2019 Kia Niro

My car is a 2019 KIA Niro Hybrid. It's only 7 years old, and my husband and I have been the only owners. It only has 61,000 miles on it, and it is serviced regularly and has to pass a state emissions test each year. As I was driving the other day, the dashboard lit up with critical alerts saying "check regenerative battery" and the braking system went completely soft; I could not stop the car using the brakes. It was terrifying. I had to pull off the road and use the emergency brake to stop the car. This was an awful incident that could have resulted in deaths or serious injuries. Again this is for a car that is well-maintained and well under 100,000 miles.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Our 2019 Kia Niro EV (approximately 138,000 miles) exhibits an abnormal rumble/growling noise from the front drive unit while driving slowly in "D" range and when accelerating or decelerating between 0–25 mph. This symptom matches exactly the condition described in Kia Technical Service Bulletin ELE234 (Rev. 1, April 2021): "Drive Unit Inspection & Replacement for EV Motor Rumble Noise," which covers all 2019MY Niro EV vehicles produced from December 5, 2018. To our knowledge, TSB ELE234 has never been performed on this vehicle. The repair involves replacement of motor/roll mount brackets and, if necessary, traction motor or reduction gear replacement. Kia has a documented, tiered repair procedure for this exact issue with assigned labor operation codes. The failure presents a safety concern because drivetrain noise at low speed can precede loss of drive power or sudden drivetrain failure, which creates a hazard in traffic, intersections, and during highway merging. Despite the existence of this TSB since April 2021, NHTSA appears to have few or no formal complaints logged for this specific defect, meaning it has not triggered the regulatory scrutiny it warrants given the documented widespread nature of the issue. I am requesting that NHTSA investigate whether a formal recall of affected 2019 Kia Niro EV vehicles is warranted for this drivetrain defect.

Reported

Jun 2026

Incident date

Feb 2025

Mileage

Not provided

Outcome flags

None reported

This complaint supplements a previously submitted report filed today, June 18, 2026, (Original is Complaint Number: 11845044) regarding the same vehicle and condition (TSB ELE234 drive unit rumble noise). The correct VIN for this vehicle is [XXX] — a 2019 Kia Niro EV EX Premium, 138,457 miles. I am filing on behalf of the vehicle owner, [XXX], who has authorized me to act as his advocate. The owner is a Ukrainian speaker and I am assisting with all documentation and communications. In addition to TSB ELE234 (drive unit motor rumble, April 2021), this vehicle is also subject to Kia Service Action SA512 (April 2023): Inverter Coolant/Debris Flushing for the "Refill Inverter Coolant" cluster warning, affecting 2019–2022 Niro EVs produced May 10, 2019 through October 4, 2021. SA512 has also not been confirmed as completed on this VIN. CARFAX records document multiple authorized Kia dealer visits — at Roseville Kia and Folsom Lake Kia — between 2019 and 2022, during the period both ELE234 and SA512 were active and applicable. Neither service action was applied during those visits. This filing requests that NHTSA investigate both the safety implications of the ELE234 drivetrain defect and the broader pattern of authorized Kia dealers failing to notify owners of and apply active service bulletins during routine service visits on affected VINs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jun 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The Hydraulic Clutch Actuator has caused functional driving issues and caused my vehicle to go into limp mode. I was never informed of the recall issue prior to purchase, and the recall was marked as complete, when it was not. The fix for KIA NIRO Recall SC276 was incomplete in January 2024, and I purchased my vehicle in April 2024. My issues started in November 2025, and the incomplete recall issue has been ongoing. KIA offers only a 1/2-way fix, and this is simply not acceptable.

Reported

Jun 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

A major drivetrain service and repair was completed by an authorized manufacturer dealership. After picking up the vehicle, an unusual front-end/steering noise was immediately reported to the staff. Over just 390 miles of driving, the symptom worsened. A subsequent formal inspection by a separate, independent authorized service center confirmed the root cause of the safety failure: the primary axle nut had been left completely unstaked during the initial drivetrain assembly, rendering the vehicle entirely unsafe to operate. The vehicle was grounded to prevent an accident. Because the mandatory safety protocol of staking the axle nut was omitted, the critical fastening hardware was allowed to back off under normal driving conditions. This component failure directly compromised the structural integrity of the front drivetrain, steering knuckle, and wheel hub assembly. Had the vehicle continued to be driven, the omission presented an imminent risk of complete mechanical separation, which could cause a wheel assembly to detach or lock up while in motion at high speeds, putting the safety of the occupants and other motorists at extreme risk. The vehicle remains grounded and is available for inspection. The safety-critical assembly failure has been fully documented by the inspecting service center via technical video (available upon request) and photographic evidence. The manufacturer has been notified of the dealer workmanship defect but has failed to authorize corrective action or safe transport of the vehicle to a certified facility for remediation.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2019 Kia Niro. The contact stated that while driving at an undisclosed speed, the vehicle stalled in the middle of the road. The vehicle was successfully restarted and moved over to the side of the road. The vehicle was towed to an independent mechanic, where it was diagnosed with a blown head gasket, a misfire in the engine, and coolant mixing with the engine oil; however, the vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 118,000.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

While traveling from upstate New York, the vehicle displayed an engine overheating warning shortly after startup while the engine was still cold. Because I was away from home, I stayed overnight and the next morning took the vehicle to a Kia dealership for inspection. The dealership inspected the vehicle and diagnosed a problem with the exhaust heat recovery system pipe. According to the service department, coolant is leaking internally through this component and is being burned in the exhaust system. The cooling system was pressure tested and held pressure externally, indicating the coolant loss is occurring internally through the exhaust heat recovery system rather than from an external leak. This condition can cause coolant loss and overheating while driving. If the engine overheats while the vehicle is in operation, it could create a safety risk due to sudden loss of power or engine damage. The dealership confirmed the diagnosis after inspection and testing and provided a repair estimate to replace the affected exhaust heat recovery system component. The overheating warning message was the first symptom observed prior to diagnosis. The problem was confirmed by the dealership after inspection and testing. This issue may indicate a defect in the exhaust heat recovery or thermal management system used in this hybrid vehicle, as coolant is entering the exhaust stream internally rather than leaking externally. If this type of failure occurs in other vehicles, it could lead to overheating while driving and potential engine damage.

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2019 Kia Niro. The contact stated while driving at an undisclosed speed, the vehicle jerked. The check engine warning light and the hybrid battery warning light were illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the clutch actuator was leaking, and the dual clutch and slave cylinder needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but denied assistance in covering the cost of the repair. The contact stated that the engine and dual clutch were replaced two years ago. The contact related the failure to NHTSA Campaign Number: 23V534000 (POWER TRAIN); however, the VIN was not included. The failure mileage was approximately 100,000.

Reported

Mar 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Hydraulic fluid is leaking onto the hydraulic clutch actuator’s circuit board, creating a potential fire hazard. The vehicle requires replacement of the dual clutch and slave cylinder. This failure occurred just over one year after Kia replaced the dual clutch and performed a full engine replacement at a Kia dealership. This condition is identical to a known safety recall affecting 2019–2022 Kia Niro vehicles involving hydraulic clutch fluid leaking onto the actuator circuit board and creating a fire risk. Although my VIN is not listed under the recall, the vehicle is the same year, make, model, and drivetrain and is exhibiting the same defect described in the recall. This appears to be a recurring safety defect involving the hydraulic clutch system.

Reported

Feb 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

My backup camera works intermittently, it has been tested at the dealership and supposed to be faulty, but if faulty why does it sometimes work, this causes danger when reversing the vehicle! The dealership wants $821 to replace the camera, I feel it should be a recall, as a whole bunch of Ford vehicles are recalled for the same issue! I have had several close calls even using my mirrors and looking over my shoulder, as the car has big blind spots!

Reported

Jan 2026

Incident date

May 1969

Mileage

Not provided

Outcome flags

None reported

Continuing and worsening motor rumbling noise and ticking/clicking at slow speeds. Spent a couple of months and without car for weeks just to have kia confirm and have gearbox changed. This has existed in some form for a couple years now.

Reported

Nov 2025

Incident date

Nov 2022

Mileage

Not provided

Outcome flags

None reported

1. Failed Component/System: EV plastic charging door does not open using the electronic unlock mechanism on the key. Unable to charge EV vehicle due to this fundamental failure. IMPORTANT: There are no manual override mechanisms provided by the manufacturer - KIA to open this charging door. This makes the EV both unsafe and unusable since it cannot be charged. 2. Safety Risk: Unable to charge an EV vehicle is a fundamental EV electrical system component failure that can create an unsafe situation since it occurs without any warning and leave the car owner stranded. The Manufacturer - KIA has not provided any manual fail safe/override mechanism to open the charging door manually. This is also a fundamental safety issue since the failure occurred without any warning lamp/other indication to the owner. IMPORTANT: Other KIA NIRO EV owners have complained about the same issue in online forums. Refer attachment - [XXX] 3. Dealer Problem Reproduction: NO since dealer demands a $299.99 diagnostic fee. Multiple attempts to contact the dealer and manufacturer KIA to waive the diagnostic fee were unsuccessful. 4. Manufacturer/Police/Insurance Inspection: No. KIA refused to deal with this issue under the KIA 10-year/100,000-Electric vehicle (EV) system warranty even though the warranty description mentions all internal parts. Reference: KIA Case No. [XXX]. NOTE: KIA does not allow the case history to be retrieved from their manufacturer portal because they have closed the case. 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure? NO 6. When did they first appear? [XXX] (approximately) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Sep 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2019 Kia Niro. The contact stated that while operating the vehicle, the message "Pull Over and Shut off Engine" was displayed and a burning odor was coming from the engine compartment. After restarting the vehicle, the failure was self-corrected. The vehicle was taken to the local dealer who determined that fluid had leaked into the clutch actuator and the clutch actuator needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was previously inspected as part of the NHTSA Campaign Number: 23V534000 (POWER TRAIN). The contact stated that the vehicle experienced the failure listed in the recall. The failure mileage was 35,000.

Reported

Aug 2025

Incident date

Aug 2021

Mileage

Not provided

Outcome flags

None reported

While driving an error message appeared about regenerative braking system error and the braking effectiveness was severely impaired.

Reported

Jul 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns 2019 Kia Niro. The contact stated that on several occasions when the vehicle was started, the check engine warning intermittently illuminated. The contact stated that while driving and accelerating, the vehicle lost motive power momentarily. The vehicle was taken to an independent mechanic and DTC: P074A, P1921, P074A/73, and P1921-77 were retrieved. The vehicle was taken to a dealer where it a diagnosed and determined that the transmission gear actuator needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 75,000.

Reported

Jun 2025

Incident date

Aug 2024

Mileage

Not provided

Outcome flags

None reported

2019 Kia Niro DCT engaged REVERSE during manual 1→2 upshift attempt in Sport Mode, causing violent reversal. Resets with ignition cycle. Smell of burnt clutch present. Happend at 41,000mi, then 73,000mi then again today at 154,584. Believe it may be a faulty range selector, corrupted tcu logic, or both. **Canadian Recall R238 (May 2022)** for DCT clutch actuators

Reported

Jun 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

I am writing to formally file a complaint regarding the mishandling of a recall repair (Recall SC276) by the authorized dealership KIA of Lincolnwood, located in Illinois. In October 2024, I contacted the dealership in relation to Recall SC276. A diagnostic inspection confirmed the issue, related to the HCA system, and was supported by multiple error codes: U1010, U1011, P17ED, P17EE. I was informed that the required parts were not available at the time and would be ordered. Despite the known fire risk associated with this recall, the dealership allowed me to drive the vehicle home, which clearly contradicts the safety procedures outlined in Kia’s own recall regulations. I waited approximately two months for a follow-up, but received no communication from the dealership. I called them myself and was informed, after repeated inquiries, that the replacement part had allegedly been damaged during delivery, and that I would need to wait longer. Weeks later, I was contacted and asked to bring the vehicle in. By that time, the car could no longer operate under its own power and had to be transported to the dealership. I left it for repairs. Shockingly, within an hour I received a call saying the car was “ready for pickup.” Upon returning, I discovered that nothing had been done. The vehicle was parked exactly where I had left it. After further discussions, the dealership admitted that the repair had not been performed and the part had not been replaced. I have photographic evidence to confirm this. They assured me the part would be ordered again. My vehicle remained at the dealership from early January until late April 2025. Eventually, I was told that I must pick up the vehicle or face storage fees. Still, no repairs had been completed. This dealership has twice returned the vehicle to me without making the required safety repairs, despite the known risk of fire and potential harm to life. They also misled me about the repair status on multiple occasions.

Reported

Jun 2025

Incident date

Nov 2024

Mileage

Not provided

Outcome flags

None reported

The rear backup camera works intermittent, checked wiring and still having issues, could cause backing issues for people that don't use their mirrors

Reported

May 2025

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

Ever since the car was purchased 2nd hand, I reported an issue with the car within the 30 day warranty period that the vehicle was steering towards the right and would not go in a straight line, also it popped when steering right, 2 days ago the rod that connects to the bar in the middle that moves in and out as you steer came undone and was chipped

Reported

Apr 2025

Incident date

Apr 2025

Mileage

Not provided

Outcome flags

None reported

I have a Kia Niro Hybrid. I had the check engine light come on. I took it to Kia dealership in Cicero, NY (Driver's Village/ Burdick Kia. Upon inspection, the dealership stated the following: "CONFIRM CUSTOMER CONCERN CEL ON, P0401 EGR INSUFFICIENT FLOW EGR PORT BECOMES CLOGGED AT HIGH MILEAGE, EGR REPLACEMENT WOULD CORRECT LIGHT TEMPORARILY HOWEVER CASUAL CONDITION WILL STILL REMAIN, CLOG IN EGR FROM ENGINE ITSELF. LONG BLOCK REPLACEMENT MAY BE NEEDED FOR FULL CORRECTION OF CONDITION"

Reported

Jan 2025

Incident date

Jan 2025

Mileage

Not provided

Outcome flags

None reported

Car brought to dealership on 12/2 due to check engine light. scan showed cylinder 4 misfire. Car in shop for 1 week to fix cylinder head replacement. stated "operating as designed". Car returned to shop due to car turning off in the highway. All light were on. now showing hybrid system fault. Dealership had to open kia tech ticket [XXX]. CONFIRMED LIGHTS ON DASH, HYBRID SYSTEM FAULT. DTC SCAN FOUND MCU,BMS DTC'S. REMOVED CONNECTIONS FROM THE HPCU TO INSPECT WIRING AND FOUND CENTER PIN IS MELTED AND THERE IS THERMAL DAMAGE TO WIRING. P0A3E DTC, OPEN TA#[XXX] TA HPCU REPLACEMENT IS NEEDED. CABLE REPLACEMENT IS NEEDED. 1/6 - now advised another part is needed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jan 2025

Incident date

Dec 2024

Mileage

Not provided

Outcome flags

None reported

The contact's customer owns a 2019 Kia Niro LX. The contact stated that his customer stated that the vehicle overheated. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic who replaced the converter. The vehicle was repaired, but the failure recurred. The owner stated that the vehicle was randomly stopping. The vehicle was taken back to the independent mechanic. While test driving at 15 MPH, the brakes were operating as designed, and then after several attempts, the brake pedal was applied and depressed to the floorboard, and the driver crashed into a parked BMW X5. There were no warning lights illuminated. The brakes were inoperable. The air bags deployed. There were no reported injuries, fire or police report filed. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not notified of the faikure. The failure mileage was approximately 144,800.

Reported

Jan 2025

Incident date

Dec 2024

Mileage

Not provided

Outcome flags

Crash

The contact owns a 2019 Kia Niro. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who determined that there was a misfire in cylinder #1. The vehicle was not repaired. The vehicle was then taken to the dealer, who diagnosed a failure with the cylinder #4 injector. The dealer also informed the contact that the clutch needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 32,000.

Reported

Dec 2024

Incident date

Dec 2024

Mileage

Not provided

Outcome flags

None reported

While I’m driving a turtle light randomly illuminates and the car shuts off. The car shuts off from a few seconds up to a minute so far. I have taken it to Kia McDonough Ga and to no avail nothing: they had my car 2 months and by the time they did the diagnostic “the computer box reset”. Why let it sit for a diagnostic when all they are doing is connecting to a computer. I provided them videos and pictures and nothing. This is a danger any passengers, other drivers, as well as myself. The times are random and once the light comes on it’s off. Battery is new, battery is charged.

Reported

Dec 2024

Incident date

Oct 2024

Mileage

Not provided

Outcome flags

None reported

Car made loud whinning noise for 6 months, due to defective transmission. KIA refused to fix because car was out of warranty- but has TSB: ELE234. My extended warranty did not cover because it was a known defect from KIA.' Car stopped working, transmission was repaired. Please see below attached 16k invoice.

Reported

Nov 2024

Incident date

Jun 2024

Mileage

Not provided

Outcome flags

None reported

Service bulletin eng212. 4th cylinder misfire. Diagnostic has been done at Dennis Dillon 9501west Fairview ave Boise id 83704. Engine shaking when increasing speeds above 30 mph. Started without warning while driving. It was recently serviced for routine items on October 16th 2024. On November 5th it had diagnostic performed. Check engine light and display showed automatic diagnostics, engine control system, possible engine condition. I was on my way to vote. Yes it is available for inspection. I am currently not driving it but unsure what to do with it since the value of the car and amount of repairs needed are close in range.

Reported

Nov 2024

Incident date

Nov 2024

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2019 Kia Niro. The contact stated while driving at an undisclosed speed, the vehicle inadvertently lost motive power with the message "Stop Engine". The check engine warning light was illuminated. The vehicle was towed to the dealer, who diagnosed failures with the hydraulic clutch actuator and catalytic converter. The catalytic converter was replaced, but the hydraulic clutch actuator was not repaired due to lack of part availability. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V534000 (Power Train); the VIN was included, but parts were not yet available. The manufacturer was notified of the failure and confirmed that the part was on backorder. The failure mileage was 87,000.

Reported

Oct 2024

Incident date

May 2024

Mileage

Not provided

Outcome flags

None reported

On June 28, 2022, I set my Juicebox Pro 40 charger to charge my car overnight. The car did not charge and I discovered that the breaker had tripped. I tried resetting the breaker and it immediately tripped again. I noticed a burning smell in the garage in the vicinity of the charger after attempting to reset the breaker. There was discoloration on the unit box. I then unplugged the unit at which point I was able to reset the breaker without it tripping. I concluded that the unit was unsafe to use and I returned it to ENEL. I bought a new one while I waited for warranty service on the old unit. I have not tested the old unit since it was repaired by ENEL. It was my judgment at the time, and remains so, that the unit presented a fire hazard.

Reported

Oct 2024

Incident date

Jun 2022

Mileage

Not provided

Outcome flags

None reported

There’s motor rumble due to a misalignment of the traction motor and reduction gear. It’s a known issue with these vehicles and a technical bulletin was issued but no recall. I’ve brought the vehicle in twice and the first time the dealer told me there was nothing wrong. Now a year later they admit it is wrong and is unsafe to drive without a $10k replacement.

Reported

Sep 2024

Incident date

Mar 2024

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2019 Kia Niro PHEV. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The manufacturer informed the contact to ship the vehicle to the United States for the repair. The contact had not experienced a failure. Parts distribution disconnect.

Reported

Aug 2024

Incident date

Aug 2024

Mileage

Not provided

Outcome flags

None reported

The contact owned a 2019 Kia Niro. The contact stated while driving at an undisclosed speed, the contact noticed a ticking and a popping sound coming from the vehicle. The contact's friend who was following behind noticed white smoke coming from the exhaust pipe. The vehicle was driven to the destination. The following day, the oil level was checked, and the contact stated that the oil level was low; however, there was no sign of an oil leak. The contact stated that when the vehicle was started and made a rattling sound. The contact turned the vehicle off and the vehicle was towed to an independent mechanic where it was diagnosed with a hole in the crankcase. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 120,000.

Reported

Aug 2024

Incident date

Jul 2024

Mileage

Not provided

Outcome flags

None reported

When accelerating from a dead stop, sometimes the car makes a very loud 'clunk' noise and lurches forward. Similar to the feeling when someone drives a manual transmission and takes the clutch out too fast. The car eventually finds the first gear and keeps driving, but this problem happens daily. Maybe around 5-10% of the time after every stop. There are multiple similar complaints on the NHTSA website and on online forums. It is a well-documented issue.

Reported

Jul 2024

Incident date

Jul 2024

Mileage

Not provided

Outcome flags

None reported

EV battery cooling system displayed the warning, "LOW INVERTER COOLANT LEVEL." I checked and it is not low.

Reported

Jul 2024

Incident date

Jul 2024

Mileage

Not provided

Outcome flags

None reported

Tire size 215/55 R17 Tire model: Nokian One. All 4 tires cracked at the sidewall and thread, around or below shoulder. It is about less than 20k miles on this set of 4 Nokian One tires. They have been used for 15 months. Nokian released the Nokia One model in 2021.

Reported

May 2024

Incident date

May 2024

Mileage

Not provided

Outcome flags

None reported

Car has warning message and several engine lights on dash come up and asks to stop car and check the regenerative brake system. Car loses all systems that are electrical, car is very hard to drive, even not operative. This has happened many times over the past four years. Each time the car has been taken to a authorized KIA Dealership and they have not been able to fix the problem. It happened almost a week ago and dealership told us that they couldn't find anything wrong and were told to pick it up. Happened again today and it was while driving. Same issue, same warnings on dash.

Reported

May 2024

Incident date

May 2024

Mileage

Not provided

Outcome flags

None reported

- While driving, we received a notice on the dashboard to "stop driving and check regenerative brakes". Simultaneously we lose 95% of our braking power and all of the acceleration. Slamming on the brakes all the way to the floor provided some minor braking ability, but it was significantly diminished and frankly terrifying. We turn the car off, turn it back on again, and everything seems totally normal. - We cannot recreate the error, but we call the dealership. They say they can get us in in a week to service us. As this is our only car we keep driving it cautiously. - This happens again once more, before we bring it into the dealership. - The dealership runs a bunch of tests, tells us its the 12V battery, replaces the 12V battery, charges us $500 and tells us its fixed. - one week later (today) the same thing happens. Clearly it's not fixed, but even if it had been fixed, why is so much of the braking tied to the 12V? The dealership cannot get us in for days and is suggesting this may not be covered under our warranty.

Reported

May 2024

Incident date

May 2024

Mileage

Not provided

Outcome flags

None reported

Constantly get a refill inverter coolant light on dash, have taken it in to dealer and are unable to correct it.

Reported

Mar 2024

Incident date

Mar 2023

Mileage

Not provided

Outcome flags

None reported

My 2019 Kia Niro LX PHEV is or has recently been the subject of multiple including NHTSA Recall Number [XXX] and Service Action [XXX]. Despite coordinating repair of these defects with the University Kia dealership located at 5105 Durham Chapel Hill Blvd, Durham, NC 27707 (hereafter 'University Kia"), and taking my vehicle to University Kia for those repairs twice, University Kia has been unable or unwilling to repair the defects over a 4-month period. This delay has not been due to parts availability, as I have received multiple assurances that parts needed to repair the defects were available. After three separate service appointments, University Kia has been unable to address these defects, and my vehicle remains in an unsafe condition. P.S.: The numbers on the prior page of the form where I can nominally report these issues (888-327-4236 & 800-424-9153) don't seem to be working. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Mar 2024

Incident date

Mar 2024

Mileage

Not provided

Outcome flags

None reported

Car caught fire

Reported

Mar 2024

Incident date

Aug 2022

Mileage

Not provided

Outcome flags

Fire

12 volt battery will suddenly and without warning loose capacity to power the vehicle operating controls and displays including remote key access, start sequence using push button start, and traction battery charging through charging port. While parked and connected to a charging station vehicle ‘died’ in place. This occurred within 10 minutes of last use of remote key to unlock doors, open doors, place shopping bags, close doors, and use driver door push button feature to relock doors. Outside air temperature was mid 20’s Fahrenheit. Traction battery was fully depleted per dashboard miles available display as vehicle driven 20 plus miles using hybrid vehicle mode just prior to parking at charging station. Vehicle was removed from charging station connection and 1.5 hours later jump started using connection under hood. After start was driven just under 4 miles to home garage where plugged into 110 volt home charger. Multimeter on 12 volt system after recharge of traction battery read over 12 volts. Appears that control system for maintaining charge on 12 volt system using traction battery has a flaw that fails to detect 12 volt battery condition and react correctly. While this occurred this time while vehicle stopped and shutoff there is potential for such to occur while vehicle in a roadway at highway speeds causing vehicle to loose all power as 12 volt system powers all operating logic. As a practicing engineer over 50 years and college instructor of engineering for about 40 years it appears that there is a software error in assuring 12 volt system intact and a failure of the software to identify potential problem, notify operator, provide a manual reboot of operating system before 12 volt system reaches failure level if it ever did. Unlike alternator equipped vehicles that show failure of alternator no such given on hybrid.

Reported

Feb 2024

Incident date

Jan 2024

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2019 Kia Niro. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while the vehicle was at the dealer for the scheduled recall repair, the vehicle was inspected. The contact's wife was informed that the hydraulic clutch actuator (HCA) was faulty and needed to be replaced. The contact's wife was informed that the parts were unavailable, and the repair needed to be rescheduled. The vehicle was not repaired. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 61,473. Parts distribution disconnect.

Reported

Feb 2024

Incident date

Feb 2024

Mileage

Not provided

Outcome flags

None reported

KIA NIRO 2019 SAFETY RECALL As described in the safety recall (previous page), my KIA Niro 2019 alarm went off with the following error message "Engine Overheating". Kia of America and its dealership refused to fix the problem. The car dealership -said- has no direction as to how or when to fix the problem, and the KIA consumer hotline is out of business.

Reported

Feb 2024

Incident date

Feb 2024

Mileage

Not provided

Outcome flags

None reported

Able to completely stop vehicle with light brake pedal pressure without activating the brake lights. Regenerative braking is engaged

Reported

Jan 2024

Incident date

Jan 2024

Mileage

Not provided

Outcome flags

None reported

This complaint references the open recall with the Kia reference SC276 and the NHTSA reference of 23V534. Kia has not been able to provide me with repair despite a notice from them stating a remedy is available, and appears Kia may be sending out faulty notices. I first received notice in July/August, 2023 that this recall was in process but remedy was not available. This week, I recieved a letter dated December 29, 2023 that explicitly states remedy is available (attachments will be added). However, the NHTSA website, the Kia recall website, and my local Kia dealer all as of today (01/04/24) say that remedy still is not available. I have attempted to call Kia customer care at the number on the letter, but every attempt has resulted in their system hanging up on me before I could reach anyone.

Reported

Jan 2024

Incident date

Jan 2024

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2019 Kia Niro. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Reported

Dec 2023

Incident date

Dec 2023

Mileage

Not provided

Outcome flags

None reported

On 7-31-2022 while traveling on the freeway the gas engine shut down, HEV triangle came on and the information center on the car displayed "turn off car restart" on this trip it happened three times. I took the car to the dealer and they had it for a month and could not get it to act up. On 5-5-2023 it did it again twice, I called the dealer and they did not have a loaner car, they said they would let me know when they do. On the 6-30-2023 it did it eleven times. I called the dealer and they checked the car into service a mouth later 7-2023. The car has been at the dealer since then, now it is 12-2023. The dealer has not been able to get it to act up. I call KIA customer service and they told me they would not do the recall unless the dealer can repeat the problem. When this happens, I have only a limited amount of room to get the car off the road. This problem has only happened on freeways and the mountain pass with limited pull outs. This exposes me and any passenger's to a rear end collision. I feel the manufacture is playing roullet with me and my passenger's lives. All my dealer paper work is in my car a two hour trip at Sunset KIA 3317 Auburn way N Auburn WA 98002

Reported

Dec 2023

Incident date

May 2022

Mileage

Not provided

Outcome flags

None reported

Recall letter from KIA states "WARNING: You may experience illumination of the HEV warning light. If this occurs, pull over to a safe location and contact Kia Roadside Assistance ... to request to have your vehicle towed to the nearest authorized Kia dealership as soon as possible." This implies that the car is not safely driveable if the HEV warning light illuminates. My HEV warning light illuminated, but neither of two local Kia dealerships is willing to take responsibility since the "remedy is not available" from Kia. This means I have lost the safe use of my car for an indefinite period without any compensation from Kia.

Reported

Dec 2023

Incident date

Dec 2023

Mileage

Not provided

Outcome flags

None reported

This is a published TSB but it doesn't appear when searching for this vehicle. I have to search in google for specific phrases to find this on your website. "DRIVE UNIT INSPECTION & REPLACEMENT FOR EV MOTOR RUMBLE NOISE " Kia Niro EV: [XXX] Hyundai Kona EV: [XXX] Known issue with many customers reporting Kia and Hyundai Motor failures. But since it is not an official recall campaign, it doesn't pop up when researching Kia Niro, Soul, Hyundai Kona, Ioniq EVs. Many consumers report that service centers will gaslight, dismiss, downplay, or falsely blame on brakes, rotors, other unrelated parts. Some have reported they flat out refuse to work on their car even if they bought it there, stating that they don't have technicians trained for EV service. And when/if we are lucky enough for service departments to do repairs, the parts are on backorder. They have to replace brackets/mounts that never resolve issue until finally replacing the motor/gearbox. Often the problem comes back in a few months as the replacement parts don't actually address the root causes. This should certainly be a full recall campaign that the public is made aware of. A final note here on the problem with these extensive complicated long services, is that people are without a vehicle during the whole process. Dealerships and Manufacturers pass the buck, point the finger to each other. Dealerships don't offer loaners, they say check with Kia for rental reimbursement. No one who plans a budget for a new car payment, ever factors in $2-3000 for months of car rental payments that the Manufacturer won't pay until the service is fully finished. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Dec 2023

Incident date

Nov 2023

Mileage

Not provided

Outcome flags

None reported

Breaks seized to respond when doing a sharp break. Vehicle did not break and slid off until it hit the vehicle up front. Waiting for vehicle inspection to begin. No warning signs, lights, or prior issues happened before the incident.

Reported

Nov 2023

Incident date

Nov 2023

Mileage

Not provided

Outcome flags

Crash

The contact owns a 2019 Kia Niro. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Reported

Nov 2023

Incident date

Nov 2023

Mileage

Not provided

Outcome flags

None reported

Kia America, Inc. (Kia) is recalling certain 2017-2022 Niro and 2018-2022 Niro Plug-in Hybrid vehicles. Fluid may leak into the printed circuit board inside the hydraulic clutch actuator, which can result in an engine compartment fire.

Risk: A fire increases the risk of injury.

Remedy: Dealers will inspect and replace the hydraulic clutch actuator as necessary and install a new fuse, free of charge. Owner notification letters were mailed December 29, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC276.