2012 Volvo XC60

Four tires purchased June 2022. As of July 2025 with 17,500 miles on the tires there is ozone/weather cracking on the entire tire and the sidewall near the rim is failing with the cord visible on one tire.

Reported

Jul 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2012 Volvo XC60. The contact stated that while it was raining, water seeped through the driver's side front windshield and onto the steering wheel. The contact placed a towel on top of the steering wheel to prevent water from damaging the electrical system. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 61,174.

Reported

May 2024

Incident date

May 2024

Mileage

Not provided

Outcome flags

None reported

The windshield leaks constantly. I'm worried about the windshield blowing out or electrical components being damaged. This seems to be a constant complaint according to internet search. Why hasn't this been addressed as a safety issue and a recall ordered?

Reported

Jan 2024

Incident date

Jan 2024

Mileage

Not provided

Outcome flags

None reported

During rain, water is leaking inside the car from the driver’s side windshield while I’m driving, obstructing my vision.

Reported

Dec 2023

Incident date

Dec 2023

Mileage

Not provided

Outcome flags

None reported

It was explained to me that since the Back rear seat in the Volvo XC60 seatbelt had a fault that it alerted the SRS airbag system. In event of a crash the airbags in my car would not deploy and that the only remedy was to replace the entire seatbelt in the Volvo. To prove this point I took my car in to a Volvo dealership and the technicians offered the fix as the only way my cars airbags would work if i got it fixed.

Reported

May 2023

Incident date

May 2023

Mileage

Not provided

Outcome flags

None reported

On October 12, 2022 while driving home from the Schar Cancer Center in Fairfax, my 2012 Volvo XC60 experienced an end of life event. My check engine light came on when I entered my neighborhood. The car began sputtering and the gas pedal was delayed and at times, unresponsive. I was able to make it to my house and made an appointment to service my Volvo. My Volvo was towed to GT Peace Automotive on November 6. The three-week delay was due to their backlog of work. They are a trusted repair service and have provided service to all my vehicles over the past four years. The attached document indicates their assessment. Highlights include that the Volvo was a fire hazard in its current condition, the ignition coils were melted, and the circuits are shorted. GT Peace provided an estimate of $3,500 for repairs as a starting point to fully replace the engine harness. Their evaluation concluded that, based on other findings, the cost would easily go north of $3,500, possibly to $5,500. Based on this assessment and the CARFAX History Based Value of my vehicle (private party value of $10,170), it was in my best interest to donate the vehicle. I gave it to the Auto Tech program at Centreville High School on November 9, 2022.

Reported

Nov 2022

Incident date

Oct 2022

Mileage

Not provided

Outcome flags

None reported

A faulty radiator anti-tamper device caused loss of communication to the engine control computer. The check engine light turns on and “charging failure-service urgent” message pops up during driving. Which cause the drivers worry even panic. I talked to local dealer several times. I was told to change battery everytime. But my battery and alternator were both tested fine. The message could pop up right after full charged battery. There are many complains at Volvo forums. Volvo knows the issue, but they decided not to recall it. The check engine light and messages pops up on and off by itself. The DTC codes are normally U0286 and/or B1087. I am already changed one battery. The problem is still there. It could cause accident because the message pops up during driving on highway and cause unnecessary worry and panic.

Reported

Oct 2022

Incident date

Oct 2022

Mileage

Not provided

Outcome flags

None reported

"Failure Charging" warning advisory light came on the dashboard. This problem has been going on for the whole ten years I have owned this vehicle. I am the original owner of this Volvo and had some engine warning on the dashboard since the first month. I took vehicle in to the Culver City Volvo for 1000 miles check-up and annual oil change and check-up for 5 years under warranty and requested software update and reported the engine stalling during the first month. The "failure charging" or "engine check" or "dangerous" "immediate" repair needed signs came on sometimes and did not come on other time. When the "failure charging" sign comes on and the engine is turned off and restarted the warning would go away sometimes. I believe this is a Volvo vehicle computer software malfunction. I reported this problem to the dealer for 5 years during annual service appointments. This problem was not solved and I have lived with this, stupidly patient for 10 years. Today, problem light came on during biennial smog check for vehicle license renewal and failed the smog test. So, I informed the mechanic and tried a second test several minutes later and passed the second time because the software problem did not surface this time. So, my question is: has this Volvo software problem been reported by others as I have heard by word of mouth that this software problem is found on Volvo cars? And, has there been a recall to fix this Volvo software problem? When this "failure charging" sign comes on, it is very worrisome and makes me feel the vehicle may stop on the road.

Reported

Aug 2022

Incident date

Aug 2022

Mileage

Not provided

Outcome flags

None reported

The front windshield was not properly sealed during manufacturing and is now leaking when it rains. Water drips down the inside of the windshield in front of the driver resulting in distraction and poor visibility. I also fear that in an accident the windshield would not perform as it should and would be a safety issue. I brought it to the Volvo dealer and they just said I had to have it replaced but they do not provide that service. I brought it to a windshield service center and the technician was able to push on the windshield with only his hand and confirm that it was not sealed and showed movement. They also mentioned that have seen this issue many times with these cars. There were no warnings other than the leak which started a few months ago.

Reported

Jul 2022

Incident date

Jul 2022

Mileage

Not provided

Outcome flags

None reported

Lately my vehicle has been shutting off power when I hard right turn during parking everything shut off then I have to restart it again, but the scary part was what happened this morning I was driving on interstate and as I was charging lanes it almost powered off again but it picked up.

Reported

Jul 2022

Incident date

Jul 2022

Mileage

Not provided

Outcome flags

None reported

The windshield was not sealed properly during manufacturing because of a problem with the sealant used. This has caused a leak from the windshield on both the driver and passenger side from the top of the windshield when it rains. This creates lowered visibility when driving with water on the inside of the car, and also causes driving distractions while operating the vehicle. This improperly installed windshield also has caused malfunctions in electrical components in the windshield. There are no warning lights for this issue, but the windshield must be resealed by an auto glass technician.

Reported

Jun 2022

Incident date

Jan 2022

Mileage

Not provided

Outcome flags

None reported

Manufacturers original windshield began leaking. On inspection windshield is not properly bonded or adhered to vehicle body and is able to be pushed off the body of the vehicle with little pressure from the inside of the cabin. Windshield repair company advised me to look for a recall notice they were so concerned. Didn't find one, so I wanted to report a safety concern

Reported

May 2022

Incident date

May 2022

Mileage

Not provided

Outcome flags

None reported

Original front windshield separating from frame of car. Leaking water during rain / melting snow. In cold weather forms ICE/FROST on INTERIOR posing visibility hazard! Autobody worker showed me how the windshield MOVED when he pushed on it with nothing more than his hand - warned me this is also a structural risk in case of crash. He stated he has personally seen hundreds of these on same model car for this year and the two following. Doesn't know why the company doesn't issue a recall!

Reported

Mar 2022

Incident date

Mar 2022

Mileage

Not provided

Outcome flags

None reported

Our 2012 Volvo XC60 has a problem with the seal along the top of the windshield, which allows water into the interior of the car. It can end up dripping onto my lap while driving, which is distracting and a potential safety issue, and it also can obstruct visibility as water runs down the inside of the glass.

Reported

Mar 2022

Incident date

Mar 2022

Mileage

Not provided

Outcome flags

None reported

During heavy rains and movement there is water leaking into the vehicle along the top drivers inside of the windshield. It also drips onto the steering wheel which often startles me while actively driving. The windshield has no cracks and is the original windshield.

Reported

Jan 2022

Incident date

Dec 2021

Mileage

Not provided

Outcome flags

None reported

There is a steady leak in the top left (driver side) of the windshield. Heard from the Tom Wood service and collision department that this is a common problem with these vehicles.

Reported

Dec 2021

Incident date

Nov 2021

Mileage

Not provided

Outcome flags

None reported

When it rains or I go through the car wash the windshield leaks water that runs down the inside of the glass and has stained the headliner

Reported

Dec 2021

Incident date

Jul 2020

Mileage

Not provided

Outcome flags

None reported

When it rains or when getting a car wash, the windshield leaks water into car.

Reported

Aug 2021

Incident date

Aug 2021

Mileage

Not provided

Outcome flags

None reported

The rain water leaking through windshield. It could cause rust in the frame, then cause the failure of whole structure. I checked the Volvo forums, seems there are many Volvo owners have similar issues. I owned other cars, it’s the first time I had leaking water through perimeter of windshield.

Reported

Aug 2021

Incident date

Jun 2020

Mileage

Not provided

Outcome flags

None reported

My volvo windshield started leaking from the top seal. When it rains water runs down the entire inside of the front windshield.

Reported

Aug 2021

Incident date

May 2021

Mileage

Not provided

Outcome flags

None reported

My left front door failed to open using the outside handle. I have tried unsuccessfully to fix the problem by removing the inside door panel, the door window, and the surrounding hardware and electrical components. I contend that this is a safety hazard because a)a rescuer would fail to get the driver out of the vehicle in case of an accident and b)the door could open while driving because the latch contains a defective part. Other Volvo models have been recalled because of this problem, but my Vin number is currently not included in the recall. I contend that it should be recalled for my vehicle.

Reported

Jun 2021

Incident date

Jun 2021

Mileage

Not provided

Outcome flags

None reported

Windshield seal failed causing water to leak into car

Reported

Jun 2021

Incident date

Apr 2021

Mileage

Not provided

Outcome flags

None reported

SEVERE INTERIOR WATER LEAK FROM TOP OF WINDSHIELD WHENEVER IT RAINS, DURING A CARWASH, ETC. - CREATING VISIBILITY PROBLEMS FOR THE DRIVER & A RESULTING SAFETY HAZARD SINCE THE WINDSHIELD IS NOT SUITABLY SEALED. THE VEHICLE HAS BEEN GARAGE PARKED, NEVER BEEN IN ANY TYPE OF COLLISION, AND NEVER BEEN DAMAGED IN ANY WAY. WINDSHIELD LEAKAGE IS A COMMON ISSUE WITH VOLVOS, EVEN THOUGH THE MANUFACTURER AND LOCAL DEALERSHIPS CONTINUE TO DENY THERE IS A PROBLEM.

Reported

Dec 2020

Incident date

Jan 2019

Mileage

Not provided

Outcome flags

None reported

THE FUEL GAUGE SHOWS NO FUEL EVEN WHEN FULL OR AT TIMES SHOWS ABOUT 1/3 FULL EVEN WHEN FULL. AND DOES NOT DECREASE - ALLOWING FOR POSSIBLE RUNNING OUT OF GAS- CAUSING A ROAD HAZARD

Reported

Dec 2020

Incident date

Dec 2020

Mileage

Not provided

Outcome flags

None reported

WINDSHIELD SEALING PROBLEM. WATER IS LEAKING THRU TOP OF THE WINDSHIELD.

Reported

Dec 2020

Incident date

Nov 2020

Mileage

Not provided

Outcome flags

None reported

2012 VOLVO XC60. CONSUMER WRITES IN REGARDS TO SOFTWARE PATCH. *LD THE CONSUMER STATED THE XM RADIO DRAINED THE VEHICLE'S BATTERY. THE COSUMER REQUESTED TO HAVE THE SOFTWARED UPDATE PERFORMED FOR FREE. THE DEALER DECLINED. *JS

Reported

Oct 2020

Incident date

Oct 2020

Mileage

Not provided

Outcome flags

None reported

THE VEHICLE'S WINDSHIELD HAS BEEN LEAKING WATER THROUGH THE TOP OF THE DASHBOARD. WHEN IT RAINS, THE WINDSHIELD LEAKS ALL OVER. I HAVE BEEN FOLLOWING FORUMS AND IT IS A COMMON PROBLEM IN THIS PARTICULAR MODEL OF VOLVO BUT HAS NOT BEEN A RECALL. IF THIS CONTINUES I'M AFRAID SOMEONE DRIVING COULD LOOSE VISIBILITY IF ITS RAINING. EVEN THROUGH THE CARWASH THIS VOLVO MODELS LEAK WATER. SOMETHING NEEDS TO BE DONE.

Reported

Jul 2020

Incident date

Jul 2020

Mileage

Not provided

Outcome flags

None reported

I BOUGHT MY XC60 IN 2012 FROM GERALD JONES VOLVO IN EVANS, GA. APPROXIMATELY IN 2017 MY WIFE NOTICE WATER COMING INSIDE THE CAR FROM THE WINDSHIELD ON THE DRIVER'S SIDE. AT THAT TIME, I HAD THE DEALERSHIP LOOK AT THE WINDSHIELD AND SUNROOF. THEY FOUND NOTHING WRONG. THE WATER CONTINUED TO LEAK IN THE CAR, BUT IN JULY 2017, THE NAVY TRANSFERRED ME TO JAPAN AND THE CAR WAS STORED IN A MILITARY APPROVED FACILITY. I WAS NOT ABLE TO GET THE WINDSHIELD REPAIRED PRIOR TO LEAVING OVERSEAS. WHEN WE RETURNED IN JULY 2019, WE WERE REMINDED OF THE LEAK WHEN WE TOOK THE CAR THROUGH A CARWASH. FINALLY, ON 10 JAN 2020 AFTER I MADE THE CLAIM WITH MY INSURANCE COMPANY, I TOOK IT TO SAFELITE IN FALLSCHURCH, VA. THE TECHNICIANS CHECKED THE WINDSHIELD AND THEY COMMENTED THAT THEY HAVE SEEN A LOT OF VOLVO'S WITH FACTORY INSTALL ISSUES WITH WINDSHIELDS. I CHECKED YOUR WEBSITE FOR RECALLS AND THERE WERE NONE. WHEN THE TECHNICIANS REMOVED IT THEY FOUND THAT THE SEAL WAS NEVER BONDED TO THE WINDSHIELD AT THE VERY TOP OF THE WINDSHIELD AND THE WINDSHIELD WAS LOOSE ALL ALONG THE ROOFLINE. I'VE ATTACHED PICTURES. I BELIEVE THIS IS A MAJOR SAFETY PROBLEM. I SEARCHED THE INTERNET FOR OTHERS THAT HAD SIMILAR COMPLAINTS AND FOUND A LOT OF PEOPLE WITH THIS SAME YEAR, MAKE, AND MODEL HAVE COMPLAINED. THIS SHOULD BE A MANDATORY SAFETY RECALL. THERE APPEARS TO BE A SERIOUS PROBLEM WITH THESE VEHICLES AND COULD CAUSE SERIOUS INJURIES IN A COLLISION, IF NOT DEATH. THIS DEFECT IS CONSISTENT WHETHER WE ARE IN MOTION OR SITTING STILL. IT LEAKS ALL THE TIME.

Reported

Jan 2020

Incident date

Feb 2017

Mileage

Not provided

Outcome flags

None reported

OVER A PERIOD OF THE LAST 45 DAYS ON TWO SEPARATE OCCASIONS,IN RAIN, AT HIGHWAY SPEED OF 55MPH+, THE OVERALL PERFORMANCE OF THE DRIVER INPUTS FAILED TO FUNCTION. WHEN DRIVING, TURNING THE WHEEL TO LEFT/RIGHT TO CHANGE LANES OR PULL TO THE SLOW LANE; MADE THE CAR FEEL AS IT WANTED TO SPIN OUT UNCONTROLLABLY.TO MOVE THE STEERING WHEEL LEFT, THE CAR WANTED TO GO RIGHT. WHEN GOING STRAIGHT THERE WAS A WOBBLY UNSTABLE FEELING, AND WAS NOTICEABLE TO PASSENGERS IN THE CAR. THE ISSUE DID NOT OCCUR AT LOWER SPEEDS AND CAR PERFORM NORMALLY. THE SENSATION WAS SIMILAR TO THE INPUT ON A BOAT. THE ONLY CORRECTION WHICH WORKED WAS TO SLOW DOWN TO 40-45 AND TAKE SIDE ROADS. AT LOWER SPEEDS BRAKE TESTING AND OTHER MANEUVERS WERE PERFORMED WITHOUT ISSUE.

Reported

Dec 2019

Incident date

Dec 2019

Mileage

Not provided

Outcome flags

None reported

DURING RAIN, THE DRIVER'S SIDE OF THE WINDSHIELD LEAKS. WITH RESEARCH OF THE ISSUE, MANY PEOPLE HAVE COMPLAINED. THE PROBLEM IS PRESENT DUE TO A PRIMER ON THE GLASS THAT IS FAILING. THIS BLACK PRIMER IS APPLIED IN A THIN LAYER TO THE WINDSHIELD. THE ADHESIVE BEING USED BY VOLVO, REQUIRES THIS PRIMER PROMOTE A PROPER BOND BETWEEN THE GLASS AND THE ADHESIVE (POLYURETHANE). HOWEVER, THIS PRIMER IS SEPARATING FROM THE GLASS. THE BIGGEST CONCERN VOLVO OWNERS SHOULD BE AWARE OF IS NOT THE POTENTIAL OF A WATER LEAK. THE WINDSHIELD IS A STRUCTURAL COMPONENT OF THE VEHICLE. IF THE WINDSHIELD IS NOT BONDED TO THE VEHICLE PROPERLY IT WILL COMPROMISE THE SAFETY OF THE OCCUPANTS IN THE EVENT OF AN ACCIDENT. THE WINDSHIELD SUPPORTS THE AIRBAGS UPON DEPLOYMENT, CRUMPLE ZONE FUNCTION DURING A COLLISION, AND THE ROOF IN THE EVENT OF A ROLLOVER.

Reported

Dec 2019

Incident date

Sep 2019

Mileage

Not provided

Outcome flags

None reported

I HAVE A 2012 VOLVO XC60 WITH AN ADHESIVE FAILURE AT THE TOP OF THE WINDSHIELD THAT IS APPARENTLY CAUSED BY A MANUFACTURING DEFECT THAT VOLVO HAS YET TO TAKE RESPONSIBILITY FOR REPAIRING AT THEIR DEALERSHIPS. THIS IS A SAFETY HAZARD. ACCORDING TO VOLVO: "THE WINDSHIELD IS ONE OF THE MOST IMPORTANT PARTS OF THE CAR. NOT ONLY DOES IT ENSURE AN UNDISTORTED VIEW ' IT ALSO IS A CRITICAL STRUCTURAL COMPONENT OF THE VEHICLE. THAT MEANS THE INSTALLATION PROCESS FOR WINDSHIELD REPLACEMENT HAS TO BE EXACT AND PERFORMED USING ONLY VOLVO GENUINE GLASS IN ORDER TO RETAIN THE ORIGINAL PROPERTIES. THE WINDSHIELD IS IMPORTANT TO THE STRUCTURAL INTEGRITY OF THE VEHICLE AND ALSO INTERACTS WITH MANY VOLVO SAFETY SYSTEMS. THE ONLY WAY TO PRESERVE PERFORMANCE AND GUARANTEE SAFETY IS TO INSTALL VOLVO GENUINE WINDSHIELDS. USING VOLVO-SPECIFIED ADHESIVES WILL BOND THE WINDSHIELD TO THE SAME STRENGTH AS WHEN ASSEMBLED IN THE FACTORY. IT'S IMPORTANT THE BOND HAS THE RIGHT STRENGTH FOR THE FUNCTION OF THE PASSENGER AIRBAG WHICH IS DESIGNED TO USE THE WINDSHIELD AS A SUPPORT WHEN DEPLOYED." HTTPS://WWW.VOLVOTECHINFO.COM/SITECONTENT/CERTIFIEDCOLLISION/FACTSHEETVOLVOGENUINEWINDSHIELD011419-FINAL.PDF I HAVE BEEN REFERRED TO AN AUTO GLASS SHOP BY THE VOLVO DEALERSHIP FOR REPAIR AND WAS TOLD BY THAT SHOP THAT THERE IS NO AFTER MARKET PART SO THE PART FROM VOLVO IS OVER $700.00 AND THAT I WOULD NEED TO BE PREPARED TO PAY FOR THAT PART SHOULD THE GLASS SHATTER UPON REMOVAL. *TR

Reported

Sep 2019

Incident date

Sep 2019

Mileage

Not provided

Outcome flags

None reported

TL* THE CONTACT OWNS A 2012 VOLVO XC60. WHILE OPERATING THE VEHICLE IN THE RAIN, WATER LEAKED FROM THE DRIVER'S SIDE WINDSHIELD AND MADE CONTACT WITH THE DRIVER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 98,000. THE VIN WAS INVALID.

Reported

Apr 2019

Incident date

Feb 2019

Mileage

Not provided

Outcome flags

None reported

WATER DRIPS FROM TOP OF WINDSHIELD INTO CAR AS FAST AS IT COMES DOWN. DRAINS INTO LIGHTS FIXTURES AS WELL AS GEARS AND WHEEL. FOGGED UP GLASS ON HIGHWAY CAUSING SERIOUS SAFETY CONCERN. IN WINTER CAUSED GEARS TO FREEZE IN PARK. WATER POOLED IN BOTTOM OF CAR AND IN LIGHT FIXTURES. WATER IN SUNROOF CONTROL - CAUSED MALFUNCTION. WHEN GOING FROM STOP TO START WATER RAINS DOWN IN EYESIGHT CAUSE ANOTHER MAJOR SAFETY CONCERN. DEALER SAID WINDSHIELD WAS LOOSE. SERVICE SAID THEY HAD NOT SEEN THIS PROBLEM. SALES SAID THIS MODEL HAS THIS PROBLEM ALL THE TIME. INTERESTING CONFLICT... VOLVO FORUMS HAVE THIS ISSUE WELL DOCUMENTED.

Reported

Mar 2019

Incident date

Jan 2018

Mileage

Not provided

Outcome flags

None reported

THE FRONT WINDSCREEN / WINDSHIELD BONDING HAD FAILED WITHIN THE FIRST COUPLE OF YEARS OF OWNERSHIP OF THE VEHICLE. THIS WAS NOT KNOWN AT THE TIME, MISDIAGNOSED BY THE MANUFACTURER, AND ONLY RECENTLY IDENTIFIED BY A 3RD PARTY. THIS IS APPARENTLY A COMMON ISSUE ENCOUNTERED AND HAS LED TO, ACCORDING TO THE LOCAL 3RD PARTY GARAGE, AT LEAST ONE INSTANCE OF A WINDSHIELD BECOMING DETACHED DURING DRIVING. IN OUR CASE THE BOND HAS PROGRESSIVELY FAILED ACROSS THE TOP OF THE WINDSHIELD WITH THE SYMPTOM BEING AN INTERMITTENT WATER LEAK. ONE CONCERN IS THE WINDSCREEN DETACHING DURING MOTION, BUT MY MORE SERIOUS CONCERN IT THE POSSIBILITY OF THE WINDSCREEN AFFECTING FUNCTION OF THE PASSENGER FRONT AIRBAG.

Reported

Mar 2019

Incident date

Mar 2019

Mileage

Not provided

Outcome flags

None reported

MY WINDSHIELD STARTED LEAKING ON THE DRIVER SIDE DURING A HEAVY RAIN STORM. WATER WAS DRIPPING IN STREAMS AND IMPEDED VISIBILITY. I HAD IT EVALUATED AND THERE IS A BREAK IN THE FACTORY SEAL. THE WINDSHIELD IS ORIGINAL EQUIPMENT. THE VEHICLE HAS NOT BEEN IN ANY ACCIDENTS OR HAD ANY INJURIES. I SEE THAT THIS HAS BEEN A PROBLEM WITH OTHER VOLVOS AS WELL.

Reported

Jan 2019

Incident date

Dec 2018

Mileage

Not provided

Outcome flags

None reported

MY ISSUE IS RELATED TO THE CONSTANT CORROSION PROBLEMS ON TPS THAT LEAD TO MULTIPLE REPLACEMENTS ON MY VEHICLE. IT WAS DISCOVERED DURING SEMI ANNUAL CHANGEOVER OF WINTER AND SUMMER TIRES, WHERE ONE OF THE WHEELS AND TIRES DEFLATED DUE TO CORROSION OF THE TPS. COSTLY PART THAT IS LIKELY DEFECTIVE IN DESIGN AND IF FAILED ON ROADWAY COULD HAVE RESULTED IN A FLAT TIRE AND VEHICLE ROADWAY INCIDENT. THIS IS A REPEATED PROBLEM...

Reported

Oct 2018

Incident date

Oct 2018

Mileage

Not provided

Outcome flags

None reported

WATER LEAKING INTO INTERIOR FROM WINDSHIELD. I'VE TAKEN IT TO THE VOLVO DEALERSHIP AND THEY WON'T FIX IT DUE TO BEING OUT OF WARRANTY. SAFELITE WANTS $350-$800 TO RESEAL OR REPLACE THE WINDSHIELD. THE LEAK IS MAKING IT DANGEROUS TO DRIVE IN WET WEATHER AS IT DRIPS ONTO THE STEERING WHEEL AND ONTO THE DRIVER. THE LEAK OCCURS DURING ANY RAINY CONDITION WHILE STATIONARY OR IN MOTION.

Reported

Feb 2018

Incident date

Feb 2018

Mileage

Not provided

Outcome flags

None reported

ADHESIVE FAILURE TO THE WINSHIELD GLASS SURFACE

Reported

Oct 2017

Incident date

Oct 2017

Mileage

Not provided

Outcome flags

None reported

THE AXLES ARE ALREADY NEEDING TO BE REPLACED ON THE FRONT WHEELS. THERE IS ONLY 68,000 MILES ON THEM. THE AUTO SHOP SAYS IT'S TOO EARLY FOR THAT TO BE HAPPENING. NOT TO MENTION THERE IS A WHOPPING PRICE TAG FOR THE PARTS!!

Reported

Oct 2016

Incident date

Oct 2016

Mileage

Not provided

Outcome flags

None reported

I WAS IN AN ACCIDENT DRIVING ON A HIGHWAY DRIVING MY VOLVO XC60. I WAS TRAVELING AT APPROX 100KM/H AND RAN INTO THE BACK OF A SEMI THAT WAS TRAVELING AT AN APPROX SPEED OF 80KM/H. THE IMPACT WAS IN THE RIGHT FRONT (PASSENGER) SIDE OF MY XC-60 AND THE LEFT REAR OF THE SEMI. THE AIRBAGS FAILED TO DEPLOY ANYWHERE ON THE VOLVO. THANKFULLY, NOBODY WAS SERIOUSLY HURT AS ALL WERE WEARING SEATBELTS. BASED ON THE SEVERITY AND SPEED OF THE IMPACT, I AM VERY SUPRISED AND CONCERNED THE AIRBAG SYSTEM DIDN'T FUNCTION.

Reported

Jan 2016

Incident date

Dec 2015

Mileage

Not provided

Outcome flags

Crash

THE CAR USES AN EXCESSIVE AMOUNT OF ENGINE OIL. CHECK OIL LIGHT COMES ON WILL DRIVING CAUSING A POTENTIAL SAFETY HAZARD WHILE I FIND A SAFE LOCATION TO STOP AND ADD ENGINE OIL.

Reported

Dec 2015

Incident date

Jun 2015

Mileage

Not provided

Outcome flags

None reported

LAST EVENING WHEN TURNING A CORNER MY FINGER WAS CUT BY THE METAL PORTION OF THE STEERING WHEEL. WHEN I GOT HOME, I NOTICED THAT AT THE "6 O'CLOCK" POSITION THERE WAS SHARP METAL THAT HAS COME LOOSE AND THAT IS WHAT CUT MY FINGER. I DID SOME RESEARCH AND THIS IS A COMMON PROBLEM WITH THIS CAR. ALSO, UPON CALLING THE DEALER THIS MORNING THEY SAID THEY KEEP A NUMBER OF THE REPLACEMENT PARTS IN INVENTORY BECAUSE IT HAPPENS ALL THE TIME. MUCH TO MY SURPRISE THERE HAS NOT BEEN A SAFETY RECALL. THE DEALER SAID THEY WILL WORK WITH ME ON THE PRICE, BUT WOULD NOT COVER IT BECAUSE MY CAR IS OUT OF WARRANTY. I REALLY THINK IF PEOPLE ARE GETTING CUT THIS SHOULD BE RAISED TO A RECALL LEVEL.

Reported

Jun 2015

Incident date

Jun 2015

Mileage

Not provided

Outcome flags

1 injuries

JUST BOUGHT THE CAR AND DROVE APPROXIMATELY 30 MILES AND THE TIRE PRESSURE MONITORING SYSTEM LIGHT CAME ON. DROVE ANOTHER 10 MILES HOME AND ARRANGED FOR AN APPOINTMENT WITH THE DEALER FOR CORRECTION/REPAIR. NOTICED THAT THE ERROR WARNING DID NOT COME ON INITIALLY AFTER VEHICLE WAS PARKED BUT, SEEMED IF I DROVE ABOUT 25 MILES OR MORE THE LIGHT WOULD COME ON AND STAY ON, AND THIS IS WHAT OCCURRED UNTIL I WENT TO HAVE IT SERVICED. DEALER GET ME FOR 4 HOURS AND TOLD ME THEY COULD NOT GET THE TIRES TO READ. THE DEALER THEN MADE AN APPOINTMENT WITH VOLVO FOR CORRECTION/SERVICE, AND THEY KEPT ME FOR 3 HOURS AND SAID THEY CHECKED THE TIRES AND RESET THE SENSORS, AND BELIEVED IT WAS THE BATTERY BECAUSE THE VOLTAGE WAS NOT HIGH ENOUGH. SO THEY WERE TRYING TO GET THE BATTERY TO FAIL...THIS DID NOT EVEN MAKES SENSE. ANYWAY THEY SAID, THEY CLEARED THE CODE AND DROVE IT AND IT WAS FINE. I LEFT AND GOT ABOUT 20 MILES AWAY AND THE LIGHT CAME ON AGAIN. THE THIRD TIME I TOOK MY CAR BACK TO WHERE I PURCHASED THE CAR (NOT VOLVO) WHO TOOK IT TO ANOTHER VOLVO DEALER AND IT ONE WEEK TO TELL ME, THE TIRE PRESSURE INDICATED ON THE DOOR PANEL WHICH IS 35PSI IS INCORRECT AND IT REALLY SHOULD 38PSI AND THE CODES WERE CLEARED AND THEY DROVE IT AND ALL WAS CORRECTED. I LEFT AND DROVE ABOUT 25 MILES AND THE TPMS ERROR LIGHT WAS ON AGAIN. NEEDLESS TO SAY THEY CANNOT DETECT WHAT WAS WRONG. *TR

Reported

Jun 2014

Incident date

May 2014

Mileage

Not provided

Outcome flags

None reported

SUDDEN FAILURE OF THE POWER STEERING, AMONGST OTHERS, RIGHT IN THE MIDDLE OF A CROSSROADS. VERY DANGEROUS EMERGENCY STOPPING OF THE CAR, ENGINE STOPPED, ALL ALARMS ON, STEERING NEARLY IMPOSSIBLE TO USE WITHOUT POWER. HAD TO TOW THE VEHICLE TO SERVICE CENTER. VOLVO CLAIMS THIS IS NOTHING MORE THAN A COMMON PLACE ALTERNATOR FAILURE (THERE HAS BEEN A RECALL CAMPAIGN FOR SIMILAR PROBLEMS WITH AUXILIARY BELT TENSIONER). POWER STEERING FAILED ALTHOUGH BATTERY WAS FULLY CHARGED. FOUND ON THE INTERNET THIS OCCURRING SEVERAL TIMES TO OTHER XC60 DRIVERS. AS ALTERNATOR FAILURES WITHOUT ANY WARNING ARE SO "COMMON PLACE" AND AS THEY CAN HAVE SUCH VERY NEGATIVE IMPACT ON SAFETY, WHY ISN'T THERE ANY BATTERY-BASED POWER STEERING SURVIVABILITY AS ON MOST OTHER VEHICLES?

Reported

Aug 2012

Incident date

Feb 2012

Mileage

Not provided

Outcome flags

None reported

UNCONTROLLABLE ACCELERATION, OVERRIDING BRAKE: UNEXPLAINED ACCIDENT OCCURRED AS I HAD PULLED INTO ANGLE PARKING SLOT, FOOT ON BRAKE READY TO SHIFT TO "PARK" . SUDDENLY THE CAR UNEXPECTEDLY ACCELERATED FORWARD ABOUT 5 FEET AND LURCHED INTO THE WOODEN PARKING BARRIER THAT DELINEATES THE EDGE OF THE PARKING LOT, CRACKING IT. ENGINE WAS REVVING. I SHIFTED INTO REVERSE TO GET BACK INTO PARKING SPOT (FOOT ON BRAKE NECESSARY TO SHIFT INTO REVERSE) AND CAR ACCELERATED BACKWARD TOTALLY OUT OF MY CONTROL, ONLY STOPPED AFTER BACKING INTO CAR PARKED ON OPPOSITE SIDE. PASSERBY SAID HE HEARD THE ENGINE REVVING FROM THE OTHER SIDE OF THE LOT! AT THIS POINT I SHIFTED INTO "DRIVE" AND, WITH CAR NOW UNDER MY CONTROL, RETURNED TO ORIGINAL SPOT. I REFUSED TO DRIVE CAR AGAIN WHEN POLICE ASKED ME TO SHOW WHAT HAD HAPPENED- HAD IT TOWED, VOLVO USA TECHNICIAN REPORTEDLY FOUND NOTHING WRONG WITH THE CAR, ( THE REPORT IS AN INTERNAL VOLVO DOCUMENT NOT AVAILABLE TO ME). THIS WAS A FRIGHTENING, HORRIFYING INCIDENT, WITH RAPID ACCELERATION OCCURRING BOTH FORWARD AND IN REVERSE, DESPITE FOOT ON BRAKE. CAR IS EQUIPPED WITH MULTIPLE SAFETY FEATURES. PEOPLE COULD HAVE BEEN HURT- LUCKILY NO ONE WAS. OVER NEXT COUPLE OF WEEKS, I WENT OVER EVERY POSSIBILITY, BUT MUST CONCLUDE IT WAS A MALFUNCTION OF THE CAR. *TR

Reported

Apr 2012

Incident date

Feb 2012

Mileage

Not provided

Outcome flags

Crash

BLIND SPOT INFORMATION SYSTEM DOES NOT FUNCTION DURING INCLEMENT WEATHER. SYSTEM PROVIDES INCORRECT INFORMATION TO THE DRIVER ABOUT THE PRESENCE OF ANOTHER VEHICLE IN THE BLIND SPOT. I BELIEVE THIS INCREASES THE RISK OF ACCIDENT. *TR

Reported

Mar 2012

Incident date

Mar 2012

Mileage

Not provided

Outcome flags

None reported

VOLVO IS RECALLING CERTAIN MODEL YEAR 2012 S60, XC60, S80 AND XC70 VEHICLES MANUFACTURED FROM MAY 16, 2011, THROUGH OCTOBER 6, 2011. IN THESE VEHICLES, THE WIRE HARNESS UNDER THE FRONT SEATS MAY HAVE NOT BEEN ATTACHED PROPERLY TO THE SEAT FRAME. AS A RESULT, WHEN THE SEATS ARE MOVED TO ADJUST THE SEATING POSITION, THE WIRE HARNESS MAY GET PULLED, CAUSING IT TO DISCONNECT.

Risk: IN THE EVENT OF CRASH, THE FRONT AND/OR SIDE IMPACT AIR BAGS MAY DEPLOY IMPROPERLY OR NOT AT ALL, INCREASING THE RISK OF INJURY. ALSO, THE LAP BELT PRETENSIONER MAY NOT DEPLOY.

Remedy: VOLVO WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND, IF NECESSARY, SECURE THE SEAT WIRE HARNESS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 12, 2012. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.

VOLVO IS RECALLING CERTAIN MODEL YEAR 2012 S60 AND XC60 PASSENGER VEHICLES. AN INCORRECT MIXTURE OF UNDERBODY COATING AND OVER-APPLICATION CAN RESULT IN RIGID, ICICLE-LIKE AREAS HANGING FROM VEHICLE’S UNDERCARRIAGE.

Risk: IF THIS CONDITION EXISTS, THE UNDERBODY COATING MAY PENETRATE THE FUELS LINES AND CAUSE FUEL LEAKAGE, INCREASING THE RISK OF A FIRE.

Remedy: DEALERS WILL INSPECT THE VEHICLE UNDERCARRIAGE, AND IF EXCESSIVE UNDERBODY COATING IS FOUND IN THE FUEL LINE AREA, IT WILL BE REMOVED. IF THE INSPECTION REVEALS THAT THE FUEL LINES ARE DAMAGED, THEY WILL BE REPLACED. THE SAFETY RECALL BEGAN ON APRIL 25, 2012. OWNERS MAY CONTACT VOLVO CUSTOMER CARE CENTER AT 1-800-458-1552.

Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating positions may fatigue over time, causing the seat belt to not secure the occupant in the event of a crash.

Risk: An unsecured occupant has an increased risk of injury in the event of a crash.

Remedy: Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R10029.