2021 Acura TLX

I took this vehicle to get serviced in the summer of 2025. I recently joined an Acura Type S (2021+) group on Facebook and learned that the issue is quite prevalent. I had to have the transmission and transfer case replaced due to transmission issues and traction issues

Reported

Jul 2026

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

On July 7th 2026 I was driving home, came to a stop light at normal speed, when the light turned green I took off at normal speed and I heard a huge cluck / bang from underneath the car and it bogged and didn’t want to move. I then stepped on the gas because of the Car behind me getting to close and my traction control light started to flash and the car started to shake and feel very uncomfortable to drive . After that I realize only the two front wheels of the car were working and even at low cruising speeds the car feels very unsafe and shakes and hear noises I never heard before the part that is causing this is the transfer case and transmission thus there are many other people who have had this same issues ranging from 21 to 23 tlx type s with 15k miles to 100k miles

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

Transmission splines went out and transfer case has also failed which is only sending power to front wheels

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

On 07/01/2026, at approximately 8:00 AM, during steady acceleration, flashing of MIL with loss of power presented northbound after merging from 235 west bound to I-135 north bound near Park City, KS. Particularly dangerous resulting in near rear end collision. Upon taking nearest exit ramp, attached BlueDriver .OBD II reader, and fault code P0303 - Cylinder 3 Misfire and U0401-68 PGM-Fi/ECM/PCM system event code was logged, with multiple warning indicators that safety system, AWD, brake, and other systems were disabled. Note, vehicle has had TSB 20-053 update w/ flash of PGM-Fi which did not resolve the fault, fault associated with hot and humid climates or period of rain fall, apparent water vapor, condensate build up in intercooler. For Honda Accord and Acura RDX w/ 4 cylinder 2.0 TDGI engine TSB includes redesigned intercooler replacement, that is not available for TLX 21-25 which is currently out of production. This has occurred previously during humid and hot weather, but no intermittent flashing MIL does not store code. Thankful in this instance P0303 and U0401-68 code is stored, and scheduling service at dealership to diagnose misfire.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

2021 Acura TLX Type S SH-AWD. Total mechanical failure of PTU/transfer case spline interface at 29,800 miles within factory powertrain warranty. Vehicle operated silently in FWD-only with no warning lights, no fault codes, and no dashboard alerts — consistent with all complaints cited in NHTSA Defect Petition DP26001 (opened March 6, 2026, NHTSA #11712885). Failure confirmed by dealer via lift test: propeller shaft and rear wheels stationary while fronts spun. During actuator test, Check AWD System light illuminated for the first time — because the lift removed road-induced wheel rotation that had masked the failure from the ECU throughout normal driving. This is the only condition under which this failure mode is electronically detectable. Dealer replaced transmission (remanufactured ATR kit) and PTU under warranty. Repair took 38 days. CRITICAL-THIRD PTU REVISION: Replacement PTU installed was part #29000-5YK-070. Known revision history: -050 (original, confirmed failure part) → 060 (revised ~2022) → 070 (installed June 2026). The 070 does not appear in any public OEM parts database. Acura has now revised this component three times with zero TSBs, zero public disclosure of engineering changes, and no recall. The 070 revision appearing after DP26001 opened in March 2026 suggests a silent root cause fix while avoiding formal recall obligations. CRITICAL-DPSM GOODWILL CLAUSE: Acura required acceptance of "One Time Goodwill Authorized by DPSM" as condition of repair. This was a warranty obligation, not a goodwill gesture. This clause was imposed while DP26001 is under active federal review, before factory warranty expires, with no confirmed root cause fix. If the 070 part fails again, this clause may be used to deny future warranty coverage. Requesting: (1) complaint added to DP26001 record; (2) Acura compelled to disclose engineering changes between part numbers 050, 060, 070; (3) investigation of DPSM Goodwill clause as systematic pre-recall liability limiation

Reported

Jun 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

I am submitting this complaint in reference to NHTSA Defect Petition DP26001, opened March 6, 2026, investigating loss of all-wheel drive capability in 2021-2023 Acura TLX vehicles due to interfacing spline failure between the transmission and the power takeoff unit (transfer case). I am the owner of a 2021 Acura TLX SH-AWD with 55,300 miles. I purchased this vehicle on June 2nd, 2026. I have not yet experienced a failure, but I am registering as an affected vehicle owner given the known defect pattern documented in DP26001 and consistent with the 137,329-vehicle population identified in the NHTSA investigation. The failure mode as described in DP26001 involves stripping of splines at the transmission-to-PTU junction, resulting in sudden and complete loss of rear-wheel drive without warning lights or dashboard indication. Documented repair costs for this failure range from $5,000 to $19,000 depending on extent of damage. I am registering this complaint to be included in the documented owner population should the petition escalate to a formal defect investigation or recall. I request notification of any recall action, extended warranty coverage determination, or technical service bulletin issued for this failure pattern.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

El problema es exactamente en el tanque de la gasolina, se está saliendo la gasolina en la unión de la manguera de llenado con el tanque de gasolina. Esto representa un riesgo no solo para mi seguridad sino también para cualquier persona.

Reported

Jun 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

While accelerating from a stop, I heard a loud bang from the drivetrain area and initially believed another vehicle had struck the rear of my car. After checking my surroundings, I realized there had been no collision. Immediately after the incident, the vehicle lost power delivery to the rear wheels. The vehicle is designed as an all-wheel-drive performance sedan, and the sudden loss of rear-wheel power significantly changed the way the vehicle handled. The vehicle became effectively front-wheel drive without warning, causing all engine power to be directed through the front wheels. This resulted in reduced traction, altered handling characteristics, and increased front tire wear. No warning lights, messages, or indicators appeared on the dashboard before or at the time of the failure. There were no symptoms that alerted me that a drivetrain failure was about to occur. The vehicle was inspected by an Acura dealership, and Acura confirmed failure of the transfer case and transmission components associated with the all-wheel-drive system. The transfer case and transmission are currently being replaced under the manufacturer's drivetrain warranty. I believe this failure created a safety risk because the vehicle unexpectedly lost its intended all-wheel-drive capability while in operation. Drivers rely on the handling, traction, and stability characteristics of the SH-AWD system. The sudden and unannounced loss of rear-wheel power changed the vehicle's behavior and could increase the risk of loss of control, particularly during acceleration, cornering, emergency maneuvers, or operation in poor weather conditions. The failed components are available for inspection through Acura as part of the warranty repair process.

Reported

May 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Transfer case failure. I was driving my 2021 Acura TLX Type S when I suddenly heard a loud pop from underneath the car. Right after that, the SH AWD system stopped working and the car was only driving in front wheel drive. There were no warning lights or signs before it happened, due to it being a mechanical failure and not an electrical one because the car does not have sensors for the transfer case. After getting it checked out, I was told the splines between the transfer case and transmission were stripped. I’ve also seen that a lot of other 2021 to 2023 TLX Type S owners have had the same problem. It’s concerning because the AWD system failed out of nowhere, especially since the car depends on it for traction and stability. The car now needs a new transfer case and possibly more drivetrain repairs. (Proof shown in pdf down below, only front wheels spinning)

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

I drive a 2021 Acura TLX 2.0 L turbo 4 cylinder. I was driving to work on [XXX] on a busy street in Boyle Heights, Ca. When all of sudden I get a warning indicator “engine temp is high do not drive”. Pulled over immediately. Good thing I was in the far right lane and was able to pull over and not stall or get rear ended by another vehicle behind me. There were no warning, symptoms and indicators of the engine's overheating. My vehicle has been in great condition prior with no major or minor issues with my vehicle. We took it to two dealerships for diagnostics. The head gasket blown, empty coolant reservoir, cracked engine block, and other parts of the engine were affected. What if I was on a highway and the car stalled. I could’ve been seriously injured or seriously injured someone else on the road. Acura corporate is aware of our situation and refuse to own their engine safety defects. They want us to pay out of pocket to repair our vehicle. My car is 5 years old there is no way out of nowhere my vehicle should have this type of engine issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Dealers are investigating and need replacing rear shocks/solenoids, stroke sensors, and wiring harnesses. The issue is commonly identified as corrosion in the rear stroke sensor wiring harness or faulty damper make "Adaptive Damper System" (ADS) error light on and can't not make change for the setting as acura design issue !

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Took my car for an oil change and found that the transfer case is leaking its fluid. Known to lead to tranfer case failure.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

I am reporting a transmission failure in my 2021 Acura TLX with approximately 84,300miles. While driving under normal conditions, after about 30 minutes on the road, I came to a stop at a red light. When I attempted to accelerate again, the vehicle would not shift out of first gear. The engine would rev, but the transmission failed to upshift. I also experienced a hard and abrupt engagement when shifting the vehicle into reverse. This issue occurred suddenly without warning and made the vehicle unsafe to operate in traffic, as I was unable to accelerate properly or maintain normal driving speed. The vehicle has been regularly serviced at an Acura dealership. At the time of the incident, the transmission fluid had not yet been replaced but had recently been recommended during a scheduled service visit. The vehicle is currently at an Acura dealership where I normally get the car serviced. The dealership has diagnosed the issue as an internal transmission failure and is recommending a transmission replacement.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

} I am submitting an update to my previous complaint. In my original complaint, I stated that the vehicle had not received transmission service. After reviewing my records, I confirmed that a transmission fluid service (drain and refill with inspection) was performed at an Acura dealership in July 2024. Despite this maintenance, the transmission still failed at approximately 84,000 miles. I am providing this update to ensure the complaint is accurate

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Sunroof exploded during drive on highway. No contact was made by any small or large objects

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The awd transfer case failed and require replacement along with the transmission

Reported

Apr 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

2021 Acura TLX A-Spec SH-AWD and my transmission is leaking from the seal between the transmission and the differential. Acura is not sure if they can cover it under warranty because I am slightly past the powertrain warranty even though they had my car about a week ago when it was just barely past that point and no one said anything about the leak on the transmission until I checked with a certified Acura mechanic somewhere else.This is not just some small problem because with fluid leaking and leaving it will eventually damage the transmission and the differential or even just make them completely give out. This can be gears grinding and overheating. It is not just a problem it is also a SAFETY HAZARD if this starts dripping onto the exhaust pipe or even on the road behind making traction a problem for someone behind. This needs to be under a recall not just warranty with how much I see this happening to these cars this is ridiculous we have to go through this.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Transfer Case has gone out. No longer getting power to the rear wheels as it is a AWD car. Problem has not been checked by the dealer yet. There were no warning lights on the dashboard when it went out.

Reported

Apr 2026

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

The All Wheel Drive (AWD) system of the vehicle became partially inoperable after hearing a loud bang under normal vehicle acceleration some time in early 2025. The vehicle did not trigger or display any warnings stored in the onboard computer or on the dash display that the AWD system had any faults or issues. Had this system failed during an emergency situation involving hazardous or dangerous driving conditions like snow, ice, heavy rain, it could have caused me to not have improved capable vehicle handling. The vehicle's ability to distribute power evenly to all 4 wheels was hindered and operating as front wheel drive only after the loud noise was observed. Additionally, transmission gear oil began leaking underneath the vehicle around the transmission casing. The issue has been reproduced, confirmed, and validated by technicians of a local Acura dealership. The dealership was approved to completely replace the following two components of the AWD system under the manufacturer's 6 year / 60K mileage powertrain warranty: 1. Transmission 2. Transfer case - also known as power transfer unit or PTU

Reported

Apr 2026

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

The all wheel drive failed do to transfer case splines being sheered off between the transmission and transfer case. No warning lights are on to warn of the rear wheel tires not receiving power to them. I was not aware of this problem and this could have contributed to and accident, as I though the AWD was working, but it wasn't.

Reported

Mar 2026

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

Transfer case needs replacing

Reported

Mar 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

My vehicle was performing as expected, but there was a smell of burning oil or rubber. When I took the car into the dealership the found that the transmission was slipping and the transfer box was failing. In the video they sent of the initial inspection there is obvious brown sludge leaking from the transmission. I was told that a complete transmission and transfer case was required.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Driving towards the gas station, still at lows speeds while I was in the neighborhood so speed limit was 15mph. I can hear and feel the car struggle to move forward, about 2 minutes into the drive a hear a big TOON and check engine light is on for about a minute before going away. I filled gas and headed back home and I heard a larger TOON but this time all the warning light came up. These are all errors reported by the car at the same time - Vehicle Stability System - Hill Start Assist Problem - Addictive Cruise Control System Problem - Collision Mitigation Braking System Problem - Road Departure Mitigation System Problem - Emission System Problem - All Wheel Drive System Problem - Brake System Problem These are all errors that appeared on the Acura app - Emission System Problem - Vehicle Stability System - Electric Parking Brake Problem - Electric Power Steering Problem - Adaptive Cruise Control Problem

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The transfer case in my Acura TLX Type S failed due to the internal splines stripping at approximately 57,600 miles. I heard a loud bang while attempting to maneuver out of a parking spot that was covered in snow. When this occurred, the transfer case was no longer able to transfer power to the rear wheels, causing the all-wheel-drive system to stop functioning. As a result, the vehicle effectively operated as front-wheel drive only. The most concerning part of this failure is that the vehicle provided no warning whatsoever to the driver. There were no dashboard alerts, drivetrain warnings, AWD system warnings, or check engine lights indicating that the AWD system had failed. The vehicle continued to operate and display information as if everything was functioning normally. This occurred during the winter in New York while driving in snowy conditions, where the AWD system is critical for traction and safety. Because there was no warning that the AWD system had failed, I continued driving the vehicle assuming it still had AWD capability. On multiple occasions the vehicle became stuck in snow due to the loss of rear-wheel power. A critical drivetrain component such as a transfer case should not fail under normal driving conditions at this mileage. Additionally, a vehicle equipped with AWD should provide a clear warning to the driver if the system is no longer functioning. The absence of any warning combined with a sudden loss of AWD capability creates a serious safety concern, particularly in winter climates where drivers rely on AWD for traction and control. Under the wrong circumstances this type of failure could potentially lead to an accident or serious injury.

Reported

Mar 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

I am submitting this complaint regarding a sudden and premature transfer case failure on my 2021 Acura TLX Type S equipped with Acura’s Super Handling All-Wheel Drive (SH-AWD) system. The failure occurred during normal driving conditions and without prior warning indicators. Based on my experience and numerous similar reports from other owners of this vehicle, this appears to be an ongoing and systemic issue that warrants formal investigation and recall consideration. While accelerating under normal road conditions, I heard a loud and distinct “pop” noise from underneath the vehicle. The sound was abrupt and mechanical in nature, as if an internal drivetrain component had failed. Immediately following the noise, the vehicle’s driving characteristics changed noticeably. Although the car continued to move forward and there were no immediate warning lights illuminated on the dashboard, the drivetrain behavior was clearly altered. After the incident, the vehicle began operating as though the majority of drivetrain load was being directed to the front wheels. The vehicle now feels significantly front-heavy during acceleration and general driving. There is a distinct change in weight transfer and torque delivery that was not present prior to the failure. The balance that is characteristic of a rear-biased SH-AWD performance system is no longer present. There were no grinding sounds, fluid leaks, or vibration at the time of failure. There were also no warning messages, check engine lights, AWD system warnings, or drivetrain alerts displayed to notify me of any malfunction. The failure occurred suddenly and without notice.I respectfully request that NHTSA open a formal investigation into premature transfer case failures on 2021–2023 Acura TLX Type S vehicles equipped with SH-AWD. This issue should be evaluated for recall eligibility or mandated corrective action to ensure driver safety. Thank you for reviewing this complaint.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

My car has suffered a well known issue in the 21-25 Acura TLX community. At 71,000 miles my transfer case splines stripped also with the transmission splines. Resulting in me having to pay out of pocket to replace both the transmission and transfer case. I’m really hoping Acura does a recall for this issue. I really like this car and don’t want to have to replace them again. Like I mentioned before. I’m in a Facebook tlx group and people are constantly posting about theirs blowing.

Reported

Feb 2026

Incident date

Apr 2025

Mileage

Not provided

Outcome flags

None reported

Adaptive Damper System error on dashboard. Took the car to the dealer and they confirmed two issues. Codes C1646-14 and C1647-14 indicating the stroke sensor has lower limit abnormality. Dealer recommended replacing both rear shocks due to over extension. Once shocks were replaced, codes returned. During further investigation, corrosion was found in the stroke sensor wiring harness. Harness is the root cause of the issue. Car is available at the dealer for inspection if necessary. From a safety perspective, if I continued to drive the car I could have experienced a malfunction in the braking system which could have led to brake failure, failure of safety features, or a car stall.

Reported

Feb 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

My gas tank is failing from the fuel seal, my safety is in danger since it throws a lot of gasoline, take the car to the dealer but they say it's not a factory problem

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

See Attached Letter for potential Defect Petition DP26001

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

This 2021 Acura TLX Type-S has experienced a complete failure of the transfer case after approximately 40,000 miles of use. This unfortunately is a known issue on the online forums for this vehicle in model years 2021-2023. I have a video inspection performed by the local dealership proving this. The only warning is a one-time loud boom when accelerating and a leaking from the transfer case of fluid thereafter. There is no safety issue best I can tell, however the car only performs in front drive mode once the transfer case quits working. The issue is due to weak splines within the transfer case that shear off and thus damage the 10-speed automatic transmission in the process. Acura has a 6 year 70,000 mile warranty, so a complete replacement is covered, however my concern is for whether the new transfer case part # 29000-5YK-060 which replaces the old 29000-5YK-050 part will do the same. This is a very expensive fix into the 5 figures (over 10,000) and really needs to have a recall as there are dozens and dozens of owners online who have experienced this failure.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

To Whom It May Concern: The purpose of my complaint is to bring to your attention reprehensible policies and misconduct displayed by the automaker, Acura, the premium subsidiary brand of the American Honda Motor Company. On 11/18/2025, I brought in my 2021 Acura TLX Tech w/SH-AWD in for a problem related to the brakes. The front brakes were and continue to make a jarring, very loud, high-pitched squeaking noise at low speeds. After 4 hours at Radley Acura of Falls Church, VA, the technician stated "could not duplicate" the concern. The problem persisted and I again returned on 12/18/2025 for the same issue. My vehicle has been at the dealership awaiting a response from Acura Client Relations on a claim that I submitted on 12/19/2025. Radley Acura diagnosed the issue as a well-known defect of 2021 TLX models, as evidenced by Acura's own service bulletin describing the very issue I continue to experience (and yet were unable to diagnose on 11/18). Radley Acura is stating that although my vehicle is 28,000+ miles UNDER the manufacturer's warranty, that by time, since purchase, it is outside the manufacturer's warranty by approximately 6 months. However, on 1/27/2025 (when my car was within manufacturer warranty and only had 17,215 miles on the odometer), I completed a lease buyout of my car. In addition, I paid to have it Acura Precision Certified. As part of this paid certification, Radley had my car for over a day to allegedly perform a 182-point inspection, and address a recall open for over a year (with a remedy from Acura - but allegedly no available repair parts to fix my car, until I requested to CPO my at the time of lease buyout). During their CPO inspection, the dealership failed to address the open service bulletin on the front brakes--a documented issue Acura has been aware of since before 2/15/2022, as established by their service bulletin. Now the dealership is stating the manufacturer's defect that they failed to address is $500 out of pocket expense.

Reported

Jan 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Problem with all safety feature sensors like Adas, lane assistance. Small car icon which always green turned orange, and none of those features working.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

My 2021 TLX Type S front wheels started to spin upon acceleration at 44K miles. I immediately scheduled an appt for the dealership. Was informed I needed a new Transfer Case Unit, as the splines were shredded. With this, I also had to replace the transmission. All replaced and picked up today 12/2/2025

Reported

Dec 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

Was driving the car under normal acceleration when the transfer case failed. No power to the rear wheels. Acura dealer confirmed the problem. Will be fixed under warranty. No warning lamps or messages on the dash.

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

Transfer case blew. AWD was not working.

Reported

Oct 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

While driving my 2021 Acura TLX Type S, I began losing traction frequently during normal daily driving, especially when turning corners or accelerating from a stop sign or stop light. At first, I believed the issue was related to my tires, so I replaced them, but the same problem continued. After researching online, I discovered that transfer case failures are a known issue on these vehicles, affecting both new and used models. Currently, my vehicle is at the dealership, but they were unaware of this recurring transfer case problem and have no information about it. This is concerning because the failure of the transfer case directly affects traction and stability, creating a potential safety risk to myself and others on the road. It appears to be a systemic issue that Honda/Acura has not yet acknowledged.

Reported

Oct 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

- The transfer case failed causing the AWD system to stop working -It is a safety concern because you may lose control since no power is going to rear wheels, especially in inclement weather that we receive in the northeast. -Yes the problem has been confirmed by dealership by putting car on lift and seeing that no power is being sent to the rear wheels. -There are no warning lights or any signs, you just hear a loud bang while driving and lost of traction while accelerating

Reported

Sep 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

While using the Air Conditioner in Comfort Mode Suspension settings on my Advanced SHAWD model, the front suspension intermittently squeaks and creaks. It is very audible in the colder months or after it rains.

Reported

Sep 2025

Incident date

Dec 1969

Mileage

Not provided

Outcome flags

None reported

While performing a right turn, under normal acceleration a loud "pop/clunk" occurred. I immediately pulled into a parking lot as the vehicle was still able to drive. The vehicle runs as normal, no leaks of any kind present. Nothing visibly broken. Afterwards, I was able to determine with the vehicle suspended off of the ground, I am getting power only to the front wheels. Utilizing google, it's easy to see that this has become a MASSIVE issue on this particular model TLX Type S. The vehicle will be taken to Acura on Monday Aug 18th 2025 for diagnostics, but it's quite obvious that the splines on the transfercase at the transmission mounting location have sheared completely, thus making the vehicle front wheel drive powered only. Given my current situation, my hope is that Acura will honor the power train warranty as it is my understanding that both the transmission and the transfercase are required to be replaced in this instance. Acura also needs to issue an updated transmission/ transfercase combination and a recall because this is happening way to often and it's quite an expensive repair.

Reported

Aug 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

The wipers come on by themselves and do not turn off. The engine may or may not start with the key fob nearby. All the dash warning lights come on with warnings about the brake system, the transmission, the steering, the adaptive cruise control all reporting a problem. The vehicle goes to limp mode and throttle response is severely reduced. There is some sort of water leak which is shorting out or causing the BCM or body control module to act erratically due to water from rain getting into the area because of improper weather sealant placed during manufacturing. There is a service bulletin that was put out in roughly April of 2024 that describes this issue affecting the 2021 TLX models.

Reported

Aug 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

Transfer case failure. Spline is stripped after 40k. AWD is disabled. Requires new transfer case and transmission

Reported

Jun 2025

Incident date

Mar 2025

Mileage

Not provided

Outcome flags

None reported

The contact owned a 2021 Acura TLX. The contact received a notification of NHTSA Campaign Number: 24V064000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that while accelerating from a stop, she was struck by another vehicle driving at 55 MPH on the front passenger side. The vehicle spun around due to the impact and came to a stop facing oncoming traffic. The contact lost consciousness. No air bags were deployed. The contact sought medical care for a brain trauma, whiplash, loss of hearing in the left ear, headaches, blurry vision, loss of hand motor skills in her left arm, and injuries to their neck and spine. A police report was filed. The vehicle was deemed a total loss by the insurance provider. The vehicle was towed to a local tow lot for further investigation. The local dealer was not notified of the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 20,000.

Reported

Jun 2025

Incident date

Mar 2025

Mileage

Not provided

Outcome flags

Crash 1 injuries

While driving normal, I heard a pop sound coming from the bottom of the car which resulted in my AWD not working. On acceleration the car would spin the front wheels and the traction light would light up. Took to dealer and they confirmed the transfer case and transmission failed and had to be replaced. The splines between both components had stripped.

Reported

Jun 2025

Incident date

Feb 2025

Mileage

Not provided

Outcome flags

None reported

-Transmission and transfer case failed, specifically the splines on the input shaft connecting the two, rendering the vehicle FWD instead of AWD. Parts are not available to inspect as they were returned to dealer. -While the vehicle could still function in front wheel drive, the lack of AWD could be a safety risk in poor weather or road conditions, especially given that the vehicle does not send an error code for this issue. -Problem was reproduced by the dealer, who replaced both parts after a 2-month wait for parts. -There is zero indication that these components failed, no error codes or anything. The car also displays how much power is going to each wheel on the gauge cluster, and displays just as it did when everything worked. The problem can only be noticed when using AWD, so many drivers may not know they have this issue. I experienced the traction control light blinking on hard acceleration due to front tire slip and understeer during turns, but beyond that there was no indication anything was wrong. -The dealer informed me this would be a 12,000 repair out of warranty, which I find unacceptable given that the car doesn't give any error codes. Many many people may not know their car is effected.

Reported

Jun 2025

Incident date

Mar 2025

Mileage

Not provided

Outcome flags

None reported

• Transfer Case failure, leading to transmission damage. • Vehicle gives no indication of Transfer Case failure, in turn, giving the Driver the impression that the vehicle is AWD. Potential risk to safety as the failure happened under normal driving conditions, vehicle suddenly jolts, with loss of power. • Problem addressed by Dealership Service Dept. but not able to recreate, as this is a drivetrain fault. • Vehicle and components inspected by Dealership Service Dept. only. • No indications or warning lights for TC failure. AWD system on dashboard indicates power is going to all four wheels when this is not the case.

Reported

Jun 2025

Incident date

Mar 2025

Mileage

Not provided

Outcome flags

None reported

At 36,823 miles and October 11,2024 I was taking off from a stop. About 10 seconds into my take off I heard a loud bang and hard jerk. Dash cam caught it happening. As soon as it happened I was still moving forward but just coasting. As soon as I accelerated a tiny bit it sounded like metal being beaten around inside something. No warning light or CEL came on. Nothing. After I parked it the sound disappeared and it seemed to drive fine but a little different. I noticed then that I would lose traction easily and my front wheels would spin out like a fwd Civic. I called the dealership immediately and told them what happened. They put a note in my file. They said they couldn’t do anything unless it happened again. I had to go to the dealership 3 separate times to try to get them to look at it. At the third trip and me being a little pissy that they took me seriously and found out that in fact my rear wheels wouldn’t spin and my driveshaft wasn’t spinning either. In December of 2024 my transfer case and transmission were replaced under warranty. The splines in the transmission were totally stripped.

Reported

Jun 2025

Incident date

Oct 2024

Mileage

Not provided

Outcome flags

None reported

Transfer case failed, awd system inoperable. Only front wheel drive when it is suppose to be awd. Vehicle is at the acura dealership getting repaired

Reported

May 2025

Incident date

Dec 2024

Mileage

Not provided

Outcome flags

None reported

2021 Acura TLX Type S. Car has 53k miles on it. No modifications, bone stock. When accelerating from a stop at 50% throttle, there was a sudden loud pop from the front of the car, followed by immediate loss of power to the back wheels (AWD car) . The vehicle was about to shift from first to second gear, so thankfully I was still only going about 10-15 mph at the time. Had i been traveling faster, turning, or if the roads were wet/slick, it could have caused an accident due to my loss of control of the car. There were no warning lights or indication prior to this occurring, and no warning lights or indication after the incident occurred either. In fact, the torque distribution screen on the console showed power to the back wheels, despite that not being true. All recommended maintenance and oil changes were performed on the car at appropriate times. The problem ended up being a completely stripped transfer case housing / damaged splined shaft on the transmission (picture of transfer case attached). This was finally diagnosed after 2-3 weeks once the dealer lifted the vehicle and checked for power in all 4 wheels (of which only the front two tires would spin). Dealer replaced the parts under warranty after it was shown that the back wheels had no power. However, I believe the same part number was used in the replacement, indicating a potential likelihood of another failure in the future if this part is defective. I'm not sure if this has been reported by others, but I was only able to identify the problem by finding a post on an owners forum that showed identical problems to mine. Conversations in other owners groups suggests this is a wide spread problem with the early renditions of the new Acura TLX Type S line (2021-2023). A poll in a TLX Type S Owner facebook group I am in, indicated that 16% of folks have had similar failures (out of 170 members polled).

Reported

May 2025

Incident date

Nov 2024

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Acura TLX. The contact stated that while driving over a bump in the roadway, there was a squeaky metallic sound coming from the front passenger’s side suspension. The cause of the failure was not yet determined, and the vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure and advised the contact to have the vehicle diagnosed. The failure mileage was 91,000.

Reported

May 2025

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

Transfer case broken; no longer sending power to the rear wheels. Car loses traction when accelerating from a stop.

Reported

Apr 2025

Incident date

Apr 2025

Mileage

Not provided

Outcome flags

None reported

Honda (American Honda Motor Co.) is recalling certain 2021-2025 Acura TLX, 2023-2025 Acura MDX, and 2023-2025 Honda Pilot vehicles. The brake pedal pivot pin was not secured properly, which can cause the pedal to shift out of position. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard numbers 108, "Lamps, Reflective Devices, and Associated Equipment" and 135, "Light Vehicle Brake Systems."

Risk: A brake pedal that shifts out of position can prevent the driver from applying the brakes as intended, increasing the risk of a crash or injury.

Remedy: Dealers will inspect and replace the brake pedal assembly as necessary, free of charge. Owner notification letters were mailed July 29, 2025. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are FLX and XLY.

Honda (American Honda Motor Co.) is recalling certain 2020-2022 Pilot, Accord, Civic sedan, HR-V, Odyssey, 2020 Civic coupe, Fit, 2021-2022 Civic hatchback, 2021 Civic Type R, Insight, 2020-2021 CR-V, CR-V Hybrid, Passport, Ridgeline, Accord Hybrid, 2020 Acura MDX, 2022 Acura MDX, 2020-2022 Acura RDX, and 2020-2021 Acura TLX vehicles. The front passenger seat weight sensor may crack and short circuit, failing to suppress the air bag as intended.

Risk: An air bag that deploys unintentionally during a crash can increase the risk of injury.

Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed March 28, 2024. This is a phased recall. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XHP and VHQ.

Acura (American Honda Motor Co.) is recalling certain 2021-2023 TLX vehicles. The fuel filler neck and fuel tank may have been improperly welded, which can result in a fuel leak.

Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Dealers will replace the fuel tank assembly, free of charge. Owner notification letters were mailed February 3, 2025. Owners may contact Honda customer service at 1-888-234-2138. Acura's number for this recall is JKX.

Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.

Risk: Air bags that deploy unintentionally during a crash increase the risk of injury.

Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.