2020 Toyota Sienna inspection checklist

The records describe a problem worth checking before purchase.

“The contact owns a 2020 Toyota Sienna. The contact stated that while his wife was driving at an undisclosed speed, the pre collision, lane assist, and air bag warning lights illuminated on the instrument panel. The vehicle was taken to a dealer and a fuse in the ECU (Electronic Control Unit) was replaced; however, the contact stated that approximately 10 days later, the failure recurred. The vehicle was taken back to the dealer where the vehicle remained for almost two weeks. The contact was informed that the wiring harness needed to be replaced; however, the wiring harness was on backorder. The manufacturer was notified of the failure, but no additional assistance was provided. The contact was provided a case number. The vehicle was not repaired. The failure mileage was approximately 60,000.”

The records describe a problem worth checking before purchase.

“My Toyota sienna is a 2020, has 83,000 miles and has recently been squealing when I accelerate. I took the van to a local body shop and they said it seems to be my transmission. I called Toyota immediately and they knew that the transmissions were faulty and that they would try to work with Toyota to get it fixed. There is no way I can pay 9k for a new transmissions because they put in faulty ones.”

The records describe a problem worth checking before purchase.

“The power sliding door assembly failed, and the driver side rear sliding door was bound shut, and could not be opened. Disabling the power door system did not resolve the issue. The cable for the power door mechanism was hanging below the rear vent windows; but for some reason the door still would not open. I ultimately with a lot of gentle force was able to get the door open enough to see the retract side of the cable was bound up, and was able to cut it with wire cutters, and ultimately get the door to work normally as a non-powered manual sliding door. Since the original NHTSA BULLITIN on this was published in 6/2019 before my 2020 Sienna was manufactured, and Toyota did not change the mechanism until the 2021 model redesign, I believe that RECALL should be extend to all 2019 and 2020 vehicles. This seems dangerous that the door does not default to manual operation in error.”

The records describe a possible crash, fire, injury, or loss of control.

“Braun Corporation (Braun) is recalling certain modified 2017-2020 Toyota Sienna vehicles. The steering shaft extensions may have been improperly manufactured, possibly causing the extensions to fracture. If the steering shaft extension completely fractures, it can cause a loss of steering, increasing the risk of a crash. Braun has notified owners, and dealers will replace the steering shaft extensions, free of charge. The recall began July 25, 2019. Owners may contact Braun customer service at 1-800-488-0359.”

The records describe a possible crash, fire, injury, or loss of control.

“Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, 2019-2020 Tundra, 2018-2020 Lexus ES350, 2017 Lexus GS200t, 2017-2019 Lexus GS350, 2019 Lexus GS300, 2018-2020 Lexus LC500h, 2019-2020 Lexus LS500, 2018-2019 Lexus GX460, 2017 Lexus IS200t, 2019 Lexus IS300, 2019 Lexus IS350, 2018-2020 Lexus LC500, 2018 Lexus LS500, 2019 Lexus LS500h, 2018-2019 Lexus LX570, 2017 Lexus RC200t, 2019 Lexus RC300, RC350, 2017 and 2019-2020 Lexus RX350, 2018-2020 RX350L, 2019 Lexus UX200, 2018-2019 Lexus NX300 vehicles. The low-pressure fuel pump inside the fuel tank may fail. If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash. Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.”

The records describe a problem worth checking before purchase.

“Safety Recall and Service Campaign - Technician Certification Requirements”

The records describe a problem worth checking before purchase.

“Toyota Safety Recall and Service Campaign - Technician Certification Requirements”

The records describe a problem worth checking before purchase.

“DL: On December 20, 2022, a settlement of claims for certain low pressure fuel pumps was approved by the federal court. The settlement includes Toyota?s agreement to provide a Customer Support Program for certain 2014-2020 model year (MY) vehicles originally equipped with low pressure fuel pumps repaired under Safety Recall 20TA02, Safety Recall 21TA03, Safety Recall 21TA05 or Special Service Campaign 21TC03. The purpose of this Customer Support Program letter is to help clarify how to administer this coverage in accordance with the settlement.”

The records describe a problem worth checking before purchase.

“The air conditioning dye injection tool kit has been developed to aid in identifying the location of air conditioning refrigerant leaks. The procedures outlined in this Service Bulletin aid in locating, inspecting, and repairing refrigerant leaks.”