2019 Ford Ranger

The Ford 10R60 and 10R80 transmission has become a hazard on the road. Please see TSB 23-2250. My Ranger only has 43,000 miles on it and is dangerous to drive because of the stuttering and lunging of the transmission. Ford is perfectly aware of this situation but won't fix vehicles that are out of the 5 year warranty at no cost to the owner. No transmission should be faulty after only 43,000 miles. I am requesting that you please investigate this situation as I believe it should be a recall. - Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jul 2026

Incident date

Jan 2022

Mileage

Not provided

Outcome flags

None reported

I was driving the vehicle, when I started to fell a " Shuddering " sensation on acceleration. I let off the gas pedal and the Shuddering went away. A few miles down the road the check engine light came on and was flashing. I immediately pulled and shut the vehicle off. After sitting for 10 minutes I restarted the vehicle and the check engine light was no longer on, but the " Shuddering " sensation was still present. I took it to Dupratt Ford in Auburn,Ca. and they diagnosed it as a Cylinder 1 mis-fire. Upon further inspection they found water in the Cylinder 1 spark plug well. After doing some research I found out the Ford issued TSB 23-2011for this exact issue, but did not order a recall to fix the faulty windshield cowl which is the problem. I found thousands of complaints and numerous Ranger owners who have had the exact same issue and had to pay out of pocket to get the issue and damaged fixed. Meanwhile Ford knew about the issue and did absolutely nothing, did not even alert the owners of the issue. I was lucky and did not have to replace the cylinder head, but others have not been so lucky. I had to pay over $1800 to have the mis-fire issue fixed and had to do my own preventative measures to seal the windshield cowl. I contacted Ford and they were only willing to reimburse me $725 dollars of my repair bill which was 100% their fault.

Reported

Jul 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The transmission has issues not shifting gears and having loss of power when pulling out into intersections that are getting worse with time.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

I am submitting this complaint regarding my 2019 Ford Ranger because I discovered what I believe to be a serious safety defect involving the rear leaf spring mounting system. My vehicle has approximately 55,000 miles and has been used primarily as a commuter vehicle for driving to and from work in the city. The truck is originally from Virginia and has very minimal rust exposure. While replacing my rear brake pads, I noticed that the area where the rear leaf spring connects to the body/frame of the truck had broken away and was no longer properly attached. This was completely unexpected. A critical suspension component such as the leaf spring mounting point should not fail on a relatively low-mileage vehicle with only 55,000 miles, especially one that has not been subjected to severe corrosion or extreme use. Had I not been performing brake maintenance myself, I likely would not have discovered this defect. I fear that many other Ford Ranger owners may be driving their vehicles unaware that they could be experiencing the same dangerous condition. A failure involving the leaf spring mounting system has the potential to affect vehicle stability, handling, braking, and overall control. This creates a significant safety risk not only for the driver and passengers of the affected vehicle, but also for everyone sharing the roadway. I respectfully urge your agency to investigate this issue and determine whether a broader defect exists involving the rear leaf spring mounting components on 2019 Ford Rangers. If warranted, I ask that Ford be required to issue a recall to inspect and repair affected vehicles before a catastrophic failure results in serious injury or loss of life. Thank you for your attention to this matter and for your efforts to protect the safety of the driving public.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Hash Shifting and at times kicks into gear hard at a stop light nearly hitting vehicle in front of me

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2019 Ford Ranger equipped with Dunlop Tires. Tire Line: AT2O, Tire Size : 265/65R17 110HI, DOT number DAAH D31R. The contact stated that while driving 65 MPH, the passenger-side rear tire blew out. The thread separated and was on the roadway. The contact was able to continue to drive. The contact called a tire center, but they failed to respond. The local dealer was not contacted. The manufacturer was not contacted. The tire mileage was unknown. The failure mileage was approximately 97,000.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

My 2019 Ford Ranger is equipped with the 10R80 10-speed automatic transmission that experiences hard/erratic shifting (as if it can't decide what gear it wants to be in), jerking/lunging especially in 1-2 gear when making a brief stop-and-go (stop sign or a crosswalk). The first couple time it happened, it felt like I got rearended or hit a curb.

Reported

May 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The brakes failed within hours of owning the Certified, WARRANTIED VEHICLE. ALMOST had an accident. Within <5 weeks of owning this warrantied certified vehicle, was stranded on Rine Ridge Indian Reservation and on the highway. Engine jerk so bad feels like I a derby car. Then just stalls. The dont comply with their own 172 point certified inspection. They claim two keys for specified vehicle. They gave me two 1 starts the vehicle the other errors no key in ignition when you insert into ignition. NOW I have to pay bills to get a warrantied certified vehicle repaired plus loaner car because Ford McKie k owing sold an Unsafe vehicle under deceptive pretense. Multiple engine and brake failures which was supposedly certified inspected.

Reported

May 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

Mileage is at 86980. I have been having issues for a good 10k miles that are slowly getting worse. Transmission is slamming into reverse from park. Shifting is slow from 1st to 2nd gear. Has begun revving engine but not engaging. I have had the transmission fluid changed 3x and flushed and changed the last time. No leakage or overheating. I do not drive her hard, off road or tow. She always gets warmed up before driving. My mechanic believes it is the PCM.

Reported

Apr 2026

Incident date

Mar 2025

Mileage

Not provided

Outcome flags

None reported

Rear rear leaf spring broken/cracked completely and disconnected from vehicle. The vehicle was unsafe to drive as the axle was not not connected to the vehicle on one side. The defective component was inspected by Firestone Auto and submitted and approved by SilverRock automotive for warranty replacement and is currently at a Ford Dealership completing repairs because Firestone Auto failed to complete the repair properly. There were no warning lamps or messages and it the problem was only noticeable when the vehicle was on a lift or floor jack. The incident is unknown and it the broken part was poor design/materials.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

JULY 2024 THE RIGHT SIDE BACK LEAF SPRING WAS BROKEN. WAS REPLACED UNDER WARRANTY. APRIL 2026 THE LEFT SIDE BACK LEAF SPRING IS BROKE. WAITING TO HEAR FROM FORD IF IT WILL BE COVERED OR NOT. LEAF SPRINGS SHOULD NOT BE BREAKING. I DO NOT HAUL THINGS OR EVEN GO OFF ROAD WITH MY 2019 RANGER. IT HAS 74012.10 MILES ON IT NOW.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, the vehicle hesitated, and the transmission was shifting hard. Additionally, the vehicle vibrated abnormally while shifting from 1st to 3rd gear. The vehicle was taken to the dealer, where the TCM was reprogrammed, and various fluids were replaced; however, the failure persisted. The manufacturer was notified of the failure. The approximate failure mileage was 951.

Reported

Apr 2026

Incident date

Feb 2019

Mileage

Not provided

Outcome flags

None reported

On friday, march 27th, 2026. My 2019 ford ranger began shaking before the engine stalled. Warning lights for an engine check came on and my vehicle would not go above 20 mph after restarting. When pressing on the accelerator the engine would rev but the vehicle would not accelerate. I took the 2019 ford Ranger to a local Ford Dealership service center and they diagnosed the following problems (listed in full below).The cooling fan was at issue and multiple wires connecting my engine to the rest of the vehicle were melted off. The ford dealership said that this issue is extremely rare and they have never seen it before. After receiving this information from the dealership I discovered that the 2019 ford ranger has had several recalls with the areas at issue in my vehicle. The recalls are under number 25V685000 (Engine block heater), and 20V137000 (Fan). Here is the full diagnosis from the ford dealership attached below: VERIFIED CUSTOMER CONCERN FOUND VEHICLE TO HAVE CEL LIGHT ON, AND MULTIPLE WARNING LIGHTS PERFORMED DIAG AND FOUND SHORT CIRCUIT PRESENT. TRACED SHORT FOUND COOLING FAN CLUTCH FAILED AND HARNESS RUBBING IN CLUCH ASSEMBLY FOR COOLING FAN The fan lowers the temperature of the engine. The cooling fan motor is an electric motor that turns the fan blades. When the vehicle is in traffic or under heavy load, the engine relies on the fan to cool itself. Some vehicles may use multiple electric fans for better control of the cooling system. For the most part, electric cooling fans are controlled by the same computer that controls the engine. However, in some engines, the fans are turned on and off by a temperature-sensitive switch mounted in either the radiator or elsewhere in the cooling system. Spark Plug Replacement 4 Cylinder: 4 Cyl Tune Up The platinum spark plug is a type of spark plug. The platinum is a precious metal that is used in the composition of the spark plug. The center electrode is made of platinum.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Restraints indicator lamp warning. Air bag warning is on due to a problem with the front passenger side airbag. The front passenger airbag may not function.

Reported

Mar 2026

Incident date

Feb 2023

Mileage

Not provided

Outcome flags

None reported

both rear springs broken at the front eye mounts. the rear leaf springs hold the rear axle in place need I EXPLAIN MORE? I have not had the truck inspected, I have been in the automotive industry for over forty years. I first heard a noise from the springs when entering a parking lot and drove over a curb. No electronics attached to the springs.

Reported

Mar 2026

Incident date

Dec 1969

Mileage

Not provided

Outcome flags

None reported

The transmission failed prematurely (my point-of-view) at around 115,000 miles. A Ford dealer diagnosed and determined the transmission needed replaced. The vehicle was a 2019 Ford Ranger XL with a 10-speed automatic transmission. The transmission would get stuck in 2 gear, sometimes upshifting and sometimes downshifting. Driving highway speeds the speed needle would also drop to zero even though I was moving. They noted that solenoids were bad but replacement was needed. I had the transmission replaced with a new warrantied transmission but it was very expensive at 9,650. It did come with a 2-year warranty. That is half the value of the truck! This is the fourth Ford truck I have owned. I do use it as a truck and haul a few things around as projects dictate but do little towing, drive it reasonably, and do not take it off-roading. I have never had a transmission fail before. The Ford dealer, and three area shops, noted they see "a lot of 10-speeds" come in for transmission rebuild or replacement. As a now review many Ford forums I see many people with issues surrounding the durability of the 10-speed transmission.

Reported

Mar 2026

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

Since owning the vehicle, I have experienced a range of serious transmission issues. These include harsh or delayed gear shifts, inconsistent downshifts, and transmission slipping. The vehicle also frequently jerks or lurches during gear changes. Of particular concern is the vehicle’s behavior during downshifting. At times, the transmission downshifts abruptly and causes the vehicle to lunge forward unexpectedly. This unpredictable behavior presents a significant safety concern, particularly in traffic situations where smooth and predictable vehicle response is essential. These transmission issues negatively affect the safety, drivability, and reliability of the vehicle and are not consistent with normal operation.

Reported

Mar 2026

Incident date

Mar 2023

Mileage

Not provided

Outcome flags

None reported

My transmission has failed at 131,000 miles on my vehicle. It roughly shifts into reverse and harshly shifts while in drive and the vehicle is in motion. My truck shakes while the transmission searches for gears and shifts slowly requiring extra power to move in normal operating conditions.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Airbags: passenger rear and front side airbags did not deploy after being struck on the passenger side by another vehicle. Seatbelts: were ineffective Vehicle was sold due to system failures and equipment issues. Safety: Head and body trauma due to non deployment. Inspection: Unknown No system messages before collision

Reported

Mar 2026

Incident date

Mar 2024

Mileage

Not provided

Outcome flags

Crash 3 injuries

10th gear, gear ratio incorrect. CDF drum failure. Rough shifts from 3-4 struggles to shifts into park and reverse.

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

Vehicle has around 50K miles and driver rear leaf spring corroded and broke, review of right rear leaf spring also showed corrosion and metal thinning. Truck has no off road time nor heavy loads in bed. I had to replce both springs at my cost even though Ford is aware of the 2019-2020 Ranger spring issues and refused to replace the springs. This is a serious safety issue that places the occupants and other drivers at risk. The mechanic said he’s replaced over a dozen broken leaf springs on model years 2019 and 2020. The manufacturer is being intentionally negligent and even the dealer parts counter agreed the springs are faulty, saying they sell quite a few regularly.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

My truck experienced a P0302 misfire on the freeway, which caused it to shake immediately and made it very difficult to drive. I had it towed to the dealership, and they told me there was water in the spark‑plug wells, which was surprising since I live in Las Vegas, NV, where it rarely rains. My spark plugs were rusted as well as the cylinder head. After looking into it online, I discovered that Ford issued TSB‑23‑2011 for the Ford Ranger due to a windshield cowl leak that allows water to drip directly onto the engine. Their proposed fix is to install an engine cover, but that clearly doesn’t solve the issue since my truck already has the engine cover installed. Now I’m stuck paying for repairs caused by a design flaw that Ford never properly addressed.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

he 2019 Ford Ranger the VIN [XXX] , the driver’s side AC only blows hot due to the climate control issue addressed in Fords service bulletin SSM 51313. This is a known issue with the early production model of the Ranger, hence the service bulletin SSM 51313. It is my belief that faulty parts were used on the early model Rangers and instead of a recall or extending the warranty on this issue only issued a service bulletin was put out. I am writing to have the Ford MOCO issue the proper recall or cover repairs under and extended warranty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The vehicle is experiencing a severe power train failure involving erratic and violent gear selection. The transmission unexpectedly jumps from 2nd, 3rd, or 4th gear directly up to 7th or 8th gear, resulting in a total loss of acceleration. This is immediately followed by the transmission "slamming" down into lower gears, usually 1st or 2nd gear without driver input. This behavior is accompanied by a strong burning smell and a dashboard "wrench" warning light. The symptoms match the manufacturing defect documented in Ford TSB 24-2101 (CDF clutch drum). Diagnosis & Manufacturer Response: The issue began in October 2025 with a noticeable transmission shudder. I paid for two transmission flushes at Big O Tires to attempt to resolve the issue, but the mechanical failure has since escalated. When the "wrench" light appeared, an independent diagnostic computer was unable to retrieve an error code, as the light is a proprietary Ford powertrain indicator. Furthermore, the wrench light clears upon restarting the vehicle, despite the violent shifting and burning smell remaining. Ford Corporate agents claim there are "no known issues" and have refused to assist with towing, despite an active NHTSA Engineering Analysis (PE 24-001) regarding this exact 10R80 transmission. Safety Risk: This defect creates an extreme safety hazard. Violent downshifting into low gears at highway speeds can cause a loss of vehicle control or a rear-end collision. The burning smell indicates internal friction and fluid oxidation, posing an immediate fire risk or the potential for a catastrophic mechanical lock-up.

Reported

Jan 2026

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

The transmission stutters at sustained modest speed (25-45 mph). It was taken to the dealer, who determined it was affected by tsb 25-2134. This is a widely known issue and the dealer refused any servicing without payment. This should have been a recall, since hundreds of known issues in and out of warranty have occurred.

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The automatic transmission and related transmission control system malfunctioned. The vehicle experienced improper shifting and loss of gears, including a condition in which 4th gear is disabled due to a failsafe logic triggered by the transmission control module. The vehicle and all affected components are currently available for inspection upon request and are at a Ford-authorized dealership. This malfunction posed a safety risk because the vehicle was unable to shift normally or maintain consistent acceleration. The unpredictable shifting and loss of gears could create hazardous situations when merging, accelerating, or driving at highway speeds, potentially endangering the driver and others. The problem has been reproduced and confirmed by a Ford dealership. After inspection and diagnostic testing, the dealership advised that the transmission requires replacement. The vehicle has been inspected by a Ford-authorized dealer. It has not been inspected by the manufacturer directly, police, or insurance representatives (UNKNOWN). Prior to the failure, warning messages and drivability symptoms were present. Specifically, the transmission control module detected an issue when attempting to shift into 4th gear, triggering a failsafe mode that disabled 4th gear for the remainder of the key cycle. These symptoms appeared before the full transmission failure and progressively worsened over time.

Reported

Jan 2026

Incident date

Jan 2025

Mileage

Not provided

Outcome flags

None reported

2019 ford ranger, 74,000 miles On way to pick up girlfriends engagement ring…. The truck started jerking, loosing power, no engine light came on. Turned around to go home and drive about 8 miles under 45 mph.Then truck started jerking again , like transmission issue. Engine light and tool wrench came on. As I was pulling in driveway, truck went into “limp” mode. Had it towed to Gullo Ford Conroe. Now they are saying need new transmission due to Internal transmission failure! Shouldn’t Ford. Over this! Only 60,000 mile warranty.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

During a PA State inspection, a leaf spring was discovered to be broken.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The climate control system on my 2019 Ford Ranger has a recurring failure that prevents the vehicle from properly adjusting temperature or directing air through the vents. The failure causes a constant clicking/snapping noise behind the dashboard, and the blend door does not move when the temperature is changed. This malfunction matches Ford’s published SSM 49264, which identifies a known defect in 2019–2020 Rangers built on or before 7/30/2020 and states that the entire HVAC housing assembly must be replaced. This issue creates a safety hazard because the truck cannot reliably defrost the windshield in cold or wet weather. Loss of defrosting capability severely limits visibility and makes safe operation of the vehicle difficult. The issue is reproducible every time the temperature is adjusted. The problem began when the vehicle was still within the original mileage window of the factory warranty, but the dealership did not repair it. Ford has confirmed the malfunction is caused by the blend door system, yet they have refused goodwill coverage for a repair that requires full dash removal and replacement of a known defective part. There were no warning lights, but the clicking noise and loss of temperature control began well before the warranty expired. The vehicle continues to experience the defect, and it poses an ongoing visibility and safety risk. Ford has acknowledged this exact failure mode in writing (SSM 49264), but has not issued a recall or safety campaign.

Reported

Dec 2025

Incident date

Nov 2023

Mileage

Not provided

Outcome flags

None reported

Transmission shifting issues. Will shift out of gear or delay shifting several seconds and sometimes limited power. The 1080r 10 speed transmission has a know design flaw that was finally fixed in 2023. My 2019 is now having the issue and is $8000 to fix for a bushing that moves out of place

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Truck looses gear when pulling into traffic. It will shift out of gear and only allow coasting. At speeds of 40 MPH and higher it will down shift causing dramatic reduced speed with no brake warning to other drivers behind. It will also randomly loose power. It will have delayed shifts squealing tires upon shifting and excessive jerking that is uncontrollable.

Reported

Dec 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

I have had my 2019 Ford Ranger in for service to address issues with the transmission on 3 different occasions starting in Fall of 2023. Each time paying $106 for the deductible on the warranty to service a "Technical Service Bulletin" (TSB). Each time, being told of a different TSB that they would be addressing. Never addressing them all at the same time. In May of 2025, still experiencing the same/similar issues, I brought in in again only to be told that there was a TSB that they did not service, that my warranty had expired. Upon searching the internet, there are many people reporting similar issues with a similar response from Ford. I have spoken to multiple dealerships as well as reached out to Ford car with little to no response.

Reported

Dec 2025

Incident date

Nov 2023

Mileage

Not provided

Outcome flags

None reported

Repeated failure of HVAC system, even after repairs, leads to not only a very cold truck in January in Maine, but inability to defrost the windshield and keep it defrosted. Repairs have been made in January 2025, April 2025, and now has to be repaired again in December 2025. My independent service provider who subscribes to OEM Ford subscriptions, was not made aware of an "internal" service memo until now. Neither from the subscription services or from contacts at a Ford dealer where he resourced parts and repair info. SSM 51313 indicates a different repair than was made on the previous two attempts. These repairs require the disassembly and reassembly of the instrument panel and are very expensive - especially when not apprised of correct. Now the SSM indicates a complete housing replacement to correct the defective part. See attached forms.

Reported

Dec 2025

Incident date

Jan 2025

Mileage

Not provided

Outcome flags

None reported

On November 7th. 2025, I took my Ranger to my mechanic for it's yearly emissions and inspection, to have the tires rotated and brakes changed. He called me later that day and had sent me pictures of BOTH rear leaf springs broken off from the under carriage. He stated that he could not tell how long they were like this and asked if I had any issues driving. I did not notice any noise or driving issues. He stated that he is shocked that I did not wreak the truck by loosing control because it should have caused my rear to be bouncing all over. He contacted FORD and asked if there was a recall on them and was told "No". He then instructed me to file a complaint with you. He ordered the parts and replaced fixed the issue.

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Hood/cowling along the windshield allows water to leak under the hood of the vehicle and wets the coils and plugs causing the engine to mis fire and shutter violently. This engine mis fire and sudden lack of power can cause the vehicle to obstruct the flow of traffic resulting in an accident. Problem was reproduced by the dealer and they replace coils, plugs, and installed an accessory engine cover to prevent the issue in the future. All at my cost. The problem remains that there are many Ford Rangers on the road unaware of this problem. This problem is documented in a Ford TSB but a more aggressive approaching is needed to resolve this issue.

Reported

Dec 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

I’ve been noticing a delay in shit out of 1st, 3rd, 6th, and 9th gear. Sometimes it slams but most of the time not. Anyways, this morning on my way to work I passed a slow driver on 2 lane road. After I merged back into the lane, I resumed cruise control and basically lost all power to the wheels. The vehicle I passed about slammed into the back of me. I canceled cruise control to give gas and the transmission was fighting me to stay in a gear. It finally caught and I drove it the rest of the way to work with the “normal” 1,3,6,and 9 being weird. My safety and the other vehicles safety was definitely at risk. The was no warning lights that came on. I haven’t had it checked out yet because this is same day

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

My complaint isn't about my vehicle. My complaint pertains to pickup truck and SUV lighting. The lighting on these vehicles have become so bright that they blind oncoming drivers. In addition, I was recently blinded by the lights on a lifted pickup truck, that was following behind me. The lights on these vehicles have become so bright that they present a hazard to other drivers. This hazard is made worse when the vehicles are lifted (body or big wheels). Please consider taking action to address this problem.

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

The front eyes of both leaf springs were broke. Took truck to local shop to repair a tire leak and they called me to ask me how I drove the truck there as they never saw anything like it before. This is a major component that maintains the rear axle geometry and could have been a safety risk and should never be a concern on a 5 year old vehicle with under 100,000 miles. Vehicle has not been inspected by any other parties than the shop and myself. No symptoms were detected.

Reported

Nov 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

Both rear leaf springs broke at the eye on the forward anchor bushing, leaving both leaf springs not anchored at one end. This was undetectable until the truck was lifted for an oil change. It was not detected and released back to me to drive. The rear axle was only anchored at 2 of the 3 anchor points. If one of the other anchor points was compromised the result could have been catastrophic depending on the driving conditions. I drove the vehicle locally until i figured out the clunking noise. Both leaf springs were replaced by a certified repair shop. There have been other reports of the same problem with no re-calls

Reported

Nov 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2019 Ford Ranger. The contact stated that while in reverse(R), the backup camera initially projected three lines at the bottom of the screen, distorting the driver’s vision. The contact stated that over time, the camera displayed a blank or distorted image, and the message "Camera Not Accessible" was displayed. The vehicle was taken to a dealer, and the backup camera was reset. The reset initially repaired the failure; however, the failure returned soon after the reset. The contact made two attempts to reach the manufacturer, but the call was disconnected each time. The vehicle was not repaired. The failure mileage was approximately 56,000.

Reported

Nov 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

My 2019 Ford Ranger 4x4 was bought new in April of 2019 and has approxiamatly 73,400 miles. Over time a slight glitch in the transission got to be more frequent. When first starting out within the first mile of operation, the vehicle would hang between gears and act like it ran out of fuel for a few seconds at low speed, as in pulling out from a stop sign or accelerating from a dead stop. My guess is inbetween first and second or second and third gear. It just wouldn'd go. Fortunatley I was not involved in any accidents. I can see where this could easily cause a mjor accident. There are several TSB's for this transmission and I believe Ford and General Motors use this same transmission. I have had my truck at the dealer for almost a month after it got scary to drive it got scary to drive. They are repairing this and contributing to the cost. I feel ike they no there is a problem and probably should have done a recall before someone gets killed.

Reported

Oct 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

While backing up out of a parking space, my BLIS system did not give me a warning letting me know there was a pole to my left side...finally, it beeped just once as I backed into the pole...no other warning. Estimate of repair is $4900. My neighbor was with me and can confirm everything

Reported

Sep 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

Crash

The contact owns a 2019 Ford Ranger. The contact received notification of NHTSA Campaign Number: 25V442000 (BACK OVER PREVENTION); however, the dealer refused to perform the recall repair. The contact stated that the rearview camera displayed a black screen while the vehicle was in reverse(R). The contact stated that the failure had obstructed the driver's visibility, which prevented the driver from safely operating the vehicle. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 33,000.

Reported

Sep 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the transmission shuddered abnormally. In addition, while driving approximately 45 MPH, the vehicle drove without issues. No warning light was illuminated. The vehicle was taken to the dealer, and the failure was diagnosed as an internal transmission pump failure. The contact was informed that the transmission pump needed to be replaced. The vehicle was not repaired. In addition, the contact was informed that the manufacturer was aware of the failure; however, the repair was not covered under the recall. The manufacturer was made aware of the failure, and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 78,000.

Reported

Sep 2025

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

Air bag malfunctions and not active passanger and driver side, hvac malfunction replaced twice, power train shifting out of gears, PCM malfunctions and triggering failures to sensors. Passanger seat belt not working. Collision sensor malfunction and not working.

Reported

Aug 2025

Incident date

Mar 2023

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. There was an abnormal sound coming from the vehicle. The contact stated that the check engine and the service warning lights then became illuminated. The vehicle was driven to a nearby Ford dealer. The vehicle was diagnosed with internal failure of the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact referenced an unknown recall with a similar description of the failure; however, the VIN was not associated with the recall. The failure mileage was approximately 73,000.

Reported

Aug 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2019 Ford Ranger. The contact stated while driving approximately 60 MPH and hauling a trailer, the vehicle unintendedly decelerated and stalled. The vehicle was towed to the local dealer who diagnosed the vehicle and determined that there was rainwater inside the engine cylinders, causing two spark plugs to rust and malfunction. The spark plugs, spark plug boots, and spark plug coils were replaced and the vehicle was repaired. The contact stated that recently, while the vehicle was in for routine maintenance, the mechanic discovered rainwater inside the engine cylinders again. The vehicle was not yet repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The contact was informed that the VIN was not included in an Extended Warranty coverage related to the failure. The failure mileage was 44,825.

Reported

Jul 2025

Incident date

Sep 2022

Mileage

Not provided

Outcome flags

None reported

My transmission failed on the highway. I was merging on the highway one day and all of a sudden I felt a sudden reduction in power which was dangerous for the people behind me, and heard an awful grinding/whining noise. I immediately limped it to the dealership and was told several days later the transmission (Ford 10R80) had a catastrophic failure and was lucky to get it to the dealership. This is unacceptable and I know I’m not the only one with issues with these transmissions. The dealership told me it happens all the time. This is a safety issue and unacceptable for the truck that is 5 years old.

Reported

Jul 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2019 Ford Ranger. The contact stated that while the vehicle was at the dealer for a tire rotation, the contact was informed that the tires were unable to be rebalanced due to swollen lug nuts. The vehicle was then taken to Goodyear, who was also unable to rotate the tires. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 106,000.

Reported

Jul 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

Own a 2019 Ford Ranger, which is experiencing severe transmission issues including harsh and delayed shifting. A diagnostic scan revealed code P07F7-00, which matches Ford's TSB 24-2046 / 25-2024, related to known defects in the 10R80 10-speed transmission. Despite this being a documented issue, authorized Ford dealerships have refused to properly diagnose the TSB entirely and claiming it was no longer valid. This unresolved defect affects the safety and reliability of my vehicle. I am filing a complaint to request that the NHTSA investigate this widespread problem and consider issuing a recall to address the transmission defect affecting many Ford Rangers (and other vehicles with this transmission). Thank you for your attention to this serious safety concern.

Reported

Jul 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Risk: An electrical short circuit can increase the risk of a fire.

Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.

Risk: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.

Ford Motor Company (Ford) is recalling certain 2019 Ranger vehicles previously repaired under recall 19V-726. The service replacement Heating, Ventilating and Air Conditioning (HVAC) blower motor that was installed may have an improper clearance between an electrical terminal and the conductive base plate that may result in an resistive electrical short.

Risk: A resistive electrical short increases the risk of a fire.

Remedy: Ford will notify owners, and dealers will inspect and replace the HVAC blower motor, as necessary, free of charge. The recall began April 6, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S12.

Ford Motor Company (Ford) is recalling certain 2019 Ranger vehicles. The Heating, Ventilating and Air Conditioning (HVAC) blower motor may electrically short.

Risk: An electrical short can increase the risk of a fire.

Remedy: Ford will notify owners, and dealers will inspect the HVAC blower motor production date, replacing it as necessary, free of charge. The recall began December 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S34.

Ford Motor Company (Ford) is recalling certain 2019 Ford Ranger vehicles with a SuperCab body style. The front passenger seat belt may have been improperly assembled.

Risk: Improperly assembled seat belts may not adequately restrain occupants in a crash, increasing their risk of injury.

Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the right front seat belt assembly, free of charge. The recall began July 29, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S23.

Ford Motor Company (Ford) is recalling certain 2019 Ranger vehicles equipped with 10-speed automatic transmissions. In some of these vehicles, the transmission shift lever can be moved from the "Park" position without the key in the starting system and without depressing the brake pedal. As a result, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."

Risk: If the vehicle can be shifted out of Park without the brake applied, the vehicle may unexpectedly move. Unintentional vehicle movement can increase the risk of injury or crash.

Remedy: Ford has notified owners, and dealers will inspect and repair the transmission floor shift selector interlock assembly, as necessary, free of charge. The recall began February 22, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C02.

Ford Motor Company (Ford) is recalling certain 2019 Ranger vehicles. The fasteners that attach the transmission shifter cable bracket to the transmission may loosen allowing the transmission to be in a different gear than indicated by the gear shift lever position.

Risk: If the gear shift lever position does not match the actual transmission gear, the vehicle may move in an unexpected direction. Additionally, despite selecting 'Park', if the parking brake is not applied before the vehicle is exited, the vehicle may roll. Either scenario increases the risk of crash or injury.

Remedy: Ford will notify owners, and dealers will inspect and tighten the transmission shift cable bracket fasteners as necessary, and verify the proper transmission shift operation, free of charge. The recall began July 1, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S15.

Ford Motor Company (Ford) is recalling certain 2019 Ranger trucks. The inline electrical connector terminals for the rear lights may be misaligned or not properly seated, potentially causing the rear lights to function intermittently or not at all.

Risk: Intermittent or inoperative tail lamps can result in loss of stop, turn, rear position, and reverse lamp functions, which reduces the vehicle's visibility and may not fully alert other drivers that the vehicle is braking, turning, or reversing, increasing the risk of crash.

Remedy: Ford will notify owners, and dealers will inspect the inline connector for loose terminals and replace the connectors, if necessary, free of charge. The recall began March 5, 2020. A renotification was sent on July 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S43.

Ford Motor Company (Ford) is recalling certain 2019-2021 Ford Ranger Super Cab vehicles. The front passenger outboard seat belt may not have been assembled properly, allowing the seat belt to be misrouted. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupant Crash Protection" and 209, "Seat Belt Assemblies."

Risk: A misrouted seat belt may not adequately restrain an occupant in a crash, increasing the risk of injury.

Remedy: Ford will provide owners with instructions to perform a preliminary inspection of their front seat belts. Owners that detect an issue with the driver's seat belt, are unsure of the results, or do not want to perform an inspection, should not drive their vehicles and contact a Ford dealership. Dealers will inspect the front row outboard seat belts and replace them, if necessary, free of charge. Interim owner notification letters were mailed on November 5, 2021. Owner notification letters were mailed December 22, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C25.

Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco, 2023 Super Duty F-250, and 2019-2023 Ranger vehicles. The Tire and Loading Information (TREAD) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Risk: An overloaded vehicle increases the risk of a crash.

Remedy: Ford will mail a new TREAD label to install over the existing label, free of charge. Owners will also have the option to take their vehicle to a Ford or Lincoln dealer to have the new label installed, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C18.

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Risk: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.