2024 Kia EV6

Car was totally dead even with a 68% charge. AAA came out to jump start. The next day while driving on the highway the car started to lose power. A red warning to check the electrical system came on along with "turtle mode". I was able to pull over off the highway, grateful the two small children were not with me. Car was towed to dealer who kept it for the three days. Only after repeated calling could I reach someone who said they couldn't reproduce the problem. I'm afraid to drive the car at this point as I feel it's just unsafe to do so. This seems to be an ongoing issue that Kia can't seem to fix.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

Rear tires on my 2024 Kia EV6 wore down to the tire wear-bar limit (2/32" remaining tread) at approximately 19,500 miles, while the front tires on the same vehicle measured roughly double that remaining tread (4/32") at the same odometer reading. The factory-installed tires are rated by the manufacturer for approximately 50,000 miles of tread life under normal use, so reaching the wear-out point on the rear tires alone at roughly 39% of that rated mileage is well outside expected wear for this vehicle at this mileage. This is not an isolated event: numerous other EV6 owners have independently reported the same front-to-rear wear disparity and premature rear tire wear online, across different driving styles and regions, which points to a vehicle characteristic (front/rear torque split, alignment or camber specification, or suspension geometry) rather than individual driver behavior. Uneven, accelerated rear tire wear reduces traction and increases stopping distance, and raises the risk of hydroplaning, tread separation, or blowout, particularly in wet weather, since the rear tires lose effective grip well before the front tires or before a typical maintenance interval would flag it. The wear was confirmed and documented, including tread-depth measurements at all four corners, by an independent third-party vehicle condition inspection performed at lease return. There were no dashboard warning lights or driver-facing alerts indicating the wear; it was only discovered through physical tread-depth measurement at that inspection. The tires inspection results are available upon request. This appears to reflect a design or specification issue affecting the vehicle's rear tires disproportionately, rather than a manufacturing defect isolated to one tire.

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

We purchased a certified pre-owned 2024 Kia EV6 GT on 6/5/2026. On 6/6/2026 while driving on city streets, the display screen suddenly displayed a large and flashing red warning message "Stop vehicle and check power supply" in addition to the battery symbol. We took the vehicle to the dealership and they diagnosed that the ICCU had failed and needed to be replaced.

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Component: ELECTRICAL SYSTEM:12V/LOW VOLTAGE BATTERY, PROPULSION system:Integrated Charging Control Unit (ICCU) Description: This vehicle previously had the mandated safety recall software update (Campaign SC327) applied by an authorized Kia dealership in December 2024 to protect the Integrated Charging Control Unit (ICCU). The corporate recall remedy failed. In January 2026, the vehicle suffered a sudden, catastrophic loss of motive power while driving on a public roadway due to a total ICCU failure, which created an immediate hazard for myself and my young child who was inside the vehicle. When the primary ICCU component failed, it starved the low-voltage system, causing severe deep-discharge damage to the 12V battery. Following the warranty repair of the ICCU in February 2026, the vehicle was returned to me. However, Kia's official corporate diagnostic and repair procedures for this defect are fundamentally flawed and incomplete; they do not mandate a comprehensive load-test or automatic replacement of the 12V battery following an ICCU collapse. Because of this failure in the official repair procedures, the vehicle was returned to service with a critically compromised low-voltage system. This directly resulted in recurring battery warning messages over the subsequent months, culminating on May 29, 2026, in a secondary, total 12V battery failure that completely bricked the vehicle. The failure of the manufacturer's official safety recall remedy and the subsequent inadequacy of their post-failure service protocol left this vehicle in a chronically un-roadworthy and unsafe condition.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The contact owned a 2024 Kia EV6 and stated that while driving at 40 MPH, an elk suddenly appeared in front of the vehicle, resulting in a head-on collision that completely crushed the front end of the vehicle with no air bags deployed. The front end of the vehicle was crushed including the windshield. The vehicle continued with the elk after collision dragging it a couple yards ahead. The air bags did not apply. No waring lights were illuminated. No police report was filed. The contact was the only passenger during the collision. The contact suffered a sever neck issue and is not able to move his neck to the right, has chest pain and shoulder pain on both sides, and a head injury. Medical treatment is need but has not gotten any due to insurance issues. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 20,000.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

Crash 1 injuries

Does not ac charge and no codes present

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

I had an ICCU failure on 4/12/26. I was fortunate enough to be close to home, so I was able to get back home before the vehicle dropped into reduced power mode. As has been reported many other places, I heard a loud pop and moments later a number or warning messages came up on the display. It was towed to the dealer the following day and has been confirmed to be an ICCU failure.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

2024 Kia EV6 leased January 2025. Vehicle is subject to NHTSA Recall 24V-867 / Kia campaign SC327 for the Integrated Charging Control Unit (ICCU). The recall remedy was performed at an authorized Kia dealer in July 2025 (software / operational logic update). The defect was not cured. Three months after the recall remedy was performed, the vehicle suffered complete loss of electrical power and would not move. It was towed to the Kia dealer. The dealer's own diagnostic recorded code P1A9096 — the exact diagnostic code Kia's recall instructs technicians to check for — and replaced the ICCU and high-voltage fuse. This is the recall-defined failure occurring AFTER the recall remedy was applied. Approximately three months later, the vehicle again suffered total loss of power and would not start in cold weather. It was towed in. The dealer replaced only the 12-volt battery and did not address the ICCU, despite the documented prior ICCU failure on this VIN. The 12V battery failure is a known downstream symptom of ICCU failure on this platform. Approximately one month after that, the vehicle returned for charging system failure ("vehicle charges briefly then stops") and a "check electrical/hybrid system" warning that appeared while driving. Diagnosed as charging port failure. Vehicle was out of service approximately 27 consecutive days. Total cumulative days out of service across four visits: approximately 35-40. Two safety-related stranding incidents resulted from these failures. Both occurred in winter conditions in Pennsylvania. In the first, the driver was stranded in a parking lot at night during a snowstorm in sub-zero conditions; three tow trucks were dispatched before a flatbed could recover the vehicle because the EV could not be towed conventionally with no power. In the second, the vehicle died in a school parking lot during a snowstorm; the first dispatched tow truck could not recover an EV with no power, and the driver had to walk multiple miles home in freezing

Reported

Apr 2026

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

Vehicle display showed a message stating 12 volt battery was low and to pull over immediately, the car the died in a parking lot. I called KIA roadside service and they connected a battery pack to the 12 volt battery and got the car started. This could have been a serious problem if I was on travelling on a public street or highway and suddenly lost power.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Listing as all 3. ICCU/fuse went out, car decelerated to 45 MPH max and flashed a warning to pull over. The bottom left battery indicator for the 12v battery also changed to red, indicating it was not regaining power from the main EV battery. Currently in shop hoping to get part in soon

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The vehicle’s ICCU unit stopped working out of the blue. This happened on a busy intersection and the car came to a sudden and violent halt. Luckily we were not involved in an accident. It’s a very well known issue with these vehicles and it’s really criminal that Kia has done nothing to fix it. They just change the ICCU unit and then it happens again.

Reported

Apr 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

I was backing out of my driveway and backed into a vehicle parked directly behind me. The collision avoidance and emergency braking system should have stopped my car before impact but it did not. No sounds other than the normal backing up beeping. Proximity alert did not ping. The vehicle is available for inspection upon request. The safety feature of collision avoidance and emergency breaking did not work. No, the problem has not been reproduced or confirmed by a dealer or independent service center. No, the vehicle component has not been inspected by the manufacturer, police, insurance representative or other. The police were called to the scene, they just looked at the damage on both vehicles. No warning lamps, messages or other symptoms of the problem prior to the failure. They only appeared once on the day of the accident. I can confirm the backup collision avoidance worked after the incident since the emergency breaking stopped my car in a parking lot after the incident of the failure.

Reported

Apr 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

Crash

Went to charge my vehicle in my garage on 4/15/26. When it was fully charged, I reached to disconnect the charger from the vehicle and the connector was hot to the touch; the charging hub on the vehicle was also hot, the charger had a slight plastic burning smell. I immediately tried to contact the company and learned that they had unbeknownst to me, ceased conducting operations in the US. So I ordered a new charger. I also tried it again on 4/17/26; and the heat was higher faster than it was on 4/15/26; so I hav disconnected the device and installed a new one. The electrician noted that the breaker was damaged and had to be replaced. I also recall, that a few months after the initial install of the charger, there was an incident where my wife saw sparks in the garage from the breaker and we heard a large pop; and then the charger went out. The company sent us a new one then that worked fine for a few years.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Issue was diagnosed as ICCU failure.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Known ICCU issue by manufacturer. While driving get alert on screen the check electrical system. Had to pull over and call tow truck for safety reasons. Charging system is not working properly and 12v battery can die at anytime.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

I had just finished charging the vehicle overnight on a Level 2 charger at a family members home. After leaving the driveway and driving a few hundred feet, an error message showed on the vehicle screen saying "Check Electric Vehicle" system, and then later a second message that said to stop the vehicle. I immediately turned the car around parked it in the driveway again and called roadside assistance to have it towed to the Kia service center. The Kia service center confirmed that it was an ICCU (integrated charging control unit) failure, which they replaced 4-5 days later after ordering the part. These error messages were the first and only indicator of the problem, there were no smaller issues leading up to the issue. Because the failure happened within a block of a family member's home, I was able to get to safety. But it could have been a completely different situation had the failure occurred even a few minutes later when I was on the freeway.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Was backing out of a parking lot space when a loud popping sound was heard from the right rear portion of the car. Shortly after a check electrical system message was displayed and to pull over. Then eventually had a power limited message pop up after 12V battery charging status/condition was checked by roadside service. Would turn out to be the ICCU (Integrated Charging Control Unit) after dealership nearby (Peak Kia) was able to diagnose the problem. Unknown if the failed part is available for inspection. I wouldn't say my safety or others safety was put at immediate risk, but could have been since the car did eventually completely shut down right as I was able to get home only about 1-2 miles away. Vehicle was seen by dealership a few days later and as far as I'm aware are the only entity to do an inspection on the vehicle. No prior warning of any kind before the ICCU failed, and car had complied with all recalls that were supposed to prevent or at least reduce chances of ICCU issues.

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

Driving car and then all of the sudden a critical battery alarm appeared and I lost the ability to go above 23 mph. It ended up being the ICCU that needed to be replaced.

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

After starting the car, a message displayed on dashboard "Check Electrical System." I tried driving the car out of the garage and then a message displayed to the effect of "Stop the car and check battery." I called the dealer and they said to have the car towed to them. After having the car towed to the dealer, they ended up replacing the Integrated Charging Control System (ICCU) and fuse. The danger is that the failure of this ICCU part could cause immediate loss of power when driving. Luckily, that didn't happen to me since I was only creeping slowly out of my garage.

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

Was trying to drive EV. As soon as I pulled out of driveway it gave me a warning sign; to check electrical system/stop vehicle and check power supply. I couldn't drive car anywhere, had to get it towed to dealership. When tow truck arrived we couldn't turn car on, it had no power. Mind you, I had full charge on EV.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

* Per paperwork from the car dealer, the ICCU failed along with a 3way valve assembly and a fuse blew. * While driving, the car went into a limp mode greatly limiting its maximum speed. * I was afraid to continue driving it and had the car towed to the KIA dealership. * It took exactly a month for it to be repaired. * The dealership kept the failed parts. * No warning lamps until the failure occurred. * When the failure happened a warning message stated "Check electric vehicle system!" and a battery symbol turned red. *Since it was taking what seemed like a long time for repair, I contacted Kia-Customer-Care and they assigned case number 25902713.

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

I had just left my house and pulled onto a 5 lane road when the ICCU died. The car lost power while underway. This posed great danger as the vehicle became unable to safely navigate traffic and pull off to safety. Kia is well aware of this hardware problem, tried to fix it with software updates, and deflates the affected number of vehicles. To make matters worse, they tried to deny this was a recall because they claimed the recall was fixed via the software update. This affects every single Kia Hyundai and Genesis EV.

Reported

Mar 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

The ICCU on the car failed and blew a fuse. KIA had to replace ICCU and fuse under warranty

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The car on 3/5 blanked out on all screens. shut car off and then came back on, no warnings came up. The car on 3/7 came up with “Check Electric Vehicle System” reverted to page 1-46 of Manual and advised do not drive, tow to nearest dealership. We drove car 4 miles home and the car had next to no acceleration, extremely dangerous and people nearing to back end us. To try and charge vehicle response is "unsuccessful"

Reported

Mar 2026

Incident date

Mar 2025

Mileage

Not provided

Outcome flags

None reported

The Integrated Charging Control Unit (ICCU) of my KIA EV6 failed. When putting the car into reverse to leave my workplace, I heard a fuse pop and a notification appeared on dashboard screen saying "Check electric vehicle system". This is a known recall issue that I was aware could happen, and in which case the car will soon become completely inoperable, so I didn't risking driving further. I had it towed to the nearest KIA dealership, where they confirmed the ICCU had failed and replaced it at no charge under the warranty coverage. There were no warnings or symptoms prior to the failure. I was fortunate that it did not fail while I was driving.

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

I purchased this vehicle just over a year ago as a CPO model with only 8,000 miles on it. It now has just over 23,000 miles. In this short time of ownership, it has been back to the dealership 3 separate times for serious EV system issues. The first visit involved a software update intended to correct a 12-volt charging issue that could prevent the vehicle from charging and potentially cause ICCU failure. Shortly after that update, the 12-volt battery failed, despite being <18 months into service, completely bricking the vehicle and leaving me stranded waiting for a tow. The battery was replaced under warranty. Less than 2 months later, while >30 miles from home, the vehicle displayed a “Check Electrical System Failure” warning. I was able to limp-mode the car back to the dealership. I am now being told that the main EV battery has failed and must be replaced, possibly also the ICCU. The dealership cannot provide a firm timeline for repairs; parts availability could mean anywhere from 2 weeks to 4 months without the vehicle. This pattern of failures raises serious concerns about the reliability and safety of the EV6. Repeated electrical system issues create a very real risk of being stranded unexpectedly, potentially in unsafe situations such as on the side of a highway. To date, I have already lost four days of use due to service repairs, and I now face being without the vehicle for an extended and uncertain period. While a loaner vehicle is being provided, I will incur fuel expenses at a time of rising gas prices, undermining the financial rationale for purchasing an EV. Meanwhile, I continue making payments on a vehicle I cannot use, which is depreciating in value. I understand that new technology carries some risk. However, despite prior updates and even a model refresh, the ICCU issue appears unresolved, and Kia does not seem to have a clear root cause identified. For a vehicle marketed on innovation and dependability, this experience has indicated otherwise.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The driver (my wife) was operating the Kia EV6 (with approximately 10,000 miles) when the vehicle suddenly experienced a severe loss of motive power. While driving, a warning message appeared on the dashboard indicating an issue with the power supply. Immediately after, the vehicle forced itself into "turtle mode," severely restricting the maximum speed to 20 mph and refusing to accelerate further. This sudden, unexpected deceleration on an active roadway put the driver at a significant risk of a rear-end collision. The driver managed to slowly navigate the vehicle back to our residence at a maximum speed of 20 mph, which was extremely hazardous. Shortly after safely parking at the residence, the vehicle experienced a complete electrical failure. It would no longer start, could not be shifted into neutral, and ultimately had to be dragged onto a flatbed tow truck by roadside assistance because the wheels were locked. The vehicle was towed to an authorized Kia dealership, where it is currently undergoing diagnosis and inspection for what is heavily suspected to be a total failure of the Integrated Charging Control Unit (ICCU) and 12-volt battery system. The vehicle and the failed components are currently at the dealership and are available for inspection upon request. Note: This catastrophic power loss occurred just weeks after the vehicle was in the shop for nearly a month to have its entire high-voltage battery pack replaced due to severe range degradation, marking the second major electrical system failure on this vehicle.

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The vehicle had an electric supply failure, suggesting a failed ICCU. This left me stranded and requiring a tow. The issue is not uncommon in this vehicle but there is no recall. Kia and Hyundai need to get this right rather than keep repairing these when they adhoc fail.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

Vehicle Information: 2024 Kia EV6 (VIN: [XXX] ) Mileage at time of failure: 14,005 Complaint Description: My 2024 Kia EV6 experienced a complete failure of the 12-volt battery system despite the high-voltage traction battery showing approximately 80% state of charge. The vehicle became completely inoperable without warning. The 12-volt battery was fully discharged and the vehicle would not enter READY mode. The vehicle required a jump start to become operational. After being jump started, the 12-volt system did not appear to charge properly, suggesting a failure of the Integrated Charging Control Unit (ICCU), which is responsible for converting high-voltage battery power to maintain the 12-volt battery. This failure created a significant safety concern because: The vehicle became completely disabled without warning. This failure occurred while driving in heavy traffic, it created a hazardous situation. The vehicle’s electrical systems, including safety systems, depend on the 12-volt battery. There are known reports of ICCU failures in Kia and Hyundai electric vehicles that result in identical symptoms (sudden 12-volt battery discharge despite adequate traction battery charge). This suggests a potential systemic defect rather than normal battery wear. I am filing this complaint due to concern that this issue represents a broader safety defect affecting multiple vehicles and may require investigation or expanded recall action. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The ICCU failed while I was driving my car on a 50 mph road. Check electrical system warning lights appeared. Maximum speed was reduced to 19mph and my car became a road hazard for other cars on the road. I managed to pull off the road once I found a safe spot. After visiting the Kia dealership, the problem was confirmed as a failed ICCU (Integrated Charging and Control Unit) and replaced under warranty. No problems appeared prior to the failure. Vehicle was required to be towed to the repair facility.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

ICCU FAILURE. COMMON ISSUE REPORTED WITH EV6s 2022-2025.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The Integrated Charging Control Unit (ICCU) and High Voltage Fuse failed twice within 100 miles, causing a total loss of motive power while driving. The first failure occurred on Jan 24, 2026 (13,954 miles), and the second on Feb 2, 2026 (approx. 14,000 miles), immediately after the first repair attempt. In both instances, the 12V charging system failed, severing connection to the high-voltage battery and forcing the vehicle into a "limp mode" with reduced speed and steering loss in active traffic, creating a severe collision risk. ​The first authorized manufacturer technician stated that the issue was with the 12v battery and not the ICCU, however the second dealership confirmed that the issue was the ICCU all along, resulting in 17 days out of service. Symptoms included a loud "pop" followed by "Check Electric Vehicle System," "Stop Vehicle and Check Power Supply," and 12V battery warnings. Despite Recall SC327/SC302 procedures, the safety defect persists.

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

2024 EV6 GT-Line with 13,165 miles suddenly showed multiple faults, including "Check electric vehicle system” followed shortly by "Stop vehicle and check power supply". The vehicle almost immediately stopped in the roadway, and my wife (driver) was unable to move the vehicle or even put the vehicle in neutral so the vehicle could be moved. The car is at a Kia dealership for repair who confirmed an ICCU failure. This is an exceptionally dangerous situation.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

While operating my 2024 Kia EV6, the vehicle began displaying repeated warnings related to the power system and 12-volt battery. The instrument cluster first showed a “Power limited” message, followed shortly by a “Stop vehicle and check power supply” warning. At the same time, the vehicle indicated that the 12-volt battery was low, despite the high-voltage traction battery being at or near full charge. Shortly thereafter, the 12-volt battery became fully depleted, resulting in a complete loss of low-voltage electrical power. I was unable to electronically unlock the doors, and the vehicle could not be started or shifted into gear. The vehicle became immobilized and inoperable, requiring towing. This failure occurred without warning and created a safety concern, as loss of power could potentially occur while driving or leave occupants stranded and unable to access the vehicle. The vehicle had previously been serviced at a Kia dealership for known power system concerns related to the Integrated Charging Control Unit (ICCU). During that visit, the dealership applied a firmware update only and did not replace the ICCU hardware. The current failure occurred after that firmware update, suggesting the issue was not resolved. This incident represents a loss of motive power and loss of vehicle electrical systems, which could present a serious safety risk if it occurs while the vehicle is in motion or in unsafe environments. The inability to unlock doors or start the vehicle due to complete 12-volt battery depletion is particularly concerning. When roadside assistance arrived to tow the vehicle to the dealership, the vehicle’s 12-volt battery was completely depleted, preventing normal recovery procedures. A portable jump starter was temporarily connected, but the vehicle would not remain powered on long enough to complete the steps required to place the vehicle into neutral or tow mode.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

ICCU failure

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

on April 7, 2025, our 2024 Kia EV6 was towed away from our driveway after an ICCU failure the day before. The tow truck driver attempted to jumpstart it with a battery eliminator and he could not. He could not get it shifted into neutral and had to pull it up on the ramp with the back tires stationary, sliding up the ramp. They had it until we got it back just before April 22, and then on that day, it was towed away again because of a 12 V battery failure. If this first computer failure had happened while we were on the highway, we would have lost power in traffic. We were told that the replacement ICCU part which we received was a different model number than the first one, but I have heard on Facebook discussion groups that it is identical and just as likely to have a failure. Our Kia EV6 is a 2024 model, an extended battery version Wind AWD. Both the initial incident on April 6 and the second incident on April 21 happened just outside my garage after just backing the car out of the garage going maybe 5 mph. For some reason, the system will not let me upload a video of the first time it was towed up the ramp, only the second time when it was taken away for the 12 V battery failure, but it also would not drive in that condition. I include parts of texts with the Kia service center. It took them one week to be convinced that it was, indeed, the ICCU.

Reported

Feb 2026

Incident date

Apr 2025

Mileage

Not provided

Outcome flags

None reported

The car his a module called the iccu that regulates the high voltage battery, battery range goes down, the iccu has been replaced with the vehicle only having 8k miles on the odometer

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Incident took place 1/31/26. I was pulling into my driveway at approximately 5 mph. Normally, as I approach the wooden driveway gate, sensors would begin to beep and I would be prompted to stop.The car normally would stop itself if a collision was imminent. This did not take place. Instead, the car picked up speed, smashed through the gate proceeded up the driveway, smashed through the garage door and the rear wall of the garage. I was alone and uninjured, but the structure was yellow tagged and there was severe damage to the contents. Airbags were not deployed. The car was towed to Caliber body shop in Santa Monica for repairs to the body. When this has been completed it will be taken to Kia of Santa Monica for analysis of the black box and braking system.

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

Crash

Driving with my wife and [XXX] child, there was a pop sound from under the car, and the car suddenly showed multiple faults, including "Check electric vehicle system”, which cleared on their own. I parked and turned the car off and on again and the faults reappeared. I started driving home, and during the drive it showed "Stop vehicle and check power supply" and audibly alarmed. As I was only half a mile from my house on local quiet roads, I made it. A few minutes later, I tried to turn on the car and some displays were off, there was no drive power, the steering wheel did not turn, the door locks were flakey, and I wasn't able to tell if I had shifted into Park or if the parking brake was engaged. When the tow truck arrived, the car was completely unresponsive and there was no way to release the parking brake or shift the car in neutral, so the car was dragged across the pavement and onto the tow truck. The failure was quick and comprehensive and could have easily caused injury. There are many highways near me with fast, busy traffic and either no emergency shoulder or a very narrow one. If my car tells me that I need to stop the vehicle, that can create a very dangerous choice between stopping somewhere less safe quickly or risking the car being completely disabled while in the travel lane while I look for a safer spot. Loss of cabin heat can easily become dangerous very quickly in the winter. Many drivers may not even understand the urgency of the warning until the car starts failing to drive. The car is at a Kia dealership for repair who confirmed an ICCU failure. See related NHTSA recall no 24V-867 and others. ICCU failures are endemic to Kia and Hyundai EVs. ICCU failures are widely discussed on many internet forums and seem much more common than the 1% failure rate claimed by Hyundai/Kia. FYI, an interesting root cause analysis was shared on a German EV forum: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

Vehicle ICCU blew up while driving, causing drive train system shut down and limited speed to 10 mph.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

About 10 miles from home a warning saying to check the electrical system came on the dash and the car would not go faster than about 25 miles per hour. We had to limp back home, turning the car off every few miles as it would start aggressively beeping to turn off the car. After getting it towed to the dealership, it took them several weeks to determine it was the ICCU and fuse, and I did not take possession of my car back for nearly 8 weeks. While this was under warranty, I am still currently waiting for reimbursement on the tow to the dealer and the rental I had to get for 3 days before the dealer could get me a loaner.

Reported

Jan 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Whike driving down the street, the car lost power despite being charged to 95%. An alert went off on screen stating an electric system issue and then stopped in the middle of the road. Between the warning showing up, and car losing full power was less than a minute. There was no opportunity to pull over safely and the car was stuck in the middle of the street until a tow truck was able to come. Police had to direct traffic as it was blocking the only lane on a busy street.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

The engine/power of my electric EV6 died. It went into limp home mode (speed limited) briefly before dying completely. I restarted it and was able to get it to a parking spot before it died again, but I was just lucky I was on a surface street with parking. Dealership confirmed it was an ICCU failure

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

ICCU failure while driving. Vehicle defaulted into limp-home mode and required towing to a dealership once it fully died. The issue was confirmed to be the ICCU and the part was replaced.

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Right front tire failed while driving on interstate highway. Sidewall blowout. The tire is available for inspection. Stability of car compromised could have caused an accident. The problem has not been reproduced. The tire was seen by a state trooper and inspected by Les Schwab tire dealer. There were no warning signs.

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

I have a 2024 Kia EV6 I took my car in for an unrelated repair. Tech found an airbag code that I asked to be investigated. The airbag wiring harness was damaged and needed replacement. The repair was quoted as $6600. The dealer claimed that this was from rodent damage but the photo evidence does not look like rodent damage. It looks like the wire was pulled out of the harness. Of note, the 2024 Kia Niro and 2024 Kia Telluride have similar active recalls. Please see NHTSA Recalls 25V-024 and 23V-035.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Car suddenly slowed from 55 mph to 25 mph because of issues with the 12v battery and the ICCU system. The car is only 1 year old. From looking online, this seems to be a fairly common issue/problem. The dealer is working on it now, but it seems likely that this issue will happen again. If it happens on a freeway, certainly a safety concern.

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Heard a pop, followed by power failure and warning lights to stop operating the vehicle. The ICCU unit had blown.

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Kia has a known ICCU issue with several of their electric vehicles. Mine went out yesterday creating an extremely dangerous situation on the road. After it blew, I lost the ability to accelerate or steer. This was obviously very scary for me and the drivers around me. I feel very lucky to have not been hit by another car. Although Kia is replacing these, this does not guarantee a fix. That is to say, the ICCU has the potential to blow again after replaced because the core issue is not something that Kia group has reengineered. I should not have to fear getting into my vehicle and wonder if it will blow again. I hope the government steps in and conducts an investigation into this. It’s only a matter of time before someone, unfortunately, will lose a life over this.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

ICCU failed. Heard a popping sound from rear of passenger compartment, dash errors lit up, car went to limp mode

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 and 2024 EV9 vehicles. The high voltage battery cells may contain misaligned electrodes, which can lead to a fire while parked or driving.

Risk: A fire increases the risk of injury.

Remedy: Owners are advised to park outside and away from structures and limit their charge to a maximum of 80% until the recall repair is complete. Dealers will replace the high voltage battery system assembly, free of charge. Owner notification letters are expected to be mailed August 7, 2026. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC375. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning July 17, 2026.

Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.

Risk: A loss of drive power increases the risk of a crash.

Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters are expected to be mailed April 29, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC302.

Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.

Risk: A loss of drive power increases the risk of a crash.

Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 13, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC327. This recall expands and replaces previous recall number 24V-200. Vehicles previously repaired under recall 24V-200 will need to have the new remedy completed.