2017 Lincoln MKC

I am filing a formal safety complaint regarding my 2017 Lincoln MKC equipped with the 2.0L EcoBoost engine (VIN: [XXX]). The vehicle has experienced a severe, progressive engine failure caused by internal coolant intrusion into Cylinder 1, directly matching the structural design defect detailed by the manufacturer in Technical Service Bulletin TSB 22-2229. This defect allows pressurized engine coolant to continuously leak directly into the combustion cylinders while driving and during engine rest. This creates an immediate safety risk of vehicle hydro-locking during ignition, sudden mid-drive engine stalls at highway speeds due to severe misfires (Fault Code P0301), and unexpected engine overheating. The manufacturer has knowingly built these open-deck engine blocks with narrow coolant grooves prone to fracturing, creating an ongoing risk of sudden thermal failure and power loss in active traffic. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

Contact owns a 2017 Lincoln MKC. The contact stated that reversing at an undisclosed speed, the rear cross traffic warning system of the vehicle was inoperable. The dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not made aware of failure. The failure mileage was approximately 36,000.

Reported

Jul 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Check engine Light P0302 Engine Misfire Cylinder 2. I noticed Low Coolant in the overflow tank. Went to dealer They did a pressure test found coolant Intrusion inside Cylinder 2 open TSB 22-2229 Car or SUV if coolant gets into cylinder can cause engine failure

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

About 3 weeks ago, I was driving, and a red flashing light came on, signalling that my coolant was low. I bought radiator fluid and put it in up to the fill line. I visited my daughter, which is 11/2 hr. away. I checked the radiator reserve when I arrived at her house. The reserve was empty again. I brought it to a local mechanic shop. They diagnosed that I have coolant intrusion in the engine. They said I would need to pay for a new engine around $8800-$9200. I had purchased a lifetime extended warranty when I purchased the car. The Ford dealership diagnosed my car with the same problem as the local mechanic. They said the repair was not covered by the Powertrain warranty do to it being a manufacturing failure. I brought the car home and it has been parked since.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Lincoln MKC. The contact stated upon starting the vehicle, the vehicle idled roughly, and there was white smoke coming out of the exhaust. The contact stated that the vehicle was experiencing excessive coolant consumption, and the low coolant temperature warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed that the engine had failed and needed to be replaced due to coolant intrusion. The vehicle was then taken to an independent mechanic, where it was determined that the engine replacement was not required, but the head gasket needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in a recall. The failure mileage was approximately 135,000.

Reported

Jun 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Lincoln MKC. The contact received a second notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention) stating that the part was currently available for the recall repair. The vehicle was taken to the dealer, who informed the contact that the rearview camera needed to be replaced; however, the part was not yet available and had been ordered. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and informed the contact that the part shipment was expedited; however, the dealer had not yet received the part. The contact had not experienced a failure.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Dear NHTSA Safety Defects Investigation Team, I am filing a safety complaint regarding my 2017 Lincoln MKC involving a child entrapment incident. On 05/17/2026, my vehicle locked itself while the engine was running, the key fob was inside the vehicle, and my [XXX] child was still inside the car. I was unable to gain entry to the vehicle and had to call 911/emergency responders for assistance. It took around 30 minutes from the time the vehicle got locked and for me door to be opened by the towing company sent by the 911 operator. Thankfully, the AC was turned on and my child was unharmed. The vehicle should not have allowed itself to lock under these conditions with the key present inside the cabin. This created a serious safety hazard involving a trapped child. Compounding the issue, the LincolnWay remote access system no longer functions because the vehicle’s original 3G modem became obsolete after U.S. 3G cellular shutdowns. As a result, I no longer had access to remote unlock functionality that had previously been available with this vehicle. Vehicle Information: • Year/Make/Model: 2017 Lincoln MKC • VIN: [XXX] • Approximate Mileage: [INSERT MILEAGE] • Incident Date/Time: 05/17/2026 at 4.15pm • Location: [XXX] Additional Details: • Vehicle was running at the time • Key fob was left inside the vehicle • Doors became locked unexpectedly • Child was trapped inside • 911/emergency assistance was required • LincolnWay remote services were unavailable due to obsolete 3G modem support ending I believe this issue represents a significant vehicle safety concern and request that NHTSA investigate whether similar incidents have occurred in other Ford/Lincoln vehicles equipped with these systems. The 911 call was placed around 4.15pm and I have the receipt from the Towing Service company Please let me know if any additional information or documentation is needed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Lincoln MKC 2017 Engine failure due to Coolant leak. Bought new Lincoln MKC 2017. The current mileage is 52, 500. Upon Starting, engine would shake for about 10 seconds. The Engine light would come ON. Engine light would turn OFF and ON for few weeks. The Dealership diagnostic indicated code P0301. I was advised Full Engine replacement. Currently the Engine is not starting at all. I have heard it's a design issue with the Engine. I have contacted multiple Lincoln dealerships, and each one has its own engine replacement costs. Lincoln Concierge declined my request to help in anyway although it seems to be a design issue with the Engine.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

I took my vehicle to the local Ford dealership for service due to a check engine light being on. They pulled the spark plug and found the cylinder full of coolant and found TSB-22-2229. I called Lincoln and was told they wouldn’t assist me because I fell outside their time and mileage limits. This issue should have been a recall due to their defective engine design. Engine replacement is very costly and the company should take responsibility for this flaw.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

My vehicle started stuttering & shaking when starting. Then the check engine light came on. It was diagnosed with cylinder 2 & 3 misfire. All spark plugs & coil packs replaced. It got better for about 3 months then the problem came right back. Have replaced coil packs multiple times. Took to dealer who said cylinder misfires were caused from coolant leaking & the only fix was to have engine replaced & quoted $11000. This started at about 95000 miles. Vehicle has had perfect maintenance, all oil changes done on Schedule. Dealer said motor can lock up at any moment & this was a manufacturer error.

Reported

May 2026

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

Issue Description: The vehicle developed a check engine light and was diagnosed with a P0302 cylinder #2 misfire. The condition persisted after basic troubleshooting, and the vehicle was taken out of service to prevent further damage. The vehicle was subsequently brought to an authorized Lincoln dealership for diagnostic evaluation. The dealership confirmed that the vehicle requires a full engine replacement due to internal engine failure. The estimated cost of repair is approximately $9,500–$10,000. This failure occurred at approximately 64,000 miles, which is significantly earlier than expected for a major engine failure. Safety Concern: The engine misfire and internal failure can lead to loss of power while driving, creating a potential safety hazard, particularly at highway speeds or during acceleration. Additional Information: Manufacturer technical service bulletins describe coolant intrusion issues in 2.0L EcoBoost engines that can lead to misfires and engine damage. The symptoms experienced in this vehicle are consistent with those described conditions. The manufacturer was contacted for assistance but declined to provide support. Summary: Premature engine failure at low mileage requiring full engine replacement, with symptoms consistent with documented issues affecting this engine type. This condition presents a potential safety concern due to possible loss of power while driving.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

My rear view camera is displaying that the rear-view camera is unavailable and the screen keeps blinking off and on.

Reported

Apr 2026

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while in reverse(R), the back over prevention camera displayed a black screen. The dealer was contacted and confirmed that the part for the recall repair was not available. The manufacturer was not made aware of the issue. The failure mileage was approximately 31,000.

Reported

Apr 2026

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Lincoln MKC. The contact stated that while attempting to reverse, the rear-view camera became inoperable. The contact stated that the rear-view camera image failed to function properly, and the image was blurry. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer confirmed that parts were not yet available. The manufacturer was not made aware of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was not available.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

In 2023 antifreeze was found in the engine cylinder chambers causing the engine to run rough. We purchased the repair/replacement of a new head gasket at a cost of 3500.00. Now, it is Apirl 2026 and we have developed the same issue plus internal oil leaking in the turbo. Our repair shop says we need to replace the engine and the turbo unit at approx cost 11,200.00 (parts and labor). We have come to learn that this Ford 2.0L 4cyn EcoBoost engine has been found to have a design defect causing regular head gasket failure. So, this is our complaint about this engine and product built by Ford Motor Company. We have come to realize we own a very unreliable vehicle built by Ford.

Reported

Apr 2026

Incident date

Aug 2023

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Lincoln MKC. The contact stated that while attempting to reverse, the rear-view camera became inoperable. The contact stated that the rear-view camera image was blurry. Occasionally, the message "Camera Not Available" was displayed. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The dealer sent a technician to the residence to diagnose the vehicle. The technician confirmed that the rear-view camera had failed and needed to be replaced. The vehicle was not repaired, and the dealer confirmed that the part was not yet available for the recall repair. The manufacturer was not made aware of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The approximate failure mileage was 76,000.

Reported

Apr 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while shifted into reverse(R), the image was distorted, and the audible alert system failed to notify the driver of an object or a person behind the vehicle. The dealer was not contacted. The manufacturer was not made aware of the issue. The failure mileage was approximately 75,000.

Reported

Apr 2026

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The local dealer was contacted on several occasions. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Lincoln MKC. The contact stated that while attempting to reverse(R), the rearview camera became inoperable. The rearview camera failed to function properly, and the screen was blank. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The approximate failure mileage was 76,000.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The engine in my 2017 Lincoln MKC (2.0L EcoBoost) has a documented manufacturing defect where the cylinder block design allows coolant to leak into the combustion chambers. This has caused persistent, unexplained coolant loss and rough engine performance on cold starts since February 2025, matching the diagnostic criteria in Ford TSB 19-2346. The defective engine assembly is available for inspection. This condition creates a significant safety hazard, including sudden power loss (Limp Mode) in traffic and a risk of engine fire from cracked cylinder heads. While Ford provided a service program (21N12) for 1.5L engines, they have failed to issue a safety recall for the 2.0L variant despite identical failure modes. This vehicle is part of the class in the consolidated litigation Miller, et al. v. Ford Motor Company (Case No. 2:20-cv-01796). I am filing this to assist NHTSA in determining the necessity of a mandatory safety recall.

Reported

Mar 2026

Incident date

Feb 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Lincoln MKC. The contact stated that while driving at an undisclosed speed, the vehicle sputtered with a misfire coming from the engine, with the check engine warning light flashing on the instrument panel. The vehicle was taken to the dealer where it was diagnosed with coolant intrusion in cylinder #3, which caused the engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 111,000.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Related to previous recall [XXX] I had the recall repair done. But my car with only 86,744 miles now has coolant in cylinder 3 and it's misfiring so badly the car shouldn't/can't be driven. Dealership says the entire engine needs to be replaced. I have NEVER had a car this low of mileage that an entire engine needed replacement. This is a design flaw in the 2.0 ecoboost and I now have a probably 20,000 or whatever it may have been worth when it ran... Paperweight. It's just sputtering and spitting out loads of smoke as described in original TSB. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Head gasket leaked coolant into the engine and now the engine is not working and needs replaced.

Reported

Feb 2026

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

See attached document for complaint. Joe Cooper Lincoln replaced our car's faulty backup camera on August 22, 2025, as documented in the attached copy. A few days later we received an email from Carfax saying that there was a recall for this defect. It did not seem fair to pay $566.91 for the repair since there was a recall. Joe Cooper Lincoln confirmed awareness of the recall but had not yet received the official notice from Lincoln. After a couple visits with Joe Cooper and phone calls to Kate at Customer Relations in Detroit, MI, phone number 1-888-214-2155, ext. 77212 we were given case number [XXX] and referred back to the dealership. Joe Cooper Lincoln said that as soon as they received the notice from Lincoln about the recall, they would let us know and complete the necessary forms to give us a refund. This issue has still not been resolved, and we request your help in this matter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Feb 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

At approximately 64,000 miles my engine light came on and I took it to a shop. Cylinder 2 was misfiring so we changed the spark plugs and coils. At 67,000 miles light came on again with same issue and while having my oil changed they noted it was unusually dirty. I changed out plugs and coils again. At 72,000 miles light came on again and I took it to a different shop and learned I had a crack engine block, a problem with these vehicles with ECO boost. I was told I needed a new engine and the only thing I could do was add sealant to buy time. I took it to Lincoln to trade and they refused because of the issue and told me to reset the light and sell to Carmax. I couldn’t do that, it was wrong. I sold it for $1,000 to Nissan because I could no longer afford to be driving my grandson in this unsafe car. Also had a lot of issues with electrical starting from purchase with battery dying and lift gate not working. When I got rid of it the windshield wipers wouldn’t work and radio made aweful static sounds. Horrible car from day 1 purchased brand new.

Reported

Jan 2026

Incident date

Jun 2021

Mileage

Not provided

Outcome flags

None reported

After a repair/service visit at a national auto repair chain, my 2017 Lincoln MKC developed ongoing severe drivability and safety issues. The check engine light began flashing (active misfire), and the vehicle was unsafe for highway travel due to risk of loss of power/engine damage. Independent shop documentation reports cylinder #4 misfire (P0304) and additional engine timing-related code(s), low oil condition, and notes indicating internal engine damage and that the engine may require replacement. The vehicle also had a vacuum/brake booster line issue that affected brake assist until corrected. The problem has been confirmed by independent service centers and the vehicle is available for inspection. There was a near crash, but no fire, injury, or police report occurred.

Reported

Jan 2026

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

My Lincoln MKC 2017 is having a recurring problem with a misfire in the 3rd cylinder due to a hood gasket, a crack in the coolant, and leaking on the sparks and coils. I have had my mechanic work on and look at it, and it is a manufacturing defect. When I called, there was no recall listed for my vehicle except the backup camera. However, when you look at Kelly Blue Book, it says there is more than one engine recall and issue, which is exactly what is happening to my Lincoln. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Reported

Jan 2026

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not available. The dealer was not contacted regarding the unrepaired recall. The manufacturer was not contacted regarding the unrepaired recall. The contact had not experienced a failure.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

The 2017 Lincoln MKC requires a full engine replacement due to a serious, well-documented defect: coolant intrusion. This is a major issue that can destroy critical engine components, including the head gasket, cylinders, and even the engine block. Ford/Lincoln is aware of this problem. They issued multiple TSBs (22-2133 and 22-2229, to name a few), yet customers are not informed. Because there is no recall, if the car is out of warranty, dealers refuse to perform the necessary repairs unless the customer pays tens of thousands of dollars for something that is a known manufacturing defect, leaving them vulnerable to catastrophic engine failure and potential accidents, injuries or worse. This is a known manufacturing defect, and consumers should not bear responsibility for the resulting safety hazards. Ford/Lincoln must take immediate action and issue a recall before it leads to serious injuries or fatalities.

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Battery drain issues - causing faulty modules on driver side door which include the safety belts modules, rear lift gate as well as black panel screen. Poor engine performance and warning lights like the check engine light come on and off intermittently. I have replaced the battery several times and having various modules problems some have come up as air bags, and ABS brakes modules. Lincoln knows about the problems and so far, is not able to fix the problems that causes the battery to drain, which causes all the faulty modules. Really don't expect anything like a recall, but this is now documented to warned others. if the modules don't work properly, the sensors will not work correctly either in the vehicles. There are over 20+ modules in the MKC that work with the sensors. Thank you for at least reading.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Engine failure due to known coolant intrusion defect documented under Ford EcoBoost TSB guidance. Denied goodwill assistance despite defect being manufacturing-related.

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

The contact owned a 2017 Lincoln MKC. The contact stated that while driving at 10 MPH, when attempting to park the vehicle on a residential street, the vehicle heisted, and the vehicle independently accelerated into her cousin's house. The contact mentioned she depressed the brake pedal to stop; however, the vehicle did not respond as intended. No air bags deployed. The contact was able to drive the vehicle from the scene. No medical attention was required. The insurance company deemed the vehicle a total loss. The contact stated that a police report was filed. The manufacturer was not notified of the failure. The approximate failure mileage was 58,000.

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

Crash

The contact owns a 2017 Lincoln MKC. The contact stated that the check engine warning light was illuminated. The vehicle was taken to O’Reilly Auto Parts and was diagnosed with a misfire in cylinder #2. The vehicle was then taken to the dealer, where it was diagnosed with a misfire in cylinder #3. The dealer replaced the ignition coils and the spark plugs; however, the failure persisted. The vehicle was taken to an independent mechanic; however, no cause for the failure was found. Additionally, the contact stated that the vehicle was experiencing excessive coolant consumption, and the contact noticed an abnormal odor coming from the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that assistance would not be provided because the vehicle was not covered under warranty. The failure mileage was approximately 190,500.

Reported

Nov 2025

Incident date

Jan 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Lincoln MKC. The contact received notification NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part for the recall repair was not available. The contact stated that the notification was received in September 2025; however, there was no indication when parts would be available. The manufacturer was made aware of the concern but provided no assistance. The contact was a retired veteran and stated that she needed to drive the vehicle; however the vehicle was unsafe to drive while reversing. The contact was in fear of the backup over prevention screen going blank while reversing. The contact had not experienced a failure.

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The contact stated that while reversing, the rearview camera was inoperable and the message "Camera Unavailable" was displayed. Occasionally, the rearview camera displayed a blue image. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 50,000.

Reported

Nov 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 23V378000 (ENGINE) and 25V572000 (BACK OVER PREVENTION). However, the parts to do the recall repair were not yet available. The contact stated that while the vehicle started, the interior lights and lights on the instrument panel failed to function as intended. No warning lights were illuminated. The vehicle was taken to an independent mechanic who determined that the failure was due to an electrical system failure. The vehicle was repaired. The contact stated that the failure persisted. The vehicle was taken back to the independent mechanic; however, the independent mechanic referred the contact to the local dealer. The vehicle was not repaired. The contact stated that on a separate occasion, the rearview camera displayed a distorted image while the vehicle was in reverse(R). The contact stated that the failure obstructed the driver's visibility, which prevented the driver from safely operating the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 80,000.

Reported

Nov 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Lincoln MKC. The contact stated that while reversing, the rearview camera displayed lines. In addition, the contact stated that the rearview camera system failure was intermittent. The vehicle was not repaired or diagnosed by an independent mechanic or dealer. The contact disconnected the battery cables, and the back-over prevention system reset independently; however, the failure reoccurred. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention). The manufacturer was not made aware of the failure. The failure mileage was approximately 50,000.

Reported

Oct 2025

Incident date

Oct 2023

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Lincoln MKC. The contact stated that while driving at an undisclosed speed, the vehicle jerked. No warning lights were illuminated. The vehicle was taken to a transmission specialty shop and was diagnosed with torque converter failure, which caused transmission failure. The torque converter was replaced. The contact stated that on a separate occasion, days after the vehicle was repaired, the check engine warning light illuminated. The contact pulled into a gas station and turned off the vehicle. The vehicle was towed to the dealer, where it was diagnosed with coolant intrusion into the engine, which caused the cylinder head to crack, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle remained at the dealer unrepaired. The manufacturer was not contacted. The failure mileage was approximately 112,000.

Reported

Oct 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Lincoln MKC. The contact stated that while reversing, the rearview camera was inoperable. The contact stated that the failure was intermittent. In addition, there was an error message displayed, indicating that the rear-view camera was inoperable. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part was not yet available for the recall repair. The contact assumed that the dealer was aware of the failure, because the vehicle was regularly serviced at the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 38,000.

Reported

Oct 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2017 Lincoln MKC. The contact stated that upon starting the vehicle, the check engine warning light illuminated on the instrument panel, followed by a coolant temperature message. The vehicle was taken to a dealer, where it was diagnosed with a hairline crack in the engine. The hairline fracture led to coolant intrusion inside cylinder #2, and the vehicle was diagnosed with engine failure. Upon investigation, the contact discovered Technical Service Bulletins 19-2346 and 22-22229, which the contact linked to the failure. The contact called another dealer about the failure and was informed that there were no recalls on the vehicle related to the failure. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The failure mileage was 98,690.

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

Engine design flaw in the gaskets. Coolant leaking into the cylinders causing misfire. Had to replace the engine. $8000.

Reported

Oct 2025

Incident date

Nov 2024

Mileage

Not provided

Outcome flags

None reported

COOLANT LEAKING INTO ENGINE, CAUSING MISFIRES AND ENGINE SERVICE LIGHT ON

Reported

Sep 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

Symptoms consistent with TSB 19-2346 for 2.0L EcoBoost engines: coolant in cylinders, white exhaust smoke and check engine light is on. I have to keep topping off the coolant weekly, engine light comes and goes with same errors. Went to a general mechanic who got error codes PO301-00 AND PO316-00. Currently scheduled next week to see an engine mechanic. Available for inspection upon request. Has not put us in danger yet but is of major concern due to potential for failure, so we are having it seen to ASAP. We don't have a Ford dealership so nearby to go out there with a failing car just to have them verify that yes that is the issue and yes it will be a very expensive repair we could not afford if we did it with them. Despite very low mileage it is still past warranty date, so any goodwill would have to come after we go through the trouble of bringing our vehicle in and hoping for the best. We called and they couldn't even provide any kind of ballpark likelyhood of goodwill.

Reported

Sep 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

None of my airbags deployed in a one vehicle accident when my tire blew. I woke up sitiing in a guard rail.and injured. This happened on September 4th, 2025. Car totaled and Travelers Insurance already paid off finance company and I was left with nothing. I have trouble walking g, a brokthumb. Constant headaches and chest soreness.

Reported

Sep 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

Back up camera goes black or really fuzzy so everything is unrecognizable. This happens very sporadically. It could stay like this for days or sometimes just once in a few weeks. Never know when it will happen.

Reported

Aug 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

I purchased a 2017 Lincoln MKC approximately 90 days ago and recently encountered a check engine light notification with the diagnostic code P303, indicating a misfire in cylinder three. After replacing the fuel injector on that cylinder and completing a tune-up, which included the replacement of all spark plugs and ignition coils, I consulted a new mechanic. They informed me of a potential issue related to engine block intrusion, which reportedly affected other 2.0 L engines from Ford Motor Company within the 2015-2019 model years. As a result, I have been advised to consider replacing the entire engine. Given that I acquired the vehicle as a used model with only 43,000 miles and is now out of warranty, I am facing an out-of-pocket expense of nearly $8,000.

Reported

Aug 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

Engine light came on. Took it to mechanic. Was told there is a well documented mechanical issue affecting my 2017 , MKC. My vehicle is experiencing a misfire and cylinder three accompanied by signs of colon intrusion into the engine, as well as transmission slippage. I have heard these are known and widespread issues in 2015 to 2019 Lincoln MKC models equipped with the 2.0L Eco boost engine. I am aware of several technical service bulletins, including TSB 19-2346 and TBS 22-2229, that detail this defect. Numerous Lincon customers have reported identical issues at similar mileage, often requiring full engine or transmission replacement. My trusted mechanic has verified that my vehicle exhibit symptoms consistent with this engine defect.

Reported

Aug 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

Coolant Intrusion into the cylinder causing overheating. New engine block required. Car has been regularly maintained. Failure occured with no warning.

Reported

Aug 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Risk: An electrical short circuit can increase the risk of a fire.

Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.

Risk: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.

Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC vehicles. The battery monitor sensor may short-circuit and overheat, causing a fire in the engine compartment while parked or driving.

Risk: An engine compartment fire while parked or driving can increase the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will add an in-line fuse to the battery monitor sensor power circuit, free of charge. Owner notification letters were mailed August 8, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S28.