2022 Volkswagen Taos

On 7/9/2026, my 2022 VW Taos was brought to the dealer for being severely underpowered, check engine lights on, and a strong raw fuel smell inside the vehicle. On 7/10/2026, the dealer stated the vehicle was ready, claiming they replaced a turbo charge pipe O-ring. The service advisor verbally stated the vehicle had been successfully test-driven for 5 miles on streets and the highway. However, official paperwork only stated "cleared faults verified no leaks in system, vehicle is now operating as designed." Immediately upon driving home on the highway, as the vehicle reached 70–75 mph under load, a loud whistling noise and a sudden, dangerous loss of propulsion occurred simultaneously. The vehicle was returned to the dealer on 7/10/2026. On 7/13/2026, the vehicle was picked up after a second repair where the dealer admitted the plastic charge pipe (05E-145-673-Q) was actually fractured and had completely blown off the turbocharger during my highway drive, generating fault code P227900 (Intake Air System Leak). Upon reviewing the paperwork from both visits, I discovered the odometer had only increased by exactly 1 mile during the first service visit. The dealer completely failed to road-test the vehicle under actual highway boost loads before certifying it as safe, which directly caused a catastrophic structural engine failure and an emergency safety hazard at 75 mph.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

While driving at highway speeds, the a low coolant caution light came on. We immediately pulled over before the engine overheated and added coolant and brought the vehicle in for repairs. This Taos currently has 43,000 miles and needs its head gasket replaced for the SECOND time. The first head gasket was replaced on 12/23 with 16,000 miles under a technical bulletin by VW. This is a know issue for this vehicle. With a head gasket failure, this can lead to engine overheating and seizing. This needs to be a recall.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

There have been multiple complaints of the mechatronics unit failing prematurely. I am facing that right now and it should be under warranty but is being challenged. So many people have mentioned the mechatronics unit failing prematurely upon research and discussion with the dealership. The car stalled on the freeway and I was unable to accelerate. It was confirmed and being worked on by the dealer. All regular maintenance has been done. “Trans in emergency mode. You can keep driving.” Showed up 5 minutes before the car stalled

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The engine coolant is leaking and the cylinder head gasket is leaking at the back of the engine. This requires full replacement. This is a known issue with Technical Service Bulletin 15-23-01 from Volkswagen back in 2023, and both VW and our Dealership are refusing to cover the costs of replacement.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2022 Volkswagen Taos. The contact stated that while driving at various speeds, the vehicle unintendedly decelerated. The contact associated the failure with NHTSA Campaign Number: 22V687000 (Engine and Engine Cooling). The contact associated the failure with the recall. The contact stated that several unknown warning lights and the EPC and engine temperature warning lights were illuminated. The contact stated that the dealer was contacted but was unable to determine the cause of the failure. The manufacturer was made aware of the failure. The failure mileage was approximately 25,000.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2022 Volkswagen Taos. The contact stated that while driving at an undisclosed speed, several unknown warning lights illuminated, and the engine seized. The contact stated that while attempting to restart the vehicle, the vehicle failed to start. The vehicle was towed to the dealer to be inspected; however, the failure was not duplicated. The failure reoccurred. The vehicle was taken back to the dealer; but the failure was not duplicated. The contact was informed that an adjustment to the fuel system was performed. The vehicle was repaired but the failure reoccurred. The failure was persistent. The contact stated that the failure had occurred with minor children inside the vehicle. In addition, the contact noticed a fuel odor on the interior of the vehicle. The vehicle was driven to the residence. The vehicle was later towed to an independent mechanic where it was diagnosed with high and low fuel pump failures. The contact was informed that the high and low fuel pumps needed to be replaced. The vehicle was repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 45,009.

Reported

Jun 2026

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

The systems failing are electrical, engine, and fuel/propulsion systems. VW TAOS 2022 purchased Sept. 2023. Two weeks after purchasing the vehicle, I'm driving down the street and the vehicle began to lose power and start slowing down. It eventually cut off. About a week later, I experienced the same issue. I called the dealer and they had me to bring my car in. I was told that they couldn't find the problem, but that the car was misfiring. They "repaired" and returned it to me. As I drove on local streets and the interstate, I have problems with acceleration. The car does not pick up speed like it should and lags behind and then suddenly jerks forward (even after battery rest times during a stop). It rides a bit rough. Occasionally, my dashboard blacks out while I'm driving. My auto-start doesn't always work, even after the fob batteries have been changed. My gas seems to disappear and I find myself gassing up more often than I should be. I would contact the dealership, they'd coordinate service around my scheduled service dates and claim that they could never find or duplicate the problems that I'm having. The problems continue. My engine light came on while I was driving and stayed on. I was told to bring in my car. The dealership kept it from July-Sept 2025, replacing parts and then returned it to me. Two days later the engine light came back on and I had to return to the dealer again for service. After leaving a parking lot (Jun 2026), two blocks down the street the TAOS began to lose power, the engine light is flashing and the EPC code (engine control malfunction) light lit up. I called VW and they dispatched a tow. My TAOS was towed to Checkered Flag VW. My safety (and others) is at risk because the power loss just happens without warning. If a driver is not paying attention, they could run into the back of me or hit me on the side during a lane change due to the slow movement.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The EVAP line has a fault, stuck open, affects nothing whatsoever. But has every single light on the dash on. It tells me the brakes don't work, the air bags don't work, the cruise doesn't work. Everything. The confusing thing is some things actually work and some don't. The brakes work, the cruise doesn't. The auto detection doesn't work. What's worse, you can't replace that part. No one sells it. This is absolutely horrendous and very dangerous.

Reported

Jun 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Had my car in at a Volkswagen dealership for its routine maintenance they called me back, letting me know that I had the head gasket leak and that coolant was leaking.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Head gasket failure is a known issue for this model. Some owners report failure at 12k miles in for quite some time. I am now faced with this known issue VW has had time to remedy. If it is a known failure why not take care of it especially if it spans across 3 models 2022 - 2024. I should not have to absorb this type of repair 4 years 57k miles in on my vehicle. Of course, everything pops up right as warranties expire. I was refused even dealer “good faith” for being 7,000 miles over the threshold VW powertrain warranty of 4 years 50k miles. Now to find $4638.83 for parts plus whatever labor will be.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The vehicle has intermittent hesitation/delayed acceleration from a stop and during low-speed stop-and-go driving. At times, engine RPM increases before the vehicle responds or accelerates normally. This creates a safety concern when entering traffic, turning, merging, or accelerating from a stopped position because the vehicle does not always respond predictably to throttle input. The concern was reported to a Volkswagen dealer in writing during a prior repair process and was later formally documented on a repair order as hesitation on acceleration. The vehicle has prior Volkswagen repair history involving a coolant warning/low coolant concern, head gasket repair, and later camshaft seal/belt cover repair. After the most recent repair, the delayed acceleration/hesitation concern remained unresolved. The vehicle is currently under review with Volkswagen Customer Care, but the safety-related drivability concern has not yet been fully resolved. Supporting documents include the 2025 written report of jerking from a stop, the 2026 repair order documenting hesitation on acceleration, and post-repair emails showing the issue remained unresolved. After I notified the dealer in writing that the hesitation/delayed acceleration concern remained after the most recent repair, I did not receive a documented response or resolution, and the concern remains unresolved with Volkswagen Customer Care.

Reported

May 2026

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

The car does not accelerate when the gas is pressed. It will delay, jerk or accelerate slower than it's supposed to.

Reported

May 2026

Incident date

Aug 2024

Mileage

Not provided

Outcome flags

None reported

Electronic parking brake engaged randomly when getting gas and would not disengage letting me leave the pump

Reported

May 2026

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

Clicking noise coming from the driver side tire/axle when making right turns only. The diagnostic at the VW service department was a faulty CV axle is the cause of the noise. VW service associate recommended replacing the CV axle. The vehicle only has 6k miles but unfortunately is no longer under warranty. According to the VW forum on line there are several issues like this on this particular model.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

leaking head gasket

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The SOS module has failed. THIS MEANS AUTOMATIC NOTIFICATION OF A CRASH OR SIGNIFICANT MECHANICAL FAILURE IS NOT FUNCTIONAL. THE MODLE HAS A BATTERY THAT FAILS IS IS NOT AVAILABLE. THE ONLY SOLUTION IS REPLACEMENT OF THE MODULE AT A COST OF $600 TO $800.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

This vehicle has ongoing drivability issues that have not been resolved despite multiple repair attempts involving engine-related components and repairs. The issue began in November 2024 while the vehicle was under warranty with coolant and engine warnings. At that time, I reported coolant loss, warning messages, hesitation during acceleration, and abnormal vehicle vibration. I was initially told no issue existed. Shortly after warranty expiration, the vehicle required a major head gasket repair in 2025 after continuing to exhibit the same coolant-related issues. In 2026, the vehicle required an additional engine-related repair involving a camshaft seal in the same area of the engine that had previously been dismantled and rebuilt. Despite these repairs, the same drivability symptoms remain. The vehicle intermittently hesitates during acceleration, particularly from a stop or during merging conditions, where engine RPM increases significantly before the vehicle responds. The vehicle also exhibits significant steering wheel and seat vibration at highway speeds and during extended driving. These conditions create a potential safety concern because the vehicle does not consistently respond as expected during acceleration and becomes unstable and uncomfortable to operate at highway speeds. The hesitation creates concern when entering traffic, crossing intersections, or attempting to accelerate in situations requiring predictable vehicle response. The issue has been repeatedly presented to the dealership and repair attempts have been performed, including major engine work, but the condition remains unresolved. The repairs were treated as separate isolated issues rather than a continuation of the original condition first reported under warranty. The vehicle has been out of service for approximately 43 days across these repairs. No loaner vehicle was provided during those periods. The vehicle remains in its current condition with unresolved issues.

Reported

May 2026

Incident date

Nov 2024

Mileage

Not provided

Outcome flags

None reported

The contact's daughter owns a 2022 Volkswagen Taos. The contact stated that while her daughter was driving at an undisclosed speed, the engine coolant warning light illuminated. The vehicle was taken to an independent mechanic, who determined that the head gasket needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 35,000.

Reported

May 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

I am filing a safety complaint regarding a 2022 vehicle with approximately 47,000 miles that experienced a sudden and dangerous mechanical failure while in operation. While driving at approximately 37 mph, a dashboard warning message appeared indicating that the vehicle required attention but could continue to be driven for a short period. Shortly after the warning, the vehicle suddenly lost the ability to maintain proper gear engagement. At one point, no gear was engaged at all, creating a hazardous driving situation. I pulled over and turned the vehicle off. After restarting it, I was able to regain limited operation; however, the vehicle would not shift beyond second gear, significantly limiting its drivability and creating an unsafe condition in traffic. This vehicle has been consistently maintained at an authorized dealership according to all recommended service intervals, with no missed or delayed maintenance. The dealership later informed me that the failure was related to the mechatronic system and SOS system. I was also told that the repair would not be covered under warranty. This incident raises serious safety concerns due to the sudden loss of power and gear function while the vehicle was in motion. I am requesting that this issue be reviewed for potential defects that could affect vehicle safety and reliability. I am submitting this complaint so that the issue can be investigated and to help prevent similar incidents from affecting other drivers.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Only 41,000 miles and head gasket is leaking

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Vehicle: 2022 Volkswagen Taos Mileage at Incident: 61,170 On April 21, 2026, while driving shortly after leaving my home, the EPC (Electronic Power Control) warning light suddenly illuminated and the engine warning light began flashing rapidly. The vehicle immediately began jerking, hesitating, and losing power. It started slowing down unexpectedly while in motion. This created a serious safety hazard. I was forced to reduce speed and maneuver to the side of the road to avoid being rear-ended. The sudden loss of power in traffic placed me and other drivers at risk of a collision. After turning the vehicle off and restarting it, both warning lights disappeared. Notably, on April 3, 2026 (60,428 miles), I had an oil change performed. On April 6, the engine light came on and remained illuminated until April 18, then turned off without repair. Three days later, the EPC failure occurred. The dealership was unable to reproduce the issue but charged $190 for diagnostics and stated the problem was a cracked N80 valve line (small leak), quoting approximately $700 for repair. I am aware of reports involving similar issues affecting thousands of vehicles of this model year. Sudden loss of engine power while driving is a clear safety concern, especially when warning lights appear and disappear intermittently. The vehicle remains available for inspection.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Head gasket failure at 42,000 miles. Transmission leak from filter and pan. VW dealership diagnosed.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

I am reporting a safety-related failure involving a 2022 Volkswagen Taos (AWD) with approximately 48,000 miles. While operating the vehicle under normal driving conditions, the vehicle entered “transmission emergency mode” without warning. At that point, the vehicle experienced a significant loss of functionality, downshifting to D1 and including the complete loss of reverse gear. This created a hazardous situation, as I was unable to maneuver the vehicle safely on the highway and in confined or urban environments. The issue was intermittent at first but became persistent, resulting in the vehicle being effectively unsafe to operate. The inability to engage reverse presents a clear safety risk, particularly in situations requiring immediate maneuverability (e.g., parking, avoiding obstacles, or exiting traffic situations). The vehicle was taken to an authorized Volkswagen dealership, where it was diagnosed with an internal transmission failure. The diagnostic fault code provided was P176F00 (K2 clutch out of tolerance due to internal wear). The dealer indicated that the appropriate repair is a full transmission replacement, with an estimated cost of approximately $8,400. Despite the relatively low mileage and the severity of the failure, Volkswagen has declined to provide assistance, citing that the vehicle is just outside of the warranty period. The vehicle has been out of service now for 10 days with no resolution provided. This failure appears to be premature for a major drivetrain component and raises concerns about potential defects affecting the safety and reliability of this vehicle model. The sudden loss of reverse and entry into emergency mode without warning creates a potentially dangerous condition for drivers and others on the road. I am submitting this complaint to document the issue and to request investigation into whether this represents a broader safety-related defect in the vehicle.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

I purchased the vehicle brand new (VW Taos 2022) and have maintained it properly. At approximately 60,000 miles—just outside the warranty period—the vehicle developed a serious transmission issue. While driving, I received a warning stating “Transmission in emergency mode” followed by a check engine light. The vehicle then entered limp mode, limiting shifting to manual gears (M2–M4) and eventually becoming stuck in M2. An authorized Volkswagen dealership diagnosed the issue as a mechatronic failure and quoted approximately $2,000 for repair. I contacted Volkswagen Customer Care to request goodwill assistance, as this represents a premature failure of a major drivetrain component. Given the relatively low mileage, the known issues associated with early model-year Taos vehicles, and the safety implications of the vehicle entering limp mode during operation, I believe this repair should not fall entirely on the consumer.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2022 Volkswagen Taos. The contact stated that while driving 35 MPH, the low coolant warning light illuminated. An independent mechanic was contacted. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the head gasket needed to be replaced. The vehicle was not repaired. The contact stated that the failure had reoccurred approximately ten times. The contact related the failure to Technical Service Bulletin: (15-23-01) Head Gasket Leakage; however, the VIN was not included in the bulletin. The manufacturer was not notified of the failure. The failure mileage was 72,500.

Reported

Apr 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2022 Volkswagen Taos. The contact stated that while driving at an undisclosed speed, there was an exhaust system malfunction warning light illuminated. Additionally, there was engine oil on the driveway. The vehicle was taken to a local dealer and during an oil leak inspection, the dealer found a fuel leak. The dealer confirmed that fuel was leaking from the vehicle and NHTSA Campaign Number: 21V651000 (FUEL SYSTEM, GASOLINE); however, the VIN was not associated with the recall. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 52,000. The VIN was not available.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Giving code 23v214000 fuel pump recall code. Fuel pump went out

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Vin # [XXX] Evap system hose-canister parts regulator valve. Check engine light stays on and this started in June 2025. Gorman McCracken Volkswagen Longview Texas diagnosed. February 1,2025 Low engine coolant light continues to come on. We have had to add coolant for the last two weeks. About 3 gallons used. The back up camera and navigation screen goes black often and has to be reset. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2022 Volkswagen Taos. The contact stated that while the vehicle was started and running, the low coolant warning light illuminated. The coolant reservoir was topped off, and the warning light disappeared. The contact referenced a Technical Service Bulletin with NHTSA ID Number: 10241177 (ENGINE AND ENGINE COOLING); and associated the failure with the TSB. The vehicle was towed to a local dealer but was not repaired. The manufacturer was notified of the failure. The failure mileage was 87,100.

Reported

Feb 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Everytime the car warms after 10 minutes of driving depending on outside temperature, there is a loud popping noise that comes from the passenger side dash windshield area. It sounds like a rock hitting the windshield, startling everyone in the vehicle. Has been happening since new. Dealer will not address the issue.

Reported

Feb 2026

Incident date

Oct 2022

Mileage

Not provided

Outcome flags

None reported

The rear camera blacks out on the dashboard. Sometimes when I start the dashboard, the thing is dark. It doesn't come on even while driving. It mainly happens with the push start option. Occasionally, I've been driving on the highway. And it'll start flashing blinking and then blackout. Also, the gear shifting to accelerate on the gas get stuck. It won't shift, it'll go into neutral mode. Even though it's since drive mode

Reported

Feb 2026

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

Since the purchase of my 2022 VW Taos in 2022, there has been a repeated issue of the check engine light coming on at random times. Each time it has happened the code indicates a problem with the fuel evap system. The issue has been fixed multiple times by replacing parts. There has been no fix for the issue and it still persists. Problems with the fuel evap system puts the drivers and passengers at risk. Being unable to determine an issue with the car and the safety of operating a motor vehicle due to continued negligence by the manufacturer is the opposite of a safe motor vehicle. Additionally, since buying the vehicle there have been repeated issues with the communications module. The module had to be replaced just days after purchasing it. Now, it is not working once again and if there was an emergency, the technology presented when purchasing the car, SOS, information, crash detection, location, etc, is not available to help me. VW presents these as safety features then does nothing to fix their equipment issues that ultimately render these options and functions useless.

Reported

Feb 2026

Incident date

May 2022

Mileage

Not provided

Outcome flags

None reported

while driving a 2022 VW Taos started experiencing a strong wobble in the front driver side tire. It started on a 2.5 hour drive back from dropping my son off at college. While accelerating from 0-40 MPH the wobble would be very strong. After reaching 45 MPH it leveled off. It would wobble more turning or moving to the left than the right side. It was frightening to drive my hour long commute and worry if my tire was going to fall of or, worse yet, would I crash. I could not get in to the VW dealership for a few days prior to this starting. I did not have any lights or warning signs prior to this. When I first spoke about the problem to a few places they were suggested the lug nuts were loose, or perhaps a tire bearing went bad. I took it to my VW dealer and they said the issue was the steering rack and I was originally quoted $7,500 to fix it. Steve at my dealership was great and moved mountains to get the price lowered and my car repaired. However I find it hard to believe that 4 year old car with 80,000 miles on it should have this kind of major repair. I had to rent a car for a few days and then VW was able to provide me with loaner. I have had issues with my 2022 VW since I purchased it during Covid and just wonder if that is that is part of the issue. Cheaper parts being used - perhaps not tested or as reliable. I just wanted to report this and see if any other 2022 VW TAOS's were experiencing the same issue and if a TSB should be issued or a recall. I had one thing fixed in the past and then a recall was issued but I was denied reimbursement since I did not use VW parts to fix the problem. I am trying to avoid that from happening again. I have owned VW's for over 20 years and I appreciate their dependability, gas mileage and longevity as I drive a lot. thank you.

Reported

Jan 2026

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

Since we bought the vehicle new in 2022, it has had an ongoing brake noise at low speeds. It sounds like a screeching or grinding, and I only hear it when I press the brake pedal. It is most noticeable right after startup when driving slowly. The main issue I am reporting is uneven rear brake pad wear, which may indicate the rear brake system is not applying evenly or not functioning correctly. The component involved is the rear brake system (rear brake pads and related parts). The vehicle is available for inspection upon request. A Volkswagen dealership confirmed an uneven wear condition. On 12/31/2025, the dealership performed an inspection and recorded that the left rear brake pad measured 3 mm while the right rear measured 8 mm. They recommended replacing the rear brake pads but did not diagnose or repair the cause of why one rear side is wearing much faster than the other. In prior visits, the dealership stated the noise was related to the type/quality of brake pads used. When I contacted the dealership again about the ongoing noise and the uneven wear, they stated they did not have a solution to correct the underlying problem and referred me to Volkswagen Customer Care, indicating they cannot get the brakes functioning beyond replacing pads. Volkswagen Customer Care then advised me I would need to work through the dealership. I believe this creates a safety risk because uneven rear brake wear may mean the brakes are not working the same on both sides, which could affect stopping distance or braking stability, and could lead to brake problems if one side wears out much sooner than the other. There have been no warning lights or messages. The symptoms began soon after purchase in 2022 and have continued over time.

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Component or system that failed or malfunctioned Rear brake rotors and rear brake pads. Both rear rotors have been diagnosed as requiring replacement along with rear brake pads. The front rotors and pads are reported to be in normal condition. The vehicle and all replaced components are available for inspection upon request. Safety risk Degraded rear braking performance increases stopping distance and could lead to brake vibration, uneven braking, or reduced control during emergency braking, posing a potential safety risk to the driver and others. Confirmation or reproduction of the problem The issue has been confirmed by a dealership service department, which recommended replacement of the rear rotors and rear brake pads. The vehicle has approximately 16,000 miles and is just over 4 years old. During the service visit, dealership staff stated that this type of rear brake wear occurs frequently with these vehicles. The dealership also indicated that Volkswagen previously replaced rear rotors and pads under warranty for similar issues at approximately 24,000 miles or 2 years, but that this coverage is no longer available. Because this vehicle was driven significantly less than average, it did not reach those mileage thresholds within that earlier timeframe. Inspections performed The vehicle has been inspected by a dealership service center. It has not been inspected by the manufacturer, police, or insurance representatives at this time. Additional details / driving conditions The vehicle has been driven very infrequently, with low-mileage trips on flat roads in Charleston, South Carolina. There has been no aggressive driving, towing, mountainous driving, or heavy stop-and-go use. The front brakes remain in normal condition. Given the low mileage, light usage, and prior warranty replacements for similar conditions, rear rotor and pad replacement at this mileage appears premature and abnormal.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

I purchased a 2022 Volkswagen Taos from TOM‘s VW, Union, New Jersey on Sep 23, 2023. At the time of purchase, the vehicle had approximately 19000 miles. Unfortunately, I experienced the engine light illuminating after starting the car at the end of October 2024. I brought this issue to Tom's VW's attention in Nov, 2024 - 1) I made an appointment with Tom's VW, and the first time I went to the dealership was on Nov 2, 2024. Since then, we have come to Tom's VW dealership to fix the same issue at least 6 times, the latest one was on May 15, 2025. 2) The car has been kept in the dealership's shop since it was drop off at the dealership on May 15, 2025. It's still kept in the dealership's shop now. 3) Several times we were told the problem was resolved and we could pick up the car, but the problem would usually reappear the next day. We immediately called Tom's VW to inform them and ask if it was safe to drive the car before it was delivered to Tom's VW again, since the problem involved the engine. However, we were told there was no safety issue. This concerns the engine, and the problem remains unresolved after a year, with no explanation for the cause of the engine light illuminating. We've been repeatedly told there's no safety issue and we can continue driving. Given this situation, I strongly suspect a serious engine-related quality problem with the car, and that the dealer's advice—that we can continue driving—poses a safety hazard.

Reported

Dec 2025

Incident date

Nov 2024

Mileage

Not provided

Outcome flags

None reported

I am reporting a repeated safety-related defect involving exhaust intrusion into the cabin of my 2022 Volkswagen Taos. The vehicle experienced loss of power, coolant loss, and engine warning indicators, and was serviced twice by Volkswagen Southtowne in Sandy, Utah. First Incident – Vehicle Returned as “Safe to Drive” During the first repair visit, the dealer diagnosed issues involving the manifold/exhaust area, head gasket, coolant system, and catalytic converter. After keeping the vehicle for an extended period, the dealership informed me the vehicle was “safe to drive,” although the repair was not fully completed. I relied on this representation. After the vehicle was returned to me, I began experiencing significant physical symptoms only while driving the vehicle, including nausea, dizziness, and vomiting. These symptoms occurred repeatedly during operation and would subside after leaving the vehicle. At the time, I did not understand that these symptoms were caused by exhaust entering the cabin. Second Incident – Defect Confirmed and Additional Repairs Performed Weeks later, the symptoms persisted and I returned the vehicle to the same dealership. At this second visit, the dealer reported coolant leakage and additional gasket failures. They removed the cylinder head, replaced gaskets, and performed additional exhaust-related repairs. I was provided a loaner vehicle during this extended repair. After this second repair, the symptoms while driving stopped. Safety Concern Based on the timing of symptoms, the repair records, and the resolution following the second repair, I believe that exhaust gases were entering the cabin of the vehicle during normal operation for an extended period. This created a significant safety hazard. I was repeatedly assured the vehicle was “safe to drive” when it was not. I unknowingly operated the vehicle while being exposed to exhaust fumes for several months. The condition caused physical illness, impaired my ability.

Reported

Dec 2025

Incident date

Apr 2024

Mileage

Not provided

Outcome flags

None reported

2022 Volkswagen Taos SE 1.5T (DNKA engine, <60,000 miles, <5 years old) developed internal coolant leak from cylinder head gasket. On 11/03/2025 Smith Volkswagen, Wilmington, DE (RO 692953/1) performed coolant system pressure test and confirmed leak coming from cylinder head gasket area at rear of engine below turbo (exactly as shown in Figures 1 & 2 of VW TSB 15-23-01). Dealer noted possible related engine damage that may require complete engine replacement in addition to head gasket. Vehicle available for inspection upon request. Safety risk: loss of coolant can cause sudden engine overheating, power loss, or seizure while driving, creating risk of crash, stranding, or fire. Symptoms began November 2025 with “Check Coolant” warning; reservoir was below MIN. Added coolant once; warning has not returned, but pressure test proved ongoing internal leak. No visible external drips. This exact failure is a known manufacturing defect per Volkswagen Technical Service Bulletin 15-23-01 (Transaction 2071245/1, issued 08/17/2023), which states: “Original engine production head gasket design can lead to coolant leaks” and was redesigned as of engine DNKA 234 458 (July 27, 2023). Despite VW’s own bulletin documenting the defective gasket in all 2022–2023 Taos/Jetta 1.5T engines built before the fix, VW classifies the TSB as “information only” with no warranty coverage. VW Goodwill offered only 50% assistance on the $4,927 head gasket replacement and nothing toward a potential full engine replacement, leaving owner responsible for thousands of dollars in repairs on a documented factory defect in a low-mileage, young vehicle.

Reported

Dec 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

Paint is peeling along panel edges and roof seams. A VW inspector confirmed original OEM paint. Multiple VW Taos owners have reported similar clear coat failures. Not impact-related and not environmental damage. VW, however, refuses to accept responsibility.

Reported

Nov 2025

Incident date

Aug 2024

Mileage

Not provided

Outcome flags

None reported

The vehicle has had repeated issues related to the fuel system, including strong fuel odor inside the cabin, a gurgling sound coming from the fuel tank area, and recurring check engine lights shortly after a previous recall repair was completed. The most recent diagnostic from the dealer indicated a faulty fuel tank pressure sensor (G400), but I was initially told the vehicle needed a fuel pressure release valve. There has been inconsistency in the diagnostics and explanations provided to me. The fuel smell in the cabin and apparent pressure issues in the tank created a safety concern for me and my passengers, especially while driving with windows closed or using cabin heat. I am concerned about a potential fuel leak or improper tank venting. The problem has occurred multiple times, including at least five check engine lights after the recall repair. The dealer has inspected the vehicle several times, but the issue has not been fully resolved, and additional related parts (such as the tank shutoff valve) were recommended for replacement. Warning lights included repeated check engine indicators, and the fuel odor occurred each time the issue recurred. The vehicle is available for inspection upon request.

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

2022 VW Taos Head Gasket failure at 63,000 miles. Coolant leaking. Potential for engine seizure/fire. Manufacturer is aware of defect (TSB 2071245/1) but refuses to assist.

Reported

Nov 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

My car is only 14,200 miles and the rear brakes are gone, I need to find help because is a safety concern and VW doesn’t want it to replace because the extended warranty is already expired, but nobody, either the VW or the dealership where I bought my car informed me regarding this issue and the extended warranty. The issue is not only for me there are a lot of customers having the same issue and VW and the dealership want me to pay for their original cheap brakes, the dealer wants to sell me new brakes for $400.00. Customer Service did not want to help. This morning I almost crash when I tried to stop at the light.

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

i got a 2022 volkswagen Taos the end of may 2025, it has been 6 months. a month after getting it i reported to the dealership that i felt like i had a wobbly tire, they looked at it and said it was fine. i have felt like it has gotten worse within the past few months so i brought it into a shop, they called me back yesterday saying i have a problem with the transmission. i’m not sure how i don’t have any warranty, but i now have to come out of pocket for the transmission. no lights came on, there was no warning. i tried driving it home after and its shifting so badly it’s now not safe to drive and im scared ill be in an accident. so im forced to fix the issue now. i’m having it sent to the dealership today but wanted to make a report to have this vehicle recalled.

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

I took the vehicle in for its 80,000 service, which included a multiple point inspection on Oct. 24th, 2025. The dealer that serviced my vehicle for that specific service was the north park volkswagen in San Antonio. On October 30, 2025 at approximately 2:15 PM, I was driving down the highway when I felt something in the brakes crack. I had to use my whole body weight and a lot of force to stop the vehicle, which could have ended in a fatal accident. I took the vehicle to the nearest Firestone with the parking brake close to my hand, where a certified technician inspected it and found that a brake line had been improperly reattached using glue and duct tape, posing a major safety hazard. There was visible glue residue and tape wrapped around the brake line. Because Firestone could not obtain the necessary part and did not feel confident repairing a European vehicle, I then took my car to Ancira Volkswagen in San Antonio. Their technicians confirmed that the brake line repair using glue and tape would not have lasted long had it been at the 70,000 service over 6 months go further proving that this unsafe and makeshift repair was done recently. When I reported this issue to North Park Volkswagen, the service manager, Albert Zapata, was rude, dismissive, and denied all responsibility, implying that I could have caused the damage myself. This situation reflects negligence and a failure to perform a proper inspection or maintain safety standards. The workmanship and lack of accountability from North Park Volkswagen directly put my life at risk.

Reported

Nov 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

I purchased the vehicle in 2022 & in 2023 the low coolant light turned on. Now at 54k miles the low coolant light has turned on again and the head gasket is definitely leaking. I’m out of warranty because I’ve hit 54k miles. This is absolutely unacceptable for a brand new car.

Reported

Nov 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

My head gasket is leaking and I saw that VW had other complaints about the engine code DNKA for year 2022 and after July 2023 the company had made a decision to redesign the head gasket and coatings. I don’t understand how this isn’t a recall just yet especially knowing that Taos 2022, has many problems than an average car. The dealership says I’m responsible for paying it but yet I have proof that the design of the gasket of my vehicle was a manufactured defect. Please please do something about this or help us that have purchased. I’ve invested 20k into this car and for me taking it in 3,4 times a year isn’t realistic and reliable.

Reported

Nov 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

I've been having issues with my car since I bought it. I've taken the car in for the Power Train System, and the codes that come up are P0456 and P2421. This car has a mind of its own. I've driven it and it started lagging, and I went into limp mode just crossing a 2 way stop with ongoing traffic. I don't understand how VW doesn't address this problem when I know that if anyone were in my shoes, they wouldn't have dealt with this, going to the dealership 3,4 times a year when I should only be going in frequently for oil changes. The dealership says after my warranty is over, I have to pay out of pocket, but I don't see why, when it's been an ongoing issue and VW needs to have an extended warranty, because I know I am not the only one with issues. Reddit has thousands of complaints about VW, but it's our problem that they couldn't produce a reliable car. The dealership has been aware of this for 4 years since I bought my car in June 2021. I have had the engine light come on every 3 -5 months since June 2021, and it's always the same when they replace a whole part. I have all the paperwork and all the information on what they perform on my car. I am a regular. citizen, and I only make around 30K a year, if I were able to, I would get another car, but I've literally invested 20K in this car, and it's ridiculous how unreliable and how I constantly have to worry if the car will work. I don't have a scanner, so I uploaded how many times I've been to the dealership for one car.

Reported

Oct 2025

Incident date

Aug 2021

Mileage

Not provided

Outcome flags

None reported

Vehicle lost power control due to engine malfunction. This was caused by a leak in the coolant head gasket. This is an issue that Volkswagen has already identified with these cars, but has neglected to recall.

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

​This statement is to formally document my ongoing and serious concerns regarding my 2022 Volkswagen Taos, which has been in and out of the Pasadena Volkswagen, California, service department for the past three weeks due to a persistent fuel smell and related fuel system issues. ​Despite the recent maintenance and attempted repairs, the vehicle continues to exhibit these dangerous problems. Most alarmingly, during a recent incident, the vehicle almost completely shut off while I was driving on the freeway. This is a critical safety hazard, and the safety of my family is paramount. I cannot accept driving a vehicle that poses such a risk of breakdown in traffic. ​Adding to my unease with the fuel issues is the fact that this specific vehicle has also previously required repair for seized rear brake calipers. Given the numerous reported complaints about the 2022 VW Taos model and the repeated, severe issues my own vehicle has experienced—from brake failure to dangerous fuel system problems—I am profoundly concerned about its reliability and long-term safety. ​The continuing issues make it difficult, if not impossible, to drive this vehicle without significant anxiety. I request an urgent and definitive resolution to these safety-critical fuel problems.

Reported

Oct 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

My 2022 Volkswagen Taos is less than 4 years old, has 23,500 miles and I have had to replace the rear brake pads twice. After 14 months in service, the rear brake pads were prematurely worn and replaced under warranty extension at 8,900 miles. This is a known issue--see this bulletin from VW: [XXX] . But the root cause issue has not been solved. At 23,500 miles, the rear brake pads were at 2mm and I had to replace them again, only two years later. So every one (1) to two (2) years, the rear brake pads on a VW Taos have to be replaced. Make it make sense. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2022 Taos vehicles equipped with all-wheel drive. The engine control unit (ECU) software may cause a stall when coming to a stop.

Risk: An engine stall increases the risk of a crash.

Remedy: Dealers will update the ECU software, free of charge. Owner notification letters were mailed October 5, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 24HH.

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2022 Taos vehicles. The underhood fuel supply quick-connector may detach from the fuel supply line causing a fuel leak in the engine compartment.

Risk: A fuel leak may cause a stall, increasing the risk of a crash. A fuel leak also increases the risk of fire in the presence of an ignition source.

Remedy: Dealers will inspect the connection and replace the fuel supply line and connector as necessary, free of charge. Owner notification letters were mailed August 31, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 20DB.

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2022 Tiguan, Taos, and 2021 Tiguan long wheel base (LWB) vehicles. A second notice will be sent once remedy parts become available. The left or right rear suspension knuckles may corrode, crack, and break.

Risk: A broken rear suspension knuckle can cause a loss of stability, increasing the risk of a crash.

Remedy: Dealers will inspect and, if necessary, replace one or both rear suspension knuckles, free of charge. Owner notification letters were mailed June 13, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42L8.

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 Golf GTI, Jetta GLI, Jetta NF, Arteon FL, Tiguan LWB, 2022 Taos, Jetta PA, Tiguan PA, 2021-2022 Atlas Cross Sport, and Atlas FL vehicles. The manufacturing process of the eMMC memory module in the infotainment system may cause the rearview camera image not to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk: A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.

Remedy: Dealers will update the infotainment software, free of charge. Owner notification letters are expected to be mailed September 16, 2022. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 91DV.

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2022 TAOS vehicles equipped with all-wheel drive. The engine control unit (ECU) software may cause a stall when coming to a stop.

Risk: An engine that stalls may increase the risk of a crash.

Remedy: Dealers will update the ECU software, free of charge. Owner notification letters were mailed September 28, 2022. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 24iL.

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2022 TAOS vehicles. The fuel delivery pump may break, which could cause a sudden engine stall.

Risk: A sudden engine stall can increase the risk of a crash.

Remedy: Dealers will replace the fuel pump, free of charge. Owner notification letters are expected to be mailed May 26, 2023. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 20DV.