These problems appeared in the records we reviewed. This is not a list of what happens most often, and it does not predict the condition of one car.
What to look for
Airbags owner reports
Moderate severity
Evidence: Limited confidence
Owner reports are bound to model year 2020.
Symptom
5 reviewed owner reports for this model year mention air bags.
Why it matters
The records describe a problem worth checking before purchase.
What to inspect
Ask the inspector to test the named system and note any warning lights, noises, leaks, or stored codes.
Ask the inspector to check: Independent pre-purchase inspection.
What may help
Use the inspection and service records to check whether this car shows the reported problem.
Sources and limitsShowHide
Source recordEvidence: Limited confidence
The records describe a problem worth checking before purchase.
“MY WIFE AND I WERE STOPPED AT A STOPLIGHT IN HOT SPRINGS ARKANSAS ON MARCH 8, 2022. ANOTHER VECHICLE RAN INTO US ALMOST HEAD ON AT AN ESTIMATED 30 MPH. THERE WAS CONSIDERABLE DAMAGE TO THE FRONT END OF OUR TRUCK. THE AIR BAGS DID NOT DEPLOY. WE WERE TAKEN TO THE HOSPITAL. MY WIFE HAS SOME BROKEN BONES IN HER BACK AND HAS EXPERIENCED SIGNIFICANT PAIN SINCE THE ACCIDENT.”
The records describe a problem worth checking before purchase.
“I hit another vehicle in the passenger side head on at 55+ MPH and the air bag did not deploy. Air bags in the other vehicle did deploy. No prior warning. Police, wrecker driver, and others questioned why the bags did not deploy. I had neck, back, arm, chest and hand injuries. Accident report annotated that the air bags did not deploy.”
The records describe a problem worth checking before purchase.
“I WAS INVOLVED IN AN ACCIDENT IN MY NEW FORD F-150 KING RANCH ON THE ABOVE DATE TRAVELING ON THE HENRY HUDSON PARKWAY (MANHATTAN) SOUTHBOUND. MY TRUCK WAS STRUCK IN THE REAR PASSENGER DOOR BY AN UNKNOWN VEHICLE AND CAUSED US TO SPIN OUT 2 TIMES AT 60 MPH AND HIT THE CENTER CONCRETE DIVIDER ALMOST DIRECTLY HEAD ON. WE HIT TO THE PASSENGER SIDE OF THE FRONT OF THE TRUCK.. THE AIRBAGS DIDN'T DEPLOY. THE CANISTERS ON THE SIDE IMPACT AIRBAGS OPENED AND THE POWDER WAS ALL OVER BUT THE BAGS DIDN'T DEPLOY. I DON'T THINK THIS WAS NORMAL AND I FEEL IT SHOULD BE LOOKED AT. THERE WAS $31,000 DAMAGE TO THE VEHICLE WHICH WASN'T TOTALED. IS THIS SOMETHING THAT THIS AGENCY WILL LOOK INTO FOR ME? RESPECTFULLY SUBMITTED, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR*DT*DT”
The records describe a problem worth checking before purchase.
“Driver side airbag failed to deploy during front end collision. Available for inspection at collision repair facility until repairs are initiated. Problem has not been noted by dealer or recall notice. Has not been inspected by anyone at this time. No warning lamps indicating the airbag was inoperable.”
3 reviewed owner reports for this model year mention electrical system.
Why it matters
The records describe a possible crash, fire, injury, or loss of control.
Mileage in the reports
In reports that included mileage, this problem showed up around 65,500 to 66,500 miles.
Based on 2 reports that included mileage. This is not a failure rate or a prediction.
What to inspect
Ask the inspector to test the named system and note any warning lights, noises, leaks, or stored codes.
Ask the inspector to check: Independent pre-purchase inspection.
What may help
Use the inspection and service records to check whether this car shows the reported problem.
Sources and limitsShowHide
Source recordEvidence: Limited confidence
The records describe a possible crash, fire, injury, or loss of control.
“The contact owned a 2020 Ford F-150. The contact stated that his employees had driven the vehicle to a work site. While at the work site, the vehicle caught fire while the engine was off. An employee stated that flames appeared to have come from the vehicle's dashboard. An attempt was made to extinguish the fire with a fire extinguisher; however, the flames quickly engulfed the vehicle. The fire department was called and extinguished the fire. The vehicle was destroyed as a result of the fire. One of the contact's employees suffered first and second-degree burns to the face. The employee was taken to a hospital where they were treated for their injury. A police report was not filed. The decal from a storage unit was melted, a blinker cover on an RV was destroyed, and several nearby trees were damaged. The vehicle was towed to an independent tow yard where it remained in their possession. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle had yet to be inspected; the cause of the fire remained unknown. The failure mileage was approximately 65,000.”
The records describe a possible crash, fire, injury, or loss of control.
“The contact owns a 2020 Ford F-150. The contact stated that upon attempting to unlock the doors of the vehicle with the key fob, only the front driver's side door unlocked. There was no warning light illuminated. Additionally, the contact stated that while attempting to manually unlock the tailgate, the tailgate failed to unlock as intended. The dealer was contacted and informed the contact that the failure could be related to an unknown actuator recall. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, and a case was filed. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 67,000.”
The records describe a possible crash, fire, injury, or loss of control.
“i AM RECEIVING ALERTS ON MY FORD APP STATING THAT IT IS A PARKING AID ALERT BECAUSE OF ELECTRICAL ISSE WITHIN THE VEHICLE. ALSO STATES TO SERVICE ENGINE SOON ALERT BECAUSE OF ELECTRICAL ISSUE HAS BEEN DETECTED WITH YOUR VEHICLE. THIS MAY CAUSE THE ENGINE START/STOP FEATURE (IF EQUIPPED) TO NOT WORK. CHECKING ON THIS I FOUND 0 ON THE NHTSA WEBSITE FOR RECALLS. WITH FURTHER CHECKING I WAS INFORMED THAT THIS SHOULD BE A RECALL TO BE DONE. PLEASE LET ME KNOW IF I CAN GET THIS REPAIRED UNDER THE RECALL. I ALSO NOTICE WHEN STARTING MY VEHICLE IN THE MORNINGS THAT IT SMOKES OUT OF BOTH TAILPIPES AND LASTS APPROXIMATELY ONE TO TWO MINUTES. [XXX] [XXX] . THANK YOU. MY EMAIL IS ALSO [XXX] ADDRESS IS [XXX] , EDNA, TEXAS [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)”
7 reviewed owner reports for this model year mention power train.
Why it matters
The records describe a possible crash, fire, injury, or loss of control.
Mileage in the reports
In reports that included mileage, this problem showed up around 22,000 to 100,000 miles.
Based on 5 reports that included mileage. This is not a failure rate or a prediction.
What to inspect
Ask the inspector to test the named system and note any warning lights, noises, leaks, or stored codes.
Ask the inspector to check: Independent pre-purchase inspection.
What may help
Use the inspection and service records to check whether this car shows the reported problem.
Sources and limitsShowHide
Source recordEvidence: Medium confidence
The records describe a possible crash, fire, injury, or loss of control.
“My 2020 Ford F-150 with the 10R80 transmission has been involved in transmission failures on multiple occasions. The last 2 incidents nearly resulted in car accidents. I had complete power failure while moving through an intersection and was narrowly avoided by another vehicle that thankfully was able to steer clear of my decelerating truck. I would have been hit on the driver side at around 45 mph. my vehicle rolled to a stop after hitting the curb on the other side of the road. I then sat with the truck off for 5 minutes, then turned it back on, got power back, and drove straight to the dealership. Lights flickered on the screen indicators saying "Pre Collision off, wrench light on, and complete loss of the gear screen." Ford had the truck for 2 weeks and replaced the transmission wiring harness saying there was a loose connection. The day after I picked the truck up I was accelerating from a stopped position at a light. Around 7th gear and around 45 mph the entire truck suddenly downshifted into 1st gear with a loud bang causing me to launch forward. It almost felt like my truck hit something as I went from 45 mph to about 20 mph in one second. The vehicle behind me honked his horn, slammed on his brakes, and swerved around me into the other lane - another accident narrowly avoided. I pulled over shut the truck down, turned it back on and drove some 10 miles never going over 40 mph. The wrench light was on. The drive modes were unavailable. The gear shift screen was gone. I was not able to get more than 3,000 rpms while driving giving me very little acceleration. Ford currently has the vehicle again. I am terrified to get back in this truck. There appears to be NO SOLUTION to the problems and I simply can't risk my life or someone else's by taking a chance of driving this truck again. Ford knows there are transmission problems. They are unable to solve it. I do not know what to do as I still have $44,000 to pay it off.”
The records describe a possible crash, fire, injury, or loss of control.
“The contact owns a 2020 Ford F-150. The contact stated that while the vehicle was locked and parked on the street with the engine running and unoccupied, the transmission erroneously shifted into gear and the vehicle drove forward. The contact stated that the vehicle crashed into another parked vehicle and landscaping and missed crashing into another vehicle that was driving in the opposite direction. The contact expressed concerns because no one was present inside the vehicle during the failure. The contact stated that the Police Department was contacted but no officers showed up on scene. No injuries were reported. The cause of the failure was not determined. The dealer was contacted and informed the contact that the PCM needed to be reprogrammed; however, the vehicle had not been diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 22,000.”
The records describe a possible crash, fire, injury, or loss of control.
“The contact owns a 2020 Ford F-150. The contact stated while driving 40 MPH, the vehicle made an abnormal rattling sound. The vehicle was taken to an independent mechanic where it was diagnosed that the transmission had failed and needed to be replaced. No further information was available. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 118,923.”
The records describe a possible crash, fire, injury, or loss of control.
“The contact owns a 2020 Ford F-150. The contact stated that while driving at various speeds on several occasions, the vehicle accelerated unintendedly while depressing the brake pedal. The contact stated that the power train warning light was illuminated, and the message "Power Train Malfunction - Reduced Power" was displayed on the Mobile App. Additionally, the contact stated that while driving 60 MPH, the transmission downshifted unexpectedly while depressing the accelerator pedal. The contact stated that the engine revved while the RPM was fluctuating. The vehicle was not repaired. No further information was available. The manufacturer was notified of the failure and informed the contact that the manufacturer could not issue recalls. The contact was referred to the NHTSA Hotline to file report the failure. The failure mileage was approximately 100,000.”
The records describe a possible crash, fire, injury, or loss of control.
“The rear differential exploded while driving without warning. immediate lose of power while traveling 70mph, the explosion blew some hot parts of the differential off the road and started a brush fire.”
The records describe a possible crash, fire, injury, or loss of control.
“My truck started to throw codes p0240 and p0430 when my truck hit 81000 miles. I am now at 141000 miles. I have since replaced both of my catalytic converters, all 4 of my O2 sensors and I still have the same p0240 and p0430 codes. I also took my truck into ford on Feb 26, 2025 for the recall on my PCM reprogramming. They claimed to have redone the programming but ever since they did that, I now have shifting problems, surging, clanking, hard shifting, random and sporadic shifting with no end in sight. This should be addressed by Ford TSB 24-2101 but again, they did nothing and claim there is nothing wrong with my truck. I have had a fluid replacement and filter replacement with no issues noted, no metal parts, no burnt smell or burnt fluid. Today I came across Ford TSB 24-2184 where they acknowledge that there is an issue with the calibration and controls sensitivity and that replacement of catalytic converters may be necessary. Ford never did any of this. The recall on my truck, which was reprogramming of my PCM also leads to dirty and fouling of the catalytic converter. I have spent over $3000 so far to fix Fords mistakes and not only in nothing fixed, I still have the exact same issues. When i take it to Ford, all the do is clear the codes and then the codes come back on before I get home. So Ford is aware of the issues, knows about the issue and yet will do nothing to fix it.”
The records describe a possible crash, fire, injury, or loss of control.
“Experience HARSH Engagement with transmission both upshift and downshift. Some downshifts at so HARSH, feels like rear wheels are trying to “lock up”. Ford dealer performed recall which did not correct the issues. Ford dealer recommended full transmission replacement. Seems this is a known issue and Ford has admitted fault by issuing a recall in an effort to “fix” the problems with the 10 speed transmission.”
Rearview Camera Fmvss 111 Noncompliance investigation
Moderate severity
Evidence: High confidence
Official record for model year 2020.
Symptom
Rearview Camera FMVSS 111 Noncompliance On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No.
Why it matters
The records describe a problem worth checking before purchase.
Mileage in the reports
In reports that included mileage, this problem showed up around 100,000 to 100,000 miles.
Based on 1 report that included mileage. This is not a failure rate or a prediction.
What to inspect
Ask the inspector to test the named system and record the result.
Ask the inspector to check: Independent pre-purchase inspection.
What may help
Use the official record to focus the inspection and service-history review.
Sources and limitsShowHide
Source recordEvidence: High confidence
The records describe a problem worth checking before purchase.
“Rearview Camera FMVSS 111 Noncompliance
On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.”
Official record covers model years 2018 through 2020.
Symptom
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recline
Why it matters
The records describe a possible crash, fire, injury, or loss of control.
Mileage in the reports
In reports that included mileage, this problem showed up around 22,750 to 95,750 miles.
Based on 10 reports that included mileage. This is not a failure rate or a prediction.
What to inspect
Check the VIN for this recall and ask for the repair receipt if it was completed.
Ask the inspector to check: Independent pre-purchase inspection.
What may help
Confirm the VIN-specific recall status and keep the completion receipt.
Fix listed in the records: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Sources and limitsShowHide
Source recordEvidence: High confidence
The records describe a possible crash, fire, injury, or loss of control.
“Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.”
Official record covers model years 2019 through 2020.
Symptom
Ford Motor Company (Ford) is recalling certain 2019-2020 F-150 vehicles.
Why it matters
The records describe a possible crash, fire, injury, or loss of control.
Mileage in the reports
In reports that included mileage, this problem showed up around 45,000 to 66,000 miles.
Based on 3 reports that included mileage. This is not a failure rate or a prediction.
What to inspect
Check the VIN for this recall and ask for the repair receipt if it was completed.
Ask the inspector to check: Independent pre-purchase inspection.
What may help
Confirm the VIN-specific recall status and keep the completion receipt.
Fix listed in the records: Ford will notify owners, and dealers will inspect the positive battery cable/BMS/PDB joint for excess sealant adhesive and remove any excessive adhesive, reassemble the joint, and retorque the fastener, as necessary, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S40.
Sources and limitsShowHide
Source recordEvidence: High confidence
The records describe a possible crash, fire, injury, or loss of control.
“Ford Motor Company (Ford) is recalling certain 2019-2020 F-150 vehicles. The fastener securing the Power Distribution Box (PDB) 12V cable and Battery Monitoring System (BMS) eyelets to the positive battery terminal may loosen and affect the vehicle's systems such as instrument panel displays and braking or steering assist. The engine could also stall.
Inoperative vehicle systems or an engine stall can increase the risk of a crash. Reduced braking and steering efforts increases the risk of a crash. This condition could also create a resistive short, increasing the risk of a fire.
Ford will notify owners, and dealers will inspect the positive battery cable/BMS/PDB joint for excess sealant adhesive and remove any excessive adhesive, reassemble the joint, and retorque the fastener, as necessary, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S40.”
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires.
Why it matters
The records describe a possible crash, fire, injury, or loss of control.
What to inspect
Check the VIN for this recall and ask for the repair receipt if it was completed.
Ask the inspector to check: Independent pre-purchase inspection.
What may help
Confirm the VIN-specific recall status and keep the completion receipt.
Fix listed in the records: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Sources and limitsShowHide
Source recordEvidence: High confidence
The records describe a possible crash, fire, injury, or loss of control.
“Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.”
Official record covers model years 2018 through 2020.
Symptom
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 trucks equipped with high series LED headlamps with Autolamp (On/Off) functionality.
Why it matters
The records describe a possible crash, fire, injury, or loss of control.
Mileage in the reports
In reports that included mileage, this problem showed up around 45 to 45 miles.
Based on 1 report that included mileage. This is not a failure rate or a prediction.
What to inspect
Check the VIN for this recall and ask for the repair receipt if it was completed.
Ask the inspector to check: Independent pre-purchase inspection.
What may help
Confirm the VIN-specific recall status and keep the completion receipt.
Fix listed in the records: Ford will notify owners, and dealers will reprogram the body control module, free of charge. The recall began March 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C03.
Sources and limitsShowHide
Source recordEvidence: High confidence
The records describe a possible crash, fire, injury, or loss of control.
“Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 trucks equipped with high series LED headlamps with Autolamp (On/Off) functionality. The Daytime Running Lamps (DRL) may remain activated instead of dimming to parking lamps when the Master Lighting Switch (MLS) is manually rotated from the "Autolamps" switch position to "Headlamps On." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.
Ford will notify owners, and dealers will reprogram the body control module, free of charge. The recall began March 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C03.”
Ford Motor Company (Ford) is recalling certain 2020 Ranger and F-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 Expedition vehicles equipped with a "police" package.
Why it matters
The records describe a possible crash, fire, injury, or loss of control.
Mileage in the reports
In reports that included mileage, this problem showed up around 23,815 to 95,250 miles.
Based on 6 reports that included mileage. This is not a failure rate or a prediction.
What to inspect
Check the VIN for this recall and ask for the repair receipt if it was completed.
Ask the inspector to check: Independent pre-purchase inspection.
What may help
Confirm the VIN-specific recall status and keep the completion receipt.
Fix listed in the records: Ford will notify owners, and dealers will inspect and correct the shift cable locking clip installation, as necessary, free of charge. The recall began April 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S18.
Sources and limitsShowHide
Source recordEvidence: High confidence
The records describe a possible crash, fire, injury, or loss of control.
“Ford Motor Company (Ford) is recalling certain 2020 Ranger and F-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 Expedition vehicles equipped with a "police" package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different gear than the gear shift position selected by the driver.
If the transmission selection does not match the indicated gear selection, and the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of injury or crash.
Ford will notify owners, and dealers will inspect and correct the shift cable locking clip installation, as necessary, free of charge. The recall began April 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S18.”
Ford Motor Company (Ford) is recalling certain 2020 F-150 vehicles.
Why it matters
The records describe a possible crash, fire, injury, or loss of control.
Mileage in the reports
In reports that included mileage, this problem showed up around 23,750 to 65,500 miles.
Based on 4 reports that included mileage. This is not a failure rate or a prediction.
What to inspect
Check the VIN for this recall and ask for the repair receipt if it was completed.
Ask the inspector to check: Independent pre-purchase inspection.
What may help
Confirm the VIN-specific recall status and keep the completion receipt.
Fix listed in the records: Ford will notify owners, and dealers will replace the starter motor B+ power supply attachment nut, free of charge. The recall began August 25, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S40.
Sources and limitsShowHide
Source recordEvidence: High confidence
The records describe a possible crash, fire, injury, or loss of control.
“Ford Motor Company (Ford) is recalling certain 2020 F-150 vehicles. An incorrect attachment nut may have been used to attach the battery positive (B+) power supply cable to the starter motor, possibly affecting the electrical conductivity, resulting in excess heat and electrical arcing.
Electrical arcing can increase the risk of a fire.
Ford will notify owners, and dealers will replace the starter motor B+ power supply attachment nut, free of charge. The recall began August 25, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S40.”
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles.
Why it matters
The records describe a possible crash, fire, injury, or loss of control.
Mileage in the reports
In reports that included mileage, this problem showed up around 100,000 to 100,000 miles.
Based on 1 report that included mileage. This is not a failure rate or a prediction.
What to inspect
Check the VIN for this recall and ask for the repair receipt if it was completed.
Ask the inspector to check: Independent pre-purchase inspection.
What may help
Confirm the VIN-specific recall status and keep the completion receipt.
Fix listed in the records: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
Sources and limitsShowHide
Source recordEvidence: High confidence
The records describe a possible crash, fire, injury, or loss of control.
“Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Reduced rearward visibility can increase the risk of a crash.
Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.”
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles.
Why it matters
The records describe a possible crash, fire, injury, or loss of control.
Mileage in the reports
In reports that included mileage, this problem showed up around 33,750 to 61,250 miles.
Based on 2 reports that included mileage. This is not a failure rate or a prediction.
What to inspect
Check the VIN for this recall and ask for the repair receipt if it was completed.
Ask the inspector to check: Independent pre-purchase inspection.
What may help
Confirm the VIN-specific recall status and keep the completion receipt.
Fix listed in the records: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Sources and limitsShowHide
Source recordEvidence: High confidence
The records describe a possible crash, fire, injury, or loss of control.
“Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.”
Official record covers model years 2018 through 2020.
Symptom
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles.
Why it matters
The records describe a possible crash, fire, injury, or loss of control.
Mileage in the reports
In reports that included mileage, this problem showed up around 9,250 to 64,000 miles.
Based on 10 reports that included mileage. This is not a failure rate or a prediction.
What to inspect
Check the VIN for this recall and ask for the repair receipt if it was completed.
Ask the inspector to check: Independent pre-purchase inspection.
What may help
Confirm the VIN-specific recall status and keep the completion receipt.
Fix listed in the records: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Sources and limitsShowHide
Source recordEvidence: High confidence
The records describe a possible crash, fire, injury, or loss of control.
“Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.”
Official record covers model years 2019 through 2020.
Symptom
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-20
Why it matters
The records describe a possible crash, fire, injury, or loss of control.
What to inspect
Check the VIN for this recall and ask for the repair receipt if it was completed.
Ask the inspector to check: Independent pre-purchase inspection.
What may help
Confirm the VIN-specific recall status and keep the completion receipt.
Fix listed in the records: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Sources and limitsShowHide
Source recordEvidence: High confidence
The records describe a possible crash, fire, injury, or loss of control.
“Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.”
Official record covers model years 2018 through 2020.
Symptom
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 vehicles previously repaired incorrectly under recall number 20V097.
Why it matters
The records describe a possible crash, fire, injury, or loss of control.
Mileage in the reports
In reports that included mileage, this problem showed up around 45 to 45 miles.
Based on 1 report that included mileage. This is not a failure rate or a prediction.
What to inspect
Check the VIN for this recall and ask for the repair receipt if it was completed.
Ask the inspector to check: Independent pre-purchase inspection.
What may help
Confirm the VIN-specific recall status and keep the completion receipt.
Fix listed in the records: Dealers will reprogram the body control module software, free of charge. Owner notification letters are expected to be mailed July 6. 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26C28. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
Sources and limitsShowHide
Source recordEvidence: High confidence
The records describe a possible crash, fire, injury, or loss of control.
“Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 vehicles previously repaired incorrectly under recall number 20V097. When the headlight switch is turned from "Autolamps" to "Headlamps On," the Daytime Running Lamps (DRLs) may remain fully bright instead of dimming to parking lamps as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Daytime Running Lamps that do not dim may reduce the visibility of other drivers, increasing the risk of a crash.
Dealers will reprogram the body control module software, free of charge. Owner notification letters are expected to be mailed July 6. 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26C28. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.”
Official record covers model years 2017 through 2020.
Symptom
Certain 2017-2020 Model Year F-150 Equipped with a 3.5L GTDI Engine Powertrain Control Module Reprogram for Cam Phaser Rattle Reports of Transmission Shudder after PCM Reprogram: Dealers are instructed to stop performing this field service action until further notice.
Why it matters
The records describe a problem worth checking before purchase.
Mileage in the reports
In reports that included mileage, this problem showed up around 16,000 to 102,250 miles.
Based on 36 reports that included mileage. This is not a failure rate or a prediction.
What to inspect
Ask the inspector to test the named system and record the result.
Ask the inspector to check: Independent pre-purchase inspection.
What may help
Use the official record to focus the inspection and service-history review.
Sources and limitsShowHide
Source recordEvidence: High confidence
The records describe a problem worth checking before purchase.
“Certain 2017-2020 Model Year F-150 Equipped with a 3.5L GTDI Engine Powertrain Control Module Reprogram for Cam Phaser Rattle Reports of Transmission Shudder after PCM Reprogram: Dealers are instructed to stop performing this field service action until further notice. This shudder is under investigation.”
The records describe a problem worth checking before purchase.
“Certain 2017-2020 Model Year F-150 Equipped with a 3.5L GTDI Engine Powertrain Control Module Reprogram for Cam Phaser Rattle Reports of Transmission Shudder after PCM Reprogram: Dealers are instructed to stop performing this field service action until further notice. This shudder is under investigation.”
The records describe a problem worth checking before purchase.
“Certain 2017-2020 Model Year F-150 Equipped with a 3.5L GTDI Engine Powertrain Control Module Reprogram for Cam Phaser Rattle Reports of Transmission Shudder after PCM Reprogram: Dealers are instructed to stop performing this field service action until further notice. This shudder is under investigation.”
Official record covers model years 2017 through 2020.
Symptom
In some of the affected vehicles, an undesirable noise may develop from the cam phasers in the 3.5L GTDI engine.
Why it matters
The records describe a problem worth checking before purchase.
Mileage in the reports
In reports that included mileage, this problem showed up around 16,000 to 101,000 miles.
Based on 35 reports that included mileage. This is not a failure rate or a prediction.
What to inspect
Ask the inspector to test the named system and record the result.
Ask the inspector to check: Independent pre-purchase inspection.
What may help
Use the official record to focus the inspection and service-history review.
Sources and limitsShowHide
Source recordEvidence: High confidence
The records describe a problem worth checking before purchase.
“In some of the affected vehicles, an undesirable noise may develop from the cam phasers in the 3.5L GTDI engine. This noise might occur as a rattle when starting the engine after the vehicle was turned off for an extended period of time or as a knocking noise when the engine is idling after it is warmed up. These concerns should be addressed by the updated calibration provided in FSA 21B10. However, for peace of mind, Ford is providing an extended warranty for customers who receive the PCM update under program 21B10 prior to December 31, 2021 and continue to experience cam phaser noise after receiving that PCM update, A cam phaser that has developed an undesirable noise does not affect the vehicle safety, performance, or emissions. ”
The records describe a problem worth checking before purchase.
“In some of the affected vehicles, an undesirable noise may develop from the cam phasers in the 3.5L GTDI engine. This noise might occur as a rattle when starting the engine after the vehicle was turned off for an extended period of time or as a knocking noise when the engine is idling after it is warmed up. These concerns should be addressed by the updated calibration provided in FSA 21B10. However, for peace of mind, Ford is providing an extended warranty for customers who receive the PCM update under program 21B10 prior to December 31, 2021 and continue to experience cam phaser noise after receiving that PCM update, A cam phaser that has developed an undesirable noise does not affect the vehicle safety, performance, or emissions. ”
The records describe a problem worth checking before purchase.
“In some of the affected vehicles, an undesirable noise may develop from the cam phasers in the 3.5L GTDI engine. This noise might occur as a rattle when starting the engine after the vehicle was turned off for an extended period of time or as a knocking noise when the engine is idling after it is warmed up. These concerns should be addressed by the updated calibration provided in FSA 21B10. However, for peace of mind, Ford is providing an extended warranty for customers who receive the PCM update under program 21B10 prior to December 31, 2021 and continue to experience cam phaser noise after receiving that PCM update, A cam phaser that has developed an undesirable noise does not affect the vehicle safety, performance, or emissions. ”
Official record covers model years 2017 through 2020.
Symptom
In some of the affected vehicles, an undesirable noise may develop from the cam phasers in the 3.5L GTDI engine.
Why it matters
The records describe a problem worth checking before purchase.
Mileage in the reports
In reports that included mileage, this problem showed up around 16,000 to 101,000 miles.
Based on 35 reports that included mileage. This is not a failure rate or a prediction.
What to inspect
Ask the inspector to test the named system and record the result.
Ask the inspector to check: Independent pre-purchase inspection.
What may help
Use the official record to focus the inspection and service-history review.
Sources and limitsShowHide
Source recordEvidence: High confidence
The records describe a problem worth checking before purchase.
“In some of the affected vehicles, an undesirable noise may develop from the cam phasers in the 3.5L GTDI engine. This noise might occur as a rattle when starting the engine after the vehicle was turned off for an extended period of time or as a knocking noise when the engine is idling after it is warmed up. These concerns should be addressed by the updated calibration provided in FSA 21B10. However, for peace of mind, Ford is providing an extended warranty for customers who receive the PCM update under program 21B10 prior to December 21, 2021 and continue to experience cam phaser noise after receiving that PCM update.”
The records describe a problem worth checking before purchase.
“In some of the affected vehicles, an undesirable noise may develop from the cam phasers in the 3.5L GTDI engine. This noise might occur as a rattle when starting the engine after the vehicle was turned off for an extended period of time or as a knocking noise when the engine is idling after it is warmed up. These concerns should be addressed by the updated calibration provided in FSA 21B10. However, for peace of mind, Ford is providing an extended warranty for customers who receive the PCM update under program 21B10 prior to December 21, 2021 and continue to experience cam phaser noise after receiving that PCM update.”
The records describe a problem worth checking before purchase.
“In some of the affected vehicles, an undesirable noise may develop from the cam phasers in the 3.5L GTDI engine. This noise might occur as a rattle when starting the engine after the vehicle was turned off for an extended period of time or as a knocking noise when the engine is idling after it is warmed up. These concerns should be addressed by the updated calibration provided in FSA 21B10. However, for peace of mind, Ford is providing an extended warranty for customers who receive the PCM update under program 21B10 prior to December 21, 2021 and continue to experience cam phaser noise after receiving that PCM update.”