2021 Chrysler Pacifica

The vehicle is affected by a Chrysler safety recall. When I brought it to an authorized dealership for the recall repair, they informed me that a warning light was illuminated and that they needed to perform a diagnostic inspection before completing the recall. After the inspection, they stated they could not determine the cause of the warning light and refused to complete the recall repair. The vehicle is available for inspection upon request. The recall involves a safety issue that could put me, my passengers, and others at risk. Because the recall has not been completed, I do not feel safe operating the vehicle. In addition, I have been unable to use the vehicle for work because it has not been repaired. Yes. The authorized Chrysler dealership confirmed that the warning light was present and performed a diagnostic inspection. However, they were unable to identify the cause of the warning light and refused to complete the recall repair. They informed me that the case had been escalated to a Chrysler/Stellantis engineer. es. The vehicle was inspected by an authorized Chrysler dealership. The dealership escalated the case to a Chrysler/Stellantis engineer, but after more than three weeks, no solution or repair has been provided. The dealership informed me that a warning light was illuminated and required diagnosis before the recall could be completed. After performing the diagnostic inspection, they were unable to determine the cause of the warning light. The recall repair has been delayed for more than three weeks without any resolution or estimated completion date.

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

The power steering is intermittently losing power during turns. This just started to occur within the past week so it has not yet been taken to a shop. Yes it is available for inspection. Safety was put at risk due to it being a family car with children. A quick response was necessary to prevent oversteer during correction. Apparently this is a known issue on earlier models and seems to be continuing. No warnings.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

I took the van to get the safety recall done in 2026, Feb 25. For the rear view back up camera. I took it to the same dealership that I bought the car from, Jones Junction. However, upon further complications with the back up camera, this issue has never been fixed or resolved. If anything, the issue has become worse. I am unable to use my camera 98% of the time. It freezes. It goes black or is unavailable to see anything out of. It's a safety recall for a reason. I want this issue fixed. As I have been driving like this with the issue for quite some time. What are my next steps? I prefer not to have to dealer hop if I can help it. But I might have to. Is there a patch they may have to do to re-install the software for the camera? Or would they have to go and flash it again and what ever else? My true gut tells me that I dont think this specific dealership ever did the recall, correctly.

Reported

Jul 2026

Incident date

Jul 2026

Mileage

Not provided

Outcome flags

None reported

The High Voltage (HV) Battery System and associated safety isolation circuits failed. Specifically, the vehicle experienced faults with the High Voltage System Interlock Circuit (HVIL), the High Voltage Service Disconnect, and the Hybrid/EV Battery System Precharge circuit. The vehicle is currently located at a manufacturer dealership and is available for inspection. The failure of the high-voltage interlock and precharge circuits compromises the vehicle's electrical isolation safety mechanisms. This poses an immediate risk of a sudden loss of motive power. Additionally, because these faults are rooted in the high-voltage battery system—a system actively under federal scrutiny and manufacturer recalls for thermal runaway—the failure presents a severe risk of spontaneous vehicle fire, endangering occupants, bystanders, and nearby structures. Yes. The failure was initially recorded by an independent diagnostic scan tool, which pulled several confirmed high-voltage fault codes. The vehicle was then taken to a certified manufacturer dealership, where it has been held in the service department for a month. The dealership has confirmed the presence of a severe system failure and initiated repairs costing at least $1800 (with final costs still potentially increasing). Yes. The vehicle is currently in the possession of, and being inspected by, technicians at a certified manufacturer dealership. Yes, the vehicle's onboard diagnostic system detected severe faults and registered the following confirmed trouble codes: * P0B37 - High Voltage Service Disconnect Open * P0C77 - Hybrid/EV Battery System Precharge Time Too Short * P1AE2 - Battery Energy Control Module High Voltage System Interlock Circuit * P0A0A - High Voltage System Interlock Circuit

Reported

Jul 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

Power steering malfunctioned and stopped working in the middle of driving. It works intermittently.

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

My 2021 Chrysler Pacifica Hybrid has a recurring hybrid/electrical defect that causes the accelerator to lose all power while driving, leaving the vehicle unable to accelerate or respond to throttle input. The vehicle remains “on,” but it cannot move under its own power and must be coasted or pulled over immediately. This has happened in traffic, including with children in the vehicle. The dealer confirmed fault code P1A21‑00 and documented that the high‑voltage system can lose its loop connection, which results in a no‑propulsion condition. They also found the HVIL high‑voltage connector loose and damaged. The vehicle was in the shop for 18 days for this issue. I picked it up on June 18, 2026, and within 24 hours the same loss‑of‑propulsion failure happened again. The vehicle is now back at the dealer. The dealer performed recall 52D and updated the BPCM software, but the failure still occurred immediately after pickup. This defect has been reproduced and confirmed by the dealership multiple times and remains unresolved. This is a serious safety hazard because the vehicle loses propulsion without warning and cannot accelerate in traffic.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Steering is clicking when stationary while turning the wheel and also while idling over bumps. Brought dealership and would need an entire steering gear assembly replacement

Reported

Jun 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

While driving on interstate 15 and going 65-70mph the vehicle dashboard flashed “Charging Error, vehicle will shut down”. Before my wife could make it through traffic to the shoulder the vehicle lost all motive power including power steering. She was able to just coast the vehicle and get into the shoulder. Vehicle would not restart. The transmission had been previously replaced during recall to correct this issue. Chrysler had the vehicle for 5 weeks.

Reported

Jun 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Chrysler Pacifica. The contact stated that the message "Service Gear Shifter" was displayed, and the gear shifter lights were not illuminated. Additionally, the contact stated that the ESS system malfunctioned, and the 12-volt battery had failed, which the contact related to the gear shifter failure. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 100,000.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

While driving the vehicle, the accelerator will become inactive and result in the vehicle slowing to a stop. I will shut off the ignition and let vehicle rest for 10-20 mins before restarting. This does not resolve the issue and I end up towing the vehicle into the manufacturer’s service department. This often results in 100s of dollars in “diagnostic” fees. The service dept claims it’s bad battery, changes and issue arises again. Next they say it needed a software update, and a few days later it fails again. Next they said it was PCM module and replaced it, and finally they replaced the transmission. The 4th visit, change of transmission, lasted a little over a year and then the issue arose once again! After paying $259 in diagnostic fees, they said I used a bad “charger”

Reported

Jun 2026

Incident date

Mar 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 CHRYSLER Pacifica. The contact received notification of NHTSA Campaign Number: (24V436000 (BACK OVER PREVENTION) however, the recall repair was done; but the issue reoccurred a month later. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was 65,000.

Reported

May 2026

Incident date

Aug 2023

Mileage

Not provided

Outcome flags

None reported

After deploying the second-row Stow 'n Go captain's chair seat from its stowed position in the floor, the integrated headrest fails to lock in the upright, passenger-safety position. The headrest remains folded forward or flops forward under normal conditions and cannot be secured in the upright position required for safe occupancy of the seat. The root cause, as identified by dealership technicians and documented by numerous owners across multiple model years (2017–2022), is failure of a small plastic component within the headrest actuator cable assembly. This cable mechanism is designed to automatically fold the headrest during stowing and return it to the locked upright position when the seat is deployed. When the plastic cable end or the locking mechanism fails, the headrest cannot return to or maintain the upright, locked position. The cable itself is not sold separately by Chrysler/Stellantis, with dealers quoting $500–$1,000+ for repair requiring full seat frame or headrest replacement. This constitutes a safety hazard because: (1) a headrest in the forward/folded position provides no rear-impact protection to an occupant, increasing the risk of whiplash or cervical spine injury in a collision; (2) the condition prevents safe installation of child booster seats in the affected seating position; and (3) the defect is a known, widespread, and persistent design flaw affecting multiple model years with no manufacturer recall or remediation issued. This issue has been reported by a large number of owners on owner forums and acknowledged by Chrysler customer care representatives, yet no recall, technical service bulletin fix, or goodwill repair program has been established. I am filing this complaint to support an investigation and potential recall.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

This vehicle quit driving and you can move it. Confirmed bad transmission. I bought it this way from the insurance company because it bounced off a concrete barrier. I suspect this happened when the transmission failed. Unsure of a police report due to it happening to the previous owner.

Reported

Apr 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

Crash

Had two different electric coolant heaters fail in just over 2 years. One at 36,000 miles and one at 72,000 miles. Each time it has failed it results in a loss of cabin heat which prevents me from being able to use the defrost capability and heat my minivan that I bought to drive my 4 young children around.

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

I encountered two incidents of the same type. One was on Friday, March 27, 2026, the same day I picked up the vehicle from a local Chrysler dealership, where software updates and issues related to recalls were supposedly completed. The vehicle was at 38% battery level at the time of pick up from the dealership parking lot. After driving it for about 14 miles, the battery level depleted to <1% and that's when the "Stop Safety. Vehicle will shut off soon" displayed on the dashboard. I slowly drove for less than a minute and parked the vehicle and turned it off. Then restarted and drove for less than two minutes, but again the same warning ("Stop Safety. Vehicle will shut off soon") displayed; I turned it off again. After taking a few minutes break, I restarted it and it was showing 1% battery; it gave me a little distance to travel until unfortunately the same warning displays. Fortunately, this time I was close to a place where I can charge the battery. The battery got charged to 100%, partly on the night of March 27th and the remaining in the morning on March 28th. The second incident was on March 29, 2026, on Sunday afternoon. As soon as the battery level reached <1%, the exact the same warning ("Stop Safety. Vehicle will shut off soon") was displayed. I slowly drove the vehicle to the side of the road and called my insurance company; I reported the issue and requested them to tow the vehicle to a nearby Chrysler dealership. As of now, the vehicle is at the dealership parking waiting for diagnosis. Based on my initial conversation with the customer service person, they don't know if this is considered part of any recall or not. Not only was I stranded on the road because of the above incidents, not having the vehicle at the moment is straining me a lot - trying to handle personal and work schedules.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

This is an intermittent issue that has been happening for a while now and the car was sent to the dealership twice but the issue still persists. The engine would shuts down or partially loses torque all of a sudden and the steering becomes very stiff. At the same time you would see all kinds of alarms, error messages, and check lights on the dashboard. I would then have to pull over to the side of the road, turn off the car, then try to start it back up. Usually after several attempts (one time that took nearly 30 minutes), the car works properly again with no error messages but sometimes I'd still have some persistent check lights on the dashboard. Error messages and check lights that I see include the following: -Service Electronic Stability Control -Autopark Engaged -Shifter Autocorrect Active -Park Brake Temporarily Unavailable -AWD System Temporarily Unavailable -Automatic Emergency Braking off check light -Forward Collision Warning off check light -Check Engine light The dealership has been unable to properly diagnose and fix this issue so far. On the first visit, they replaced the main battery, auxiliary battery, some wire harnesses that I was told had some corrosion, and the adaptive cruise control module. On the second visit, they replaced the CAN Bus star connector. The same issue still persists after replacing all above components.

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

Incident: While driving at highway speeds (65–75 mph), the vehicle issues imminent-shutdown warnings, the reduced-power (‘turtle’) light and check engine light illuminate, and the vehicle loses motive power. The driver must pull over to the freeway shoulder immediately and restart the vehicle. The condition is intermittent, occurs after cold starts, and sometimes with cruise control engaged. Safety Risk: Sudden loss of motive power at 65–75 mph without warning creates extreme crash risk. This is the exact risk stated in the recall notice. The software-only remedy appears insufficient. FCA’s own Warranty Extension Campaign XE1 — covering transmission replacement at unlimited years/unlimited mileage — suggests FCA is aware the software fix may not be adequate. Requested Action: Please investigate whether the recall remedy is adequate or whether physical transmission replacement is required. This vehicle has been documented experiencing the recalled defect seven times after the recall repair was completed.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The power liftgate safety detection has failed numerous times, hiting both myself and my husband on our heads with the full force of the liftgate closing. It is not detecting an obstruction in the way and going back up again, this is incredibly dangerous - I was hurt quite badly today.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

While driving at normal road speed, the vehicle suddenly lost propulsion and entered limp mode. A turtle warning icon appeared along with multiple system fault messages. The vehicle began slowing down on it's own and was unable to accelerate. I pulled to the side of the road. The vehicle displayed an error "Stop Safely Vehicle Will Shut Off Soon". After sitting for a period of time, the vehicle restarted and was able to be driven again, but the failure occurred without warning and created a dangerous situation in traffic. Diagnostic trouble codes were present related to the hybrid system and high-voltage battery, including P1D43, P1A21, U029A, and U0412. These codes indicate faults in the hybrid control system and battery communication. A Chrysler service department inspected the vehicle, confirmed the trouble codes, and returned it to me without repair because the issue was not immediately reproducible at the dealership. The vehicle has a history of similar intermittent issues, including prior loss-of-power events and repeated service visits for hybrid system faults. The condition is not consistently reproducible, but when it occurs it results in a sudden loss of motive power while driving. This creates a significant safety risk due to unexpected loss of propulsion in active traffic.

Reported

Mar 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

The rear headrest will not stay in its proper upright position. After putting it into its Stow N Go position in the floor, the headrest is broken and down and no one can sit in the seat safely. This is a safety issue and Chrysler needs to repair it for free. It is a design flaw. A very thin piece of plastic breaks and results in an unusable rear seat! So many complaints from people who have had this happen. It is not a fluke. It is a regular problem with this otherwise great car! And if someone has an accident with someone trying to sit in that broken seat and gets hurt because there is no headrest………..

Reported

Mar 2026

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

When driving at speeds over 45 mph and making turns (eg on high ways) the van will sway and rock. I have installed new shocks, had an alignment, had ball joints and sway bars inspected, and had tires restated. I’m wondering if there is some sort of an issue with the electronic assist power steering that senses g forces and compensates inappropriately. It is extremely dangerous and we have nearly lost control of the car while doing a routine turn. It happens when turning left, but not when turning right.

Reported

Mar 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The Electric Coolant Heater (ECH) failed (Error Code P0E15), which is a critical component of the High Voltage Battery Thermal Management System. This failure disabled the vehicle's hybrid propulsion system and prevented the vehicle from operating in electric mode. This is a documented systemic issue (Ref: TSB S2208000203) that affects the driveability and safety of the vehicle's hybrid powertrain.

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

The back up camera does not work intermittently. The screen is just black. This was supposed to be resolved as part of recall 66B/NHTSA 24V-436. I had that recall work completed in January 2026 but it did not resolve the issue. The dealer said they are unaware of that repair not resolving the issue and said I would be liable for the costs associated with the additional diagnostics if the manufacturer refuses to pay. I went on line and apparently a lot of people are continuing to have the same issues. This is a recurring issues that happens about 25% of the time we back up. The attached photo was the latest time.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Chrysler Pacifica. The contact stated that while driving approximately 30 - 35 MPH, there was an abnormal rattling sound coming from the wheel well or near the front underbody near the air dam, as if there was a piece of ice stuck in the air dam. The vehicle was taken to the dealer, who diagnosed that the front wheel hub hardware was loose, affecting the wheel bearings, and causing the failure. The contact was informed that the wheel hub hardware and front wheel bearings needed to be replaced, and the front wheels needed to be rotated. The vehicle was not repaired. The manufacturer was informed of the failure, and a case was opened. The failure mileage was approximately 20,000.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

I was driving my Pacifica, got the warning light telling me to pull over. The van lost power 3/4 way up a hill blocking traffic and had to get towed to the dealer, where it now awaiting a transmission rebuild. This is the 4th time this same van has died like this, including twice on the highway. Previous times when I brought to the dealer, they only updated software or told me there was nothing they could do

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

Went to start vehicle and it was possessed. Would not turn over. Wipers lights everything was going off. Could not get it out of a/c mode. When hooked to a computer at mechanics it can only read two modules. ECM is malfunctioning.

Reported

Feb 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

If I am trying to park and going like 10 miles an hour and start turning the steering wheel, it starts shaking. And it does it every time.

Reported

Jan 2026

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

On January 14, 2026 while driving on highway fast lane warning light came on that engine was going to shut off and withing a few minutes it did. I managed to pull over off the freeway before engine completely shut off. Turned everything off and waited about five minutes and turned car back on. Car ran with engine warning lights on. Took it to Carl Burger Dodge but they could not check in the car due to an abundance of work. Asked that I make an appointment later. On January 26, 2026 while driving on the highway same thing happened, warning light came on that engine was going to shut off, pulled over from fast lane to side of busy highway and stopped. Turned everything off and waited for about five minutes and started car again with car warning lights on. Drove it that day. Later in the day parked car at a shopping mall and turned car off. When I returned to turn car on warning light came on that engine was shut down. Turned everything off and waited for about five minutes and turned car back on, it drove with engine warning lights on. On January 29, 2026 took car to Carl Burger Dodge and left it there for evaluation and repairs. Question, has there been any recalls or fixes relating to alleged problem an internal transmission wiring connector that may short and can cause the car to shut off? An issue NHTSA had previously identified as a problem.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

The transmission is defective, and according to the warranty, under the lemon law, it has a lifetime warranty, which in my understanding means the entire defective transmission should be replaced. However, I received a call where I was told they would only repair the transmission with a 3-year warranty, and if it breaks down again, I would have to bear the future costs. In my understanding, if I have a warranty on the transmission, they should replace it with a new one. Therefore, I want to make it clear in writing that I do not wish to or authorize any repair of the transmission, but rather the replacement of the transmission as is my right. If there is any problem with the transmission, the company is solely responsible for the decision.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Chrysler Pacifica. The contact stated that while driving at 10 MPH and attempting to slow down to park in a parking spot, the steering wheel started shaking unexpectedly. There was a clunking sound coming from the steering wheel. A dealer was contacted. The vehicle was taken to the dealer, where it was diagnosed, and it was determined that the steering rack and pinion needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 70,432.

Reported

Jan 2026

Incident date

Dec 2024

Mileage

Not provided

Outcome flags

None reported

Another driver failed to yield to traffic and drove right into the side door, gas tank and rear wheel at about 35 mph. Not a single airbag was deployed within my 2021 Chrysler Pacifica. I did sustain injury

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

Crash 1 injuries

I am reporting a safety defect involving my 2021 Chrysler Pacifica Hybrid. The vehicle experiences repeated hybrid system failures, including “system charging” errors, rapid battery depletion from full to zero within minutes, and vehicle stalling. These failures have occurred multiple times, even after dealership repair attempts. The vehicle has stalled and been towed more than once, most recently on September 26, 2025. Now, today, January 20, 2026, the vehicle has once again stalled and will have to be towed for the third time since purchasing in August 2024. This has left us stranded once again. This is a serious safety concern, especially given the risk of stalling while driving. I transport elderly family members and depend on this vehicle for medical appointments. I am requesting NHTSA document this issue and review whether this represents a broader safety defect.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Car rolls forward when in reverse and takes a dangerously long time to slip into gear. Car rolls back when foot is taken off brake, especially on hills.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

On [XXX] while driving my vehicle on the fast lane of the freeway the warning came on that the vehicle was going to shut down soon. I was able to pull over to the slow lane and immediately exit the freeway and as I was exiting the freeway the vehicle completely shut down. I was able to move the car to park in a safe area on the street with what little power it had. Shut the vehicle down and contemplated what to do. I waited for a few minutes and then turned the engine on and it drove but the orange engine light was still on. I slowly drove it to the Carl Burger Dodge dealership in La Mesa, CA using side streets, avoiding the freeway, approximately 10 miles distance. They would not take my car in for service due to their back log and asked for I to make an appointment which would likely be around two to three weeks away or take it to another dealer that may look at my car sooner. Hesitant, I slowly drove my car to my residence again using only side streets, a distance of about 20 miles. Made it safely but the orange engine light was still on. I have had recall repairs on this vehicle previously. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Similar to the Ford recall, the LED Daytime Running Light Module is defective. This LED went out in under 3 years and Chrysler won’t fix it. This is a problem that many people are experiencing, and they want $2,000 to replace the entire head lamp system.

Reported

Dec 2025

Incident date

Oct 2024

Mileage

Not provided

Outcome flags

None reported

Reversing onto roadway and shifted from reverse to drive via rotary dial and vehicle went into park and would not move causing me to block the roadway. In addition and even more concerning was that the vehicle could not be turned off and any and all actions to do so just left the car "on" and the hybrid system running. Eventually we pulled the battery cable on the main 12v in the trunk and the reset allowed us to move the vehicle again. I sat across a busy section for twenty minutes with no way to move, turn off, or overide the system with three kids with me in a busy traffic area. The vehicle has not reproduced the issue as of yet. The dash had multiple warnings for park system and service various items needed. this occurred 12/17/2025 with 70,000 miles.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Chrysler Pacifica Plug-In Hybrid. The contact stated that the vehicle failed to start. The vehicle was towed to the dealer, where it was diagnosed with a power inverter module (PIM) failure. The dealer replaced the power inverter module (PIM); however, the failure persisted. The dealer determined that the hybrid battery needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 41,000.

Reported

Dec 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

While driving down the highway at 70 miles per hour ater driving 2.5 hours our 2021 Pacifica hybrid minivan flashed a warning on the vehicles display saying approximately "Warning Engine Shutting Down". The engine immediately shut down in the middle of the highway and we were forced to coast off the highway to the shoulder. The engine warning light came on. We turned the car off for a few minutes and proceeded to start the engine. The engine warning light was still on, but the other message was gone. We attempted to drive towards our destination and approximately 30 minutes later the same thing happened again. We tried one more time since we were several hours from home and within 30 minutes the vehicle had the same issue. At that point we decided to try to get home. We drove the vehicle 15-20 mins at a time and then exited the highway over and over giving the vehicle time turned off. After returning home with no additional events the engine warning light went off the next warning. This was on a Sunday so we were unable to get it to a dealer. The next day we dropped off the vehicle at Nappletom Chrysler dealership. The called us the next day and told us they could not cause the event to happen again. They could see a set of error codes showing the problem occurred, but told us there was nothing they could do and it was up to us to cause the problem and then return the vehicle. Now I have a minivan with 70k miles on it that my wife primarily uses my with to get my daughter from place to place and I have no idea when this vehicle will shut the engine down at any time potentially causing a dangerous accident. I believe Chrysler has the responsibility to determine what the issue is. Researching on the internet show this is a common problem for my vehicle and typically requires a new transmission or and engine wiring short.

Reported

Nov 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

See attached document for complaint.

Reported

Nov 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

More often than not, the steering wheel column gets stuck at 10-11 o’clock positions and 1-2 o’clock positions. So it typically happens when making slight bends on my local roads and highways. This requires a hard jolt on the steering wheel to get it un-stuck. This is extremely unsafe to do at high rates of speed and/or with traffic on either side of me and it feels only a matter of time before it results in an accident. When I brought the car into the dealer for a different repair, they noted in their follow-up inspection a, “rep clunk from steering gear the wheel both ways” and quoted me $4800 for repair. I’m assuming that’s to replace the entire steering column, which is pretty outrageous considering the part is less than $900 OEM and would be about 2-3 hours of labor. I purchased the car 6 months ago as a certified pre-owned car from a dealership and the CarFax report came back completely clear, recall repairs weren’t even mentioned on it. I’ve seen some discussions on online forums describing a similar issue.

Reported

Nov 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

High pressure fuel leak with large fan spray pattern in fuel line part number 68492134AA where it sits and rubs against a sharp corner of another component, (appears to be ignition coil) above the rear passenger side of the engine. Searched online and found another owner had posted an image of the exact same leak! https://www.reddit.com/r/ChryslerPacifica/comments/1amcdp9/2021_pacifica_hybrid_fuel_leak/Their photo and mine are identical and in comments on their thread, Two other owners that responded to that thread also said they've also had exactly the same leak. The cause appears to be how this line is routed by the factory. it is resting against the coil and not secured in a way to prevent chafing. Result is extremely dangerous with fuel spraying down towards the exhaust. The part is available for inspection. Safety of my family was put at risk by fuel spraying towards hot exhaust while my wife was driving. She was unaware of problem until fuel smell just prior to arriving at home. Problem is easily reproduced. I spoke with Olympia Chrysler Jeep and the service advisor Corey, said he had seen this issue before as well. He also said because car is not under warranty and I don't have roadside assistance, towing would be at my expense. I have ordered replacement part and will install and secure it to prevent chafing. I will keep part to be availalbe for examination. There were no warning lamps, messages or other symptoms prior to the fuel smell.

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2021 Chrysler Pacifica. The contact stated that while reversing, the back-over prevention camera image was frozen. The contact stated that the failure was intermittent. The vehicle was taken to the local dealer, who performed a software update as part of the manufacturer's Extended Warranty Coverage related to the failure. The contact stated that after the software update was performed, the failure occurred intermittently. The manufacturer was notified of the failure. The failure mileage was 55,000.

Reported

Oct 2025

Incident date

Oct 2024

Mileage

Not provided

Outcome flags

None reported

2nd Row Seat fails to latch and lock in position. The seat reclines back and forth without being able to be latched in place. My [XXX] and [XXX] 's safety is greatly impacted by this, as the seat is unable to be properly secured in the event of a crash. I have had the other 2nd row seat repaired nearly 2 months ago at a Chrysler dealership, but am dealing with the same problem on the other 2nd row seat. When I took the vehicle to the dealership 2 months ago, the 2nd row seat that has now failed to latch was not experiencing those problems. There were no warning lamps or symptoms of this failure to occur other than knowing that the other 2nd row seat had experienced the same failure 2 months prior to this. A poor design in the seat reclining mechanism in the 2nd row seats of the Chrysler Pacifica by Chrysler appears to be the problem. Numerous other posts about this same issue exist on the [XXX] webpage, as well as by doing a google search on the failure INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Oct 2025

Incident date

Oct 2025

Mileage

Not provided

Outcome flags

None reported

Rear view camera does not work 50% of time since recall was updated. Back seat entertainment games no longer work due to recall “fix”. Service department at Chrysler had no diagnosis besides that the recall has messed up other peoples vans entertainment as well.

Reported

Sep 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

The ESS battery fails constantly and manufacturer will not find problem and just replaces battery. When the ESS battery fails it drains the main battery which then leaves the driver and its occupants at risk of being stranded. The transmission is an electronic transmission and if the battery fails while driving that could compromise the occupants also. We have had to have the battery replace twice and a third time tomorrow 9/21 if the dealership will "fit" us in. The ESS system will tell you it is unavailable but only after the battery has failed.

Reported

Sep 2025

Incident date

Jul 2024

Mileage

Not provided

Outcome flags

None reported

The transmission stutters and searches from 15 mph - 30 mph. Dealer ship told us it was a known issue and they just reset the "learning" feature of the transmission. The fix gives you another 6 months and then the issue slowly returns. This causes undue wear on the transmission and leaves it open for catastrophic failure. Dealership refuses to repair after warranty expires even though it is a known issue. There are no warning lamps or messages just an slowly growing clunking at slow speeds over time.

Reported

Sep 2025

Incident date

Jan 2024

Mileage

Not provided

Outcome flags

None reported

When adaptive cruise control is enabled and I’m at cruising speed, new vehicles entering the lane in front of my vehicle are not being acknowledged leading to my vehicle getting too close and collision becoming likely. This leads to me having to takeover control frequently to prevent accidents. This happens often, not always, but it is becoming more and more frequent. This happens at all speeds from 30 mph to 70mph

Reported

Sep 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

While driving my vehicle soon after purchase I notice an engine light on along with a huge fan noise from under the hood. Addressed the issue with dealer they diagnosed the car and so called fixed the issue. about a month ago I’m driving the car on a residential street and noticed the car jerking loud fan noise and the whole dashboard light up saying service hybrid service engine and transmission.. Suddenly the engine stops in moving traffic. The vehicle windshield wipers cut on by themselves and the car stayed in park.. tow the vehicle to the dealer using only a dolly tow truck due to vehicle unable to be placed in neutral. Dealer calls to give update and noted no codes were stored and there is currently no issue with vehicle..He suggested to keep the vehicle longer to see if the problem returns. I’m afraid the electrical issue that is going on with this hybrid will cost me and my children life one day. this vehicle is not safe to drive and I am stuck in a purchase contract.

Reported

Aug 2025

Incident date

Aug 2025

Mileage

Not provided

Outcome flags

None reported

Vehicle is new and delivered on 08/27/21. Complaint: The front axle nuts on vehicle loosen over time. The first incident was reported to I-10 Chrysler Dodge Jeep Ram on 09/29/23 (see Invoice), with 24,832 miles as a noise coming from the front left suspension. This dealer replaced both front hubs at that time which resolved the noise. The second incident was reported to Chrystal Chrysler Jeep Dodge Center on 02/13/24 (see Invoice) with 27,952 miles as a noise coming from front left axle. Dealer mechanic went on test drive with me and found noise coming from front left axle shaft nut. RO states, "Found axle nut not torqued to specs. Tight down left front axle nut. Test drove vehicle. No noise found after repair.". The third incident was reported to Hemet Chrysler Dodge Jeep Ram on 08/26/25, and I asked them to check the torque on the front axle nuts. They told me that the odds that they would be loose again was very small and they would need 2 days to diagnose the issue. Because I was leaving for a vacation road trip with the vehicle within a few days, I decided to take it to an independent automotive shop (Cam Stones Automotive Inc.) on 08/26/25 and reported that the vehicle has a history of the axle nuts loosening over time. I asked that they check the torque on the front axle nuts (see Invoice). The invoice states, "Retorque axle nuts and apply lock tight. Suggest contact dealer or NHTSA as to permanent fix. 120 Ft. Lbs.". As I'm sure you are aware of the danger in axle nuts that loosen over time. Is there a Recall on this issue? If not, are you investigating complaints of the axle nuts loosening time and time again?

Reported

Aug 2025

Incident date

Sep 2023

Mileage

Not provided

Outcome flags

None reported

There are clearly many design flaws on my 2021 Chrysler Pacifica Hybrid. One issue I am having with this car is the Daytime Running Lights. These are expensive LED lights that should function for the life of the vehicle. Unfortunately, I believe there is a problem with the control module on the LED lights, and part of the driver's side light does not function. This is a clear safety issue, and seems to be very common problem people are having with the 2021 Chrysler Pacifica Hybrid. I notified Chrysler about the issue, and because the car was just over 36 months old, they would not repair the issue. They told me I would have to pay for a complete replacement of the headlight which would cost over $1000. Just today, I noticed Ford posted a recall for the same issue they are having with their Daytime Running Lights. I believe it is only fair for Chrylser to provide a voluntary recall on this same issue because of the clear safety hazard it can creates. What is the purpose of Daytime Running Lights if they don't function properly. This is a minivan I rely on to safely transport my family, and I do not want to risk a hazardous collision because Chrysler refuses to repair a faulty part in their vehicle.

Reported

Aug 2025

Incident date

Oct 2024

Mileage

Not provided

Outcome flags

None reported

Chrysler (FCA US, LLC) is recalling certain 2020-2022 Pacifica Plug-In Hybrid Electric (PHEV) vehicles. The battery pack may cause a vehicle fire, even when the vehicle is parked with the ignition in the "Off" position.

Risk: A vehicle fire increases the risk of injury.

Remedy: Owners are advised not to charge their vehicles, and to park outside and away from structures, until their vehicle is repaired. Dealers will update the high voltage battery pack control module software. In addition, dealers will inspect and replace the battery pack assembly, as necessary. All repairs will be performed free of charge. Owner notification letters were mailed beginning June 23, 2026. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is 52D. The Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on June 11, 2026.

Chrysler (FCA US, LLC) is recalling certain 2021-2022 Pacifica and 2021 Voyager vehicles. The second-row seat-to-floor mounting latch may bind and stick open, preventing the seat from properly securing to the floor. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 225, "Child Restraint Anchorage Systems."

Risk: An unsecured seat increases the risk of injury in a crash.

Remedy: Dealers will inspect and, if necessary, replace the second-row seat cushion frame, free of charge. Owner notification letters were mailed April 7, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is Z22.

Chrysler (FCA US, LLC) is recalling certain 2017-2023 Pacifica Plug-In Hybrid Electric vehicles (PHEVs). An internal transmission wiring connector may short circuit, resulting in an unexpected engine shutdown.

Risk: An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash.

Remedy: Dealers will update the Power Inverter Module (PIM) software and, if necessary, update the instrument panel cluster (IPC) and the electronic control module (ECM) software, free of charge. FCA US will notify dealers and begin notifying owners on or about: 03/21/2023 for 2021 model year vehicles, 05/02/2023 for 2019-2020 model year vehicles, and 06/15/2023 for 2017-2018 model year vehicles. FCA began notifying owners on February 23, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 03A.

Chrysler (FCA US, LLC) is recalling certain 2021-2022 Dodge Durango, 2021-2023 Chrysler Pacifica, Jeep Grand Cherokee L, 2022 Ram 1500, 2500, 3500, Chrysler Voyager, 2022-2023 Jeep Compass, Grand Cherokee, Wagoneer, Grand Wagoneer, and Ram Promaster vehicles. The radio software may prevent the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk: A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash.

Remedy: Dealers will update the radio software or the software will be OTA, "Over-The-Air," free of charge. Owner notification letters were mailed beginning July 9, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's numbers for this recall are 66B and 79B.

Chrysler (FCA US, LLC) is recalling certain 2020-2023 Pacifica and 2020-2021, 2023 Voyager vehicles. An improperly secured connector for the side curtain air bags may prevent the air bags from deploying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 214, "Side Impact Protection" and 226, "Ejection Mitigation."

Risk: An air bag that does not deploy during a crash increases the risk of injury.

Remedy: Dealers will secure the connector, free of charge. All vehicles have been remedied. Owner notification letters were mailed October 22, 2024. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is A8B.

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Risk: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

Vantage Mobility, LLC (VM) is recalling certain 2021-2026 Honda Odyssey, 2021-2025 Chrysler Pacifica, and Toyota Sienna vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. The retractors may not lock, preventing the wheelchair from being properly secured.

Risk: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Dealers will inspect and replace the retractors, free of charge. Owner notification letters was mailed January 27, 2026. Owners may contact Vantage Mobility customer service at 1-800-488-9082.