2025 BMW i4

Charging interrupted-failed. Unable to fully use EV. Dealer confirms issue & has EV for two weeks, BMW USA has been notified, no remedy offered.

Reported

Jul 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

Entire car was bricked after a software update (03/2026.54). Even the gear could not be changed to neutral for placing on a tow truck. Nothing wrong with the batteries. After more than 12 hours, finally the engine powered on but the software failure notification sign would still not work, and car had to be towed to authorized service center for a clean software reinstall.

Reported

Jun 2026

Incident date

Jun 2026

Mileage

Not provided

Outcome flags

None reported

I was driving last night on the highway in a monster rainstorm in Long Island, NY. In a full monsoon the wipers stopped working stuck in the up position. I was fortunate to not get in a very serious accident as I was going 50mph with ZERO visibility. I was able to make it to the side of the road where i drove with my hazards to exit the highway and pull into a gas station. I could have been killed. I called BMW to have the car towed to the dealer as it was still raining and I was unable to drive. It was over 2 hours for the tow so I waited for the rain to stop and then I drove home.

Reported

May 2026

Incident date

May 2026

Mileage

Not provided

Outcome flags

None reported

On November 18, 2025, I was driving a 2025 BMW i4 eDrive, VIN [VIN], at approximately 10–15 mph in slow traffic. I applied the brake pedal firmly when the vehicle in front of me slowed, but the vehicle did not decelerate as expected. The vehicle continued moving forward, resulting in a rear-end collision with the car in front of me, which in turn struck another vehicle. Prior to this incident, the vehicle occasionally exhibited brief reductions in forward drive power that were subtle and initially attributed to drive mode (e.g., comfort/eco or battery status). At the time of the incident, the vehicle was subject to Safety Recall 25V-395, but I had not received any recall notification prior to reporting the incident to BMW. This appears to be a potential vehicle safety defect involving braking performance or interaction of propulsion and braking systems, as the vehicle did not stop when brake input was applied under normal conditions. I am reporting this to NHTSA for investigation of a possible safety defect. Related documents, including accident reports, repair invoices, and correspondence with BMW regarding ongoing investigation and requested diagnostics, are available upon request.

Reported

Feb 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

Crash

The backup camera at night is very dark and unsafe. I can barely see anything. It’s a major safety issue even though sensors can warn you, I almost ran over my neighbor while backing out of the garage. My wife has a 2025 X5 that does not have this issue at all. I see online forums where tons of people are complaining about the same issue, making it very unsafe.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

My 2025 BMW i4 has experienced two distinct but related tire safety issues involving abnormal wear and repeated structural failures. Issue 1: Extreme Accelerated Tire Wear The factory-installed tires on my new vehicle were fully worn out in approximately 4 months and ~5,000 miles. All four tires required replacement. This level of wear is far outside normal expectations, including for heavy EVs or performance summer tires, and indicates abnormal loading or alignment behavior. Issue 2: Repeated Structural Failures of Right Rear Tire After replacement tires were installed by the BMW dealer on 12/04, two separate right rear tires developed holes/structural failures within a short period. One failure occurred by 01/09, approximately 30 days after installation, while the tire was nearly new. Damage was located at the inner shoulder/inner sidewall transition area, not consistent with normal tread wear or road damage. The recurrence of structural failure on the same wheel position strongly suggests a localized vehicle-related cause rather than tire defects or driving behavior. The dealer stated there were “no issues with the vehicle” and attributed both problems to normal EV weight and summer tire wear. No documented alignment measurements, wheel runout checks, or suspension diagnostics were provided. After the repeat right rear failure, the dealer proposed reinstalling the same tire type without offering any corrective action. The replacement tires installed were summer-compound tires during winter conditions, which increases brittleness and susceptibility to structural damage on heavy EVs. A nearly new tire developing a hole presents a blowout risk. The combination of extreme accelerated wear of all four tires and repeated structural failure of the right rear tire represents a predictable and ongoing safety concern.

Reported

Jan 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2025 BMW I4 EDRIVE40. The contact stated that while driving at various speeds, the vehicle experienced pulling and skidding to the right. The contact stated that the vehicle became unsafe to drive and was a severe safety hazard to the driver and other motorists. The vehicle was taken to the local dealer, where the failure was replicated. The dealer replaced the tires and performed a front-end alignment, but the failure recurred. The contact stated that the dealer had replaced seven different tires and had performed 2 front-end alignments, but the failure persisted. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 22.

Reported

Dec 2025

Incident date

Dec 2024

Mileage

Not provided

Outcome flags

None reported

Nuna had a major recall for their rava convertible car seats as your organization is aware of. However, there are two main issues that I'm having that Nuna has refused to address nor do they have a viable solution for. The first is that with the recall fix which was new material they sent out, the harness button is covered by Fabric and when the rava is in rear-facing mode it becomes almost impossible to reach the harness release button. Nuna recommended using the leg rest to address the issue, however, the issue does still persist. In a time of emergency, it would be incredibly difficult to get the child out quickly , and normally it is just very difficult. I have attached image so you can understand what I'm talking about. The second issue is that the Fabrics that Nuna has issued for the recall do not match the Fabrics of the original purchased equipment. This is a huge problem because there are now mismatches in fabric types versus inserts and consumers paid for a certain type of fabric and have only gotten the black or the granite as replacements as part of the recall. For the date that these things happen as is required by this form , I've put in and around the date that I received the Fabrics.

Reported

Dec 2025

Incident date

Jun 2025

Mileage

Not provided

Outcome flags

None reported

I am writing to formally report a serious and ongoing safety defect with my BMW i4, present since the beginning of ownership. The vehicle pulls and skids to the right while driving and intermittently swerves, making it unsafe to operate and posing a clear risk to both myself and other road users. This is a safety-critical issue, not a comfort or preference concern. Despite repeated repair attempts, the defect remains unresolved. To date, the following actions have been taken without success: Six (6) tire replacements Two (2) wheel alignments Multiple inspections and service visits at BMW of West St. Louis All work was performed while the vehicle is under warranty, yet I have also incurred out-of-pocket expenses attempting to correct this safety issue. After these failed repairs, I escalated the matter to BMW of North America. A case manager was assigned, but after one initial call, I received no response despite more than seven follow-up emails and three voice messages. Only after I indicated that I would contact consumer protection agencies did BMW respond and offer a little monetary amount credit. I want to be clear that I am not seeking goodwill or compensation. I am seeking a safe and reliable vehicle. Due to the unresolved safety defect and lack of effective support, I no longer feel safe driving this vehicle. I remain loyal to the BMW brand and am willing to purchase another BMW; however, given the repeated failed repairs and ongoing safety risk, I am requesting that BMW repurchase this vehicle and provide a replacement or buyback solution. This matter involves vehicle safety and requires urgent attention. I respectfully request prompt assistance and a fair resolution. Numerous incidents that occurred and tire burst with steering tight and goes on left and right hand side. Documents attached. Two major incidents out of 6: 1st - Car first time swerving: [XXX] - No crash-Fire-Injury-Police Report. 2nd: [XXX] mentioned in additional details.INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Dec 2025

Incident date

Feb 2025

Mileage

Not provided

Outcome flags

None reported

On September 10, 2025, while my son was driving, the lane assist system activated twice during a single drive without a cause. The first activation was manually corrected, but the second caused the vehicle to veer into a roadside barrier. There were no environmental or road condition that would justify the intervention. The vehicle was declared a total loss by our insurance provider. (Please see attached Vehicle Safety Complaint Report pdf for more detail) I am concerned this may reflect a defect in the lane assist system and could pose a risk to other drivers. I am requesting NHTSA investigate whether similar incidents have been reported.

Reported

Sep 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

Crash

While parking the car it accelerated up over the curb and into the bushes in an office parking lot. The sudden unintended acceleration occurred in B mode with the automatic cruise control system setting to follow the posted speed limit when activated. The cruise control was not activated by the driver at the time of incident. The car went from 0mph to full acceleration while the parking distance system was activated. I am reporting this issue to make others aware of the accident, in case a similar issue happens with other cars. The car is new and only has about 250 miles on it at the time of accident. The insurance company has received the initial claims info and is fixing the car. No warning, messages or indicator preceded the accident.

Reported

May 2025

Incident date

May 2025

Mileage

Not provided

Outcome flags

Crash

On March 23, after driving approx 2 miles, I was at a red light. The light turned green and I began accelerating. There was a loud "bang" from under the car toward the rear, the car abruptly halted, the displays turned red with a message (all caps) DO NOT DRIVE. I power cycled the car a few times and the error cleared, but my state-of-charge had dropped from 77 to 59%. I drove the car the 1 mile home and called BMW Roadside Assistance. The rep asked for permission to pull logs from the car, told me he would be sending a flatbed Monday morning and advised me, in no uncertain terms, DO NOT DRIVE THE CAR. I asked if I could pull the car out of the driveway and he said no; he would send skids with the driver. Friday afternoon I was advised there was nothing wrong and to pick up the car. The work order is blaming an LA DWP 50KWh charger I had used 2 days prior to charge from 65 to 81% and recommends avoiding this charger. Just to be clear, I charged 15% on 3/21 and the car went "bang" on 3/23, and that was the fault of the charger.

Reported

Mar 2025

Incident date

Mar 2025

Mileage

Not provided

Outcome flags

None reported