2021 Ford Escape

Complaint to the National Highway Traffic Safety Administration (NHTSA) I am filing this complaint regarding an unresolved safety recall on my vehicle. This recall has remained open for more than one year, yet no remedy has been made available. Despite the manufacturer acknowledging the safety defect, I continue to operate a vehicle that presents significant safety concerns because the defect has not been corrected. The recall has caused my vehicle to experience severe drivability issues, including engine failure, excessive rough idling, and violent shaking while the vehicle is operating. These conditions create an increased risk of the vehicle stalling unexpectedly, reducing my ability to safely operate the vehicle and placing myself, my passengers, and other motorists at risk. Additionally, because of the unresolved recall condition, my vehicle is unable to pass the required state safety inspection. This has left me with a vehicle that I cannot fully utilize or register while I continue waiting for the manufacturer to provide a repair. It is unreasonable for consumers to wait more than a year for a safety recall remedy while continuing to experience hazardous operating conditions. I respectfully request that the NHTSA investigate the manufacturer’s failure to provide a timely remedy, determine whether it is complying with its obligations under federal motor vehicle safety laws, and take appropriate action to ensure affected owners receive a prompt repair or other appropriate relief. I have retained documentation regarding the recall, the symptoms affecting my vehicle, and the impact this unresolved defect has had on my ability to safely operate and maintain the vehicle. I am prepared to provide this information upon request.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

Seatbelt locks in position on the passenger side. Must stop car let seatbelt retract all the way and reattach seatbelt. Dealer wanted $225 to diagnose problem if they could not find and/or duplicate issue.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

After picking my vehicle up from a day and a half of recall repairs, I immediately experienced a rubbing sound and a shuddering when I turned my wheels to the right and moved forward as I attempted to drive away from the parking space. There were no issues when turning the wheels to the left to back out of the parking space. I immediately pulled into the service bay to report the problem. A maintenance tech came out and asked to drive it. When the vehicle was returned, I was told they felt it was the rear differential but would need to schedule another appointment so they could listen to it more, at a cost of $130 to diagnose. I researched this issue and found out that a recall has been issued for a different lot of VINs for 2021 Ford Escapes for this same issue due to installation errors or incorrect lubrication.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

Subject: Formal Complaint – Recall 23B56 & 23S27 + Rental Car Reimbursement Demand – McCombs Ford (7111 NW Loop 410) To Whom It May Concern, I am writing to file a formal complaint regarding the unacceptable service I experienced at McCombs Ford West, located at 7111 NW Loop 410, San Antonio, TX, concerning two open safety recalls on my 2021 Ford Escape, VIN: [XXX] and to formally request reimbursement for out-of-pocket expenses caused directly by the dealership's failure to prepare for my scheduled appointment. I scheduled a service appointment in February 2026 to address two outstanding safety recalls: •Recall 23B56 – Inspect front door check-arm reinforcement spot welds •Recall 23S27 – Underhood fire risk After waiting nearly five months, I was given an appointment on July 7, 2026. I dropped off my 2021 Ford Escape on July 7, 2026 as scheduled. At drop-off, I was informed the repairs would take multiple days, and I was told no loaner vehicle would be provided. Based on that, I rented a vehicle at my own expense to cover my transportation needs. The following day, I received a call from the service department informing me: 1.Recall 23B56 (Door Reinforcement): The dealership was unable to perform the repair because they had never ordered the required replacement door — despite having five months' notice from my original February 2026 booking. They stated they would "order it now." This is entirely unacceptable and reflects a clear failure of basic service planning. 2.Recall 23S27 (Underhood Fire): The dealership refused to perform Supporting documents attached : McCombs Ford service reference document & rental car invoice ($43.92) Reference details /dealership : MCCOMBS. 7111 N.W. LOOP 410 SAN ANTONIO, TEXAS 78238 (210) 509-1000 VIN: [XXX] 23S27 UNDER HOOD FIRE 26S14 FRONT WIPER MOTOR REPAIR 23E09 REPROGRAM POWERTRAIN CONTROL MODULE 23B56 INSPECT FRONT DOOR CHECK-ARM REINFORCEMENT SPOT WELDS 23N06 LONG BLOCK REPLACEMENT INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

My car was at only 55,000 miles, there was a weird shuddering and my RPMs were very jumpy. It almost felt like my car was going to stall out. I took it in to the ford dealership and I had to get my Torque Converter replaced. I had no dash lights on or any other problems. I got it replaced, but my car still feels shaky while at low speeds. Apparently it’s a very common problem in this car.

Reported

Jul 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

See attached document for complaint.

Reported

Jul 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

This car is constantly sputtering and when you give it gas to take of, it sputters as if it is going to stall. This poses a safety concern when you are giving the car gas and it is not properly accelerating. I was almost hit several times now. The check engine light is on, the wrench is illuminated and I keep getting an AWD/power train message, as well as a battery saving mode message. Then soon after this started, all the audio in the sound system is gone.

Reported

Jul 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Escape. The contact received recall notifications for NHTSA Campaign Numbers: 25V467000 (Fuel System, Gasoline) and 26V117000 (Visibility); however, the parts required to complete the recall repairs were not yet available. The contact called the local dealer and left a voicemail message, but the contact had not received a return call. The manufacturer was not contacted. The contact had not experienced a failure.

Reported

Jul 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

On XXX, the 8F35 transmission in my 2021 Ford Escape experienced a critical failure, characterized by severe slipping and a violent shuddering condition while operating at speed. This sudden loss of predictable power and drivetrain stability directly compromised my ability to safely operate the vehicle in traffic, creating an immediate highway safety hazard for myself and others. The vehicle was towed to an independent service center, Brownie’s Independent Transmission Shops ([XXX]), where technicians inspected the vehicle and confirmed a total internal failure along with a defective torque converter. Resolving this manufacturing defect required a complete transmission replacement and overhaul. The repair required a total out-of-pocket expense of $8,275.77 (with $8,236.97 directly tied to the transmission failure defect). I paid this balance in full across two installments: a $3,500.00 down payment on XXX, and a final balance of $4,775.77 on XXX. Prior to the sudden failure on XXX, there were no preceding dashboard warning lamps or long-term symptoms—the severe shuddering and loss of acceleration occurred abruptly. Ford Motor Company is internally aware of this defect, having issued Special Service Message (SSM) 54939, which explicitly documents a known "shudder condition" occurring within the 8F35 transmission spanning 2020–2026 Ford Escapes. Despite this awareness, Ford has failed to issue a safety recall. I have uploaded the complete itemized diagnostic notes and proof of payment receipts under the file name "Transmission Invoice and Receipts.pdf INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jul 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

The vehicle stutters on acceleration. This causes issues when at intersections or when merging into traffic. I have since replaced the torque converter that has resolved the problem.

Reported

Jul 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

This vehicle has had transmission slipping issues since I bought it. I had the PCM flashed and reset but it still jerks and slips out of gear ALL the time. The car actually stalled on me while turning through an intersection. This almost cause me to be t boned via a car crash. The transmission has already been replaced and still malfunctions. When it stalled there were no lights and the car would not go into neutral unless you pulled the emergency latch for it. This is a HUGE safety issue and from what I read a lot of people are having the exact same problem. Ford is just giving me the run around and my local dealer literally acted like he didn't know what I was talking about when I mention the new service bullentin. This transmission has clearly been an issue since the vehicle was new according to service records. The fact that ford isn't reaching out to people is nuts to me. They are also saying it may be over miles for the work to be covered. I really don't understand that as the transmission was replaced with only about 75000 miles on it. That's not normal. They are not honoring any work on an item they built poorly.

Reported

Jul 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

transmission bucking jerking lurching at low speeds. dangerous in stop and go traffic. hard 3rd gear shift. ford refused to remedy.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Transmission shifts hard, jerking, stuttering when pushing the accelerator. Continues to go into limp mode when driving highway speeds.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The sunroof cover has come off its tracks and has lost tension. It requires a full sunroof cover replacement. Upon searching this issue online, I found it was a common issue in Escapes around 2020-2022.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Escape. The contact received notification of NHTSA Campaign Number: 26V117000 (Visibility); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

Reported

Jun 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Escape. The contact received notifications of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline), 26V123000 (Back Over Prevention), and 26V117000 (Visibility); however, the parts to do the recall repairs were unavailable. The dealer was not contacted. The manufacturer was not contacted. The contact had not experienced a failure.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

After a couple days of rain my 12V battery died, when I went to replace it I found the removable carpet in the trunk area was saturated with water throughout and was growing mildew and what appeared to be mold. The old battery was replaced and disposed of. My safety was not at risk as the car was parked. This problem has not been reproduced or confirmed by a dealer. No components were inspected. There were no warning lamps or signals, but I did smell an odd musty order sometimes.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Rear passenger window failed two different times, we have gotten it fixed. Now today the rear driver window will not go up or move.

Reported

Jun 2026

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

Passenger rear window would not go up, we got it fixed. We also have a second 2021 ford escape with the same problem.

Reported

Jun 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

following up on Nov 20,2025 Manufacturer Recall Number25SC4 NHTSA Recall Number25V789 Recall StatusRecall Incomplete, remedy not yet available This recall has been out for 7 months - no remedy yet. We are not able to use our PHEV to the extgent is was designed.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Escape. The contact received notification of NHTSA Campaign Number: 25V467000(FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The contact stated that the vehicle had experienced difficulty starting and hesitation upon acceleration. Additionally, the check engine warning light was persistently illuminated. The local dealer was contacted, and it was confirmed that the part was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was 70,000.

Reported

Jun 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Escape. The contact received notification of NHTSA Campaign Number 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

Reported

Jun 2026

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

On XXX I was driving my 2021 Ford Escape for 10 minutes before I stopped at Sheetz gas station on [XXX]. I ran into the building to withdraw cash from the ATM leaving my fiance and dog in the car while it sat idle. Upon exiting the building about 30 seconds to a minute later, I witnessed smoke coming up from the hood of my car. My fiance and Dog quickly evacuated the car as we saw flames emerging. I ran inside to get assistance from the workers and they brought out fire extinguishers. The attempt to extinguish the flames was unsuccessful and the front of the car quickly went up. Police and fire department were called and they showed up about 10 minutes later to handle the situation. Reports from the officer, fire department and the Sheetz assistant were taken. I do not have access to those. My car insurance is covering the cost of the vehicle and a 7 day car rental. They are not covering the loss of both mine and my fiance's cell phones. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

Fire

When the brake is applied, the gas pedal accelerates. It has happened 2 times and I could have went through a stop sign or traffic light. The tool light came on but went off. This has happened a few times starting in April.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The panoramic sunroof cover shade completely detached from the side tracks and the rear roller mechanism failed. When the shade is fully closed, it just sags on the sides and lets light beams leak through. The actual safety issue happens when you press the button to retract it fully away. Instead of rolling up into the headliner like it is supposed to, the fabric folds up and hangs down at the back. It creates a huge flap of loose fabric hanging all the way down to the back seat headrests, which completely blocks the view through the back glass window and eliminates rear visibility while driving. The component is available for inspection upon request. The problem has not been inspected by a dealer or independent shop yet, and there were no warning signs or symptoms before the failure happened.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

My windshield wipers aren’t working properly and it causes me to not be able to see while driving which cause me to hit a curb and damage my front fender and my trunk makes a nose when I drive like it wants to pop open my car flashes warnings and then no sign of issues

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

There is a cover over the bar that divides the sunroof that has come off. This is only held on with two-sided tape. It will not stay in place. After investigating this on-line, it is recommended not to move the shade without this cover in place - the bar (without the cover) could damage the fabric on the shade. This bar fell while my children were sitting the in back seat, while they were not hurt, they could have been. I have not taken this to a service center but I have seen many Ford Escape owners on-line that have complained of this problem happening. I have pictures but this page will not let me upload them.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Escape PHEV. The contact received notification of NHTSA Campaign Number: 25V789 (Electrical System); however, the part to do the recall repair was not yet available.  The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

What component or system failed or malfunctioned, and is it available for inspection upon request? - Transmission. Codes pulled read P0751 and P0752. "Shift Solenoid 1 stuck open/closed". Yes, it is available for inspection. How was your safety or the safety of others put at risk? - I was driving in active traffic through a roundabout when the vehicle suddenly jolted, the seized. At the time, my two young children were in the vehicle. I narrowly avoided a collision due to another vehicle swerving around my vehicle. Has the problem been reproduced or confirmed by a dealer or independent service center? - Yes. I took the vehicle to Mark Grainger's Quality Service Center, Rincon Transmission, and the J.C. Lewis Ford dealership, which all reproduced and confirmed the issue with coresponding error codes P0751 and P0752. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? - Yes. Mark Grainger's Quality Service Center told us the transmission work required was beyond their scope. They sent us to Rincon Transmission. Rincon Transmission told us they'd never serviced that engine before and said they'd prefer the work to be done by a Ford dealership. J.C. Lewis Ford told us a new transmission was required, but wouldn't produce results of any testing to verify that verdict. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? - No. Not at the time of this incident. A CEL previously indicated a fault O2 sensor, which was then serviced by the J.C. Lewis Ford dealership.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Escape. The contact received notification of NHTSA Campaign Number: 26V117000(VISIBILITY); 25V467000(FUEL SYSTEM, GASOLINE); 26V123000(BACK OVER PREVENTION); however, the part to do the recall repair was unavailable. The local dealer was contacted and it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced the failure 39,000.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

My daughter owns a 2021 Ford Escape FWD equipped with the 1.5L turbocharged EcoBoost inline-3 engine, VIN [XXX] , with approximately 95,000 miles. The vehicle has been serviced almost exclusively by Ford dealerships and maintained in accordance with manufacturer recommendations. The vehicle recently began exhibiting significant drivability and transmission-related problems, including shuddering while driving, hard shifting, RPM surging/revving, hesitation during acceleration, and erratic transmission behavior. The vehicle has hesitated in traffic, creating a significant safety concern. No warning lights or diagnostic alerts were displayed prior to diagnosis. On May 26, 2026, the vehicle was taken to [XXX] Ford, [XXX] , for a routine oil change and completion of open recall repairs. At that time, the transmission-related symptoms were reported to the Ford service department. The dealership performed a road test with a data logger and diagnosed the issue as: “Torque converter slipping causing shudder / bump while driving.” The dealership recommended the following repairs: Replacement of the torque converter Transmission line flush Replacement of transmission fluid Retesting after repair The quoted repair estimate was approximately $4,500. The Ford service advisor stated that the repair did not necessarily have to be completed immediately, but also warned that the condition could worsen and leave the driver stranded. This presents a serious safety concern. A vehicle experiencing transmission shuddering, torque converter slippage, hesitation, hard shifting, and erratic RPM behavior can experience loss of propulsion, delayed or inadequate acceleration, unpredictable drivetrain response in traffic, inability to safely merge or clear intersections, and stranding in unsafe conditions. Given that the vehicle has been routinely maintained, no warning lights were provided to alert the driver, and similar complaints INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

THIS FORD 2021 ESCAPE HAS A SERIOUS TRANSMISSION SHUDDER. IT RELIABLY WILL DO IT AT APPROX 13-15 MPH. APPROX 27-30 MPH. ABOUT 33-35 MPH. THE RATTLE, SHUDDERING ACTS AS IF THE TRANSMISSION IS GOING TO DO SOMETHING DANGEROUS. WITHOUT ANY HESITATION, THE TRANSMISSION WILL SHAKE, SHUDDER, VIBRATE. IF YOU KEEP SPEED STEADY, FOR INSTANCE 17 MPH, IT IS SCARY, AND WILL KEEP SHAKING AS LONG AS CAR IS AT A PARTICULAR SPEED. THE FORD DEALER WHERE IT WAS PURCHASED SAYS NO RECALLS, ALTHOUGH THEY ADMIT VIBRATION ISSUES IN THESE MODELS.

Reported

May 2026

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

Nothing malfunctioned. All I was asking for was a fender to hood adjustment and the dealership kept telling me they don't do that and that I would need to go to a bodyshop. The fender to hood alignment issue didn't put others at risk. What the problem is is the door is not aligned based on OEM requirements and the recall repair was completed but not done correctly. The problem has been identified by the dealer. The vehicle has been inspected by the manufacturer. No warning lights or anything. Simply dealership refusing to get my door realigned. After taking it to body shop 3 times and still this problem has not been fixed. This is unacceptable especially since it was a recall through the manufacturer. Also when I asked dealership for proof in writing that they don't do their own bodywork the service advisor told me no. That is also unacceptable. I should be given my proper recall documentation whenever I ask for it.

Reported

May 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Windows and engines

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

Crash

Hello I am so sick of the recall on the high voltage battery. When I first got in in april of last year it had 126 miles on it and was told by [XXX] at the time and ford Auffenburg used cars that it had no recalls at all. Low and behold months later after charging the plug in portion found out there was a recall and I couldn't plug it in which was the reason I bought it. So I had no choice mostly it was sitting until I had to travel for funeral services not local to me. Then there was a fix for the recall only to find out its a software patch they don't replace the battery knowing there is a defect in the high voltage battery confirmed. So now the same issue just new number there is a second recall on it again and not to plug it in. Since then it has 138800 on it now. because I have to get some where but I stay local. At this point I just want a buy back I am tired of dealing with it and now there are two more recalls concerning a wiper motor and something to do with sync screen update. I can't afford to have them contstantly diagnose this issue. I am tired of trying to deal with auffenburg in general on these issues I had to get them to program the computer just to do emmisions in illinois. All I want it a buy back so I can pick something else. The first recall was 24S79 Now its 25SC4/25V789 This car has been nothing but recall on the high voltage battery. It's a bad safety issue and really want to get rid of it. Thee have been a few times taking it down the street I lost power in hybrid normal running mode. It's just scary I had no control in the wheel INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Sunroof shade came off track while driving and I had to hold it the whole way home so I could see out the back window to safely drive. Upon research I found this is a common defect on the escapes and ford has done nothing to prevent this. Repairs cost thousands of dollars and this is not ok. This needs to be a recall to be fixed for all escapes affected.

Reported

May 2026

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Escape. The contact received notification of NHTSA Campaign Number: 25V789000 (Electrical System) and 26V123000 (Back Over Prevention) and 26V117000 (Visibility) however, the part to do the recall repair was not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that the remedy parts were not yet available. The manufacturer was not made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The panoramic sunroof shade disconnected from the clips that holds it in place to allow it to be opened and closed. It is now rolled up in the car so the sunroof is always exposed and cannot be reconnected without a full replacement according to the dealership. It can impact visibility in bright sunlight.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Escape. The contact stated that while reversing out of the driveway, the vehicle suddenly shut off and failed to start. The vehicle was towed to the dealer, who diagnosed that the fuel injector had failed. The vehicle was repaired. After having the vehicle repaired, the contact received notifications of NHTSA Campaign Numbers: 25V467000 (Fuel System, Gasoline), 25V829000 (Structure), 26V123000 (Back Over Prevention), and 26V117000 (Visibility); however, the parts for the repairs were unavailable. The contact stated that when idle and attempting to acclerate the vehicle would jerk forward. The vehicle would jolt forward and shake when transitioning from 2nd to 3rd gear at various speeds. Whistle noises were coming from near the liftgate. The contact was experiencing hard shifting. There were no warning lights illuminated. The contact stated the manufacturer had exceeded a reasonable amount of time for the remedy to be available. The vehicle was taken to the dealer to change the transmission fluid, but they were told that the transmission was damaged and needed to be rebuilt. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was 79,845.

Reported

May 2026

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

Canister purge valve getting stuck open and causing a hard start

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

I am filing this safety complaint on behalf of myself and my wife, [XXX] , the primary driver of our 2021 Ford Escape PHEV, with active under Recall 25SC4 (no remedy available). The vehicle has experienced 8+ sudden complete shutdowns during normal driving since February 2026, always during EV-to-hybrid mode transition, always without prior warning. The only warning is a brief sound like air escaping immediately before shutdown. At shutdown: engine cuts completely, steering wheel locks rigid and cannot be turned, brake pedal locks hard and cannot be depressed, gear selector locks in Drive and cannot be changed. The driver has zero ability to steer, brake, or move the vehicle. Must activate hazards and wait 1-5 minutes for restart while immobilized in an active traffic lane. Incidents occurred: (1) February 2026: multiple times, dealer retained vehicle 5 days, found nothing. (2) Early April 2026: multiple times, including one witnessed by a police officer who directed traffic around immobilized vehicle. Dealer kept 3 days, blamed the original Ford-supplied charger. Replacement did not fix defect. (3) May 1, 2026: 4 times in one day with my wife only in the car, including on the Dolphin [XXX] near Miami Int [XXX] 3:30PM Friday rush hour, with our [XXX] child in the vehicle on thr [XXX] r occasions. Ford's own recall documentation states steering and braking remain functional during shutdown. This is directly contradicted by our firsthand experience. Both are completely inoperable. Dealer on second attempt blamed original Ford-supplied charger — replacement did not resolve defect. This vehicle is subject to active class action [XXX] et al. v. Ford Motor Company (Case XXX). Formal warranty demand letter sent to Ford Motor Company via certified mail under Magnuson-Moss Warranty Act simultaneously with this complaint. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Vehicle headlights constantly dimming in and out, replaced alternator and battery, problem still persisted if not worse than before. Vehicle constantly struggles to accelerate once at running temperature, high revs and doesn't accelerate at all, vehicle experienced complete power loss after approaching red light, vehicle restarted but showed severe signs of power deficiency

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Escape. The contact stated that while driving at an undisclosed speed, there was an abnormal fuel odor inside the vehicle. The contact stated that the engine seized. No warning lights were illuminated. The contact stated that the vehicle was restarted. The vehicle was driven to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The dealer was made aware of the failure but provided no assistance. The contact received notifications of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline), 26V123000 (Back Over Prevention), and 26V117000 (Visibility); however, parts to do the recall repairs were not yet available. The manufacturer was not made aware of the failure. The failure mileage was approximately 40,000.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Escape. The contact received notifications of NHTSA Campaign Numbers: 25V789000 (Electrical System), 25V829000 (Structure), 26V123000 (Back Over Prevention) and 26V117000 (Visibility); however, the parts to do the recall repairs were unavailable. The dealer was contacted, and the contact was informed that the parts were not yet available. The manufacturer was contacted and confirmed that the parts were not yet available. The contact had not experienced a failure.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

MY VEHICLE HAS HAD A FUEL INJECTOR RECALL SINCE 07/2025. MY CAR HAS GRADUALLY STARTED TO IDLE AND DROP RPMS. IT STARTS WHEN THE VEHICLE WAS ONLY IN PARK AND NOW IT IS HAPPENING WHEN I AM IN DRIVE AND FOOT IS ON THE BRAKE. I AM NOT SURE WHAT TO DO BECAUSE OF THE OPEN RECALL WITH NO REPAIR OPTIONS IN SIGHT ALMOST A YEAR LATER.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Escape. The contact stated that while driving at an undisclosed speed, the engine coolant overheated warning light illuminated. The vehicle stalled after the warning light illuminated and became inoperable. The dealer was notified of the failure; however, the vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 39,700.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

This has been an ongoing recall for three years. They fixed my car the first time according to them and now it’s still an issue they are saying they can’t fix. I’ve went through two evap solenoids and my car still is having issues with the fuel vapor intake. I’m to the point I don’t ride in it or drive it with my children bc I’m scared it’s going to catch fire especially being in south florida. I’m very upset with ford!

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Escape. The contact received notifications of NHTSA Campaign Numbers: 25V467000 (Fuel System, Gasoline), 26V123000 (Back Over Prevention), and 26V117000 (Visibility); however, the parts to do the recall repairs were not yet available. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Everytime I drive the car and I don’t get no warming and I bring the car to the dealer and tell them what going on and dealer do and don’t tell me what going on.. i should be able to get another car free because they want me to keep pay thing out my pocket which I don’t have Also want to let you know that [XXX] and I will like to explain more on phone [XXX] Also the ford dealership want me to trade in my car for 2,000 which my car is value7,000 because what three thing broken and they want 5600 it not right because I just have Tht car right after my mother pass away and it only 2 years now INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Escape. The contact received notifications of NHTSA Campaign Numbers: 26V123000 (Back Over Prevention) and 26V117000 (Visibility); however, the parts to do the recall repairs were not yet available. The contact stated that the rearview camera image was blurry while in reverse(R). Additionally, the contact stated that the windshield wipers failed to operate while driving 35 MPH in the rain. The driver’s view was obstructed due to the failure, which almost caused a crash with another vehicle during the failure. The vehicle was taken to an unknown dealer, and the contact was informed that a diagnostic test was needed to determine the cause of the failure. The contact paid for a diagnostic test and the repair of the windshield wipers. The vehicle was repaired; however, the windshield wipers operated at a slower speed while on the highest setting. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The vehicle was not repaired. The failure mileage was approximately 121,000.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer, Escape, Lincoln Aviator, and Lincoln Corsair vehicles. The windshield wiper motor may fail and prevent the windshield wipers from operating properly.

Risk: Windshield wipers that fail to operate properly can reduce visibility, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the front wiper motors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed April 2, 2026. Additional letters will be sent once the final remedy is available, anticipated in October 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S14. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.

Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, Lincoln Corsair, 2020-2024 Lincoln Aviator, and Explorer vehicles. The image on the center display may flip or invert, resulting in an incorrectly displayed rearview image when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk: An incorrectly displayed rearview image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.

Remedy: Dealers will update the accessory protocol interface module (APIM) software, free of charge. Owner notification letters were mailed June 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C11. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2020-2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.

Risk: A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.

Remedy: Dealers will update the engine control software. and replace the high pressure fuel rail assembly and the fuel injector ,free of charge. As an interim repair, dealers will update the engine control software, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed August 29, 2025. Second letters will be sent once the final remedy is available, anticipated in July 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S76. This recall expands and replaces previous recall numbers 22V-859, 24V187, and 25V165. Vehicles previously remedied under 22V-859, 24V187, and 25V165 will need to have the new final remedy performed once it is available.

Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Risk: An electrical short circuit can increase the risk of a fire.

Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2025 Escape vehicles. The liftgate hinge covers may not be properly secured and detach from the vehicle.

Risk: A detached liftgate hinge cover can create a distraction or a road hazard, increasing the risk of a crash.

Remedy: Dealers will inspect and reinstall, or replace any missing liftgate hinge covers as necessary, free of charge. Owner notification letters were mailed June 3, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SD6. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 3, 2025.

Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2020-2022 Escape, and 2021-2022 Lincoln Corsair vehicles. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.

Risk: A loss of drive power increases the risk of a crash.

Remedy: Dealers will update the HPCM software, free of charge. Owner notification letters were mailed May 22, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S33.

Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.

Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

Ford Motor Company (Ford) is recalling certain 2022 Corsair and 2021-2022 Escape vehicles equipped with a 2.5L Hybrid powertrain. The high voltage battery may fail, resulting in a sudden loss of drive power.

Risk: A sudden loss of drive power increases the risk of a crash.

Remedy: Dealers will replace the high voltage battery, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S48.

Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, 2021-2022 Lincoln Corsair, and 2022 Maverick vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.

Risk: An engine compartment fire increases the risk of injury.

Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will modify the under engine shield and active grille shutter, free of charge. Owner notification letters were mailed August 19, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S47.

Ford Motor Company (Ford) is recalling one 2021 Escape vehicle equipped with a 2.5L hybrid powertrain. The high voltage battery may fail, resulting in a sudden loss of drive power.

Risk: A sudden loss of drive power increases the risk of a crash.

Remedy: A dealer will replace the high voltage battery, free of charge. The owner notification letters were mailed December 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S48.

Ford Motor Company (Ford) is recalling certain 2021 Escape, Lincoln Corsair, and 2021-2022 Bronco Sport vehicles. The fuel delivery module may leak inside the fuel tank, causing low fuel pressure which could result in an engine stall.

Risk: An engine stall increases the risk of a crash.

Remedy: Dealers will replace the fuel delivery module, free of charge. Interim notification letters (remedy not available) were mailed on September 30, 2021. Owner notification letters were mailed on December 14, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S38.

Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco Sport and Escape vehicles. The rear brake linings may have been manufactured incorrectly, which can affect braking performance. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."

Risk: During certain situations, the driver may have to apply more brake pedal force, and the distance required to stop the vehicle may be extended, increasing the risk of a crash.

Remedy: Dealers will replace the front brake pads, free of charge. Owner notification letters were mailed August 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C31.

Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2022 Bronco Sport vehicles equipped with 1.5L engines. The engine oil separator housing may crack and develop an oil leak.

Risk: An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

Remedy: Dealers will inspect the oil separator for damage or oil leaks, and replace the oil separator and seals, as necessary, free of charge. Owner notification letters were mailed April 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S21.

Ford Motor Company (Ford) is recalling certain 2020-2023 Escape and 2021-2023 Bronco Sport vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.

Risk: A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

Remedy: Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Interim owner notification letters informing owners of the safety risk were mailed January 9, 2023. Remedy parts are expected to be available in 1st Quarter of 2023. Owner notification letters were mailed February 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S73. This recall includes all vehicles previously recalled under 22V-191. Vehicles previously remedied under 22V-191 will need to have the new remedy performed.

Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2022-2023 Maverick, and 2021-2023 Corsair vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.

Risk: An engine compartment fire increases the risk of injury.

Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will replace the engine long-block in 2023 Escape and Corsair vehicles. For the other vehicles, dealers will update the powertrain control module software. If a connecting rod bearing failure is detected, dealers will replace the engine long-block. All inspections and repairs will be performed free of charge. Owner notification letters were mailed on June 14, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S27. This recall expands and replaces recall number 22V-484. Vehicles previously repaired under 22V-484 will need to have the new remedy completed.

Ford Motor Company (Ford) is recalling certain 2020-2024 Ford Escape, and 2021-2024 Lincoln Corsair vehicles. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.

Risk: Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.

Remedy: Owners are advised not to charge battery till the remedy has been completed. Dealers will perform a battery energy control module (BECM) software update, and replace the high voltage battery pack, as necessary, free of charge. Owner notification letters were mailed on May 30, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S79.

Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2023 Bronco Sport vehicles previously repaired incorrectly under recall numbers 22V-859 or 24V-187. A fuel injector may crack and leak fuel inside the engine compartment.

Risk: A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S21.

Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.

Risk: An engine compartment fire increases the risk of injury.

Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S54.

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Risk: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.