Power Train owner reports: Ford Fusion years in the records

The records describe a possible crash, fire, injury, or loss of control.

“A failed transmission cooling line caused the transmission fluid to leak. At no point did the vehicle display a check engine light, transmission warning, or any other indication that there was a problem. According to the Ford dealership, the transmission fluid had been leaking for some time. Because the transmission pan is wrapped in a fabric-like insulating material, the leaking fluid was absorbed rather than dripping onto the ground, making the leak virtually impossible for an owner to detect during normal use. The dealership also advised that this condition could have created a potential fire hazard within the engine compartment. The vehicle has only approximately 40,000 miles, making this type of catastrophic transmission failure especially concerning for a relatively low-mileage vehicle. The first and only symptom occurred when I started the vehicle one day. It hesitated, struggled to shift out of first gear, and drove abnormally. I immediately drove it to the Ford dealership, where it was diagnosed with a complete transmission failure. The vehicle is currently at the dealership, and I have been presented with an estimated repair cost of approximately $12,000. My primary concern is that there was absolutely no warning before this major failure. No warning lights, no diagnostic alerts, and no indication that a significant transmission fluid leak or internal transmission damage was occurring. A safety-critical failure of this magnitude should provide drivers with some form of warning before resulting in complete transmission failure.”

The records describe a possible crash, fire, injury, or loss of control.

“I have had this car for 6 years and the transmission has gone out on top of the purge valve, I have seen many people have the same issues with this model and year of this car. THIS NEEDS TO BE ADRESSED. I also see that there is a lawsuit against this issue with the transmission model 6F35”

The records describe a possible crash, fire, injury, or loss of control.

“2020 Ford Fusion 1.5L EcoBoost engine completely failed. Ford dealership diagnosed need for complete engine and turbo replacement at $13,475. Believed to be related to known EcoBoost coolant intrusion defect.”

The records describe a possible crash, fire, injury, or loss of control.

“Coolant problems and cylinder damage on engine due to coolant intrusion. Ford has not issued a recall on this well known problem and issue on ALL Ford Fusion Models. Several complaints have been made by many Ford Fusion owners for putting drivers and vehicle owners at risk of driving unsafe vehicles and poor driving conditions.”

The records describe a possible crash, fire, injury, or loss of control.

“The contact owns a 2020 Ford Fusion. The contact stated that upon rolling to a stop, the vehicle started shuddering while depressing the brake pedal. The contact stated that the message "Transmission Not in Park" was displayed. The gear shifter then unexpectedly shifted to several positions independently. The contact discovered a YouTube video that assisted with correcting the issue. The contact used a screwdriver to manually shift the gear shifter back to park(P). The contact was forced to maneuver the shifter back and forth until the gear shifter engaged and resumed normal operation. The contact stated while his wife was driving the vehicle on one occasion, the failure recurred, and the driver was forced to tow the vehicle to a local dealer. Upon investigation, the contact discovered NHTSA Campaign Number: 22V413000 (Power Train) and associated the failure with the recall. The manufacturer was notified of the failure and informed the contact that the vehicle was not included in the recall. The contact was provided a case number. The vehicle was not diagnosed or repaired and remained with the dealer. The failure mileage was approximately 150,000.”

The records describe a possible crash, fire, injury, or loss of control.

“Automatic transmission failed No warning No smells no shaking no jerking no light on dash board until it went out that's when it jerk and still no check engine light just a wrench that popped up once”