2024 Lincoln Aviator

In addition to the recall for the C-pillar appliques and window division bars (NHTSA ID Number: 25V407000), the chrome trim piece directly below the window also suffers from insufficient adhesive bonding. See the photo below. It came lose while driving at high speeds.

Reported

Nov 2025

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

Problem: 2024 Lincoln Aviator has electronic door release switches on all four doors (both front and rear). If an emergency occurs and: •The driver’s door is blocked or jammed •Electrical systems fail (e.g., due to a crash, battery failure, fire, or water submersion) Then all four doors can simultaneously become inoperable, trapping all passengers besides the driver inside, as there is NO mechanical backup to manually release the front passenger door or both rear doors. This puts all the 2nd and 3rd row occupants and the front seat passenger in grave danger is access to the driver door is blocked or limited for any reason. ONLY THE DRIVER’s door has an emergency manual release latch. There is NO MANUAL RELEASE ON PASSENGER SIDE or for rear doors in this 3 row SUV. ⸻ ️ Why This Is Dangerous: •Passengers, especially in the rear seats, may be unable to exit the vehicle. •First responders may not be able to open the doors quickly. •This could lead to injury or death in fire, submersion, or crash scenarios.

Reported

May 2025

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

The headlight control switch emits high pitch noise.When you toggle the switch To go between the different Segments of the headlight switch. I've brought it to the dealer and the tech was able to determine where the noise Was coming from. I had advised them.I had disconnected the battery prior and made the noise go away.So that's what they did and now they say it's a non issue cause the noise went away. I have a video demonstrating the issue with the switch.I'm afraid of an issue of fire. It's been. To the dealership twice now, for this issue and it still has not been resolved.I've spoke to corporate Lincoln in regards to the issue.And it's supposed to be escalated.But i'm getting ghosted by everyone at this time. This issue started in the first week of my ownership.It was worse than that point in time.It was so bad.I was unable to drive the car because it was giving me such severe migraine headaches because of the pitch of the noise. The noise when present is very distracting when you are trying to operate the vehicle safely.

Reported

Oct 2024

Incident date

Jun 2024

Mileage

Not provided

Outcome flags

None reported

I took my new car through the car wash I notice water go in the car some how and I could hear this gargling I thought it was coming from the A pilar. I also notice this when it rainned would do the same thing. I took it in to the dealership and they told that it was the drain lines from the moon roof. two week later it rained again and took my car and could hear that same noise that water was in the car. I have called the dealership again to get back in so see what is causing this

Reported

Jul 2024

Incident date

Jun 2024

Mileage

Not provided

Outcome flags

None reported

The vehicle was already in for service once for this issue and is going back a second time the rear camera when backing up randomly starts to flicker and go crazy, and sometimes blanking out. The first fix replaced the camera to no avail. It seems to happen randomly, but about 50% of the time. I have video of the rear backup camera going crazy.

Reported

Apr 2024

Incident date

Apr 2024

Mileage

Not provided

Outcome flags

None reported

Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, Lincoln Corsair, 2020-2024 Lincoln Aviator, and Explorer vehicles. The image on the center display may flip or invert, resulting in an incorrectly displayed rearview image when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk: An incorrectly displayed rearview image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.

Remedy: Dealers will update the accessory protocol interface module (APIM) software, free of charge. Owner notification letters were mailed June 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C11. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.

Ford Motor Company (Ford) is recalling certain 2024-2026 Explorer and 2024-2026 Lincoln Aviator vehicles. The trailer hitch assembly bolts may be loose.

Risk: While towing a trailer, loose trailer hitch bolts can cause a loss of vehicle handling and control, or cause the trailer to detach. Either of these conditions can increase the risk of a crash.

Remedy: Dealers will inspect and tighten the trailer hitch bolts, or replace them as necessary, free of charge. Owner notification letters were mailed October 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA3. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.

Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

Ford Motor Company (Ford) is recalling certain 2020-2024 Lincoln Aviator vehicles. The accessory protocol image module (APIM) can be affected by electromagnetic interference with a cell phone in the vehicle, causing the rearview camera image to flicker or become distorted.

Risk: A flickering or distorted rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.

Remedy: Owners are advised not to use their cell phones while reversing until the remedy is completed. Dealers will install shielding on the accessory protocol image module (APIM), free of charge. Owner notification letters were mailed on October 23, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S35.

Ford Motor Company (Ford) is recalling certain 2020-2025 Aviator, and Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, folding, or sliding unexpectedly while driving.

Risk: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing their risk of injury.

Remedy: Dealers will inspect the second-row seat switch, and replace the bezel around the switch as necessary, free of charge. Owner notification letters were mailed August 7, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S67.

Ford Motor Company (Ford) is recalling certain 2020-2025 Aviator vehicles. The rear door window bars and C-pillar trim may have insufficient adhesive bonding, which can allow the trim to detach from the vehicle.

Risk: Detached trim may cause a road hazard and increase the risk of a crash.

Remedy: Dealers will repair or replace C-pillar appliques and window division bars, free of charge. Owner notification letters were mailed September 29, 2025. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 25S66.

Ford Motor Company (Ford) is recalling certain 2020-2026 Explorer and Lincoln Aviator vehicles. The seat belt anchor bolts at the second-row outer seating positions may be improperly secured.

Risk: A loose seat belt buckle may not properly restrain an occupant during a crash, increasing the risk of injury.

Remedy: Dealers will inspect the second-row outer seat belt lower anchor bolts and replace or repair them as necessary, free of charge. Owner notification letters were mailed March 30, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C18. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 19, 2026.

Ford Motor Company (Ford) is recalling certain 2020-2027 Aviator and 2020-2026 Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, tipping, or sliding unexpectedly.

Risk: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing the risk of injury.

Remedy: Dealers will inspect and replace the bezel around the switch as necessary, free of charge. Interim letters explaining the safety risk are expected to be mailed July 27, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S52. This recall expands Recall 25V393. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.