2019 Kia Sportage reported problems

The records describe a problem worth checking before purchase.

“The engine locked up about a year ago, and since we didn’t technically have a recall we didn’t know what to do. It was able to drive again after we had a technician work on it, but now it’s not driving anymore. It shakes hard when it’s idling and driving. We have waited over 2 weeks to be diagnosed with the problem. We have had to spend $1300 on rental cars because we can’t get a loaner until diagnosed. The car is not safe to drive and puts our lives at risk to drive it. We were lucky it didn’t start shaking while we were driving on a major highway, but it did still happen while driving and was terrifying. The car is at Williams Kia now, in Elmira NY. They still haven’t diagnosed the problem. The check engine light is on.”

The records describe a problem worth checking before purchase.

“The vehicle is experiencing excessive engine oil consumption. The engine was found by the dealership to be low by 3 quarts of oil after about 1000 miles during an oil consumption test, indicating abnormal oil loss. The suspected failure involves internal engine components, possibly piston rings, allowing oil to enter the combustion chamber and burn. This condition creates a safety risk because the engine can become critically low on oil, without warning, potentially leading to engine damage, loss of power, or engine failure while driving. The problem has been reproduced and documented by the dealership during oil consumption testing. However, there are inconsistencies in the dealership’s reporting, as later documentation stated that no oil consumption was found despite earlier records showing excessive oil loss. This vehicle has been inspected multiple times by an authorized dealership and is currently part of an open case with the manufacture. The vehicle was also held at the dealership for approximately three weeks without clear documentation of work performed. There were minimal warnings indicators prior to the issue. The vehicle showed rough engine performance, which was consistent with oil fouling the spark plugs. No clear warning light reliably indicated the severity of the oil loss before the condition was discovered during testing.”

The records describe a problem worth checking before purchase.

“Severe oil consumption issue at 100k miles. Same issue seen on kia class action lawsuit for GDI engines. No leaks present, after 800 miles from oil change, no oil seen on dip stick.”

The records describe a problem worth checking before purchase.

“Engine went out at 150,000 miles.”

The records describe a problem worth checking before purchase.

“The contact owns a 2019 Kia Sportage. The contact stated that while the vehicle was in for maintenance, the contact was informed that there was no oil in the engine. The contact stated that the oil warning light had only illuminated once. The vehicle was taken to the dealer, where the first oil consumption test was performed. The dealer added oil to the vehicle. The contact checked the oil level every two weeks and noticed that the engine was consuming an excessive amount of engine oil. The contact was adding several quarts of oil every two weeks. The vehicle had several oil consumption tests performed by the dealer. The contact was informed that less than a quart of oil was lost. However, while the vehicle was at the dealer, all the oil had leaked out of the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but did not offer any assistance. However, a claim was filed. The failure mileage was approximately 70,000.”

The records describe a problem worth checking before purchase.

“My engine has been burning through oil very fast, it is only 6 years old. I have to put oil in it approx 3 times before another oil change is due. My mechanic suggested I see if there were any recalls but there are none. I have no lights on or any other issues.”

The records describe a problem worth checking before purchase.

“The I started noticing my oil light was coming on after only few hundred miles. After every oil change a week or 2 later I would need oil. Took it to a several mechanics and no leaks founds they all said the GDI engines are known for consuming high amounts of oil. I called Kia and they admitted they know about the problem but will do nothing about it”

The records describe a problem worth checking before purchase.

“The car started stalling anf an engine light came on”

The records describe a problem worth checking before purchase.

“Hyundai and Kia ABS Module Fires The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.”

The records describe a problem worth checking before purchase.

“Loss of Motive Power The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing.  There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.”