Verdict
2011 Volvo S60: Complaints, Recalls & Known Issues
What the public record actually says about the 2011 Volvo S60 — every figure below is a NHTSA or EPA number, not an opinion.
The read
Fewer reported complaints than most sedan.
Owners filed 5 NHTSA complaints — fewer complaints than 91% of 2011 sedans. Engine And Engine Cooling leads the reports (20%). 6 safety recall campaigns on record — check the VIN and remedy terms with a dealer.
Based on NHTSA complaint volume against 2011 sedans, not adjusted for how many were sold. It describes the model year, not the individual car you are looking at.
Complaints filed
5
Reports to NHTSA, 2011
Safety recalls
6
NHTSA campaigns on record
NHTSA crash test
Not rated
Overall NCAP rating
Combined MPG
21
EPA estimate
Complaint volume vs. segment peers
Fewer complaints than 91% of 2011 sedans
The bar is this car's percentile among 2011 sedans by complaint volume — a full bar means the fewest complaints in its class. Not adjusted for sales.
Known issues
Engine And Engine Cooling issues lead owner complaints (20% of 5 reports), followed by steering (20%).
Share of all 5 NHTSA complaints for this model year, grouped by the component owners named. Bars are scaled to the largest category. Examples: ODI 10399515.
Recalls(6)
Open a recall to read what NHTSA says is wrong, what can happen, and how it gets fixed. Check the VIN and remedy eligibility with a dealer; federal no-charge requirements have an age limit, though a manufacturer may offer more coverage.
Engine And Engine Cooling · 10V579000Details +Close −
VOLVO IS RECALLING CERTAIN MODEL YEAR 2011, S80, S60, XC70 AND XC60 VEHICLES. THE SOFTWARE CALIBRATION FOR THE FUEL CUT-OFF FUNCTIONALITY IN THE ENGINE CONTROL MODULE (ECM) IS TOO SENSITIVE.
Risk: SUDDEN ENGINE STALL COULD OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL UPDATE THE ECM AND TCM WITH NEW SOFTWARE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE DECEMBER 10, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR AT CUSTOMERCARE@VOLVOFORLIFE.COM.
Seats · 10V591000Details +Close −
VOLVO IS RECALLING CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER FRONT PASSENGER SEATS. THE FRONT SEAT RAIL'S DETECTION SYSTEM WAS MANUFACTURED INCORRECTLY AND MAY PERMIT THE PASSENGER TO FORWARD THE SEAT BEYOND THE INTENDED MAXIMUM.
Risk: POSITIONING OF THE SEAT BEYOND THE INTENDED MAXIMUM CAN CAUSE INCREASED RISK OF INJURY TO THE PASSENGER IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE FRONT POWER SEAT STOPS FOR BOTH FRONT SEATS FOR THE PRESENCE OF AN "END STOP" AND REPAIR THE VEHICLES AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 23, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR AT CUSTOMERCARE@VOLVOFORLIFE.COM.
Equipment · 11V508000Details +Close −
VOLVO IS RECALLING CERTAIN MODEL YEAR 2006-2012 C70 VEHICLES MANUFACTURED FROM NOVEMBER 15, 2005, THROUGH JULY 31, 2011, AND MODEL YEAR 2011-2012 S60 VEHICLES MANUFACTURED FROM JULY 14, 2010, THROUGH APRIL 16, 2011, THAT WERE EQUIPPED WITH OPTIONAL ACCESSORY SPARE TIRE KIT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES DO NOT CONTAIN THE CORRECT INFORMATION FOR VEHICLES EQUIPPED WITH THE OPTIONAL ACCESSORY SPARE TIRE AND WHEEL KIT.
Risk: A MISPRINTED LABEL COULD LEAD TO IMPROPER TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy: VOLVO WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE VEHICLE AND INSTALL THE LABEL AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 23, 2012. OWNERS MAY CONTACT VOLVO AT 1-201-768-7300.
Engine And Engine Cooling · 13V592000Details +Close −
Volvo Cars of North America, LLC (Volvo) is recalling certain model year 2011-2012 S60 vehicles manufactured June 22, 2010, through May 14, 2012, and equipped with 5-cylinder B5254T5 (VIN code 62) engines. In the affected vehicles, the vehicle may not alert the driver of a low oil pressure situation.
Risk: Without being warned of a low oil pressure situation, the driver may continue to drive the vehicle until it stalls, which increases the risk of a crash.
Remedy: Volvo will notify owners, and dealers will update the vehicle's software so that the driver is alerted should there be a low oil pressure situation, free of charge. The recall began on January 10, 2014. Owners may contact Volvo at 1-800-458-1552. Volvo's number for this campaign is R29436.
Latches/Locks/Linkages · 19V849000Details +Close −
Volvo Car of USA LLC (Volvo) is recalling certain 2011-2017 S60, S60I, V60, S60CC and V60CC vehicles. A component within the door latches may break, making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
Risk: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
Remedy: Volvo will notify owners, and dealers will replace all four door latches, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89978.
Seat Belts · 20V378000Details +Close −
Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating positions may fatigue over time, causing the seat belt to not secure the occupant in the event of a crash.
Risk: An unsecured occupant has an increased risk of injury in the event of a crash.
Remedy: Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R10029.
A campaign can apply to this model year without being incomplete on a specific vehicle. Check the VIN with NHTSA or a dealer to confirm whether a particular car needs repair.
Investigations
0 NHTSA investigations on record
No investigations are on record as of Jul 2026. An empty record is not a clean bill of health.
Crash-test ratings
2011 Volvo S60 4 DR FWD NHTSA source
- Overall
- Not rated
- Frontal
- Not rated
- Side
- Not rated
- Rollover
- Not rated
Fuel economy by trim
| Trim | Engine | Drivetrain | Transmission | City | Hwy | Combined |
|---|---|---|---|---|---|---|
| S60 AWD | 3.0L 6-cyl | All-Wheel Drive | Automatic (S6) | 18 | 26 | 21 |
EPA laboratory estimates by trim and engine. Actual mileage varies with driving, weather, load, and maintenance. EPA source.
Before you buy
Useful next checks
Federal records tell you about patterns. These checks can tell you more about the specific car in front of you.
These are affiliate links. TireKick may earn a fee if you use one.
Compare model years
"Fewest reports" and "most complained" describe raw NHTSA complaint totals, not vehicle reliability. The last few model years are left unlabelled because they have had less road time.
2011 Volvo S60: frequently asked
What does the complaint record show for the 2011 Volvo S60?
Owners filed 5 NHTSA complaints about the 2011 Volvo S60 — fewer complaints than 91% of comparable 2011 sedans, so it sits toward the stronger end of its class. That's a signal, not a guarantee about any single car.
What are the most common problems on the 2011 Volvo S60?
The most-reported problem areas are Engine And Engine Cooling (20% of complaints) and steering (20%).
How many recalls does the 2011 Volvo S60 have?
6 recalls have been issued that affect the 2011 Volvo S60, covering components such as engine and engine cooling. Check the VIN with NHTSA and ask a dealer to confirm remedy eligibility; federal no-charge requirements have an age limit, though manufacturers may offer more coverage.
What gas mileage does the 2011 Volvo S60 get?
The EPA rates the 2011 Volvo S60 at 21 mpg combined.