2020 BMW 3 Series

The contact owns a 2020 BMW 330i. The contact stated that upon starting the vehicle, the starter made an abnormal, grinding metal-like sound. The vehicle was taken to the dealer, who diagnosed that the starter had failed. The starter was replaced under NHTSA Campaign Number: 26V056000 (Electrical System); however, the vehicle failed to start one morning post-repair. The message "Engine Cannot Start" was displayed. The vehicle was towed back to the dealer, where it was diagnosed that the starter failure had caused damage to the battery. The dealer informed the contact that the battery needed to be replaced prior to the starter replacement. Additionally, the contact was informed that the transmission harness, signal wire, and ending harness had overheated and needed to be replaced. The manufacturer was made aware of the failures, and a case was opened. The failure mileage was approximately 110,897.

Reported

Jun 2026

Incident date

Mar 2026

Mileage

Not provided

Outcome flags

None reported

It was discovered during a routine check that the alternator for my 2020 BMW 330i with xdrive was dying. The car had around 40,000 miles on it. Alternator was replaced with an aftermarket part.

Reported

Apr 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

Good afternoon. I have called and spoken to my local BMW dealership at Grayson BMW service department many times. As of today they report no remedy and have no idea when a resolution will be available. Filing this complaint (second formal written complaint) due to lack of this not being in any sort of "timely manner." This recall is noted as an URGENT FIRE RISK WHEN PARKED for almost seven months now. I have parked the car outside and through the winter and now getting into the summer. In looking up this recall and reading associated documents, it seems there has been a remedy to many makes and models but still nothing for the 2020 330i, and no word on what to do, advisement, or timeline on resolution. I called the NHTSA hotline but after waiting, decided to attempt another written complaint. Previous complaint #11712900. Thank you, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Apr 2026

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2020 BMW 330I. The contact received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

Reported

Apr 2026

Incident date

Apr 2026

Mileage

Not provided

Outcome flags

None reported

My car was parked at home and hadnt been driven in hours. My neighbor contacted me, saying that my car was on fire. I went outside, and it was on fire, and the fire department was called. After BMW conducted an investigation, they deemed the car fire to be related to the active recall. The manufacturer (BMW) is violating the National Traffic and Motor Vehicle Safety Act (49 U.S Code Section 30120) by refusing a "remedy without charge" for recall 24V-536. A manufacturer is required to provide a remedy for a safety recall "without charge." BMW is offering a loan payoff (21,851.37). This current offer violated this federal statute by forcing me to absorb the loss of my 2500 down payment and accumulated equity. Additionally, Case Management is threatening to revoke my essential transportation (loaner) unless I sign a settlement that omits a verbally promised 4,000 credit buy with non-complaint conditions: it is a restricted discount only valid for future BMW purchases, it was omitted from the legal contract that I am being pressured to sign, and it places burden on me, the victim, to find a replacement vehivle while threaten to revoke my loaner transportation. This is a clear attempt to bypass the federal requirement for a free and complete remedy for a dangerous safety defect. I have attached a picture of the fires along with the fire department report, and the email thread between Case Management of BMW and me. On March 25, 2026, I was offered a loyalty goodwill of 4,000 after the purchase of a BMW from their dealership. March 26, 2026, I was told to contact my loan finance company to inquire about a collateral substitution. After I emailed the CEO and VP of BMW executives, I was then asked about what car I was interested in as a substitute for collateral. March 31, 2026, I am told to coordinate with the dealership as well because the BMW corporation doesn't coordinate with the dealership about the substitution of collateral.

Reported

Apr 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

Fire

The Active Grille Shutter (AGS) system on my vehicle suffered an internal mechanical failure (fault codes 138206 and 138224). These shutters are a critical part of the engine cooling system. Failure of the AGS to operate correctly leads to immediate engine overheating risks, potential sudden loss of power (Limp Mode) in high-speed traffic, and thermal damage to engine components, posing a severe safety hazard. The manufacturer, BMW of North America, has officially acknowledged this defect via Extended Warranty SIB 01 03 25. However, both the local dealer (BMW of Sterling) and BMW of North America corporate office have formally refused to honor this safety-related warranty repair. Despite clear video and photographic evidence showing zero external impact to the vehicle's front end or grilles, both parties claim 'outside influence' without providing any technical proof or documentation of such impact. By refusing to repair a known cooling system defect, the manufacturer and the dealer are forcing a vehicle with a high risk of overheating back onto public roads. This represents a systemic failure to address a safety-critical component under a federally protected warranty

Reported

Mar 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

The contact owned a 2020 BMW 330i. The contact stated that while accelerating from a complete stop and making a left turn, another vehicle, trying to beat the light and driving 60 MPH, crashed into the driver's side of the vehicle. The contact was trapped because the front driver's side door failed to open. The air bags failed to deploy. The police officers delayed their arrival, and a police report was not filed. The contact was in shock. The contact drove to the residence and was able to exit the vehicle through the front passenger's side door. The contact sustained C8-T1 nerve injuries, spinal injuries, and underwent surgery, developed myelopathy, severe PTSD, severe whiplash, and the contact sustained right eye bruises after hitting her eye against the steering wheel. The T1 neck screw that was previously installed in the contact's neck had backed out due to the impact and was replaced. The contact was informed that she nearly sustained paralysis due to the crash impact. The vehicle was taken to an autobody repair shop, and the vehicle was totaled by the insurance company. The dealer was not contacted. The manufacturer was notified of the failure and sent an engineer who performed the vehicle inspection. The manufacturer later sent a letter to the contact, providing an engineering explanation for the air bag's failure to deploy. The failure mileage was approximately 6,500.

Reported

Feb 2026

Incident date

Aug 2024

Mileage

Not provided

Outcome flags

Crash 1 injuries

I am not sure this the the right form for filing my complaint. I was issued a recall letter in November about my car catching on fire. I have seen videos of other BMWs catching on fire. I am not sure if legally I can take it to a mechanic? What if something happens while it is at the mechanic? Legally do I have to take it to the dealership? What if it catches on fire and my neighbors property gets damaged? I have called and email BMW but no response. I need to take my BMW in for other issues but live out in the country, what are we suppose to do? It has been several months. They shouldn’t be allowed to do this. They should replace the vehicle or buy it back. It is dangerous.

Reported

Feb 2026

Incident date

Feb 2026

Mileage

Not provided

Outcome flags

None reported

I own a 2020 BMW 330i xDrive with an open safety recall involving a fire risk related to the engine starter. The recall has been open for approximately five months, and BMW has not provided a remedy or repair timeline. I have been informed that parts are unavailable, and no interim fix has been offered. This defect presents a serious fire hazard, and I do not feel safe operating the vehicle. I am currently pregnant, which increases my concern for personal safety and the safety of my unborn child. Despite the unresolved safety recall, I am still required to make monthly payments on the vehicle. BMW has not provided alternative transportation or sufficient guidance on how to safely manage this situation.

Reported

Jan 2026

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

On November 15th 2025, while driving at highway speed in my lane, the vehicle’s lane assist system applied a sudden and unexpected steering input. I did not command a lane change or steering correction. The steering input caused the vehicle to become unstable, rotate, and spin across the roadway, resulting in a collision with the highway barrier. Prior to the incident, the vehicle had repeatedly failed to install a BMW-issued lane assist software update despite multiple attempts following BMW’s published instructions. BMW dealership personnel were aware of the update failure. The lane assist system remained active and provided no warnings or limitations. Weather conditions changed rapidly due to a brief, unexpected ice storm lasting approximately ten minutes. The vehicle did not provide a warning, restriction, or automatic disengagement of the lane assist system under these conditions. The loss of control occurred immediately following an unexpected steering intervention by lane assist. The loss of control occurred immediately following the steering intervention.

Reported

Jan 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Car manufacturer (BMW) has had a recall (ID 25V636000) for over two months. It requires parking the vehicle outside away from overhanging trees, because of risk of fire. BMW knows what the fix is (replace the starter motor) but has not begun recalling vehicles. Please compel BMW to perform the repair/replacement.

Reported

Jan 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Urgent fire risk when parked recall as of September 23, 2025 and received this safeyy recall letter in November 2025 along with 'remedy is unavailable.' Called local BMW dealership today and no remedy and no clue as to when will be available. Urgent fire risk safety recall that is 4 months without a remedy?! Is this acceptable? And no communication or updates available is very frustrating for a vehicle that is used daily for family, children, and work purposes. Please advise.

Reported

Jan 2026

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2020 BMW 330I. The contact received notification of NHTSA Campaign Number: 25V636000 (Electrical System). The contact had been calling a local dealer for updates on when parts would be available and was advised that the part was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed of the issue. The contact had not experienced a failure.

Reported

Jan 2026

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

Manufacturer unable to remedy recall. No parts available nor timeline of when a replacement will be available.

Reported

Jan 2026

Incident date

Jan 2026

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2020 BMW 330i. The contact received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that while attempting to use the Auto-Start and depressing the accelerator pedal, the vehicle failed to start up as intended. In addition, the contact stated that the Auto-Start button failed to respond while pressed. No warning lights were illuminated. Two local dealers, including BMW of Nashville (1568 Mallory Ln, Brentwood, TN 37027); were contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 34,000.

Reported

Jan 2026

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

The vehicle is subject to an urgent safety recall (NHTSA Recall 25V636 – engine starter fire risk when parked). BMW has confirmed that there is no available remedy and no estimated timeline for repair. Due to the open recall and fire risk warning, the vehicle has been restricted from commercial use and removed from a car-sharing platform, resulting in loss of use. BMW has stated that there is no approved interim repair, workaround, or guaranteed loaner or rental assistance. The recall remains open despite the stated risk of fire when the vehicle is parked, creating an ongoing safety concern and consumer impact.

Reported

Jan 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

The vehicle is subject to an urgent safety recall (NHTSA Recall 25V636 – engine starter fire risk when parked). BMW has confirmed that there is no available remedy and no estimated timeline for repair. Due to the open recall and fire risk warning, the vehicle has been restricted from commercial use and removed from a car-sharing platform, resulting in loss of use. BMW has stated that there is no approved interim repair, workaround, or guaranteed loaner or rental assistance. The recall remains open despite the stated risk of fire when the vehicle is parked, creating an ongoing safety concern and consumer impact.

Reported

Jan 2026

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

Re: 25V-636 We received a recall notice for the above notice over a month ago. No further communication has been sent from BMW in the status of new part availability and they refuse to assist with accommodations because of the scale of the recall. The letter clearly states that there is a fire risk and to not park near structures. This leaves almost everybody who owns affected cars with no option but to put themselves or someone else at risk of this car catching on fire - where else can you park a car that might catch on fire? Its been 4 months since this recall has been issued nationally and no communicated resolution or targetted timing for resolution. Im concerned this recall will potentially start a gigantic car fire and harm someone, their homes, or their neighbors' property. I find it completely unacceptable that there's not even clear resolution timing for this problem which is essentially a ticking time bomb. People with these cars need help beyond what we're able to do as individuals. Thanks, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Dec 2025

Incident date

Nov 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2020 BMW 330i. The contact received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure.

Reported

Dec 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

Within days of purchasing the vehicle, multiple warning lights and safety-related alerts appeared, including repeated check engine warnings, an alert stating “Driver Assistance Support Reduced,” and a wrench indicator referencing an auto lighting and wiping system malfunction. While driving, the vehicle felt unstable and would sway side to side, making it difficult to maintain confident control. The vehicle was brought in for service shortly after purchase due to these concerns and was removed from my possession because of the seriousness of the issues. During the service process, I was informed that the vehicle had previously been involved in an accident and that a critical structural safety component (the front crash bar) was damaged. This damage had not been disclosed prior to purchase. The crash bar is a key part of the vehicle’s body structure designed to absorb impact and protect occupants in a collision. Driving a vehicle with damage to this component posed a potential safety risk. The combination of structural damage, reduced driver assistance alerts, visibility system warnings, and unstable handling raised concerns about crash protection, vehicle control, and overall safety. The issues were identified by the selling dealer during inspection after the vehicle was returned for service and are available for further inspection if requested.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

I own [XXX] BMW vehicle affected by a safety recall for a defective engine starter relay that may corrode, overheat, and cause a fire. The recall notice dated November 2025 states the vehicle is not safe to drive, with no remedy available, rendering it unusable and hazardous. Recall N0.25V-636. Under Kansas Lemon Law (K.S.A. 50-645 et seq.), I am entitled to a refund or replacement for this substantial defect impairing use, value, and safety, which BMW cannot repair. I demanded a full buyback at original purchase price, including fees, taxes, and incidental costs, or a comparable replacement. I requested a response within 10 business days. I sent this demand in November 2025 and have heard nothing since. The statute of limitations for lemon law claims in Kansas is four years from defect discovery, per UCC provisions for warranty breaches. If unresolved, I want to pursue legal action for breach of warranty, lemon law violations, and negligence, seeking damages, fees, and costs. Please investigate BMW's handling of this recall and failure to respond. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Dec 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2020 BMW 330I. The contact received a recall notification NHTSA Campaign Number: 25V63600 (Electrical System); however, parts for the recall repair were not yet available. The vehicle was taken to the dealer, and the contact was informed that parts were not available. In addition, the contact was informed that the parts would not be available for another two to ten months. The contact stated that the recall notification indicated a fire risk, which was extremely concerning. The manufacturer was not contacted. The contact had not experienced a failure.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

We have been notified that there is a recall and fault in the ignition. BMW says they don't have the parts for a repair and will not provide a loner car.

Reported

Dec 2025

Incident date

Dec 2025

Mileage

Not provided

Outcome flags

None reported

Defective airbag wiring harness for the passenger seat. The car is giving a warning; it has never been in any accident. The dealer refuses to cover repair expenses.

Reported

Nov 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2020 BMW 330I. The contact received notification of NHTSA Campaign Number: 25V636000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Reported

Oct 2025

Incident date

Sep 2025

Mileage

Not provided

Outcome flags

None reported

The Oil filter housing on my BMW 330i failed randomly while driving causing my vehicle to be depleted off coolant within seconds. If you want to inspect the part you will have to reach out to bmw of Columbus for documentation and I can provide the service records for repair. This caused my vehicle to have to be brought to an immediate halt to not cause overheating or engine destroying failure at a time where service/repair isn’t available. There were no warning lights or leaks prior to the vehicle malfunctioning all at once. I ubered to get coolant and once filling the reservoir the coolant immediately leaked out resulting in me needing a tow to the dealership. This problem has been reproduced with many dealers as there’s numerous of report of this online and I believe the dealer has inspected this part but is refusing to replace or recall this part under any type of program or create any type of solution to make this not happen again. There wasn’t any small leaks or warning lights shown before this issue spawned all at once then showing the low coolant light.

Reported

Jul 2025

Incident date

Jun 2024

Mileage

Not provided

Outcome flags

None reported

While driving, my 2020 BMW 330i suddenly entered “drivetrain limited power” mode, severely restricting acceleration and overall performance. Upon diagnostic review, the cause was found to be a failure of the Heat Management Module (HMM). This created a hazardous situation as the vehicle unexpectedly lost power while merging into highway traffic. Researching online, I’ve discovered numerous reports from other BMW owners experiencing the exact same failure on this model and other recent 3-series vehicles. This component failure is both common and costly, and yet there has been no recall or formal action from BMW to address it. Worse, the HMM is not covered under third-party powertrain warranties because it is considered an electronic part, leaving many owners with unsafe vehicles and no support. Given how widespread this issue appears to be — and the serious safety risk posed by sudden engine power loss — I urge the NHTSA to investigate this component for a potential recall or required manufacturer remedy.

Reported

Jun 2025

Incident date

May 2025

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2020 BMW 330I. The contact stated while his wife was pulling into the yard, the engine overheated and the vehicle stalled. The contact stated that the message "Engine Compartment Overheating" was displayed. The vehicle was towed to Billy's Imports Service, where the spark plug wires, the engine oil filter, the PCV system, the hoses, the injectors, the O-rings, and the valve cover gasket were replaced. The vehicle was repaired. The dealer was not notified of the failure. The contact later received notification of BMW Campaign Number: 15Y150M, which the contact related to the failure. The manufacturer was contacted for reimbursement; however, the contact was advised that no assistance could be provided because the vehicle had exceeded the 150,000-mile limitation. The failure mileage was 156,894.

Reported

May 2025

Incident date

Feb 2025

Mileage

Not provided

Outcome flags

None reported

Motor mounts collapse

Reported

Apr 2025

Incident date

Mar 2025

Mileage

Not provided

Outcome flags

None reported

Failed Component: Driver Side (Left) Exterior Mirror Available for Inspection: Yes Safety Risk: The mirror does not stay securely unfolded, requiring manual adjustment while driving, which creates a major distraction and increases the risk of an accident. If not manually secured, it shifts unpredictably due to wind resistance at city speeds, creating a dangerous blind spot that makes lane changes and merging hazardous. Glass isn't adjustable with buttons.The heating function is non-operational, which may impact visibility in cold/wet conditions. Problem Reproducibility: The issue is persistent. Dealer or Independent Confirmation: The problem has not been diagnosed by a dealer, but has been check for DTC and there are no faults. Multiple reset attempts have been performed, including iDrive reset, manual folding/unfolding, and a BMW battery reset procedure, CLS was allowed to shut down fully, with no resolution Inspection by Manufacturer, Police, or Insurance: No Warning Lamps or Symptoms Prior to Failure: None. The mirror was working perfectly before it failed suddenly with no warning signs, noises, or gradual malfunction. No known fault codes prior to the issue. Additional Details: The mirror does not respond to electronic adjustments and must be manually repositioned. The glass will not adjust either unless by hand. When fully open or fully folded manually, makes a loud, forceful clunk and becomes slightly harder to move, but can still be adjusted moved with some effort. It opens far past the normal open position. In any other position other than fully extended or fully closed, it moves freely due to any external forces such as wind force while driving or lightly pushing it. The passenger-side mirror functions normally, including folding, heating, and glass adjustment. No OBD error codes, warning lights, or system messages have appeared related to the failure. Mirror has not had any physical damage or abuse in any manner.

Reported

Feb 2025

Incident date

Jan 2025

Mileage

Not provided

Outcome flags

None reported

Engine coolant leaking and took it to BMW dealer. Was advised that the issue was a oil filter housing gasket, heating control module and hose. Was advised by the Dealer that it was a common issue and happens all the time

Reported

Jan 2025

Incident date

Dec 2024

Mileage

Not provided

Outcome flags

None reported

The vehicle has persistent issues with its software and safety systems, creating significant safety risks. The Remote Software Upgrade feature fails to install, despite indicating it is “ready to install” with preparations complete. This prevents critical updates that could address safety and performance defects. BMW Customer Support was unable to resolve the issue, and a local dealership confirmed no hardware faults but could not address the software issue due to limitations as a non-BMW-certified service center. Several critical safety features also do not function properly. The Blind Spot Warning system has never issued alerts, leaving the driver unaware of vehicles in adjacent lanes. The Forward Collision Warning system has never activated, even in close proximity to other vehicles. The Lane Departure Warning fails to consistently activate, while Lane Keeping Assistance operates only intermittently, despite being designed to engage above 40 mph. Additionally, the Parking Collision Warning and Rear Cross Traffic Warning systems have never provided alerts, even when obstacles or approaching vehicles are present. These malfunctions severely compromise the vehicle’s ability to prevent accidents and ensure safety. The vehicle also intermittently displays drivetrain failure warnings, stating the car can still be driven but should be serviced. Upon inspection, no issues were identified. Consistent fault codes for the active kidney grille shutters appear, but no check engine light is illuminated. These recurring warnings create uncertainty about the vehicle’s reliability and the accuracy of its diagnostics. The combination of these issues places the driver, passengers, and others at risk. A thorough investigation is needed to identify and resolve the root causes. All systems are available for inspection upon request.

Reported

Jan 2025

Incident date

Jan 2025

Mileage

Not provided

Outcome flags

None reported

I started my vicheal up and turned the heater on on my 330i 2020i bmw I sat there for about 15 mins and noticed a smoke smell I stepped out my car and realized my car was on fire! No sensors went off saying car had any issues regarding coolant or engine oil or anything so I have zero idea what started my car fire Police and fire rescue was there Fire investigation is making a report an insurance representative will be inspecting From what I see online bmw was been having issues with 3 series randomly catching fire either by faulty water pump? By a short circuit? The vicheal is completely totaled my safety was at risk if I wouldve started driving and didn't notice it would've been way wrose than what happened unsure where insurance will be taking the vicheal to

Reported

Jan 2025

Incident date

Jan 2025

Mileage

Not provided

Outcome flags

Fire

Error in vehicle computer software causing check engine light to show error in active grill position sensor, could lead to engine not properly cooling. Manufacturer error.

Reported

Dec 2024

Incident date

Dec 2024

Mileage

Not provided

Outcome flags

None reported

The drivers side front tie rod buckled while backing into a parking space at less than 5mph. This vehicle had pulled out of our home garage and driveway just 5 minutes prior to tie rod buckling. The car was fully operational with no steering issues. NO IMPACT had taken place in the time from garage cam video until vehicle was pulling into a parking space and steering was off for one tire. Vehicle could not steer correctly to be parked so we had it towed to Hafkemeyer Motors. Before the vehicle arrived they told us it sounded like a tie rod was broken, which is likely due to impact. NO IMPACT occurred. Upon inspection of the vehicle, two separate technicians agreed this vehicle has no signs of any impact. This tie rod appears to have buckled for no reason. They reported that 2018-2019 model years of this same vehicle had a tie rod defect which resulted in a recall and replacement. With no evidence of any impact, they recommended replacing the both front drivers and passenger side tie rods because they feared the same thing could happen to the other side. We have video of the vehicle leaving home 5 minutes before the buckle happened and the vehicle was operational with no steering issues at all. Mechanic took photos of the undercarriage of the vehicle to show buckled tie rod and lack of any evidence of impact to the vehicle. They also noted in their reporting system what was observed and replaced. We believe this recall may need to be expanded to include additional model years or vehicles with this same tie rod defect. This car has less than 50K miles and no crashes or impact. This tie rod should not have buckled like this. Show below are photos of both front tie rods as well as mechanic notes and receipt for work done. I cannot upload the video of the operational vehicle, but it can be viewed in my DropBox folder here: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Reported

Dec 2024

Incident date

Dec 2024

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2020 BMW 330I. The contact stated that while driving at an undisclosed speed, the vehicle shuddered with an abnormal sound coming from underneath the vehicle. The vehicle was taken to a local independent mechanic where it was diagnosed that the bearing and motor mount needed to be replaced. Upon further investigation, the contact stated that the failure was related to NHTSA Campaign Number: 19V732000 (Engine); however, the VIN was not included. The local dealer was contacted, but the vehicle was not diagnosed or repaired because the VIN not included in the recall. The manufacturer was made aware of the failure. The failure mileage was approximately 80,000.

Reported

Aug 2024

Incident date

Aug 2024

Mileage

Not provided

Outcome flags

None reported

Over time, the wiring harness going to the knee air bag(s) can rub against the metal support tubes for the instrument panel, chafing and damaging the wiring. SIB 65 20 22

Reported

Aug 2024

Incident date

Aug 2024

Mileage

Not provided

Outcome flags

None reported

It's been about 3 weeks since the most BMW recent software update, (11/2023.50) has downloaded to my vehicle via the BMW connected drive services. This is the second time that over the air, BMW connected drive upgrades have failed to install on my vehicle. As before, the upgrade has downloaded to the automobile but will not activate as has happened successfully in the past. The above upgrade is supposed to solve a safety/visability problem, a stated legal requirement, pertaining to the position of the heads up display. I have consulted with BMW customer relations and Technical advisors. I received and followed several sets of recommended self-install procedures without success. I was the advised to contact my BMW Service Center in Seattle who would be able to install the update. However, they, in turn, advised me the problem was related to a weak battery. My local mechanic subsequently test the batter and indicated no discernible problem and no current need for its replacement. I’ve seen a variety of internet comments indicating other owners with similar unresolved problems with the BMW system. There appears to be no hardware or direct software install alternative. There is nothing like a recall in place to solve this problem. Given this latest update is required in part to meet safety requirements related to the vehicle heads up display, I am hoping your assistance will resolve this matter quickly. Thank you in advance -

Reported

Aug 2024

Incident date

Jul 2024

Mileage

Not provided

Outcome flags

None reported

Passenger safety restraint system warning occurred. meaning passenger air bag is not effective. Upon searching internet for the problem I realized this has been a common issue with BMW's for years. It is a very expensive fix and is a safety hazard. My dealership wants $2700 to fix the pressure sensor in the passenger seat. Until I can get this fixed I am not going to transport any passengers in the front seat, just to be safe.

Reported

Jun 2024

Incident date

May 2024

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2020 BMW 330i. The contact stated that the headlight housings would become foggy whenever it rained. The contact stated that the failure had caused the low beam lights to be diffused and to fail to illuminate the roadway beyond 15-30 feet. The vehicle was taken to the dealer with photos of the foggy headlight housings, but the dealer informed the contact that they could not replicate the failure because the headlight housings were clear the time. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 34,000.

Reported

Mar 2024

Incident date

Feb 2024

Mileage

Not provided

Outcome flags

None reported

The lower active grill on my 2020 BMW 330i failed. I purchased the vehicle on January 24th. On February 27th, the check engine light came on. I called the dealership I bought it from. They told me they did not have the necessary technology to diagnose, so I took it to a BMW mechanic. The mechanic told me it is a known warranty issue with this particular BMW, and that BMW should fix it for free under the limited warranty bulletin. When I tried to contact BMW about this issue, they refused to pay for it stating that my specific VIN number was not affected by this issue, and therefore they wouldn't pay for it. This makes no sense seeing as it is a clearly known issue with an active bulletin out for the same exact year make and model as my vehicle. The production clearly did not change enough to fix the issue, so my vehicle should be included in the limited warranty/recall. The flaps can get stuck closed, which can cause the car to overheat quickly, which can be extremely unsafe. BMW refused to even look at the vehicle to see if the issue was in fact the warranty issue without me paying a $250 diagnostic fee, when I had just paid to have it diagnosed at a different BMW mechanic.

Reported

Mar 2024

Incident date

Mar 2024

Mileage

Not provided

Outcome flags

None reported

Both the UPPER and LOWER active grille shutters for most BMW models in the 5 model years prior to mine had extended service warranties due to frequent failures of the part. It appears that the design was not improved with my model year and yet my vehicle is NOT part of the extended warranty. My vehicle is only 4 years old and BOTH the upper and lower air flap control motors have failed. The motors are not sold individually, but are sold as a part of the entire shutter assembly which has a part cost of $250 - $350 each with comparable installation costs. The lower shutter assembly requires the removal of the entire bumper. Why is the extended service warranty not applicable to newer models?

Reported

Jan 2024

Incident date

Jun 2023

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2020 BMW 330I. The contact stated while driving approximately 65 MPH, there was a loud boom that came from the sunroof. The contact pulled over and noticed that the sunroof had shattered. The contact had not taken the vehicle to the dealer. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 75,000.

Reported

Sep 2023

Incident date

Sep 2023

Mileage

Not provided

Outcome flags

None reported

I have been in the motorcycle industry 1988-2000 and the auto industry since 2000 to current, a break for about 10 years in there. I am fairly mechanically knowledgeable. On 8/1/2 was showing a customer a BMW 330I that we had in inventory. The customer sat in the driver's seat, started the engine and popped the primary hood latch. I was at the front on the vehicle. Since I deal with every make, model and years finding the secondary latch release can be challenging. Initially, I felt under the hood at the center, not finding it I proceeded to feel my way down both sides of the hood. Still not finding the release I inserted my right hand into the grill at first grill opening center right (drivers side). I was feeling inside to find the elusive release. About 1-2 seconds of feeling around I felt the a pressure against my hand. There isn't much space in the grill openings and very quickly I could not remove my hand in time, it was pinched between the vertical grill vent and, at that point unknown, active grill venting. My hand was stuck and the active grill venting continued to close since it indicated the cycle was not complete. I was stuck and it was very painful. My right was stuck in the first opening and I tried to overpower the electric motor with my left hand on the second grill opening (drivers side) I could not overpower it. I slowed it but it continued trying to close. I told the customer that I was stuck and in pain and that I needed help. I could not pull hand out since it was never intended to have a hand in there, the edges where sharp plastic on the inside, almost like a barb. It took me, being one handed and both his hands pushing on the vents to over power the system. Without the second adult male, I was trapped. Issues: 1. excessively overpowered 2. no reverse sensor like auto up passenger windows 3. no break-away safety system

Reported

Aug 2023

Incident date

Aug 2023

Mileage

Not provided

Outcome flags

1 injuries

The check engine light comes on every time there is low fuel in tank. BMW will not address the issue even though there is previous recalls on earlier years. Please recall before someone is hurt or killed.

Reported

Apr 2023

Incident date

Apr 2023

Mileage

Not provided

Outcome flags

None reported

Car was t-boned by another vehicle at 65-70 MPH (other driver was cited as negligent and responsible for accident)—and other driver’s car caused damage to the BMW and driver (my daughter) due to the side airbags on the BMW not deploying (damage to daughter would have been significantly less had the BMW side airbags deployed as they should have upon impact).

Reported

Mar 2022

Incident date

Mar 2022

Mileage

Not provided

Outcome flags

Crash 2 injuries

I do not know What component or system failed or malfunctioned, the car is available for inspection upon request. The car started and moved forward with no driver or passenger inside and stopped because it hit my garage door from which it was parked 3 feet from before it moved forward driverless. A car which moves by itself is unsafe because it can hit a person or object. to date, 8/11/2021 the problem has not been reproduced or confirmed by a dealer or independent service center? The car has not been inspected. Today a message from BMW initiated an inspection appointment at the dealer. Problem occurred without warning.

Reported

Aug 2021

Incident date

Jul 2021

Mileage

Not provided

Outcome flags

None reported

The contact owns a 2020 BMW 330i. The contact stated that while he was sleeping, the vehicle was parked outside of the garage and had started itself without the key in the ignition then drove itself and crashed into the aluminum garage door. The contact was aware of the failure when he went inside the garage and heard the engine running but could not open the garage door. When the contact went outside, he saw that the vehicle had crashed into the garage door with the engine still running and the headlights were on. A police report was filed. The dealer was contacted but had not returned the contact's phone call. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The failure mileage was 17,218.

Reported

Jul 2021

Incident date

Jul 2021

Mileage

Not provided

Outcome flags

Crash

TL* THE CONTACT OWNS A 2020 BMW 330I EQUIPPED WITH CONTINENTAL TIRES, TIRE LINE: PROCONTACT GX SSR, TIRE SIZE: 225/45/R18. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE AND THE FRONT AND REAR PASSENGER'S SIDE TIRES FAILED. THE CONTACT STATED THAT THE FRONT DRIVER'S TIRE HAD A BUBBLE ON SIDEWALL AND THE REAR PASSENGER TIRE WAS CRACKED ON SIDE WALL WHILE THE FRONT PASSENGER'S SIDE TIRE EXPERIENCED A BLOWOUT. THE VEHICLE WAS TOWED TO RALLYE BMW (1 BRUSH HOLLOW RD, WESTBURY, NY 11590, (516) 393-0000) WHERE IT WAS DIAGNOSED WITH NEEDING 3 TIRES TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 10,000. THE VIN WAS UNAVAILABLE.

Reported

Apr 2021

Incident date

Apr 2021

Mileage

Not provided

Outcome flags

None reported

TL* THE CONTACT OWNS A 2020 BMW 330I. THE CONTACT STATED THAT THE ENGINE COOLANT LOW WARNING LIGHT ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO RALLYE BMW (1 BRUSH HOLLOW RD, WESTBURY, NY 11590; (516) 393-0000) WHO CONFIRMED THEM THAT THE COOLANT LEVEL WAS LOW. THE DEALER STATED THAT THE HEAT MANAGEMENT MODULE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE DEALER ALSO DISCOVERED THAT COOLANT HAD LEAKED INTO THE OIL FILTER HOUSING AND THE HOUSING WAS DAMAGED. THE MECHANIC REPLACED THE OIL FILTER HOUSING, ADDED OIL, AND FLUSHED THE COOLANT. THE CONTACT RETURNED THE VEHICLE TO THE SAME DEALER. THE DEALER BLED AND CHECKED THE COOLING SYSTEM AND FOUND NO LEAKS. THE DEALER TOPPED OFF THE COOLANT LEVEL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OPENED A CASE. THE APPROXIMATE FAILURE MILEAGE WAS 3,142.*DT*JB

Reported

Oct 2020

Incident date

Sep 2020

Mileage

Not provided

Outcome flags

None reported