2023 Ford Bronco

The MIC hard top component on my Ford Bronco is cracking. I have gotten it replaced twice through Ford for the same issue, but now this is my 3rd top and the issue keeps coming back.

Reported

Jul 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

2023 Ford Bronco with 7 speed manual transmission. The transmission started grinding while shifting into 3rd gear and occasionally popping out of 3rd gear. This mostly occurred while upshifting and rarely while downshifting. All other gears are operating as normal. While the grinding problem would pop up occasionally around the 40,000 mile mark, it became chronic at 58,000 mile mark (24Jun2026)

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

After making a right hand turn, when the steering wheel recenters for some unknown reason it is turning on the left turn signal. I had noticed it in the past and thought I was wrong, but it continuing to do it.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

TOTAL BRAKE FAILURE IN 2023 BRONCO. What happened is exactly what is described for current recall of the electronic brake booster for 2025 broncos. Mine is a 2023.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Camera and sensor on driver side does not indicate movement/stops working. This results in the Blindspot detection not working or any cross traffic alerts or object detection, which can lead to an accident. occurs intermittently and car does not issue a warning that the system is not working or down. Also causing an issue when backing up

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

-Complete steering and suspension failure occurred while driving on highway. Vehicle is currently sitting at Ford dealer. - The safety of all passengers was put at risk and nearly caused a fatal accident. -Dealer and another shop are saying it was lower control arm and bushing failure. They are unclear on path forward for repairs and it seems like something bigger is going on they do not want to disclose. They deny problem has been reproduced on this model, however a similar recall for this type of failure has occurred on other bronco models under recall number 26S36. That recall report matches what happened to my vehicle. -It has been inspected by Ford and Bronco Barn in Las Vegas. I will be getting a third opinion for a clear path forward since none has been supplied by ford or the third party company. -There were no warning lamps, check engine lights, or messages prior to failure. There was a slight misalignment of tires felt while driving just prior to losing full steering control.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Delamination of roof and cracking with leaks

Reported

May 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The contact owned a 2023 Ford Bronco. The contact stated that while her boyfriend was driving at an undisclosed speed, the vehicle made an abnormal noise. The contact's boyfriend had pulled over. They discovered an unknown fluid leaking under the vehicle and a spark coming from the engine before the vehicle caught fire. There were no injuries were sustained. The firefighters arrived and extinguished the fire. Police and fire department reports were filed. The vehicle was towed to a tow yard and deemed totaled by the insurance company. Upon research, the contact related the failure to the fuel injector. The manufacturer was made aware of the failure and informed the contact that there was no recall associated with the VIN. The failure mileage was approximately 10,000.

Reported

May 2026

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

Fire

when engine is cold and I go down a hill to a stop sign and apply the brakes , the brakes begin to engage almost fully then release and the Bronco lurches forward 6-8" and then the brakes grab and slam the car to a stop. This only happens on an incline and when the engine is cold or has sat for awhile. THe brake pedal is fully depressed and when the bronco rolls forward, there is nothing to do to stop it since the pedal is already fully engaged. I have taken it to the dealer numerous times to diagnose, but since there is not a hill or incline near them, they are not able to reproduce the same issue. I have videos of this happening and it is a known problem that has been diagnosed in the Ford bronco online forums. The dealer suggested I call Ford Service to report the issue and I started a case complaint.There are no warning messages or codes that are present that the dealer can find to explain the problem. The car is not safe to rely on due to the brake system currently and the dealer nor Ford corporate will do anything but document my issue.

Reported

May 2026

Incident date

Sep 2023

Mileage

Not provided

Outcome flags

None reported

My husband was sitting at a stop light when he noticed what appeared to be steam/smoke coming out from under the hood of the Bronco. Then smoke came into the vehicle through the air vents. When he looked up, flames were coming out from under the hood. He got out and the whole front of the car burst into flames and torched the car.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

Fire

The contact owns a 2023 Ford Bronco. The contact received notification of NHTSA Campaign Number: 26V124000 (Back Over Prevention). The contact stated that on several occasions when the vehicle was in park(P) and running, the infotainment screen turned black after several seconds. The vehicle was taken to a dealer, but was not diagnosed. The dealer stated that the failure might be possible with the recall repair and that the part was not yet available. The manufacturer was notified of the failure. The failure mileage was approximately 64,000.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Going 80 on the fwy. It stared shaking, engine light came on. Immediately go off the fwy as soon as I stopped it died and wouldn’t start.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

I am reporting unresolved safety recalls and unreasonable delay in repair for my 2023 Ford Bronco (VIN: [XXX] ). This vehicle currently has two open safety recalls issued by Ford Motor Company     •    NHTSA Recall 25V721 (issued October 2025) – seat frame defect that may increase injury risk in a crash. There is currently no available remedy, and Ford has notified me that a repair is not expected until April 2027.     •    NHTSA Recall 26V124 (issued March 2026) – APIM defect that may overheat and cause the rearview camera to fail while reversing, increasing crash risk. In addition, this vehicle has had prior recalls (25V025 and 25V273) that remained unresolved for extended periods. One of these recalls had no available repair for approximately 10 months. These recalls affect critical safety systems including suspension, rear visibility, and seat safety. The delay for Recall 25V721 is expected to exceed 18 months, which I believe is an unreasonable delay for a safety recall repair. Ford has continued issuing new recalls while prior recalls were still unresolved, indicating a pattern of repeated safety defects and delayed remedies. Due to these active recalls, I have been unable to use my vehicle commercially. Rental platforms such as Turo prohibit listing vehicles with open safety recalls. This has resulted in financial losses exceeding 80,000. This situation forces consumers to choose between operating a vehicle with known safety defects or suffering significant financial loss due to lack of repair availability. I am requesting that NHTSA investigate whether Ford is complying with its obligation to provide timely safety recall remedies and whether delays of this length are reasonable. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Apr 2026

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

Steering would get stuck when turning, then let loose. Fortunately I didn’t lose control. Happens all the time now when driving. Had the car towed to dealer. They diagnosed failed steering shaft. This Bronco has approx 28,000 miles on it. Ford Motor Company refused to help me pay for the approx $1000 repair. Finally, the dealer worked with a contact at Ford for them to cover most of the cost. Ford wouldn’t consider issuing a recall, or expanding an existing recall for a similar steering problem, which didn’t include my VIN. No warning lights, messages, etc. I consider this a serious defect.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

My infotainment screen goes blank when I backup instead of displaying my backup camera. There is an active recall on this but there is no remedy and no estimated remedy date. Ford Motor Company is only prioritizing 2026 model years so they can sell brand new vehicles. They are not trying to fix previous model years. This poses a safety risk that can result in a crash and/or death. Cars are required by law to have a backup camera, so Ford is breaking the law by not fixing this issue.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

A couple of times on as well as off pavement when traveling on a decline I depress the brake pedal and it only very softly applied the brakes. I have to press very hard to come to a stop. Much harder than normal. Once (off pavement) they did not work until the third time I pressed them. The pedal just went to the bottom. Normally the steep decline seems to be associated to the issue.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

UNKNOWN Windshield wipers will change speeds without driver intervention. While in steady to heavy rain, wipers will slow to intermittent after a few minutes of being on. This is causing visibility issues and safety issues as a result. Very dangerous!

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2023 Ford Bronco. The contact stated that upon inspection the hard top roof, there were several cracks formed on the roof. The vehicle was taken to the dealer where the failure was acknowledged, and it was agreed that the hard top would be replaced under warranty. After the hard top was replaced, the contact inspected the new hard top and discovered several dents and uneven surfaces on the roof. The dealer was notified of the failure, and an agent advised the contact to bring the vehicle back to the dealer. The contact was informed that he could inspect the hardtops of the newer vehicles at the dealer lot and if he found a top that he liked, the dealer would swap the hardtop and replace the hardtop. After inspecting approximately 5 vehicles, each vehicle had issues with their hardtops. Upon investigation, the contact discovered General Service Bulletin: 23-7174, which was associated with the failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 18,000.

Reported

Mar 2026

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

1. Component/system that failed/malfunctioned — Braking system (electronic parking brake and brake control modules) combined with electrical/communication defect preventing storage of diagnostic trouble codes (DTCs). Vehicle available for inspection upon request. 2. How safety was put at risk — Repeated "Park Brake Fault – Service Now" and "Brake System Fault" warnings on dash while driving risk sudden loss of parking brake function, reduced braking, or unexpected behavior (e.g., transmission no-engagement beyond walking pace after cold start), impairing safe stopping/control and endangering driver and others. 3. Problem reproduced/confirmed by dealer — Yes — reproduced/confirmed multiple times by authorized Ford dealer (Town & Country Ford, Evansville, IN) across five visits (invoices attached): active brake faults visible on dash during service, yet "no codes found," "unable to verify," "NP no problem found." Examples: [XXX] (30,113 mi) brake fault while driving; [XXX]intermittent parking brake light, no codes; [XXX] transmission slip and brake fault, no codes. 4. Inspected by manufacturer, police, insurance, or others — Inspected only by dealer. Ford CX team contacted (CRM [XXX] , July 2025) but no further inspection/resolution. No police or insurance inspections. 5. Warning lamps/messages prior to failure and when first appeared — "Park Brake Error Message" and "Park Brake Fault" warnings first documented 25,722 miles (early visits after [XXX] purchase at 13 miles). No-DTC retention defect prevented earlier alerts/diagnosis. Symptoms escalated (transmission slip, cold no-start die-out, brake faults recurring). 6. Additional notes — Out of service 60 cumulative days; loaner restricted to local driving only when provided. Part of Indiana Lemon Law claim (BBB AUTO LINE Case [XXX]). Due to 10-file/10MB upload limit, core documents attached; additional photos, full invoices, loaner agreement, BBB correspondence available upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Mar 2026

Incident date

Oct 2023

Mileage

Not provided

Outcome flags

None reported

The vehicle experienced recurring electrical system failures beginning in December 2023. The vehicle intermittently would not start and on several occasions lost power unexpectedly. The vehicle was taken multiple times to an authorized Ford dealership for diagnosis while still under the manufacturer warranty. The dealership repeatedly reported that no issue could be identified despite the recurring electrical malfunction. The vehicle battery was replaced more than once within three years, however the underlying electrical issue persisted. In August 2025 the dealership instructed that the vehicle remain at the service center for extended diagnosis. The vehicle remained at the dealership for more than 40 consecutive days before being returned on October 8, 2025. Because the vehicle intermittently fails to start and has experienced electrical system malfunction, this creates a potential safety risk if the vehicle stalls or loses power while operating in traffic. Additionally, the vehicle currently has two outstanding manufacturer safety recalls that remain unresolved after nearly three years of ownership. This complaint is being submitted because the defect remains unresolved despite multiple repair attempts while the vehicle was under the manufacturer warranty.

Reported

Mar 2026

Incident date

Dec 2023

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2023 Ford Bronco. The contact stated that while driving a motorhome at an undisclosed speed and towing the vehicle in tow mode, the transmission blew up. The contact pulled over to retrieve sunglasses from the vehicle and became aware that there was an odor of transmission fluid coming from the vehicle. The vehicle was towed to the local dealer, who confirmed there was no warranty coverage for the failure. The dealer stated that the failure was due to operator error. The vehicle was diagnosed and determined that the transmission needed to be replaced. The vehicle was repaired. The manufacturer was contacted and opened a case. The approximate failure mileage was 10,642.

Reported

Mar 2026

Incident date

Apr 2025

Mileage

Not provided

Outcome flags

None reported

Automatic 10 speed transmission has unpredictable shifting from 1st through 3 gears, offten with long lags between shifts, losing power temporarily, especially from 1st to 2nd gear, and harsh shifting. Sometimes, the 1st - 2nd shift lag happens upon acceleration during merging or in an intersection and that loss of power is critical, requiring an adjustment in throttle position, and when 2nd gear catches, then there is too much power. It is unpredictable. The Bronco has about 35K miles now, but this has happening since day 1. Twice in dealer, twice the tech noted it, and twice the only solution was to clear the adaptive shift control memory. Does not fix the issue.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

I took my Bronco into Michigan City Ford for recall 25V273 repair. Shortly after this the front camera stopped working. I took it back in and they are saying the camera module is M2DZ-19H405-D has gone bad. They are saying this module controls front and rear camera but is not part of the recall. On the internet, there are many examples of the front camera issue after the rear recall repair.

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

soy based wire shielding second time that my ford bronco was in the shop for wire fault issues due to critters/animals eating the wires. Ford service agent said he has seen hundreds of vehicles come in with the same issue. This is not a ford problem it is an automotive industry problem. Please investigate

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

My vehicle was sitting in a small parking lot at work and the back liftgate glass blew out onto the pavement. It was 95 degrees outside. The liftgate arms and all the shattered glass were on the outside of my vehicle. I called the dealership and was told nothing they could do and they didn't even ask to look at it. I paid out of pocket to replace the glass. Then on January 24th when it was -25 degrees I remote started my vehicle and it ran for about 10 minutes, I went outside to leave for work, got in started my vehicle and looked in the rearview mirror and noticed the leads for the rear defrost were hanging down. I got out of my vehicle to find shattered glass all over my driveway and the liftgate glass arms outside of my vehicle. I called Ford and I called the Ford dealership. No help. Just told they've never heard of this happening. Well, I told them the1st time it happened and this is the second time. Brought to the dealership and no answers. Asked if they reported this and the last incident to ford as it's my understanding they are to notify corporate. Nothing. I asked them to see if there was a short in the rear defrost or any other reason why this is happening. I got a to bad so sad, if ya want it fixed it will be $1700. There are no warnings that this will happen.

Reported

Feb 2026

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

Hood latch sensor alarms hood ajar when hood is actually closed and secure. This issues inhibits the use of remotely starting, or unlocking vehicle. This appears to be a possible recall with the make and year of my vehicle but has never been listed as recall.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Parked my car overnight, I had the car for 3 days , I came out in the morning and the windshield was shattered, it looked like it burst or exploded outward from inside the car , there was no foul play involved, I checked my cameras etc. I have no idea what caused this but this is a potential safety issue especially if the car was in motion or being driven…

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Front differential mounts are cracking and breaking leading to insecure front differential and damage to adjacent suspension and power train components. This is a significant risk to both the driver/occupants and potentially other vehicles on the road. This problem is appearing with increasing frequency on the Ford Bronco forums to the point that Ford now has a TSB out relating to this known engineering failure. It require an extensive repair including rewelding the mounting brackets. There appears to be inadequate guidance to the repairing dealers, however, as there is a large degree of uncertainty as to how to approach executing the weld repair, according to my dealer, Corwin Ford, in Spokane, Washington.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Chronic water leak from roofline obstructing vision and causing confusion while underway

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

My vehicle has both cracked and leaking rear shocks as well as issues with the rearview camera and infotainment system. I have gone through two Ford Dealerships to remedy this issue and was told parts are on back order. I attempted to remedy this issue when I first received notification that parts were available in August 2025. When I drive, I can feel the suspension is not providing support and continued use will cause other issues with the vehicle that may not be covered under warranty or the recall. My vehicle will also trigger the collision avoidance feature when there is physical trigger. This has caused my brakes to lock up in traffic.

Reported

Dec 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

Check engine light stayed on, constant. Code run showed cylinder 4 misfire. Bronco still under warranty so took to dealership. Mechanic said coolant was inside cylinder so he requested recommended remedy from Ford and would probably be engine replacement.

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

The vehicle was parked and not in operation when a fire occurred. There was no collision or impact. The fire originated in the vehicle and caused significant damage. Emergency services responded to extinguish the fire. The vehicle had been properly maintained and there were no aftermarket modifications. The cause of the fire is unknown at this

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

Fire

On November 30th, 2025 I drove southbound from Milwaukee to Chicago, leaving at approximately 5:30 a.m., on I-41. There was a winter storm warning in effect. Approximately every twenty miles I needed to stop and deice my headlights as light output had diminished to almost zero, resulting in extremely dangerous visibility. I have experienced similar problems in Manitoba and western Minnesota. In these areas, there is often more than fifteen miles before you can exit the highway or find a safe place to pull over. It is not possible to get this problem diagnosed by a dealer. However, it is a common complaint among Bronco (and Jeep) owners. The combination of an upright grill and the low heat output of LED lighting quickly render headlights useless in snowy or icing conditions. No warnings appear; light output simply quickly drops to almost nothing.

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2023 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V273000 (Back Over Prevention), and the vehicle was taken to the dealer for the recall repair. The dealer replaced the rearview camera, but the rearview camera software update could not be completed. The dealer replaced the rearview camera a second time; however, the issue persisted. The dealer informed the contact that the software update might have failed due to the aftermarket 2-inch lift that was performed on the vehicle. The contact was advised that a fee would be charged for the lift removal and was informed that the lift removal might not correct the issue. The contact stated that the aftermarket 2-inch lift was a replication of the Sasquatch, 2-3" Lift package that the manufacturer offered. The recall repair was not completed. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue, but no assistance was provided. The contact had not experienced a failure.

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

I have a 2.7l V6 Bronco with an automatic transmission. There is a steep downhill road (22% grade) a couple blocks from my house that ends at a stop sign for a major cross street. I apply the brake pedal to slow down for the stop sign and the Bronco behaves normally and comes to a full stop, but then with no change in brake pedal pressure by me nor any pedal feedback, i notice the Bronco starts creeping forward a few feet, then abruptly stops again. When the Bronco starts creeping downhill and then abruptly stops again, there is no brake pedal feedback or movement, and the engine does not change RPM. The only sound I hear is something that sounds like service brakes releasing pressure then suddenly reapplying full pressure. I compensate by stopping early, so I don’t drift into the intersection, or a vehicle in front of me, or pedestrian. It can startle any pedestrian that starts to cross in front of my “stopped” Bronco and it suddenly starts creeping down on them. I have noticed this for months but have not taken it to a dealer for resolution yet. The problem appears to not happen after I have been driving for a few minutes. Because this is a problem that occurs on hills in the first few minutes of driving, it likely will be hard to demonstrate to a dealership for diagnosis because there are no hills near my local Ford dealership. The incident occurrence date entered below ([XXX]) is just today’s date - this problem has been present for many months, if not since new. Other uses have reported this same issue in online forums: [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Aug 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

There are reports of Ford Broncos rolling forward under braking, after a full stop. This occurs most often on a hill. To be clear, the brakes are already fully depressed, the vehicle is stopped, and THEN the vehicle suddenly rolls forward while the brakes are depressed, endangering pedestrians and others. This is NOT caused by driver error. Here are some vehicle owner complaints about this issue: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Aug 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2023 Ford Bronco. The contact stated that after opening the driver's side door and then closing the door, the passenger's side hard top fractured into several pieces. The dealer was contacted and informed of the failure. The dealer confirmed that the repair would not be covered for free. The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure. The manufacturer confirmed that the repair would not be covered. The manufacturer opened a case regarding the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 11,000.

Reported

Aug 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

My rear shocks have been corroding on the external resevior attached to the lower shock body and is rusting really bad in the exact place where the manufacturer of this vehicle says that it's breaking down ( rusting ) at. I called the dealership and the service department and they REALLY gave me the impression that they really don't want to repair my vehicle and is why I'm filling this report with NHTSA . I want the dealership of the manufacturer to replace my rear shocks with new shocks and not put RTV sealant and a retention clamp on this external resevior as stated as one of the remedies the manufacturer has listed in a letter sent out to all of it's dealerships about the manufacturers recall on the rear shocks . In the manufacturer's letter it does state that one of the remedies is replacing the shocks but ONLY if the shocks are leaking oil from the shock resevior/ flange damper area . The corrosion on my shocks are bad . The manufacturer is not SERIOIS about fixing this problem and is why I trust NHTSA to help me and thank you NHTSA .

Reported

Aug 2025

Incident date

May 2024

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2023 Ford Bronco. The contact stated that upon starting the vehicle, the message "Parking Brake Fault - Service Now" message was displayed. The vehicle was taken to a local dealer to be diagnosed; however, the contact was informed that further diagnostic test was needed to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 33,990.

Reported

Aug 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

rear tailgate on the bronco gives off a very loud rattling noise when driving

Reported

Jul 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

I am sending a complaint as I purchased this vehicle brand new from the dealer in June. They have not been able to give me my vehicle because Ford has not come up with a fix on these two recalls. My complaint is how long does Ford have to make this right? They keep extending the recall dates out from a month or so to now 4th quarter. I am paid for a vehicle that I can't use because of Ford's Delay. I am hoping you all as a government agency will give back some feedback and push Ford to fix the issue a bit more timely.

Reported

Jul 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2023 Ford Bronco. The contact stated that while driving at an undisclosed speed and flat towing an RV, the Flat-Tow mode inadvertently disengaged and the contact smelled a burning odor permeating the interior of the vehicle with the message "Stop vehicle immediately, excessive temperature detected" displayed. The transmission temperature warning light was illuminated. The vehicle was taken to the dealer, who determined that there was damage to the transmission and turbocharger due to the Flat-Tow mode not being engaged properly during towing. The contact was informed that the transmission and turbo charger needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Technical Service Bulletin: 22-7086. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The contact was later informed that the manufacturer concluded that the disengagement of Flat-Tow mode was the result of user error. The manufacturer declined to cover the cost of the repair. The contact contested the manufacturer’s findings as inconceivable, stating that the Flat-Tow mode was still engaged after arriving at his destination. The failure mileage was 50,200.

Reported

Jul 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2023 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V315000 (BACK OVER PREVENTION); however, the part to do the recall repair was not yet available. The contact stated that the rearview camera displayed a black screen while the vehicle was in reverse(R). The contact stated that the failure obstructed the driver's visibility, which prevented the driver from safely operating the vehicle. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.

Reported

Jul 2025

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

I was driving on the back of my property and a loud pop and clanking sound occurred right where the rear shocks are ; also there was/is a thin oil film all around the area where the shocks are . FORD is not fixing this problem is why I'm filing this report . I've also tried reaching out to Ford a few times with no success. THIS has been a problem for four years with Ford and no one has held Ford accountable. Lawsuits it seems are the only method that works I hope NHSTA proves me wrong. Sincerely [XXX] , thank you NHTSA INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jul 2025

Incident date

Jun 2024

Mileage

Not provided

Outcome flags

None reported

While attempting to back up I was checking my backup camera and it showed that nothing was behind me, as I started to turn while backing up I felt a bump, there was a car right behind me, I couldn’t see it in my mirror and apparently the camera was frozen on my Bronco.

Reported

Jun 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

Crash

After Avis Ford replaced my seatbelt on the driver’s side, my vehicle began to rattle from underneath the same area and in the front. The seatbelt side was serviced twice, and now the car feels unsafe. The dealership refused to re-inspect and told me to fix it out of pocket. I’m concerned this may be a structural or safety-related defect caused by improper repair.

Reported

Jun 2025

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

We have 3 Diono 3QXT car seats in our 2023 Bronco back seat. I noticed today that two of the car seat's vehicle seatbelts were unlatched. The middle car seat and the passenger-side car seat were loose because the securing seatbelt in the Bronco was unlatched. My concern is that one of the car seats activated the seat belt release button in the Bronco. I will monitor my car seats to see if the issue occurs again, but I thought it was important enough to report, in case there are any other similar complaints regarding either the Diono car seat or the Ford Bronco's rear seatbelts.

Reported

Jun 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

Engine began to leak air in intake where this is a faulty problem in the previous two models years and is an active recall on them also, 23 Ford Bronco, began to misfire causing to have to get engine replaced

Reported

Jun 2025

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2023 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V273000 (BACK OVER PREVENTION); however, the part to do the recall repair was unavailable. The contact stated that several dealers were contacted and informed the contact that the parts were no longer available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Reported

May 2025

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

Hello, I previously wrote about this problem under ID#116588898 however i feel as though it did not explain what happened correctly. As I was backing out of my garage, I stopped my vehicle putting it in park. After putting my vehicle in reverse and looking in my mirrors I didn't see anything behind me. (a blind spot) I was on an angle. My radio was on and as I proceeded in reverse, I hit a car that was in my driveway. There was no damage to my vehicle however there is about $3900 damage to the car behind me where the spare tire crushed the trunk lid and rear left qtr. At no time did I hear any warning lights, the radio did not lower, and warning lights and sounds were not doing the job of what they were supposed to do. As I thought about it, I'm not even sure the camera was on. I hope this explains this a little better than ID# 11658898. Sorry for the inconvenience of reporting this twice. If the other can be deleted that would be appreciated.

Reported

May 2025

Incident date

May 2025

Mileage

Not provided

Outcome flags

Crash

Ford Motor Company (Ford) is recalling certain 2021-2026 Ford Bronco and 2021-2024 Ford Edge vehicles. The Accessory Protocol Interface Module (APIM) may overheat and shutdown, which can prevent the rearview camera image from displaying as intended.

Risk: A rearview camera that fails to display an image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.

Remedy: The APIM software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed April 13, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S09. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.

Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Risk: An electrical short circuit can increase the risk of a fire.

Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.

Risk: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.

Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.

Risk: An engine stall increases the risk of a crash.

Remedy: Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Interim notification letters notifying owners of the safety risk were mailed July 16, 2025. Second letters will be sent once the remedy is available, anticipated 2nd Quarter 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.

Ford Motor Company (Ford) is recalling certain 2023-2024 Bronco 4-door vehicles. The left-side rear door may be opened from the inside of the vehicle when the child safety lock is in the "ON" position.

Risk: A malfunctioning child safety lock that allows a rear door to be opened unintentionally can increase the risk of injury.

Remedy: Dealers will inspect the child safety locks and replace the rear door latch, as necessary, free of charge. Owner notification letters were mailed April 9, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S15.

Ford Motor Company (Ford) is recalling certain 2022-2023 F-150, Mustang, Explorer, Bronco, and 2023 Lincoln Aviator vehicles equipped with automatic transmissions. The transmission may contain a loose bolt which could prevent the transmission from engaging the park gear, although the gear shifter position may indicate that the vehicle has been shifted to "PARK."

Risk: The inability to secure the vehicle in the park position can result in a rollaway, increasing the risk of a crash or injury.

Remedy: Dealers will inspect and, if necessary, replace the transmissions, free of charge. Owner notification letters were mailed April 25, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S06.

Ford Motor Company (Ford) is recalling certain 2023 Bronco Wildtrak and 2022 Bronco Raptor vehicles. Internal damage to the steering gear may require increased steering effort or cause the steering wheel to lock-up.

Risk: A steering wheel that locks-up can result in a complete loss of steering control, increasing the risk of a crash.

Remedy: Owners are advised not to drive their vehicles until the remedy is performed. Dealers will replace the steering gear, free of charge. Owner notification letters were mailed March 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S09.

Ford Motor Company (Ford) is recalling certain 2023 Bronco vehicles. The transmission park system may have been damaged during assembly, which can prevent the parking pawl from fully engaging and result in a vehicle rollaway.

Risk: A vehicle rollaway can increase the risk of a crash.

Remedy: Dealers will replace the transmission, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S44.

Ford Motor Company (Ford) is recalling certain 2023 Bronco and Ranger vehicles. The lug nuts on the driver's side wheels may have been improperly tightened.

Risk: Loose lug nuts may result in wheel detachment while driving, increasing the risk of a crash.

Remedy: Owners are advised not to drive their vehicles until the remedy is completed. Dealers will inspect, and if necessary, retighten the lug nuts, free of charge. Owner notification letters were mailed May 2, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S17.

Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco vehicles built with the 5-Door body style. The first-row seat belt latch plates may be difficult to access from their stowed position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: Difficulty accessing the seat belt latches may result in occupants not wearing their seat belts, increasing the risk of injury in a crash.

Remedy: Dealers will add a sliding clip latch stop to the driver and front passenger seat belts, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed July 14, 2023. Owner letters informing owners that parts are available were mailed on October 2, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C16.

Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco, 2023 Super Duty F-250, and 2019-2023 Ranger vehicles. The Tire and Loading Information (TREAD) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Risk: An overloaded vehicle increases the risk of a crash.

Remedy: Ford will mail a new TREAD label to install over the existing label, free of charge. Owners will also have the option to take their vehicle to a Ford or Lincoln dealer to have the new label installed, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C18.

Ford Motor Company (Ford) is recalling certain 2023-2024 Bronco and Bronco Heritage vehicles. The rear quarter glass panels may have been improperly installed to the vehicle hard top, which can allow them to detach.

Risk: Detached rear glass panels may create a road hazard and increase the risk of a crash.

Remedy: Dealers will inspect and reinstall the rear glass panels on Bronco vehicles. On Bronco Heritage vehicles, dealers will replace the rear left-hand removable quarter glass panel. Repairs will be performed free of charge. Bronco owner notification letters were mailed June 6, 2024. Bronco Heritage owner letters were mailed June 12, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S10.

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco vehicles. The rear shock absorbers may corrode and fail, resulting in detachment of the external reservoir.

Risk: An external reservoir that detaches from a vehicle can create a road hazard, increasing the risk of a crash.

Remedy: Dealers will replace the rear shock absorbers, as necessary free of charge. Owner notification letters were mailed August 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S01.

Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco vehicles. The 360-degree view camera may not display a rearview image when the vehicle is placed in reverse.

Risk: Loss of the rearview camera image can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.

Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed October 8, 2025. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 23S48. This recall expands previous recall number 23V-598.

Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco vehicles. The front seats may have a loose or dislodged seat frame height-adjust pivot bolt.

Risk: A seat with a dislodged bolt may not properly restrain an occupant in a crash, increasing the risk of injury.

Remedy: Dealers will inspect and replace the pivot links and bolts as necessary, free of charge. Owner notification letters were mailed April 28, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB5. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning October 28, 2025.

Ford Motor Company (Ford) is recalling certain 2021-2025 Bronco vehicles. The transmission to transfer case joint may be misaligned due to an incorrectly performed previous repair, which could lead to wear of the transmission output shaft splines and transfer case input splines.

Risk: Excessive wear of the transmission and transfer case splines may result in a loss of drive power or vehicle rollaway, increasing the risk of a crash.

Remedy: Dealers will inspect the transmission to transfer case joint and replace the transmission and transfer case as necessary, free of charge. Owner notification letters were mailed July 9, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S26. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 15, 2026.

Ford Motor Company (Ford) is recalling certain 2022-2026 Bronco vehicles. The fender flares may not be properly secured and detach from the vehicle.

Risk: A detached fender flare can become a road hazard and increase the risk of a crash.

Remedy: Dealers will inspect and repair, or replace the fender flares as necessary, free of charge. Interim letters, notifying owners of the safety risk, are expected to be mailed August 10, 2026. Additional letters will be sent once the remedy is available, anticipated in late August 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S47. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning August 7, 2026.