2019 Hyundai Tucson reported problems

The records describe a problem worth checking before purchase.

“I have noticed that the engine oil level in my vehicle drops significantly between regular oil changes. Despite adhering to the manufacturer's recommended maintenance schedule, I frequently have to add a quart of oil after driving only about [800~1,000 마일] miles.I understand that this is a widely reported issue with Hyundai Owners Forum affecting 2019 models. Many experts and fellow owners have identified that this rapid oil loss is often caused by manufacturing defects, such as faulty piston rings, which can eventually lead to catastrophic engine failure.As a Hyundai owner, I am highly concerned about the safety, reliability, and decreased resale value of my vehicle. Running low on oil without warning creates a high risk of sudden engine breakdown while driving on the highway.I kindly request that Hyundai Corporate or my local authorized dealer investigate and resolve this matter. Specifically, I am asking for:An official engine inspection and a proper Oil Consumption Test.Necessary repairs or a full engine replacement under the applicable powertrain warranty at no cost to me.”

The records describe a problem worth checking before purchase.

“The vehicle will not get to highway speed causing it to impede traffic and presenting a safety risk for collision.”

The records describe a problem worth checking before purchase.

“The contact owns a 2019 Hyundai Tucson. The contact stated while driving at an undisclosed speed, the contact noticed an abnormal sound and the engine seized. The check engine warning light illuminated. The contact stated that while attempting to start the vehicle, the vehicle started. The failure reoccurred. The contact stated while attempting to start the vehicle, the vehicle started and the engine spuddered. The vehicle was towed to an independent mechanic where it was diagnosed with a failed engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact was advised to take the vehicle to the dealer. The vehicle was towed to the dealer where it was diagnosed with a failed engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact was advised to take the vehicle to the dealer for diagnostic testing. The contact was later informed that the repair was not covered under the recall because of open recalls associated with the contact's VIN. The failure mileage was approximately 81,000.”

The records describe a problem worth checking before purchase.

“I purchased this vehicle from CarMax about 5 months ago. It had 74,XXX miles. CarMax showed no open recalls and a printed sheet from your site showing the same. Several weeks ago, while driving, the engine seized. I sent it to one of the local Hyundai dealers for repair. Hyundai said because recall Campaign #966 had not been performed, they would not replace the engine under the extended warranty. When I purchased the vehicle, I had the foresight to purchase an extended warranty from Assurant. Eventually I found they will cover the repair. I have to pay the $600 deductible, plus a $350 labor charge for diagnostic work. Here is my problem, CarMax told me there was no open recalls (based on your web site), and I counted on CarMax having an accurate knowledge about this when I purchased the vehicle. This is particularly disturbing because in 2022 CarMax settled out of court with 30+ states in part, for failure to disclose open recalls on vehicles they sold. True, I could have checked myself, but how did your entity report no open recalls on this VIN, and CarMax reported no open recalls on this VIN, but Hyundai was aware of the open recalls, and denied an engine warranty repair because the recall campaign had not been completed? There are two other open campaigns, # 933 and #P33 as well. The Hyundai dealer is going to perform these recalls after the repair. To summarize, I purchased this vehicle in good faith that the information provided on the NHTSA sheet, and the CarMax sheet were correct there were no open recalls. My bank financed the auto under the premise it was a safe reliable risk for them. Now, I'm going to be out $950 plus rental car expenses I've already paid. Please contact me if you have more questions.”

The records describe a problem worth checking before purchase.

“2019 Hyundai Tucson experienced catastrophic engine failure, including internal damage. Vehicle previously had Hyundai Campaign 966 (engine monitoring logic) completed. Despite this, engine failed without sufficient warning. Concern that prior campaign did not prevent engine failure”

The records describe a problem worth checking before purchase.

“Oil consumption is at an all time high. At last oil change I had Milage 71847 on 3/8/26. I checked my oil on 4/26/26 with 73182 miles, oil was at the add mark on the dipstick which means 2 quarts was gone from my engine at about 1500 miles put on my car since the oil change. Upon reading up on this issue, it is a wide spread issue with several Hyundai models. I bought it used at a car dealship when it was only a year old, so the warranty is only for the original owner. I still owe $3400.00 on this car and I am afraid the engine will go before it is paid off.”

The records describe a problem worth checking before purchase.

“The vehicle has had two catalytic converters replaced in 70,000 miles”

The records describe a problem worth checking before purchase.

“The contact owns a 2019 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly stalled and was idling roughly. The message “Stop Driving” was displayed. The contact stated that the vehicle failed to accelerate and lost automotive power. The failure had occurred several times. On one occasion, the vehicle had to be towed. The vehicle was able to restart after several failures. The vehicle was taken to the dealer, where it was diagnosed with engine failure due to excessive oil consumption. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 59,000.”

The records describe a problem worth checking before purchase.

“While driving at highway speed, the engine suffered a sudden connecting rod bearing failure (Cylinder 3) with no prior warning lamps, messages, or symptoms. The vehicle made a slapping noise, a belt came off, the engine died, and would not restart. The vehicle was towed to an authorized Hyundai dealership. The driver, a [XXX] [XXX] , was able to safely guide the vehicle to a stop without injury. The dealership inspected the engine and confirmed a complete Cylinder 3 connecting rod bearing failure. The technician contacted Hyundai Techline, who confirmed the diagnosis and recommended engine replacement. The estimated repair cost is 6,500. The failed engine is available for inspection at the dealership. This vehicle is a 2019 Tucson with the Nu 2.0L GDI engine, which is covered under the E2 Class Action Settlement for connecting rod bearing defects. Hyundai Service Campaign 966 provides a KSDS software update designed to detect abnormal bearing noise before catastrophic failure occurs. This update was never performed on the vehicle. The 2019 Tucson was not added to Campaign 966 until April 2022, after the vehicle had already been purchased used. The owner was never effectively notified of the campaign and the vehicle was never at a Hyundai dealership where the update could have been performed. Hyundai denied warranty coverage solely because Campaign 966 was not completed, despite confirming the failure is the exact defect type the campaign and settlement were designed to address. The vehicle had only 49,437 miles at the time of failure. The engine failed without any prior warning — the exact scenario Campaign 966 was designed to prevent. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)”

The records describe a problem worth checking before purchase.

“While driving a flashing engine light came on in my 2019 Hyundai Tucson. This made the car slow down and have no power. I brought the car to the nearest mechanic, they told me it was the knock sensor and told me it was a recall for this car, I should bring it back to the dealership. I called the dealership and they had told me to bring the car in. They inspected the car on 8/30/24 at 44,990 miles and told me it was the knock sensor and replaced it. On 11/4/24 at 46,246 miles the car was brought back in for the same issue and the car was inspected again, it was the knock sensor. This time the software was replaced. On 1/29/25 at 48,042 while driving on a highway going 70 mph the flashing light comes on again, brought it back to the dealership and I was given a loaner. The reached out to me and told me it was the knock sensor. They had the car for about 5 days. On 2/14/25 at 48,248 again, driving on a highway the flashing engine light appears again. Called the dealership and brought in the car and again, the knock sensor. On 12/31/25 at 56,712, driving on the highway, the flashing light appears again...On 1/2/26 the car goes back to the dealership, they call me and said that it's the strangest thing, the serpentine belt is worn, and it was making a banging sound which was setting off the knock sensor. At this point they offered to put in a new serpentine belt. I refused because after 5 failed attempts, I decided to bring it to my mechanic (I had lost all confidence with Hyundai mechanics). He did replace it. At this point I sent a letter to Hyundai motors stating all the facts that have been happening and asked for a buyout. After their investigation they called me and said, because you brought it to your mechanic they couldn't help me, but, if it happens again, bring it back to Hyundai. On 2/2/26, 57,286, again. I called the dealership and brought it back. This time they said that they didn't have a loaner to give so I rented one, 4 days. This is 5 failed attempts”

The records describe a problem worth checking before purchase.

“Hyundai and Kia ABS Module Fires The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.”

The records describe a problem worth checking before purchase.

“Loss of Motive Power The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing.  There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.”

The records describe a problem worth checking before purchase.

“Certain Hyundai vehicles with exterior white paint may exhibit peeling or bubbling on metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. The paint warranty coverage for affected vehicles has been extended to 10 years/unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners. The warranty extension does NOT apply to any vehicle that has been previously declared a total loss, and/or sold for salvage by a financial institution or insurer, and/or has a branded or similar title under any state’s law.”

The records describe a problem worth checking before purchase.

“Certain Hyundai vehicles with exterior white paint may exhibit peeling or bubbling on metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. The paint warranty coverage for affected vehicles has been extended to 10 years/unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners. The warranty extension does NOT apply to any vehicle that has been previously declared a total loss, and/or sold for salvage by a financial institution or insurer, and/or has a branded or similar title under any state’s law.”

The records describe a problem worth checking before purchase.

“Certain Hyundai vehicles with exterior white paint may exhibit peeling or bubbling on metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. The paint warranty coverage for affected vehicles has been extended to 10 years/unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners. The warranty extension does NOT apply to any vehicle that has been previously declared a total loss, and/or sold for salvage by a financial institution or insurer, and/or has a branded or similar title under any state’s law.”

The records describe a problem worth checking before purchase.

“Description: Certain Hyundai vehicles with exterior white paint may exhibit peeling or bubbling on metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. The paint warranty coverage for affected vehicles has been extended to 10 years/unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners. The warranty extension does NOT apply to any vehicle that has ever been declared a total loss or sold for salvage by a financial institution or insurer, or has a branded or similar title under any state’s law. ”

The records describe a problem worth checking before purchase.

“Description: Certain Hyundai vehicles with exterior white paint may exhibit peeling or bubbling on metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. The paint warranty coverage for affected vehicles has been extended to 10 years/unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners. The warranty extension does NOT apply to any vehicle that has ever been declared a total loss or sold for salvage by a financial institution or insurer, or has a branded or similar title under any state’s law. ”

The records describe a problem worth checking before purchase.

“Description: Certain Hyundai vehicles with exterior white paint may exhibit peeling or bubbling on metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. The paint warranty coverage for affected vehicles has been extended to 10 years/unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners. The warranty extension does NOT apply to any vehicle that has ever been declared a total loss or sold for salvage by a financial institution or insurer, or has a branded or similar title under any state’s law. ”

The records describe a problem worth checking before purchase.

“Certain 2015 – 2018 model year Elantra, 2015 – 2019 model year Sonata, 2017 – 2021 model year Tucson, 2017 – 2018 model year Santa Fe Sport, 2019 model year Santa Fe, 2021 – 2023 model year Santa Fe Hybrid, and 2020 – 2023 model year Palisade vehicles may exhibit excessive paint peeling or bubbling of the primer/paint film on the exterior metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. This warranty extension only applies to factory-applied paint and does not cover collision-related paint repairs or vehicles with a salvaged title. Hyundai is extending the warranty coverage for certain white paint colors under these conditions from 3 years and 36,000 miles, to 10 years with unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners.”

The records describe a problem worth checking before purchase.

“Certain 2015 – 2018 model year Elantra, 2015 – 2019 model year Sonata, 2017 – 2021 model year Tucson, 2017 – 2018 model year Santa Fe Sport, 2019 model year Santa Fe, 2021 – 2023 model year Santa Fe Hybrid, and 2020 – 2023 model year Palisade vehicles may exhibit excessive paint peeling or bubbling of the primer/paint film on the exterior metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. This warranty extension only applies to factory-applied paint and does not cover collision-related paint repairs or vehicles with a salvaged title. Hyundai is extending the warranty coverage for certain white paint colors under these conditions from 3 years and 36,000 miles, to 10 years with unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners.”

The records describe a problem worth checking before purchase.

“Certain 2015 – 2018 model year Elantra, 2015 – 2019 model year Sonata, 2017 – 2021 model year Tucson, 2017 – 2018 model year Santa Fe Sport, 2019 model year Santa Fe, 2021 – 2023 model year Santa Fe Hybrid, and 2020 – 2023 model year Palisade vehicles may exhibit excessive paint peeling or bubbling of the primer/paint film on the exterior metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. This warranty extension only applies to factory-applied paint and does not cover collision-related paint repairs or vehicles with a salvaged title. Hyundai is extending the warranty coverage for certain white paint colors under these conditions from 3 years and 36,000 miles, to 10 years with unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners.”

The records describe a problem worth checking before purchase.

“Some vehicles may exhibit excessive paint peeling or bubbling of the primer/paint film on the exterior metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. This warranty extension only applies to factory-applied paint and does not cover collision-related paint repairs or vehicles with a salvaged title. Hyundai is extending the warranty coverage for certain white paint colors under these conditions from 3 years and 36,000 miles, to 10 years and unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners.”

The records describe a problem worth checking before purchase.

“Some vehicles may exhibit excessive paint peeling or bubbling of the primer/paint film on the exterior metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. This warranty extension only applies to factory-applied paint and does not cover collision-related paint repairs or vehicles with a salvaged title. Hyundai is extending the warranty coverage for certain white paint colors under these conditions from 3 years and 36,000 miles, to 10 years and unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners.”

The records describe a problem worth checking before purchase.

“Some vehicles may exhibit excessive paint peeling or bubbling of the primer/paint film on the exterior metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. This warranty extension only applies to factory-applied paint and does not cover collision-related paint repairs or vehicles with a salvaged title. Hyundai is extending the warranty coverage for certain white paint colors under these conditions from 3 years and 36,000 miles, to 10 years and unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners.”

The records describe a problem worth checking before purchase.

“This TSB references the Op codes to use for claim submission and the Parts required based on the vehicle’s inspection results from TSB 22-01-023H (DTC P1326 – Engine Bearing Inspection/Engine Replacement) or the latest version.”

The records describe a problem worth checking before purchase.

“This TSB references the Op codes to use for claim submission and the Parts required based on the vehicle’s inspection results from TSB 22-01-023H (DTC P1326 – Engine Bearing Inspection/Engine Replacement) or the latest version.”

The records describe a problem worth checking before purchase.

“This TSB references the Op codes to use for claim submission and the Parts required based on the vehicle’s inspection results from TSB 22-01-023H (DTC P1326 – Engine Bearing Inspection/Engine Replacement) or the latest version.”