2018 Volkswagen Tiguan inspection checklist

The records describe a possible fatal outcome.

“Engine keeps failing and dings while driving non-stop. Causes the vehicle to think there is another vehicle near me and activates the emergency braking in the middle of the highway almost causing me to crash. I have taken the vehicle to dealer and told it is fixed about 8 times now”

The records describe a problem worth checking before purchase.

“First purchased this car from a dealership in 2023, used at128,051 miles. Did not have any problems with it in the first year I would say. Then suddenly while driving down the road the epc light would come on limiting my speed to 4,000 rpm. It would come on and off also causing my check engine light to come on and off. It has now become more frequent, the epc and check engine lights will come on and off creating a major hazard while driving. Got it scanned while the check engine light was on and it ran a code for a cylinder 4 engine misfire from my fuel injector wiring rail harness. It looks to be a common problem with this model but it’s showing my vin is not attached to a recall.”

The records describe a possible crash, fire, injury, or loss of control.

“Seat Belt Webbing Failure In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA Research Corp. (MGA) in Wisconsin and December 13, 2017, at the Transportation Research Center (TRC) of Ohio.During both crash tests, the driver seat belt webbing completely separated at the point where the webbing loops through the Crash Locking Tongue (CLT). In both NCAP tests, the dummy injury criteria requirements, as set forth in Federal Motor Vehicle Safety Standard (FMVSS) 208, were met with one exception. The chest deceleration G force requirement was exceeded in the test conducted at TRC. The FMVSS 208 injury criteria requirement for the chest deceleration is 60 Gs and it was measured at 67 Gs in the test conducted at TRC. It should be noted, FMVSS 208 does not include a requirement that the seat belt webbing remain intact during a frontal collision to comply with the standard. Compliance with the standard is based on the dummy injury criteria.Further, the Agency has conducted NCAP testing with no substantial protocol changes for over forty (40) years. This includes tests conducted prior and subsequent to the subject NCAP tests. During that time there has not been a similar failure of the seat belt webbing in any other NCAP tested vehicle manufactured by VW or another manufacturer.In November 2020, VW filed a defect notice (20V-724/69BH) that recalled seat belt systems, both driver, and front passenger, that were manufactured with webbing from the same lot as the two NCAP tested MY2018 Tiguan vehicles. VW has tested and inspected several of the returned seat belt systems and found no anomalies in either the webbing or the CLT that would substantially affect system performance in a frontal collision.The Office of Defects Investigation (ODI) estimates that between 2000 and 3500 frontal collisions involving MY2018 VW Tiguan vehicles have occurred in the field during the time these vehicles have been in service. This estimate is based on vehicle population and an estimated yearly rate of severe frontal collisions.A severe frontal collision is defined, in this instance, as being of sufficient severity to warrant a commanded deployment of the frontal air bags. These collisions would place a significant load on the seat belt system similar to loads experienced during the NCAP tests. To date, neither ODI nor VW is aware of any frontal collision in the field that resulted in separation of the seat belt webbing. ODI believes that had any field collisions involved separation of the seat belt webbing, the Agency would have been notified.In view of the recall being conducted by VW, and lack of field data demonstrating a system defect, ODI is closing this Engineering Analysis (EA). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.”

The records describe a possible crash, fire, injury, or loss of control.

“Seat Belt Webbing Failure In December 2017, NHTSA conducted two New Car Assessment Program (NCAP) tests on the 2018 MY Volkswagen (VW) Tiguan. Both tests were 35 mph, full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front-passenger position. The tests were conducted on December 8, 2017 at MGA Research Corp. in Wisconsin (MGA) and December 13, 2017 at the Transportation Research Center of Ohio (TRC).During both crash tests, the driver seat belt webbing completely separated in tension where it looped through the seat belt latch tongue (see attached photos). Based on its analysis of the NCAP test results, VW asserted that the test dummy umbilical cord exerted additional forces on the seat belt system causing the separation. To support this theory, VW conducted several sled tests.The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE18-001) on 01/10/2018 to evaluate the two (2) incidents of seat belt separation. ODI and NCAP reviewed the sled test data submitted by VW in support of their theory. Micro analysis, conducted by the Materials Laboratory at the National Transportation Safety Board (NTSB), verified the seat belts failed in tension and not due to cuts or abrasion.PE18-001 has been upgraded to an Engineering Analysis (EA18-005) to further examine seat belt behavior in the subject vehicles and to determine, among other things, a root cause for the seat belt separation. ODI will perform a thorough review of any vehicle and seat belt design changes for the new 2018 MY Tiguan platform and their effects on the performance of the seat belt system.”

The records describe a possible crash, fire, injury, or loss of control.

“Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan long wheel base (LWB) vehicles. The back-up lights in the taillight assemblies may not be bright enough. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment." If the back-up lights are not bright enough, other drivers may not see the vehicle reversing, or the driver may back into an obstacle, increasing the risk of a crash. Volkswagen will notify owners, and dealers will replace the affected inner taillight assemblies, free of charge. The recall began December 15, 2017. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 94J9.”

The records describe a possible crash, fire, injury, or loss of control.

“Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2018 Tiguan Limited vehicles. The front driver air bag installed on these vehicles may not be intended for use in vehicles sold in the United States. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection." In the event of a crash, the incorrect air bags may not protect the driver as intended, increasing the risk of injury. Volkswagen will notify owners, and dealers will replace the steering wheel and front driver air bag module, free of charge. The recall began May 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69V2.”

The records describe a possible crash, fire, injury, or loss of control.

“Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan long wheel base (LWB) vehicles. The engine support bolts on these vehicles may not have been properly tightened. If the engine support bolts were not properly tightened, an unexpected engine breakdown or loss of engine power may occur, increasing the risk of a crash. Volkswagen will notify owners, and dealers will replace engine support bolts, free of charge. The recall began March 26, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 10F7.”

The records describe a possible crash, fire, injury, or loss of control.

“Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan long wheelbase (LWB) vehicles. A lower loop of a rear shock absorber may separate from its base due to an incorrect welding process If the lower loop of the rear shock absorber detaches, there may be a loss of vehicle control, increasing the risk of a crash. Volkswagen will notify owners, and dealers will inspect the rear shock absorbers, replacing them as necessary, free of charge. The recall began May 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42i7.”

The records describe a possible crash, fire, injury, or loss of control.

“Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan and Tiguan long wheel base (LWB) vehicles. The nut that holds the lower ball joint of the front wheel on each side of the vehicle may be loose or improperly tightened. A loose or improperly tightened ball joint nut can result in the separation of the lower ball joint causing steering, traction or other stability issues, increasing the risk of a crash. Volkswagen has notified owners, and dealers will replace the nut on the lower ball joint and, as necessary, clean the thread in the ball joint, free of charge. The recall began May 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 40N4. Note: owners are advised not to drive their vehicle until the recall repair has been performed.”

The records describe a possible crash, fire, injury, or loss of control.

“Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Atlas and Tiguan vehicles. In the event of a crash, the passenger frontal air bag may tear or not properly unfold during deployment. If the air bag were to tear or unfold incorrectly during deployment, it can increase the risk of injury. Volkswagen will notify owners, and dealers will replace the passenger frontal air bag, free of charge. The recall began July 19, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 69W8, and 69W9.”

The records describe a possible crash, fire, injury, or loss of control.

“Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan vehicles. The LED module for the panoramic sunroof ambient light bar may short circuit. A short-circuit can increase the risk of a fire. Volkswagen will notify owners, and dealers will disconnect the power supply for the panoramic sunroof LED module, free of charge, until a future service action can safely reactivate the feature. The recall began July 24, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall 60D1.”

The records describe a possible crash, fire, injury, or loss of control.

“Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas and Tiguan and 2019 Volkswagen Jetta vehicles that do not have keyless entry. The instrument cluster may not provide an audible warning to let the driver know that the key is still in the ignition when the door is open. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection." If the driver is not notified by an audible noise that the key is left in the ignition, it can increase the risk of vehicle theft or crash. Volkswagen will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began December 13, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 90L3 and 90L4.”

The records describe a possible crash, fire, injury, or loss of control.

“Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Golf Sportwagen, 2019 Jetta, 2015-2019 Golf, and 2018-2019 Tiguan vehicles. The rear coil springs may prematurely fracture. If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash. Volkswagen will notify owners, and dealers will replace the rear axle coil springs, free of charge. The recall began April 12, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J5.”

The records describe a possible crash, fire, injury, or loss of control.

“Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Volkswagen Passat, 2018 Tiguan LWB, 2007-2009 Jetta Sedan, 2011-2013, 2015 and 2019 Jetta, 2013 Jetta Hybrid, 2008-2009 Jetta Sportwagen, 2015 Golf Sportwagen, 2013 Golf, 2008-2010 and 2012-2013 Beetle and Beetle Convertible, 2008-2010 Beetle, and Beetle Convertible vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements. If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury. Volkswagen will notify owners and repurchase the affected vehicles. The recall began November 6, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01D7. Note: This recall is an expansion of NHTSA recall number 18V-329.”

The records describe a possible crash, fire, injury, or loss of control.

“Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan LWB vehicles. In the event of a crash, one or both of the front seat belt's webbing may tear. A torn seat belt may not adequately restrain the seat occupant during a crash, increasing their risk of injury. Volkswagen will notify owners, and dealers will inspect the front seat belts and replace them as necessary, free of charge. The recall began April 13, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69BH.”

The records describe a possible crash, fire, injury, or loss of control.

“Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan vehicles. During the repair of roof damage, an incorrect roof reinforcement assembly may have been installed. The incorrect roof reinforcement may decrease the roof's structural integrity or impact deployment of the side curtain air bags, increasing the risk of injury in the event of a crash. Dealers will be replace the roof reinforcement, free of charge. Owner notification letters were mailed November 19, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 51H5.”

The records describe a possible crash, fire, injury, or loss of control.

“Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2022 Tiguan and 2018-2021 Tiguan long wheel base (LWB) vehicles. Due to incorrect installation instructions, the accessory rear hatch spoiler may be insufficiently attached to the vehicle. An insufficiently attached spoiler may separate from the vehicle, becoming a road hazard and increasing the risk of a crash. Dealers will replace the spoiler, free of charge. Owner notification letters were mailed June 3, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 66N5.”

The records describe a problem worth checking before purchase.

“This Document informs dealers on VWP-18-11 for the Steering Wheel Clock Spring Limited Warranty Extension ”

The records describe a problem worth checking before purchase.

“Service Action - Front Brake Pad Noise”

The records describe a problem worth checking before purchase.

“This Document informs dealers on the Sunroof Class Action Limited Warranty Extension”

The records describe a problem worth checking before purchase.

“This Document informs dealers on the Sunroof Class Action Limited Warranty Extension FAQ for commonly asked questions”

The records describe a problem worth checking before purchase.

“This Document informs dealers on the Sunroof Class Action Limited Warranty Extension FAQ for commonly asked questions. Revised to include info on how to proceed with vehicles not applicable to the 60E2/60E5.”

The records describe a problem worth checking before purchase.

“This Document informs dealers on the Sunroof Class Action Limited Warranty Extension revision. Revised to include info on how to proceed with vehicles not applicable to the 60E2/60E5.”

The records describe a problem worth checking before purchase.

“These documents are for the Automatic Emergency Braking (AEB) Limited Warranty Extension as part of the Class Action Settlement”