2020 Hyundai Tucson · keep 3 yr

The records describe a problem worth checking before purchase.

“Tried passing someone on the thruway, as I was about to the car jerked a bit then started decelerating. The check engine light started flashing and so did the oil light. Read the code as cylinder 3 misfire and a knock sensor. Changed the spark plugs and coil packs then checked the oil and saw there was no oil in the engine. Was told by my mechanic it’s a common problem with these Hyundai engines, it seems the rings are getting fried in the engine and that’s why it consumes oil so quickly.”

The records describe a problem worth checking before purchase.

“While driving on the highway with adaptive cruise control on, car began decelerating without any vehicle in front. Started to get off highway, check engine light began flashing and came to a full stop. Car died. Tried restarting and car died. Check engine, oil and battery lights then on. Total engine failure and no warning lights prior.”

The records describe a problem worth checking before purchase.

“Vehicle is a 2020 Hyundai Tucson with a 2.4 liter engine: Theta II GDI. Vehicle was purchased new and maintained properly. Excessive oil consumption began at about 50,000 miles. Vehicle was purchased in early 2020 and therefore has an engine manufactured in 2019. Tucson vehicles with this engine from 2011 through 2019 were recalled for engine problems including excessive oil consumption and rod bearing failure possibly resulting in engine fires. If engines were not replaced an extended warranty was given for 150,000 miles or 15 years. Hyundai will not remedy our excess oil consumption problem locally or nationally. An oil consumption test was done at the Hyundai dealer. Conclusion: by dealer and national level office: it's not bad enough to remedy. There were no engine warning lights activated because we check the oil regularly and add as needed. This post-2019 2.4 liter engine continues to be a hazard as some owners from previous year's models had engine seizures in traffic which is dangerous. Some owners reported engine fires. We have not experienced those tragedies but possibly post-2019 Tucson owners should be alerted to potential dangers.”

The records describe a problem worth checking before purchase.

“I am reporting a serious safety issue involving diagnostic code P1326. My vehicle developed engine knocking and little to no acceleration and appeared to enter a reduced-power or limp-mode condition while driving. This made it difficult to merge, maintain speed, and travel safely in traffic, creating a risk of collision or becoming stranded in an unsafe location. Based on publicly available Hyundai materials, code P1326 is associated with the Knock Sensor Detection System (KSDS) and may indicate abnormal engine vibration, possible bearing-related engine damage, and reduced-power operation. Those materials also indicate that certain vehicles were eligible for software updates, inspection, and possible engine repair or replacement. I request that this issue be documented as a safety complaint and that the dealership perform a full diagnostic inspection, determine whether my vehicle qualifies for any applicable campaign or warranty extension, and provide appropriate repairs.”

The records describe a problem worth checking before purchase.

“The engine consumes oil which is a known problem at Hyundai with the Tucson for the year 2020. The car has ~51,000 miles on it. When we took the car to the dealer at which we bought the car they diagnosed that the engine was burning oil. We were told that the engine is covered by standard warranty (10 yr. 100,000 miles). there is a process Hyundai has established for engines suspected of having this issue - first we had to have them check the oil and engine and then we had to drive the car 1000 miles and bring it back to them. when we brought it back they confirmed the the engine was consuming oil. They asked us to provide our maintenance records on the car (oil changes). We were able to find evidence of 5 oil changes but we know the we changed the oil on the car every 3-5k miles as we always do. The next step in the process is a combustion chamber cleaning which costs $1400 which would normally be covered by warranty but since we did not have all records of oil changes they will not cover it so we are being told we have to pay the $1400 out of pocket and also the the cleaning is not assured to fix the issue with the engine. If it fails to fix the issue the car will need a new engine which Hyundai is telling us they will not do under the warranty and it will be our financial obligation ($10-15K additional paid by us). It is clear that Hyundai is trying to shirk their warranty obligation to us. So we are stuck - we have to pay out of pocket for a service that may not resolve the issue and if it does not the car needs a new engine. If we sell the car back to the dealership they will only pay us $6000 when the car with a good engine is worth $15K. We take our obligation of regular maintenance seriously and have been loyal buyers at this dealership for >20 years never having an issue with proper maintenance. We think it unconscionable that Hyundai is leaving us holding the bag for a problem they know exists with theses engines”

The records describe a problem worth checking before purchase.

“I recently purchased a 2020 Hyundai Tucson with a Nu 2.0 GDI engine. Shortly after purchase the engine completely failed and requires full replacement. When taken to a Hyundai dealership, they pulled an internal STUI report showing A95 branding, meaning Hyundai had previously denied warranty coverage blaming the prior owner for outside influence. This A95 designation does not appear on any consumer vehicle history report including Carfax or AutoCheck. I paid $13,500 for this vehicle with no knowledge of this engine history. The Nu 2.0 GDI engine in this vehicle is specifically named in Hyundai’s class action settlement. Hyundai is using internal branding to avoid responsibility for a known manufacturing defect while allowing these vehicles to re-enter the used car market with clean vehicle history reports, leaving consumers completely unprotected.”

The records describe a problem worth checking before purchase.

“I have had the car in twice to the mechanic within the last 6 months for check engine light. He said I keep loosing oil, but there is no leak and it's something with the Engine. Hyundai will not recall the engine, but I see so many people are having the same issue. On a 2020 vehicle, you should not have engine issues. At what point do they have a recall on this issue, as so many are reporting the same thing.”

The records describe a problem worth checking before purchase.

“ABOUT 18 MONTHS AGO, SOON AFTER AN OIL CHANGE AT THE DEALERSHIP, I CHECKED THE DIPSTICK. IT SHOWED LOW OIL AND I ADDED SOME. IT MADE ME THINK THAT THE DEALER HAD SHORTED THE OIL. NEXT OIL CHANGE, I HAD THEM SHOW ME THE OIL WAS FULL. IT SHOWED LOW FULL. I'VE BEEN CAREFULLY CHECKING THE OIL EVER SINCE AND HAVE CONTINUED ADDING OIL IN BETWEEN OIL CHANGES. 8 OR SO MONTHS AGO, I HAD THE OIL AND FILTER CHANGED. I MENTIONED THE PROBLEM TO THE MECHANIC AND HE SAID HE WAS AWARE HYUNDAI'S LOSE OIL. SINCE THEN, I HAVE CONTINUED TO ADD A HALF QUART AT LEAST ONCE A MONTH. I PARK ON CONCRETE AND THERE IS NO SIGN OF LEAKING OIL. I STARTED RESEARCHING THIS ISSUE AND FIND IT IS AN ONGOING PROBLEM WITH 2020 TUCSONS. I AM VERY CONCERNED WITH ENGINE DETERIORATION, SAFETY AND OIL LOSS.”

The records describe a problem worth checking before purchase.

“Complete engine failure. Car was burning oil, wasn't aware. Since I am an on the road salesman I travel alot and get oil changes consistently. Then recently the engine oil light keeps coming on when rounding bends or stopping on a hill. I checked the dip stick and see oil is Half gone in between oil changes. The car stalled as I was approaching a dangerous intersection. Thankfully I was able to stop the car.”

The records describe a problem worth checking before purchase.

“I have a 2020 Tucson Sport with 82k miles. Since new, it consumes 1US qt. of oil every 6 month, although I religiously do the tune-up on its recommended intervals using only Mobil 5w-20 synthetic oil. What can I do?”

The records describe a problem worth checking before purchase.

“This engine has 70,000 miles on it and has burned a quart of oil every 2500 to 3000 miles, two full quarts between oil changes. In talking to others Hyundai owners, they have similar issues. I have owned multiple other brands of vehicles with well over 150K miles and they did not burn any oil. Fords, BMWs, Volvos, and Subarus.”

The records describe a problem worth checking before purchase.

“2020 HYUNDAI Tucson Engine blown @ 89,307 miles and 1,265 miles after oil change due to missing oil plug. Daughter drives about 5 miles per day for college and groceries. The day before Thanksgiving 2025, her 2020 HYUNDAI Tucson died about 48 miles down the Highway without warning, no prior warning lights or sounds before shutting down. I had the car towed to the local HYUNDAI dealer in the town where her college is, where they told us the engine was totaled due to a lack of oil and a missing oil plug. I discussed with the HYUNDAI service advisor about having an extended warranty; however, they would not work with me or the company I had the extended warranty with, mentioning they would not cover the engine failure due to the oil plug being missing. I asked the service advisor in a separate conversation whether an oil pan drain plug that was not properly torqued during an oil change could remain in place for some time—particularly during short, low-speed driving—and then gradually work loose over additional miles. The service advisor mentioned that in situations like my daughter’s, where only about 1,265 miles were driven after the oil change (mostly short trips), it would be within reason for an improperly installed drain plug to stay in place until a longer highway drive with higher RPMs, at which point it could back out completely and result in a sudden oil loss and engine shutdown. The service advisor also mentioned that this is something they had seen before and is not unheard of on these vehicles.”

The records describe a problem worth checking before purchase.

“Proceeding with flow of traffic, Southbound on a 2 lane st, I was in the curb lane. A truck exiting interstate ran through, at approx 50-60 MPH, a red light. Initial contact was made on passenger side front and rear door. He continued to push my car, and I turned the wheel to the right to avoid left lane traffic (as they couldn't move becuase of guard rail facing East) and he gunned it and pushed me into a concrete the guard rail at about 15-25 mph. The car was stuck in drive, it couldn't be put into any other gear.?There were no airbag deployment at all?I've missed worked since 2/11. I have severe left side injuries-neck, shoulder, upper/lower arm, wrist, and left hand, upper back pain, lower back pain, pain down the back of my legs, right shoulder pain, concussion, numbness, tingling in fingers, back, and feet. Labored breathing, bruising, headache, some loss of mobility, in constant pain, panic attacks/anxiety, under care of pulmonologist, family dr., physical therapist, chiropractor (as of now), insurance company towed car to their facility to get estimate. They have the car in their possession and the only ones to do any inspection at this point. THERE WERE ABSOLUTELY NO WARNING LIGHTS, MESSAGES, NOISES, NO WARNINGS ON BLUELINK APP, NOTHING THAT WOULD GIVE ME ANY INDICATION THERE WERE ISSUES WITH TRANSMISSION (GEAR STUCK IN DRIVE) OR AIRBAG MALFUNCTIONS.”

The records describe a problem worth checking before purchase.

“While driving, the engine began making a loud knocking/rattling noise and the check engine light began flashing. The vehicle experienced a loss of power and was unsafe to continue operating normally. The vehicle was taken to a Hyundai dealership for diagnosis. The engine requires replacement. Hyundai denied coverage, claiming excessive oil consumption and/or maintenance concerns. However, upon inspection, the dealership removed the valve cover and advised that the engine was internally clean and showed no significant sludge buildup consistent with severe neglect. I am concerned that this engine failure may be related to known Hyundai engine issues involving the 2.4L GDI engine. The failure occurred well before the expected service life of the engine and created a potential safety hazard due to the loss of power while driving. I am requesting that NHTSA review this failure and determine whether similar failures are occurring in 2020 Hyundai Tucson vehicles equipped with the 2.4L GDI engine.”

The records describe a problem worth checking before purchase.

“My car has been burning through about 2 quarts of oil every 1000 miles. Hyundai will NOT replace the engine. If this continues My engine could malfunction while driving. This is a serious safety concern and there's plenty of information on it. They refuse to recall it.”

The records describe a problem worth checking before purchase.

“burning oil at a rate of 2 qts per 1000 miles driven. Known issue in these models of tucsons. Not covered by the class action lawsuit as this VIN was not identified. It is burning oil at a catastrophic rate. The problem has burned through multiple catalytic converters that were covered under the warranty but did not solve the underlying problem. Has been burning oil since owning the car a year ago.”

The records describe a problem worth checking before purchase.

“Hyundai and Kia ABS Module Fires The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.”

The records describe a possible crash, fire, injury, or loss of control.

“Hyundai Motor America (Hyundai) recalled certain 2019-2021 Tucson vehicles on September 4, 2020. On December 30, 2020, Hyundai expanded the recall population, and added certain 2016-2018 Tucson vehicles. The Anti-lock Brake Hydraulic Electronic Control Unit (HECU) could corrode internally and cause an electrical short, possibly resulting in an engine compartment fire. An engine compartment fire can increase the risk of injury or crash. Hyundai will notify owners, and dealers will replace the HECU fuse. For 2019-2021 model years, the Electronic Stability Control (ESC) software will also be updated. Recall repairs will be performed free of charge. Owners are advised to park outside and away from structures as a precaution until the recall repair is complete. The recall began November 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 195.”

The records describe a problem worth checking before purchase.

“Certain Hyundai vehicles with exterior white paint may exhibit peeling or bubbling on metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. The paint warranty coverage for affected vehicles has been extended to 10 years/unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners. The warranty extension does NOT apply to any vehicle that has been previously declared a total loss, and/or sold for salvage by a financial institution or insurer, and/or has a branded or similar title under any state’s law.”

The records describe a problem worth checking before purchase.

“Certain Hyundai vehicles with exterior white paint may exhibit peeling or bubbling on metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. The paint warranty coverage for affected vehicles has been extended to 10 years/unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners. The warranty extension does NOT apply to any vehicle that has been previously declared a total loss, and/or sold for salvage by a financial institution or insurer, and/or has a branded or similar title under any state’s law.”

The records describe a problem worth checking before purchase.

“Certain Hyundai vehicles with exterior white paint may exhibit peeling or bubbling on metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. The paint warranty coverage for affected vehicles has been extended to 10 years/unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners. The warranty extension does NOT apply to any vehicle that has been previously declared a total loss, and/or sold for salvage by a financial institution or insurer, and/or has a branded or similar title under any state’s law.”

The records describe a problem worth checking before purchase.

“Description: Certain Hyundai vehicles with exterior white paint may exhibit peeling or bubbling on metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. The paint warranty coverage for affected vehicles has been extended to 10 years/unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners. The warranty extension does NOT apply to any vehicle that has ever been declared a total loss or sold for salvage by a financial institution or insurer, or has a branded or similar title under any state’s law. ”

The records describe a problem worth checking before purchase.

“Description: Certain Hyundai vehicles with exterior white paint may exhibit peeling or bubbling on metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. The paint warranty coverage for affected vehicles has been extended to 10 years/unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners. The warranty extension does NOT apply to any vehicle that has ever been declared a total loss or sold for salvage by a financial institution or insurer, or has a branded or similar title under any state’s law. ”

The records describe a problem worth checking before purchase.

“Description: Certain Hyundai vehicles with exterior white paint may exhibit peeling or bubbling on metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. The paint warranty coverage for affected vehicles has been extended to 10 years/unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners. The warranty extension does NOT apply to any vehicle that has ever been declared a total loss or sold for salvage by a financial institution or insurer, or has a branded or similar title under any state’s law. ”

The records describe a problem worth checking before purchase.

“Certain 2015 – 2018 model year Elantra, 2015 – 2019 model year Sonata, 2017 – 2021 model year Tucson, 2017 – 2018 model year Santa Fe Sport, 2019 model year Santa Fe, 2021 – 2023 model year Santa Fe Hybrid, and 2020 – 2023 model year Palisade vehicles may exhibit excessive paint peeling or bubbling of the primer/paint film on the exterior metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. This warranty extension only applies to factory-applied paint and does not cover collision-related paint repairs or vehicles with a salvaged title. Hyundai is extending the warranty coverage for certain white paint colors under these conditions from 3 years and 36,000 miles, to 10 years with unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners.”

The records describe a problem worth checking before purchase.

“Certain 2015 – 2018 model year Elantra, 2015 – 2019 model year Sonata, 2017 – 2021 model year Tucson, 2017 – 2018 model year Santa Fe Sport, 2019 model year Santa Fe, 2021 – 2023 model year Santa Fe Hybrid, and 2020 – 2023 model year Palisade vehicles may exhibit excessive paint peeling or bubbling of the primer/paint film on the exterior metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. This warranty extension only applies to factory-applied paint and does not cover collision-related paint repairs or vehicles with a salvaged title. Hyundai is extending the warranty coverage for certain white paint colors under these conditions from 3 years and 36,000 miles, to 10 years with unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners.”

The records describe a problem worth checking before purchase.

“Certain 2015 – 2018 model year Elantra, 2015 – 2019 model year Sonata, 2017 – 2021 model year Tucson, 2017 – 2018 model year Santa Fe Sport, 2019 model year Santa Fe, 2021 – 2023 model year Santa Fe Hybrid, and 2020 – 2023 model year Palisade vehicles may exhibit excessive paint peeling or bubbling of the primer/paint film on the exterior metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. This warranty extension only applies to factory-applied paint and does not cover collision-related paint repairs or vehicles with a salvaged title. Hyundai is extending the warranty coverage for certain white paint colors under these conditions from 3 years and 36,000 miles, to 10 years with unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners.”

The records describe a problem worth checking before purchase.

“Some vehicles may exhibit excessive paint peeling or bubbling of the primer/paint film on the exterior metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. This warranty extension only applies to factory-applied paint and does not cover collision-related paint repairs or vehicles with a salvaged title. Hyundai is extending the warranty coverage for certain white paint colors under these conditions from 3 years and 36,000 miles, to 10 years and unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners.”

The records describe a problem worth checking before purchase.

“Some vehicles may exhibit excessive paint peeling or bubbling of the primer/paint film on the exterior metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. This warranty extension only applies to factory-applied paint and does not cover collision-related paint repairs or vehicles with a salvaged title. Hyundai is extending the warranty coverage for certain white paint colors under these conditions from 3 years and 36,000 miles, to 10 years and unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners.”

The records describe a problem worth checking before purchase.

“Some vehicles may exhibit excessive paint peeling or bubbling of the primer/paint film on the exterior metal body panels: hood, fender(s), roof, door(s), quarter panel(s), and tailgate/trunk. This warranty extension only applies to factory-applied paint and does not cover collision-related paint repairs or vehicles with a salvaged title. Hyundai is extending the warranty coverage for certain white paint colors under these conditions from 3 years and 36,000 miles, to 10 years and unlimited miles from the date of original retail delivery or date of first use, and is valid for original and subsequent owners.”

The records describe a problem worth checking before purchase.

“This TSB references the Op codes to use for claim submission and the Parts required based on the vehicle’s inspection results from TSB 22-01-023H (DTC P1326 – Engine Bearing Inspection/Engine Replacement) or the latest version.”

The records describe a problem worth checking before purchase.

“This TSB references the Op codes to use for claim submission and the Parts required based on the vehicle’s inspection results from TSB 22-01-023H (DTC P1326 – Engine Bearing Inspection/Engine Replacement) or the latest version.”

The records describe a problem worth checking before purchase.

“This TSB references the Op codes to use for claim submission and the Parts required based on the vehicle’s inspection results from TSB 22-01-023H (DTC P1326 – Engine Bearing Inspection/Engine Replacement) or the latest version.”