannot be fixed, because only Ford Corporation can create a computer software fix for the problem. I was instructed by the dealership not to bring the vehicle back for the same issues, because nothing can be done, and they will not touch it. However, Ford has failed to launch a computer software fix, since I had had the vehicle to 2 years. Since the dealership can't fix it and Ford can't fix it, I am stuck with a defective vehicle that is "Unsafe" to drive, because all of these safety features that are not functional help prevent and reduce the probability of motor vehicle accidents. Ford is refusing to help me and rejected my claim even though they can't fix it.

Reported

Apr 2026

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

I bought this vehicle brand new in 2024 and none of the safety features are functional and can't be fixed. Ford corporation cannot find a a computer software fix for it and the dealership can't fix it. The vehicle in unsafe to drive. The following sensors are faulty and have continued to give failure alerts since I purchased the vehicle: 1) Cross Traffic Alert; 2) Blind Spot System Fault; 3) Pre-Collision Assist; 4) Front Camera Fault; 5) Parking Sensor Fault; 6) Lane Keeping Assistance, 7) Rear backup assistance. It is a safety hazard and unsafe to drive because none of the "Safety Warning" or "Driver Assistance" features work, that would help prevent accidents. For the past 2 years, I have been driving this defective vehicle that is a safety hazard, which is not repairable, nor is the vehicle marketable. I have tried to resolve this issue numerous times, but there is no solution. The dealership advised me to not bring it in for service again, because there is nothing that can be done. I tried to file a claim with Ford Corporate and requested they buy the vehicle back, because it meets the criteria and the elements under the Texas Lemon Law, regarding electrical and safety concerns. However, my claim was rejected. As of right now, there is no solution for this issue.

Reported

Apr 2026

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

I have had my car at the dealership twice, once in August of 2025 and once in February of 2026 because when I start I get a warning, front collision assist malfunction, lane keep assist malfunction, blind spot monitoring malfunction, and as a result, I have no cruise control, even in normal cruise control mode. I have been told it’s an electrical update, and it was October, then January, now it’s March. Just saw a recall was issued for Navigator, Nautilus, Aviator, and Explorer with this exact problem, but no recall for the expedition.

Reported

Mar 2026

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

Bought the car on Feb 14th 2026. We were told Avis car sales in fontana does their vehicle inspection on every car before its sold. We noticed the two back tires on the expedition were bald and showing cords. We told Tawnya and George about the tires and they said they would order them, they'd be in within two days and to bring the car back to get them replaced. When we got home we setup ford diagnostics and found out the oil life was at 29% so they also lied and sent us out with bad oil. We checked the dip stick and yeah super dark oil. We've called two days in a row and keep getting told they are busy and they will call us back, they have not. We have tried to reach corporate but they dont have a department for this. The vehicle is currently sitting because of how bad the tires are, its 100% not safe to drive. Trying to get the dealership to honor the safety fix they promised but they are avoiding it.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The rear portion of the panoramic moonroof shattered spontaneously while the vehicle was being operated, without any impact or external cause.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

On Monday, January 12, I was driving down the highway with 2 of my coworkers, when all of a sudden there was a loud pop and glass shattered. My sunroof had exploded. It was a sunny clear day, there were no vehicles in front of us and we were not going under an overpass. We pulled over to take pictures and drove the vehicle straight to Ford. We have since read that this type of incident has occurred before with multiple other Expeditions.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

My wife tried to move my expedition from spot to another in our parking lot During that maneuver the gas pedal assembly broke down and the car in high speed created some personal and property damages I have the part handy and ready for inspection up on request The insurance knows about it And I had a police report No warning prior to the incident

Reported

Dec 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

Crash 1 injuries

Vehicle was driving approximately 65 miles per hour on interstate. Upon crossing a bridge the sunroof exploded sending glass flying inside the vehicle. The vehicle was equipped with a dash camera which also captured audio. No external object struck the vehicle. Two children and an adult in the vehicle were struck with flying glass. The video has been saved and can be provided in addition to the pictures.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

3 injuries

I was driving on the I95 and just passed the McHenry tunnel when out of nothing I heared a loud bang and my moon roof spontaneously shattered into pieces. Nothing hit it and after inspection there was also no other damage on the car but the rear part of the moonroof that was completely shattered.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

I own a 2024 Ford Expedition XLT. The vehicle repeatedly loses multiple federally mandated safety systems including Blind Spot Monitoring, Cross-Traffic Alert, Automatic Emergency Braking, Forward Collision Warning, and camera systems. Alerts include: ‘Cross-Traffic System Fault,’ ‘Blind Spot System Fault,’ ‘Pre-Collision Assist Not Available,’ ‘Front Camera Fault,’ and ‘Check Parking Sensors.’ Ford has acknowledged this as a known issue with a fix delayed until June. My dealer (Morries Ford, Buffalo MN) is charging $225 each time the defect recurs just to clear errors. This is a safety defect that places my family at risk. Ford is refusing to cover the full repair cost and the dealer is charging for temporary resets.

Reported

Dec 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

Driver assistance warning lights come on. All safety systems such as blind spot, collision avoidance, and lane keeping fail and are inoperable. This also shuts down cruise control. For has been aware of this issue since December 2024

Reported

Oct 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

I purchased this 2024 Ford Expedition brand new from a Ford certified dealer (Conklin Cars, Newton , Kansas). Upon driving off the lot for the first time to a gas station across the street from the dealer, at restart all the sensor gave warnings. Sensors that gave warning include: Blind spots sensors, back-up sensors, Froward impact, lane departure, automatic braking, rear cross traffic, and the cruise display. I took it back to the dealership and the reset the system and upon starting the vehicle after parked, all the sensors stopped working again. I then took the Ford Expedition back to the certified dealer (Conklin Cars, Newton , Kansas) and they game me sheets of paper, Last one give after 4 visits to dealer [XXX]) stating that Ford knows of the an issues, which appear to be right off the factory line. This has been over a year and there have been several close calls for me and my family without these sensors, which is standard in most cars these days. Me and my family expect these sensors to work on the vehicles we drive, rather basic or premium. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Oct 2025

Incident date

Mar 2025

Mileage

Not provided

Outcome flags

None reported

See attached document for complaint.

Reported

Oct 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

I would like to report the seats. I bought my vehicle new. The seats has caused me to have medical issues. It has also caused one other person issues too, so it was not just me. I have never had any sort of back or leg issues before getting this vehicle. I now have severe Sciatica Nerve problems. Which, I have seen the Doctor for. It flares up so bad while I am driving my right leg goes into extreme pain then it goes numb. Which is not helpful since this is the foot I use the gas and brake with. This is my only transportation, so I do not have another vehicle to drive. I have had my son drive this vehicle when we went on a trip. I sat in the middle row captain chair and it was the same issue. This trip was when my daughter in-law (Which is an RN) starting having the same issues as myself.

Reported

Oct 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

The 2024 Ford expedition brakes was not working at the time of the accident, we later found that there was a recall on the brakes. PMA companies is the TPA for the Victaulic Companies, please see accident description below: Insured driver states she Pulled in driveway and was trying to park vehicle. Driver hit the brakes all the way down and the vehicle did not stop. Vehicle went through drivers fence and struck a tree causing damages to vehicle. Caused damages to neighbors fence.

Reported

Sep 2025

Incident date

May 2025

Mileage

Not provided

Outcome flags

Crash

The fuel line/fuel pump was leaking. Smelled fumes from the gasoline. Fuel was leaking over the fuel tank from the top of the tank. The vehicle was drivable when fuel was leaking. Very concerned that their could have been a fire due to the fuel leak. Took the vehicle to the Ford service department where it was purchased. Service shop stated that during inspection they noticed that something chewed through the fuel line/fuel pump. Comments made by the service advisors stated that they have seen squirrels/rodents attracted to the soy based ingredients of the parts/wiring. The repair would not be covered under warranty due to "outside influence". The manufacturer is installing a similar part and not covering under warranty. No warning lights; no warning messages. If the same type of soy based part is being installed, what is going to prevent the same thing from happening. Ford is not offering different types of parts and they do not have a way to prevent additional damage. No shield/tape/covering is being offered. Numerous instances of this referenced online due to soy based parts and Ford knowingly installing these parts without a fix or prevention. Consumer is responsible for all repairs. No warranty.

Reported

Aug 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2024 Ford Expedition. The contact stated that while driving at various speeds, the message "Drive Assist Unavailable" was displayed. The contact stated that when the vehicle was turned off and restarted, the system was functional. The contact had taken the vehicle to a local dealer, who checked the 12-Volt battery and found that the battery was operational and there were no other electrical issues. The contact stated that later, while starting the vehicle, the message "Loss of Power Steering Assist" was displayed, and the steering wheel was difficult to turn to the left or the right. The vehicle was turned off and restarted, and regained power steering functionality; however, the failure reoccurred. The contact attempted to reset the electrical system by disconnecting the battery terminals. The contact stated that loss of power steering reoccurred with the loss of the Lane Keep Assist feature. The contact had taken the vehicle back to the same dealer who diagnosed the vehicle and checked the wiring harness and coated the terminal connectors with a gel for better connectivity. The vehicle was repaired; however, the failures reoccurred. Additionally, the contact stated that the “Driving Modes” light was illuminated. The contact stated that while attempting to switch modes to Snow or Sport, or another option, the light illuminated with the message that each selected mode was unavailable. The contact stated that the vehicle would be taken back to the dealer for the failure. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 36,000.

Reported

Aug 2025

Incident date

Feb 2025

Mileage

Not provided

Outcome flags

None reported

I am the owner of a 2024 Ford Expedition, purchased new in March 2024. I am writing to formally report multiple instances of complete brake failure, which pose a significant safety risk. The most recent incident occurred on [XXX], at approximately [XXX], while I was driving northbound on [XXX] in Cupertino, California, with my wife and two grandchildren (ages [XXX] and [XXX]) in the vehicle. As I approached the [XXX] exit, I began decelerating. While applying continuous pressure on the brake pedal during the descent of the off-ramp, the brake pedal suddenly went soft and sank to the floor. The vehicle failed to slow down and began accelerating downhill, due to gravity, toward the intersection at [XXX] , where the light was red. This total loss of braking control lasted for approximately 5 to 10 seconds and nearly resulted in a serious collision. I was only able to regain control by releasing and reapplying the brake pedal and shifting the transmission into Park, at which point the brakes resumed normal function. A similar brake failure occurred earlier in 2024 under comparable driving conditions. At that time, I believed it to be an isolated mechanical glitch, and therefor did not take it to the dealer. I brought the vehicle to Frontier Ford in Santa Clara the following day ([XXX]) for immediate inspection. Despite ongoing efforts by the dealership and Ford engineering, the issue has not been duplicated or resolved. As of this writing, the vehicle remains at the dealership. I am filing this complaint so that the matter may be officially documented and thoroughly investigated as a potential systemic safety defect affecting this model. I urge you to investigate this issue promptly to help prevent similar incidents and ensure the safety of other drivers and passengers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Aug 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2024 Ford Expedition. The contact stated that while driving on several occasions at speeds between 60 MPH - 80 MPH, the vehicle was shaking abnormally. The vehicle was taken to the dealer approximately six times however, the dealer was unable to duplicate the failure. The manufacturer was notified of the failure. The failure mileage was approximately 5,000.

Reported

Aug 2025

Incident date

Oct 2024

Mileage

Not provided

Outcome flags

None reported

Was rear ended on highway and both driver and passenger seats upon impact where laid back.

Reported

Aug 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

Crash 2 injuries

I am filing this complaint regarding Ford Safety Recall 25S49 (NHTSA Campaign Number 25V315). My vehicle is a 2024 Ford Expedition Max, VIN [XXX] . The Ford pass app and the Ford recall site both show the remedy for the recall as "Available", but when I contact my dealer (Maxwell Ford in Austin, TX) they say that the repair cannot be performed because the update is not yet active in the Oasis dealer system. Ford has had months to release the software fix, but continues to delay the rollout to dealerships. Meanwhile, I have been without my vehicle because the rearview camera is unreliable and considered a safety hazard under the recall. I am paying for a new vehicle that is parked at the dealership and undriveable due to Ford's failure to provide a timely remedy. I have contacted Ford Executive Relations and their social media team, but have received no response or resolution. I am requesting that NHTSA hold Ford accountable for failing to make this safety recall fix available in a timely and transparent manner. The communication has been misleading to owners, and the delay is causing both financial and practical hardship. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Aug 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

Passenger sideview mirror does not open upon unlocking and starting the vehicle. I need to stop (if started driving) turn to park, turn off car, open driver's door to signal car that I have left, lock car using remote, wait few seconds and then unlock to reset car then it usually opens. Issues with mirror began happening a month after purchasing brand new car (5/24), first mirror was "popping or clicking" upon turning outright, mirror had been replaced once, over last year issue has been on going and brought to dealershop " deemed a technological glitch" - no warning lights or messages appear - sometimes my control panel screen will turn black upon starting the car which I now know means to look at my passenger mirror. This last occurred on Friday 7/25/25.

Reported

Jul 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

The issue involves the brake system, specifically a brake fluid leak from the master cylinder area, which was identified under Ford Safety Recall 25S47. The component is still in the possession of the dealership and should be available for inspection upon request. I did not personally experience any symptoms while driving. There were no warning lights, messages, or noticeable changes in braking performance before the issue was discovered. The problem was confirmed by the service department at JC Lewis Ford during a recall inspection. They deemed the vehicle unsafe to drive due to the risk of reduced or complete loss of front braking power, which could place my safety and the safety of others at risk. As of now, the vehicle has been at the dealership for over 35 days, and Ford has not provided a fix or repair parts. I am currently driving a loaner vehicle. The issue has not been resolved and the vehicle remains out of service.

Reported

Jul 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

6/10/25- car turned off in the middle of the road 6/12/25- car would not start 7/6/25- car would not start 6/16/25 and 7/12/25 car apparently had warning in the ford system of a malfunction

Reported

Jul 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2024 Ford Expedition. The contact stated that while making a right turn, the vehicle accelerated independently and rear-ended a city bus. The vehicle came to a stop from the impact. None of the air bags deployed. There were no injuries sustained. The "Pre-Collision Assist not available" and the "Adaptive Cruise not available" messages were displayed. In addition, the contact stated that the accelerator pedal fractured in two pieces. No police report was filed. The vehicle was towed to a dealer. The vehicle was not diagnosed. The accelerator pedal was replaced. The contact stated that one month prior to the accident, the "Pre-Collision Assist not available" and the "Adaptive Cruise not available" illuminated intermittently. The insurance company was not made aware of the accident. The manufacturer was made aware of the failure, and a case was opened. The failure mileage was 15,263.

Reported

Jul 2025

Incident date

Apr 2025

Mileage

Not provided

Outcome flags

Crash

I have a 2024 FORD Expedition Platinum I purchased new in May 2024. It has a vehicle vibration at 70+ MPH. This vibration is severe and felt through the entire SUV. Our retailer has tried all that FORD will allow under warranty to correct the problem. This includes rotating, rebalancing and replacing all the tires. Yet the problem prevails. The dealer service manager told me that complaints have come in from other owners expressing the same problem. However there has been no forward progress at this point. My concern is with this vibration, over time there will be some component fatigue and failure. And, I feel FORD is not actively engaged in correcting the issue. HELP.

Reported

Jul 2025

Incident date

May 2024

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2024 Ford Expedition. The contact received notification of NHTSA Campaign Number: 25V314000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

Reported

Jul 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

I actually have already sent in an assessment for airbag, but then read the recall on brakes, which at the time, because a new vehicle, I didn’t think possible. Even when pushing on my brakes, my vehicle was not slowing down like it should have, and I had a front end collision. It was hard for me to think this was because of brakes because new, but I do think they need to be examined.

Reported

Jun 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

Crash 1 injuries

When driving at highway speeds with speed control on the car will on its own slow down to 55 or 45 for no apparent reason and will not pick up the highway speed until the next sped limit sign is passed. More concerning is running at speed control set of 55mph on [XXX] the car speeds up when passing a state highway 70 sign the car ...on its own ...speeds up to 70mph. This happened numerous times between Eagle River, WI and Woodruff, WI. When slowing down thru a town the speed control slowed down on its own to 45 then 35 and as we left town the speed control on its own speed up tp 45 , then we passed another Wisconsin highway #70 sign the car speed up to 70 until 50 feet later we passed a 55mph speed sign and the car slowed to 55. Very concerning and the Ford dealer in Eagle River asked if we were on [XXX] ? I answered yes and he acted like he has heard that complaint before, and that there was no known fix to the issue. In our travels we stopped at a Ford dealer in Hazelwood, MO. and the service writer said he had never had heard of the issue. Any help with this ongoing issue would be helpful. Thank you [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jun 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2024 Ford Expedition. The contact stated while driving 75 MPH, the messages "Pre-Collision Assist Not Available", "Front Camera Default -Service Required", "Lane Merge Default", "Check Parking Sensors", "Blind Spot System Fault", "Cross Traffic System failure", and "Normal Cruise Control Active - Adaptive Braking Off" were displayed. The contact stated that a large red warning box appeared stating 'Resume Control" and the brakes were applied independently, causing the vehicle to come to an abrupt stop. The vehicle was taken to a dealer and the contact was informed that a software update would be released in October, and the vehicle was released. The vehicle was taken to two dealers ; however, the vehicle was not diagnosed, but the system was reset. The contact stated that the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 3,000.

Reported

Jun 2025

Incident date

Dec 2024

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2024 Ford Expedition. The contact stated that the driver's side front floor mat was buckling and slipping underneath the brake and accelerator pedals. There were no warning lights illuminated. The contact stated that occupants were tripping on the passenger’s side front floor mat. The local dealer was contacted, where it was diagnosed and determined that floor mats needed to be replaced. The vehicle was not repaired. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.

Reported

Jun 2025

Incident date

Oct 2024

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2024 Ford Expedition. The contact stated that while operating the vehicle, there was an abnormal rattling sound coming from the roof of the vehicle. The vehicle was taken to the local dealer, who determined that the panoramic sunroof brackets had fractured and needed to be replaced. The brackets were replaced; however, the failure later reoccurred. The contact was informed by the local dealer that the sunroof glass was too heavy for the brackets used to secure the sunroof. The contact was concerned that once the vehicle was repaired, the failure would likely recur. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 10,000.

Reported

Jun 2025

Incident date

Oct 2024

Mileage

Not provided

Outcome flags

None reported

I was in a car accident on June 12, 2025, and my steering wheel airbag did not deploy correctly or function correctly. It was a front in straightforward collision. I did not have warning signs so my brakes could have been an issue because I was paying attention and unable to avoid an accident going under the speed limit. The rear cross traffic. Warning stays on pretty consistently because we live down a dirt road, and every time it rains, it again comes back on. I do not believe I heard the forward collision detection go off either. When I hit the back of a work convoy truck straight on, My steering wheel airbag did not deploy correctly. It did come out it never inflated. It did not protect me. I do not have any broken bones, but I do have a hematoma right beside my under arm, and a great deal of bruising.

Reported

Jun 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

Crash 1 injuries

Sunroof exploded while driving down the road.

Reported

Jun 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

The differential came apart while my family and I were traveling on the highway out of town. This cause the vehicle to start violently jolting and wheels locked up. The vehicle began to skid across the center line into on coming traffic, we were almost hit head on and from behind due to this. My husband couldn’t get the vehicle to move, it was making a grinding and screeching noise. Finally, he got it into 4x4 mode and was able to move the vehicle to the shoulder of the road. This was a very traumatic and terrifying experience for my whole family, we literally thought we were doing to die. Not to mention, there was no indication or warning that notified us on the dashboard. Since we were 100 miles from home, I had to have my vehicle towed, partially at my expense to the closest Ford dealership in California, which was still 40 miles from my home. The service department confirmed it was the differential, it took almost two weeks to get the part and to fix it. Since, my vehicle was practically brand new and only had 2000 miles on it, the repair was covered under warranty. I contacted Ford customer service and notified them of what happened. I requested them to buy back the vehicle, however they declined. Now I am stuck with a brand new $75,000 vehicle with only 2150 miles on it, that I do not feel safe driving my family in. If one major issue has already happened, then the probability of something else major happening is pretty good. I’m extremely disappointed in Ford for not standing by their vehicles.

Reported

Jun 2025

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

Components: Engine & Power Train Safety Risk: Momentary loss of power Problem has not been reproduced by dealer or independent service center. Vehicle has been inspected by Ford Dealer Joe Cooper Ford in Oklahoma City, OK There were/are no warning lamps, messages or other symptoms of the problem that appear prior to the failure. This has happened 6 or 7 times since vehicle was purchased in October 2024 : Accelerating from stop with Auto Start/Stop either on or off and reach between 35 - 40 mph. Vehicle suddenly dies but immediately started back up like nothing ever happened. Joe Cooper Ford reinstalled the latest update on 4/29/2025 and thought this would fix the problem. [XXX] - Accelerated from start. Auto Start/Stop is on. Reached 38 mph-engine suddenly died then immediately restarted. Drive selector blinking red on console in D. Could rev engine but seemed transmission was in N. Switched drive selector to N, the back to D and resumed as normal. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6

Reported

May 2025

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

We are driving cross country. Three times the adaptive cruise control has accelerated and showed a new speed going as much as from 74 mph to 107 the third time. The second it went 75 to 88. I can’t remember the first but I know we had a sudden acceleration and quickly disengaged as we did all three sessions. Now we are finishing our trip to our summer home in Maryland without engaging because we don’t trust the system.

Reported

May 2025

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

At 715 miles on the odometer, the driver's side rear axle became detached from the wheel hub bearing, causing a loss of power while driving. Dealer states this was a manufacturing defect as the axle retaining bolt was cross-threaded and not properly seated.

Reported

Apr 2025

Incident date

Apr 2025

Mileage

Not provided

Outcome flags

None reported

While using the adaptive cruise control, the speed of the vehicle rapids accelerates. If set to any speed less than 50, the vehicle speeds up to 56mph. If set to any speed greater than 56 but less than 86 mph, the speed of the vehicle accelerates to 86 mph. I have tested this issue over and over. I haven't talked to the dealership yet, but plan to today. Very scary to have the vehicle accelerate for no reason and for no driver input. The acceleration is fairly abrupt. The speed does not decline only speeds up.

Reported

Apr 2025

Incident date

Apr 2025

Mileage

Not provided

Outcome flags

None reported

When driving my entire window switch controller unit stopped working on the driver's side. At the time the window was partially down. After research I came to find this has been a common problem with the switch unit in Expeditions, F150s, Explorers. This is a safety issue as you cannot get the window to roll up which allows rain and snow to enter the driver's side door and affect your vision. Also, because the whole switch unit stopped working at once, I can not fold/unfold my side mirrors and I can not adjust them. I have an appointment on April 8th for repair. The switch should be available for inspection with them then. There were no warning lights prior to it stopping working.

Reported

Apr 2025

Incident date

Mar 2025

Mileage

Not provided

Outcome flags

None reported

Ford Motor Company (Ford) is recalling certain 2018-2024 Expedition vehicles. The chrome plating on the center console may bubble and peel, resulting in sharp edges.

Risk: Vehicle occupants may contact the center console's sharp edges, increasing the risk of injury.

Remedy: Dealers will inspect and replace the center consoles as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 16, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S38. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 10, 2026.

Ford Motor Company (Ford) is recalling certain 2022-2024 Navigator and Expedition vehicles. The front brake lines may contact the engine air cleaner outlet pipe and become damaged, possibly resulting in a brake fluid leak and reduced brake function.

Risk: A loss of brake function increases the risk of a crash.

Remedy: Dealers will inspect the front brake line and replace the brake line or air cleaner outlet pipe, as necessary, free of charge. Owner notification letters were mailed May 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S47.

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.

Risk: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.

Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.

Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

Ford Motor Company (Ford) is recalling certain 2024-2025 F-150, 2024 Expedition and 2024 Lincoln Navigator vehicles equipped with a 3.5L GTDI engine. The engines may have a misaligned engine cup plug, which can result in a rapid oil leak.

Risk: A rapid oil leak can result in an engine stall, increasing the risk of a crash. In addition, an oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

Remedy: Dealers will inspect the engine cup plug alignment, and replace the plug if necessary, free of charge. Owner notification letters were mailed on May 23, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S70.

Ford Motor Company (Ford) is recalling certain 2024-2025 F-150, Expedition, and 2024 Lincoln Navigator vehicles equipped with 3.5L GTDI engines. The engine may have a misaligned engine cup plug, which can result in a rapid oil leak.

Risk: A rapid oil leak can result in an engine stall, increasing the risk of a crash. In addition, an oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

Remedy: Dealers will inspect the engine cup plug alignment, and replace the plug if necessary, free of charge. Owner notification letters were mailed May 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S30.

Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."

Risk: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.

Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.