2019 Toyota RAV4

The contact owns a 2019 Toyota Rav4. The contact stated that while driving at an undisclosed speed, an orange steering symbol appeared on the instrument panel accompanied by the message: "Power Steering Malfunction, Steering Power Low, Visit Your Dealer." An initial inspection by an independent mechanic indicated that the electrical power steering and the rack and pinion assembly needed to be replaced. Subsequently, the vehicle was taken to a dealer, where diagnostic testing confirmed a defective power steering system. Following a software update performed by the dealer, the warning symbol transitioned to red, accompanied by an audible alarm and a significant increase in the physical force required to steer the vehicle. Restarting the vehicle temporarily reverted the warning light to orange and restored steering functionality. Upon investigation, the contact discovered NHTSA Campaign Number: 20V373000 (Steering); however, the VIN was not included in the recall. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was 105,857.

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Rav4 2019 - We lost engine power while driving on the highway at 75 mph. We were in the #2 lane and were fortunate to be able to coast to the side of the road. Quite scary as there were semi trucks behind us.We had been driving for approximately 3.5 hours on the highway at 70-75 MPH. The outside temperature registering on our vehicle began at 110 and continued to increase on up to 118 degrees at the time of the incident. When we lost engine power, the following errors began flashing on the dashboard: PKSB Malfunction, Pre Collision System Malfunction, Secondary Collision Brake System Malfunction. We cleaned the sensors, turned the car off for 5 minutes and then turned it back on. Same warnings appeared. Got towed to the Toyota dealership. Next day all malfunction warnings gone. Car was behaving normally. Toyota service team was unable to reproduce the problem. They inspected the electrical, battery, sensors, etc. but could not find anything. Ultimately the service lead stated that the intense heat could have caused sensor malfunction. Scary!! We fortunate!

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

transmission went out at 109,217 k miles had to pay for it out of pocket Toyota doesn't recommend transmission fluid replacement until 120k miles

Reported

Jul 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Door locks failed to lock or unlock via the key fob, intermittent problem

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

I am having issues with my 2019 RAV 4 rear hatch. The struts/hinges issue is not allowing my rear hatch to open. I feel like one issue caused the other, but warranty will only cover the struts. There is a potential class action lawsuit right now over this issue. Toyota will not do anything about it.

Reported

Jun 2026

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

The infotainment system of my 2019 RAV4 hybrid will randomly turn off while driving. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Was in a front driver side T-bone @ 35 miles and hour accident and no Airbags deployed

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

1 injuries

The Coolant Bypass Valve on my vehicle failed, leading to a risk of sudden engine overheating and potential coolant leaks into the electrical harness. This is a documented defect (CSP 23TE03) that Toyota has failed to address for vehicles over 100,000 miles, creating a safety hazard for high-mileage owners. This is a major concern on a known issue and those that don't have funds to pay for this known failure. They need to do a recall for ALL!

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The 8-speed automatic on my 2019 RAV4 (2.5L 4 Cyl) has been shifting super rough at lower speeds, to the point to where downshifts can send the revs into redline territory, but the car really doesn't move. No warning lights, passed state inspection, recently serviced. purchaced this car in Janurary with 50k miles on it and noticed it within a few weeks of driving. I am now at 57k and the issue is signifigantly worse than it was before. Will be taking it to Toyota soon. The safety issues arise when I do not know how the car is going to accelerate or respond to throttle input in traffic. I don't trust the car to handle any fast throttle input if I need to move out of the way quickly.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The rear door (lift gate) hinges are failing and tearing away from the vehicle body, causing misalignment of the rear door, operational failure of the automated lift gate, and water leaking into the interior. This has occurred under normal use conditions. It appears that the hinge design is insufficient to handle the load and forces of normal operation of the door. The failure has been documented in pictures. The Toyota dealership where the vehicle was purchased stated that the vehicle is out of warranty and there is no recall for the hinges, therefore the owner is responsible for repair costs. Had the issue not been found and the hinges failed completely, it could have been extremely hazardous.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

My 2019 Toyota RAV4 Adventure suffered a sudden catastrophic transmission failure while driving on the highway on April 28, 2026, resulting in loss of forward gears and a dangerous situation. On April 28, 2026, while traveling in [XXX] , my 2019 Toyota RAV4 Adventure (159,173 miles) experienced a sudden transmission failure with no prior warning symptoms. The vehicle began slipping, made a whining noise, would not properly upshift or hold speed (became stuck in 3rd gear), and eventually lost all forward propulsion, creating a safety hazard on the road. I had the vehicle towed to Zanesville Toyota in [XXX] . Their diagnosis (copy of repair order attached) revealed severe internal damage including: Torque converter clutch actuator stuck off Multiple pressure control solenoids stuck Transmission slipping and complete loss of all forward gears Fluid full but contaminated with metal debris and clutch material Whining noise The dealer quoted approximately $15,000 for a full transmission + torque converter replacement and denied goodwill assistance. This appears to be part of a known issue with the 8-speed automatic transmission (UB80) in 2019+ Toyota RAV4 models. I am concerned this is a safety defect that can cause sudden loss of power while driving, increasing the risk of a crash. I have attached the Zanesville Toyota repair order dated 04/30/2026 documenting the failure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

I am reporting a serious concern and safety issue regarding the SlimFit3 LX car seat. We purchased it for a [XXX] old [XXX] male. After adjusting the head rest to the proper height so that the harness straps were slightly below his shoulder, we placed him in the seat and his head was unnaturally pushed forward and down so that his chin was pushed into his chest. This was caused by the headrest sitting too far forward of the back padding so there was no way for him to keep his head in natural alignment with his back. The contributing factor is the minimal back padding and its inset into the car seat. There should be more padding to move the back forward or the headrest should be retracted into the seat more. We immediately returned the two car seats we purchased because of this and went with a different manufacturer. Not only is this an ergonomic/comfort issue, but it could introduce airway obstructing breathing issues if the child fell asleep. It is an extremely unnatural position. Also, I would be concerned about long term damage to a child's posture after repeated use. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The rear hatch hinges are undersized causing them to fail and undue stress on the motor.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

A coolant leak from the flow shut‑off valve caused the engine maintenance warning light to remain on for an extended period. This issue is covered under Toyota Customer Support Program 24TE04. The warning light is a safety concern because it indicates an active engine‑related malfunction and can mask other warnings. The defect was first diagnosed by a Toyota dealership at approximately 97,000 miles, well within the CSP coverage window. The dealership stated the vehicle “did not meet criteria” and refused to perform the repair, even though the symptoms matched those described in the CSP. The issue continued until a second Toyota dealership later confirmed the same defect and replaced the coolant bypass valve. Because the vehicle had since exceeded 100,000 miles, Toyota refused to cover the repair under the CSP, despite the defect being documented earlier within the coverage period. Multiple attempts to resolve the issue with Toyota corporate have resulted in no returned calls or meaningful response. The defect caused prolonged operation with an illuminated engine warning light, which presents a safety risk and indicates a failure to properly address a known issue covered under Toyota’s Customer Support Program

Reported

May 2026

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

Braking while pulling into a parking space. Instead of slowing down the car accelerated and went over the curb. Maintained pressure on the break but it did not slow the car. Instead the car kept accelerating down an embankment, across an empty street and towards a telephone pole. Turning the steering wheel to the left to avoid the telephone pole the car further descended into a ditch. The car had to be towed and is now deemed to be totaled. The brake- pads had been inspected during a routine maintenance check the day before this accident occurred and they were good. No other vehicle was involved. My personal injury was an abrasion and bruise where my seat belt did it's job. My muscles are sore. The side airbags did deploy after the car stopped. The floor mats were locked in place.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

Crash 1 injuries

Safety Defect: Data Communication Module (DCM) Failure Affecting Hands-Free Microphone and Safety Connect / SOS Emergency System Vehicle: 2019 Toyota RAV4 Hybrid LE The DCM (which controls both the CarPlay/Bluetooth hands-free microphone and the Safety Connect SOS emergency button) suddenly failed without any warning or accident. Symptoms: - No one can hear me during CarPlay or Bluetooth calls (microphone inoperative). - Safety Connect / SOS light became intermittent or inoperative (directly impacts emergency calling, crash notification, and roadside assistance). This is a known recurring issue documented in Toyota TSBs T-SB-0112-20 and T-SB-0089-21. Toyota of Hackensack diagnosed it and quoted $1,300 for DCM replacement/update while charging me $200 for diagnosis. They did not disclose during the multipoint inspection that this is a documented safety-related DCM fault. I performed the manufacturer-recommended 12V battery disconnect reset (standard TSB procedure), which fully restored the microphone and returned the SOS light to solid green. However, this is only a temporary fix for a known defect. This failure compromises hands-free calling while driving and the emergency SOS system — both critical safety features. I request NHTSA investigation and urge Toyota to issue a recall or service campaign for all affected 2019–2025 RAV4 Hybrids.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Tailgate problem since Purchase. Tailgate won't close. Gets stuck open. Dangerous. Known issue. Fixed 3 times at Toyota dealer. Faulty hinge and other real parts problems. Dealer says there is a class action lawsuit about the problem. 1st occurred only during Winters starting 2022. Gas door broken 2023. Water leaking into passenger front door 2022. Also door actuator . Have had to replace front 2, now rear broken. Can report separately.

Reported

Apr 2026

Incident date

Dec 2022

Mileage

Not provided

Outcome flags

None reported

While driving, the moonroof on my 2019 Toyota RAV4 XLE AWD suddenly exploded with a loud bang and the glass blew outward. There was no impact, debris, or external cause. The sound was similar to a gunshot. The remaining glass appeared to be pushed upward/outward, not inward. This created a safety hazard due to potential driver distraction and risk of injury from falling glass. This appears consistent with other reported incidents involving spontaneous sunroof shattering. No warning light. Moonroof was shut.Sunny day about 40 degrees outside. Traveling at 68 mph. Dog in crate in back

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

At 92,000 miles my transmission went out and Toyota told me I need a brand new one. It goes in for routine services. It’s available for inspection. For the last few years I addressed the issues of jerky shift motion and it was blown off every time. It is only 7 years old. It stalled out in a busy intersection and wouldn’t move forward or backwards. There were no warning lamps before it went out.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2019 Toyota Rav4. The contact stated that while driving at an undisclosed speed, the message "Engine Maintenance Required - Visit the Dealer" was displayed on the screen. The vehicle was taken to a local dealer, where it was diagnosed, and determined that the coolant flow control valve needed to be replaced. The vehicle was repaired out-of-pocket. Upon further investigation, the contact related the failure to Customer Support Program: 24TE04. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 116,000.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

I have a 2019 Toyota Rav4 and my liftgate hinges are breaking . The welds are breaking and its causing my truck to no close all the way. Also is truck itself had misaligning itself to the driver side and its also breaking my tail light from the truck hitting it. This is a known problem with this model of car. Toyota has refuse to fix this problem. Leaving people to pay for this repair out of their pocket. The price i have quote for is $2,288.27 that's alot of money. This problem needs to be fix without us coming out of our pocket to fix something that Toyota has known about for some time now. I have been back and forward with my local deal ship snice 3/20/2026. Today i s 3/24/2026 and nothing has changed. I have called Toyota corporate to see if i can some help with is repair. All they keep saying is my car" doesn't meet the reequipments. There should be a recall cause this isnt one two RAV4s its hundreds maybe even tens of thousands.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

I have noticed visible rust forming on the roof, specifically the front drivers side adjacent to the inside edge of the roof rail that runs forward to aft on the vehicle. The same stated rust spot is near where the roof meets the windshield. It is available for inspection upon request. My 2019 Toyota Rav4 along with several other 5th generation Rav4 owners online are experiencing rust in the same exact spot. This rust may be a result of the Toyota Customer Service Program (CSP) #22TE05 and T-SB-0016-23 that came of a result of the Fishkind v. Toyota Motor Sales, USA et al. No. Case 2:23-cv-02279 Class Action Lawsuit. This rust may have been formed by the leaking roof rail gaskets that have a slow enough leak rate to penetrate the roof rail clip holes and create moisture and rust over an extended period of time but not high enough of a leak rate to cause excess leakage into the vehicle that would immediately alarm the driver to have the vehicle taken into the dealership for immediate repair before the corrosion and rust can have a chance to spread. After several conversations with Toyota Corporate and my Toyota dealership they have denied me CSP inspection and any coverage or good will assistance through the CSP# 22TE05 & T-SB-0016-23 despite evidence of water residue buildup on the headliner visible through a UV blacklight. Even if the rust is not caused from the roof rail gasket leakage, there are still multiple other instances online of other 5th gen rav4 owners experiencing roof rust in the same exact spot adjacent to the drivers side roof rail near the windshield, which points to a manufacturing defect. My safety will be put at risk when the corrosion worsens and leaks through into the electrical components of the vehicle. My dealership witnessed the rust but denied performing an inspection of the roof rail clips since there is currently visible rust, likely due to the roof rail clips leakage. No manufacturer inspection. No noticeable warning symptoms.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

A recall was issued for a roof leak defect that allowed water intrusion into my vehicle. The recall repair was performed at Autonation Toyota of Weston dealership, where the roof was replaced due to water staining. However, water intrusion which led to black mold growth into the interior carpeting and floor board remained after the repair. The dealership stated that the remaining water intrusion affecting the carpeting was caused by another source. Documentation showing that the recall repair procedure was completed according to the manufacturer’s requirements was requested but has not been provided. The defect involving water entering the vehicle interior remains unresolved. I was last told by the General Manager that my requests and concerns were forwarded to legal, but I have not heard back from October of 2025.

Reported

Mar 2026

Incident date

Jun 2023

Mileage

Not provided

Outcome flags

None reported

The rear liftgate began malfunctioning and would intermittently fail to open or close properly. The issue had previously been reported to a Toyota dealership, but the problem could not be reproduced at the time. I noticed recently that the liftgate was not fully closing on the passenger side. While inspecting the liftgate more closely, I discovered that the passenger side liftgate hinge is cracked and the metal at the hinge base is separating. The crack appears to run through the hinge bracket where it attaches to the body. The driver side hinge also shows signs of stress. Because the hinge is cracked and separating, there is concern that the liftgate could eventually detach or fall unexpectedly. The liftgate is heavy, and a hinge failure could allow it to drop suddenly, posing a risk of injury to someone standing near or underneath it. If both hinges fail at the same time, the liftgate could become detached from the vehicle while driving resulting in an accident and potential injury to myself, my family, and others that are hit by or hit the liftgate. The dealership suggested the damage may have occurred from forcing the liftgate closed when the liftgate struts failed to function. However, the cracking appears consistent with progressive metal fatigue rather than a single impact event. This appears to be a structural hinge failure that could affect the safe operation of the liftgate. The dealership has documented my concerns on numerous occasions and today they visually saw the hinges in their current shape.

Reported

Mar 2026

Incident date

Jan 2002

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2019 Toyota Rav4. The contact stated that while seated in the vehicle, while the vehicle was parked, there was an abnormally strong plastic burning odor inside the vehicle. The contact stated that a top light was plugged in the trunk, but the light was turned off. After opening the trunk, the contact became aware that the wiring in the trunk had overheated and burned the laundry that was inside the vehicle and the rear passenger's side seat. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 129,000.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

On February 2, 2026, while driving approximately 65 mph on the freeway in Wisconsin, the panoramic sunroof glass on my 2019 Toyota RAV4 XLE Premium (VIN: [XXX] ) spontaneously exploded. The ambient temperature was approximately 20°F. Crucially, the glass buckled outward, indicating the failure was caused by internal pressure or a structural defect, rather than an external impact (such as a rock). There were no other vehicles immediately ahead of me that could have kicked up debris. Safety Risk: The explosion created a loud, gunshot-like noise that caused severe driver distraction at highway speeds. While no crash occurred and no injuries were sustained this time, the sudden structural failure posed a significant risk of loss of vehicle control. Status: No warning lights or messages appeared prior to the failure. The vehicle had no prior damage to the roof area. Photos of outward buckling available upon request INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The hinge has broken from the body, causing the liftgate to fail to close the back trunk area of the vehicle. The defective hinge has caused misalignment of the door and an unsecure compartment which is a violation of NC State Law according to NC GS 20-116. This puts the passenger's and driver of the vehicle and other surrounding vehicles at risk by failing to stay aligned or seal properly. I fear that glass may crack due to the currently misalignment. I have sought out further information from a Vehicle Repair Center, who confirmed there is a current Lawsuit on the Case No.: 5:24-cv-00912ZACH HUGHES, individually and on behalf of all others similarly situated, Plaintiffs, v. TOYOTA MOTOR SALES, U.S.A., INC., TOYOTA MOTOR CORPORATION, and TOYOTA MOTOR.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

I was driving down a road and my engine just stopped working lights came on saying there were several issues including the engine. I researched online and found there were recalls due to this same problem for the same make, model and year as my Vehicle, but there is no recall on my vehicle. The dealer confirmed the engine was seized up or whatever wording they used. No one has inspected it other than Rodland Toyota. There were no warning lights or messages or symptoms before the issue.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The rear trunk door would occasionally fail to open or shut for the last several years. It was inconsistent with this behavior and I was never able to get it to fail when at the dealership servicing department. This weekend when at the store, it failed shutting and I had to force it to shut. While driving home it rattled itself open. I had to pull over to inspect it and could not get it to close. When I looked closer, the hinge of the door had been ripped from the body on the passenger side of the vehicle. I have never been in an accident nor have I ever had any impact on this door.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

Infotainment Center turns on and off, and will not work. Because the screen turns on and off, the camera for back up intermittently works. May 2025 i took it to Karl Malone Toyota in Sandy Utah. They said to buy a 3rd party, after investigation I confirmed that no display has the options to reset maintenance, change clock on the dashboard, and communicate with the car. Yes radio, navigation, carplay, etc work with a 3rd party system, but the functions that talk with the car do not work on any 3rd party system.

Reported

Jan 2026

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2019 Toyota RAV4. The contact stated that the headlights failed to produce adequate lighting at night. While driving at 30 MPH in the dark with the headlights on, making a turn into her subdivision, she crashed into the stop sign, pedestrian crossing sign, and a street sign. There were no reported injuries, fire, or airbag deployment. A police report was filed. The local dealer was contacted, who informed her that the headlights were working as designed. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was approximately 15,000. The VIN was not available.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

Crash

My 2019 Toyota RAV4 8 speed transmission has died. There are 105,000 miles on it. I’ve read that my year and model of car have deficient transmissions and multiple class action lawsuits on this issue.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Vehicle consistently accepts only approximately 9–10 gallons of fuel when the fuel gauge indicates empty, resulting in significantly reduced driving range. Issue has been widely reported by other Toyota RAV4 Hybrid owners and appears related to fuel tank design. Manufacturer declined assistance and referred responsibility to selling dealer despite known complaints.

Reported

Jan 2026

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

I began experiencing intermittent rear liftgate sensor issues on my 2019 Toyota RAV4 in late 2020. The power hatch would stop halfway while opening. On 3/24/2021, while the vehicle was under factory warranty, I brought it to a Toyota dealer for inspection. The dealer stated the issue could not be replicated and advised me to manually push the hatch upward. No repair was made. Over time, the condition worsened. The liftgate began intermittently stopping halfway while closing, using both the key fob and the interior dash button. In 2022, a rattling noise developed in the rear of the vehicle, later determined to be associated with progressive liftgate structural failure. By 2024, the rear liftgate became unsafe and largely inoperable. The hatch shifted significantly to the left, leaving an abnormally large gap at the top and driver’s side. I stopped using the liftgate due to concern it could fail unexpectedly or not close properly. I contacted Toyota Engagement Services multiple times, explaining that this issue is widely reported among 2019 RAV4 owners and presents a safety concern. On 11/18/2025, the vehicle was inspected at Crabtree Toyota. The inspection confirmed rear liftgate hinge failure. The dealer provided video documentation and a written repair estimate. The health inspection also noted a separated and broken passenger-side rear hatch pulse sensor requiring replacement. Toyota closed my case without repairing the defect. Toyota offered a “good faith” credit of approximately 75% of the repair cost that cannot be applied to the liftgate structural or sensor repair and is only usable for unrelated future service. This appears to be a known, progressive defect involving rear liftgate hinges and related sensors on 2019 Toyota RAV4 vehicles. The condition presents a safety risk, as the liftgate may fail to stay open, close unexpectedly, or malfunction electronically. My VIN has been provided. Photos, video, and repair documentation are available upon requ

Reported

Jan 2026

Incident date

Dec 2020

Mileage

Not provided

Outcome flags

None reported

This is another complaint with the same issue. Got gas on January 1, 2026, the truck did not how any indication that it was going to have any problems. Engine shut down and wouldn’t turn back on. This has happened twice after getting gas, no dealership knows the problem. This is casing me stress and putting myself and family in danger. Considering it stops out of no where

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Toyota RAV4 LE gas pump burst and caught fire leading to total fire damage along with major water damage from the firefighters putting out the fire. The vehicle was idle for hours at the time of explosion of the fuel pump. This was a major safety hazard/risk especially being that myself and two others were minutes away from going out to the vehicle before it all happened as I was getting ready to take a friend home for the night. A claim representative will look into this matter in coming days.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

Fire

my 2019 Toyota 8 speed transmission jerking in stop and go traffic

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2019 Toyota Rav4. The contact stated while driving 70 MPH, the vehicle experienced a loss of motive power. No warning light was illuminated. The contact managed to push the vehicle over to the shoulder of the road, and the vehicle was towed to the residence. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000.

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Safety issue: The vehicle experiences intermittent loss of acceleration and transmission “slip/rev” events, especially when cold, from a stop, or at low speed. At times, the vehicle revs as if in neutral, then re-engages. The driver sometimes must press the accelerator fully to gain speed. In one instance, the vehicle was driven slowly for several miles, pulled over, shut off, restarted, and the function temporarily improved. When it started: Symptoms began immediately after a routine service visit at a Toyota dealership ([XXX]). First noted deceleration going uphill with recovery. Next day, multiple warning indicators/messages appeared and vehicle was towed to the same dealership. Dealer response: Dealership advised transmission replacement based on diagnostic codes and quoted approximately $10,000, stating fluid check was not necessary. Second opinion: Independent shop found transmission fluid level extremely low (reported approx. 1/4 full). They refilled fluid; initially vehicle drove normally, but intermittent slipping/revving continued after pickup (worse when cold/low speed). No external leaks observed by second shop at that time. Current status: Vehicle continues to show intermittent loss of acceleration/slipping behavior, creating a safety risk in traffic. No current check engine light, but symptoms persist. Codes/records available: Codes: P07457F, P28167F, P088A7F, P27137F, C137BA2, C1241, C1280, U1117, B2227. Location: New York. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

While traveling back from out of state, the fuel sensor and fuel gauge failed causing me to run out of gas when the fuel gauge stated I had just a tick under a 1/4 tank of gas left and the app read 35 miles left. While driving on freeway at freeway speed, the car sputtered, bogged down and then stalled, placing me in a very dangerous situation broken down on the shoulder of the freeway in the desolate country at night with semi trucks and cars flying by at estimated between 70-80 mph. While stalled and waiting for help, all the lights except the hazard flashers went out. The Sheriff assisted and added 2 gallons of gas that finally got the car restarted and I was able to get to the gas station which was 1 mile ahead of where I had been stranded. I kept filling the gas tank not allowing it to go under 1/2 tank on the fuel gauge the remainder of the trip home. I took the car to Tansky Sawmill Toyota for service, who thought it was a fuel sensor in fuel tank, which had to be dropped, resulting in a tube from the fuel sender being disconnected and not taking fuel from the other side of the tank and corrosion was cleaned out. They had to go through electrical system to check the fuel gauge which had corrosion on the electrical harnesses and sensors not caused by water or rodents - still unknown cause - resulting in $6500.00 to replace both electrical harnesses 82152-0R370 wire FR Door LH and 82141-oRB80 wire Instrument Panel! Known Toyota defect as the 2019 Rav4 Hybrids have already been recalled. Issues of this type with the regular Rav4s are posted all over the online Toyota boards. My platinum extended warranty on my well cared for 2019 RAV4 with 45,131 miles (purchased at 3 year lease end) refused to all of the charges and the dealership did not budge, sticking me with 6 hours of diagnostic fees over what the warranty allowed in the sum of $1014.37. These harnesses need recalled so no one else is stranded in a very dangerous place on the side of the freeway!

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2019 Toyota Rav4. The contact stated that while her daughter was driving at an undisclosed speed, the vehicle stalled. The contact was unsure if the vehicle could be coasted to the side of the road. Several unknown warning lights were illuminated. The vehicle was towed to a collision center. The vehicle was then towed to the dealer, where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 116,248.

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

I am reporting a concern regarding the driver’s seat design in my Toyota RAV4. While driving this vehicle, I experience consistent back pain that can begin within approximately 15 minutes of driving and often persists for about two hours after driving has ended. The pain includes sharp discomfort in my mid-to-upper back and occurs despite adjusting the seat position and using aftermarket lumbar and seat supports. I do not experience similar pain when driving other vehicles for comparable durations, including a Toyota Highlander, Toyota Camry, Subaru Impreza, Ford Focus, Rivian truck, or a pickup truck. This strongly suggests the issue is related to the RAV4’s seat ergonomics rather than a preexisting condition. Because of this issue, I have begun avoiding driving my own vehicle when possible. I am submitting this report to document a potential seat design issue that may affect driver comfort and safety.

Reported

Dec 2025

Incident date

Jun 2022

Mileage

Not provided

Outcome flags

None reported

Steering wheel is making a buzzing noise when you turn the wheel towards the left or right while you’re driving. It will make the noise in park doing the same back and forth. I’m afraid that my power steering will go out while driving.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Jerks during acceleration. Lurching sensation when acceleration from a stop or after slowing down for a turn. The engine control module (ECM) not communicating effectively with the transmission, leading to searching for gears, rough shifting and low speed hesitation.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Strong gas smell when the engine is turned on. I started feel this issue about 2 year ago, now the gas smell is more stronger every time engine is turned on.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Complaint Summary: Seatbelt failure on 2019 Toyota RAV4. Complaint Description: I own a 2019 Toyota RAV4, and the driver-side seatbelt has begun failing. The retractor and locking mechanism are not working reliably. Sometimes the belt won’t retract, sometimes it locks up randomly, and other times it doesn’t lock at all. This is a major safety hazard. I’ve owned many vehicles over my lifetime—older cars, newer cars, even vehicles over 50 years old—and I’ve never had a seatbelt go bad. This is the first time I’ve experienced a critical safety component failing like this. Toyota has issued seatbelt-related recalls on other RAV4 model years, but not on the 2019, even though the symptoms match what others have reported. This failure puts me at risk in the event of a crash, and it needs to be investigated. I am reporting this because I believe this is a safety defect, not normal wear, and it may affect more 2019 RAV4s than just mine.

Reported

Dec 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2019 Toyota Rav4. The contact stated that the rear hatch door failed to remain securely closed. The contact stated that the failure intermittently occurred and became more frequent over time. Additionally, the front driver’s side seat belt buckle and rear passenger’s side seat belt buckle failed to buckle and lock securely. They also stated that the front driver's side electronic reclining seat made grinding sounds while operating. The contact also stated that water was leaking into the vehicle from the rear passenger’s side quarter panel. The cause of the failures was not yet determined. The manufacturer and local dealer were notified of the failures, but no assistance was provided. The failure mileage was 32,000.

Reported

Dec 2025

Incident date

Dec 2024

Mileage

Not provided

Outcome flags

None reported

My 2019 Toyota RAV4 experienced a dangerous electrical and transmission failure that ultimately caused the vehicle to stall while driving and made me lose control. For several weeks before the incident, the vehicle showed subtle hesitation when accelerating but no warning lights. After the car stalled and spun out coming off the Ben Franklin Bridge onto I-76 near downtown Camden, police responded, confirmed the vehicle had unexpectedly shut off, and verified there was no crash damage. I later brought the car to the Toyota dealership, where they discovered corrosion on the battery cable, failed ABS sensors, and a weak battery. I paid $668 for a new battery, new cable, and ABS sensor repairs. At that time, the dealership did not inform me of any transmission issues and released the vehicle back to me. I made it only a short distance up the road before realizing the vehicle could not accelerate past 40 mph and was still malfunctioning, so I immediately returned it. The next day, the dealership initially claimed there was nothing wrong with the vehicle, but after I insisted they re-evaluate the car, they then informed me that the transmission was failing and needed replacement. This sequence of electrical instability, combined with the transmission malfunction, ultimately led to the earlier stall where I lost all power steering and braking assist and spun out into the median. The vehicle, diagnostic records, and replaced components are available for inspection. The sudden loss of power and control created a major safety risk to me and other drivers in a high-traffic area.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Rear door liftgate hinges defective. They are too week combined with electric power struts. They are being pulled away from body of vehicle and become misshapen (bent, deformed,etc) and causes door/liftgate to be unbalanced and and stick out too far away from body. Now the door/liftgate can not close and be secured

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Was insinuating engine was over heating even in -4° weather has no hot air plenty of coolant. This is causing the vehicle to "buck" amd having to have to pull over and waiting several minutes to let the engine "cool off" I can make it about 3 miles in-between pull overs. After some research I feel like the issue falls under a current lawsuit against Toyota regarding the coolant valve based on reading other issues and what my rav is doing. It is a several thousand dollar fix through a dealership and one my family can not afford especially if it is a poorly manufactured part of the car. It is one of two vehicles we have and need to daily living especially having a child and no means yo offered another safe vehicle at this time. The coolant pump itself

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020 Toyota Avalon Hybrid, Camry, Camry Hybrid and Lexus ES300h and 2019-2020 RAV4 and RAV4 Hybrid vehicles equipped with 2.5L 4-Cylinder engines. Porosity in the engine castings may result in cracks than can allow coolant to leak internally and/or externally.

Risk: A coolant leak can cause the engine to overheat and cause a vehicle stall in conventional gasoline vehicles, increasing the risk of a crash. Additionally, for all involved vehicles, the engine may get damaged mechanically, possibly resulting in an engine oil leak, increasing the risk of a fire.

Remedy: Toyota will notify owners, and dealers will inspect and replace the engine including the engine block, as necessary, free of charge. The recall began April 3, 2020. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus at 1-800-255-3987. Toyota's number for this recall is 20TA04. Lexus' number for this recall is 20LA02.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, 2019-2020 Tundra, 2018-2020 Lexus ES350, 2017 Lexus GS200t, 2017-2019 Lexus GS350, 2019 Lexus GS300, 2018-2020 Lexus LC500h, 2019-2020 Lexus LS500, 2018-2019 Lexus GX460, 2017 Lexus IS200t, 2019 Lexus IS300, 2019 Lexus IS350, 2018-2020 Lexus LC500, 2018 Lexus LS500, 2019 Lexus LS500h, 2018-2019 Lexus LX570, 2017 Lexus RC200t, 2019 Lexus RC300, RC350, 2017 and 2019-2020 Lexus RX350, 2018-2020 RX350L, 2019 Lexus UX200, 2018-2019 Lexus NX300 vehicles. The low-pressure fuel pump inside the fuel tank may fail.

Risk: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.

Remedy: Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019 RAV4 and RAV4 Hybrid vehicles. Due to a damaged electrical connector, the back-up camera may not activate when the vehicle is in reverse. As such, these vehicles fail to comply to Federal Motor Safety Standard (FMVSS) number 111, "Rearview Mirrors."

Risk: If the backup camera system does not activate and the driver does not check his/her surroundings while reversing, there is an increased risk of a crash.

Remedy: Toyota will notify owners, and dealers will inspect the back-up camera system and replace the audio display unit, if necessary, free of charge. The recall began September 27, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is K0N.

Gulf States Toyota (GST) is recalling certain 2019 C-HR, 4Runner, Avalon, Avalon Hybrid, Camry, Camry Hybrid, Highlander, Land Cruiser, Prius, RAV4, Sequoia, Tacoma, Sienna, Tundra and Yaris vehicles. The text on the load capacity label may become illegible. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."

Risk: If the driver cannot read the label, they may unknowingly overload the vehicle, increasing the risk of a crash.

Remedy: GST will notify owners, and dealers will provide corrected load carrying capacity modification labels, free of charge. The recall began May 24, 2019. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 19R1.

Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."

Risk: An incorrect label may lead to unintentionally overloading the vehicle, increasing the risk of a crash.

Remedy: SET will notify owners and provide a corrected label for placement over the inaccurate label, free of charge. The recall began August 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371. SET's number for this recall is SET19A.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and RAV4 Hybrid vehicles. The front lower suspension arms may have cracks, which may result in the suspension arm separating from the front wheel assembly.

Risk: If a suspension control arm breaks, it can result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Toyota will notify owners, and dealers will replace both front lower suspension arms, free of charge. This recall began August 10, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's interim numbers for this recall are 20TB08 / 20TA08.

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and 2020 RAV4 Hybrid vehicles equipped with electric power steering (EPS). Water may enter through the steering gear box cover and cause a loss of electric power steering assist.

Risk: A loss of power steering assist could increase steering effort at low vehicle speeds, increasing the risk of a crash.

Remedy: Toyota will notify owners, and dealers will replace the power steering gear box, free of charge. The recall began August 17, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is 20TB11 / 20TA11.