2019 Mini Cooper

The contact owns a 2019 Mini Cooper S. The contact stated that while driving at an undisclosed speed, the contact noticed that a rock had hit the driver's side of the windshield due to construction work on a local highway. The contact stated that the passenger's side of the windshield was also hit by a rock while driving. The contact stated that the driver's side of the windshield sustained a minor fracture; however, the passenger's side of the windshield was severely damaged. An unknown dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 81,485. The VIN was not available.

Reported

Aug 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

Loss of power steering on startup or at stop light. A message pops up indicating that the Dynamic Stability Control is re-initializing and that steering may become difficult: Drive carefully. The warning message usually appears shortly after the failure. In fact, the steering gets so stiff, that my wife can barely turn corners. The problem comes and goes unexpectedly. This is my wife's car, and it has happened to her on several other occasions. Sometimes we can reset by restarting the car, but that isn't reliable. We put the car out of ECO mode into Sport mode, so that the engine does not stop at stop lights, but the engine sometimes stops anyway. When it happened at a stop light today, we tried several restarts, but the steering remained out. Steering is worse at low speeds. Today, we stopped at a light. My wife was driving. The engine stopped and restarted, and the error message appeared. She had difficulty steering into a parking lot where I swapped places with her. I drove her home. It was difficult for me to steer around corners after today's lock up, but I drove the car to a local BMW-Mini mechanic with whom I had discussed the problem, but it never appeared at his shop. Today, we tried starting at the shop and the difficult steering persisted without an error message. He ran a quick scan indicating that some modules in the steering column were not operating properly. He said the modules were not available for replacement, and that the entire steering column might need to be replaced. Unfortunately, he was booked up until Friday. I drove home and let the car sit in the garage for a couple of hours. I started it while writing this to try to more accurately reproduce the warning messages. However, no messages appeared and the car steered easily. Clearly, sudden loss of power steering poses a danger for my family and others on the road. I've looked on the internet and discovered that others have experienced similar problems with steering in Mini Coopers.

Reported

May 2025

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

my vehicle only has 23000 how is it that vehicle with low miles and 5 yrs old and there telling me that engine mounts are cracked what mini cooper said was that the reason why is because there made out of plastic . how can this be legal what holds the engine in place made from plastic ? i think this need to be investigated and looked into is not safe and is not fair to the consumer to have to pay for this bad choice in design .

Reported

Apr 2024

Incident date

Apr 2024

Mileage

Not provided

Outcome flags

None reported

The contact's daughter owns a 2019 Mini Cooper S Clubman. The contact stated that while his daughter was driving at an undisclosed speed, she depressed the brake pedal, but the rear driver's side brake light failed to illuminate. The contact stated that he was driving behind his daughter when he noticed the failure. The vehicle was taken to an independent mechanic, and the rear driver's side brake light bulb was replaced; however, the failure persisted. The mechanic referred the contact to the dealer for assistance. Additionally, the contact stated that the vehicle failed to start. The vehicle was jumpstarted by AAA. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they could not assist unless NHTSA required that they do so. The failure mileage was unknown.

Reported

Feb 2024

Incident date

Feb 2024

Mileage

Not provided

Outcome flags

None reported

Car sent a message about vehicle stabilization initiation in the middle of the road. I could barely turn the steering wheel and change the lane. Authorized dealer service center tells me it’s a click and drive wiring malfunction issue. I was on the way to the airport via toll road and highway. Continue to drive with the stabilization in progress could caused me an accident for not being able to move the wheel smoothly.

Reported

Nov 2023

Incident date

Nov 2023

Mileage

Not provided

Outcome flags

None reported

*The condensate drain hose is not properly draining the condensate from the vehicle. *Breathing in mold and didn't know it *Yes the problem was confirmed by the dealer *The dealer inspected *no warnings, no recalls

Reported

Oct 2023

Incident date

Oct 2023

Mileage

Not provided

Outcome flags

None reported

I am writing regarding the failure of the steering column on my 2019 Mini Cooper Hardtop. The incident occurred on December 31, 2022. I drove my car to a residential location in Seattle, parked and locked the vehicle. When I returned to my car and started it up to move it, I realized I had no control of the car because the steering wheel was spinning uncontrollably. When the car was towed to Seattle Mini, the AAA tow truck driver and the dealership service department personnel receiving the car said they had seen nothing like this before. Seattle Mini takes the position that the steering column was forcibly broken due to an accident which is not the case. I’m very concerned about the safety of this vehicle and not comfortable with Seattle Mini’s theory as to the cause of the failure since no accident or “great force” event occurred as described in the service department video. If this had occurred while I was on-route to the location where the car was parked, the outcome could have been catastrophic. We would like to confer with you this coming week on the best course of action to address this situation. Thank You.

Reported

Jan 2023

Incident date

Dec 2022

Mileage

Not provided

Outcome flags

None reported

Foul odor coming from vents when starting up AC, and after turning off for 10 - 15 minutes.

Reported

Aug 2022

Incident date

May 2020

Mileage

Not provided

Outcome flags

None reported

Center console phone charger Center console is and enclosed component and when a cell phone is placed in the console and used for Bluetooth navigation and or phone calls it shuts down the system. The phone heats to such a temp that all phone operations and interaction with the vehicle system freeze or shut down and the phone continues to heat. I have spoken to the dealership and have been told it's a problem. When I communicated to MINI USA they acted as if this had never been reported. As far as warnings all car play functions slow down then freezes, and all functions stop. The phone had become so hot I was afraid it may cause a fire or explode the battery. This process usually takes an hour or so to happen.

Reported

Aug 2022

Incident date

Jun 2022

Mileage

Not provided

Outcome flags

None reported

Entire Driver Side Tail Lamp assembly stopped working (includes running light, brake light, reverse light, and blinker). Dash board did display warning (while driving) of lights malfunction, but nevertheless stopped working while driving. Upon further Inspection, found a “short” / melted pig tail (electrical connector) connecting to the rear of the lamp assembly. (Both the connector and pig tail showed signs of melted plastic/fire hazard). After further investigation, I realized this is not an isolated incident as I found multiple threads/posts on the Mini Cooper (F56) Internet forums, in which multiple owners complained of the same issue (many posting pictures as I have), which dates back many years, link to forum attached. https://www.minif56.com/threads/rear-left-lights-not-working.80537/

Reported

Feb 2022

Incident date

Feb 2022

Mileage

Not provided

Outcome flags

None reported

WHILE DRIVING ON ROAD DRIVER'S SIDE ROLL OVER BAR JUST POPPED UP. I'M CONCERNED THAT IF CAR WOULD HAVE ROLLED OVER PASSENGER WOULD HAVE BEEN CRASHED. ALREADY NOTIFIED MIN ICOOPER WAITING FOR A RESPONSE. CAR WILL BE SERVICE THIS WEEK.

Reported

Aug 2020

Incident date

Aug 2020

Mileage

Not provided

Outcome flags

None reported

175 MILES ON 2019 MINI S COUNTRYMAN. TRAVELING AT HIGHWAY SPEED. DRIVETRAIN MALFUNCTION INDICATOR CAME ON, CAR SHUDDERED REPEATEDLY AND DECELERATED RAPIDLY TO APPROX. 20 MPH IN 60 ZONE. CREATED INSTANT HAZARD TO MYSELF AS MULTIPLE LANES OF FASTER MOVING TRAFFIC NEEDED TO BE CROSSED TO REACH SAFETY AND NO WARNING TO TAILING VEHICLE.

Reported

Jan 2019

Incident date

Jan 2019

Mileage

Not provided

Outcome flags

None reported

THIS IS A BRAND MODEL AND BRAND NEW CAR THAT I HAD JUST PURCHASED AND WAS DRIVING HOME FROM BUYING IT- I HAD NOT EVEN OWNED FOR A COUPLE OF HOURS. WHILE ON MY WAY HOME VEHICLE MALFUNCTIONED AND HAD NEAR FATAL COLLISION. WHILE DRIVING ON HIGHWAY - AT HIGHWAY SPEED I WAS UNABLE TO CONTROL CAR AND MAINTAIN SPEED. ENGINE SEEMINGLY LOCKED UP AND AS I WAS UNABLE TO CONTROL CAR ALMOST CAUSED A NEAR FATAL COLLISION AS CAR BEHIND ME DID NOT REALIZE I WAS LOSING SPEED. TAKEN TO DEALERSHIP AND THEY NOTED THE CRANKSHAFT SPEED PULSE GENERATOR SENSOR HAD MALFUNCTIONED.

Reported

Aug 2018

Incident date

Jun 2018

Mileage

Not provided

Outcome flags

None reported

THIS IS SECOND INCIDENT THAT OCCURRED WITH BRAND NEW MINI COOPER 2019 WITH SAME EXACT ISSUE THAT AGAIN ALMOST CAUSED A NEAR FATAL ACCIDENT. WHILE DRIVING ON HIGHWAY, AT HIGHWAY SPEED THE CAR PRECIPITOUSLY MALFUNCTIONED AND CAR LOCKED UP AND WOULD ALLOW ME TO MAINTAIN SPEED- NOR ACCELERATE. I WAS UNABLE TO MAINTAIN SPEED OF THE CAR THEREFORE STARTED TO LOSE SPEED AND DECELERATE. THE VEHICLES BEHIND ME COULD NOT TELL THAT I WAS SUDDENLY LOSING SPEED AND I WAS ALMOST INVOLVING A NEAR FATAL COLLISION AGAIN. I HAD BEEN DRIVING ON THE HIGHWAY FOR ABOUT 5 -10 MINUTES PRIOR TO THIS PRECIPITOUSLY OCCURRING. THIS WAS THE SAME SITUATION I EXPERIENCED WITH A BRAND NEW MINI COOPER 2019 MODEL A WEEK EARLIER. THE CAR WAS TOWED TO THE DEALERSHIP AND THEY NOTED THAT THE CRANK SHAFT SPEED PULSE GENERATOR SENSOR WAS NO GOOD AND HAD MALFUNCTIONED. AS THIS IS A REPEAT ISSUE AND VERY SERIOUS AS IT ALMOST CAUSED 2 NEAR FATAL INCIDENTS, I AM CONCERNED THAT THE MAKER OF THE VEHICLE IS NOT DOING THEIR DUE DILIGENCE TO ENSURE THAT OTHER 2019 MODELS ARE SAFE. I HAVE BEEN TOLD OTHER MINI MODELS WERE HAS EXPERIENCED SAME MALFUNCTION. THIS INCIDENT AND THE OTHER BOTH OCCURRED AT HIGHWAY SPEED WHICH CREATES A VERY DANGEROUS SET UP AFTER THE VEHICLES HAD BEEN DRIVEN FOR A FEW MILES ON THE HIGHWAY AND IN WET CONDITIONS.

Reported

Aug 2018

Incident date

Jul 2018

Mileage

Not provided

Outcome flags

None reported

BMW of North America, LLC (BMW) is recalling certain 2018 BMW 540d xDrive vehicles. The crankshaft sensor may be equipped with incorrect firmware, preventing the sensor from properly processing input from the crankshaft reluctor ring, possibly resulting in a vehicle stall. On September 12, 2018, BMW expanded the recall to a total of 5,309 vehicles including certain 2018-2019 BMW 540d xDrive, 230i M240i, M240i xDrive, X2 sDrive28i, X2 xDrive28i, X1 sDrive28i, X1 xDrive28i, 330i, 330i xDrive, 340i, 340i xDrive, 330i xDrive Gran Turismo, 530i, 530i xDrive, 540i, 540i xDrive, 530e, 530e xDrive, 640i xDrive Gran Turismo, 330e, 2019 430i Gran Coupe, 430i xDrive Gran Coupe, 440i Gran Coupe, 440i xDrive Gran Coupe, 430i, 430i xDrive, 440i, 440i xDrive, 740i, 740i xDrive, MINI Cooper, Cooper S, JCW, MINI Countryman (Cooper, Cooper All4, Cooper S, Cooper S All4, JCW All4), and MINI Clubman (Cooper, Cooper S, Cooper All4, Cooper S All4, JCW All4) vehicles.

Risk: A vehicle stall can increase the risk of a crash.

Remedy: BMW will notify owners, and dealers will replace the crankshaft sensor, free of charge. The recall began September 6, 2018. Owners may contact BMW customer service at 1-800-525-7417.

BMW of North America, LLC (BMW) is recalling certain 2018-2019 BMW X1 sDrive28i, X1 xDrive28i, 2019 X2 xDrive28i, MINI Cooper S Convertible, Countryman, and John Cooper Works Countryman vehicles. The steering gear tie rod may have been assembled incorrectly, which may result in excessive wear of the tie rod end, eventually causing it to break.

Risk: A broken steering tie rod would lead to a loss of vehicle control, increasing the risk of a crash.

Remedy: BMW will notify owners, and dealers will inspect the vehicles and replace the tie rods and ball joints as necessary, free of charge. The recall began October 11, 2019. Owners may contact BMW customer service at 1-800-525-7417 or MINI customer service at 1-866-825-1525.