Verdict
2010 Volvo S80: Complaints, Recalls & Known Issues
What the public record actually says about the 2010 Volvo S80 — every figure below is a NHTSA or EPA number, not an opinion.
The read
Fewer reported complaints than most sedan.
Owners filed 27 NHTSA complaints — fewer complaints than 75% of 2010 sedans. Structure leads the reports (15%). 5 safety recall campaigns on record — check the VIN and remedy terms with a dealer.
Based on NHTSA complaint volume against 2010 sedans, not adjusted for how many were sold. It describes the model year, not the individual car you are looking at.
Complaints filed
27
Reports to NHTSA, 2010
Safety recalls
5
NHTSA campaigns on record
NHTSA crash test
Not rated
Overall NCAP rating
Combined MPG
19
EPA estimate
Complaint volume vs. segment peers
Fewer complaints than 75% of 2010 sedans
The bar is this car's percentile among 2010 sedans by complaint volume — a full bar means the fewest complaints in its class. Not adjusted for sales.
Known issues
Structure issues lead owner complaints (15% of 27 reports), followed by visibility/wiper (15%).
+ 7 more component categories with fewer reports.
Share of all 27 NHTSA complaints for this model year, grouped by the component owners named. Bars are scaled to the largest category. Examples: ODI 11665865, ODI 11458491, ODI 11453263, ODI 11437898.
Recalls(5)
Open a recall to read what NHTSA says is wrong, what can happen, and how it gets fixed. Check the VIN and remedy eligibility with a dealer; federal no-charge requirements have an age limit, though a manufacturer may offer more coverage.
EquipmentAug 2010 · 10V566000Details +Close −
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Risk: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
Electrical SystemJan 2009 · 09V343000Details +Close −
VOLVO IS RECALLING MY 2008-2010 S80, MODEL YEAR 2009-2010 XC70 AND MODEL YEAR 2010 XC60 VEHICLES. UNDER CERTAIN CONDITIONS THE SOFTWARE WITHIN THE CENTRAL ELECTRONIC MODULE (CEM) MAY NOT SEND A SIGNAL TO THE FUEL PUMP ELECTRONIC MODULE (PEM). THIS MISSING SIGNAL TO THE PEM INHIBITS THE START OF THE FUEL PUMP. THE DRIVER MAY BE ABLE TO START THE ENGINE IN SPITE OF THE FUEL PUMP NOT BEING ACTIVATED DUE TO RESIDUAL PRESSURE IN THE FUEL SYSTEM. IN SOME CASES, THE DRIVER MAY BE ABLE TO DRIVE THE VEHICLE A SHORT DISTANCE AT IDLE BUT THEN THE ENGINE MAY STALL.
Risk: IF THE VEHICLE STALLS IN CERTAIN CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL DOWNLOAD SOFTWARE TO THE VEHICLES' CEM FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 30, 2009. VEHICLES IN DEALER'S INVENTORY WILL BE REPAIRED PRIOR TO DELIVERY. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Tires · 10V335000Details +Close −
VOLVO IS RECALLING CERTAIN MODEL YEAR 2007-2010 S80 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE AND LOADING INFORMATION LABEL AND A PAGE IN THE OWNER'S MANUAL CONTAIN INCORRECT MAXIMUM PERMISSIBLE INFLATION PRESSURE AND THE TIRE PRESSURE MONITORING SYSTEM (TPMS) SOFTWARE HAS AN INCORRECT TRIGGER LEVEL.
Risk: THESE VEHICLES DO NOT MEET THE REQUIRED SAFETY STANDARDS.
Remedy: DEALERS WILL UPDATE THE VEHICLES WITH A NEW TIRE AND LOADING INFORMATION LABEL, OWNER'S MANUAL LABEL AND TPMS SOFTWARE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT AUGUST 27, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR CUSTOMERCARE@VOLVOFORLIFE.COM .
Air Bags · 10V489000Details +Close −
VOLVO IS RECALLING CERTAIN MODEL YEAR 2010-2011 S80, XC70, MODEL YEAR 2011 XC60 AND MODEL YEAR 2010 V70 VEHICLES. THERE MAY BE AN INTERMITTENT FAULT IN THE DRIVER'S AIRBAG CLOCKSPRING WIRING CONNECTOR FOR THE SUPPLEMENTAL RESTRAINT SYSTEM.
Risk: IN THE EVENT OF A CRASH, THE DRIVER'S FRONTAL AIRBAG MAY NOT DEPLOY AS INTENDED OR AT ALL, AND THEREFORE WILL NOT BE ABLE TO PROPERLY PROTECT THE DRIVER, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSTALL A METAL SHIM IN THE DRIVER'S AIR BAG CLOCKSPRING WIRING CONNECTOR. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 20, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Seat Belts · 20V378000Details +Close −
Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating positions may fatigue over time, causing the seat belt to not secure the occupant in the event of a crash.
Risk: An unsecured occupant has an increased risk of injury in the event of a crash.
Remedy: Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R10029.
A campaign can apply to this model year without being incomplete on a specific vehicle. Check the VIN with NHTSA or a dealer to confirm whether a particular car needs repair.
Investigations
0 NHTSA investigations on record
No investigations are on record as of Jul 2026. An empty record is not a clean bill of health.
Crash-test ratings
2010 Volvo S80 4-DR. w/SAB NHTSA source
- Overall
- Not rated
- Frontal
- Not rated
- Side
- Not rated
- Rollover
- Not rated
Fuel economy by trim
| Trim | Engine | Drivetrain | Transmission | City | Hwy | Combined |
|---|---|---|---|---|---|---|
| S80 FWD | 3.2L 6-cyl | Front-Wheel Drive | Automatic (S6) | 18 | 27 | 21 |
| S80 AWD | 3.0L 6-cyl | All-Wheel Drive | Automatic (S6) | 16 | 24 | 19 |
| S80 AWD | 4.4L 8-cyl | All-Wheel Drive | Automatic (S6) | 15 | 22 | 18 |
EPA laboratory estimates by trim and engine. Actual mileage varies with driving, weather, load, and maintenance. EPA source.
Before you buy
Useful next checks
Federal records tell you about patterns. These checks can tell you more about the specific car in front of you.
These are affiliate links. TireKick may earn a fee if you use one.
Compare model years
"Fewest reports" and "most complained" describe raw NHTSA complaint totals, not vehicle reliability. The last few model years are left unlabelled because they have had less road time.
2010 Volvo S80: frequently asked
What does the complaint record show for the 2010 Volvo S80?
Owners filed 27 NHTSA complaints about the 2010 Volvo S80 — fewer complaints than 75% of comparable 2010 sedans, so it sits toward the stronger end of its class. That's a signal, not a guarantee about any single car.
What are the most common problems on the 2010 Volvo S80?
The most-reported problem areas are Structure (15% of complaints) and visibility/wiper (15%).
How many recalls does the 2010 Volvo S80 have?
5 recalls have been issued that affect the 2010 Volvo S80, covering components such as equipment. Check the VIN with NHTSA and ask a dealer to confirm remedy eligibility; federal no-charge requirements have an age limit, though manufacturers may offer more coverage.
What gas mileage does the 2010 Volvo S80 get?
The EPA rates the 2010 Volvo S80 between 18 and 21 mpg combined, depending on trim and drivetrain.