2023 Ford Escape

The contact owns a 2023 Ford Escape. The contact stated that while the vehicle was parked, the vehicle became inoperable. The vehicle was jump-started and the vehicle operated as intended. The contact received notification of NHTSA Campaign Number: 25V789000 (Electrical System); however, the part to do the recall repair was not yet available, and the contact associated the failure with the recall. The local dealer was contacted, and the battery was replaced. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and advised the contact not to charge the vehicle to full capacity to avoid the failure. The failure mileage was approximately 12,000.

Reported

Jul 2026

Incident date

Nov 2024

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2023 Ford Escape. The contact received notification of NHTSA Campaign Number: 25V789000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the recall was an inconvenience because the battery could only be charged to 80 percent. The dealer was notified and informed the contact that parts were still unavailable. The manufacturer was notified of the issue and referred the contact back to the dealer for assistance. The contact had not experienced a failure.

Reported

Jul 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

I received a recall notice for my car for the batteries. I parked my car in the garage so now I'm worried that my house is going to catch on fire and if I'm doing 70 mph down the freeway is my engine going to shut down. I'm not sure if this is part of it but my car doors lock on their own and a couple times my keys have been inside the car thank goodness I had an extra fob or the window was rolled down enough I could put my hand in it.

Reported

Jul 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

My 2023 Ford Escape (with fewer than 50,000 miles) began experiencing significant mechanical issues. I noticed exhaust fumes entering the cabin that passengers and I would inhale, loud noises from under the hood, and lose power during acceleration. After inspecting the vehicle, the dealership determined that the turbocharger wastegate/flapper valve had failed mechanically, causing the turbocharger to overboost and sustain internal damage. This failure led to numerous drivability issues, including hesitation, rough shifting, delayed upshifts, loud whining noises during cold starts, slipping during acceleration, and, at times, the inability to shift beyond second gear. Ultimately, the dealership concluded that the transmission needed to be rebuilt or replaced. My vehicle remained at the dealership from January 28, 2026, through May 14, 2026, over three and a half months. The vehicle still has transmission issues and loses power at times when driving on the highway commuting to work. At this moment of time, I scheduled it to go back to the dealership on July 9th.

Reported

Jul 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2023 Ford Escape. The contact stated that while driving approximately 65 MPH the "WRENCH Icon" was illuminated and the message "Service Gear Shifter" and the vehicle began to rapidly reduce speed. The contact was able to drive the vehicle to the shoulder of the highway road and the vehicle stalled. The vehicle was towed to the local dealer who diagnosed the vehicle and determined that the transmission had failed and needed to be rebuilt. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 33,000.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Dear Ford Motor Company Customer Relationship Center, We are resending our original letter (dated March, 2026), as we have still not received any response or resolution regarding this ongoing recall matter. Since sending that letter, we received a notice stating the recall fix for the battery issue was finally available. Despite the significant inconvenience, we promptly brought our vehicle in to have the repair completed. We were then informed that only ONE of the two critical battery fixes was available and performed — the second, equally critical portion of the recall repair remains unavailable and unresolved. This is unacceptable. We have now been dealing with this issue for well over a year, have complied with every restriction Ford has asked of us, and made yet another trip to the dealer in good faith — only to be told the problem is still not fully fixed. As outlined in our original letter, we are asking Ford directly — not through our dealer, who has been unable to provide answers — for the following: 1.A confirmed timeline for when the remaining battery fix will be available and completed. 2.Confirmation of whether our current high-voltage battery will be fully replaced with an improved unit. 3.A formal response regarding compensation for the 24+ months we have been without full use of our vehicle’s core PHEV functionality — the primary reason we purchased and waited over 8 months for this vehicle. Our original email was sent Marc h 2026 and we have tried email, mailing and calling with no response or resolution. Considering the language of the recall we are very concerned about the safety AND also concerned we cannot use this as the commuter car intended.

Reported

Jun 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The car started and when I went to put it in gear, turns off. Park brake limited function appeared on the dash . The car would not let me put it in gear without turning off. A month prior my dash with the speedometer was blank while driving not allowing me to see my speed . I turned the car off and on three different times. Only after sitting for several hours would the dash info reappear.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2023 Ford Escape. The contact stated that while the vehicle was parked, the engine unexpectedly stated revving at a high rate. No warning light was illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with turbo charger assembly failure. The turbo charger assembly was replaced; however, the failure persisted. The oxygen sensor was replaced, and the vehicle was repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 42,616.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2023 Ford Escape. The contact received notification of NHTSA Campaign Number: 25V789000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the unrepaired recall repair was an inconvenience because the battery could only be charged to 80-percent. The dealer was not contacted. The manufacturer was not contacted. The contact had not experienced a failure.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2023 Ford Escape PHEV. The contact received notification of NHTSA Campaign Number: 26V091000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The local dealer was contacted and confirmed that the part was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced the failure.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

My 2023 Ford Escape is equipped with a factory-installed rearview backup camera system and SYNC infotainment system. Beginning on or around February 2026. I began experiencing a series of recurring, intermittent, and worsening failures with the rearview camera and the Accessory Protocol Interface Module (APIM) that controls it. These failures render the backup camera system unreliable or completely non-functional during vehicle operation. Specific Symptoms Observed •BLUE / BLANK SCREEN: When the vehicle is placed in reverse, the rearview camera display shows a solid blue screen or goes completely blank rather than displaying the rear camera image. This failure occurs with no warning and leaves me unable to see what is behind the vehicle while backing up. •INVERTED / UPSIDE-DOWN IMAGE: The rearview camera image displays upside-down and/or mirrored, rendering the image confusing and unsafe. Guidelines, directional aids, and proximity warnings displayed on screen are also inverted, making them unusable. •DISTORTED / CORRUPTED IMAGE: The camera feed displays visual distortion, artifacts, freezing, flickering, or corruption that makes it impossible to accurately interpret what is behind the vehicle. •APIM FAILURE: The Accessory Protocol Interface Module (APIM) — the core software module controlling the SYNC 3 display and camera feed — has failed or malfunctioned. Dealership diagnosis has identified the APIM as requiring repair or replacement. This module failure is the root cause of the camera display issues described above. The failures occur intermittently and unpredictably. The camera may function correctly for a period, then fail on the next use. In some cases, the failure is persistent across multiple ignition cycles. There is no consistent triggering condition — the defect occurs in varied weather conditions, temperatures, and after varying periods of use. Turning the vehicle off and back on sometimes temporarily restores the camera, but the defect returns.

Reported

Jun 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

2023 Ford Escape with approximately 80,000 miles. While traveling home, vehicle started shifting violently making loud bang. Lost acceleration while traveling on a two-way roadway with no shoulder. Vehicle would shift violently and allow acceleration momentarily and then would again lose acceleration. Just prior to reaching a pull off area in a safe place, the vehicle shifted violently one last time and would no longer accelerate. The service engine now warning light then came on advising of a powertrain malfunction. Vehicle was towed to Ford dealership and the technition reported that the planetary gears were locked up and a full transmission replacement would need to be done. This posed a serious safety issue on the road way due to the initial sudden speed changes becuase of the loss of acceleration and then the complete loss of ability to accelerate causing the vehilce to have to drift slowely to the shoulder while impeding traffic.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Stopped at a Light and took off thru the intersection and car made a loud bang noise then no power and kept bogging out, pulled into parking lot and stopped then car wouldn’t move. Shut car off then restarted it and put into reverse and car drive forward, put in neutral and car still drove forward, couldn’t get it to go into reverse, now the motor is tilting back to fire wall like motor mounts are broke and it’s make a grinding noise when idling.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

[Recurring No-Start Issue with Multiple Warning Alerts – Safety Concern] I am reporting a recurring vehicle issue involving failure to start, which I believe may pose a safety risk. The issue has occurred five times: August 11, 2023 April 12, 2025 June 13, 2025 December 12, 2025 April 1, 2026 During these incidents, the vehicle failed to start and displayed multiple warning messages on the dashboard. On some occasions, the vehicle only started after several hours. The vehicle becomes completely inoperable when this issue occurs. After the third occurrence, I brought the vehicle to an authorized service center. However, the issue was not resolved and has continued to occur. This repeated failure raises serious concerns about vehicle reliability and safety, as the vehicle may become inoperable without warning. I have attached documentation, including repair records and photos of the dashboard warnings. I am submitting this report so that this issue can be properly investigated.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

1.engine failed and my infotainment system turned off 2.i feel like I was scared because I didnt know if I was going to come back on 3. No 4. No

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2023 Ford Escape. The contact stated that while driving at an undisclosed speed, the message "Battery Issue, Pull Over" displayed, and the battery, check engine, and master warning lights illuminated. The contact pulled over and contacted the dealer, who instructed him to turn off and restart the vehicle. After following the dealer's instructions, the failure was resolved. The contact later received notification of NHTSA Campaign Number: 26V091000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the recall but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 28,000.

Reported

May 2026

Incident date

Mar 2025

Mileage

Not provided

Outcome flags

None reported

While pulling into a residential parking space at low speed, the vehicle (2023 Ford Escape) suddenly accelerated unexpectedly without additional throttle input. The acceleration was abrupt and forceful, and I was unable to stop the vehicle before it struck the structure in front of the parking space. The incident occurred at very low speed and under normal driving conditions. The driver was applying the brake at the time of the unintended acceleration. Airbags deployed upon impact. There were no prior warning lights or indications of a mechanical issue before the incident. The vehicle sustained significant front-end damage.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

Crash

The contact owns a 2023 Ford Escape. The contact stated that while attempting to start the vehicle, the radio displayed a blank screen. A dealer was contacted. No warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed. The contact stated that the failure had occurred on several occasions. The manufacturer was not notified of the failure. The approximate failure mileage was 34,756.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The left rear liftgate hinge cover flew off in the car wash during the drying cycle. The same thing has happened to my 2020 Escape and that vehicle is covered under a recall but this 2023 Escape is not. I feel it should be because it has the same issue for the same part.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2023 Ford Escape. The contact received notification of NHTSA Campaign Number: 25V789000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Reported

Mar 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

I am reporting a recurring safety issue involving sudden loss of power while driving in my 2023 Ford Escape. The vehicle has experienced multiple incidents where, while accelerating or pulling into traffic, it suddenly loses power, hesitates, or fails to respond to the accelerator. In some cases, the RPM drops unexpectedly, and the vehicle will not move or respond for several seconds. After this delay, the vehicle may jerk or surge forward suddenly. This creates a dangerous situation, especially when entering busy roads or intersections, as it puts me at risk of being struck by oncoming traffic. This issue has occurred multiple times and has been brought to the dealership on several occasions. The vehicle has undergone multiple repair attempts, including major engine-related repairs such as cylinder head and cooling system work, as well as a fuel system component replacement. Despite these efforts, the problem persists. On multiple visits, the dealership has stated they were unable to duplicate the issue, even though the condition continues to occur during normal driving. The vehicle has been out of service for an extended number of days due to these ongoing issues. This defect is intermittent but poses a serious safety hazard due to the unpredictable loss of power and delayed acceleration. I am concerned about the risk of an accident or injury if this issue is not properly identified and corrected. I am requesting that this issue be investigated, as it appears to be a recurring defect that may affect other vehicles of the same make and model

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Vehicles coolant emptied out causing vehicle to overheat and smoke from under engine.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Reporting Long term safety defect and manufacturer behavior. There was no single incident. This is an ongoing safety defect related to multiple battery recalls that now limit my vehicle to 80% charging (in the past, no plug in charging), now going on nearly three years. My Ford Escape PHEV has been subject to limited charging due to these multiple recalls, and I am concerned Ford may close the recall with a software‑only fix that cannot truly validate battery safety, especially if modeled on limited and not real world charging. I have complied with all of Ford's requests which came at my expense and caused increased fuel usage and a diminished efficiency of my car. Now I need assurance that when a "fix" is determined that it will indeed be a permanent fix that is safe at 100% charge. This is a potentially crucial safety issue and thermal consequences with my grand daughters sitting above the battery is of the greatest concern.

Reported

Mar 2026

Incident date

Nov 2023

Mileage

Not provided

Outcome flags

None reported

My vehicle has stalled several times in the last couple of months. I go to accelerate and the vehicle suddenly stops out of no where. This has almost caused me to get into an accident. I see there have been several recalls on ford escapes and this issue should be looked into for my 2023 escape.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

My 2023 Ford Escape acts like it is about to stall out once I hit the gas from a stop. It has happened multiple times. After idling for 10 minutes when I go to take off it will shift so hard that it pushes you forward in your seat. It has not been taken to a dealership yet since no light comes on and it doesn’t happen all the time. It has put my safety at risk since I was turning on the highway and it took 10-15 seconds to get up to speed.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The engine shut off and immediately turned on

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

Symptoms appeared in January 2026. Check engine light is on-HAD P0301 & P0316. Ran misfire monitor & Relative compression and cylinder 1 is the issue with 70 PSI. Performed cylinder head leak down test- exhaust valve leaking replace cylinder head assembly. Problem confirmed and diagnosed by Ford dealership. The safety issue associated with the car are: sudden jerking or hesitation, loss of acceleration when merging or crossing traffic, unpredictable throttle response, sudden loss of power. Symptoms appeared in September 2025. In October 2025, the car required a turbo repair, which cost a total of $1,600. The safety issue associated with the car are: air-fuel balance, engine misfires, complete stall, loss of power. This was diagnosed by certified repair show. Similar recalls have been made to other Ford Escape cars and I believe my VIN number should be included.

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

I have had many issues with this vehicle. Most concerning is that the other night while driving down the road at night, my car blacked out and I had no lights inside or headlights outside while driving in the dark. My back hatch button only works when it wants to. My screen freezes every once in awhile and also makes horrible noises very frequently. I’ve had one case of my screen freezing on a longer drive with my seat warmer on and the seats getting too hot and burning me. My safety features shut off all the time. My cruise control wouldn’t work at all on a 4 hour drive last month. When I get my oil changed they tell me under my hood is way louder than it should be for a vehicle this old. The dealership did a factory reset hoping it would help but I’ve already had issues with the hatch door not working appropriately, the sound coming from my screen, and notifications that my safety features have been shut off.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

My ford escape has an ongoing safety issue where the instrument cluster shuts off while driving and the dealership has not been able to fix it.

Reported

Feb 2026

Incident date

Jul 2024

Mileage

Not provided

Outcome flags

None reported

I drive a 2023 Ford escape active, 8F35 transmission, with 111,114 miles on it. I purchased my car in July 2025 from truauto of Ladson SC with 93,000 miles on it. Had a transmission complete failure in December 2025 (5 months after buying). Ford dealership in Valdosta Georgia (where I lived) was no help in trying to get it fixed and it sat on there lot for a months or so, because it was undriveable. I got it towed back to SC to get it fixed by a local transmission shop and it is being halted due to a current planetary lawsuit with these cars for parts. I have now been without a car for 2-3 months and have forked over $6,000+ to get this car fixed. I was not told about any known transmission issues when I bought this car (verbally or written) from Truauto, nor was I contacted about any recall from Ford and I was denied a Remanufactured transmission at the dealership that I went to to get the car fixed. I am out of warranty but that still doesn’t explain a transmission failure in a close to brand new car regardless of miles. I have already paid the $5400 or so for the repair at the local shop and it has yet to be fixed due to lack of availability of parts.

Reported

Feb 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2023 Ford Escape. The contact stated that on several occasions, while stopped, while the accelerator was depressed, the vehicle hesitated while accelerating. The contact was almost rear-ended several times when the failure occurred. The contact stated that whenever the vehicle idled for longer than five minutes, the vehicle also hesitated while accelerating. The vehicle was taken to a dealer; however, the failure could not be duplicated. The manufacturer was not notified of the failure. The failure mileage was approximately 3,000.

Reported

Feb 2026

Incident date

Jan 2024

Mileage

Not provided

Outcome flags

None reported

The transmission failed at 70,000 miles. The research the transmission shop did indicated the main bearing fails in these because they are made of cheap metal. The transmission just stopped pulling with little warning. It started with a jerking and then quit pulling. Within a few feet. There was not any slipping of the transmission before hand.

Reported

Feb 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Purchased brand new 11/2023, immediately started with electrical problems 01/2024, also would put car in reverse and car would cut off, was dropped off at service but never given a reason for the issue or a repair. 01/2025 car had acceleration issues, dropped off at service and was given a rental and given car back with no explanation. 6/2025 car went into limp mode and was towed to service where they found shards of metal throughout motor, replaced motor and then started having problems with cab filling with exhaust, was told they had no rental available and could continue to drive the car with my baby in it, then told was just a gasket needed to be replaced, car had same issue immediately, returned back to service where the turbo then needed to be replaced as well as catalytic converter gasket, after repair, called numerous times complaining that car would shift very hard and wouldn’t accelerate while driving or pulling out on an intersection or from a stop light, was told valve body needed to be replaced, then check engine light came on immediately after pickup, returned car and purge valve needed to be replaced, after pickup issue of car not accelerating continued, was told no issue found, car acceleration issues has became worse and now have been told soonest available appointment and rental is 02/12/2026.

Reported

Jan 2026

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

Rearview Camera Has turned dark....

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

i found the brake pedal too high.i was involved in a very low speed crash. i found my right foot caught between the accelerator and break peddle .unable to stop in time. am checking for a video and police report at this time

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

Crash

I was driving on a very flat highway (no other cars around me) and it sounded like an explosion and glass rained down the back of the car. When I get to my destination, I looked at my roof and the sun roof glass had exploded.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

The contact owned a 2023 Ford Escape. The contact stated that the infotainment center would display a black screen, and while doing so, the radio would continue to play. The contact stated that while driving at different speeds, the trunk would suddenly open, causing the contact to have to pull over and close the trunk in order to continue to drive. The failure occurred 3 times while the vehicle was parked at home. There would be a burning odor emitting from the vehicle intermittently; however, there would be no smoke or indication of where the smell was coming from. While parked at home and unoccupied, the rear window suddenly shattered, and the vehicle caught on fire. The fire department was called and extinguished the fire. The fire department and the insurance company had determined the vehicle would be totaled; however, an official determination had not been provided. A police report was filed. The dealer was informed of the failure. There were no injuries or medical attention needed. There was no damage done to the property. The manufacturer was informed of the failure. The failure mileage was approximately 37,000.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

Fire

HI, Vehicle is under a second recall for the High Voltage Battery potential fire hazard. The first recall lasted 7 months before a potential fix. The second recall was issued in November with no fix available yet. Received second recall identical to first recall indicating a fire risk with no apparent fix. I have requested Ford buyback the vehicle, but it fell outside the 18 month NYS Lemon Law. They have refused. They have no fix and will not provide a loaner until it is fixed. The original vehicle electric range was between 38 and 40 with a window sticker range of 37. It is now down to around a range of 20 on full charge with an actual driveable of about 16. I have asked both Ford and delivering dealership to replace the High Voltage Battery pack as it has seriously deteriorated. Ford refuses to allow dealer to replace the Battery Pack. The vehicle is basically unusable for it's original intended purpose as a partial electric vehicle. I asked Ford, what am I supposed to do if I am transporting my two grandchildren in the vehicle and it starts on fire. How do I choose which child to get first? No response. These vehicles should be removed from use by Ford and loaner vehicles provided or a full buy back should take place. I only have 11,000 miles on this vehicle and it has been in the shop for more than 30 days for various warranty repairs and multiple recalls. These vehicles are not safe. See pictures attached for factual information from vehicle. I have plenty of detail if you need it. Please help. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Accessory protocol interface module went out screen went dark. No recall on my vin but should be. Problem appeared 12/26/2025 and has been inspected by Peach State Ford.

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The transmission had an internal failure that caused metal fragments to end up in the transmission fluid and caused failure. The vehicle will not drive and required the transmission to be rebuilt

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

My 2023 Ford Escape Plug-In Hybrid has experienced repeated high-voltage battery safety issues and prolonged loss of intended function. In February 2025, Ford notified me under recall 24S79 that I must immediately stop charging the vehicle due to the risk of internal battery cell short, potential battery thermal venting, and fire. That “do not charge” instruction lasted approximately six months, eliminating the core plug-in hybrid functionality of the vehicle. Ford originally stated the remedy would be available in Q2 2025, but the repair was not completed until late August 2025. The recall documentation stated that an internal battery cell short could cause the “Stop Safely Now” warning and sudden loss of motive power, which presents a serious safety risk while driving, especially when transporting my family. During the “do not charge” period the vehicle’s plug-in hybrid capability was unusable, and Ford acknowledged the risk of fire and loss of power. In November 2025, I received a new high-voltage battery recall 25SC4 (NHTSA 25V789) for the same general hazard category (internal short, potential fire, loss of motive power). The new recall states that no remedy is available at this time. This means the vehicle is again subject to a serious unresolved safety defect involving the same critical system. The repeated battery failures and the absence of a current fix create an ongoing safety concern, and the vehicle cannot be reliably used or sold during this open recall with no remedy. I am requesting NHTSA review the repeated HV battery defects, extended loss of plug-in hybrid functionality, delayed first recall remedy, and the current “no remedy available” condition, and assess whether further investigation or corrective action is needed for these vehicles.

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Purchased the vehicle approximately 45 days ago. Has driven fine with no problems. Randomly had a hard down shift and when I went to leave my destination put the vehicle in reverse and it would not go. The vehicle would not move in drive and when put in neutral it was still not even able to be pushed. Had it towed to the nearest ford dealership, they diagnosed that there were metal shavings in the transmission, stated the vehicle was no longer drive able and recommend a transmission replacement or rebuild. Vehicle only has 80,000 miles.

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2023 Ford Escape. The contact stated that the 12-Volt battery had become inoperable. The contact stated that the vehicle lost motive power while attempting to start the vehicle. There was no warning light illuminated. The contact had to charge the battery several times to start the vehicle. The vehicle was taken to the dealer, but was not diagnosed or repaired. The contact was informed that the issue was battery-related and was advised to drive the vehicle differently and to obtain a trickle charger for the battery. The manufacturer was not made aware of the failure. The approximate failure mileage was 8,000.

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

During braking the car experienced what seemed to be a glitch and lost all breaking power. Foot went to the floor and had to press and release multiple times for break power assist to come back. This happened three times within 100 mile drive.

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

my 2023 ford edge caused burns to the back of my legs. i was unaware until my grandma informed me that something was wrong with my legs. i noticed when i got the car 2 months ago level 3 of the seat warmer was way to hot like i felt it burning. so i only used on setting 1 or 2 and did not feel the burning sensation like when used on 3 but somehow my legs are burned

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

Sunroof molding roof drip rail. Ford part #LJ6Z5450036A. This part is held on with double stick tape. When it comes loose, it can interfere with the proper operation of the sunroof sunshade or fall into the passenger compartment. Mine has been replaced several times under warranty. Even though it was nearly detached, it did not fall. However, if it had, it has the potential of either damaging the sunshade or creating a driver distraction while driving.

Reported

Aug 2025

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

Campaign 23B56 Description Inspect front door check-arm reinforcement spot welds Next Steps Contact your dealer for next steps. ---------------------------------------------------------------------------------------------------------------- Recall Action Soon Issue Since 03-14-2025 Drivers side seat buckle replacement For More Information Telematics Generated Issue Recall Action Soon Issue Since 11-08-2024 Inspect front door check-arm reinforcement spot welds For More Information

Reported

Jul 2025

Incident date

Mar 2025

Mileage

Not provided

Outcome flags

None reported

Recall Action Soon Issue Since 03-14-2025 Drivers side seat buckle replacement For More Information Telematics Generated Issue Recall Action Soon Issue Since 11-08-2024 Inspect front door check-arm reinforcement spot welds For More Information

Reported

Jul 2025

Incident date

Mar 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2023 Ford Escape. The contact stated while driving at various speeds with the Adaptive Cruise Control Mode engaged, the vehicle failed to respond as needed after another vehicle pulled in front of the vehicle. The contact stated that the vehicle jerked and decelerated, and then revved up and accelerated unintendedly until the vehicle was within proximity of the other vehicle. Additionally, the contact stated that the Lane Keep Assist failed to keep the vehicle within the intended lane while driving, and the vehicle veered to the left unintendedly while the Lane Keep Assist was engaged. The vehicle was taken to the dealer to be diagnosed, but the cause of the failure could not be determined. Additionally, the dealer informed the contact that the vehicle was previously repaired under NHTSA Campaign Number: 24V440000 (Forward Collision Avoidance), which the contact related to the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 98,000.

Reported

Jun 2025

Incident date

Sep 2024

Mileage

Not provided

Outcome flags

None reported

For the last 2 weeks After accelerating my engine coolant overheat warning light goes off and i can't accelerate any further until light goes off. Also ford mechanic states there is metal shavings in the coolant that might be causing engine to overheat on top of the sensor issue.

Reported

Jun 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.

Risk: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.

Ford Motor Company (Ford) is recalling certain 2023-2025 Escape, and 2025 Bronco Sport vehicles. The cylinder head may have been improperly manufactured, which can cause the ball plugs to fail, resulting in an oil leak.

Risk: An oil leak can result in loss of drive power, increasing the risk of a crash. In addition, an oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

Remedy: Dealers will replace the cylinder head assembly as necessary, free of charge. Owner notification letters were mailed August 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S61.

Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.

Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

Ford Motor Company (Ford) is recalling certain 2020-2023 Escape and 2021-2023 Bronco Sport vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.

Risk: A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

Remedy: Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Interim owner notification letters informing owners of the safety risk were mailed January 9, 2023. Remedy parts are expected to be available in 1st Quarter of 2023. Owner notification letters were mailed February 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S73. This recall includes all vehicles previously recalled under 22V-191. Vehicles previously remedied under 22V-191 will need to have the new remedy performed.

Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2022-2023 Maverick, and 2021-2023 Corsair vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.

Risk: An engine compartment fire increases the risk of injury.

Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will replace the engine long-block in 2023 Escape and Corsair vehicles. For the other vehicles, dealers will update the powertrain control module software. If a connecting rod bearing failure is detected, dealers will replace the engine long-block. All inspections and repairs will be performed free of charge. Owner notification letters were mailed on June 14, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S27. This recall expands and replaces recall number 22V-484. Vehicles previously repaired under 22V-484 will need to have the new remedy completed.

Ford Motor Company (Ford) is recalling certain 2023 Escape, Super Duty F-250, Super Duty F-350, Super Duty F-450, and Super Duty F-550 vehicles equipped with a digital instrument panel cluster. The module may have been improperly soldered, preventing the instrument panel from illuminating. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."

Risk: An inoperable instrument panel cannot show critical safety information, such as the speedometer or warning lights, which may increase the risk of a crash.

Remedy: Dealers will replace the module or instrument panel as necessary, free of charge. Owner notification letters were mailed on November 4, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C25.

Ford Motor Company (Ford) is recalling certain 2023-2024 Escape two-wheel drive vehicles equipped with adaptive cruise control. The cruise control radar module was misaligned during production.

Risk: Misalignment of the radar module can result in the Adaptive Cruise Control (ACC) misclassifying an overhead object as an object in the vehicle's path, causing the vehicle to unexpectedly slow and/or stop. Other safety systems that depend on the radar model (Pre-Collision Assist, Forward Collision Warning, and Auto Emergency Braking) could have diminished or lost function. These conditions increase the risk of a crash.

Remedy: Dealers will adjust the angle of the radar module, free of charge. Owner notification letters were mailed July 3, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S39.

Ford Motor Company (Ford) is recalling certain 2023 Lincoln Corsair, 2023-2024 Escape, 2024 Mustang, and 2025 Explorer vehicles. The fuel injectors may have been assembled without O-ring support discs, which can result in a fuel leak.

Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Dealers will install new fuel injector O-rings and O-ring support discs, free of charge. Owner notification letters were mailed on October 7, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S54.

Ford Motor Company (Ford) is recalling certain 2020-2024 Ford Escape, and 2021-2024 Lincoln Corsair vehicles. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.

Risk: Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.

Remedy: Owners are advised not to charge battery till the remedy has been completed. Dealers will perform a battery energy control module (BECM) software update, and replace the high voltage battery pack, as necessary, free of charge. Owner notification letters were mailed on May 30, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S79.

Ford Motor Company (Ford) is recalling certain 2024-2025 Lincoln Nautilus, 2023-2025 Escape, 2023 Lincoln Corsair, 2025 Lincoln Corsair, Maverick, and Bronco Sport vehicles equipped with a 1.5L or 2.0L MPC engine and an engine block heater. The engine block heater may overheat when the vehicle is parked with the block heater plugged in.

Risk: An overheated engine block heater can increase the risk of a fire.

Remedy: Dealers will replace the block heater element and inspect the electrical cord, replacing it if necessary, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug coupled, and remove the block heater electrical cord. Owner notification letters were mailed June 9, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S52.

Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.

Risk: An engine compartment fire increases the risk of injury.

Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S54.