2018 Ford Edge

Our Edge has the Ford known coolant leak issue. When we talked with Ford, they flat out refused to help in any way. Buying a bottle of coolant about every month and a half now until funds are raised for the new engine/long block.

Reported

Jul 2026

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

2.0L motor cel on mechanics \ service tech said coolant is intruding the cylinders. the car may over heat ,crack a piston, destroy motor and may catch fire! confirmed by dealer. no earlier symptoms just CEL came on.

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

*Initial engine startup rough idling and also after filling gas tank up, periodic stalling, Check Engine light come on, P302 Code misfire of cylinder #2, Disappearing coolant with no observable leaks, white smoke upon startups. I am bringing the car in tomorrow to Ford for an engine inspection/analysis. *The engine stalled on the Hwy. The vehicle will be inspected tomorrow to confirm long block flawed design. *rough idling and check engine light has progressively become more frequent over a prior of the last 2 years. Reported to service advisor on multiple occasions without resolution.

Reported

Jul 2026

Incident date

Aug 2023

Mileage

Not provided

Outcome flags

None reported

Engine misfires when driving. The cause is coolant intrusion. Loss of power when driving. Rough idling. Very dangerous to drive. Diagnosed by a ford certified dealership. No symptoms prior to the problem. Vehicle is available for inspection.

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

ENGINE replacement due to coolant intrusion. This is common BIG problems reported by many and Ford is not fixing it. Engine light came after visit at Ford dealer service and was told to drive the car as long as the engine light was not flashing. Inspected by Ford and told $10,000 to fix No messages or symptoms before the car was taken to Ford for a recall, fixing of brakes and oil change.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

A week prior to the engine light going on, I noticed the car running rough when stopped at a traffic light. I thought it was due to the extreme heat and the A/C running high. The check engine light went on in my 2018 Ford Edge on XXX. I took it to the dealer where I purchased it and they ran a diagnostic. Then they told me it was misfiring and nothing to worry about, and they would have the service department call me after the holiday to schedule maintenance. On Monday, XXX, [XXX] called me from Ford Service telling me to bring the car in and they would have a loaner available for me while they looked into the problem, so I did. Tuesday morning, XXX, Kevin from Ford service calls to tell me the coolant is leaking into cylinders and I will need a new engine, approximately $9-10,000. I bought the car new in 2018, with a few extras added thinking this would be the last car I would need to buy. However, I was wrong. In 2020, with less than 23,000 miles it needed a new transmission. Now with 72, 200 miles it needs a new engine. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

receiving code p0304 cylinder 4 misfire. technician placed scope inside cylinder 4 and signs of coolant inside the cylinder. TSB 19-2346 matches what is happening in with his vehicle

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

This is an issue that could lead to sudden engine failure while driving, causing a serious accident risk. A few months ago the engine sputtered while idle after starting and the heater wasn't working well. Noticed coolant was a low and topped it off. The issue seemed resolved after this. A few weeks ago the check engine light came on indicating a misfire in cylinder 2. We changed the spark plugs, but the issue returned shortly after. We swapped coil packs, but the issue returned, still for cylinder 2. We noticed at that time the coolant was very low. There were no puddles of coolant seen underneath the car in its usual parking spot. Pulled the spark plug and noticed white residue on the end of it. The vehicle was taken to a Ford dealership where we were informed there was a crack leading to coolant intrusion into cylinder 2, requiring engine replacement at over $10,000 cost. Online research has found this is a known issue affecting multiple Ford/Lincoln models spanning several model years and Ford has a few Technical Service Bulletins (#19-2346, 22-2133 and 22-2229) regarding it. This was not communicated to vehicle owners as a possible issue to have checked out. This problem will lead to inevitable engine failure. If this happens while driving, it could cause an accident as the vehicle could just come to a stop, possibly in the middle of an interstate highway.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The check engine light came on while the vehicle was being driven during a vacation. This happened after the vehicle had a maintenance-required tune-up performed by the dealership on May 19, 2026. The vehicle was not having performance issues at the time, but I did not want to drive home with the check engine light on. The very next business day, I took the vehicle to the dealership for inspection. The dealership advised me that the vehicle had coolant intrusion involving cylinder 4 and that the engine would need to be replaced. Because this was a serious diagnosis, I then took the vehicle to another reputable automotive repair shop for a second opinion. That shop also advised that the engine needed to be replaced due to the coolant intrusion issue. This creates a safety concern because coolant intrusion can lead to misfires, engine damage, overheating, loss of power, stalling, or engine failure while the vehicle is being driven. I was more than 250 miles from home and had to avoid driving the vehicle because of the risk of further engine damage or possible failure on the road. The vehicle is available for inspection upon request. The issue was inspected by the dealership and by an independent automotive repair shop. No crash, fire, injury, or death occurred. The check engine light came on while driving during a vacation. No other warning message is known at this time.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Approximately 3–6 months ago, my 2018 Ford Edge (2.0L EcoBoost, ~86,650 miles) began exhibiting symptoms including repeated coolant loss requiring frequent top-offs with no visible external leak, a check engine light with misfire codes, and rough idle and rough running conditions. I brought the vehicle to a Ford dealership for diagnosis. The dealership confirmed coolant intrusion into the engine cylinder, consistent with the known defect described in Ford Technical Service Bulletin (TSB) #22-2229. The recommended repair per the TSB is a full long-block engine replacement, quoted at approximately $13,000. This issue affects 2015–2018 Ford Edges equipped with the 2.0L EcoBoost engine and is the result of a documented design flaw in which channels scored into the cylinder head allow coolant to degrade the head gasket seal and enter the cylinders. Ford redesigned the engine around 2020 to address this flaw but has not issued a recall or provided remediation for affected owners. My vehicle is out of warranty and Ford has declined to cover the repair despite acknowledging the defect in the TSB. I am filing this complaint to add to the documented record of this defect and urge NHTSA to investigate and require a recall. Coolant intrusion can lead to complete engine failure, overheating, and fire risk — posing a serious safety hazard.

Reported

Jun 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Known ford edge issue, coolant intrusion, that occurs due to bad design of the engine block and related cooling issue. Engine nearly locked up while driving without warning or notice on highway, bad stuttering.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

A torque converter positioning sensor component stuck off

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The check engine light came on 2 weeks ago, and I have had rough cold starts since then. Brought my car to the dealership after Autozone scanned the code and told me I need new spark plugs and an ignition coil. The mechanic at the Ford dealership determined that Coolant is leaking into the cylinders - I am being told I need to replace the whole engine. Apparently, this is a very common issue with my car, as well as many other Ford models

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The engine continually exhibits cylinder #2 misfiring, disappearing coolant, and rough idling. Efforts have been made, but these issues relate directly to a cracked block allowing coolant into the combustion chamber. The car has about 93,000 miles on it and has been meticulously maintained, but still the issues are getting worse and more frequent.

Reported

Jun 2026

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

I have a 2018 Ford Edge where the liftgate will not open at all from any method—key fob, interior button, or the hatch button. This appears to be a mechanical or electrical failure, and I’m concerned it may be a defect and a potential safety issue since the trunk cannot be accessed. It has had many Safety recalls reguarding a lot of issues, the rear view camera is in the same area, so they fixed my camera but they wouldn't fix the trunk not opening, I feel this is major safety issue, should I get pinned in my car while in an accident, on day in where I live in [XXX] and it's 110 outside with my mom or my kids, it could cause us to lose our lives. It's clear they know it's a problem, it a known issue but they are doing nothing to fix, because I purchased the car used and the warrenty for them was over in 05/08/2026. This dangerous, and not something I as the buyer/drive caused. I wasn't in accident, I wasn't in flood, I did not cause this damage and they should fix. Espcially knowing they already have problems with this area on the car. However, they want me to go get the car checked for transmission issues cause there a recall on that on my car, Customer Satification Number 22N12. I am asking for Help. There are no lights on, no messages from the car it just stops randomly working. This has been going for about 4 months. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The part behind the dashboard touchscreen for the radio went bad, they call it the APIM (Accessory Protocol Interface Module). It allows us to see the screen when in reverse among other things. They are incredibly common to go bad on certain model years of ford vehicles. Very expensive to fix as the module is programmed per VIN. The screen does not work, just stays black the entire time.

Reported

Jun 2026

Incident date

Jun 2024

Mileage

Not provided

Outcome flags

None reported

The car is a 2018 Ford edge titanium 2.0L Eco Boost engine.After 75,600 miles the check engine light came on. After a local auto repair shop diagnosed the problem as a coolant contamination in cylinder 3, I was instructed to take the car to a Ford dealer because a new engine was needed. The dealer confirmed the coolant intrusion in cylinder 3 and a new engine has been ordered. After calling Ford Care, I was told that this is a known problem but because my warranty had expired there was nothing Ford would do. So I will need to spend $8,500 for the new engine and installation.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

This 2018 Ford Edge of 65, 775 miles was loosing antifreeze, releasing white smoke out exhaust and would throw codes of overheating issues etc. Took vehicle to Pettus Ford in Fredericktown, Missouri for diagnostic of codes. It was noted that these codes are all related and owner must get a new engine to fix the problem. No other remedy was suggested. This seems to be a none problem with this year of vehicle with no recalls noted to date. There were a few different warning lamps that were displayed to notify owner.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

I bought the car may 1st. MAY 3RD the check engine light came on. Dealership changed spark plugs. Next day light came on again. Then the engine over heating warning light came on. Coolant looked low but went took cap off and air hit coolant level came back up.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Car keeps overheating and mis firing causing the car to break down on the side of the road, coming to find out that the engine is having head gasket failure without warning, check engine light doesn't appear to after the fact, causing my 82 year old mother stranded on the side of the road

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The 2.0L EcoBoost engine in my 2018 Ford Edge Titanium experienced head gasket failure due to Ford’s known cylinder channel design defect present in 2015–2019 EcoBoost 2.0 engines. Ford scored channels between cylinders in an attempt to improve cooling, which allows coolant to degrade the head gasket and mix with engine oil. Symptoms included white smoke from the exhaust, coolant loss, rough idle, and a check engine light prior to failure. The coolant-oil contamination caused engine performance degradation and risk of sudden failure while driving, endangering myself and other motorists. The engine drained all coolant unbeknownst to me while driving, causing the car to overheat and causing damage to the head gasket. Car had to be pulled over and towed to a shop. Head gasket was repaired, but the issue continued and more coolant was found in the engine oil in 2026. Coolant constantly has to be replenished after driving. The failure was confirmed by an independent mechanic. The vehicle has not been inspected by Ford or NHTSA. Ford has not issued a recall for this known defect despite widespread reports from 2015–2019 Edge, Fusion, and other EcoBoost 2.0 owners experiencing identical failures. I am filing this complaint to contribute to the pattern of evidence needed to compel a formal NHTSA investigation and potential recall action.

Reported

Jun 2026

Incident date

Jan 2024

Mileage

Not provided

Outcome flags

None reported

I have a 2018 Ford Edge supposedly bought "brand new" was advertised "brand new" but later find out it wasn't because dealership had titled it to themselves as a loaner. A few weeks ago my check engine light came on and my husband had it checked and was a cylinder 2 fault code. He took it to our local mechanic and he said he looked with scope and saw coolant in the cylinder. My car now sits at the Ford Dealership in Albemarle and has been diagnosed with the coolant intrusion issue and I have to pay for a engine. My calls to Ford were useless, they refused to help even though this issue was well known to them and I was never informed or I would have traded this vehicle in a long time ago. The service rep at the dealership said I was looking at about 7400 out the door plus an issue with "fluid leaking" on both front wheels, which is another 1000. She also said she would advocate on my behalf with Ford to see if they will cover any of this repair. We are waiting to find out their response. I have a line of credit set up to pay for this but really can't afford to put money into this lemon. I am disappointed in Ford as a Ford Mustang was my first car and my husband and I have bought several brand new and used vehicles over the years. We were life long Ford people but Ford doesn't stand behind well known (to them) defective engines so we are no longer. My choices are 1) pay 8500 to have the repairs fixed, 2) Ford assisting me with paying for the engine replacement 4) Selling/trading my vehicle to avoid the expensive repair and only getting between 2000 and 3000. Either way (unless Ford helps me) I am out around 7400-8500! Most of all I feel like I've been driving around blind to the fact that a fire could have resulted. I frequently have my grandchildren in my car and it could have been devastating. Or my engine could have blown in the middle of heavy traffic putting us at risk of collision and the task of somehow getting it out of the road safely.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

2018 Ford Edge 2.0L EcoBoost. Vehicle CEL came on, took it to the dealership for diagnostic and report indicated a known TSB 22-2229 to apply to my vehicle's condition. Trouble code P0302. White exhaust smoke, misfire at start up, low coolant levels, runs rough. Dealer performed a borescope inspection and found the engine long block has internal fluid leak. My safety, my kids, and others on the road were put as risk because at any given moment, the car could have overheated, stalled and caused an accident. The engine is available for inspection upon request. Prior to the CEL, the car began shaking and blowing white exhaust smoke. Now I'm left with no car as a single mom trying to make ends meet. Ford won't help to pay $13K for a new engine with a known manufacturing defect.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

See attached document for complaint.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Error code, cylinder 2. This is 2018 Ford Edge 2L ecoboost and personal mechanic looked in cylinder and saw small amount of coolant. The car is sitting at Ford dealership in Albemarle NC at this time for full diagnostics. The car has mostly been parked since getting error code but husband said coolant is full, oil looks normal, is not cloudy and car drove fine to dealership. We are hoping this will be a minor (not replace the whole engine) fix. But I am bracing for worst, and scared it is the "well known to Ford" coolant intrusion issue due to defective engines in models 2015-2018. If so I hope Ford will do the right thing. My husband and I have been life long Ford customers, but if I have to pay for that engine with no assistance from them I will never owl another Ford. This seems to be a chronic issue with these engines. Im not sure exact date we got the error code but sometime in April. I can probably get exact date my husband had it checked from parts store if need be. I bought this car brand new (although it was technically NOT new. It was advertised and sold as new but I later found out it had been previously titled to dealership...but this is another story). I changed oil regularly, with full synthetic and I am in my late [XXX] and drive accaccordingly. This vehicle has been well taken care of. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2018 Ford Edge. The contact stated while driving at an undisclosed speed, the check engine warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the head gasket needed to be replaced; the independent mechanic made the contact aware of an unknown technical service bulletin associated with the failure. The vehicle was not repaired. The vehicle was taken to a different independent mechanic where it was diagnosed once again that the head gasket needed to be replaced. The vehicle was not repaired. The vehicle was taken to a dealer where it was diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 78,000.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

2018 Ford Edge 2.0l ecoboost engine that has a design flaw that allows coolant to leak into the cylinders and destroys engine. Approximately 65,600 ish miles and it was just diagnosed with coolant intrusion and new engine is needed.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2018 Ford Edge. The contact stated that while driving, the vehicle began to vibrate excessively. There was an abnormal swishing sound detected. The check engine light was illuminated. The vehicle was taken to the local dealer, where a video was sent to the contact displaying coolant intrusion into the cylinders. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was approximately 79,000.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Blown head gasket, coolant leak into engine tsb222229

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The Long block of the engine, which has seemingly been a known issue, is causing damage to the engine and spark plugs. It is. This could leave me stranded or cause an accident with how violent it makes the car misfire, and sometimes it's hard to accelerate. This is an issue that Ford has acknowledged as well as the Ford dealership. It has undergone a diagnostic run at the Ford dealership. There were no warnings prior to this. The problem makes it seem like it is another issue, and with further investigation, it shows that it is the long block of the engine that is the root cause.

Reported

May 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

My 2018 Ford Edge (VIN: [XXX] ), equipped with a 2.0L EcoBoost engine, suffered a catastrophic engine failure due to internal coolant intrusion into the cylinders — a known defect covered under Ford Technical Service Bulletin TSB 22-2229. Approximately four months before the failure, I brought the vehicle to Red McCombs Ford in San Antonio after the check engine light illuminated. Despite this warning, the authorized Ford dealer failed to diagnose the issue or recommend any repair, and advised me it was safe to continue driving. Shortly thereafter, while driving on a busy highway with my grandchildren in the vehicle, the engine suddenly lost all power with no additional warning. We were forced to coast to the shoulder, placing us and other motorists at serious risk of collision. The vehicle was towed immediately to McCombs Ford West (7111 Northwest Loop 410, San Antonio, TX 78238), another authorized Ford dealer in the same Red McCombs Automotive Group, where technicians confirmed the engine requires full replacement at an estimated cost of $7,415.89. A warranty claim was submitted but denied on the basis that I allegedly drove too long after the problem began — a determination I dispute, as the vehicle was towed immediately upon failure without further operation. The failed engine remains at the dealership, has not been repaired, and is available for inspection upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

May 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Vehicle, a 2018 Ford Edge SEL, recently experienced misfiring and overheating with the "check engine" light illuminated. Took the vehicle to an automotive repair shop and, after performing diagnostics, they advised the vehicle's engine coolant is leaking into the cylinders, which was the subject of a prior Technical Service Bulletin #19-2208 from Ford, and is a KNOWN DESIGN DEFECT with the 2.0L EcoBoost engine produced by Ford for this and other model vehicles. After researching this issue I determined it was the subject of a prior recall, technical service bulletin, and class action lawsuit which lead Ford to offer free repairs of the engine block and extended warranty coverage to affected vehicle owners. WE WERE NEVER NOTIFIED OF THE RECALL, TSB, OR CLASS ACTION and, therefore, were not aware of the problem and unable to take advantage of any corrective program. Now, Ford Customer Service and the Ford dealership are both refusing to effect the necessary repairs without cost to me. The vehicle's ENGINE has an ACKNOWLEDGED DESIGN FLAW that can cause misfires, hydro-locking, overheating, and total engine failure with a fire risk. The vehicle is available for inspection upon request. Safety risks to the driver, occupants and others is obvious. The problem has been confirmed by a Firestone automotive repair shop. No other inspections have occurred due to a fear of driving the vehicle. The "check engine" light did activate when the problem first occurred, approximately 5 days ago (04/29/2026).

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The component or system that failed or malfunctioned due to this issue was our cylinder number 1 had a misfire code showing. Upon further inspection of the car at the shop with a borescope camera it was found that coolant is leaking into the cylinder causing a misfire to occur after the vehicle has been driven and then sits while cooling system is still under pressure. Our safety was put at risk because while driving the car on the interstate in [XXX] around end of February to sometime in March the car was jerking and acting as though it would die at any point where cars are travelling of speeds 65-70 mph plus. We had our [XXX] old and then [XXX] old who has a neurological condition and is under a neurologist for treatment of severe migraine headaches in the car with us. We had to pull over on the side of the road, then my husband started driving slowly with emergency blinkers on, we were able to get to a dealership who looked at it and ran a code and told us that the code showed a misfire in our cylinder 1 and that we needed to replace the ignition coil, which we just replaced in May 2024 and we have a rceipt to show proof of this. The car will no longer be in our possession because when my husband learned that the car was in engine failure he wanted to trade it in because we need a safe car but we do have the reports to it. The problem was confirmed by an independent service center- Christian Brothers Automotive in Crestwood, Ky. To fix the problem we have to have a total engine replacement which is priced at 12 grand. Manufacturer refuses to take responsibility for this. Engine blockhead was also found to not line up with the engine, which had to have happened at factory when car was built. The check engine light came on 2x recently, car was jerking in May 2024 and that's when the problem 1st started. Problem corrected for almost 2 years, but then same problem reappeared. Any other information I am willing to share with you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

May 2026

Incident date

May 2024

Mileage

Not provided

Outcome flags

None reported

Driving at 65 mph without warning car adaptive steering and airbag light comes on. Found there is a clock spring failure. There clockspring failures reported in 2020s. Ford haven’t achieved function of clocksprings

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

On April 15, 2026, I brought my 2018 Ford Edge SEL to an authorized Ford dealership with a loud rattling noise at startup and an illuminated check engine light. Ford Motor Company had previously sent me two written notices (September 2022 and June 2023) identifying a known cracked flexplate defect on my vehicle under Customer Satisfaction Program 22N12, describing these exact symptoms. The defect was never repaired at any of my 16 service visits. Additionally, on September 2, 2025 — just 8 days after Safety Recall 25S87 for the rear brake flexible hose was issued — the dealership presented that recall repair to me as a $532 optional paid service without disclosing it was a free safety recall I was entitled to by federal law. Safety Recall 25S89 for the rear-view camera also remains unperformed. The vehicle is currently undriveable.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The ecoboost 2.0 engine allowed coolant to intrude into the block. The engine misfires, runs rough, and had the potential to allow large amount of coolant into the cylinder resulting in complete engine stoppage. The safety of the driver and those around the driver are at risk when the engine shuts off. The engine has been inspected by an independent service center. Yes, the engine light illuminated and a P0301 fault code was produced.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2018 Ford Edge. The contact stated that while attempting to reverse, the rearview camera became inoperable. The contact stated that the rearview camera image was distorted, and occasionally the message “Camera not Available” was displayed. The contact received notification of NHTSA Campaign Numbers: 25V572000 (Back Over Prevention) and 25V544000 (Service Brakes, Hydraulic); however, the parts to do the recall repairs were not yet available. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was approximately 163,000.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

My 2018 Ford Edge with the 2.0L EcoBoost engine (approximately 100,000 miles) has experienced coolant intrusion into the engine cylinders — a known manufacturing defect documented by Ford in TSB 19-2346 (NHTSA ID 10169807). The coolant leak was discovered over the course of several months as I noticed that heat wasn't coming out and I checked that the coolant was low. I replaced the coolant twice over six months. The dealership confirmed coolant in the cylinders and stated the only repair is a full long-block engine replacement, quoted at approximately $12,000. Ford Motor Company has acknowledged this defect affects 2015–2018 Edge vehicles with the 2.0L EcoBoost engine, yet has refused to issue a recall or provide financial assistance to affected owners. This is a manufacturing defect — not owner-caused damage — as Ford's own TSB identifies erosion and corrosion of the engine block as the root cause. Ford Customer Service declined to assist when contacted. I am requesting NHTSA investigate this issue and consider a formal recall, as thousands of owners of 2015–2018 Ford Edge, Escape, Fusion, MKZ, and MKC vehicles with the 2.0L EcoBoost are facing the same failure.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The vehicle experienced engine failure due to coolant intrusion into the engine cylinders. The issue presented with engine misfire, including diagnostic trouble code P0302, rough running, and coolant entering the combustion chamber. The condition was confirmed by a dealership, which determined that the engine has internal damage and requires full engine replacement. There were no external coolant leaks observed. This failure occurred at approximately 88,000 miles and was not consistent with normal wear and tear. The issue developed without significant prior warning other than engine misfire and rough operation. This condition may create a safety risk, as engine misfire and internal damage can lead to loss of power, reduced vehicle performance, or potential engine stall while driving. Technical Service Bulletins have been issued for similar vehicles equipped with the same engine, including TSB 19-2172, TSB 19-2208, and TSB 22-2229, which describe coolant intrusion into engine cylinders and require engine replacement. This suggests the issue is not isolated and may affect other vehicles with the same engine design.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2018 Ford Edge. While the contact’s wife was driving 40 MPH, the brake pedal was depressed, and the vehicle unexpectedly lost automotive power. The contact stated that after refueling the vehicle and attempting to start the vehicle, the vehicle started shaking abnormally. The check engine warning light was illuminated. A dealer was contacted. The vehicle was taken to the dealer to be diagnosed, and it was determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 68,000.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2018 Ford Edge. The contact received notification of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

When approaching a stop, the vehicle vibrates heavily as if it is trying to fight the brakes to continue moving and avoid downshifting. The wrench light on my dash came on, so I took it into the dealer to have the problem evaluated. The torque converter has failed on my Edge, according to the dealership evaluation. They also indicated that this could lead to complete failure of the transmission, inability to drive the vehicle and loss of power train control. The shop was able to verify the issue and confirm that it won't go away. There is no noted recall for bad torque converter according to Ford, but the service manager informed me that this is the most common issue with the Edge platform and it is expensive (between $5-10k). I contacted customer relations and ford says there is no issue with the platform and all vehicle repairs are the responsibility of the owner. I have independently reviewed documents regarding customer complaints and discussed the issue with Ford technicians and they confirm that Ford knows there is a problem and doesn't want to address it as a recall. Independent repair shops have refused to repair this transmission issue on the premise that it is a known issue that there is no resolution for and they do not want to have any responsibility over repairing a flawed powertrain and risk famage to their reputations, causing a disparate impact to the consumer. This needs to be addressed and remedied by Ford, especially since this is not an isolated issue, but platform wide.

Reported

Apr 2026

Incident date

Jul 2024

Mileage

Not provided

Outcome flags

None reported

It has a miss in cylinder 2. I understand there is a recall about this problem and I would like Ford to take care of problem. I have been driving Fords since 1960 and I also retired from a Ford dealership in Texas after 22+ years of service. Would like to hear back from you on this matter.

Reported

Apr 2026

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

See attached document for complaint.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2018 Ford Edge. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The local dealer was contacted but the vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that the rearview camera had displayed a blank screen. The approximate failure mileage was 101,500.

Reported

Apr 2026

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

2018 Ford Edge 116,000 Due to poor engine issues since 2015 Edge cars a new engine of nearly 10,000 needs to be replaced. Ford knew this but continued to use this failed engine.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2018 Ford Edge. The contact stated that while reversing, the back over prevention camera screen malfunctioned, and displayed either a dark image or no image. The contact stated that the failure created a visibility hazard for the driver. The contact received notification of NHTSA Campaign Number: 25V572000 (BACK OVER PREVENTION). The manufacturer and local dealer were contacted and stated that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was 60,000.

Reported

Apr 2026

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2018 Ford Edge. The contact received notifications of NHTSA Campaign Numbers: 25V544000 (Service Brakes, Hydraulic) and 25V572000 (Back Over Prevention); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The contact stated that while in reverse, the back over prevention camera displayed a distorted image, with the message, "Rear-view Camera Not Available" and the screen went black. The dealer was contacted, and it was confirmed that parts were not yet available to repair the vehicle. The manufacturer was made aware of the issues. The failure mileage was approximately 65,000.

Reported

Apr 2026

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2018 Ford Edge. The contact received notifications of NHTSA Campaign Numbers: 25V544000 (Service Brakes, Hydraulic) and 25V572000 (Back Over Prevention); however, the parts to do the recall repairs were not yet available. The dealer was contacted and confirmed that the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was unreachable. The contact had not experienced a failure.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The engine requires full replacement due to a cracked engine block, coolant intrusion into cylinder 2, heavy spark plug corrosion, and diagnostic code P0302 (cylinder 2 misfire). The defect was confirmed by an authorized Ford Dealership. The vehicle is available for inspection upon request. Safety risk: This defect causes sudden loss of engine power without reliable warning, engine stalling in active traffic, and risk of engine fire due to coolant-oil contamination - all documented safety hazards Ford has acknowledged in its own technical bulletins. The vehicle was inspected by a Ford-certified technician at an authorized dealership. The problem was confirmed and dealership issued a written diagnosis for requiring engine replacement. 100% of our services to this vehicle have been done by Ford dealerships, up to and including the appointment to diagnose the engine. Warning symptom appeared prior to failure: check engine light, an audible sloshing sound from the engine compartment. Symptoms first appeared in early December 2025, (approximately 2 weeks before the end of our warranty.) A service appointment was scheduled for the check engine light, but was cancelled because the light cleared itself. We learned in April 2026 that it was engine failure. Ford's own TSBs 19-2346 and 22-2229 document that symptoms of this defect occur with or without an illuminated MIL. Ford has not issued a recall despite NHTSA's own database showing 727 complaints on this vehicle, 128 pages of which relate to engine and engine cooling issues. They stated when asked about a warranty claim or goodwill there is no open customer service issues related to this, and since the diagnosis is post warranty they will not cover any of the approximate 10,000 it will cost to replace the engine.

Reported

Apr 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.

Risk: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.

Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.

Risk: A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.

Remedy: Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notification letters were mailed October 27, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S43.

Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.

Risk: A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.

Ford Motor Company (Ford) is recalling certain 2018 Ford Edge and Lincoln MKX vehicles. These vehicles may have door striker bolts that are shorter than intended. Vehicles with shorter door striker bolts fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components" potentially resulting in the doors opening in the event of a crash.

Risk: If the doors open in the event of a crash, there is an increased risk of injury.

Remedy: Ford will notify owners, and dealers will replace the door striker bolts, free of charge. The recall began October 18, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18C06.

Ford Motor Company (Ford) is recalling certain 2017-2018 Ford Edge and 2017 Lincoln MKZ vehicles. On vehicles with 2.0L gas engines and six-speed automatic transmissions, the torque converter weld studs may have been inadequately welded.

Risk: If the torque converter weld studs fail, the torque converter will not be connected to the engine flexplate and the vehicle will lose the ability to move, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the torque converters, free of charge. The recall began on July 5, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S16 (S2). Note: This recall is an expansion of recall 17V-427.

Ford Motor Company (Ford) is recalling certain 2018 Ford Edge, Lincoln MKX, 2019 Ford Flex, and Lincoln MKT vehicles. The power supply cables at the starter and the alternator may not have been properly secured, possibly resulting in an electrical arc.

Risk: An electrical arc can increase the risk of a fire.

Remedy: Ford will notify owners, and dealers will inspect the alternator and starter motor power supply cables to verify that they are properly secured, correcting them as necessary, free of charge. The recall began September 26, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S25.

Ford Motor Company (Ford) is recalling certain 2016-2018 Lincoln MKX and 2015-2018 Edge vehicles. The rear brake jounce hose may rupture and leak brake fluid.

Risk: A brake fluid leak can extend the distance required to stop the vehicle, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the brake jounce hoses and adjust brake jounce hoses with no damage present, free of charge. Interim owner letters notifying owners of the safety risk were mailed September 8, 2025. Additional letters will be sent once the remedy is available, anticipated August 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S87.