Verdict
2016 GMC Savana: Complaints, Recalls & Known Issues
What the public record actually says about the 2016 GMC Savana — every figure below is a NHTSA or EPA number, not an opinion.
The read
Not enough federal data to rank this one yet.
Complaint data for this model year is still being compiled. Steering leads the reports (50%). 7 safety recall campaigns on record — check the VIN and remedy terms with a dealer.
Based on NHTSA complaint volume against 2016 vans, not adjusted for how many were sold. It describes the model year, not the individual car you are looking at.
Complaints filed
6
Reports to NHTSA, 2016
Safety recalls
7
NHTSA campaigns on record
NHTSA crash test
Not rated
Overall NCAP rating
Combined MPG
12.5
EPA estimate
Complaint volume vs. segment peers
Peer ranking not yet available for this model year.
Known issues
Steering issues lead owner complaints (50% of 6 reports), followed by electrical system (17%).
Share of all 6 NHTSA complaints for this model year, grouped by the component owners named. Bars are scaled to the largest category. Examples: ODI 11408196, ODI 11365198, ODI 11219707.
Recalls(7)
Open a recall to read what NHTSA says is wrong, what can happen, and how it gets fixed. Check the VIN and remedy eligibility with a dealer; federal no-charge requirements have an age limit, though a manufacturer may offer more coverage.
Electrical SystemJun 2023 · 23V247000Details +Close −
General Motors, LLC (GM) is recalling certain 2003-2023 Chevrolet Express Cutaway and GMC Savana Cutaway incomplete vehicles equipped with wiring for an optional rear heating, ventilation, and air-conditioning (HVAC) system. When the HVAC blower motor circuit is left unused with exposed connectors and wiring, the circuit can corrode and overheat.
Risk: An overheated electrical circuit increases the risk of a fire.
Remedy: Dealers will properly seal the rear HVAC blower motor circuits at the left side B-pillar, free of charge. Owner notification letters were mailed May 2, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GMC's number for this recall is N222386050.
VisibilityMar 2018 · 18V295000Details +Close −
General Motors LLC (GM) is recalling certain 2014-2017 Chevrolet Express and GMC Savana vehicles equipped with power windows. Liquid may leak into the driver's power window switch and cause corrosion, resulting in high electrical resistance.
Risk: High electrical resistance can increase the risk of a fire.
Remedy: GM will notify owners, and dealers will replace the driver side window switch, free of charge. The recall began August 10, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 18155.
TiresJan 2016 · 16V184000Details +Close −
General Motors LLC (GM) is recalling certain model year 2014-2016 Chevrolet Express and GMC Savana incomplete vehicles equipped with a 159 inch wheel base manufactured August 2, 2013, to January 30, 2016. The affected vehicles were shipped to final stage manufacturers without a tire pressure monitoring system (TPMS). As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."
Risk: Without a TPMS, the driver would not be alerted if one or more tires became under inflated. Driving with under inflated tires increases the risk of a crash.
Remedy: GM will notify owners, and dealers will install the hardware and software necessary to equip the vehicles with a TPMS, free of charge. The recall began on May 25, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 15819.
Visibility · 16V700000Details +Close −
General Motors LLC (GM) is recalling certain model year 2016-2017 Chevrolet Express manufactured September 25, 2015, to August 22, 2016, and 2016 GMC Savana cargo and cutaway vans manufactured January 28, 2016, to May 18, 2016. The affected vehicles were manufactured without an inside rearview mirror and with a right-hand convex exterior review mirror. These vehicles are required to have either an inside rearview mirror or both left and right-hand flat exterior rearview mirrors. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Risk: If the driver does not have a clear unobstructed view to the back of the vehicle, it can increase the risk of a crash.
Remedy: GM will notify owners, and dealers will instal a right-hand flat rearview mirror, free of charge. The recall began on November 8, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16036.
Equipment · 18V267000Details +Close −
General Motors LLC (GM) is recalling certain 2009-2014 Chevrolet Silverado HD and GMC Sierra HD, 2009 GMC Topkick 5000, 6000, 7000 and 8000 Series and Isuzu F Series, and 2009-2018 Chevrolet Express, and GMC Savana vehicles, equipped with certain Plastic-Handle Fire Extinguishers or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Risk: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Remedy: GM will notify owners, instructing them to contact Kidde to get a replacement fire extinguisher, free of charge. The recall began June 11, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Isuzu customer service at 1-866-441-9638. GM's number for this recall is 18146.
Electrical System · 18V655000Details +Close −
General Motors LLC (GM) is recalling certain 2016-2018 Chevrolet Express and GMC Sierra vehicles equipped with a single, manual, rear climate control module (CCM). If the temperature is set to maximum heat or the mode knob is set to maximum floor vent and an electrical short occurs, components within the CCM may overheat.
Risk: If the CCM overheats, there is an increased risk of a fire in the vehicle's headliner.
Remedy: GM will notify owners, and dealers will remove the electrical insulation from a wiring connector within the CCM to remove the fire risk, free of charge. The recall began November 6, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 18299.
Visibility · 19V387000Details +Close −
General Motors LLC (GM) is recalling certain 2016-2019 Chevrolet Express and GMC Savana vehicles. One or both of the rear-quarter windows may be tempered glass instead of laminated glass. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 226, "Ejection Mitigation."
Risk: Tempered glass increases the risk of injury in the event of a side impact or rollover crash.
Remedy: GM will notify owners, and dealers will replace the tempered glass windows with laminated glass windows, as necessary, free of charge. The recall began July 5, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this recall is N192218960.
A campaign can apply to this model year without being incomplete on a specific vehicle. Check the VIN with NHTSA or a dealer to confirm whether a particular car needs repair.
Investigations
1 NHTSA investigation on record
Investigations are agency reviews, not findings that a vehicle is defective.
The Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE) after receiving one Vehicle Owner Questionnaire (VOQ) complaint related to four school buses built on General Motors (GM) van chassis. The VOQ alleged transmission failure resulting in a loss of all forward gear. In ODI's pre-investigative discussions with GM, ODI learned that valve body separator plates had been machined out of tolerance during production periods between October 2016 to April 2017 and February 2021 to April 2021. This out of tolerance machining may create excessive wear to the valve body check balls, possibly resulting in an inability to engage drive or reverse. The potential loss of drivability only begins when shifting from a park or neutral transmission selection and does not occur during a functional drive cycle. The average failure mileage of vehicles which experienced this condition is within warranty and related claims or complaints did not include any accidents, injuries, or fatalities. After discussions with GM, Technical Service Bulletin (TSB) 23-NA-142 (NHTSA ID number 10243753) was released in September 2023. This technical service bulletin provides a procedure for technicians to replace the forward check ball and separator plate if found to be the cause of a customer's concern. During the course of the investigation, GM also released a Customer Satisfaction Program (CSP) N232428780 (NHTSA ID 10253316) in February 2024, to notify school bus and ambulance fleets of the concern and to proactively mitigate the risk in these essential-operation vehicles. Recently, ODI contacted multiple school bus fleets, verifying that there have not been any stranded buses mid-route from this condition. Additionally, ODI has not received any additional VOQ complaints since the opening of this investigation. Based on the available information, including GM's TSB and CSP, this PE is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI report cited in the Closing Resume ODI Report Identification Numbers document, go to NHTSA.gov.
Crash-test ratings
No NHTSA crash test is on record for this year. Some vehicles and model years were not tested or do not have a published NCAP result.
Fuel economy by trim
| Trim | Engine | Drivetrain | Transmission | City | Hwy | Combined |
|---|---|---|---|---|---|---|
| Savana 2500 2WD (Passenger) | 6.0L 8-cyl | Rear-Wheel Drive | Automatic 6-spd | 11 | 16 | 13 |
| Savana 3500 2WD (Passenger) | 6.0L 8-cyl | Rear-Wheel Drive | Automatic 6-spd | 11 | 16 | 12 |
EPA laboratory estimates by trim and engine. Actual mileage varies with driving, weather, load, and maintenance. EPA source.
Before you buy
Useful next checks
Federal records tell you about patterns. These checks can tell you more about the specific car in front of you.
These are affiliate links. TireKick may earn a fee if you use one.
Compare model years
"Fewest reports" and "most complained" describe raw NHTSA complaint totals, not vehicle reliability. The last few model years are left unlabelled because they have had less road time.
2016 GMC Savana: frequently asked
What does the complaint record show for the 2016 GMC Savana?
Owners filed 6 NHTSA complaints about the 2016 GMC Savana. Among the 15 model years of this Savana, that ranks #10 by complaint volume, where #1 has the fewest.
What are the most common problems on the 2016 GMC Savana?
The most-reported problem areas are Steering (50% of complaints) and electrical system (17%).
How many recalls does the 2016 GMC Savana have?
7 recalls have been issued that affect the 2016 GMC Savana, covering components such as electrical system. Check the VIN with NHTSA and ask a dealer to confirm remedy eligibility; federal no-charge requirements have an age limit, though manufacturers may offer more coverage.
What gas mileage does the 2016 GMC Savana get?
The EPA rates the 2016 GMC Savana between 12 and 13 mpg combined, depending on trim and drivetrain.