2021 Ford Bronco Sport

I was in another town and my car kept stalling. I was going across traffic and it stalled and almost caused an accident. When I was in a parking lot my car would not go in reverse. I had to be pushed out of the parking space. I have already went to the have this recall fixed once. I know the part is not available but I should not have to keep going every few months to keep getting this done on a vehicle that I am paying on. It is not reliable and I could have caused an accident.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Bronco Sport. The contact stated that the check engine warning light illuminated. There was an abnormal odor of exhaust fumes inside the vehicle. Initially, the driver thought it emerged from other vehicles; however, a passenger smelled exhaust fumes, became sick, and vomited once the driver pulled over. The Ford mobile app failed to display any failure codes. The contact related the failure to NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline). The vehicle was taken to a local dealer, where diagnostic trouble codes for the engine were cleared. The fuel vapor was purged, and the valve was replaced; however, the failure recurred. The vehicle was then taken to an independent mechanic shop, where it was diagnosed that the catalytic converter was fractured. The catalytic converter was replaced, and the fuel injector was serviced. The manufacturer was not contacted. The failure mileage was approximately 67,830.

Reported

Jul 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

Continuously when I am driving the vehicle, it will randomly loose acceleration and come to an almost complete stop when driving, including on major interstates.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The first incident was the car shifting to park while I was trying to reverse it said “system shift fault” I called ford they told me that since it wasnt coming back on I was okay to drive it hadn’t come back on so I didn’t get the diagnostic done due to not having a vehicle to use while it was being done. The second one I parked and again went to reverse and what popped up was “gear selected will engage at low speed” but as soon as I turned my car off and back on the vehicle was able to reverse and drive normally.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The vehicle was parked in my parking garage and rolled away causing a collision. There were no warning lights indicating an issue. The vehicle is currently sitting at a shop awaiting warranty paperwork for a transmission replacement that was done last year.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

Crash

The contact owns a 2021 Ford Bronco Sport. The contact stated that while reversing, the vehicle went forward. While in neutral, the vehicle moved forward. No warning lights were illuminated. The contact stated that the failure was associated with NHTSA Campaign Number: 26V236000 (Power Train), but the VIN was not included in the recall. The vehicle was towed to the local dealer, where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not repaired. The alternator had been replaced previously. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 125,000.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The vehicle failed to shift back into Drive after being placed in Park, rendering it inoperable. As a result, the vehicle had to be pushed out of a busy driveway and towed to a local repair shop. The local repair shop was unable to diagnose or repair the issue because the required diagnostic equipment is specific to Ford vehicles and was not available to them. The shop advised that the transmission may have failed. After researching the issue, transmission failure has been reported as a known concern affecting early-model Ford Bronco Sport vehicles. Because the local shop could not complete the repair, the vehicle had to be towed a second time to the nearest Ford dealership. The Ford dealership confirmed a transmission failure and determined that the transmission required replacement. The dealership replaced the transmission at a total cost of $10,971.48. At the time of failure, the vehicle had fewer than 75,000 miles on the odometer. Given the relatively low mileage and the significant cost of repair, a complete transmission failure under normal operating conditions raises serious concerns regarding the reliability and durability of this component. The Ford dealership's description of the diagnosis, repairs performed, and parts replaced is provided below. 7000: *TRANSMISSION REPAIRS TRANSMISSION DIAGNOSIS (NOT SHIFTING PROPERLY, LEAKS, OTHER) - C/S: TRANS SEEMS TO NO GO INTO GEARS, WAS AT ANOTHER SHOP WHO COULD NOT REPAIR, ADVISE ON NEEDED REPAIRS PLEASE WENT FOR TEST DRIVE - VERIFIED CONCERN. PULLED VEHICLE INTO SERVICE BAY. SCANNED CODES - FOUND P07E1 UNABLE TO ENGAGE NEUTRAL. CHECKED OIL LEVEL AND CONDITION - WAS FULL BUT HAD CLUTCH AND METAL DEBRIS PRESENT. RECOMMEND TRANS REPLACEMENT. APPROVED. PULLED VEHICLE BACK INTO SERVICE BAY. REMOVED AND REPLACED TRANSMISSION. FLUSHED COOLER. PROGRAM STRATEGY AND FILL FLUID PER WSM. PERFORMED ADAPTIVE DRIVE CYCLE. TEST DROVE TWICE AND TRANSMISSION SHIFTED WELL. PULLED TO BACK LOT.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

STILL NO REMEDY AND THIS HAS BEEN OVER A YEAR AGO!!! Jul 16,2025 Manufacturer Recall Number 25S76 NHTSA Recall Number 25V467 Recall Status Recall Incomplete, remedy not yet available Summary ON YOUR VEHICLE THERE IS A POSSIBILITY THAT A FUEL INJECTOR MAY CRACK, WHICH MAY RESULT IN FUEL ACCUMULATING ON THE TOP OF THE ENGINE. Safety Risk LIQUID FUEL ANDOR FUEL VAPOR THAT ACCUMULATES NEAR A HOT SURFACE, SUCH AS HOT ENGINE OR EXHAUST COMPONENTS MAY IGNITE RESULTING IN AN UNDER-HOOD FIRE, INCREASING THE RISK OF INJURY.

Reported

Jun 2026

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

The rearend is making a shuddering on tight turns . Vehicle only has 24,700 miles on it. Unknown if oil is low in differential oil or if vent hose is plugged. May be contaminated oil in differential.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

THIS PROBLEM CAUSES MY VEHICLE TO SPUTTER AND JERK WHEN TRAVELING. I brought it to the dealership and they said to bring it back when the recall was submitted. This is ridiculous. So many recalls on this vehicle

Reported

Jun 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The ford dealerships in Cullman and Decatur were unable to resolve my software recall and rear camera issue. They attempted 4 times

Reported

Jun 2026

Incident date

Apr 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Bronco Sport. The contact stated that there was an abnormally loud grinding sound detected while driving, reversing, and turning the steering wheel. There was no warning light illuminated. The vehicle was taken to two independent mechanics, who related the failure to a recall. The mechanics referred the contact to the dealer. The contact referenced NHTSA Campaign Numbers: 21V011000 (Power Train), 21V074000 (Suspension) and 21V075000 (Suspension). The vehicle was taken to the local dealer, who confirmed there were no open recalls. The dealer diagnosed and determined that the rear clutch needed to be repaired. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 90,000.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

This vehicle has had the same recall for longer than a year now that Ford doesn't seem to have any kind of remedy for. They just keep "inspecting" and "reprogramming." How many fires need to happen under the hood of these vehicles before Ford is forced to either replace the fuel injectors or compensate their customers in some way? I drive around with kids in my car. Safety is not up for negotiation and this has taken far longer than it should have.

Reported

Jun 2026

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

Purchased a Ford Bronco Sport brand new in 2021. I received a recall notice for my bronco sport last July. I took my vehicle to the Ford dealership and they told me there was no remedy available. The recall states that my vehicle could catch on fire and crash at any time while I’m driving it. Ford still does not have a remedy almost a year later and they don’t know when they will have one. They don’t have parts even though my VIN number is affected. Ford expects me to risk my life and the life of my passengers, who happen to be my grandsons, by driving this vehicle on a daily basis. At any time, my car can catch on fire because of the fuel injector recall. I filed a claim with the Ford buyback program, but was denied because my vehicle warranty has expired. The recall didn’t even come out until after my warranty had expired. Recall info: Campaign 25S76/25V467

Reported

Jun 2026

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed on two separate occasions, the turbocharger became inoperable. The contact reported hearing a knocking sound coming from the engine at the time of the failures. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and advised the contact that the remedy was not available to complete the repair. The approximate failure mileage was 80,000.

Reported

Jun 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Bronco Sport. The contact stated that the daughter had reported that while in a parking lot, the brakes unintendedly engaged, and then the vehicle suddenly accelerated. The driver immediately applied the brakes to stop the vehicle. The contact was able to duplicate the failure while attempting to park the vehicle. The messages "Power Train Malfunction" and "Reduced Power" were displayed, the power train warning light illuminated, and the parking brake warning light flashed continuously. The vehicle was being towed to the dealer. The vehicle was not yet diagnosed or repaired. The manufacturer was informed of the failure. The failure mileage was 108,236.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Vehicle was sold to me with a bad transmission. Dealer is refusing to fix it or buyback the vehicle. There is a recall for potentially cracked fuel injector which poses a significant risk of fire under the hood, however it’s been almost a year and Ford still doesn’t have a fix for it.

Reported

Jun 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

Reported

Jun 2026

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

This recall has not been handled as of yet due to unavailable parts at it has almost been a year since it was issued on 7.16.2025.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

I have a running recall from 7/25 that states the fuel injectors can leak and should be replaced by Ford. This is the second attempt to fix the issue on the bronco sport engine. Ford says parts not available now for almost 12 months now.

Reported

Jun 2026

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V467000(Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

Reported

Jun 2026

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

Defective Purge Valve. From my research this is a major issue with the 2021 Ford Bronco Sport

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Water pump failure. From my research this is a major problem with the 2021 Ford Bronco Sport

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The front and rear brake system has repeatedly malfunctioned across at least 7 dealer visits since 2022 on my 2021 Ford Bronco Sport (VIN: [XXX] ). Brake squealing and grinding (particularly in reverse at low speeds) have persisted despite multiple repair attempts. Ford's own SSM 52515 acknowledges engineering was working on a fix and that rotor resurfacing is "not a guaranteed fix." TSB 23-2308 was performed in March 2024 (caliper bushings/guide pins replaced). In June 2024 a dealer verbally confirmed a brake recall was coming in Oct/Nov 2024 and that rotors would be covered — that recall never materialized. Front brake pads were replaced under Recall 21C31 in September 2022 at ~8,797 miles. Front pads and rotors required full replacement again in April 2025 at ~28,833 miles — just 20,000 miles later and well below the typical 50,000–70,000 mile service life — at my out-of-pocket cost of $747. Rear brakes were documented as "in the red" in January 2026 at ~38,000 miles. The vehicle is currently at a Ford dealership. In August 2024, one dealer attributed the issue to driving habits despite Ford's own TSBs acknowledging the defect. Brake wear across both axles is abnormally premature for a [XXX] vehicle. Across brake-related and recall visits the vehicle has been out of service for approximately 30 days. Relevant: TSB 23-2308, TSB 25-2143, SSM 52515 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

May 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Transmission went out at 100k

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

1. While driving my 2021 Ford Bronco Sport, Big Bend, ⁠the automatic transmission (Ford 8F35 8-speed automatic) experienced internal mechanical failure. The vehicle lost the ability to engage reverse gear and the check engine light illuminated. Ford authorized dealer Koons Woodbridge Ford [XXX] ) confirmed the failure under Repair Order #38386 with the finding: "VERIFIED CONCERN. THE TRANSMISSION HAS INTERNAL DAMAGE." The vehicle has not been repaired and is currently at the dealership. 2. How was your safety or the safety of others put at risk?* ⁠Complete loss of reverse gear created an immediate safety hazard the vehicle cannot be moved out of parking spaces, driveways, or roadway positions where reversing is required to avoid a collision or escape danger. The failure occurred without warning during normal vehicle operation. An inability to select a transmission gear while in traffic or a parking situation creates collision risk for the driver, passengers, and surrounding vehicles and pedestrians. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? ⁠Yes. Ford authorized dealer Koons Woodbridge Ford confirmed the failure on May 4, 2026, under RO# XXX. Diagnosing technician: David Ford (Tech ID XXX). Official finding documented on the dealer repair estimate: "VERIFIED CONCERN. THE TRANSMISSION HAS INTERNAL DAMAGE." No repair has been authorized pending Ford Motor Company's goodwill review. *4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others?* ⁠Yes. The vehicle was inspected by Koons Woodbridge Ford, an authorized Ford Motor Company dealership, on May 4, 2026 (RO# XXX). Koons Woodbridge Ford is a Ford-franchised service center whose technicians are Ford-certified. The inspection confirmed INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Faulty valve inside of transmission caused transmission failure. Has been properly diagnosed by ford mechanic. Mechanic said it was nothing I’ve done to cause the problem, it was a faulty part.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

I have 130,000 miles on my 2021 Ford Bronco sport. With no warning I'm unable to put vehicle in gear. I attempt to put the car into drive, then reverse and it will not go. The gear gets stuck in park, but unable to park, The car instructs me to intiated emergency park with many warning lights appearing. when driving it jerks , make grinding noises, and I even lost momentum. Ford said the help line states they have attempted to fix the codes and replace the parts on the inside of the transmission and no luck. Ford recommends a new transmission. I believe the 2021 Bronco sport have a faulty transmission and replacing with another will result with the same issue due to the transmission being a close system it isn't preventable. Many other owners have experienced this very same safety issue and Ford should address ot and be responsible.

Reported

May 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

In January of 2026, I took my 2021 Ford bronco sport Outer Banks to the dealership because my car had a wrench light come on and it went into limp mode. Supposedly it was fixed and now it is April 2026 and my car went into limp mode again, it would not shift in the park and would not start and now the dealership is telling me that there’s transmission issues but from what I’ve read, there is clearly been a lot of transmission issues in these vehicles.

Reported

May 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

There has been a NHTSA recall for AWD module on 2021 and some newer Bronco sports. The letter in reference to this problem dates 4/9/2021 to include only certain VIN at the time based on manufacturing sites. I feel there has been an underestimation of vehicles/parts affected on this recall based on the fact that it included very limited vehicles only 4 month into production. There have been several more known to be experiencing this same exact issues as evidenced by many reviews online by bronco sport owners experiencing the same problem. Specifically detailing the triggering of same codes (mentioned in this letter) leading to faulty AWD module diagnosis and replacement at the owners cost. I have reached out to Ford North America to file a claim and have been told my VIN is not included, without even comparing with specific part serial number. In addition, I have found the part #LX6Z-7P238-AANP as replacement referred in the letter has now recently been replaced with a newer more expensive version with a different name and part number M1PZ*7P238*C. I also find it significant that the old part is still for sale at a now discounted price on ford OEM website as of today. I believe this indicates there are known problems with this original part causing need for an updated replacement. Given this evidence l, I feel it is only fair that Ford acknowledges vehicles with the same problem/part are experiencing these issues and be willing to extend the recall. I have reached out to North American Ford and have a claim #Cxh-07823745-c2n6y4. In hopes that they will do what’s right for this customer and replace at no charge, aware that it is defective. My vehicle is currently at the dealership and I am hoping for a fair resolution. Thank you for your time and attention.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

Since purchasing the vehicle, I have had ongoing issues: a rattling noise when accelerating, a squeaking noise in reverse, and a fuel odor. The fuel injector recall (NHTSA 25V467) is still open, and Ford has not provided a remedy." Keep it simple and focused on the recurring noise and the recall.

Reported

Apr 2026

Incident date

Jan 2025

Mileage

Not provided

Outcome flags

None reported

Grinding noises started to occur coming from the back of my vehicle. This only occurs when turning the wheel and driving slowly. I took my vehicle to Ford to get it checked out and they stated that my rear axle differential needed to be replaced. I asked why does this need to be replaced as I have not been in any accidents. They told me that it was due to wear and tear on the vehicle. The car has just hit over 80k miles and no accidents, I have taken great care of this vehicle and get it serviced regularly. I have done some research on this issue with other Bronco owners and it seems like it is a VERY common thing. There are many complaints on Reddit on the same exact issue with their Ford Bronco Sports. Would love for this to be a recall as I do not want my vehicle to just stop out of nowhere on the highway as I was told this is a VERY serious situation that needs to be taken care of immediately, I do not have $2k to get this fixed, with taking care of this vehicle regularly there is no way that this is on my driving or just regular wear and tear. This should be taken care of by Ford as a recall so none of us Bronco Sport owners get hurt or get screwed out of money for an issue that we did not cause.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The rpm will shoot up to 6 without movement. It doesn’t want to stop or go and it says park is unavailable. There have been many recalls on this vehicle, this is a premature failure and a huge safety concern the resulted in my car being undrivable.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

On December 13, 2025, we drove to Flagstaff, Arizona from Tucson, Arizona, where we live. As we came into town, the Bronco began to lurch and seemed to have difficulty shifting. I managed to make it to the Babbitt Ford service center’s parking lot, where it seized and died altogether. It stayed at Babbitt Ford where they worked on it until February 3, 2026. They replaced the transmission at great expense. On Feburary 3, we drove it home to Tucson. The next day, February 4, it died in the road twice, once in a major intersection. The first time it eventually resarted. The second time it died completely and required a special tow truck because we couldn't even get it into neutral to roll. It was towed to Holmes Tuttle Ford where they kept it for a week but were able to eventually restart it. They had it for 5 days, ran a diagnostic and reset the system. They drove it for over 80 miles and couldn’t recreate the problem. Then on February 25, I drove to Phoenix. While in Phoenix, it again inextricably had trouble shifting, died and wouldn’t start. I then had it towed to Camelback Ford. On March 6, Camelback Ford called and said they ran numerous tests and still can’t pinpoint the problem and the vehicle still won’t start or shift into neutral.

Reported

Apr 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Transmission failed - vehicle completely lost power alternating with shuddering and full stopping without braking at slower speeds. Vehicle revved at very high RPMs at low speed, and struggled to shift. Sometimes, when shifted into reverse, vehicle would unexpectedly roll forward almost an entire car length. Transmission fully failed on freeway doing highway speeds of 75+ MPH. Full transmission failure has been confirmed by Ford dealer.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

I chose the engine and fuel questions as I believe these would be the issue. While driving on the I 10 east towards [XXX] there are areas on the freeway that you drive upward from a flat freeway service to (up hill). Today 04/22/2026, my bronco sport lost drive power from 65 mph to 45 mph which caused the warning lights of the engine and wrench notifications to come on. It was a little difficult and scary but I was able to get off the freeway safely and park. I looked under the hood and under the car for leaks but there were non found and after about 30 minuets, I got back on the freeway and went back home. Back in July of 2025, I believe their was a recall for the fuel injector system and I think this issue of today is based on that recall. I have not been able to confirm with Ford if this has anything to do with the 2025 recall and I have not seen any repair options. I have however, seen other's reporting the same issue. I don't know if you can doing anything but I wanted to provide my experience of today. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving on several occasions, cold condensation dripped onto the right leg and the floorboard smelled like rotting fish. The contact added that the condensation line should have leaked outside of the vehicle, not inside the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 63,450.

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

I own a 2021 Ford Bronco Sport Base (VIN: [XXX] ) equipped with the 1.5L EcoBoost 3-cylinder engine. I am experiencing a complete and repeated loss of engine coolant with no visible external leak. Upon inspection, air bubbles were observed rising through the coolant reservoir when coolant was added, indicating combustion gases are entering the cooling system through a compromised seal. On multiple occasions upon startup, sweet-smelling white smoke has been emitted from the exhaust, consistent with coolant burning in the combustion chamber. The vehicle has overheated as a result of coolant loss. These symptoms are consistent with the known 1.5L EcoBoost cracked engine block or head gasket failure defect affecting 2021 Ford Bronco Sport and 2020-2022 Ford Escape vehicles. I have been advised by a ford dealership mechanic that the vehicle is unsafe to drive due to the risk of engine failure and potential engine fire. The vehicle has been parked and is not being driven. I am filing this complaint as a safety concern given Ford’s history of engine fires related to this defect, which was the basis of recall 22S43 and ongoing federal class action litigation. I am requesting NHTSA investigate whether an expanded recall or additional consumer remedy is warranted for this vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

I brought my car in for an emissions state inspection, I was than told the machine wouldn’t connect to my car and the reasoning being was that the gateway module needed to be reprogrammed. I was aware ford had this issue so I was prepared with paperwork from the customer satisfaction program that states any bronco manufactured at the Hermosillo plant between the dates of February 2020 and October of 2021 was covered under a customer satisfaction program 22N15 to repair the gateway module one time regardless of mileage or years on the vehicle. At first I was lied to and told my car wasn’t manufactured at the Hermosillo factory but upon further investigation with another repair shop simply by verifying my vin number it certainly was manufactured their on the date of September 9th 2021. I explained all this to ford of sayville and ford corporation, but they both denied my claim without any reasoning other than its not part of your vin….I asked could you tell me why and never got an answer besides we aren’t covering the repair. My vehicle meets all the criteria for the known problem that ford distributed this vehicle with, I was forced to pay the $260 for a repair that should be covered by ford plain and simple. I ask that you can please help me resolve this matter and maybe help any future scammed consumers from dealing with the lies of ford. Thank you

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The listed safety recall was entered July 16, 2025. To date there is no remedy, parts not available. The Ford app shows no active recalls. I contacted Ford regarding this and they advised there was a temporary, interim fix available since August 2025 but no correspondence has ever been sent. I have been in contact several times with the dealer and was never advised of this interim fix. Ford rep advised some dealers don’t have the equipment for the temporary fix. Ford did have a Customer Satisfaction Program regarding this but I was advised that they would only complete if there was signs of an issue to the high flow injectors. It has now been 9 months since the recall and every time I’ve checked “no remedy/parts not available”!

Reported

Apr 2026

Incident date

Jul 2025

Mileage

Not provided

Outcome flags

None reported

Vehicle stutters when accelerating under normal driving conditions, causing uneven acceleration which can be dangerous in a situation where I am merging into traffic or turning from a stop onto a roadway. I believe this may be connected to the fuel injector recall which has been open without repair options since July 2025.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

My 2021 ford bronco sport had a very dangerous issue on April 4th 2026. Nearly run over by a huge semi. Traveling at 70 miles per hour on I- 5 my vehicle had a sudden loss of power and wrench light went on, no prior signs. Semi traveling behind me nearly crashed into semi in the next lane as he slammed on his brakes and veered to the left to avoid running me over. Caused a big problem with the transmission .. Ford dealership now has car. Corning ford, Ca Unsafe to ever drive again with no remedy to fix this deadly problem. Recall 25s76 Powertrain control module. Third time this vehicle had a reset for this recall issue.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving on several occasions at various speeds, the infotainment screen went black or displayed a half-operating screen. An unknown warning light was illuminated with the message "Attention Needed - Service Engine Soon" displayed. The vehicle was taken to a dealer, and it was determined that Part Number: BE52 needed to be replaced. The vehicle was not repaired. The contact stated that while driving on several occasions at various speeds, the check engine warning light illuminated. The vehicle was taken to the same dealer where it was diagnosed, and determined that an unknown part needed to be replaced after retrieving DTC: P0496. The vehicle was not repaired. While the vehicle was parked, the vehicle hesitated while starting. The vehicle was taken to another dealer to be diagnosed, and it was determined that the battery charge was lower than 40 percent but did not need to be replaced. The vehicle was taken to another dealer where it was determined that the battery needed to be replaced. The vehicle was repaired, but within 24 hours there was an unknown warning light illuminated with an audible chime. The contact believed that the failure was associated with the body control module (BCM). The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 52,000.

Reported

Apr 2026

Incident date

Nov 2020

Mileage

Not provided

Outcome flags

None reported

I purchased the 2021 Ford Bronco Sport in August of 2025. There were issues after about a week with all kinds of messages of components not working cycling through constantly on the display. The electric brake would engage on its own while parked and had to be shut off before I could go forwards after starting the vehicle. I took it to the dealership where I bought it and after a few days they said it was a batter issue and replaced it at no cost to me. It worked okay for a short time and then I had the same issues and now added to those were it wouldn't start for at least 15 minutes and several tries. Cruise Control could not be used and the turn signals would not work while all of the messages were displaying. The windshield wipers would only work at the highest setting and the rear wipers would not work at all. I took it to another Ford Dealership and they said it was an electrical wiring issue that they found. The High Speed Cam wiring is what they found a break in and they fixed it and cleared the codes. I paid 450 for this repair. Just 4 days later the issues have returned. Messages about components not working, this time the right turn signal would not shut off. I am concerned about the safety issues while driving with my turn signal stuck on. I called the same Ford dealership and they can get it in on Friday so that I can have a loaner car. I just don't feel safe driving the Bronco. I don't have the money to loose on trying to trade it in with these issue. Help!!!!

Reported

Apr 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The back lift window just shattered while the car was in park heard a loud boom and the weather has not changed temp

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

While driving, the vehicle stutters during acceleration, creating hesitation and inconsistent power delivery. This occurs during normal driving conditions and has not improved after being inspected by a dealership. The issue has been reproduced multiple times and remains unresolved. The vehicle was taken in for service, but no effective repair was provided, and the condition persists. There is an active recall related to a potential fuel injector defect, which may cause fuel to accumulate on top of the engine. The recall remedy is currently unavailable. Given the ongoing stuttering and known fuel system issue, there is concern this condition is related. This creates a safety risk, particularly when merging into traffic or accelerating from a stop, as the vehicle does not respond consistently. No warning lights have consistently appeared. The issue continues despite dealership involvement and lack of available recall repair.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

While driving between [XXX] and [XXX] , the vehicle suddenly lost fuel. The estimated miles to empty started to drop rapidly from 70 miles to 50 miles within minutes. At a safe point, I pulled over, there was no pooling of fuel under the vehicle, no other warning lights were issued. I turned around to return to [XXX] , the engine stalled and ran out of gas at mile marker 18 just north of [XXX] . I left the vehicle on the side of the road and walked back to [XXX] . This stretch of road has no cell service. The vehicle was towed to Corwin Ford for inspection. I requested that Recall CSP25S76 be completed on the vehicle, and replace the fuel injectors. The response was that the fuel tank needs to be replaced. They have not provided diagnostic evidence of why. I think this falls under CSP 21S38. Additionally, the catalytic converter was replaced in January under [XXX] and the emissions warranty extension. The vehicle has high mileage, but the purge valve should not have stuck open and this is a known issue with the Ford Bronco Sports. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

Something is happening when I get gas, the vehicle has trouble starting. It often times feels like it's going to die when it idles. Electrical issues have started to occur where I cant switch off the air or my lights wont turn off.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

My car has been stalling at stops and I am unable to fill my car as it will not start so I have to put increments of 10-15.00 at a time they have told me now for over three months that parts were on back order and the recall that can catch my entire car on fire while driving cannot be fixed as their is no fix for it. Multiple issues continue to pile on when the vehicle isn’t even 5 years old

Reported

Mar 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2020-2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.

Risk: A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.

Remedy: Dealers will update the engine control software. and replace the high pressure fuel rail assembly and the fuel injector ,free of charge. As an interim repair, dealers will update the engine control software, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed August 29, 2025. Second letters will be sent once the final remedy is available, anticipated in July 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S76. This recall expands and replaces previous recall numbers 22V-859, 24V187, and 25V165. Vehicles previously remedied under 22V-859, 24V187, and 25V165 will need to have the new final remedy performed once it is available.

Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Risk: An electrical short circuit can increase the risk of a fire.

Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.

Risk: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.

Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed on June 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S24.

Ford Motor Company (Ford) is recalling certain 2021 Escape, Lincoln Corsair, and 2021-2022 Bronco Sport vehicles. The fuel delivery module may leak inside the fuel tank, causing low fuel pressure which could result in an engine stall.

Risk: An engine stall increases the risk of a crash.

Remedy: Dealers will replace the fuel delivery module, free of charge. Interim notification letters (remedy not available) were mailed on September 30, 2021. Owner notification letters were mailed on December 14, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S38.

Ford Motor Company (Ford) is recalling certain 2020-2021 Edge, 2020 Lincoln Nautilus and Ford Escape and 2021 Lincoln Corsair and Ford Bronco Sport vehicles. An inadequate amount of lubricant in the rear drive unit may cause seizure of the rear drive axle.

Risk: If the rear drive unit seizes, there may be a loss of drive and/or a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will check the rear drive unit lubricant level. Axles found to have lubricant at the minimum level will be filled to the full level. Axles found to be below the minimum lubricant fill level will be replaced, free of charge. This recall began March 12, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S02.

Ford Motor Company (Ford) is recalling certain 2021 Bronco Sport vehicles. These vehicles may have been produced with incorrect front lower control arms.

Risk: An incorrect lower control arm may affect vehicle handling and control, increasing the risk of a rollover crash.

Remedy: Ford will notify owners, and dealers will inspect and replace the front lower control arms, if necessary, free of charge. The recall began April 9, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S03.

Ford Motor Company (Ford) is recalling certain 2021 Bronco Sport vehicles. The rear suspension subframe assembly may have loose or missing bolts.

Risk: Loose or missing bolts may affect the vehicle's handling and control, increasing the risk of a crash. It could also reduce the vehicle's performance in a rear impact crash, increasing the risk of injury.

Remedy: Ford will notify owners, and dealers will inspect the rear suspension bolts, and secure or replace the bolts, as necessary, free of charge. The recall began March 10, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S04.

Ford Motor Company (Ford) is recalling certain 2021 Bronco Sport vehicles. The moonroof glass may not have been bonded correctly to the moonroof frame, which could result in the glass panel detaching from the vehicle.

Risk: A detached glass panel can become a road hazard, and increase the risk of a crash or injury.

Remedy: Dealers will inspect the moonroof glass date code and replace the glass, if necessary, free of charge. Owner notification letters were mailed November 18, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S46.

Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco Sport and Escape vehicles. The rear brake linings may have been manufactured incorrectly, which can affect braking performance. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."

Risk: During certain situations, the driver may have to apply more brake pedal force, and the distance required to stop the vehicle may be extended, increasing the risk of a crash.

Remedy: Dealers will replace the front brake pads, free of charge. Owner notification letters were mailed August 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C31.

Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2022 Bronco Sport vehicles equipped with 1.5L engines. The engine oil separator housing may crack and develop an oil leak.

Risk: An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

Remedy: Dealers will inspect the oil separator for damage or oil leaks, and replace the oil separator and seals, as necessary, free of charge. Owner notification letters were mailed April 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S21.

Ford Motor Company (Ford) is recalling certain 2020-2023 Escape and 2021-2023 Bronco Sport vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.

Risk: A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

Remedy: Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Interim owner notification letters informing owners of the safety risk were mailed January 9, 2023. Remedy parts are expected to be available in 1st Quarter of 2023. Owner notification letters were mailed February 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S73. This recall includes all vehicles previously recalled under 22V-191. Vehicles previously remedied under 22V-191 will need to have the new remedy performed.

Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco Sport and 2022-2023 Maverick vehicles. The 12-volt battery may experience degradation and suddenly fail.

Risk: Battery failure can result in a loss of electrical accessories, including the hazard lights, or cause a loss of drive power, increasing the risk of a crash.

Remedy: Dealers will inspect and if necessary, replace the 12-volt battery, free of charge. Owner notification letters were mailed May 2, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S02. Vehicles in this recall were previously repaired under 24V-267 and will need to have the new remedy completed.

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.

Risk: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.

Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S26.

Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2023 Bronco Sport vehicles previously repaired incorrectly under recall numbers 22V-859 or 24V-187. A fuel injector may crack and leak fuel inside the engine compartment.

Risk: A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S21.

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Risk: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco Sport and 2022-2026 Maverick vehicles. The front lower control arm ball joints may have been incorrectly installed or incorrectly repaired at the vehicle assembly plant, allowing the control arm to disconnect from the front wheel knuckle.

Risk: A detached control arm can cause a loss of vehicle control, increasing the risk of a crash.

Remedy: Owners are advised not to drive their vehicles until the remedy is completed. Dealers will inspect and repair the front lower control arm ball joints as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 4, 2026. Additional letters will be sent once the remedy is available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S36. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 29, 2026.