2025 Ford Bronco

Bronco hard top is beginning to warp really bad and delaminate. Classic problem happening with there and ford still refuses to come up with a real solution. Every day the warping gets worse and I’m just waiting for it to get bad enough so I can take it in and ford actually do something about it. The warping and delaminating also impacts the seals of the hardtop panels on the car. The top also rattles really bad. Absolutely crazy for an expensive car. It’s very obvious that climate and humidity have the largest impact on this issue and STILL they do nothing about it.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

On June 22, 2026, my 2025 Ford Bronco caught fire while parked outside a store. The vehicle had been parked for approximately five minutes when the fire began. There were no warning lights, alerts, unusual odors, or other indications of a problem before the incident. The fire and heavy smoke appeared to originate from the center console area near the gear shifter. The flames quickly spread throughout the driver’s side, center console, front passenger area, and the rest of the vehicle’s interior. The entire interior sustained severe fire and heat damage and was substantially melted. The responding fire department advised that temperatures inside the vehicle were well over 300 degrees. Firefighters disconnected the vehicle’s battery, after which the vehicle began to cool. Based on their initial observations, they indicated that the fire appeared to be electrical in nature. The vehicle had recently been filled with gasoline, which made the situation even more dangerous. Fortunately, no one was inside the Bronco, no other vehicles were parked nearby, and the fire department responded quickly. The vehicle has been transported to a repair facility but has not yet been inspected to determine the precise cause of the fire. I am extremely concerned that a nearly new vehicle could suddenly catch fire while turned off and parked, without any warning. This could have occurred while I was driving, with passengers inside, or while the Bronco was parked in my garage. Under those circumstances, the fire could have caused serious injury or death, destroyed my home, or endangered other people and property. I am submitting this complaint because I believe this incident presents a serious public-safety concern. I respectfully request that NHTSA investigate whether other 2025 Ford Bronco owners have experienced similar electrical fires and whether a defect exists that could place drivers, passengers, families, first responders, and the public at risk.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

Fire

When the vehicle is in "Eco" mode, and an attempt is made to rapidly accelerate in an emergency situation, pressing the accelerator pedal to the floor results in a significant delay before *any* engine response is detected, far beyond what is reasonable for a normal gasoline powered vehicle. In several situations, I was in heavy traffic; traffic in the lane in which I was travelling was relatively slow. I attempted to change lanes into an adjacent lane in which traffic was moving much faster. When traffic allowed, I merged into the faster lane, and pressed the accelerator pedal to the floor. Prior to pressing the accelerator pedal, the vehicle was moving approximately 20 mph. Nothing happened for several seconds, and then the vehicle suddenly accelerated. During the period of non-response, traffic in the faster lane caught up to my vehicle. I am able to reproduce the issue 100%. The dealer's response is that "it's normal" (typical service response) and there was no attempt to investigate. I have driven several identical make/model vehicles belonging to friends, and one dealer vehicle (test drive) and they all exhibit the same issue. There are no warning lamps, errors, codes, or any indication that any system is faulty. The high latency in the throttle control system is clearly an ECU programming issue, and it increases the risk of collision. I have only observed this issue in models of this vehicle with an automatic transmission. I do own an identical model of this vehicle with a manual transmission, and this issue is not present.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

I have a 2025 Ford Bronco Big Bend with 5233 miles. The windshield wipers stopped working. I checked the fuse and the fuse was good. I changed the fuse anyway and the wipers still do not work.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Its becoming more frequent and a huge safety issue. When you're driving the car, it feels like the emergency parking brake automatically engages. And when you push the brake pedal, it almost feels like it's dead, meaning there's no pressure back against your foot, which is really unusual for this vehicle, period. You don't necessarily lose control of the car, but you certainly don't have complete control of the braking system, period. Then you are in a period of time to get off the road safely and turn the vehicle off and restart it. Then the system seems to correct itself, and you can drive away. But I'm concerned about this from a safety perspective,

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Vehicle was parked in a secured location and the back windshield spontaneously broke more likely due to hot weather.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The Pre-Collision Assist false-triggers on turns daily, flashing the red collision warning and actively applying autonomous emergency braking without any obstruction present. This phantom braking is a severe safety hazard. The vehicle has been serviced before for this issue - and is going back to the shop next week (for the same issue).

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Car would shut off shortly after using remote start on key fob then display a warning on digital instrument cluster for two days now. It would also show my speed going back and forth from 0 to 1mph while parked.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

I am filing a safety complaint regarding repeated windshield cracking on my new 2025 Ford Bronco. I purchased the vehicle approximately 2 months ago. Since purchase, the vehicle has experienced 3 separate windshield cracks under normal commuting use only. The vehicle has not been used off-road or in extreme driving conditions. The most concerning issue is that after the windshield was replaced, the replacement windshield developed another crack within approximately 24 hours of installation. The dealership has repeatedly classified the damage as “normal road debris” or “rock impact,” but I am concerned this may involve a structural, installation, or manufacturing defect rather than ordinary wear and tear. My concerns are based on the following: Multiple windshield failures in a very short period of ownership Failure occurring on a brand-new replacement windshield within 24 hours Normal commuting use only Concern for stress-related cracking, improper installation, body/frame flex, or windshield mounting issues Potential safety hazard involving driver visibility and windshield integrity I am requesting investigation into possible manufacturing, installation, or structural defects involving windshield cracking or windshield mounting systems on the 2025 Ford Bronco. I am also aware of other Ford Bronco owner complaints involving repeated windshield cracking and windshield-related issues. This issue creates ongoing safety concerns due to impaired visibility and repeated glass failure in a nearly new vehicle.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

On [XXX] at [XXX] PM I was driving westbound on [XXX] at [XXX] while traveling through the intersection, my vehicle started shaking, lost acceleration, and nearly caused me to have a collision. My vehicles check engine light began flashing, and I was able to safely exit the highway. On May 20, 2026, Crouse Ford diagnosed a “cylinder #6”, however attributed the event as “an anomaly”, and no corrective action was taken despite the seriousness of the safety concerns. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

This is in reference to Safety Campaign 26S32. My fiancé owns a 2025 Ford Bronco 5 door and her roof has the same exact issue that is described in this safety campaign. Before the vehicle had 5000 miles on it the roof had already begun to show cracks, honeycombing and is beginning to show signs of delamination. The vehicle is going to our local dealer in a week to hopefully have the roof replaced under warranty but I doubt that permanently fixes the issue. Fords comment that they have resolved the issue is patently false. I will gladly send photos of the cracks as soon as possible but this safety campaign, in my opinion, should be extended to all of Broncos from 2021 to current.

Reported

May 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2025 Ford Bronco. The contact stated while attempting to start the vehicle depressing the brake pedal, heard a clunking noise and on for second the vehicle attempts to move while in park. The contact mention he could hear clunking sound coming from the front of the vehicle. A dealer was contacted. The vehicle was taken a dealer to be diagnosed, however the diagnoses was unknown. The vehicle was not repaired. The contact was relating the failure to NHTSA Campaign Number:25V164000 (Power Train), however the VIN was not included in the recall The manufacturer was not notified on the failure, and they informed him to take the vehicle to dealer. failure mileage was 2,200.

Reported

May 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

After only 880 miles, the clutch and cylinder have failed.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Sunday April 19 2026, in a drive thru while stopped, the following alerts popped up with their corresponding dash lights: Check Brake System Park Brake limited service function Pre-collision assist not available Service Advance Track Brake pedal lost vacuum / pressure and became hard. Brake would not engage and needed to use electric park brake to stop vehicle. Got out of the drive thru and into an empty parking lot. I tried accelerating and then stopping but vehicle would not stop while pressing the brake. Used e brake again to stop. I turned vehicle off and back on. All errors did not pop up again and there were no lights on the dash. While driving home less then a mile from original incident location, the same errors and brake failure occurred while going 30+ miles per hour. Same issue with a hard brake pedal occurred. This time, if brake pedal was depressed far enough, the e brake would engage but only the rear wheels would lock up and vehicle would skid/slide in order to slow down. I have video recordings of these incidents. Brake system failed as vehicle lost ability to brake at low and high speeds. The loss of brakes could result in a car crash and deaths. The vehicle has been towed to a ford dealer and they are in possession of the vehicle. They are currently investigating the issue. The vehicle has not been inspected by manufacturer or authority agency. There were no warning lamps, messages, or symptoms prior to the brake system failing. The brakes worked normally and then suddenly failed.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Crain Ford in Jacksonville Arkansas (72076) sold me this vehicle while it was under a national stop-sale with an active recall and expected me to make payments on the loan while they held the vehicle for several months.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Description: My 2025 Ford Bronco suffered a catastrophic failure of both rear shock absorver external reservoirs, consistent with Recall 25S01 (NHTSA 25V025). The reservoirs detached intirely while driving out-of-state, forcing an 800-mile transit with 5 passengers on an unstable suspension. Issue: Upon presenting the vehicle to Interstate Ford, the dealer and a Ford Representative issued a formal denial of warranty coverage. They cited Claim Type 14, Condition Code 39 ("Missing Part"). Why it's a Safet Risk: Ford is using the severity of the defect - the fact that the part sepearated - as a reason to deny the repair, even though Recall 25S01 explicitly warns that the defect causes "seperation fo the external reservoir." This is a refusal to remedy a known safety defect that has already caused a hazardous driving condition.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2025 Ford Bronco. The contact was made aware by the Turo App that the VIN was associated with NHTSA Campaign Number: 26V124000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that parts were not yet available. The manufacturer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

This vehicle had an open safety recall at the time the dealership sold it to me. The recall existed before the sale and the dealership knew or should have known about it. The dealer submitted loan paperwork and accepted funding but never delivered the vehicle to me. I was not informed of the open recall before signing. This is a safety and compliance issue involving a dealer selling a vehicle with an unrepaired recall

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

On oct. 26, 2025, I was in a bad car accident. I was coming home and came to a stop on Spring Street.In Marion. MA before entering Rte 6 . I looked both ways and the rte was clear. I looked again both ways and still was clear, so I moved my 2025 Bronco Badlands onto the Rte 6 and within seconds I was hit very hard on the front left quarter. My SUV spun around at least 270º and I was immediately taken to the ER nearby (Tobey Hospital) for Brain and neck Studies. No airbags deployed. I have photos of the vehicle showing my damage. The driver of the other car must have been speeding as the hit was huge. I was the sole person in my car. The Marion PD Officer who was in charge of this accident changed the story to say "I looked both ways, saw a car coming and I moved forward" into Rte 6 to get home around the corner. I had injuries all over my body and brain with concussion/mild TBI. There were no witnesses and the building near the scene of the MVA had a professional camera over their front door. They would not let me see the video. They did let the other driver see the video The angle of this cam was changed from straight across the street looking at the scene directly. I had no way of knowing what happened and I have spent about a half a year getting therapy at three different physical therapy sites/hospital. I asked the Police to see if I could ask the State Police if they would do a Collision Analysis and Reconstruction so I could know what happened as I was labeled At Fault which I understood if the other driver was driving normally and safely. I was told that if no one is seriously hurt or dead then they would do it. I lost my memory and am still getting visual changes and severe headaches. The series of Radiologic images show that I had lots of Damage. I am a XXX Physician and I know I was hit by surprise and never saw the other car because of the angles of the road. I told photos and have images of the scene and of my car and the other car

Reported

Mar 2026

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

Crash 1 injuries

The contact owns a 2025 Ford Bronco. The contact received notification of NHTSA Campaign Number: 26V124000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that the part was not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The contact owned a 2025 Ford Bronco. The contact stated while driving 30 MPH, another driver pulled closer to the vehicle and honked to get the contact's attention. The contact stated that upon rolling down the window, the contact noticed flames coming from the front driver's side wheel well. There was no warning light illuminated. The contact was able to pull over to the side and exited the vehicle. The contact stated that the vehicle completely burned from the front end to the front seats. The contact stated that the fire originated from the driver's side of the engine compartment. The front driver's side of the vehicle sustained more fire damage than the passenger's side of the vehicle. The fire was extinguished by the fire department. A fire department report and a police report were filed. There was no reported injury. The vehicle was towed to a tow yard. The vehicle was a total loss. The dealer and the manufacturer were not contacted. The failure mileage was approximately 13,500.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

Fire

The contact owns a 2025 Ford Bronco. The contact was made aware of NHTSA Campaign Number: 26V124000 (BACK OVER PREVENTION) after contacting the manufacturer. The contact had recently purchased the vehicle and was not informed about the recall. The contact became aware afterwards that the part was not yet available. The local dealer was contacted. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

I am sending this to anonymously report a critical compliance issue at Stivers Ford in Birmingham, Alabama. They are actively selling brand-new vehicles with active safety recalls. Dealership employees have openly admitted to taking brand-new, never-titled vehicles and delivering them to end consumers. They are doing this even though recall 26S09 is still active and it has absolutely no remedy available right now. This is a HUGE safety problem. The Proof: • Stock B9380, VIN [XXX] • Stock B9259, VIN [XXX] These two units are just the tip of the iceberg. I am confident that a deeper look will uncover many more cases across all of their dealerships. We need to look into this and make sure they stop delivering unsafe vehicles immediately. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

on Jan 15, 2025. A cold start for the Bronco, putting in reverse, the vehicle lurched back and to the hard right, uncommanded acceleration at a high rate of speed, steering locked up, brakes locked up, tires spinning, engine revving causing the bronco to smash into the exterior of my home garage area. Then, shifting to drive, the vehicle again lurched, uncommanded acceleration hard to the left now, steering locked up, brakes locked up, tires spinning engine revving traveling 20-30 feet crashing into the electrical box coming to rest on top of it. Numerous faults showing multiple systems malfunctioning causing this incident.

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

Crash

I have experienced three total brake failures in my 2025 Ford Bronco. During the most recent incident on 2-18-2026 the brake pedal traveled completely to the floorboard, requiring extreme force and multiple pumps to stop the vehicle. This appears to be the exact failure described in Ford Recall 25S77 (NHTSA Campaign 25V488) regarding the Electronic Brake Booster (EBB) module. The vehicle was presented to Suntrup Ford twice previously for this issue, but the defect was not corrected. I am reporting a life-threatening safety failure. After February 18th 2026 brake failure I had bronco towed to Suntrup Ford in Kirkwood Missouri and that's where it will stay. I am too frightened to drive it again.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

Structural crack in molded in color roof compromising the integrity of vehicle roof.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

Loss of braking. Note weather was cold in single digits Fahrenheit and midly snowy. I drove my 2025 Ford Bronco that was purchased in Octorber about 20 minutes to drop off my child at daycare. Going into the daycare I turned to Slippery/4A mode. After about 5 minutes inside I pulled out and switched back to Normal/2H mode. Less than half a mile later I got multiple warnings that the brakes, EBB, collision detect, and ABS had faulted, and I should service now. I only had the electronic parking brake available. I was able to use it and engine braking with my manual transmission to get to off the road to a parking lot, although I did also receive a parking brake overheat fault the turn before getting into the parking lot. I shut the vehicle off without the parking brake on. I turned it back on and the dash warning lights all disappeared after a few seconds. Brake function returned and I drove it to a Ford service center about 1 mile away. They were not able to reproduce the problem or find any DTCs. I did get notifications of some of the faults to my Ford app on my phone. I am uploading the redacted RO and screenshots of the Ford notifications. Losing braking obviously put myself and my passenger pregnant wife at risk. Thankfully I was moving at lower speeds on a flat section of road and not taking a highway exit at the time of failure.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

While slowly backing into our home garage, the vehicle accelerated brakes were not working and smashed into the side of the house, put the car in drive to move it. It accelerated forward over correcting and drove into our power box and came to a halt. No brakes were working and the wheels/steering locked up.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

While driving, after a missed downshift that causes engine bogging, the vehicle experiences a loss of engine power. The engine remains running but will not produce usable torque and will not rev above approximately 800 RPM, despite clutch disengagement and selecting the correct gear. Holding the clutch fully depressed does not immediately restore power; instead, after approximately 4 seconds, the engine stalls or cycles/resets, after which normal operation resumes. The condition persists until the vehicle nearly stops, the engine stalls, or the ignition is cycled. This has occurred in traffic and adverse weather conditions and is repeatable.”

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Description of Incident: > While driving in freezing drizzle/sleet conditions in northern Minnesota, the factory-installed LED headlights on my 2025 Ford Bronco became obscured by ice buildup within 15 minutes of driving. ​The Safety Issue: > the LED headlights do not produce sufficient heat to melt frozen precipitation. This resulted in a degradation of forward visibility during nighttime driving, creating a safety hazard. I was forced to pull over repeatedly on a high-speed roadway to manually scrape ice from the lenses. ​Request: > I am reporting this as a design defect for vehicles sold in northern climates. The lack of a heating element or de-icing mechanism in the standard LED equipment makes the vehicle unsafe for nighttime driving during freezing weather with high humidity conditions.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Accident Statement – Instrument Panel Cluster Failure & Collision While driving my 2025 Ford Outerbanks, the Instrument Panel Cluster (IPC) screen suddenly went completely black without warning. At the time of the malfunction, I was attempting to merge into traffic on my left with my left turn signal activated. Simultaneously, an 18-wheeler in the lane beside me was merging to his right. The sudden loss of my IPC screen meant I could not see my speedometer, warning indicators, safety messages, or any visibility cues needed to safely judge traffic speed and spacing. This created an immediate hazardous situation and made it extremely difficult to manage both my own speed and the surrounding traffic patterns. As I recognized the danger, I attempted to brake and avoid a collision. During this moment, my steering wheel began to shake slightly—possibly due to the lane-keeping or lane-safety system responding. Despite my efforts to correct and avoid impact, the 18-wheeler collided with my vehicle. At the time of the crash, I had no visibility of any dashboard warnings, alerts, vehicle speed, or safety notifications due to the IPC failure. My insurance representative has inspected my vehicle and deemed it a total loss.

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

Crash 1 injuries

Driving in sub-freezing temperatures with snow/rain falling and slush on the road, the headlights iced over with thick slush and ice and reduced visibility to dangerous levels requiring me to pull off the road and chip off the ice putting myself in a dangerous situation being on the side of the road during a storm.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The slave Cylinder failed causing the clutch to not fully disengage burning out the clutch at only 783 miles on the vehicle. Ford headquarters claims driver misuse, dealership disagrees at such low mileage.

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

When I purchased my vehicle I noticed the round rod that contains the backup camera, which is mounted on the spare tire bracket to be all scratched and scruffed up. The dealership (Hawk Ford, Carol Stream) agreed to replace this. Their are scratches inside where the camera sits around the threading and the rod it self is all banged up. I showed the dealer ship this and they replaced the mounting bracket, not the rod so when I got my car back I contacted them right away and sent before and after pictures. Manager went into lot and said all of the other ones he checked had the same issue. He was going to contact Ford to see if they were aware and how to go about this concern affecting my vehicle and all others on their lot. It should be new with no physical defects, but it appears used. When you buy a new car, you expect everything to be new and look new but this does not.

Reported

Oct 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

The display panel for the speedometer and gas would not work or display anything.

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

Description of the Problem: The issue involves the speakers and radio system in my 2025 Ford Bronco. The audio system intermittently cuts out completely, resulting in a total loss of sound. This includes music, phone calls via Bluetooth, and most importantly, navigation voice instructions. The component (the vehicle’s speaker/radio system) is still installed in the vehicle and available for inspection upon request. Safety Risk: This malfunction poses a safety risk while driving. When using navigation, if the sound cuts out unexpectedly, I am forced to look down at my device for directions, which distracts me from the road and increases the risk of an accident. In modern vehicles where navigation and hands-free systems are standard for safe driving, losing audio output directly impacts driver safety. Reproduction and Confirmation: The problem has been reproduced and confirmed by my local Ford dealership on two separate visits. The service department acknowledged that they are aware of the issue affecting multiple vehicles but stated that there is currently no available fix from Ford. Inspection: The vehicle has been inspected by the Ford dealership twice. They ran diagnostics and confirmed the issue originates from the speaker/radio system, but no replacement or repair has been offered at this time. The manufacturer (Ford) has not provided a technical service bulletin or recall to address it. Warning Signs or Messages: There were no warning lamps, error messages, or prior symptoms before the failure. The sound loss occurs randomly while driving, without any visible indicator or pattern. The first occurrence was shortly after purchasing the vehicle in September 2025, and the issue has continued intermittently since.

Reported

Oct 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

I was driving the vehicle on high mountain pass roads in Colorado. Anytime I would approach approximately 11,400 feet of elevation. The vehicle would instantly lose all power with no warning lights of any kind. All gauges were in the normal operating range. Vehicle would barely move 2 mph. Created a very unsafe condition on narrow steep dirt roads in the mountains. As soon as I turned around and descended approximately 100 feet in elevation the power came back instantly and vehicle operated normally. This happened on three occasions. The roads we were on were narrow, off-road vehicle mountain roads, and it created an extremely dangerous situation. I contacted Ford and they have not heard of this issue and there are no recalls associated with it. I spoke to a Ford bronco ambassador, who was also on the trail system with a lot of other off-road vehicles, including Broncos and they had never heard of this happening . This vehicle is Six months old. Ford says there are no codes set on my computer and since they cannot duplicate this where I live in Phoenix because there are no roads high enough I don’t know where to turn.

Reported

Sep 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

New vehicle sold to me by Paul Miller Ford Mazda, 975 East New Circle Rd., Lexington, KY 40505 with an open, uncured, undisclosed recall regarding vent flap on passenger airbag.

Reported

Sep 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

Repeated cross traffic alert and blind spot alert fault message.

Reported

Aug 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

2025 Bronco Sport Safety Recalls* Replace instrument panel cluster Recall incomplete Block heater element replacement Recall incomplete Cylinder head replacement Recall incomplete Cylinder head inspectionreplacement Recall incomplete DO NOT DRIVE! RECOMMENDED TO REPORT NATIONAL ALERT FOR OWNERS OF THIS VEHICLE TYPE. INVESTOR REPORTING FOR BROADCAST RECALL ALERT!

Reported

Aug 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

Vehicle was parked in driveway and put into park. After getting out of vehicle and walking into house we noticed the car started to roll forward and by the time we could react the car was picking up speed and rolled into a tree at the end of our driveway. A few days prior while driving 40 mph near our house the car inadvertently went into neutral without notice and without switching the gear shifter and we had to put the shifter back into drive while moving.

Reported

Jul 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

Crash

Child safety locks on back left door do not lock allowing back seat passengers to open door freely and endangering everyone in vehicle.

Reported

Jun 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

ABS light going off when parked in reverse on an inclined hill with the left side of vehicle on a higher level than right. Pre collision showing as unavailable as well as Service AdvancTrac and Park brake Limited function Service Required all displayed on odometer screen.

Reported

Jun 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

When starting my commute to work and when returning home, the instrument panel and gauges display would not turn on. After power/engine restart and open/close driver door, I drove off and about 10 minutes into drive the instrument panel and gauges display started working. On the way to work I pulled over and took a photo. On the way home I sat in parking lot at work and videoed trying to get display to work. Vehicle security system was installed the day *after* the display failure, 04/18/2025.

Reported

Apr 2025

Incident date

Apr 2025

Mileage

Not provided

Outcome flags

None reported

Ford Motor Company (Ford) is recalling certain 2025 Ranger, Lincoln Nautilus, Mustang, Maverick, Explorer, Escape, Lincoln Corsair, Bronco Sport, and Bronco vehicles. The exhaust gas recirculation (EGR) valve may fail, resulting in an unexpected loss of drive power.

Risk: An unexpected loss of drive power increases the risk of a crash.

Remedy: Dealers will replace the EGR valves, free of charge. Interim letters, notifying owners of the safety risk, were mailed March 20, 2026. Additional letters will be sent once the final remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S10. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.

Ford Motor Company (Ford) is recalling certain 2021-2026 Ford Bronco and 2021-2024 Ford Edge vehicles. The Accessory Protocol Interface Module (APIM) may overheat and shutdown, which can prevent the rearview camera image from displaying as intended.

Risk: A rearview camera that fails to display an image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.

Remedy: The APIM software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed April 13, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S09. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.

Ford Motor Company (Ford) is recalling certain 2025 Bronco and Ranger vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."

Risk: In the event of a crash, windshield detachment can increase the risk of injury.

Remedy: Dealers will remove and replace the windshield, free charge. Owner notification letters were mailed October 20, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C52. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 14, 2025.

Ford Motor Company (Ford) is recalling certain 2024-2025 Bronco vehicles. The front lower control arm fasteners may not have been tightened properly, allowing the control arm to detach from the frame.

Risk: A detached control arm can cause a loss of vehicle steering and control, increasing the risk of a crash.

Remedy: Owners are advised not to drive their vehicles until they have been repaired. Dealers will inspect and verify that the lower control arm fasteners are tightened properly. If a fastener is loose or missing, the dealer will replace the fastener. Repairs will be performed free of charge. Owner notification letters were mailed June 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S48.

Ford Motor Company (Ford) is recalling certain 2024-2025 Bronco and Ranger vehicles. The front upper control arm ball joint fastener may be missing or tightened improperly, allowing the front upper control arm to detach from the knuckle assembly.

Risk: A detached control arm can cause a loss of vehicle steering and control, increasing the risk of a crash.

Remedy: Dealers will inspect and tighten, or replace the ball joint fastener as necessary, free of charge. Owner notification letters were mailed May 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S45.

Ford Motor Company (Ford) is recalling certain 2025 Ranger and Bronco vehicles. The bolts that secure the driver's seat frame to the body may be loose or missing. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 207, "Seating Systems."

Risk: A seat with loose or missing fasteners may not properly restrain an occupant during a crash, increasing the risk of injury.

Remedy: Dealers will inspect the seat fasteners and tighten or install new fasteners as necessary, free of charge. Owner notification letters were mailed May 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C16.

Ford Motor Company (Ford) is recalling certain 2025 Lincoln Navigator, F-150, Expedition, Bronco, and Ranger vehicles. The Electronic Brake Booster (EBB) module may malfunction while driving or when the driver is utilizing an Advanced Driver Assistance System (ADAS) feature, resulting in a loss of power brake assist.

Risk: An unexpected loss of power brake assist while driving can extend stopping distance and increase the risk of a crash. Additionally, a loss of power brake assist while ADAS features are engaged can result in the vehicle not braking as expected, increasing the risk of a crash.

Remedy: Dealers will replace the electronic brake booster, free of charge. Owner notification letters were mailed February 26, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SD4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 3, 2025.

Ford Motor Company (Ford) is recalling certain 2024 Ranger, and 2024-2025 Bronco vehicles. The front upper control arm ball joint nut may not have been installed or tightened properly, allowing the front upper control arm to detach from the knuckle assembly.

Risk: A detached control arm can cause a loss of vehicle steering and control, increasing the risk of a crash.

Remedy: Dealers will inspect and verify that the ball joint fastener is tightened properly. If a fastener is loose or missing, the dealer will replace the ball joint and knuckle assembly as necessary, free of charge. Owner notification letters were mailed on November 20, 2024. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 24S64.

Ford Motor Company (Ford) is recalling certain 2024-2025 F-150, Bronco, 2024 Ranger, 2025 Mustang, Explorer, and Aviator vehicles. The transmission valve body may have been machined incorrectly, which can cause reverse gear failure, or unexpected forward movement in reverse or neutral gear.

Risk: Unexpected vehicle movement increases the risk of a crash.

Remedy: Dealers will replace the transmission main control valve body, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S19.

Ford Motor Company (Ford) is recalling certain 2025 Bronco vehicles. The front upper control arm ball joint nut may be missing or tightened improperly, allowing the front upper control arm to detach from the knuckle assembly.

Risk: A detached control arm can cause a loss of vehicle steering and control, increasing the risk of a crash.

Remedy: Owners are advised not to drive their vehicles until they have been repaired. Dealers will inspect and verify that the ball joint fastener is tightened properly. If a fastener is loose or missing, the dealer will replace the ball joint and knuckle assembly. Repairs will be performed free of charge. Owner notification letters are expected to be mailed in April 2025. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 25S40.

Ford Motor Company (Ford) is recalling certain 2025 Bronco vehicles. The active vent flap on the passenger side may prevent the air bag from deploying as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: An air bag that does not deploy as intended increases the risk of injury during a crash.

Remedy: Dealers will replace the passenger air bag module, free of charge. Owner notification letters were mailed October 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C27.

Ford Motor Company (Ford) is recalling certain 2025 Bronco four-door vehicles. The left-hand rear door may be able to be opened from inside the vehicle when the child safety lock is in the "ON" position.

Risk: A malfunctioning child safety lock that allows a rear door to be opened unintentionally can increase the risk of injury.

Remedy: Dealers will inspect and replace the rear door latch, as necessary, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S64.

Ford Motor Company (Ford) is recalling certain 2025 Lincoln Navigator, F-150, Expedition, Bronco, and Ranger vehicles. The Electronic Brake Booster (EBB) module may malfunction while driving or when the driver is utilizing an Advanced Driver Assistance System (ADAS) feature, resulting in a loss of power brake assist.

Risk: An unexpected loss of power brake assist while driving can extend stopping distance and increase the risk of a crash. Additionally, a loss of power brake assist while ADAS features are engaged can result in the vehicle not braking as expected, increasing the risk of a crash.

Remedy: The EBB module software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters were mailed on August 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S77.

Ford Motor Company (Ford) is recalling certain 2025-2026 Bronco and Bronco Sport vehicles. The Instrument Panel Cluster (IPC) may fail at startup.

Risk: An instrument panel display that does not show critical information, such as warning lights or vehicle speed, increases the risk of a crash.

Remedy: The instrument panel cluster software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed December 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SC3.

Ford Motor Company (Ford) is recalling certain 2021-2025 Bronco vehicles. The transmission to transfer case joint may be misaligned due to an incorrectly performed previous repair, which could lead to wear of the transmission output shaft splines and transfer case input splines.

Risk: Excessive wear of the transmission and transfer case splines may result in a loss of drive power or vehicle rollaway, increasing the risk of a crash.

Remedy: Dealers will inspect the transmission to transfer case joint and replace the transmission and transfer case as necessary, free of charge. Owner notification letters were mailed July 9, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S26. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 15, 2026.

Ford Motor Company (Ford) is recalling certain 2024-2026 Ranger and Bronco vehicles. The front seats may have a loose or dislodged seat frame height-adjust pivot bolt.

Risk: A seat with a dislodged bolt may not properly restrain an occupant in a crash, increasing the risk of injury.

Remedy: Dealers will inspect and replace the pivot links and bolts as necessary, free of charge. Owner notification letters were mailed May 22, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford’s number for this recall is 26S30. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning April 30, 2026.

Ford Motor Company (Ford) is recalling certain 2025-2026 Explorer, Ranger, and Bronco vehicles. The engine may fail, which can result in a loss of drive power.

Risk: A sudden loss of drive power can increase the risk of a crash.

Remedy: Dealers will replace the engine long block, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 5, 2026. Additional letters will be sent once the remedy is available, anticipated in November 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S35. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 28, 2026.

Ford Motor Company (Ford) is recalling certain 2022-2026 Bronco vehicles. The fender flares may not be properly secured and detach from the vehicle.

Risk: A detached fender flare can become a road hazard and increase the risk of a crash.

Remedy: Dealers will inspect and repair, or replace the fender flares as necessary, free of charge. Interim letters, notifying owners of the safety risk, are expected to be mailed August 10, 2026. Additional letters will be sent once the remedy is available, anticipated in late August 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S47. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning August 7, 2026.